2008 IC BUS CE Recalls (14)

Campaign:
08V258000 on 06/08/2008
Component:
Electrical system
Manufactured:
11/20/2000 - 05/20/2008
Affected:
51,588
Defect:
Navistar is recalling 51,588 heavy trucks, commercial buses and school buses manufactured between november 21, 2000 and may 21, 2008, equipped with one or more remote power modules. the potting material that encapsulates the circuit board of the vehicle's remote power module may not sufficiently seal the circuit board from water and contamination intrusion. if the encapsulation is compromised, water and contaminants may cause an internal electrical short, possibly resulting in a fire.
Consequence:
A fire could cause personal injury or death.
Correction:
Navistar will notify owners and repair the vehicles free of charge. the recall began on july 10, 2008. owners may contact navistar at 1-280-461-1890.
Notes:
Navistar recall no. 08505.customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.
Campaign:
08V353000 on 07/29/2008
Component:
Engine and engine cooling
Manufactured:
09/20/2001 - 12/13/2007
Affected:
24,975
Defect:
Navistar is recalling 24,975 my 2003 through 2008 ic be, ce, hc, and re school and commercial buses and 2002 through 2008 international 3200 and 3300 model buses manufactured between september 21, 2001 through december 14, 2007, equipped with international vt365 engines. these vehicles may exhibit engine hard start, no start, or stall conditions due to possibly damaged terminals in the fuse holder connector of the injector drive module (idm) clean battery power circuits. the terminals may have been damaged during electrical continuity testing in the manufacturing process.
Consequence:
These conditions could result in a vehicle crash, possibly resulting in personal injury.
Correction:
Navistar will notify owners and replace the idm fuse holder free of charge. the recall began on october 3, 2008. owners can contact navistar toll-free at 1-800-448-7825.
Notes:
Navistar's recall no. 08506.customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.
Campaign:
09V052000 on 02/09/2009
Component:
Equipment:electrical
Manufactured:
02/01/2000 - 06/01/2008
Affected:
61,316
Defect:
Navistar is recalling 61,316 my 2001 through 2009 ic be, ce, and fe model commercial and school buses manufactured between february 2, 2000 and june 2, 2008, equipped with an entrance door stepwell heater feature code 0048pms or 0548001 and/or a rear wall mounted heater feature code 0048tar or 0048psx. the affected heater units may fail in low speed operation causing elevated temperatures.
Consequence:
Elevated temperatures can result in a fire, possibly resulting in property damage, personal injury, or death.
Correction:
An interim letter was mailed on february 20, 2009, to communicate the defect and recommend action to mitigate the risk until the final remedy and customer notification could be provided at a later date. the manufacture filed an amended defect report dated march 27, 2009 advising that a final remedy has been developed and parts are being manufactured. the safety recall began on june 2, 2009. owners may contact navistar toll-free at 1-800-448-7825.
Notes:
Navistar's recall no. 09501.owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to <a href=http://www.safercar.gov>http://www.safercar.gov</a> .
Campaign:
09V052000 on 02/09/2009
Component:
Equipment:electrical
Manufactured:
02/01/2000 - 06/01/2008
Affected:
61,316
Defect:
Navistar is recalling 61,316 my 2001 through 2009 ic be, ce, and fe model commercial and school buses manufactured between february 2, 2000 and june 2, 2008, equipped with an entrance door stepwell heater feature code 0048pms or 0548001 and/or a rear wall mounted heater feature code 0048tar or 0048psx. the affected heater units may fail in low speed operation causing elevated temperatures.
Consequence:
Elevated temperatures can result in a fire, possibly resulting in property damage, personal injury, or death.
Correction:
An interim letter was mailed on february 20, 2009, to communicate the defect and recommend action to mitigate the risk until the final remedy and customer notification could be provided at a later date. the manufacture filed an amended defect report dated march 27, 2009 advising that a final remedy has been developed and parts are being manufactured. the safety recall began on june 2, 2009. owners may contact navistar toll-free at 1-800-448-7825.
Notes:
Navistar's recall no. 09501.owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to <a href=http://www.safercar.gov>http://www.safercar.gov</a> .
