2009 FORD E-250 Recalls (18)

Campaign:
09V434000 on 11/04/2009
Component:
Equipment:air conditioner
Manufactured:
04/30/2007 - 08/30/2009
Affected:
53
Defect:
E-n-g mobile system is recalling certain model year 2008 chevrolet w5500, model year 2007-2009 dodge 3500, model year 2009 mighty mover, model year 2006-2009 ford e-250, e-350 and e-450, model year 2008-2009 gmc w4500, model year 2007 international 4300, model year 2009 toyota land cruiser vehicles equipped with carrier airv ceiling units, model nos. 68rv0010ba, 68rv0012ca, and 68rv0010ea. the heater element in these assemblies may be defective which could cause the unit to create smoke or sparks.
Consequence:
This defect could result in a fire.
Correction:
E-n-g mobile system will notify owners and the vehicles will be repaired by carrier free of charge. please see carrier's defect report 09e-053. the safety recall is expected to begin during december 2009. owners may contact carrier at 1-877-584-7059 or e-n-g mobile system at 1-925-798-4060.
Notes:
Owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to <a href=http://www.safercar.gov>http://www.safercar.gov</a> .
Campaign:
10V151000 on 04/14/2010
Component:
Equipment adaptive
Manufactured:
12/06/2007 - 12/22/2009
Affected:
65
Defect:
Comm-trans is recalling certain model year 2007-2009 ada conversion vans built on ford e-150, e-250, and e-350 chassis between december 7, 2007 and december 23, 2009 and fitted with ricon public use lifts. the restraint belt on these lifts was designed to prevent the lift from moving, unless the tongue of the belt is fully engaged and latched in the buckle. ricon has discovered, however, that it is possible for the operator to insert the belt tongue into the buckle without fully engaging the latching mechanism. in this case, the restraint belt would appear to be latched, and the operator could run the lift. if the restraint belt tongue is not fully engaged into the restraint belt buckle, and latched, the lift may operate with an occupant on the platform.
Consequence:
The user of the lift could be injured should the lift move without the restraint belt properly buckled.
Correction:
Comm-trans is working with ricon and ricon will be performing the remedy for this campaign. please see ricon's defect report 09e-060. ricon will provide customers with a warning decal and a dvd-based training aid. the safety recall began on july 6, 2010. owners may contact ricon at 1-818-267-3000 or comm-trans at 1-901-726-9394.
Notes:
This recall only pertains to vehicles altered by comm-trans and has no relation to any vehicles manufactured by ford motor company.owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to <a href=http://www.safercar.gov>http://www.safercar.gov</a> .
Campaign:
10V153000 on 04/14/2010
Component:
Equipment adaptive
Manufactured:
12/06/2007 - 12/22/2009
Affected:
65
Defect:
Comm-trans is recalling certain model year 2007-2009 ada conversion vans built on ford e-150, e-250, and e-350 chassis between december 7, 2007 and december 23, 2009 and fitted with certain ricon s series and k series l-model wheelchair lifts. due to a problem in the software that controls the lift's "up" function, should the "up" button be released before the floor level limit switch is activated, the lift may continue its upward travel and may overrun the floor level cut off point.
Consequence:
When the platform overruns the vehicle floor level and stops at an angle from 15-20 degrees, it is possible for a person in a wheelchair to tip over and for someone standing on the platform to fall, possibly resulting in injuries.
Correction:
Comm-trans will notify owners and the repairs will be performed by authorized ricon dealers free of charge. a software solution for this safety defect is under investigation. until the software solution is available, ricon will provide owners with a bulletin outlining proper wheelchair lift operation and will ship owners a dvd-based training aid to promote proper lift operation at no cost. the safety recall began on july 6, 2010. owners may contact ricon at 1-818-267-3000 or comm-trans at 1-901-726-9394.
Notes:
This recall only pertains to vehicles altered by comm-trans and has no relation to any vehicles manufactured by ford motor company.owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to <a href=http://www.safercar.gov>http://www.safercar.gov</a> .
