2009 FORD ESCAPE Recalls (3)
- Campaign:
- 10E043000 on 09/09/2010
- Component:
- Equipment
- Affected:
- 294
- Defect:
- Marathon is recalling certain seat covers, brand superhides with part numbers 593, 594, 578, 960, 228, 228-09, 267-08, 333, 625, and 630, sold for use as aftermarket equipment for various passenger vehicles. these seat covers are made of heavier thread and are not compatible with seats containing side airbags. the heavier seat cover could interfere with full deployment of the airbag in the event of a crash.
- Consequence:
- An improperly deployed airbag could result in serious injury.
- Correction:
- Marathon will notify owners of record and replace the seat cover free of charge. the safety recall began on september 14, 2010. owners may contact marathon at 1-800-735-2769.
- Notes:
- This recall only pertains to aftermarket marathon seat covers and has no relation to any original equipment installed on general motors, ford, chrysler, toyota, or nissan vehicles.owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to <a href=http://www.safercar.gov>http://www.safercar.gov</a> .
- Campaign:
- 14V284000 on 05/28/2014
- Component:
- Steering:electric power assist system
- Manufactured:
- 08/17/2006 - 09/10/2010
- Affected:
- 740,878
- Defect:
- Ford motor company (ford) is recalling certain model year 2008-2011 ford escape and mercury mariner vehicles manufactured august 18, 2006, through september 11, 2010. the affected vehicles have a steering torque sensor that may not be able to properly detect driver steering input. as a result, the system could remove the electric power steering (eps) assist.
- Consequence:
- If power steering assist is lost, greater driver effort would be required to steer the vehicle at low speeds, increasing the risk of a crash.
- Correction:
- Ford will notify owners, and dealers will update the software for the power steering control module (pscm) and the instrument cluster module, free of charge. if a vehicle shows a history of a loss of the torque sensor signal or fault codes relating to the pscm when the vehicle is brought in for the recall remedy, the affected components will be replaced, free of charge. the recall began on july 18, 2014. owners may contact ford customer service at 1-800-392-3673. ford's number for this recall is 14s05.
- Notes:
- Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.
- Campaign:
- 15E045000 on 06/02/2015
- Component:
- Suspension:front:wheel bearing
- Affected:
- 576
- Defect:
- The timken company (timken) is recalling certain aftermarket front wheel bearings, part number 510072, sold from january 22, 2015, to may 21, 2015, to be used as service parts on 2001-2012 ford escape, 2001-2011 mazda tribute, and 2005-2011 mercury mariner vehicles. the affected wheel bearings have incorrect dimensions of a 42mm bore, 76mm outer dimension, and 39mm width, instead of a 42mm bore, 78mm outer dimension and a 45mm width.
- Consequence:
- Use of an incorrectly sized wheel bearing can adversely affect the braking and steering of the vehicle, increasing the risk of a crash.
- Correction:
- Timken has begun notifying distributors who will offer purchasers replacement wheel bearings, free of charge. the recall began on may 21, 2015. owners may contact timken customer service at 1-866-984-6536.
- Notes:
- Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.
2009 FORD ESCAPE TSBs (41)
- Bulletin:
- TSB-09-5-5
- Component:
- 036400 service brakes, hydraulic:antilock:abs warning light
- Summary:
- Ford: vehicles may exhibit a clicking or rubbing noise from the left front wheel speed sensor and/or exhibit abs warning light activation. escape and escape hybrid only. *pe
- Bulletin:
- TSB-09-15-5
- Component:
- 046100 service brakes, air:antilock:control unit/module
- Summary:
- Ford/mercury: abs module self test creating a slight vibration in accel/brake pedal at 12mph (20km/h) and/or 42mph (68km/h). the abs module will initiate a one time self test at 12mph (20km/h) and at approximately 42mph (68km/h) for every
- Bulletin:
- TSB-09-15-1
- Component:
- 026000 traction control system
- Summary:
- Ford/mercury: traction control light with dtc c1440. some vehicles built may exhibit the traction control light on with dtc code c1440. if the vehicle is operated for an extended period following the illumination of the traction control
- Bulletin:
- TB-21019
- Component:
- 103400 power train:automatic transmission:lever and linkage:column shift
- Summary:
- Ford: increased shift lever effort may have debris or something, such as sweetened drinks spilled in/on the shifter. shifter replacement resulting from spillage or debris is not warrantable. *pe
- Bulletin:
