2008 TOYOTA TUNDRA Recalls (11)

Campaign:
09V223000 on 06/14/2009
Component:
Equipment:other:labels
Manufactured:
08/31/2005 - 05/03/2009
Affected:
27,080
Defect:
Toyota is recalling 27,080 model year 2005 through 2010 passenger cars built from september 1, 2005 to may 4, 2009. these vehicles were not equipped with load carrying capacity modification labels which fails to conform with the requirements of federal motor vehicle safety standard no. 110, "tire selection and rims."
Consequence:
Incorrect load carrying capacity modification labels could result in the vehicle being overloaded, increasing the risk of a crash.
Correction:
Toyota will notify owners and provide them with a new, accurate label to be installed over the inaccurate label free of charge. the safety recall began on august 18, 2009. owners may contact toyota at 1-888-270-9371.
Notes:
Owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to <a href=http://www.safercar.gov>http://www.safercar.gov</a> .
Campaign:
09V388000 on 10/05/2009
Component:
Vehicle speed control:accelerator pedal
Affected:
4,445,056
Defect:
Toyota is recalling certain model year 2004-2010 passenger vehicles. the accelerator pedal can get stuck in the wide open position due to its being trapped by an unsecured or incompatible driver's floor mat.
Consequence:
A stuck open accelerator pedal may result in very high vehicle speeds and make it difficult to stop the vehicle, which could cause a crash, serious injury or death.
Correction:
Toyota filed an amended defect report on november 25, 2009, stating that dealers will modify the accelerator pedal and, on certain vehicles, alter the shape of the floor surface under the pedal. these changes address the risk of pedal entrapment due to interference with the floor mat. redesigned accelerator pedals will become available beginning in april 2010 and dealers will replace any modified pedal with the new pedal if desired. also, dealers will replace any genuine toyota or lexus all-weather floor mats with redesigned all-weather mats, or repurchase the previous mats from owners who do not want the new ones. additionally, software modifications will be installed on camry, avalon and lexus es 350, is 350 and is 250 models that will ensure that the brake overrides the accelerator in the event both brake and accelerator pedals are applied. toyota will begin mailing letters to owners on december 31, 2009. owners may contact toyota at 1-800-331-4331, lexus at 1-800-255-3987.
Notes:
Toyota recall no. 90l/90lg.owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to <a href=http://www.safercar.gov>http://www.safercar.gov</a> .
Campaign:
10V017000 on 01/20/2010
Component:
Vehicle speed control:accelerator pedal
Manufactured:
01/03/2007 - 01/20/2010
Affected:
2,230,661
Defect:
Toyota is recalling certain model year 2005-2010 avalon, model year 2007-2010 camry, model year 2009-2010 corolla, corolla matrix, rav4, model year 2010 highlander, model year 2008-2010 sequoia, and model year 2007-2010 tundra vehicles. due to the manner in which the friction lever interacts with the sliding surface of the accelerator pedal inside the pedal sensor assembly, the sliding surface of the lever may become smooth during vehicle operation. in this condition, if condensation occurs on the surface, as may occur from heater operation (without a/c) when the pedal assembly is cold, the friction when the accelerator pedal is operated may increase, which may result in the accelerator pedal becoming harder to depress, slower to return, or, in the worst case, mechanically stuck in a partially depressed position.
Consequence:
The accelerator pedal may become hard to depress, slow to return to idle, or, in the worst case, mechanically stuck in a partially depressed position, increasing the risk of a crash.
Correction:
Dealers will install a reinforcement bar in the accelerator pedal which will allow the pedal to operate smoothly. gm will notify owners for the pontiac vibe please see 10v-018. this service will be performed free of charge. the safety recall is expected to begin on february 5, 2010 and will be completed on march 15, 2010. owners may contact toyota at 1-800-331-4331.
Notes:
Toyota safety recall no. aoa. owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to <a href=http://www.safercar.gov>http://www.safercar.gov</a> .
Campaign:
10V036000 on 02/02/2010
Component:
Equipment:other:labels
Affected:
153,418
Defect:
Southeast toyota is recalling certain model year 2005-2011 passenger vehicles for failing to comply with the requirements of federal motor vehicle safety standard no. 110, "tire selection and rims." these vehicles were sold without the requisite load carrying capacity modification labels.
Consequence:
A driver may overload a vehicle which may increase the risk of a crash.
Correction:
Dealers will mail to consumers the corrected label or the customer will have the option for dealers to install the label free of charge. the safety recall began on may 27, 2010. owners may contact southeast toyota at 1-800-301-6859.
Notes:
Owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to <a href=http://www.safercar.gov>http://www.safercar.gov</a> .
Campaign:
10V035000 on 02/02/2010
Component:
Equipment:other:labels
Affected:
271,417
Defect:
Gulf states toyota is recalling certain model year 2005-2010 vehicles for failing to comply with the requirements of federal motor vehicle safety standard no. 110, "tire selection and rims." these vehicles were sold between september 1, 2005 and june 2, 2008 without the requisite load carrying capacity modification labels.
Consequence:
This does not meet the standard requirements.
Correction:
Dealers will mail to consumers the corrected label or the customer will have the option for dealers to install the label free of charge. dealers will also correct the owner's manual. the safety recall began on may 27, 2010. owners may contact gulf states toyota at 713-580-3300.
Notes:
Owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to <a href=http://www.safercar.gov>http://www.safercar.gov</a> .
Campaign:
11V148000 on 03/03/2011
Component:
Tires:pressure monitoring and regulating systems
Affected:
22,000
Defect:
Toyota is recalling certain model year 2008 through 2011 fj cruiser, land cruiser, tacoma, sequoia and tundra vehicles for failing to comply with the requirements of federal motor vehicle safety standard no. 138, "tire pressure monitoring system (tpms)." when factory-installed wheels and tires were replaced with toyota authorized accessory wheels and lt tires prior to first sale, the tire pressure monitoring systems were not re-calibrated correctly and therefore do not start illuminating the low tire pressure warning telltale at the required minimum activation pressure.
Consequence:
Failure to warn of tire deflations is a non-compliance with fmvss 138 and could lead to tire failure increasing the risk of a crash.
Correction:
For the land cruiser, sequoia, tacoma and tundra vehicles, the dealer will re-calibrate the tire pressure monitoring system on affected vehicles and install an updated tire and loading information label at no charge. for the fj cruiser vehicles, the tpms cannot be reset so the electronic control unit (ecu) for the tpms will be replaced. toyota is currently developing the remedy ecu. if an owner is not certain whether his or her vehicle is equipped with these accessories, please contact any toyota dealer for an inspection at no charge. the safety recall began on march 31, 2011. owners may contact toyota at 1-800-331-4331.
Notes:
Owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to <a href=http://www.safercar.gov>http://www.safercar.gov</a> .
Campaign:
11V278000 on 05/11/2011
Component:
Tires:pressure monitoring and regulating systems
Affected:
1,629
Defect:
Southeast toyota is recalling certain model year 2007-2011 tundra vehicles for failing to comply with the requirements of federal motor vehicle safety standard no. 138, "tire pressure monitoring systems." the tpms on some vehicles may not have been properly calibrated and as a result the low tire pressure warning lamp may not illuminate should the inflation pressure in one or more of the vehicle's tires fall below the threshold for when the low tire pressure warning lamp should illuminate.
Consequence:
Drivers will not receive a warning from the tire pressure monitor that one or more tires are underinflated, increasing the risk that the vehicle will be driven with one or more underinflated tires, increasing the risk of a tire failure that may lead to a crash.