Campaign:
10V207000 on 05/12/2010
Component:
Equipment adaptive
Manufactured:
10/31/2007 - 05/05/2010
Affected:
74
Defect:
Mobility works is recalling certain model year 2008 and 2009 conversion vans built on ford e150, e250, and e350 chassis and chevrolet 2500 chassis after november 2007 and fitted with certain ricon s series and k series l-model wheelchair lifts. due to a problem in the software that controls the lift's "up" function, should the "up" button be released before the floor level limit switch is activated, the lift may continue its upward travel and may overrun the floor level cut off point.
Consequence:
When the platform overruns the vehicle floor level and stops at an angle from 15-20 degrees, it is possible for a person in a wheelchair to tip over and for someone standing on the platform to fall, possibly resulting in injuries.
Correction:
Mobility works will notify owners and the repairs will be performed by authorized ricon dealers free of charge. a software solution for this safety defect is under investigation. until the software solution is available, ricon will provide owners with a bulletin outlining proper wheelchair lift operation and will ship owners a dvd-based training aid to promote proper lift operation at no cost. the safety recall began on august 20, 2010. owners may contact ricon at 1-818-267-3000 or mobility works at 1-800-769-8267.
Notes:
Owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to <a href=http://www.safercar.gov>http://www.safercar.gov</a> .
Campaign:
10V206000 on 05/12/2010
Component:
Equipment adaptive
Manufactured:
10/31/2007 - 05/04/2010
Affected:
156
Defect:
Mobility works is recalling certain model year 2008 and 2009 conversion vans built on ford e150, e250, and e350 chassis after november 2007 and fitted with ricon public use lifts. the restraint belt on these lifts was designed to prevent the lift from moving, unless the tongue of the belt is fully engaged and latched in the buckle. ricon has discovered, however, that it is possible for the operator to insert the belt tongue into the buckle without fully engaging the latching mechanism. in this case, the restraint belt would appear to be latched, and the operator could run the lift. if the restraint belt tongue is not fully engaged into the restraint belt buckle, and latched, the lift may operate with an occupant on the platform.
Consequence:
The user of the lift could be injured should the lift move without the restraint belt properly buckled.
Correction:
Mobility works is working with ricon and ricon will be performing the remedy for this campaign. please see ricon's defect report 09e-060. ricon will provide customers with a warning decal and a dvd-based training aid. the safety recall began on august 20, 2010. owners may contact ricon at 1-818-267-3000 or mobility works at 1-800-769-8267.
Notes:
Owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to <a href=http://www.safercar.gov>http://www.safercar.gov</a> .
Campaign:
10V243000 on 06/06/2010
Component:
Equipment adaptive
Manufactured:
09/15/2008 - 04/14/2008
Affected:
60
Defect:
Mobility transportation (mts) is recalling certain model year 2007 through 2009 conversion vans built on ford e150, e250, and e350 chassis from september 16, 2008 through april 15, 2009 and fitted with certain ricon s series and k series l-model wheelchair lifts. due to a problem in the software that controls the lift's "up" function, should the "up" button be released before the floor level limit switch is activated, the lift may continue its upward travel and may overrun the floor level cut off point.
Consequence:
When the platform overruns the vehicle floor level and stops at an angle from 15-20 degrees, it is possible for a person in a wheelchair to tip over and for someone standing on the platform to fall, possibly resulting in injuries.
Correction:
Mts will notify owners and the repairs will be performed by authorized ricon dealers free of charge. a software solution for this safety defect is under investigation. until the software solution is available, ricon will provide owners with a bulletin outlining proper wheelchair lift operation and will ship owners a dvd-based training aid to promote proper lift operation at no cost. the safety recall began on october 18, 2010. owners may contact ricon at 1-818-267-3000 or mts at 1-734-453-6452.
