2009 HUMMER H3 SUT Recall

Campaign:
09V080000 on 03/10/2009
Component:
Fuel system, gasoline:storage:tank assembly
Manufactured:
05/31/2008 - 10/30/2008
Affected:
1,738
Defect:
General motors is recalling 1,738 my 2009 hummer h3t vehicles. some of these vehicles have a condition in which the fuel tank front support strap may fracture. if this occurs, the fuel tank would be supported by the rear support strap and stone shield only. continued use of the vehicle may eventually fracture the rear support strap and shield fasteners.
Consequence:
The fuel tank could separate from the vehicle increasing the risk of a crash.
Correction:
Dealers will install a new design fuel tank front support strap free of charge. the recall is expected to begin on or before april 10, 2009. owners may contact hummer at 800-732-5493, or the gm owner center at ww.gmownercenter.com.
Notes:
General motors 09048.owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to <a href=http://www.safercar.gov>http://www.safercar.gov</a> .

2009 HUMMER H3 SUT TSBs (52)

Bulletin:
SB-020842001B
Component:
121000 exterior lighting:headlights
Summary:
General motors vehicles and trucks: subject regarding, 2002 and prior passenger cars and trucks, chemical damage to exterior polycarbonate headlamp lenses. *slc updated *eh updated 3/30/11. headlamp lens overheating when cov
Bulletin:
PIT-4767
Component:
160000 structure
Summary:
General motors: installation issue; h3t accessory assist step. passenger side rear bracket may not align correctly with vehicle frame weld nuts. *pe
Bulletin:
TB-090940001
Component:
151400 seat belts:front:buckle assembly
Summary:
General motors: the seat belt buckles not operating and /or seat belt warning light illumination, as well as difficulty latching and unlatching the buckle or the buckle release button sticking. affects 2010 and prior gm passenger cars and t
Bulletin:
SB-09-06-04-025
Component:
061000 engine and engine cooling:engine
Summary:
Saab/hummer/gmc/chevrolet: malfunction indicator lamp (mil) illuminated, dtcs p0300-p0306, engine runs rough (inspect for water intrusion in spark plug recess area, replace spark plug and ignition coil, seal ignition coil bolt hole vents a
Bulletin:
05-09-40-002E
Component:
151200 seat belts:front:webbing
Summary:
Gm: service bulletin explaining when the safety belts are supposed to lock. *rm updated 12/6/11. *pe
Bulletin:
PI-0304
Component:
111100 electrical system:battery:cables
Summary:
Gm: positive battery cable is too close to the engine sight shield cover. the battery cable could rub through. *rm
Bulletin:
PIT-3749D
Component:
161000 structure:frame and members
Summary:
Gm: on some truck models there is some frame corrosion. *rm updated on 5/2/2012. *kb
Bulletin:
PIT-3929C
Component:
026000 traction control system
Summary:
Gm: service stability or traction light is on with one internal trouble code. *rm
Bulletin:
PI-0153B
Component:
103700 power train:automatic transmission:torque converter
Summary:
Gm: there is a whine noise when in drive or reverse. there is a bearing problem in the torque converter. *rm
Bulletin:
SB-11157
Component:
033210 service brakes, hydraulic:power assist:hydraulic:hoses, lines/piping, and fittings
Summary:
Hummer: see document search button for owner letter. due to snow or water that contains other contaminants or road salt and enter and remain in fitting, the front brake hose fitting may corrode. if remains in fitting can develop a leak
Bulletin:
SB-11273
Component:
060000 engine (pws)
Summary:
Hummer/cadillac, chevrolet, gmc: see document search button for owner letter. engine may have reduced power, running rough, and possible have malfunction indicator lamp on, due throttle position sensor. models 2008-2010 cadillac escalade
Bulletin:
PI-0018-B
Component:
132000 visibility:glass, side/rear
Summary:
General motors: the windows, front and rear, would bind, poor fit, misalignment, makes rattle or squeaking noises, moves slowly and is inoperative. model 2008-2014 vehicles and trucks. *pe
Bulletin:
SB-11273-A
Component:
060000 engine (pws)
Summary:
Summary to be provided on a future date.
Bulletin:
SB-03-07-29-004K
Component:
102000 power train:manual transmission
Summary:
This informational bulletin provide information on the operating characteristics of a manual transmission.