Campaign:
10V103000 on 03/15/2010
Component:
Service brakes, hydraulic
Manufactured:
11/18/2003 - 02/08/2010
Affected:
5,016
Defect:
Navistar has notified nhtsa about a defect in certain model year 2010 and 2011 ic ce, be, and fe school buses manufactured from november 19, 2003 through february 9, 2010. the parking brake may release if the brake system electronic control unit software misinterprets input signals generated from cycling the ignition switch more than once at a specific frequency.
Consequence:
Release of the parking brake may cause sudden, unexpected shift in vehicle position possibly resulting in property damage, personal damage, or death.
Correction:
Navistar will notify owners and will repair the buses by reprogramming the vehicle's brake system ecu free of charge. the safety recall began on april 2, 2010. owners may contact navistar at 1-260-461-1890.
Notes:
Navistar's recall campaign number is 10505.owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to <a href=http://www.safercar.gov>http://www.safercar.gov</a> .
Campaign:
10V265000 on 06/14/2010
Component:
Vehicle speed control
Manufactured:
12/03/2001 - 12/13/2009
Affected:
4,131
Defect:
Navistar is recalling certain model year 2006 through 2008 ic be, re, and ce school buses manufactured from december 4, 2001 through december 14, 2009 equipped with international vt365 engines having engine calibration pan2pvr0, pan2pvr1, or pan2pwr. the engine normally responds to a failed open accelerator position sensor circuit fault by returning the engine to low idle speed of 800 rpm and disabling the driver's ability to increase the engine speed. however if the open circuit corrects itself within 30 seconds of initiation, engine speed could suddenly increase to a high idle speed of 1200 rpm.
Consequence:
This increase to high idle speed may occur without warning causing a sudden and unexpected shift in vehicle position possibly resulting in property damage, personal injury, or death.
Correction:
Navistar will notify owners and dealers will repair the vehicles free of charge. the safety recall began on july 1, 2010. owners may contact navistar at 1-800-448-7825..
Notes:
Navistar's recall campaign number is 10512.owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to <a href=http://www.safercar.gov>http://www.safercar.gov</a> .
Campaign:
10V267000 on 06/15/2010
Component:
Vehicle speed control
Manufactured:
12/03/2001 - 12/13/2009
Affected:
2,085
Defect:
Navistar is recalling certain model year 2003 through 2010 international trucks and ic commercial buses manufactured from december 4, 2001 through december 14, 2009 equipped with international vt365 engines having engine calibration pan2pvr0, pan2pvr1, or pan2pwr. the engine normally responds to a failed open accelerator position sensor circuit fault by returning the engine to low idle speed of 800 rpm and disabling the driver's ability to increase the engine speed. however if the open circuit corrects itself within 30 seconds of initiation, engine speed could suddenly increase to a high idle speed of 1200 rpm.
Consequence:
This increase to high idle speed may occur without warning causing a sudden and unexpected shift in vehicle position possibly resulting in property damage, personal injury, or death.
Correction:
Navistar will notify owners and dealers will repair the vehicles free of charge. the safety recall began on july 1, 2010. owners may contact navistar at 1-800-448-7825.
Notes:
Navistar's campaign number is 10512.owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to <a href=http://www.safercar.gov>http://www.safercar.gov</a> .
Campaign:
11V375000 on 07/24/2011
Component:
Structure:body:door
Manufactured:
10/31/2006 - 05/01/2011
Affected:
70
Defect:
Navistar is recalling certain model year 2008 through 2012 ic be, ce, and fe school buses manufactured from november 1, 2006, through may 2, 2011. the reflective tape for the rear exit door may not have been totally completed. accordingly, the buses fail to conform to the requirements of federal motor vehicle safety standard no. 217, "bus emergency exits and window retention and release."
Consequence:
This noncompliance may reduce conspicuity of the rear door, reducing the ability of emergency personnel to identify and gain access to the rear exit during an emergency, possibly increasing the occupant's risk of personal injury or death during an emergency.
Correction:
Navistar will notify owners and dealers will inspect the buses and add reflective tape if necessary. the safety recall began on august 3, 2011. owners may contact navistar at 1-800-448-7825.