Notes:
Owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to <a href=http://www.safercar.gov>http://www.safercar.gov</a> .
Campaign:
10V242000 on 06/06/2010
Component:
Equipment adaptive
Manufactured:
09/15/2008 - 04/14/2009
Affected:
60
Defect:
Mobility transportation (mts) is recalling certain model year 2007 through 2009 conversion vans built on ford e150, e250, and e350 chassis from september 16, 2008 through april 15, 2009 and fitted with ricon public use lifts. the restraint belt on these lifts was designed to prevent the lift from moving, unless the tongue of the belt is fully engaged and latched in the buckle. ricon has discovered, however, that it is possible for the operator to insert the belt tongue into the buckle without fully engaging the latching mechanism. in this case, the restraint belt would appear to be latched, and the operator could run the lift. if the restraint belt tongue is not fully engaged into the restraint belt buckle, and latched, the lift may operate with an occupant on the platform.
Consequence:
The user of the lift could be injured should the lift move without the restraint belt properly buckled.
Correction:
Mts is working with ricon and ricon will be performing the remedy for this campaign. please see ricon's defect report 09e-060. ricon will provide customers with a warning decal and a dvd-based training aid. the safety recall began on october 18, 2010. owners may contact ricon at 1-818-267-3000 or mts at 1-734-453-6452.
Notes:
Owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to <a href=http://www.safercar.gov>http://www.safercar.gov</a> .
Campaign:
11E019000 on 05/22/2011
Component:
Fuel system, other:delivery:hoses, lines/piping, and fittings
Affected:
39
Defect:
Roush is recalling certain aftermarket roush clean tech liquid propane autogas fuel system kits produced between december 17, 2010, and may 6, 2011, used for installation on fleet vehicles model year 2009 through 2011 ford e-series vans/wagons/shuttles/cutaway (150, 250 and 350) with 5.4l engines ("e-series"), and my 2011 ford e-450 cutaways. the valves installed in the service port of the fuel rails of the kit were under minimum specification for the diameter. this led to insufficient compression of the o-ring, allowing leakage of propane autogas. the part numbers of the affected kits are: p10c2-r150kit-aa, p10c2-r150kit-ac, p10c2-r350kit-ac, p11c2-r150kit-aa, p11c2-r150kit-ab, p11c2-r350kit-aa, p11c2-r350kit-ab, p-10-so-rkit-ba, pbc2-rkit158-ab, pbc2-rkit176-ab, and pbc2-rkitmb-ac.
Consequence:
A gas leak in the presence of an ignition source can result in a fire.
Correction:
As of may 27, 2011, roush had notified all owners of record by telephone and shipped to them replacement valves free of charge. owners may contact roush at 1-734-466-6255.
Notes:
Owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to <a href=http://www.safercar.gov>http://www.safercar.gov</a> .
Campaign:
11E033000 on 08/30/2011
Component:
Fuel system, other:fuel injection system
Affected:
286
Defect:
Roush is recalling certain aftermarket roush clean tech liquid propane autogas fuel system kits used for installation on the following vehicles: model year 2007 and 2008 ford e-350 (duel rear wheel), my 2009-2011 ford e- 150, e-250, and e-350, and my 2009-2011 ford e-450 cutaways. the fuel rails included in the kits contain improperly seated injector retention clips. this could result in leakage of propane autogas. the part numbers of the affected kits are: p07c2-176kit-ab, p10c2-rcommkit-ab, p10c2-r150kit-aa, p10c2-r150kit-ac, p10c2-r350kit-ac, p11c2-r150kit-aa, p11c2-r150kit-ab, p11c2-r350kit-aa, p11c2-r350kit-ab, p10-so-rkit-ba, pbc2-rkit158-ab, pbc2-rkit176-ab, and pbc2-rkitmb-ac.
Consequence:
A gas leak in the presence of an ignition source can result in a fire.