Correction:
Dealers will recalibrate the tire pressure monitoring system in accordance with the regulation free of charge. the safety recall began during july 2011. owners may contact southeast toyota customer assistance center toll free at 1-800-301-6859, monday through friday, 8:30 am to 5:00 pm, eastern standard time.
Notes:
Owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to <a href=http://www.safercar.gov>http://www.safercar.gov</a> .
Campaign:
12V491000 on 10/09/2012
Component:
Visibility:power window devices and controls
Manufactured:
10/25/2006 - 12/21/2008
Affected:
2,519,424
Defect:
Toyota is recalling certain model year 2007-2009 camry, camry hybrid, rav4, corolla, corolla matrix, tundra, sequoia, highlander, highlander hybrid, yaris, scion xb, scion xd and pontiac vibe vehicles. the power window master switch assemblies in some of these vehicles were built using a less precise process for lubricating the internal components of the switch assemblies. irregularities in this lubrication process may cause the power window master switch assemblies to malfunction and overheat.
Consequence:
If the switch overheats, it may melt, possibly resulting in a fire.
Correction:
Toyota will notify its owners, and dealers will inspect the switch and apply a special grease that inhibits heat build up or replace any switch damaged by the defect, free of charge. toyota owners that experience a problem with a switch should not attempt to make repairs, but should contact their toyota dealer or the toyota customer experience center at 1-800-331-4331. general motors will contact the pontiac vibe owners affected by this recall and gm dealers will inspect and repair switches as necessary. those owners may contact pontiac customer care at 1-800-762-2737.
Notes:
Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.
Campaign:
13V123000 on 04/08/2013
Component:
Equipment:other:labels
Affected:
7,525
Defect:
Southeast toyota is recalling certain model year 2008 and 2010-2013 toyota tundra, 2010-2012 rav4, 2012 toyota sequoia, 2010-2011 toyota corolla, 2010-2011 toyota camry and camry hybrid, 2010-2013 toyota highlander and highlander hybrid, 2010-2013 toyota fj cruiser, 2011 toyota land cruiser, 2010-2013 toyota venza, 2010-2011 toyota 4runner, 2010-2013 toyota tacoma, 2011-2012 toyota sienna, 2012 toyota prius, 2013 scion fr-s, 2011 scion xd, 2011 scion xb, and 2012 scion tc vehicles. these vehicles were sold with labels that were outside the allowable one percent of accuracy of actual weight added. thus, these vehicles fail to comply with the requirements of federal motor vehicle safety standard (fmvss) number 110, "tire selection and rims."
Consequence:
An inaccurate label could lead to owners overloading their vehicles and tires. an overloaded vehicle can result in a tire failure which may result in a vehicle crash, personal injury, or property damage.
Correction:
Southeast toyota will notify owners and provide a corrected label with instructions concerning its installation. a small group of the affected vehicles will need additonal remedies which are still being developed. the recall began on may 28, 2013. owners may contact southeast toyota at 1-800-301-6859.
Notes:
Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.
Campaign:
14V743000 on 11/18/2014
Component:
Seats:front assembly:seat heater/cooler
Manufactured:
05/31/2005 - 09/29/2011
Affected:
3,233
Defect:
Southeast toyota distributors, llc (set) is recalling certain model year 2010-2011 prius and corolla, 2009-2011 venza, 2006-2010 avalon, 2007-2010 fj cruiser, 2005-2011 sienna and sequoia, 2006-2011 tacoma 4x2 and 4x4, camry, highlander, tundra 4x2 and 4x4, and 2007-2011 rav4 and 4runner. the affected vehicles may experience compression of the seat cushion which may damage the seat heater wiring.
Consequence:
Damage to the seat heater wiring could cause the wires to short, increasing the risk of the seat burning and causing personal injury to the occupant.
Correction:
Set will notify owners, and dealers will disconnect the heaters with copper strand heating elements and refund the purchase price of the seat heater accessory, free of charge. the recall is expected to began in january 2015. owners may contact set customer service at 1-866-405-4226.
Notes:
Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.
Campaign:
16V396000 on 06/01/2016
Component:
Seats:front assembly:seat heater/cooler
Manufactured:
12/04/1987 - 01/26/2012
Affected:
7,749
Defect:
Southeast toyota distributors, llc (set) is recalling certain 2005-2011 4runner, highlander, sequoia, and sienna, 2005-2010 avalon and tundra, 2006-2008 camry solara, 2006-2010 highlander hybrid, 2006-2011 rav4 and tacoma, 2007-2010 fj cruiser, 2007-2011 camry hybrid, 2009-2010 venza, 2010-2012 prius, 1988-1990 and 2005-2010 camry, and 1989 and 2009-2010 corolla vehicles equipped with aftermarket accessory seat heaters with a copper strand heating element. the electrical wiring in the seat heaters may be damaged when the seat cushion is compressed.
Consequence:
If damaged, the copper strand heating element may short circuit, increasing the risk of a fire.
Correction:
Set will notify owners, and dealers will disconnect the seat heaters, free of charge, and refund the purchase price of the seat heater accessory. the recall began on july 14, 2016. owners may contact set customer service at 1-866-405-4226. set number for this recall is set16b.
Notes:
Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.

2008 TOYOTA TUNDRA TSBs (183)

Bulletin:
13707
Component:
980000 unknown or other
Summary:
Floor mat installation during (pds) pre-delivery service. *nj
Bulletin:
00507
Component:
203000 wheels:lugs/nuts/bolts
Summary:
Wheel lug nut torque specification. *nj
Bulletin:
01807
Component:
103700 power train:automatic transmission:torque converter
Summary:
Torque converter shudder. vehicles equipped with 6 speed atm. *nj
Bulletin:
TSB-0115-08
Component:
105300 power train:driveline:driveshaft
Summary:
Toyota: rear driveshaft/propeller shaft clunk/thunk noise. some owners of 4wd equipped 2007-2008 model year tundra vehicles may experience a clunk/thunk noise from the rear of the vehicle or a bump-from behind sensation just before or whe
Bulletin:
TSB-0133-08
Component:
016000 steering:electric power assist system
Summary:
Toyota: m.i.l. on dtc p0552/p0553: power steering pressure sensor malfunction. steering/power assist systems. *pe
Bulletin:
TSB-0325-08
Component:
032100 service brakes, hydraulic:switches:brake light
Summary:
Toyota vehicle: abs, brake, or 4wd mil "on". if the abs, brake, 4wd, and/or "check engine" light is "on" due to dtcs u0129 and p0500, replace the brake actuator assembly. *pe
Bulletin:
T-SB-0170-09
Component:
103000 power train:automatic transmission
Summary:
Toyota: automatic transmission/transaxle. transmissions in sequoia and/or tundra vehicles may experience transmission slipping, mil on with transmission shift performance dtcs such as p2714, p0751, p0756, p0766, p0729, p0781, p0894, p2757
Bulletin:
SB-0397-09 REV1
Component:
355200 equipment:other:owners/service/other manual
Summary:
Toyota: vehicle interior: interior panels/trim to improve serviceability of the floor carpet grommet (floor clamp retainer), a new service part has been developed which allows the floor carpet grommet to be replaced separately from the ca
Bulletin:
TSB-0121-08
Component:
105500 power train:driveline:differential unit
Summary:
Toyota: some four wheel drive trucks may exhibit a condition where a cyclic noise can be heard from the front of the vehicle between 15 and 30 mph (24-48km/h) only when driving in 2wd. this noise can be described as a howl, growl, grind,
Bulletin:
TSB-0329-08
Component:
061000 engine and engine cooling:engine
Summary:
Toyota: air injection pump with water intrusion-mil on dtc p0418, p0419, and/or p244#. *pe
Bulletin:
TSB-0151-10
Component:
106200 power train:axle assembly:axle shaft
Summary:
Toyota: rear ale bearing abnormal noise. some vehicles may exhibit a howling or growling noise from the rear of the vehicle that increases with vehicle speed. changes have been made to the rear axle bearing to correct this condition. *p
Bulletin:
TSB-0064-10