Notes:
Navistar's recall campaign number is 11514.owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to <a href=http://www.safercar.gov>http://www.safercar.gov</a> .
Campaign:
11V428000 on 08/17/2011
Component:
Electrical system:alternator/generator/regulator
Manufactured:
06/26/2006 - 03/22/2011
Affected:
73
Defect:
Navistar is recalling certain model year 2007-2012 ic ce and be commercial buses manufactured from june 27, 2006, through march 23, 2011, equipped with a maxxforce 7 engine feature code 12nth, 12ntd, 12nte, 12ntg, 12vyy, or 12627 and alternator feature code 0008ggr, 0008ggm, 0008gwx, or 0008gel. the positive alternator cable may rub on the engine control module mounting bracket, possibly chafing its insulation and causing an electrical short.
Consequence:
An electrical short may cause a vehicle fire possibly resulting in property damage, personal injury, or death.
Correction:
Navistar will notify owners and dealers will inspect and replace, if necessary, the alternator cable. tie straps will be installed to route the alternator cable away from the engine control module mounting bracket. these repairs will be performed free of charge. the safety recall began on september 27, 2011. owners may contact navistar at 1-800-448-7825.
Notes:
Navistar's campaign number is 11518.owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to <a href=http://www.safercar.gov>http://www.safercar.gov</a> .
Campaign:
11V427000 on 08/17/2011
Component:
Electrical system:alternator/generator/regulator
Manufactured:
06/26/2006 - 03/22/2011
Affected:
15,457
Defect:
Navistar is recalling certain model year 2007-2012 ic ce and be school buses manufactured from june 27, 2006, through march 23, 2011, equipped with a maxxforce 7 engine feature code 12nth, 12ntd, 12nte, 12ntg, 12vyy, or 12627 and alternator feature code 0008ggr, 0008ggm, 0008gwx, or 0008gel. the positive alternator cable may rub on the engine control module mounting bracket, possibly chafing its insulation and causing an electrical short.
Consequence:
An electrical short may cause a vehicle fire possibly resulting in property damage, personal injury, or death.
Correction:
Navistar will notify owners, and dealers will inspect and replace, if necessary, the alternator cable and the installation of the tie straps to route the alternator cable away from the engine control module mounting bracket. repairs will be performed free of charge. the safety recall began on september 27, 2011. owners may contact navistar at 1-800-448-7825.
Notes:
Navistar's recall campaign number is 11518.owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to <a href=http://www.safercar.gov>http://www.safercar.gov</a> .
Campaign:
14V692000 on 11/02/2014
Component:
Equipment adaptive
Manufactured:
01/01/2006 - 09/22/2014
Affected:
4,784
Defect:
Navistar, inc. (navistar) is recalling certain model year 2013-2015 ic ae, 2007-2015 ic be, ce, 2007-2011 ic fe, and 2007-2014 ic re school buses equipped with certain model s2005, s2010, s5005, s5010, s5505, and s5510 wheelchair lifts manufactured by ricon corporation after january 1, 2006. the platform side plate of the affected wheelchair lifts may crack.
Consequence:
If the platform side plates crack, the lift platform can separate from the lift and come to rest against the vehicle's lift door. when the doors are opened, the platform may fall out, increasing the risk of injury to the lift operator.
Correction:
Navistar will notify owners to take buses to a ricon dealer or service center who will install supplemental platform support bumpers. any platform that has already started cracking will be replaced, free of charge. the recall began on january 29, 2015. owners may contact navistar customer service at 1-331-332-1590 or ricon customer service at 1-800-322-2884. navistar's number for this recall is 14518.
Notes:
Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.
Campaign:
14V691000 on 11/02/2014
Component:
Equipment adaptive
Manufactured:
01/22/2006 - 05/11/2014
Affected:
68
Defect:
Navistar, inc.(navistar) is recalling certain model year 2007-2015 ic ce transit buses manufactured january 23,2006, to may 12, 2014, 2008, and 2011 ic fe transit buses manufactured october 5, 2006, to september 28, 2009, and 2009-2010, and 2013 ic re transit buses manufactured september 19, 2007, to november 29, 2011, equipped with certain model s2005, s2010, s5005, s5010, s5505, and s5510 wheelchair lifts manufactured by ricon corporation after january 1, 2006. the platform side plate of the affected wheelchair lifts may crack.