- TSB-09-19-5
- Component:
- 103400 power train:automatic transmission:lever and linkage:column shift
- Summary:
- Ford: some vehicles equipped with a 6f35 transmission may exhibit diagnostic trouble codes (dtcs) p0770, p0772, p0773, p0774. the dtcs indicate open, short to ground or short to power in shift solenoid e (sse) circuit. erratic shift and/
- Bulletin:
- TSB-09-20-3
- Component:
- 036100 service brakes, hydraulic:antilock:control unit/module
- Summary:
- Ford/mercury: abs module self test creating a slight vibration in accelerator/brake pedal at 12mph (20km/h) and/or 42mph (68km/h). the abs module will initiate a one time self test at 12mph and at approximately 42mph for every key on cycl
- Bulletin:
- SB-21321
- Component:
- 016000 steering:electric power assist system
- Summary:
- Ford/mercury: clunk noise at steering; stops during first lock to lock cycle. the noise typically occurs during tight parking lot maneuvers. the clunk noise heard on the first steering lock to lock cycle is a normal characteristic of the
- Bulletin:
- TSB-10-13-2
- Component:
- 012000 steering:column
- Summary:
- Ford/mercury: steering column pop/clunk noise on turns. some vehicles may exhibit a pop or clunk noise from the steering column area while turning. this noise typically occurs quarter turn before the steering wheel reaches it's end of tr
- Bulletin:
- TSB-10-19-1
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Ford: on various 2009-2010 models there may be a malfunction light on with five possible fault codes. *rm
- Bulletin:
- TSB-10-18-3
- Component:
- 063200 engine and engine cooling:exhaust system:manifold/header/muffler/tail pipe
- Summary:
- Ford: some hybrid vehicles may have a malfunction light on with two possible fault codes. *rm
- Bulletin:
- TSB11-1-5
- Component:
- 063100 engine and engine cooling:exhaust system:emission control
- Summary:
- Ford: vehicles may run rough, hard start after refueling, clicking noise under hood, and have trouble codes stored. *rm
- Bulletin:
- SIS-21841
- Component:
- 118000 electrical system: software
- Summary:
- Comm-trans lund: some 2009-2011 models may have the air bag inicator flashing with a stored trouble code. this is a software problem. *rm
- Bulletin:
- AS-21769
- Component:
- 046000 service brakes, air:antilock
- Summary:
- Ford: if there is an intermittent lack of power, surge, or hesitation while driving the brakes will override acceleration. *rm
- Bulletin:
- AS-21624
- Component:
- 103000 power train:automatic transmission
- Summary:
- Ford: the transmission may leak fluid from a seal. 2009-2010 escape/mariner. *rm
- Bulletin:
- TSB-11-3-22
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Ford: there may be a leaking/stuck canister purge valve which can cause multiple driving systems. the malfunction light may be on with or without stored trouble codes. *rm
- Bulletin:
- TSB-11-8-8
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Ford: after refueling vehicle, would be hard to start, runs rough and an audible clicking noise can be heard. *pe
- Bulletin:
- TSB-12-4-3
- Component:
- 162600 structure:body:hatchback/liftgate
- Summary:
- Ford: vehicle's liftgate is difficult to open or difficult to close. *pe
- Bulletin:
- SB-32167-70
- Component:
- 060000 engine (pws)
- Summary:
- Ford/lincoln/mercury: some vehicles may experience an illuminated mil or safety stop now message, or a no start condition or possible misfire or roughness at idling through 2000rpm or a lack of acceleration. models 2009-12 escape, 2009-1
- Bulletin:
- TSB-13-6-2
- Component:
- 220000 seats
- Summary:
- Mercury/ford: on some vehicles, the front seat track assemblies may show rust or corrosion and may need track assembly cleaned. model 2009-2012 escape, mariner. *pe
- Bulletin:
- ASI-32332
- Component:
- 060000 engine (pws)
- Summary:
- Ford: due to an intermittent loss of rpm or lack of acceleration, in some vehicles, with illuminated wrench light, diagnostic trouble codes (dtcs) p2111, p2112 may or may not be stored in powertrain control module (pcm). models 2009-12 es
- Bulletin:
- SB-44300
- Component:
- 103000 power train:automatic transmission
- Summary:
- Ford: on the left hand half shaft seal, there is a fluid leak from the transmission because of wear on case bushing. model 2009-2012 escape, 2009-2011 mariner, 2010-2012 fusion, 2010-2011 milan. *pe
- Bulletin:
- TSB-14-0016
- Component:
- 015000 steering:hydraulic power assist system
- Summary:
- Ford/mercury: if diagnostic code b2278 is stored in power steering control module (pscm), it needs replacing with torque sensor service kit that is available and if not, does not apply. model 2008-2012 escape, 2008-2011 mariner.