Component:
061000 engine and engine cooling:engine
Summary:
Toyota: techstream ecu flash reprogramming procedure. flash reprogramming allows the ecu software to be updated without replacing the ecu. flash calibration updates for specific vehicle models/ecus are released as field-fix procedures de
Bulletin:
TSB-0049-11
Component:
102000 power train:manual transmission
Summary:
Toyota: information on installing manual transmission shift lever or park neutral position switch. *rm
Bulletin:
SB-8040
Component:
200000 wheels
Summary:
Toyota service campaign: see document search button for owner letter. there may be crack devoloping in the spoke area of the wheel. 2007-2010 tundra. *rm
Bulletin:
SB-P-111
Component:
200000 wheels
Summary:
Toyota service campaign: see document search button for owner letter. 2007-2010 tundra. cracks may develop in the spoke area of the alloy wheels. *rm
Bulletin:
SB-00016
Component:
200000 wheels
Summary:
Toyota: a crack may develop in the spokes of the alloy wheels. the vehicles will function normally. *rm
Bulletin:
TSB-0122-11
Component:
140000 air bags
Summary:
Toyota: information provided for replacing the seat covers for vehicles equipped with side airbags. *pe
Bulletin:
TSB-0147-11
Component:
105300 power train:driveline:driveshaft
Summary:
Toyota: information is being provided for some 4wd vehicle experiencing a sensation of being bumped from behind before or when accelerating from a stop or may exhibit a clunk/thunk noise from the rear of vehicle. *pe
Bulletin:
TSB-0148-11
Component:
105300 power train:driveline:driveshaft
Summary:
Toyota: on some vehicles, coming from rear of vehicle, a noise like a clunk or thunk or a feeling of a bump from behind sensation would occur before or when accelerating from stop. on the rear propeller shaft (driveshaft) improvements h
Bulletin:
TTT-1177-11
Component:
061000 engine and engine cooling:engine
Summary:
Toyota: some vehicles may exhibit mil on condition (crankshaft position correlation bank 1/bank 2 sensor b) after engine area room repairs. these are 3ur and 1ur equipped vehicles. *pe
Bulletin:
TCS-11-027
Component:
061000 engine and engine cooling:engine
Summary:
Toyota: see document search button for owner letter. on some vehicles, due to moisture/water in air injection pumps and/or air switching valves in engines, the check engine light (malfunction indicator light) would illuminate. *pe
Bulletin:
TSB-0087-12
Component:
181000 vehicle speed control:accelerator pedal
Summary:
Toyota: accelerator pedal sensor assembly information regarding the inspection, removal, and installation, if lubrication or oil, is applied. *pe
Bulletin:
TSB-0101-12
Component:
161000 structure:frame and members
Summary:
Toyota: information provided regarding blistering or bubbling of paint where corrosion or perforation in specific areas inside of floor bed surface. *pe
Bulletin:
TC-14-032
Component:
350000 equipment
Summary:
Toyota: on some vehicles, information being sent out regarding installation of smart stop technology. model years 2003-2010 corolla, corolla matrix, land cruiser, highlander rav4, 4runner, tundra. *pe
Bulletin:
T-SB-0013-13
Component:
030000 brakes (pws)
Summary:
Summary to be provided on a future date.
Bulletin:
T-SB-0187-12
Component:
190000 tires
Summary:
Summary to be provided on a future date.
Bulletin:
T-TT-0051-10
Component:
353600 equipment:air conditioner
Summary:
Summary to be provided on a future date.
Bulletin:
T-TT-0124-11
Component:
190000 tires
Summary:
Summary to be provided on a future date.
Bulletin:
TC13-019
Component:
355200 equipment:other:owners/service/other manual
Summary:
Summary to be provided on a future date.
Bulletin:
T-TT-0268-13
Component:
353400 equipment:electrical:radio/tape deck/cd etc.
Summary:
Summary to be provided on a future date.
Bulletin:
PHASE 3
Component:
355200 equipment:other:owners/service/other manual
Summary:
Summary to be provided on a future date.
Bulletin:
SET-TSB-16-003
Component:
063100 engine and engine cooling:exhaust system:emission control
Summary:
Tundra split rear dual exhaust revised exhaust hangers on vehicles equipped with the set accessory split rear dual exhaust system, the exhaust pipe may become loose due to the rubber isolator separating from the bracket. thi
Bulletin:
T-SB-0012-13 REV
Component:
060000 engine (pws)
Summary:
"tsb: flash reprogramming allows the ecu software to be updated without replacing the ecu. flash calibration updates for specific vehicle models/ecus are released as field-fix procedures described in individual service bulletins. this bul
Bulletin:
T-TT-0381-16
Component:
350000 equipment
Summary:
Tech tip: some customers may experience difficulty programming homelink.
Bulletin:
T-TT-0360-15
Component:
350000 equipment
Summary:
Tt: customers may experience connectivity issues when the following conditions are met: the customer's iphone is operating on ios9 firmware. the customer's iphone is connected to the vehicle via bluetooth. the customer may complain of the f
Bulletin:
T-TT-0362-15
Component:
060000 engine (pws)
Summary:
Tt: the vehicle may be difficult to start or have an abnormally low or rough idle after the battery has been disconnected or power to the engine ecm has been interrupted.
Bulletin:
F10_REMEDY UPDAT
Component:
198000 tires:temporary/emergency spare tire
Summary:
Rl: toyota is providing enhanced instructions for the use and reinstallation of the spare tire.
Bulletin:
F10_DEALER LETTE
Component:
198000 tires:temporary/emergency spare tire
Summary:
Dl: toyota is providing enhanced instructions for the use and reinstallation of the spare tire.
Bulletin:
F10_PRODUCT UPDA
Component:
198000 tires:temporary/emergency spare tire
Summary:
Ec: toyota is providing enhanced instructions for the use and reinstallation of the spare tire.
Bulletin:
ZTQ_WARRANTY POL
Component:
060000 engine (pws)
Summary:
Warranty policy bulletin (pol11-05): toyota has received reports of customer concerns regarding the illumination of the check engine light (malfunction indicator light) due to moisture/water in the air injection pumps and/or air switching
Bulletin:
T-TT-0268-13 REV
Component:
350000 equipment
Summary:
"tt: some customers may encounter bluetooth connectivity concerns such as: ' difficulty pairing the phone. ' intermittent bluetooth failure to connect when first turning on the vehicle. ' various bluetooth audio functions are no lo
Bulletin:
T-SB-0006-11 Rev
Component:
100000 power train
Summary:
Tsb: world standard (ws) automatic transmission fluid (atf) was introduced to reduce maintenance costs and increase the mileage between scheduled maintenance checks. here are some important tips when working with atf-ws in toyota vehicles r
Bulletin:
T-SB-0014-11 Rev
Component:
103000 power train:automatic transmission
Summary:
Tsb: the purpose of this service bulletin is to provide information regarding the installation of the correct torque converter bolts during automatic transmission/transaxle assembly replacement. incorrect torque converter bolts or missing w
Bulletin:
T-SB-0049-11 Rev
Component:
100000 power train
Summary:
Tsb: the purpose of this bulletin is to provide information regarding transmission and/or park neutral position switch installation. if the manual shift lever is rotated prior to installing the park neutral position switch, the detent sprin
Bulletin:
T-TT-0307-14
Component:
118000 electrical system: software
Summary:
Tech tip: customer complains of carious bluetooth connectivity concerns after upgrading to ios 8.0 and later. conditions typically experienced include inability to pair the iphone to the system, poor sound quality during phone calls placed
Bulletin:
T-SB-0134-14
Component:
100000 power train
Summary:
Tsb: the purpose of this bulletin is to provide precautions to follow when installing an automatic transmission/transaxle assembly to avoid mil "on" shifting issues and/or transmission damage. use the information in this bulletin when insta
Bulletin:
T-SB-0200-08 Rev
Component:
103000 power train:automatic transmission
Summary:
Tsb: the purpose of this bulletin is to assist in the identification and location of serial numbers on 2006 - 2014 model year automatic transmissions.
