2008 IC RESB Recalls (8)

Campaign:
06V479000 on 12/20/2006
Component:
Seats
Manufactured:
10/10/2005 - 10/30/2006
Affected:
1,948
Defect:
Certain ic school and commercial buses manufactured between october 11, 2005, and october 31, 2006. these buses have the following safety issues: if the driver's seat is in the highest and most rear position, the back of the seat may lean against a barrier behind the seat, or against the seat back. this will prevent the seat belt from retracting which fails to conform to federal motor vehicle safety standard no. 209, seat belt assemblies. when adjust the seat to a higher position, the driver may pull the seat past the last stop so that the seat sits on the adjusting pin, which allows the seat to teeter on top of the pin. if over-travel occurs, the upper seat pedestal tube could separate from the lower pedestal tube during vehicle operation. if the driver is sitting in the driver's seat and reaches to adjust the seat height, their weight will cause the seat to drop, which could result in their hand being pinched between the seat and the lever. the driver's seat is difficult to adjust to a higher position because of the additional weight of the all belts to seat (abts) design.
Consequence:
This may result in personal injury.
Correction:
Ic will notify owners and repair the seats free of charge. the recall began on february 23, 2007. owners may contact ic at 1-800-448-7825.
Notes:
Ic recall no. 06512.customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.
Campaign:
07V028000 on 02/04/2007
Component:
Other:school bus stop arm assembly
Manufactured:
01/17/2006 - 01/16/2007
Affected:
422
Defect:
Certain 2007 and 2008 my ic school buses manufactured between january 18, 2006, and january 17, 2007. the air supply fitting may separate from the base plate, preventing actuation air from reaching the stop arm and/or crossing arm. this condition will result in non-deployment of the stop arm and/or crossing arm during a school bus stop to pick-up or discharge passengers.
Consequence:
If the stop arm does not deploy, a child or pedestrian may be endangered by passing motorists failing to stop at a safe location. if the crossing arm does not deploy, a child or pedestrian may enter the driver's blind spot in front of the vehicle possibly resulting in property damage, personal injury or death.
Correction:
Ic will notify owners and repair the affected stop arms. the recall began on march 2, 2007. owners can contact ic corporation at 1-800-843-5615 or international at 1-800-448-7825.
Notes:
International recall no. 07502.customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.
Campaign:
07V224000 on 06/03/2007
Component:
Equipment adaptive
Manufactured:
01/19/2006 - 09/27/2006
Affected:
727
Defect:
Certain my 2007 and 2008 international school and commercial buses manufactured between january 20 and september 28, 2006, equipped with ricon wheelchair lifts . the lift inner barrier interlock switch system may not detect the presence of a passenger on the inner barrier and allow the platform to move down more than one inch below floor level while occupied which does not conform to federal motor vehicle safety standard no. 403, platform lift systems for motor vehicles.
Consequence:
The defect involves the interlock switch system in the lift not detecting the presence of a passenger (either wheelchair or standee) on the ricon wheelchair platform lift. in the event this condition occurs during passenger operations it may be possible for the wheelchair to tip backwards onto the platform when the platform was lowered. this could result in injury to the wheelchair's occupant. also, anyone standing on the platform could lose his or her balance and fall, resulting in injury.
Correction:
International is working with ricon to repair the buses free of charge (please see 06e101). the recall began on july 20, 2007. owners can contact ricon at 818-267-3012 or international at 1-800-448-7825.
Notes:
International recall no. 07508.customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.
Campaign:
08V089000 on 02/26/2008
Component:
Engine and engine cooling
Manufactured:
07/31/2006 - 06/11/2007
Affected:
34,993
Defect:
International is recalling 34,993 my 2006-2008 school and transit buses and heavy duty trucks/tractors manufactured between june 1, 2006 and june 28, 2007, equipped with international dt466 or dt570 engines. the base plate of the engine oil cooler may crack allowing pressurized oil to leak into the engine compartment.
Consequence:
This condition may cause either engine shut down without warning, or in extreme cases, possible engine fire which can lead to property damage, personal injury, or death.
Correction:
International will notify owners and repair the vehicles free of charge. the recall began on november 21, 2008. owners may contact international at 800-448-7825.
Notes:
International recall no. 08502.customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.
Campaign:
08V438000 on 08/26/2008
Component:
Equipment adaptive
Manufactured:
01/03/2006 - 11/14/2007
Affected:
1,607
Defect:
Navistar is recalling 1,607 my 2007 through 2009 ic besb, cesb, fesb, and resb school buses manufactured from january 4, 2006 through november 15, 2007, equipped with ricon s or k series wheelchair lifts. the anti-stow interlock may not detect the presence of a wheelchair or mobility aid user. the pressure sensing switch that detects the presence of weight on the platform was not adjusted to the necessary sensitivity level. the lift could stow even though someone or something is still on the lift which fails to comply with federal motor vehicle safety standard no. 403, "platform lift systems for motor vehicles."
Consequence:
A lift occupant can be injured should the lift begin to stow unintentionally.
Correction:
Navistar is working with ricon to correct the wheelchair lifts (please see 07e097). owners may contact ricon at 1-800-322-2884 or navistar at 1-260-461-1890.
Notes:
Navistar's recall no. 08509.customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.
Campaign:
08V436000 on 08/26/2008
Component:
Equipment adaptive
Manufactured:
05/04/2005 - 11/14/2007
Affected:
1,889
Defect:
Navistar is recalling 1,889 ic school buses manufactured from may 4, 2005 through november 15, 2007, equipped with ricon platform style wheelchair lifts. these lifts fail to comply with the requirements of federal motor vehicle safety standard no. 403, "platform lift systems for motor vehicles." the threshold warning system may not detect the presence of a wheelchair or mobility aid user in a certain spot within the defined threshold area.
Consequence:
The user of the lift could be injured should the lift move unintentionally.
Correction:
Navistar is working with ricon to correct the wheelchair lifts free of charge (please see 07e095). the recall began on october 1, 2008. owners may contact ricon at 1-818-267-3000 or navistar at 1-260-461-1890.
Notes:
Navistar's recall no. 08508.customers may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov.
Campaign:
12V476000 on 09/27/2012
Component:
Engine and engine cooling
Manufactured:
06/16/2004 - 10/14/2009
Affected:
20,902
Defect:
Navistar is recalling certain model year 2006 through 2011 ic school buses, models cesb, resb, and fesb, manufactured from june 17, 2004, through october 15, 2009, equipped with i-6 engines within feature codes 12n (pl, pm, pn, pr, ps, pt, pu, pv, sa, sg, sk, sl, sm, sv, sz, tb, ua, ub, uc, and ud). the high pressure engine oil line may develop a leak or possibly rupture.
Consequence:
A leak or rupture of the high pressure oil line could possibly result in an unexpected engine stall or may result in an engine compartment fire.
Correction:
Navistar will notify owners, and dealers will replace the high pressure oil line free of change. the safety recall began on december 21, 2012. owners may contact navistar at 1-331-332-1590.
Notes:
Navistar's recall campaign number is 12523.owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.
Campaign:
13V320000 on 07/23/2013
Component:
Seats
Manufactured:
10/05/2005 - 04/17/2012
Affected:
662
Defect:
Navistar is recalling certain model year 2006 through 2009, and 2012 ic ce school buses and certain model year 2006 through 2009, and 2011 through 2013 ic re school buses manufactured from october 6, 2005, through april 18, 2012, and equipped with c. e. white inc. brand flip seats.
Consequence:
When a flip seat is installed in front of another passenger seat, it is possible for the occupant of the rearward passenger seat to insert their toes and/or foot into the lower frame area of the flip seat. when a vehicle passenger occupies the flip seat, pushing the seat bottom downward to the horizontal position to sit in the seat, the occupant of the rearward seat could suffer a pinch point injury to their toes and/or foot.
Correction:
Navistar will notify owners, and dealers will install a safety guard to prevent passengers from placing their toes or feet in the opening on the back of the subject flip seats, free of charge. the recall began on november 12, 2013. owners may contact navistar 1-800-448-7825 for more information. navistar's number for this recall is 13511.
Notes:
Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.