Consequence:
If the platform side plates crack, the lift platform can separate from the lift and come to rest against the vehicle's lift door. when the doors are opened, the platform may fall out, increasing the risk of injury to the lift operator.
Correction:
Navistar will notify owners to take buses to a ricon dealer or service center who will install supplemental platform support bumpers. any platform that has already started cracking will be replaced, free of charge. the interim notices were mailed on december 29, 2014. the recall began on january 29, 2015. owners may contact navistar customer service at 1-331-332-1590 or ricon customer service at 1-800-322-2884. navistar's number for this recall is 14517.
Notes:
Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.
Campaign:
15V868000 on 12/21/2015
Component:
Equipment adaptive
Manufactured:
01/01/2006 - 09/22/2014
Affected:
4,784
Defect:
Navistar, inc. is recalling certain model year 2007-2015 ic be and ce school buses, 2013-2015 ic ae school buses, 2007-2011 ic fe school buses, and 2007-2014 ic re school buses equipped with certain model s2005, s2010, s5005, s5010, s5505, and s5510 wheelchair lifts by ricon. the affected lifts are equipped with folding link arms that may have pivot holes that are too big, allowing the bearings to move out of position.
Consequence:
If the bearings move out of position, the stowed platform may have excessive movement resulting in failure of the platform mounting. this failure could cause the wheel chair lift platform to fall out of the vehicle when the doors are opened, increasing the risk of injury for the lift operator.
Correction:
Navistar will notify the purchasers of the lifts, and dealers will inspect the link arms for damage or for displaced bearings. the platform will be inspected for cracks. any damaged parts will be replaced, free of charge. the recall began on february 19, 2016. owners may contact navistar customer service at 1-800-448-7825. note: these buses and wheelchair lifts were subject to a similar recall in 2014. all vehicles that received that recall remedy are still affected by this recall as well.
Notes:
Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.
Campaign:
15V870000 on 12/22/2015
Component:
Equipment adaptive
Manufactured:
01/22/2006 - 05/11/2014
Affected:
68
Defect:
Navistar, inc. is recalling certain model year 2007-2015 ic ce transit buses, 2008-2011 ic fe transit buses and 2009-2013 ic re transit buses equipped with certain model s2005, s2010, s5005, s5010, s5505, and s5510 wheelchair lifts by ricon. the affected lifts are equipped with folding link arms that may have pivot holes that are too big, allowing the bearings to move out of position.
Consequence:
If the bearings move out of position, the stowed platform may have excessive movement resulting in failure of the platform mounting. this failure could cause the wheel chair lift platform to fall out of the vehicle when the doors are opened, increasing the risk of injury for the lift operator.
Correction:
Navistar will notify the purchasers of the lifts, and dealers will inspect the link arms for damage or for displaced bearings. the platform will be inspected for cracks. any damaged parts will be replaced, free of charge. the recall began on february 19, 2016. owners may contact navistar customer service at 1-800-448-7825. note: these buses and wheelchair lifts were subject to a similar recall in 2014. all vehicles that received that recall remedy are still affected by this recall as well.
Notes:
Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.

2008 IC BUS CE TSBs (83)

Bulletin:
IK-2200087
Component:
162300 structure:body:door
Summary:
International: bus entrance door adjustment procedures. the following procedures outline the entrance door bracket, control bar, actuator rod, electric door controller, and air door cylinder and valve adjustments. no model years listed.