Bulletin:
T-SB-0043-14 Rev
Component:
353000 equipment:electrical
Summary:
Tsb: the immobilizer and smart key reset is a feature that allows the registration of new keys when all master keys are lost. once the system is reset, all previously registered keys will be erased. follow the procedures in this bulletin to
Bulletin:
T-SB-0083-13 Rev
Component:
353600 equipment:air conditioner
Summary:
Tsb: the procedure in this bulletin is a general guideline on how to properly diagnose the air conditioning system after a component failure. refer to the applicable repair manual for vehicle specific repair procedures and parts.
Bulletin:
T-SB-0142-13 Rev
Component:
353600 equipment:air conditioner
Summary:
Tsb: some 2004 - 2015 model year toyota vehicles may exhibit odors naturally occurring from the hvac system and/or related environmental factors. although there is no way to eliminate these odors, follow the general procedure in this bullet
Bulletin:
T-SB-0101-11 Rev
Component:
110000 electrical system
Summary:
Tsb: when servicing interior electrical switches and components, please note the precautions in this bulletin to avoid damaging electrical components and switches. many lubricants, cleaners, and automotive chemicals contain silicone or othe
Bulletin:
T-SB-0017-15
Component:
162900 structure:body:roof and pillars
Summary:
Tsb: should removal and replacement of the upper b-pillar trim become necessary, follow the procedure in this bulletin to ensure proper installation of the upper b-pillar trim.
Bulletin:
T-SB-0040-08
Component:
162000 structure:body
Summary:
Tsb: on some vehicles, when rapgard is removed, the paint may have a stained appearance. these stains appear to be under the clear coat (repainting this area is not necessary). the stain patterns are usually under wrinkles in the rapgard. t
Bulletin:
TT-0307-14 Rev2
Component:
118000 electrical system: software
Summary:
Tt: some customers may encounter various bluetooth connectivity concerns after upgrading to ios 8.0 and later. conditions typically experienced include inability to pair the iphone to the system, poor sound quality during phone calls placed
Bulletin:
T-TT-0268-13 Rev
Component:
118000 electrical system: software
Summary:
Tt: some customers may encounter bluetooth® connectivity concerns such as: * difficulty to pair the phone. * intermittent bluetooth® failure to connect to the vehicle when first turning on the vehicle. * various bluetooth® audio function
Bulletin:
T-TT-307-14 Rev1
Component:
118000 electrical system: software
Summary:
Tt: customers complain of various bluetooth connectivity concerns after upgrading to ios 8.0 and later. conditions typically experienced include inability to pair the iphone to the system, poor sound quality during phone calls placed throug
Bulletin:
T-TT-307-14 Rev1
Component:
353000 equipment:electrical
Summary:
Tt: customers complain of various bluetooth connectivity concerns after upgrading to ios 8.0 and later. conditions typically experienced include inability to pair the iphone to the system, poor sound quality during phone calls placed throug
Bulletin:
T-SB-0040-08
Component:
162000 structure:body
Summary:
Tsb: on some vehicles, when rapgard is removed, the paint may have a stained appearance. these stains appear to be under the clear coat (repainting this area is not necessary). the stain patterns are usually under wrinkles in the rapgard. t
Bulletin:
TT-0307-14 Rev2
Component:
353000 equipment:electrical
Summary:
Tt: some customers may encounter various bluetooth connectivity concerns after upgrading to ios 8.0 and later. conditions typically experienced include inability to pair the iphone to the system, poor sound quality during phone calls placed
Bulletin:
T-TT-0268-13 Rev
Component:
353000 equipment:electrical
Summary:
Tt: some customers may encounter bluetooth® connectivity concerns such as: * difficulty to pair the phone. * intermittent bluetooth® failure to connect to the vehicle when first turning on the vehicle. * various bluetooth® audio function
Bulletin:
T-SB-0142-13 Rev
Component:
353600 equipment:air conditioner
Summary:
Tsb: some 2004 - 2015 model year toyota vehicles may exhibit odors naturally occurring from the hvac system and/or related environmental factors. although there is no way to eliminate these odors, follow the general procedure in this bullet
Bulletin:
T-SB-0101-11 Rev
Component:
110000 electrical system
Summary:
Tsb: when servicing interior electrical switches and components, please note the precautions in this bulletin to avoid damaging electrical components and switches. many lubricants, cleaners, and automotive chemicals contain silicone or othe
Bulletin:
T-SB-0017-15
Component:
162900 structure:body:roof and pillars
Summary:
Tsb: should removal and replacement of the upper b-pillar trim become necessary, follow the procedure in this bulletin to ensure proper installation of the upper b-pillar trim.
Bulletin:
T-SB-0043-14 Rev
Component:
353000 equipment:electrical
Summary:
Tsb: the immobilizer and smart key reset is a feature that allows the registration of new keys when all master keys are lost. once the system is reset, all previously registered keys will be erased. follow the procedures in this bulletin to
Bulletin:
T-SB-0083-13 Rev
Component:
353600 equipment:air conditioner
Summary:
Tsb: the procedure in this bulletin is a general guideline on how to properly diagnose the air conditioning system after a component failure. refer to the applicable repair manual for vehicle specific repair procedures and parts.