Correction:
Roush will notify owners of the vehicles of which the kits were installed on in order to arrange for free replacement of the injector retention clips. the safety recall began on september 29, 2011. owners may contact roush at 1-800-59-rouch (1-800-597-6874.
Notes:
Owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to <a href=http://www.safercar.gov>http://www.safercar.gov</a> .
Campaign:
11V450000 on 08/31/2011
Component:
Fuel system, other:fuel injection system
Affected:
101
Defect:
Roush is recalling certain model year 2009-2011 ford e-150, e-250, and e-350 5.4l engin vans/wagons/cutaways, and model year 2010-2011 ford e-450 6.8l engine cutaway vehicles altered by rouch to operate using the roush branded cleantech propane autogas fuel system. the fuel rails included in the kits contain improperly seated injector retention clips. this could result in leakage of propane autogas.
Consequence:
A propane leak in the presence of an ignition source can result in a fire.
Correction:
Roush will notify owners of the vehicles of which the kits were installed in order to arrange for free replacement of the injector retention clips. the safety recall began on september 26, 2011. owners may contact roush at 1-734-466-6255.
Notes:
Owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to <a href=http://www.safercar.gov>http://www.safercar.gov</a> .
Campaign:
13V261000 on 06/25/2013
Component:
Equipment
Manufactured:
07/31/2006 - 08/30/2012
Affected:
37
Defect:
Mobility works is recalling certain model year 2006-2012 ford e-150, e-250 and e-350 vehicles manufactured august 2006 through august 2012. the vehicles are equipped with certain ricon s series and k series wheelchair lifts with an optional armored pendant cable. the armored cable may be positioned such that it does not clear the wheelchair lift.
Consequence:
If the cable does not clear the wheel chair lift it may contact the power lug and, if it does not have a nonconductive cover, or it has an improperly installed non-conductive cover, a short circuit may occur that could result in a fire.
Correction:
Mobility works will notify owners and ricon will provide a supplemental cover kit and instructions, free of charge. this recall campaign is expected to begin july 15, 2013. owners may contact mobility works at 1-877-275-4912 and ricon at 1-818-267-3000.
Notes:
Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.
Campaign:
14V584000 on 09/22/2014
Component:
Equipment adaptive
Manufactured:
12/31/2005 - 09/11/2014
Affected:
45
Defect:
National van builders, inc. (national van) is recalling certain 2007-2014 ford e-150 and e-250 vehicles manufactured february 26, 2007, to august 19, 2014, and equipped with certain model s2005, s2010, s5005, s5010, s5505, and s5510 wheelchair lifts manufactured by ricon corporation. the platform side plate of the affected wheelchair lifts may crack.
Consequence:
If the platform side plates crack, the lift platform can separate from the lift and come to rest against the vehicle's lift door. when the doors are opened, the platform may fall out, increasing the risk of injury to the lift operator.
Correction:
National van will notify owners to take buses to a ricon dealer or service center who will install supplemental platform support bumpers. any platform that has already started cracking will be replaced, free of charge. the recall began on october 3, 2014. owners may contact national van customer service at 1-800-527-7477. national van's number for this recall is ricon2014.
Notes:
Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.
Campaign:
14V617000 on 10/02/2014
Component:
Equipment adaptive
Manufactured:
01/31/2006 - 08/30/2014
Affected:
286
Defect:
New england wheels (new england) is recalling certain model year 2006-2014 e-250, and e-350 vehicles modified by new england to be equipped with certain model s2005, s2010, s5005, s5010, s5505, and s5510 wheelchair lifts manufactured by ricon corporation. the platform side plate of the affected wheelchair lifts may crack.
Consequence:
If the platform side plates crack, the lift platform can separate from the lift and come to rest against the vehicle's lift door. when the doors are opened, the platform may fall out, increasing the risk of injury to the lift operator.