2008 IC RESB TSBs (11)

Bulletin:
AFC-G-10913
Component:
161000 structure:frame and members
Summary:
Navistar: to prevent frame or underbody damage there is a service campaign to repair body mounting isolators. *rm
Bulletin:
IK0800475
Component:
110000 electrical system
Summary:
Radio diagnostics and information
Bulletin:
IK1200029
Component:
062100 engine and engine cooling:cooling system:radiator assembly
Summary:
Radiator internal restriction and flush procedure
Bulletin:
IK1201259
Component:
060000 engine (pws)
Summary:
Maxxforce 7 fuel dilution diagnostics
Bulletin:
IK2200075
Component:
131000 visibility:windshield
Summary:
Windshield glass discoloration (fogging)
Bulletin:
Rec15V-868
Component:
356000 equipment adaptive
Summary:
Ricon public use,"s" 2000 and 5500 series lift recall
Bulletin:
IK0700096
Component:
110000 electrical system
Summary:
Urea quality sensor (uqs) supplemental diagnostic and service information; only models with scr aftertreatment system and n9, n10, n13, a26 or cummins isb, isl, isx engines built from january 2016
Bulletin:
IK0700097
Component:
061200 engine and engine cooling:engine:diesel
Summary:
New ultrasonic def tank sending unit; only models with scr aftertreatment system.
Bulletin:
IK0800546
Component:
060000 engine and engine cooling
Summary:
Hvac fault 2609-19 with 4th gen bcm; only models equipped with 4th generation bcm
Bulletin:
IK0800475
Component:
353400 equipment:electrical:radio/tape deck/cd etc.
Summary:
Radio diagnostics and information
Bulletin:
IK1201299
Component:
060000 engine (pws)
Summary:
Engine oil capacities all electronic international engines 1994 - present. cummins isb, ism & isx

Home | Privacy