Bulletin:
T-TT-0414-16
Component:
353000 equipment:electrical
Summary:
Tt: some customers may encounter bluetooth® connectivity concerns such as: *difficulty to pair the phone. *intermittent bluetooth® failure to connect to the vehicle when first turning on the vehicle. *various bluetooth® audio functions a
Bulletin:
H0F_Massachusett
Component:
356000 equipment adaptive
Summary:
Dealer letter: toyota has received a letter dated september 5, 2017 from the massachusetts department of environmental protection (madep), confirming that the h0f campaign is exempt from air permit requirements as long as toyota dealers com
Bulletin:
H0F_Dealer Lette
Component:
160000 structure
Summary:
Dealer letter: september 7, 2017 tacoma uio (units in operation) has been updated. toyota will initiate a limited service campaign (lsc h0f) to apply corrosion resistant compound to key areas of the vehicle?s frame for the following vehicle
Bulletin:
H0F_ West Virgin
Component:
355200 equipment:other:owners/service/other manual
Summary:
Dealer letter: toyota has received a letter dated september 8, 2017 from the west virginia department of environmental protection (wvdaq), confirming that the h0f campaign is exempt from air permit requirements as long as toyota dealers com
Bulletin:
H0F_Dealer Lette
Component:
160000 structure
Summary:
Dealer letter: october 12, 2017 sequoia (zh8 and zh9) frame replacement and crc application now available. toyota will initiate a limited service campaign (lsc h0f) to apply corrosion resistant compound to key areas of the vehicle?s frame f
Bulletin:
ZH7_Toyota POL17
Component:
161100 structure: frame and members:underbody shields
Summary:
Warranty policy bulletin: toyota has received reports of customer concerns in which the vehicles operated in specific cold climate areas (cold climate states) with high road salt usage may exhibit more-than-normal corrosion with the vehicle
Bulletin:
ZH7_Region Email
Component:
160000 structure
Summary:
Region email: ? 2007-2008 (zh7) tundra frame replacement and crc application is now available. on may 21, 2017, a settlement of claims in a class action lawsuit involving 2005 ? 2010 toyota tacoma, 2007-2008 tundra, and 2005-2008 sequoia ve
Bulletin:
ZH7_Dealer Email
Component:
160000 structure
Summary:
Dealer email: ? 2007-2008 (zh7) tundra frame replacement and crc application is now available. on may 21, 2017, a settlement of claims in a class action lawsuit involving 2005 ? 2010 toyota tacoma, 2007-2008 tundra, and 2005-2008 sequoia ve
Bulletin:
ZH7_Region Lette
Component:
160000 structure
Summary:
Region letter: october 19,2017 tundra frame replacement (zh7) and crc application is now available. ? added additional op codes for tundra to cover dealer costs of maintaining vehicles while waiting for frames, if applicable. ? added op cod
Bulletin:
ZH7_Dealer Lette
Component:
160000 structure
Summary:
Dealer letter: october 19, 2017 tundra frame replacement and crc application is now available. ? additional rental op codes have been provided. in our continuing efforts to ensure the best in customer satisfaction, toyota is announcing a wa
Bulletin:
H0F_Dealer Lette
Component:
160000 structure
Summary:
Dealer letter: october 19, 2018 tundra (zh7) frame replacement and crc application is now available. toyota will initiate a limited service campaign (lsc h0f) to apply corrosion resistant compound to key areas of the vehicle?s frame for the
Bulletin:
T-SB-0304-17
Component:
162300 structure:body:door
Summary:
Tsb: vehicle replacement certification labels (the vinyl label installed on the driver door or door post) and vin plates (the metal plate riveted to dashboard) may be available from toyota, provided the request meets one of the criteria lis
Bulletin:
T-SB-0134-16_Rev
Component:
355200 equipment:other:owners/service/other manual
Summary:
Tsb: revision notice october 30, 2017 rev1: * applicability has been updated to include 2018 model year vehicles. supersession notice the information contained in this bulletin supersedes sb no. t-sb-0012-13. flash reprogramming allows the
Bulletin:
H0F_Tundra_Techn
Component:
355200 equipment:other:owners/service/other manual
Summary:
Ti: technical instructions for limited service campaign, h0f, certain 2007-2008 model year tundra corrosion-resistant compound application.
Bulletin:
ZH7_Tundra Frame
Component:
160000 structure
Summary:
Technical instructions: warranty enhancement program zh7. certain 2007-2008 model year tundra. frame replacement. update 12.21.17. - updated frame serial number tracker information.
Bulletin:
ZH7_TI_01.25.18
Component:
160000 structure
Summary:
Technical instructions: technical instructions for warranty enhancement program zh7. certain 2007-2008 model year tundra. frame replacement. update 1.25.18 - added additional frame serial number tracker information.
Bulletin:
T-SB-0187-12_Rev
Component:
190000 tires
Summary:
Tsb: revision notice february 12, 2018 rev2: ? applicability has been updated to include 2015 ? 2018 model year vehicles. january 23, 2014 rev1: ? applicability has been updated to include 2013 ? 2014 model year vehicles. any previous print
Bulletin:
T-SB-0304-17_Rev
Component:
350000 equipment
Summary:
Tsb: supersession notice the information contained in this bulletin supersedes service bulletin nos. pg021-88, pg015-89, pg0015-90, pg002-91, pg002-93, pg005-97, pg007-01, pg007-07, and t-sb-0144-08. service bulletin nos. pg021-88, pg015-89
Bulletin:
T-SB-0187-12_Rev
Component:
190000 tires
Summary:
Tsb: revision notice february 12, 2018 rev2: ? applicability has been updated to include 2015 ? 2018 model year vehicles. january 23, 2014 rev1: ? applicability has been updated to include 2013 ? 2014 model year vehicles. any previous print
Bulletin:
T-SB-0202-17
Component:
171100 latches/locks/linkages:doors:latch
Summary:
Tsb: some 2007 ? 2015 tundra and 2008 ? 2015 model year sequoia vehicles may exhibit an abnormal feeling, dragging or sticking when using the outside door handle. use the following procedure to address this condition.
Bulletin:
T-TT-0268-13
Component:
350000 equipment
Summary:
Customer complains of bluetooth connectivity concerns such as: difficulty to pair phone, intermittent bluetooth failure to connect to the vehicle when first turning on the vehicle. these concerns can be caused by changes made on the custom
Bulletin:
T-SB-0187-12 Rev
Component:
190000 tires
Summary:
Toyota vehicles are equipped with either conventional or run-flat tires. sometimes punctures may occur as a result of contact with road debris or other hazards. if a puncture occurs, it may be possible to repair the tire and return it to se
Bulletin:
T-TT-0213-13
Component:
140000 air bags
Summary:
Toyota vehicles are equipped with supplemental restraint systems (srs), including various airbags and in some models, seat belt pre-tensioners, to help reduce the risk of injury in a collision. if a customer expresses any concerns that the
Bulletin:
T-SB-0141-13
Component:
050000 parking brake
Summary:
A new special service tool (sst 09709-00002) has been introduced to aid in the inspection procedure for certain vehicles equipped with a floor pedal-type parking brake system. this bulletin references the correct method for installing the b
Bulletin:
T-SB-0142-13
Component:
353600 equipment:air conditioner
Summary:
Some 2004 ? 2014 model year toyota vehicles may exhibit odors naturally occurring from the hvac system and/or related environmental factors. although there is no way to eliminate these odors, follow the general procedure in this bulletin to
Bulletin:
T-SB-0185-13
Component:
130000 visibility
Summary:
The following procedures are recommended during routine maintenance or in the event of a customer concern for wiper performance.
Bulletin:
TS-BO030-01 Obso
Component:
130000 visibility/wiper (pws)
Summary:
This bulletin is now obsolete. please see t-sb-0185-13.
Bulletin:
T-TT-0124-11
Component:
190000 tires
Summary:
Please refer to the following recommendations for the best practices for vehicle tire rotations.
Bulletin:
T-SB-0122-11 Rev
Component:
140000 air bags
Summary:
Beginning in 1998, toyota introduced side airbags as optional equipment. toyota does not recommend replacement of original seat covers with non-toyota leather or other seat cover materials on vehicles due to the following: seat covers not
Bulletin:
T-SB-0071-11 Rev
Component:
100000 power train
Summary:
The purpose of this service bulletin is to provide precautions to follow when installing an automatic transmission/transaxle assembly to avoid mil ?on,? shifting issues, and/or transmission damage. use the information in this bulletin when
Bulletin:
T-TT-0268-13
Component:
110000 electrical system
Summary:
These concerns can be caused by changes made on the customer?s phone. make sure to inquire with the customer if the connectivity concerns occurred after receiving an operating system update on their phone or they have restored their phone d
Bulletin:
T-TT-0269-13
Component:
132000 visibility:glass, side/rear
Summary:
The appearance of spots in tempered glass (when viewed at certain angles) is the result of the heat treating and quick quenching process during manufacturing.