Correction:
New england will notify owners to take vehicles to a ricon dealer or service center who will install supplemental platform support bumpers. any platform that has already started cracking will be replaced, free of charge. the recall began on november 17, 2014. owners may contact new england customer service at 1-800-886-9247 or ricon customer service at 1-800-322-2884. new england's number for this recall is 14e-041.
Notes:
Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.
Campaign:
14V706000 on 11/04/2014
Component:
Equipment adaptive
Manufactured:
12/31/2005 - 10/07/2014
Affected:
34
Defect:
Cummings mobility conversion & supply (cummings) is recalling certain model year 2006-2014 ford e-150, e-250, e-350, chevrolet express, 2006-2008 dodge sprinter, and 2009-2014 mercedes-benz sprinter, and 2013 ford transit connect vehicles manufactured january 1, 2006, to october 8, 2014, equipped with certain model s2005, s2010, s5005, s5010, s5505, and s5510 wheelchair lifts manufactured by ricon corporation after january 1, 2006. the platform side plate of the affected wheelchair lifts may crack.
Consequence:
If the platform side plates crack, the lift platform can separate from the lift and come to rest against the vehicle's lift door. when the doors are opened, the platform may fall out, increasing the risk of injury to the lift operator.
Correction:
Cummings will notify owners to take buses to a ricon dealer or service center who will install supplemental platform support bumpers. any platform that has already started cracking will be replaced, free of charge. the recall began january 13, 2015. owners may contact cumming's customer service at 1-800-639-5438 or ricon customer service at 1-800-322-2884. cumming's number for this recall is 14e-041.
Notes:
Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.
Campaign:
15V729000 on 11/03/2015
Component:
Equipment adaptive
Manufactured:
12/31/2005 - 12/30/2014
Affected:
667
Defect:
Mobilityworks (wmk inc.) is recalling certain model year 2006-2014 ford e-150, e-250, and e-350 vans modified by mobilityworks to be equipped with certain model s2005, s2010, s5005, s5010, s5505, and s5510 wheelchair lifts manufactured by ricon corporation. the affected lifts are equipped with folding link arms that may have pivot holes that are too big, allowing the bearings to move out of position.
Consequence:
If the bearings move out of position, the stowed platform may have excessive movement resulting in failure of the platform mounting. this failure could cause the wheel chair lift platform to fall out of the vehicle when the doors are opened, increasing the risk of injury for the lift operator.
Correction:
Mobilityworks will notify owners, and ricon dealers will inspect the link arms for damage or for displaced bearings. the platform will be inspected for cracks. any damaged parts will be replaced, free of charge. the recall began on december 15, 2015. owners may contact mobilityworks customer service at 1-800-769-8267, or ricon customer service at 1-800-322-2884. note: these vehicles and wheelchair lifts were subject to a similar recall in 2014. all vehicles that received that recall remedy are still affected by this recall as well.
Notes:
Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.
Campaign:
15V763000 on 11/16/2015
Component:
Equipment adaptive
Manufactured:
04/03/2006 - 08/06/2014
Affected:
285
Defect:
Mobility specialists, inc. (mobility specialists) is recalling certain model year 2006-2014 ford e-250, and e-350 vehicles modified to be equipped with certain model s2005, s2010, s5005, s5010, s5505, and s5510 wheelchair lifts manufactured by ricon corporation. the platform side plate of the affected wheelchair lifts may crack. additionally, the affected lifts are equipped with folding link arms that may have pivot holes that are too big, allowing the bearings to move out of position.
Consequence:
If the platform side plates crack, the lift platform can separate from the lift and come to rest against the vehicle's lift door. when the doors are opened, the platform may fall out, increasing the risk of injury to the lift operator. additionally, if the bearings move out of position, the stowed platform may have excessive movement resulting in failure of the platform mounting. this failure could cause the wheel chair lift platform to fall out of the vehicle when the doors are opened, increasing the risk of injury for the lift operator.