Bulletin:
PI-0281-E
Component:
161100 structure: frame and members:underbody shields
Summary:
This preliminary informational bulletin provides information that may be helpful when addressing underbody component corrosion with customers.
Bulletin:
PI-0754-B
Component:
132000 visibility:glass, side/rear
Summary:
This informational bulletin provides information on a normal condition on tempered glass of spots showing on the rear and side windows when the vehicle is in the sunlight.
Bulletin:
SB-16-NA-117
Component:
350000 equipment
Summary:
This informational bulletin provides information on the purpose of magnetic drain plugs.
Bulletin:
SB-16-NA-119
Component:
355200 equipment:other:owners/service/other manual
Summary:
This warranty administration bulletin provides information on gm's policy on performing gm covered vehicle services and maintenance on vehicles originating/sold in canada.
Bulletin:
SB-07-06-01-016C
Component:
060000 engine (pws)
Summary:
This informational bulletin provides information internal engine noise or damage after oil filter replacement
Bulletin:
SB-06-08-47-001L
Component:
118000 electrical system: software
Summary:
This informational bulletin provides warranty information on using the service programming system (sps) for programming control modules
Bulletin:
SB-03-06-03-004Q
Component:
111000 electrical system:battery
Summary:
This warranty administration bulletin provide policy information on using the el-50313 midtronics gr8 battery tester/charger for diagnosing battery replacements and maintaining batteries on new vehicles in dealer inventory.
Bulletin:
SB-15-06-03-001B
Component:
111000 electrical system:battery
Summary:
This informational bulletin provides information that may be useful on diagnosing batteries that have set for a long period of time and/or set in cold weather climates and testing those batteries.
Bulletin:
SB-10-08-46-001C
Component:
353400 equipment:electrical:radio/tape deck/cd etc.
Summary:
"this technical bulletin provides a procedure to contact onstar for hard mute request to correct a customer concern when the radio is on, it does not mute enough when the onstar® turn-by-turn navigation directions are announced due to custo
Bulletin:
PIC-5260-A
Component:
110000 electrical system
Summary:
This preliminary information communication advises the technician the steps on diagnosing the concern. vehicle's sunroof operation intermittent, bind, noise, auto-reverse, and/or water leaks.
Bulletin:
PIC-5050-A
Component:
110000 electrical system
Summary:
This preliminary information communication advises the technician the steps on repairing the concern. a customer may identify a concern of unable to reactivate a vehicle's onstar that has been previously disabled by onstar. dealer is to ca
Bulletin:
PIC-4935-E
Component:
110000 electrical system
Summary:
This preliminary information communication provides information to help the dealership technicians perform a parasitic drain test for the onstar module. when performing battery parasitic drain test, there may be some confusion as to what th
Bulletin:
PIC-5374-D
Component:
353500 equipment:electrical:navigational system(global positioning system)
Summary:
This preliminary information communication advises the technician on the steps to diagnose and repair the concern of receiving frequent "off route" messages while following turn by turn (tbt) route navigation. the technician is provided in
Bulletin:
16NA119
Component:
355200 equipment:other:owners/service/other manual
Summary:
This warranty administration bulletin provide policy on performing gm covered vehicle services and maintenance on vehicles originating/sold in canada.
Bulletin:
16NA241
Component:
110000 electrical system
Summary:
This technical bulletin provides a procedure to check the cylinders for damaged pistons and determine if the use of aftermarket calibrations or performance parts may be the cause.
Bulletin:
16NA260
Component:
353400 equipment:electrical:radio/tape deck/cd etc.
Summary:
This technical bulletin provides a procedure to reprogram the media disc player with the latest calibrations to correct a condition of the rear entertainment system not operating as intended in colder ambient temperature areas due to calibr
Bulletin:
000601012F
Component:
060000 engine (pws)
Summary:
This informational bulletin provides information to gm dealers on the correct cleaning methods when cleaning engine gasket sealing surfaces.
Bulletin:
000601026I
Component:
060000 engine (pws)
Summary:
This informational bulletins provides information on the intake manifold inspection/replacement after servere internal engine damage.
Bulletin:
030603004R
Component:
060000 engine (pws)
Summary:
This informational bulletin provides information on how to test a battery and what is needed to warranty a battery.
Bulletin:
030604017I
Component:
061200 engine and engine cooling:engine:diesel
Summary:
This informational bulletin explains the use of diesel fuel additives in an engine, are not required unless the customer desires additives to prevent fuel concerns depending on fuel or temperature related conditions.