Bulletin:
T-TT-0051-10 Rev
Component:
353600 equipment:air conditioner
Summary:
If a customer states there is an unpleasant odor in the vehicle from the hvac system, there are various factors that may be involved.
Bulletin:
T-SB-0141-10 Rev
Component:
162320 structure:body:door/window:emergency exit
Summary:
If a creak, tick, or rattle noise is heard at the top or bottom of the windshield, or at the top of the rear glass, the source of the noise may be the two stoppers bonded to the top of the windshield/rear glass, or the windshield retainers
Bulletin:
T-SB-0054-13
Component:
350000 equipment
Summary:
California (ca), federal (fed), and 50 state certified emission control underhood labels (emission labels) may be obtained through your dealership?s parts department utilizing standard replacement parts ordering procedures. follow the guide
Bulletin:
T-PG006-00 Obsol
Component:
355100 equipment:other:labels
Summary:
This bulletin is now obsolete. please see t-sb-0054-13.
Bulletin:
ZH6, ZH7, ZH8, Z
Component:
160000 structure
Summary:
Region letter email: on may 21, 2017, a settlement of claims in a class action lawsuit involving 2005 ? 2010 toyota tacoma, 2007-2008 tundra, and 2005-2008 sequoia vehicles regarding frame corrosion was approved. this finally approved cla
Bulletin:
ZH6, ZH7, ZH8, Z
Component:
160000 structure
Summary:
Dealer packet email: on may 21, 2017, a settlement of claims in a class action lawsuit involving 2005 ? 2010 toyota tacoma, 2007-2008 tundra, and 2005-2008 sequoia vehicles regarding frame corrosion was approved. this finally approved cla
Bulletin:
ZH7_Dealer Packa
Component:
160000 structure
Summary:
Dealer package: on may 21, 2017, a settlement of claims in a class action lawsuit involving 2005 ? 2010 toyota tacoma vehicles regarding frame corrosion was approved. this finally approved class action settlement includes inspection of the
Bulletin:
ZH7_Toyota POL17
Component:
161000 structure:frame and members
Summary:
Warranty policy bulletin: toyota has received reports of customer concerns in which the vehicles operated in specific cold climate areas (cold climate states) with high road salt usage may exhibit more-than-normal corrosion with the vehicle
Bulletin:
TI_Frame Inspect
Component:
355200 equipment:other:owners/service/other manual
Summary:
Technical instructions for warranty extension program zh6, zh7, zh8, and zh9.
Bulletin:
T-SB-0218-17_Rev
Component:
140000 air bags
Summary:
Tsb: revision notice july 20, 2017 rev1: applicability has been updated to exclude 2007 ? 2017 model year avanza vehicles. some hazardous material treatment and handling regulations at the state and local level define the pre-disposal deplo
Bulletin:
H0F_CRC_Spray De
Component:
355200 equipment:other:owners/service/other manual
Summary:
Crc spray application preparation. frame corrosion resistant compound (crc) application. please reference the included crc readiness checklist and faq (frequently asked question). these documents should be used to prepare your dealership fo
Bulletin:
H0F_PA Dealer Le
Component:
355200 equipment:other:owners/service/other manual
Summary:
Dealer letter: this communication only applies to dealerships located in pennsylvania. as discussed in our august 28, 2017 dealer daily message, dealers in pennsylvania were required to wait to commence crc application for the h0f campaign
Bulletin:
H0F_Dealer Lette
Component:
160000 structure
Summary:
Dealer letter: the attached dealer letter has been updated. september 29, 2017 rental invoice requirement has been added. ? estimated launch timing has been updated for tundra and sequoia models. september 7, 2017 tacoma uio (units in opera
Bulletin:
ZH7_Dealer Lette
Component:
161000 structure:frame and members
Summary:
Dealer letter: the attached dealer letter has been updated. september 29, 2017 rental invoice requirement has been added. ? estimated launch timing has been updated for tundra and sequoia models.
Bulletin:
T-TT-0086-11
Component:
060000 engine (pws)
Summary:
Techtip: condition - the vehicle may be difficult to start or have an abnormally low or rough idle after the battery has been disconnected or power to the engine ecm has been interrupted.
Bulletin:
ZH7_Toyota POL17
Component:
160000 structure
Summary:
Warranty policy bulletin: toyota has received reports of customer concerns in which the vehicles operated in specific cold climate areas (cold climate states) with high road salt usage may exhibit more-than-normal corrosion with the vehicle
Bulletin:
ZH3_Toyota POL17
Component:
171100 latches/locks/linkages:doors:latch
Summary:
Warranty policy bulletin: toyota has received a number of reports regarding the outside door handles on certain 2008-2015 model year sequoia vehicles and on certain 2007-2015 model year tundra vehicles. in these reports, customers have indi
Bulletin:
T-SB-0202-17_Rev
Component:
171100 latches/locks/linkages:doors:latch
Summary:
Tsb: revision notice october 6, 2017 rev1: ? the parts information and repair procedure sections have been updated. some 2007 ? 2015 model year tundra and 2008 ? 2015 model year sequoia vehicles may exhibit an abnormal feeling, dragging, or
Bulletin:
ZH8 and ZH9_Regi
Component:
160000 structure
Summary:
Region email: ? 2005-2007 (zh8) sequoia frame replacement and crc application is now available. ? 2008 (zh9) sequoia frame replacement and crc application is now available. on may 21, 2017, a settlement of claims in a class action lawsuit i
Bulletin:
ZH8 and ZH9_Deal
Component:
160000 structure
Summary:
Dealer email: ? 2005-2007 (zh8) sequoia frame replacement and crc application is now available. ? 2008 (zh9) sequoia frame replacement and crc application is now available. on may 21, 2017, a settlement of claims in a class action lawsuit i
Bulletin:
ZH8_Region Lette
Component:
160000 structure
Summary:
Region letter: october 12,2017 sequoia frame replacement (zh8 and zh9) is now available. ? added additional op codes for sequoia to cover dealer costs of maintaining vehicles while waiting for frames, if applicable. specific information for
Bulletin:
ZH7_Tundra Frame
Component:
160000 structure
Summary:
Ti: technical instructions for warranty enhancement program zh7 certain model year tundra frame replacement.
Bulletin:
ZH7_Toyota POL17
Component:
160000 structure
Summary:
Warranty policy bulletin: toyota has received reports of customer concerns in which the vehicles operated in specific cold climate areas (cold climate states) with high road salt usage may exhibit more-than-normal corrosion with the vehicle
Bulletin:
ZH7_Tundra Frame
Component:
160000 structure
Summary:
Ti: technical instructions for warranty enhancement program zh7 certain model year tundra frame replacement.
Bulletin:
T-SB-0043-14
Component:
353100 equipment:electrical:anti-theft devices
Summary:
Tsb: the immobilizer and smart key reset is a feature that allows the registration of new keys when all master keys are lost. once the system is reset, all previously registered keys will be erased.
Bulletin:
T-SB-0043-14 Rev
Component:
353100 equipment:electrical:anti-theft devices
Summary:
Tsb: the immobilizer and smart key reset is a feature that allows the registration of new keys when all master keys are lost. once the system is reset, all previously registered keys will be erased.
