2009 BMW 3 SERIES Recall

Campaign:
12E029000 on 08/13/2012
Component:
Engine and engine cooling:cooling system:fan
Affected:
585
Defect:
This recall involves aftermarket parts sold by valeo. valeo is recalling certain engine cooling fans, part numbers 696121, 696273, and 696275, used as service replacement parts for model year 2008-2011 bmw 1-series, 2006-2011 bmw 3-series, 2000-2009 bmw 5-series, 2004-2005 bmw 6-series, and 2006-2007 bmw 7-series vehicles. a metal-oxide semiconductor may overheat due to insufficient screwing of the semiconductor on the aluminum heat sink. this primary failure could cause adjacent components on the fan assembly motor circuit board to overheat and short.
Consequence:
This condition could cause the fan motor to become inoperative, or cause the motor circuit board in the assembly to overheat, potentially leading to a fire in the engine compartment.
Correction:
Valeo will notify owners and replace the fans free of charge. the safety recall began on august 22, 2012. this recall is being conducted by valeo, not by bmw. for further information, owners may contact valeo at 1-888-718-2536.
Notes:
Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.

2009 BMW 3 SERIES TSBs (81)

Bulletin:
SIB-11-02-08
Component:
061000 engine and engine cooling:engine
Summary:
Bmw vehicle: the service engine soon (mil) lamp is illuminated and a power reduction is clearly perceptible. this situation may occur after driving for some time with the engine already at full operating temperature. if the ignition is c
Bulletin:
SIB-11-14-07
Component:
061000 engine and engine cooling:engine
Summary:
Bmw vehicle: n54 turbocharger waste gate control noises and operation. after turning off engine, a slight rattle noise is heard from the engine compartment. this noise is similar to a mechanical typewriter. in addition, the complaints o
Bulletin:
SIB-34-078-07
Component:
102000 power train:manual transmission
Summary:
Bmw vehicles: dsc disabling function. dsc off function has been implemented in m5 and m6 vehicles equipped with the optional 6 speed manual transmissions. no model years listed. *pe
Bulletin:
SIB-36-05-07
Component:
199000 tires:pressure monitoring and regulating systems
Summary:
Bmw: tire warning light illuminated due to low ambient temperature. model e90, e91(3 series);e92, e92 (3 series); e60 (5 series); e60 (m5); e63, e64 (6 series); e63, e64 (m6); e65, e66 (7 series); e70 (x5); e83 (x3); and e85, e86 (z4).
Bulletin:
SIB-16-01-06
Component:
072100 fuel system, gasoline:delivery:fuel pump
Summary:
Bmw: fuel level sensor repair procedure. the case where it is necessary to replace the right side fuel level sensor due to a failure, the entire pump and housing does not need to be replaced. no model years listed. *pe
Bulletin:
SIB-24-03-08
Component:
061000 engine and engine cooling:engine
Summary:
Bmw: complaint of a delayed engagement and a harsh jolt when accelerating from a stop. the situation occurs only during the engine warm up phase (cold engine), and cannot be reproduced in the sport mode. egs software-unfavorable nic cali
Bulletin:
SIB-16-02-09
Component:
072100 fuel system, gasoline:delivery:fuel pump
Summary:
Bmw vehicles: fuel level sensor repairs. where it is necessary to replace the right or the left side fuel level sensor due to a failure, the entire pump and housing or delivery unit (suction jet assembly) do not need to be replaced as wel
Bulletin:
SIB-16-08-06
Component:
091200 fuel system, other:storage:fuel gauge system
Summary:
Bmw vehicles: engine cranks but does not start; fuel level gauge displays a sufficient amount of fuel, although the fuel tank is empty; fault code 2a1c (fuel level plausibility) is stored in msv80. right side fuel sending unit is dislodge
Bulletin:
SIB-41-02-09
Component:
022520 suspension:rear:axle:non-powered axle assembly
Summary:
Bmw vehicles: rear axle carrier (sub frame) support proposed class action settlement. under certain circumstances, a fracture in the steel body structure could form in the area around one of the rear axle carrier mounting points. as a re
Bulletin:
SI-B-63-06-10
Component:
123000 exterior lighting:tail lights
Summary:
Bmw: leds in rear lamp inoperative. the leds (light emitting diodes) in the outer left or outer right rear lamp are inoperative. affected are the leds for the parking lamp/tail lamp or the turn signals. no check control message is displ
Bulletin:
SI-B-13-03-10
Component:
061200 engine and engine cooling:engine:diesel
Summary:
Bmw: program control units. vehicles with m57y diesel engine. service engine soon lamp (mil) is illuminated erroneously. dde software error. *pe
Bulletin:
SIB-61-18-09
Component:
110000 electrical system
Summary:
Bmw vehicles: various simultaneous electrical problems. there is a software error in the jbbfe-3r control module. very intermittently, the jbbfe-3r wakes up in bootloader ode instead of application mode. perform diagnostics with ista and
Bulletin:
SI-B12-22-10
Component:
061000 engine and engine cooling:engine
Summary:
Bmw vehicle: program control units. service engine soon (mil) lamp may come on due to a diagnostic error. to determine whether a specific vehicle has had this service completed or is affected by this service, first check the b pillar lab
Bulletin:
SIB-16-04-10
Component:
071100 fuel system, gasoline:storage:tank assembly
Summary:
Bmw vehicle: teileclearing for diagnostic module tank leakage (dmtl) system. teileclearing process has been developed to help identify the root causes of customer complaints relating to the dmtl system (e.g., evaporative system leaks, che
Bulletin:
SIB-24-01-08
Component:
103000 power train:automatic transmission
Summary:
Bmw vehicle: transmission warning light is illuminated and the transmission enters failsafe mode. fault code 4f81 (ratio monitoring, clutch a), in some cases combined with the subsequent faults 507b/507c (parking gear sensor implausible s
Bulletin:
SIB-63-02-08
Component:
123000 exterior lighting:tail lights
Summary:
Bmw vehicle: rear bulb failure. the bulb out warning shows in the instrument cluster. diagnosis shows a fault for the rear lamp. the bulb out can be displayed for 2 possible causes: poor fit between the bulb and bulb holder; bulb failur
Bulletin:
SIB-72-01-10
Component:
151000 seat belts:front
Summary:
Bmw vehicle: front safety belt does not retract smoothly or jams. the upper part of the driver's or passenger's front safety belt does not roll up fully or rolls up slowly. the adjustment of the inertia reel is incorrect at the fastenin
Bulletin:
SIB-32-04-07
Component:
015000 steering:hydraulic power assist system
Summary:
Bmw: a new technical process has been created for bmw to identify causes of steering complaints with a wide range of models. *rm
Bulletin:
SIB-28-02-08
Component:
102000 power train:manual transmission
Summary:
Bmw: a new technical process is being used on many models to determine the root cause of double-clutch transmission problems. *rm
Bulletin:
SIB-16-03-10
Component:
061200 engine and engine cooling:engine:diesel
Summary:
Bmw: warning message on about low diesel exhaust fuel level and that the engine will not restart within 999 miles. the light comes on a few thousand miles earlier than a recommended oil change. *rm
Bulletin:
SIB-13-07-10
Component:
061000 engine and engine cooling:engine
Summary:
Bmw: there is a rough engine idle and "service engine soon light" when driving downhill in high altitudes during cold weather. there may be six different fault codes. *rm
Bulletin:
SIB-11-02-10
Component:
061200 engine and engine cooling:engine:diesel
Summary:
Bmw: service engine soon light is on with diesel engines. *rm
Bulletin:
SIB-13-02-10
Component:
070000 fuel system, gasoline
Summary:
Bmw: it is now possible to perform a fuel quality detection test on vehicles with an n54 engine. *rm
Bulletin:
SIB-13-06-10
Component:
061000 engine and engine cooling:engine
Summary:
Bmw: a service engine soon light comes on. the engine will only operate to 1500 rpms and lacks power. there is a software application error. *rm
Bulletin:
SIB-11-08-03
Component:
061000 engine and engine cooling:engine
Summary:
Bmw: six different models equipped with the m54 engine could have valve covers break in cold weather and ruin the engine. this is due to moisture accumulation. *rm
Bulletin:
SIB-63-02-01
Component:
120000 exterior lighting
Summary:
Bmw: procedure for determining and replacing incandescent and halogen light bulbs under warranty. *rm
Bulletin:
SIB-65-24-03
Component:
141000 air bags:frontal
Summary:
Bmw: operating description of the passenger airbag status light. *rm
Bulletin:
SIB-12-18-10
Component:
061000 engine and engine cooling:engine
Summary:
Bmw: bmw: there is a software error that is causing the service engine soon light to illuminate without a fault code. *rm
Bulletin:
SIB-27-01-07
Component:
104000 power train:transfer case (4-wheel drive)
Summary:
Bmw: a fault for oil wear is stored in the memory, but it does not illuminate the warning lamp. *rm
Bulletin:
SIB-51-20-09
Component:
162500 structure:body:tailgate
Summary:
Bmw: the tailgate opens slower in low temperatures and doesnt fully open. *rm
Bulletin:
SIB-41-03-10
Component:
162510 structure:body:tailgate:hinge and attachments
Summary:
Bmw: on e91 models the instructions for repairing/removing the tailgate hinge has been revised. *rm
Bulletin:
SIB-28-01-10
Component:
102000 power train:manual transmission
Summary:
Bmw: there is a software problem with the dual clutch transmission module. data can't be read from the module's memory. *rm updated 8/10/11. *pe
Bulletin:
SIB-22-01-10
Component:
061000 engine and engine cooling:engine
Summary:
Bmw: there can be vibration in the engine while driving at various speeds due to engine mount bracket bolts. *rm
Bulletin:
SIB-16-01-09
Component:
063000 engine and engine cooling:exhaust system
Summary:
Bmw: there is an extraction and refilling process for the desiel exhaust fluid. e70 and e90 models. *rm
Bulletin:
SIB-65-36-09
Component:
114000 electrical system:wiring
Summary:
Bmw: the airbag warning lamp is illuminated due to a software error. *rm
Bulletin:
SIB-12-21-10
Component:
061000 engine and engine cooling:engine
Summary:
Bmw: service engine soon light is on. the vehicle lost power and the engine cranks with no start. *rm updated 5/19/15. *pe
Bulletin:
SIB-72-03-10
Component:
151000 seat belts:front
Summary:
Bmw: on some e92 models the safety belt extender is not extending the belt or is noisy. this can be a fault of the extender or the belt is contorted. *rm
Bulletin:
SIB-12-24-05
Component:
116000 electrical system:ignition
Summary:
Bmw: the service engine soon light may be on with the vehicle running rough and internal misfire codes. this is an ignition coil problem. *rm
Bulletin:
SIB-32-01-09
Component:
011000 steering:wheel and handle bar
Summary:
Bmw: immediately after a cold start if electronic components are turned on such as heated seats it may switch off after 5-10 seconds because of a voltage level dip. *rm
Bulletin:
SIB-11-13-07
Component:
061120 engine and engine cooling:engine:gasoline:turbo-charger
Summary:
Bmw: there is a clanking noise from the engine or exhaust area. wastegate valve is not completely closing and clanking. *rm updated 7/17/12. *pe
Bulletin:
SI B12 55 06
Component:
060000 engine and engine cooling
Summary:
Bmw: there may be excessive cranking before the vehicle starts. the service engine soon light may also be on with a lack of engine power. *rm
Bulletin:
SI B12 11 10
Component:
060000 engine and engine cooling
Summary:
Bmw: there are high fuel pressure faults stored due to a software error. *rm
Bulletin:
SI B12 02 11
Component:
060000 engine and engine cooling
Summary:
Bmw: on low mileage vehicles the engine runs rough, mifires, or fails to crank. this is caused by multiple short start-ups without the engine properly going through a warm-up phase. *rm
Bulletin:
SIB-52-12-10
Component:
221700 seats:front assembly:seat heater/cooler
Summary:
Bmw: the front seat heater activates on its own because of defective wiring contacts. *rm
Bulletin:
SIB-11-03-08
Component:
063110 engine and engine cooling:exhaust system:emission control:crankcase (pcv)
Summary:
Bmw: crankcase pressure diagnosis and information for all vehicles. *rm updated on 4/24/2013. *kb
Bulletin:
SIB-17-05-10
Component:
061000 engine and engine cooling:engine
Summary:
Bmw: the service engine light is on with stored fault codes. there is a wiring/connection problem or a faulty sensor. *rm
Bulletin:
SIB-51-18-06
Component:
162300 structure:body:door
Summary:
Bmw: the painted surface on the interior door handle may peel due to exposure to hand creams and sun-tanning lotions. *rm
Bulletin:
SIB-12-01-11
Component:
091100 fuel system, other:storage:tank assembly
Summary:
Bmw: the service engine soon light is on while driving. this is a programming issue. *rm updated 1/4/12. *pe updated 4/24/12. *pe
Bulletin:
SIB-23-01-08
Component:
103000 power train:automatic transmission
Summary:
Bmw: a new technical support process has been created regarding transmission concerns. *rm
Bulletin:
SIB-63-04-11
Component:
330000 interior lighting
Summary:
Bmw: the seal on the rear lamps in the side panel emits a gas and causes damage to the electrical connectors on the leds inside the lamp. e91. *rm
Bulletin:
SIB-63-03-11
Component:
121000 exterior lighting:headlights
Summary:
Bmw: wiring on the headlights may have deteriorated due to environmental conditions and the cover not being secured properly. e60/e92. *rm updated 9/30/11. *pe
Bulletin:
SIB-12-16-07
Component:
060000 engine and engine cooling
Summary:
Bmw: a software error is causing the the service engine soon light to come on. there will be stored trouble codes. *rm
Bulletin:
SIB-51-09-11
Component:
117000 digital instrument panel
Summary:
Bmw: poor electrical connections are causing the instrument cluster to show the doors are open while driving even though they are closed. *rm
Bulletin:
CN-10E-A02
Component:
072100 fuel system, gasoline:delivery:fuel pump
Summary:
Bmw service campaign: see document search button for owner letter. there may be a problem with the fuel pump which could not meet emissions requirements. there may be a long crank and a service engine soon light. *rm
Bulletin:
SIB-61-01-11
Component:
110000 electrical system
Summary:
Bmw: various functions in the vehicle are not working including: instruments, door locks, wipers, and other electrical functions. there may also be warning lights on. k-can wiring in the vehicle shorted. *rm updated 10/5/11. *pe
Bulletin:
SIB-12-15-11
Component:
061000 engine and engine cooling:engine
Summary:
Bmw: the service engine soon light is on. there are trouble codes stored for the crankshaft sensor. no driveability issues. *rm
Bulletin:
SIB-33-01-02
Component:
022520 suspension:rear:axle:non-powered axle assembly
Summary:
Bmw: a grinding noise is coming from the differential during slow cornering. when turning a slip/stick effect is created on the lining and steel discs incorporated in the differential clutch causes a grinding noise. *rm
Bulletin:
SIB-61-08-11
Component:
110000 electrical system
Summary:
Bmw: the vehicle electrical system fails and the vehicle fails to start. the central locking system fails to operate with the remote key. the key cannot be inserted into the key slot. communication to the vehicle is not possible. the positi
Bulletin:
TS-12-19-10
Component:
061000 engine and engine cooling:engine
Summary:
Bmw: service engine soon light is on with a fault code stored. internal dmtl pump failure.*rm
Bulletin:
SIB-51-46-10
Component:
162300 structure:body:door
Summary:
Bmw: the door cannot be locked or unlocked when using the key or key remote. lubrication of the door can cause defects. *rm
Bulletin:
SIB-63-05-10
Component:
053000 parking brake:indicator light
Summary:
Bmw: the rear led lights are inoperative. there is connection corrosion in the tail lamp. *rm
Bulletin:
SIB-12-16-11
Component:
061000 engine and engine cooling:engine
Summary:
Bmw: service engine soon light is on and the engine has reduced power with trouble codes stored. *rm updated on 4/24/2013. *kb
Bulletin:
SIB-72-01-11
Component:
150000 seat belts
Summary:
Bmw: e92. the seat belt extender on the front driver's or passenger side failed to deliver the belt. the safety belt extender extends but the belt slips off. the 'hand' on the extender fails. the safety belt is twisted. the extender will no
Bulletin:
SIB-13-13-10
Component:
063100 engine and engine cooling:exhaust system:emission control
Summary:
Bmw: on some vehicles, the high pressure fuel pump has an internal component that may fail and causing drivability symptoms such as erratic engine operation and longer starting times. *pe
Bulletin:
SIB-61-06-11
Component:
118000 electrical system: software