- Bulletin:
- CSP-13N03
- Component:
- 110000 electrical system
- Summary:
- Ford: throttle body will develop contamination on internal motor contacts resulting in an intermittent electrical connectivity and malfunction indicator lamp (mil) or wrench light will illuminate. model 2009-2013 fusion, milan, escape, ma
- Bulletin:
- TSB-14-0056
- Component:
- 103000 power train:automatic transmission
- Summary:
- Mercury/ford: on some vehicles, there is a fluid leakage, coming from left hand (lh) halfshaft seal of the automatic transmission and a service kit is available now, for repair. model 2009-2012 escape, mariner, fusion, milan. *pe
- Bulletin:
- ASI-44427
- Component:
- 114000 electrical system:wiring
- Summary:
- Ford: the wrench light will illuminate when 4x4 function is inoperative due to active torque coupling solenoid coil wiring being broke, but a kit is available to service rear axle assembly/rear drive unit (rdu), at lower level. model 2008
- Bulletin:
- CSP-13B17
- Component:
- 350000 equipment
- Summary:
- Ford: the throttle body internal motor contacts may be contaminated, resulting in an electrical, intermittent, connectivity, causing malfunction indicator lamp (mil) or wrench light to be illuminated. model 2009-2012 fusion, milan, escap
- Bulletin:
- TSB-14-0157
- Component:
- 353600 equipment:air conditioner
- Summary:
- Mercury/ford: in one or more speed settings, electronic manual temperature control (emtc) a/c system is warm and/or lack blower motor operation in settings due to damaged blower motor resistor caused by water entering heater and evaporator
- Bulletin:
- ASI-44649
- Component:
- 350000 equipment
- Summary:
- Ford: a job aid was developed and now available for the ptu internal or external fluid leakage for all wheel drive vehicles. *pe
- Bulletin:
- ASI-44733
- Component:
- 350000 equipment
- Summary:
- Ford: in valve body, a worn solenoid pressure regulator valve has diagnostic trouble code (dtc) p0735 stored and indication of repair history was the valve body was not replaced previously. model 2009-10 escape, mariner, 2010 fusion, mila
- Bulletin:
- ASI-44707
- Component:
- 100000 power train
- Summary:
- Ford: after powertrain control module reprogramming, the malfunction indicator lamp (mil) is on with several diagnostic trouble codes (dtc) p06b8, p068a, p2610, if key not left for 30 seconds in off position following programming on some m
- Bulletin:
- 13N03
- Component:
- 162000 structure:body
- Summary:
- Ford fusion, milan, escape, mariner 2009-2013: customer satisfaction program throttle body extended coverage. *lj
- Bulletin:
- 15-0079
- Component:
- 103000 power train:automatic transmission
- Summary:
- Ford 2009-2014 escape, 2010-2014 fusion, 2012-2014 edge, explorer, 2013-2014 taurus: lincoln 2013-2014 mkt,mkz: mercury 2009- 2011 mariner, 2010-2011 milan. some vehicles equipped with 6f35 automatic transmission may exhibit a fluid leak f
- Bulletin:
- 44986
- Component:
- 012000 steering:column
- Summary:
- 2008-2012 ford escape/mariner: service information involving the power steering control module with dtc b2278- steering column replacement is not required. *lj
- Bulletin:
- 45006
- Component:
- 012000 steering:column
- Summary:
- Ford 2008-2012 escape/mariner: bulletin information regarding steering control module with dtc b2278, not required to have steering column replaced. *lj
- Bulletin:
- 16-0043
- Component:
- 100000 power train
- Summary:
- 6f35 transmission - fluid leak at left side halfshaft seal built on or before 10/14/2013 issue some 2009-2014 escape, 2009-2011 mariner, 2010-2014 fusion, 2010-2011 milan, 2012-2014 edge/explorer, and 2013-2014 taurus/mkt/mkz vehicles b
- Bulletin:
- SSM 46132
- Component:
- 030000 brakes (pws)
- Summary:
- Some 2008-2017 ford/mercury/lincoln vehicles equipped with sync may generate a vhr that identifies a concern with the brakes and suspension category indicating service is required due to a brake system warning lamp being illuminated. if the
- Bulletin:
- SSM 46132
- Component:
- 030000 brakes (pws)
- Summary:
- Some 2008-2017 ford/mercury/lincoln vehicles equipped with sync may generate a vhr that identifies a concern with the brakes and suspension category indicating service is required due to a brake system warning lamp being illuminated. if the
- Bulletin:
- SSM 46085
- Component:
- 060000 engine (pws)
- Summary:
- The powertrain control/emissions diagnosis (pc/ed) manual has been revised for diagnosing electronic throttle bodies (etbs). the etc_act and etc_dsd pids should not used to diagnose possible etb concerns. the ids has a limited refresh rate
- Bulletin:
- SSM 47201
- Component:
- 350000 equipment
- Summary:
- Replacing the original equipment sync/navigation system with either an aftermarket sync/navigation kit or modifying original sync/navigation parts to provide additional features is not recommended nor supported on any ford, mercury or linco
- Bulletin:
- SSM 47009
- Component:
- 353000 equipment:electrical
- Summary:
- The accessory (wireless) keyless entry keypad can only be used with vehicles that are factory built with remote keyless entry (rke). the master code for the accessory (wireless) keyless entry keypad can be retrieved from fmcdealer - parts a
- Bulletin:
- SSM 47009
- Component:
- 350000 equipment
- Summary:
- The accessory (wireless) keyless entry keypad can only be used with vehicles that are factory built with remote keyless entry (rke). the master code for the accessory (wireless) keyless entry keypad can be retrieved from fmcdealer - parts a
Home | Privacy