Bulletin:
FG-G-10914
Component:
061200 engine and engine cooling:engine:diesel
Summary:
Ic corp. service campaign: see document search button for owner letter. there is a service to reduce engine egr cooler failures and vehicle down time. *rm
Bulletin:
IK-1200496
Component:
110000 electrical system
Summary:
Iknow: the aps sensors have been released for use with pre-2010 emissions international engines. this applies to all maxxforce equipped engines, 2007 to 2010 model year maxxforce 5, 7 dt, 9 and 10 engines, vehicles to include, but not limi
Bulletin:
IK1300085
Component:
044100 service brakes, air:drum:shoes/linings
Summary:
Iknowledge: navistar ce bus, be bus, and durastar models due to vehicle vocation, loading, operating environment, and driving habits, may experience brake lining wear rate that will vary. *ta
Bulletin:
IK-0500013
Component:
021240 suspension:front:springs:leaf spring assembly
Summary:
Ik0500013 - iros suspension auxiliary leaf spring rattle
Bulletin:
IK0800475
Component:
110000 electrical system
Summary:
Radio diagnostics and information
Bulletin:
IK1400033
Component:
100000 power train
Summary:
Torque change for 5/8 inch rear axle shaft flange mounting stud with cone locks and flat washer type hardware.
Bulletin:
IK1500051
Component:
Fuel/propulsion system (pws)
Summary:
Only vehicles equipped with davco fuel pro 382; technical manual installation diagnostics and service
Bulletin:
IK2200132
Component:
150000 seat belts
Summary:
Driver and passenger seat belts
Bulletin:
IK1200029
Component:
062100 engine and engine cooling:cooling system:radiator assembly
Summary:
Radiator internal restriction and flush procedure
Bulletin:
IK0400024
Component:
030000 service brakes, hydraulic
Summary:
Wabco full power brakes park brake troubleshooting; only with sahr (hydraulic powered) praking brake
Bulletin:
IK0700032
Component:
063000 engine and engine cooling:exhaust system
Summary:
Dpf snap accel test - quick test to all vehicles with dpfs
Bulletin:
IK1900212
Component:
060000 engine and engine cooling
Summary:
Front blower motor runs breifly at initial power up
Bulletin:
IK1900218
Component:
356000 equipment adaptive
Summary:
Espar airtronic low run time.
Bulletin:
IK0700079
Component:
060000 engine and engine cooling
Summary:
Scr vehicles setting 3363-16 (fc1713) due to crossed def tank coolant lines or inverted defthv
Bulletin:
IK1201360
Component:
355200 equipment:other:owners/service/other manual
Summary:
Cylinder performance analyzer (cpa) resource center; only models with 2004 thru 2017 international engines.
Bulletin:
IK1201363
Component:
070000 fuel system, gasoline
Summary:
Cpa injector misfire detection; only models with 2004 thru 2017 international engines.
Bulletin:
IK1900022
Component:
353600 equipment:air conditioner
Summary:
A/c refrigerant and oil capacities
Bulletin:
IK2700090
Component:
355200 equipment:other:owners/service/other manual
Summary:
Oncommand ez-tech download center
Bulletin:
IK2700100
Component:
355200 equipment:other:owners/service/other manual
Summary:
Oncommand eztech
Bulletin:
IK2900030
Component:
118000 electrical system: software
Summary:
Dealer ez-tech and diagnostic software support resource center
Bulletin:
IK2200016
Component:
110000 electrical system
Summary:
Post trip inspection system will not disarm or does not operate correctly; excludes child reminder system or child check mate.