Correction:
Mobility specialists will notify owners to take their vehicles to a ricon dealer or service center who will install supplemental platform support bumpers. any platform that has already started cracking will be replaced, free of charge. the recall began on november 13, 2015. owners may contact mobility specialists customer service at 1-877-777-5438, or ricon customer service at 1-800-322-2884.
Notes:
Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.
Campaign:
15V779000 on 11/19/2015
Component:
Equipment adaptive
Manufactured:
12/31/2005 - 09/29/2014
Affected:
278
Defect:
New england wheels is recalling certain model year 2006-2014 ford e-250, and e-350 cargo vans modified to be equipped with certain model s2005, s2010, s5005, s5010, s5505, and s5510 wheelchair lifts built by the ricon corporation. the affected lifts are equipped with folding link arms that may have pivot holes that are too big, allowing the bearings to move out of position.
Consequence:
If the bearings move out of position, the stowed platform may have excessive movement resulting in failure of the platform mounting. this failure could cause the wheel chair lift platform to fall out of the vehicle when the doors are opened, increasing the risk of injury for the lift operator.
Correction:
New england wheels will notify owners, and ricon dealers will inspect the link arms for damage or for displaced bearings. the platform will be inspected for cracks. any damaged parts will be replaced, free of charge. the recall began on january 5, 2016. owners may contact new england wheels customer service at 1-800-866-9247, or ricon customer service at 1-800-322-2884. new england wheels' number for this recall is 15e-068. note: these vans and wheelchair lifts were subject to a similar recall in 2014. all vehicles that received that recall remedy are still affected by this recall as well.
Notes:
Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.
Campaign:
16V350000 on 05/23/2016
Component:
Equipment adaptive
Manufactured:
12/31/2005 - 04/19/2015
Affected:
2
Defect:
New england wheels (new england) is recalling certain model year 2006-2014 ford e-250, e-350, and 2015 ford transit vans equipped with certain model s2005, s2010, s5005, s5010, s5505, and s5510 wheelchair lifts by ricon. the platform side plate of the affected wheelchair lifts may crack. additionally, the lifts are equipped with folding link arms that may have pivot holes that are too big, allowing the bearings to move out of position.
Consequence:
If the platform side plates crack or the platform mounting fails from out-of-position bearings, the lift platform can separate from the lift and come to rest against the vehicle's lift door. when the vehicle's doors are opened, the platform may fall onto the lift operator, increasing their risk of injury.
Correction:
New england will notify owners, and ricon dealers will inspect the link arms for damage or for displaced bearings. the platform will be inspected for cracks. any damaged parts will be replaced, free of charge. the recall began on june 29, 2016. owners may contact new england customer service at 1-800-886-9247. new england's number for this recall is 16e-020.
Notes:
Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.

2009 FORD E-250 TSBs (19)

Bulletin:
TSB-09-20-7
Component:
010000 steering
Summary:
Ford: steering wander. some vehicles may exhibit steering wander or free play. steering gear mesh load adjustment. front end alignment may be adjusted to improve the wander/free play condition. sticky on center feel may also be due to b
Bulletin:
TSB11-1-5
Component:
063100 engine and engine cooling:exhaust system:emission control
Summary:
Ford: vehicles may run rough, hard start after refueling, clicking noise under hood, and have trouble codes stored. *rm
Bulletin:
SIS-21841
Component:
118000 electrical system: software
Summary:
Comm-trans lund: some 2009-2011 models may have the air bag inicator flashing with a stored trouble code. this is a software problem. *rm
Bulletin:
AS-21769
Component:
046000 service brakes, air:antilock
Summary:
Ford: if there is an intermittent lack of power, surge, or hesitation while driving the brakes will override acceleration. *rm
Bulletin:
ER-2011-001P
Component:
355100 equipment:other:labels
Summary:
Roush industries service campaign: see document search button for owner letter. the emission control labels do not meet standards. *rm
Bulletin:
TSB-11-8-8
Component:
061000 engine and engine cooling:engine
Summary:
Ford: after refueling vehicle, would be hard to start, runs rough and an audible clicking noise can be heard. *pe
Bulletin:
ER-11-2011
Component:
355100 equipment:other:labels
Summary:
Roush industries: see document search button for owner letter. on some trucks, roush determined an incorrectly installed label was placed for vehicle emission control mandated by epa. *pe
Bulletin:
CSP-13B15
Component:
190000 tires
Summary:
Ford: there is an increasing number of tires experiencing rapid air loss and/or tread loss, on some vans, causing tire failure and possible crash and tires need to be replaced. model 2010-2013 e series (e-150, 250, 350, 450).