Bulletin:
BST_Renotificati
Component:
355200 equipment:other:owners/service/other manual
Summary:
Region letter: toyota will be sending limited service campaign notices to remind owners whose vehicles have not yet had smart stop technology installed on their vehicle under lsc bst. initial notification informing customers of the availabi
Bulletin:
BST_Renotificati
Component:
355200 equipment:other:owners/service/other manual
Summary:
Dealer letter: toyota will be sending limited service campaign notices to remind owners whose vehicles have not yet had smart stop technology installed on their vehicle under lsc bst. initial notification informing customers of the availabi
Bulletin:
T-SB-0012-13 Rev
Component:
118000 electrical system: software
Summary:
Tsb: flash reprogramming allows the ecu software to be updated without replacing the ecu. flash calibration updates for specific vehicle models/ecus are released as field-fix procedures described in individual service bulletins. this bullet
Bulletin:
T-TT-0010-10 Rev
Component:
060000 engine (pws)
Summary:
Tech tip: low battery voltage can contribute to a mil "on" condition for p0335 (crankshaft position
Bulletin:
T-SB-0161-16
Component:
162300 structure:body:door
Summary:
Tsb: some 2008 ? 2016 sequoia and 2007 ? 2017 model year tundra vehicles may exhibit a loud popping noise when operating the front doors. noise is due to a fracture/crack in the plastic over mold of the door check arm by the pivot area. fo
Bulletin:
T-SB-0142-13 Rev
Component:
353600 equipment:air conditioner
Summary:
Tsb: revision notice november 10, 2016 rev2: ? applicability has been updated to include 2016 ? 2017 model year toyota vehicles. ? parts information section has been updated. some 2004 ? 2017 model year toyota vehicles may exhibit odor
Bulletin:
T-SB-0012-13 Rev
Component:
118000 electrical system: software
Summary:
Tsb: obsolete notice: september 14, 2016: this bulletin is now obsolete. please see t-sb-0134-16.
Bulletin:
ZH7_Dealer Packe
Component:
160000 structure
Summary:
Dealer letter: march 2, 2018. rental sublet period added for use during repair. ? primary coverage expiration date changed. ? ancillary parts coverage section added. warranty enhancement program zh7 certain 2007 ? 2008 model year tundra
Bulletin:
ZH7_Toyota POL17
Component:
160000 structure
Summary:
Warranty policy bulletin: toyota has received reports of customer concerns in which the vehicles operated in specific cold climate areas (cold climate states) with high road salt usage may exhibit more-than-normal corrosion with the vehicle
Bulletin:
T-SB-0144-08_Obs
Component:
350000 equipment
Summary:
Tsb: obsolete notice november 21, 2017: this bulletin is now obsolete. please see t-sb-0304-17.
Bulletin:
T-SB-0229-12_Rev
Component:
110000 electrical system
Summary:
Tsb: revision notice november 22, 2017 rev1: ? applicability has been updated to include 2014 ? 2018 model year vehicles. any previous printed versions of this bulletin should be discarded. in the event that a toyota vehicle becomes submerg
Bulletin:
LSC BST Phase 3
Component:
030000 service brakes, hydraulic
Summary:
As part of the settlement described above, toyota will install smart stop technology on the above listed model and model year vehicles. this feature will cut engine power in case of simultaneous application of both the accelerator and brake
Bulletin:
LSC BST Phase 1.
Component:
180000 vehicle speed control
Summary:
On july 24, 2013, the settlement of claims for economic loss arising from allegations of unintended acceleration was approved. as part of the settlement toyota will be launching the third phase of a limited service campaign to install smar
Bulletin:
LSC BST Phase 3
Component:
030000 service brakes, hydraulic
Summary:
It has been brought to our attention that claim processing for lsc bst phase 3 (2003-2009 4runner and 2007-2010 tundra vehicles) we be delayed until monday april 7, 2014.
Bulletin:
LSC BST Phase 3
Component:
100000 power train
Summary:
As part of the settlement described above, toyota will install smart stop technology on the above listed model and model year vehicles. this feature will cut engine power in case of simultaneous application of both the accelerator and brake
Bulletin:
LSC BST Phase 1.
Component:
355200 equipment:other:owners/service/other manual
Summary:
On july 24, 2013, the settlement of claims for economic loss arising from allegations of unintended acceleration was approved. as part of the settlement toyota will be launching the third phase of a limited service campaign to install smar
Bulletin:
LSC BST Phase 3
Component:
355200 equipment:other:owners/service/other manual
Summary:
It has been brought to our attention that claim processing for lsc bst phase 3 (2003-2009 4runner and 2007-2010 tundra vehicles) we be delayed until monday april 7, 2014.
Bulletin:
T-SB-0391-08 Rev
Component:
100000 power train
Summary:
This bulletin contains general vehicle pulling diagnosis and repair procedures along with specific information to help correct pulling complaints.
Bulletin:
T-TT-0226-13
Component:
110000 electrical system
Summary:
The customer is having difficulty changing the multi-display screen from day mode. if the multi-display screen is set to day mode when the headlights are on, the setting we be memorized when the engine is turned off.
Bulletin:
SST Requirements
Component:
355200 equipment:other:owners/service/other manual
Summary:
Ssts are key elements to provide your customers with swift and accurate repairs resulting in superior customer satisfaction.
Bulletin:
T-SB-0064-10 Rev
Component:
118000 electrical system: software
Summary:
Flash reprogramming allows the ecu software to be updated without replacing the ecu. flash calibration updates for specific vehicle models/ecus are released as field-fix procedures described in individual service bulletins. this bulletin de
Bulletin:
T-SB-0012-13
Component:
118000 electrical system: software
Summary:
Flash reprogramming allows the ecu software to be updated without replacing the ecu. flash calibration updates for specific vehicle models/ecus are released as field-fix procedures described in individual service bulletins. this bulletin de
Bulletin:
T-SB-0013-13
Component:
050000 parking brake
Summary:
Some 2007 ? 2012 model year tundra vehicles may exhibit a rubbing or grinding noise from the rear when making left or right turns. new parking brake plate sub-assemblies have been developed to address this condition.
Bulletin:
T-SB-0064-10 Rev
Component:
355200 equipment:other:owners/service/other manual
Summary:
This bulletin is now obsolete. please see t-sb-0012-13.
Bulletin:
T-TT-0213-13
Component:
140000 air bags
Summary:
Toyota vehicles are equipped with srs, including various airbags and in some models, seat belt pre-tensioners, to help reduce the risk of injury in a collision. if a customer expresses any concerns that the srs airbags or pretensioner devi
Bulletin:
T-SB-0151-10 Rev
Component:
100000 power train
Summary:
Some 2007 ? 2010 model year tundra vehicles may exhibit a howling or growling noise from the rear of the vehicle that increases with vehicle speed. changes have been made to the rear axle bearing to address this condition. follow the proced
Bulletin:
T-SB-0187-12
Component:
162000 structure:body
Summary:
Toyota vehicles are equipped with either conventional or run-flat tires. sometimes punctures may occur as a result of contact with road debris or other hazards. if a puncture occurs, it may be possible to repair the tire and return it to se
Bulletin:
TSB-0012-13 Rev2
Component:
060000 engine (pws)
Summary:
Tsb: flash reprogramming allows the ecu software to be updated without replacing the ecu. flash calibration updates for specific vehicle models/ecus are released as field-fix procedures described in individual service bulletins. this bull
Bulletin:
T-TT-0381-16
Component:
118000 electrical system: software
Summary:
Tech tip: some customers may experience difficulty programming homelink.
Bulletin:
T-TT-0360-15
Component:
110000 electrical system
Summary:
Tt: customers may experience connectivity issues when the following conditions are met: the customer's iphone is operating on ios9 firmware. the customer's iphone is connected to the vehicle via bluetooth. the customer may complain of the f
Bulletin:
T-TT-0362-15
Component:
060000 engine (pws)
Summary:
Tt: the vehicle may be difficult to start or have an abnormally low or rough idle after the battery has been disconnected or power to the engine ecm has been interrupted.