Bulletin:
070898001B
Component:
350000 equipment
Summary:
This informational bulletin provides information on gm does not approve the use of 'clipping' to repair collision damage to vehicles. gm has not tested or validated a 'clipped vehicle' repair; therefore, gm cannot endorse this type of repai
Bulletin:
PI1394A
Component:
060000 engine (pws)
Summary:
This informational bulletin provides additional information on how to install pistons and suggest what tools to use.
Bulletin:
PIP4786C
Component:
060000 engine and engine cooling
Summary:
This preliminary information communication provides information to the technician about vehicles that may have low oil pressure message. technician may also find a diagnostic trouble code p0521 in the engine control module. technician shoul
Bulletin:
PIT5074J
Component:
110000 electrical system
Summary:
This preliminary information communication provides information to the technician about the use of j-35616-64b terminal test probe, replacement terminals, and terminated leads. the j-35616-64b is the latest test probe released for checking
Bulletin:
PIC4707E
Component:
353000 equipment:electrical
Summary:
This preliminary information communication advises the technician to diagnose the concern and the steps to repair the concern. the vehicle's xm travel link may be inopertive.
Bulletin:
PIC4935E
Component:
110000 electrical system
Summary:
This preliminary information communication provides information to help the dealership technicians perform a parasitic drain test for the onstar module. when performing battery parasitic drain test, there may be some confusion as to what th
Bulletin:
PIC5050A
Component:
353000 equipment:electrical
Summary:
This preliminary information communication advises the technician the steps on repairing the concern. a customer may identify a concern of unable to reactivate a vehicle's onstar that has been previously disabled by onstar. dealer is to ca
Bulletin:
PIC5088F
Component:
353400 equipment:electrical:radio/tape deck/cd etc.
Summary:
This preliminary information communication advises the technician on the steps to diagnose and repair the concern. the vehicle's xm radio only has xm preveiw channels.
Bulletin:
PIC5260A
Component:
130000 visibility
Summary:
This preliminary information communication advises the technician the steps on diagnosing the concern. vehicle's sunroof operation intermittent, bind, noise, auto-reverse, and/or water leaks.
Bulletin:
PIC5374D
Component:
353500 equipment:electrical:navigational system(global positioning system)
Summary:
This preliminary information communication advises the technician on the steps to diagnose and repair the concern of receiving frequent "off route" messages while following turn by turn (tbt) route navigation. the technician is provided in
Bulletin:
PIP5168E
Component:
110000 electrical system
Summary:
This preliminary information communication advises the technician on the steps to diagnose the concern, and the steps to repair the concern of the vehicle cranks but does not start. the technician is to inspect for a sheared cam pin in the
Bulletin:
PIT5389A
Component:
353500 equipment:electrical:navigational system(global positioning system)
Summary:
This preliminary information communication advises the technician on the steps for diagnosing the concern. the vehicle may be unable to connect to onstar using the white, blue or red onstar buttons.
Bulletin:
PIT5485B
Component:
110000 electrical system
Summary:
This preliminary information communication advises the technician if unable to place an onstar call in the ignition on mode after the onstar canada upgrade, to contact the gm technical assistance center onstar group for further assistance.
Bulletin:
PIT5485A
Component:
110000 electrical system
Summary:
This preliminary information communication advises the technician, if unable to place an onstar call in the ignition on mode after the onstar canada upgrade to contact the gm technical assistance center onstar group for further assistance.
Bulletin:
PI0086D
Component:
110000 electrical system
Summary:
This preliminary informational bulletin provides a list of corrections for multiple concerns regarding unexpected loss of radio audio (radio goes silent/no sound) and other blackberry phone - bluetooth issues
Bulletin:
PI0373A
Component:
135000 visibility:rearview mirrors/devices
Summary:
This preliminary informational bulletin provides a procedure for relearning the power folding mirriors and road testin to verify they correct a condtion of the power folding mirriors glass shakes, flutters at normal driving conditions.
Bulletin:
00-03-10-006M
Component:
190000 tires
Summary:
This informational bulletin provides guidance to gm dealers when using gm approved tire force variation measurement equipment.
Bulletin:
GCUS-3-848
Component:
353000 equipment:electrical
Summary:
44180 02 - customer satisfaction. certain vehicles may have key codes which were inappropriately handled by a third party which could increase the risk of vehicle theft. dealers are to replace all applicable keys and lock cylinders with ne

Home | Privacy