Bulletin:
TSB-14-0022
Component:
103100 power train:automatic transmission:control module (tcm, pcm)
Summary:
Ford: the diagnostic trouble code (dtc) p0130, (oxygen sensor circuit bank 1, sensor 1) or p0150 (oxygen sensor circuit bank 2, sensor 1) will appear when the malfunction indicator lamp (mil) is illuminated on some trucks and service proce
Bulletin:
ASI-44404
Component:
061200 engine and engine cooling:engine:diesel
Summary:
Ford: on some trucks, there is a no crank situation and if voltage on transmission range sensor at pin 21, is less than 5 volts, disconnect the engine cooling fan clutch, electronically, and recheck voltage. model 2003-2007 f super duty,
Bulletin:
ASI-44538
Component:
103000 power train:automatic transmission
Summary:
Ford/lincoln/mercury: the indicator may illuminate overdrive off and/or slipping in 3rd or no 4th gear, due to direct clutch failure and diagnostic trouble code (dtc) p0733 and/or p0734. model 2008-2013 mark lt, f-150, crown victoria, gra
Bulletin:
ASI-44534
Component:
103000 power train:automatic transmission
Summary:
Ford: when shifting between park, reverse and/or during 2-3 shift, an intermittent clunk occurs with a torqshift transmission. model 2003-2014 f-super duty, e series, excursion, f-53 motorhome chassis, low cab forward. *p
Bulletin:
TSB-14-0153
Component:
103000 power train:automatic transmission
Summary:
Ford/lincoln/mercury: failure of planetary gear assembly is due to transmission, on certain vehicles, exhibiting grinding, gear slippage, whine type noise, vibration, while driving or loss of reverse. *pe
Bulletin:
16-0032
Component:
100000 power train
Summary:
4r75e transmission - grinding/whine/vibration/gear slippage - service kit available issue a service kit has been released to assist with proper repair of the 4r75e transmission in 2008 mark lt, 2008-2010 f-150, 2008-2010 / 2013-2014 e-ser
Bulletin:
SSM-45869
Component:
118000 electrical system: software
Summary:
2009-2016 e-series ' difficulty programing trailer brake control (tbc) module.
Bulletin:
SSM 46900
Component:
103100 power train:automatic transmission:control module (tcm, pcm)
Summary:
Some vehicles may exhibit a no start condition with an illuminated malfunction indicator lamp (mil) and a dtc p161a after pcm replacement. this may be due to the parameter reset procedure not being properly completed. to clear this dtc, use
Bulletin:
SSM 47201
Component:
350000 equipment
Summary:
Replacing the original equipment sync/navigation system with either an aftermarket sync/navigation kit or modifying original sync/navigation parts to provide additional features is not recommended nor supported on any ford, mercury or linco
Bulletin:
SSM 47009
Component:
353000 equipment:electrical
Summary:
The accessory (wireless) keyless entry keypad can only be used with vehicles that are factory built with remote keyless entry (rke). the master code for the accessory (wireless) keyless entry keypad can be retrieved from fmcdealer - parts a
Bulletin:
DOR-B8H4Z-11
Component:
010000 steering
Summary:
This sku is a front upper ball joint. the customer communication requested return of unsold inventory to inspect for ball studs with excessive rotational friction in the ball joint assembly. excessive friction in the ball joint assembly ma

Home | Privacy