Bulletin:
F10_Remedy Updat
Component:
198000 tires:temporary/emergency spare tire
Summary:
Rl: toyota is providing enhanced instructions for the use and reinstallation of the spare tire.
Bulletin:
F10_Dealer Lette
Component:
198000 tires:temporary/emergency spare tire
Summary:
Dl: toyota is providing enhanced instructions for the use and reinstallation of the spare tire.
Bulletin:
F10_Product Upda
Component:
198000 tires:temporary/emergency spare tire
Summary:
Ec: toyota is providing enhanced instructions for the use and reinstallation of the spare tire.
Bulletin:
TTT-0268-13 Rev3
Component:
110000 electrical system
Summary:
Tt: some customers may encounter bluetooth connectivity concerns such as: ? difficulty pairing the phone. ? intermittent bluetooth failure to connect when first turning on the vehicle. ? various bluetooth audio functions are no lon
Bulletin:
T-TT-0086-11
Component:
100000 power train
Summary:
Techtip: condition - the vehicle may be difficult to start or have an abnormally low or rough idle after the battery has been disconnected or power to the engine ecm has been interrupted.
Bulletin:
ZTQ_Warranty Pol
Component:
060000 engine (pws)
Summary:
Warranty policy bulletin (pol11-05): toyota has received reports of customer concerns regarding the illumination of the check engine light (malfunction indicator light) due to moisture/water in the air injection pumps and/or air switching
Bulletin:
Tundra CRC Techn
Component:
356000 equipment adaptive
Summary:
Technical instructions: limited service campaign h0f. certain 2007- 2008 model year tundra. corrosion-resistant compound application.
Bulletin:
H0F Dealer Lette
Component:
355200 equipment:other:owners/service/other manual
Summary:
Dealer letter: december 14, 2017. ? technician certification requirements updated. ? instructions added for crc spray gun/parts replacement requests.
Bulletin:
T-SB-0161-16_Rev
Component:
162300 structure:body:door
Summary:
Tsb: revision notice may 18, 2018 rev1: * applicability has been updated to include 2018 model year tundra and 2017 - 2018 model year sequoia vehicles. * the entire bulletin has been updated. any previous printed versions of this bulletin s
Bulletin:
ZH6, ZH7, ZH8, Z
Component:
160000 structure
Summary:
Dealer daily message: frame programs. extension of warranty coverage for frame corrosion/frame replacement. frame ordering/repair/administration updates mis-built. for frames that are suspected to have been mis-built, dealers should: 1. co
Bulletin:
ZH3-Region Email
Component:
350000 equipment
Summary:
Region email: toyota is announcing a warranty enhancement program to extend the warranty coverage for the outside door handles on certain 2008 ? 2015 model year sequoia vehicles and certain 2007 ? 2015 model year tundra vehicles.
Bulletin:
ZH3-Region Lette
Component:
162300 structure:body:door
Summary:
Region letter: toyota has received a number of reports regarding the outside door handles on certain 2008 ? 2015 model year sequoia vehicles and on certain 2007 ? 2015 model year tundra vehicles. in these reports, customers have indicated t
Bulletin:
ZH3-Dealer Email
Component:
162300 structure:body:door
Summary:
Dealer email: toyota is announcing a warranty enhancement program to extend the warranty coverage for the outside door handles on certain 2008 ? 2015 model year sequoia vehicles and certain 2007 ? 2015 model year tundra vehicles.
Bulletin:
ZH3-Dealer Lette
Component:
162300 structure:body:door
Summary:
Dealer letter: toyota has received a number of reports regarding the outside door handles on certain 2008 ? 2015 model year sequoia vehicles and on certain 2007 ? 2015 model year tundra vehicles. in these reports, customers have indicated t
Bulletin:
ZH3-POL17-07-04.
Component:
162300 structure:body:door
Summary:
Warranty policy bulletin pol17-07: toyota has received a number of reports regarding the outside door handles on certain 2008-2015 model year sequoia vehicles and on certain 2007-2015 model year tundra vehicles. in these reports, customers
Bulletin:
ZH3-Dealer Daily
Component:
162300 structure:body:door
Summary:
Dealer daily message: zh3 warranty enhancement program ? certain 2008 - 2015 model year sequoia vehicles and certain 2007 - 2015 model year tundra vehicles extension of warranty coverage for the outside door handles.
Bulletin:
Toyota PRO18-03_
Component:
350000 equipment
Summary:
Mis-built for frames that are suspected to have been mis-built, dealers should: 1. contact the parts technical support group (ptsg) at prasupport@toyota.com with information on the condition and status of repair. a. include the original par
Bulletin:
ZH3_Toyota POL17
Component:
162300 structure:body:door
Summary:
Warranty policy bulletin: toyota has received a number of reports regarding the outside door handles on certain 2008-2015 model year sequoia vehicles and on certain 2007-2015 model year tundra vehicles. in these reports, customers have indi
Bulletin:
T-SB-0057-18
Component:
350000 equipment
Summary:
Tsb: supersession notice the information contained in this bulletin supersedes service bulletin no. t-sb-0043-14. ? applicability has been updated to include 2017 ? 2018 model year toyota vehicles. service bulletin no. t-sb-0043-14 is obso
Bulletin:
T-SB-0304-17_Rev
Component:
350000 equipment
Summary:
Tsb: revision notice july 31, 2018 rev2: ? the supersession notice has been updated. january 11, 2018 rev1: ? the supersession notice has been updated. any previous printed versions of this bulletin should be discarded. supersession notice
Bulletin:
PG004-97-Obsolet
Component:
350000 equipment
Summary:
Technical service bulletin: obsolete notice: july 31, 2018: this bulletin is now obsolete. please see t-sb-0304-17.
Bulletin:
PG006-01-Obsolet
Component:
350000 equipment
Summary:
Technical service bulletin: obsolete notice: july 31, 2018: this bulletin is now obsolete. please see t-sb-0304-17.
Bulletin:
Safety Recall an
Component:
350000 equipment
Summary:
Update on technician certification requirements.
Bulletin:
Frame Campaign W
Component:
160000 structure
Summary:
Dealer daily message: frame warranty claim submission the information below should be referenced to ensure correct warranty claim submissions for frame replacement or spray campaigns (zh6-9 and h0f). key points ? do not perform campaign h0f
Bulletin:
H0F-Dealer Packa
Component:
160000 structure
Summary:
Dealer package: june 25, 2018 added warranty claim submission flowchart. see appendix a. toyota will initiate a limited service campaign (lsc h0f) to apply corrosion resistant compound to key areas of the vehicle?s frame for the following v
Bulletin:
ZH7-Dealer Packa
Component:
160000 structure
Summary:
Dealer package: june 25, 2018 added warranty claim submission flowchart. see appendix a. in our continuing efforts to ensure the best in customer satisfaction, toyota is announcing a warranty enhancement program to extend the warranty cover
Bulletin:
ZH7-Toyota POL17
Component:
160000 structure
Summary:
Warranty policy bulletin: toyota has received reports of customer concerns in which the vehicles operated in specific cold climate areas (cold climate states) with high road salt usage may exhibit more-than-normal corrosion with the vehicle
Bulletin:
Tundra CRC Techn
Component:
160000 structure
Summary:
Technical instructions: limited service campaign h0f certain 2007-2008 model year tundra corrosion-resistant compound application.
Bulletin:
HOF Dealer Lette
Component:
161000 structure:frame and members
Summary:
Dealer letter: december 14, 2017. technician certification requirements updated. instructions added for crc spray gun/parts replacement requests.

Home | Privacy