Bulletin:
IK0600020
Component:
020000 suspension
Summary:
Determine wheel speed or driveline vibration using a smart phone and free vibsensor application
Bulletin:
IK0700096
Component:
355200 equipment:other:owners/service/other manual
Summary:
Urea quality sensor (uqs) supplemental diagnostic and service information
Bulletin:
IK0700100
Component:
060000 engine (pws)
Summary:
2010 maxxforce 7 engine dpf cracking
Bulletin:
IK0800092
Component:
355200 equipment:other:owners/service/other manual
Summary:
First check to make when troubleshooting any body controller or esc issue
Bulletin:
IK0800284
Component:
350000 equipment
Summary:
Ambient air temperature (aat) sensor faults/location/diagnostics
Bulletin:
IK0800374
Component:
355200 equipment:other:owners/service/other manual
Summary:
How to get a helios capture
Bulletin:
IK0800482
Component:
111000 electrical system:battery
Summary:
Battery testing, diagnostics, and maintenance information
Bulletin:
IK1201299
Component:
060000 engine (pws)
Summary:
Engine oil capacities
Bulletin:
IK1900203
Component:
353000 equipment:electrical
Summary:
Troubleshooting & resetting hvac doors; only vehicles with feature codes 0016wct and 0016wcs
Bulletin:
IK2500127
Component:
355200 equipment:other:owners/service/other manual
Summary:
Using vehicle health report faults
Bulletin:
IK2700065
Component:
355200 equipment:other:owners/service/other manual
Summary:
Ez-tech download center
Bulletin:
IK2700090
Component:
355200 equipment:other:owners/service/other manual
Summary:
Oncommand ez-tech download center
Bulletin:
IK2900029
Component:
353000 equipment:electrical
Summary:
Diagnostic interface cable reference guide
Bulletin:
IK1201009
Component:
060000 engine (pws)
Summary:
Winter front usage
Bulletin:
IK1201299
Component:
060000 engine (pws)
Summary:
Engine oil capacities
Bulletin:
IK1201398
Component:
060000 engine (pws)
Summary:
Bus with isb frequent regeneration; only models with cummins isb engine
Bulletin:
IK2200070
Component:
160000 structure
Summary:
Bus body tie down, floor sill repair
Bulletin:
IK2200137
Component:
162320 structure:body:door/window:emergency exit
Summary:
Bus passenger window troubleshooting; only buses built after 4/17/17
Bulletin:
IK2700100
Component:
118000 electrical system: software
Summary:
Oncommand ez-tech
Bulletin:
IK4300001
Component:
118000 electrical system: software
Summary:
Updating oncommand link with accelerator
Bulletin:
IK0400147
Component:
030000 service brakes, hydraulic
Summary:
Wabco hydraulic power brake cap/grounds diagnostics and repair procedure
Bulletin:
IK0500058
Component:
010000 steering
Summary:
Steering fluids
Bulletin:
IK0800351
Component:
118000 electrical system: software
Summary:
J1939 data link source address information
Bulletin:
IK1201248
Component:
062000 engine and engine cooling:cooling system
Summary:
Cooling system flush procedure
Bulletin:
IK0400056
Component:
030000 service brakes, hydraulic
Summary:
Brake light operation on hpv with full power brakes; only models equipped with meritor wabco full power hydraulic brakes
Bulletin:
IK2200087
Component:
162300 structure:body:door
Summary:
Bus entrance door adjustment procedures; only models built prior to 9/15/2011
Bulletin:
IK2200116
Component:
162300 structure:body:door
Summary:
Bus door adjustment procedure for electric and air; only models built 9/15/11 or later
Bulletin:
IK2200139
Component:
151000 seat belts:front
Summary:
Driver?s seat belt tongue button; only with seat belt part numbers 4091405c1 thru 4091408c1
Bulletin:
IK2500511
Component:
118000 electrical system: software
Summary:
Using supplier software to check dtcs
Bulletin:
IK0800196
Component:
110000 electrical system
Summary:
Asterisk in lower right quadrant of dash display
Bulletin:
IK0800080
Component:
118000 electrical system: software
Summary:
J1939 data link troubleshooting
Bulletin:
IK0400155
Component:
030000 brakes (pws)
Summary:
Ic bus service brake switch inspection
Bulletin:
IK0700096
Component:
110000 electrical system
Summary:
Urea quality sensor (uqs) supplemental diagnostic and service information; only models with scr aftertreatment system and n9, n10, n13, a26 or cummins isb, isl, isx engines built from january 2016
Bulletin:
IK0700097
Component:
061200 engine and engine cooling:engine:diesel
Summary:
New ultrasonic def tank sending unit; only models with scr aftertreatment system.