Summary:
Bmw: on certain vehicles, the jbe (junction box electronics) module fails programming during a software update of the vehicle. *pe
Bulletin:
SIB-16-03-12
Component:
091100 fuel system, other:storage:tank assembly
Summary:
Bmw: the evaporative system leakage is found, when using the nvld tank leakage test plan. *pe updated 1/18/13. *pe
Bulletin:
SIB-61-02-12
Component:
110000 electrical system
Summary:
Bmw: electronic malfunction and various check control messages are displayed in cid (central information display) and instrument cluster. *pe models 2009-2012 e70, e71, e72, e82, e88, e90, e91, e92, e93, f01, f02, f04, f07, f10, f1
Bulletin:
B63-03-12
Component:
123000 exterior lighting:tail lights
Summary:
Bmw: the left or right rear light in the side panel has condensation concerning vehicles produced up to february 27,2012. *js
Bulletin:
SIB-01-02-12
Component:
063100 engine and engine cooling:exhaust system:emission control
Summary:
Bmw: a failure of the turbocharger wastegates, caused by a defect, has an emissions extended warranty, 8 years or 82,000 miles, whichever comes first, not otherwise falling within coverage exclusion. *pe
Bulletin:
SIB-12-14-12
Component:
060000 engine (pws)
Summary:
Bmw: experiencing loss of engine power, service engine soon lamp is illuminated, a noise, like rattling, coming from engine compartment. *pe updated 10/31/12. *pe models 2010 e70, 71, 82, 88, 90, 92, 93, f07, 10, 12, 13, 25.
Bulletin:
SIB-18-02-12
Component:
063100 engine and engine cooling:exhaust system:emission control
Summary:
Bmw: see document search button for owner letter. the replacing and/or checking of emissions monitoring components to increase emissions stability, high pressure (hp) egr valve restriction of excessive soot and improved diesel exhaust f
Bulletin:
SIB122512
Component:
060000 engine (pws)
Summary:
Bmw: vehicle does not start: loose ground z6000 *4b. covered under the terms of the bmw new vehicle/sav limited warranty. *js
Bulletin:
SIB270212
Component:
103000 power train:automatic transmission
Summary:
Bmw: dsc warning light is on. the warning lamps for dsc, abs and brake warning illuminated. there may also be a warning in the control display for chassis control system failure. *js
Bulletin:
SIB-61-37-12
Component:
111000 electrical system:battery
Summary:
Bmw: the high-voltage (hv) battery cells could be damaged if the vehicle is prevented from entering sleep mode for an extended period of time. updated 03/11/2013 *js
Bulletin:
SIB-61-13-05
Component:
111000 electrical system:battery
Summary:
Bmw: battery has an increased demand due to developemental process of the electrical system. this is causing the batter to need to undergo an energy diagnosis. *kb
Bulletin:
SIB-34-06-12
Component:
045000 service brakes, air:disc
Summary:
Bmw: warning lamps are illuminated for the dsc, abs and brake and a possible warning in control display for chassis control system failure. models 2012 f25, 30, 01, 02, 07, 10, 12, 13, e70, 71, 84. *pe
Bulletin:
SIB-12-15-13
Component:
061000 engine and engine cooling:engine
Summary:
Bmw: service engine and engine malfunction light illuminates. vehicle may have reduced power output. fault code may not clear from dme fault memory. *kb updated on 11/8/2013. *kb updated 2/21/2014 *js updated 3/11/14. *
Bulletin:
SIB-84-03-14
Component:
118000 electrical system: software
Summary:
Bmw: when using iphone, various connectivity failures occur, such as disconnection of call, list of contacts incomplete, due to the variants and software used. model 2008-2014.
Bulletin:
SIB-16-16-14
Component:
060000 engine (pws)
Summary:
Bmw: selective catalyst reduction module (scr) has a stored fault, pressure build up is low, causing service engine soon light to illuminate. *
Bulletin:
SIB-63-11-14
Component:
121300 exterior lighting:headlights:high/low beam dimmer switch
Summary:
Bmw: on some vehicles, when starting, low beam, with 0552 option, would briefly flashes, due to a faulty led main light module that needs replacing. model 2008-14 f01, f02, f06, f07, f10, f12, f13, f25. *pe
Bulletin:
B540907
Component:
160000 structure
Summary:
Retractable hardtop status request supplement

Home | Privacy