Bulletin:
IK0800546
Component:
060000 engine and engine cooling
Summary:
Hvac fault 2609-19 with 4th gen bcm; only models equipped with 4th generation bcm
Bulletin:
IK0400154
Component:
030000 service brakes, hydraulic
Summary:
Hydraulic brake system park brake inspection and adjustment procedures; only models with hydraulic brake system equipped with 04gbj park brake
Bulletin:
IK0800080
Component:
353000 equipment:electrical
Summary:
J1939 data link troubleshooting
Bulletin:
IK1200357
Component:
062200 engine and engine cooling:cooling system:fan
Summary:
Horton 2 speed drive master fan clutch missing or loose magnets; only with maxxforce dt, 9 and 10 engines and feature 12tht horton drive master 2 speed fan clutch
Bulletin:
IK1600023
Component:
135200 visibility:rearview mirrors/devices:exterior
Summary:
Mirror repair procedures and replacement parts availability
Bulletin:
IK0800478
Component:
121000 exterior lighting:headlights
Summary:
Headlight condensation or frost; excludes sealed beam headlights such as on workstar, paystar and 9900i)
Bulletin:
IK1300055
Component:
102000 power train:manual transmission
Summary:
Transmission upshifting too fast; only with allison gen 4 lct (1000 and 2000 series) transmission
Bulletin:
IK0400028
Component:
030000 brakes (pws)
Summary:
How to program parameters after changing a wabco fpb ecu ( park brake shows na ); only models equipped with wabco full power brakes
Bulletin:
IK0400057
Component:
040000 service brakes, air
Summary:
2007 and newer brake light operation; only equipped with air brakes
Bulletin:
IK0400114
Component:
030000 brakes (pws)
Summary:
Wabco toolbox error message when downloading wabco file; only models equipped with wabco full power brakes.
Bulletin:
IK0800037
Component:
110000 electrical system
Summary:
Location of 1000 ohm resistor in the hvac wiring
Bulletin:
IK0800169
Component:
070000 fuel system, gasoline
Summary:
How to change from a 5 wire fuel transfer pump to a 2 wire fuel transfer pump
Bulletin:
IK0900007
Component:
060000 engine and engine cooling
Summary:
Ethylene glycol coolant color change to be phased-in approximately april 1, 2004
Bulletin:
IK1200715
Component:
060000 engine and engine cooling
Summary:
Open breather kit installation and turbo charger cleaning instructions
Bulletin:
IK1200634
Component:
355200 equipment:other:owners/service/other manual
Summary:
Aftertreatment resource center; all models equipped with epa 2007 and newer engines
Bulletin:
AFC12948
Component:
063000 engine and engine cooling:exhaust system
Summary:
Ecm recalibration and cleaning of the diesel oxidation catalyst (doc) to prevent possible diesel oxidation catalyst (doc) face plugging resulting in excessive fuel dilution of the engine oil. retired
Bulletin:
REC12523
Component:
060000 engine and engine cooling
Summary:
The engine high pressure oil line may develop a leak or possibly rupture.
Bulletin:
REC12525
Component:
060000 engine and engine cooling
Summary:
The engine high pressure oil line may develop a leak or possibly rupture.
Bulletin:
IK1201009
Component:
060000 engine (pws)
Summary:
Medium duty cole weather operation / solid winter front; excluding high cab durastar
Bulletin:
REC13511
Component:
220000 seats
Summary:
The occupant of the adjacent seat located to the rear of the flip seat could suffer a pinch point injury to their toes and/or foot as a result of this condition.
Bulletin:
IK0400056
Component:
046400 service brakes, air:antilock:abs warning light
Summary:
Brake light operation; only models equipped with meritor wabco full power brakes
Bulletin:
IK0800411
Component:
110000 electrical system
Summary:
Body controller resource center
Bulletin:
IK0800475
Component:
353400 equipment:electrical:radio/tape deck/cd etc.
Summary:
Radio diagnostics and information
Bulletin:
IK1201299
Component:
060000 engine (pws)
Summary:
Engine oil capacities all electronic international engines 1994 - present. cummins isb, ism & isx
Bulletin:
IK1201360
Component:
060000 engine (pws)
Summary:
Cylinder performance analyzer (cpa) resource center
Bulletin:
IK1900022
Component:
060000 engine (pws)
Summary:
A/c refrigerant and oil capacities
Bulletin:
IK2200143
Component:
350000 equipment
Summary:
Diagnosis and repair of intermittent operation of the child checkmate reset button.

Home | Privacy