2008 GOSHEN GC II Recalls (10)

Campaign:
07V462000 on 10/01/2007
Component:
Exterior lighting
Manufactured:
05/25/2005 - 09/24/2007
Affected:
1,333
Defect:
Certain buses fail to comply with the requirements of federal motor vehicle safety standard no. 108, "lamps, reflective devices, and associated equipment." the buses were built without the required reflex reflectors on the rear and rear side and, on certain models, the side intermediate reflectors are missing.
Consequence:
Missing reflectors could lead to reduced visibility of the bus increasing the risk of a crash.
Correction:
Goshen will mail the required reflectors along with installation instructions to owners. if the customer is uncomfortable in performing this procedure, they may take the bus to any goshen coach dealer to have the reflectors installed free of charge. the recall began on november 5, 2007. owners may contact goshen coach at 1-877-734-4943.
Notes:
Customers may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov.
Campaign:
08V147000 on 03/27/2008
Component:
Equipment adaptive
Manufactured:
05/31/2005 - 10/30/2007
Affected:
518
Defect:
Goshen coach is recalling 518 my 2005-2008 gcii, pacer ii, pacer ls, pacer ltd, sentinel, and euroshuttle buses equipped with ricon platform style wheelchair lifts. these buses fail to comply with the requirements of federal motor vehicle safety standard no. 404, "platform lift installations in motor vehicles." the threshold warning system may not detect the presence of a wheelchair or mobility aid user in a certain spot within the defined threshold area.
Consequence:
The user of the lift could be injured should the lift move unintentionally.
Correction:
Goshen coach is working with ricon to correct the wheelchair lifts free of charge (please see 07e095). owners may contact ricon at 1-818-267-3000 or goshen coach at 1-574-970-6300.
Notes:
Customers may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov.
Campaign:
09V138000 on 04/27/2009
Component:
Equipment
Affected:
11
Defect:
Goshen coach is recalling 11 my 2008-2009 gc ii buses equipped with k410 air conditioning condenser assemblies supplied by carrier. the k410 unit is installed on the top of a bus and its cover may not be properly fastened because of a mechanical interference.
Consequence:
If the cover fasteners fail to securely fasten the cover in place, it may become detached during bus operation, possibly causing a crash or cause injury to pedestrians.
Correction:
Goshen coach will work with carrier please see 09e013. carrier will provide a free retrofit repair kit to remedy the issue. owners may contact carrier at 1-800-673-2431 or goshen coach at 574-970-6300.
Notes:
Owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to <a href=http://www.safercar.gov>http://www.safercar.gov</a> .
Campaign:
09V374000 on 09/29/2009
Component:
Interior lighting
Manufactured:
04/30/2005 - 08/30/2009
Affected:
44
Defect:
Goshen coach is recalling certain model year 2005 through 2009 transit buses equipped with luminator horizon led side destination signs. the connector board can corrode due to an accumulation of moisture under the connector.
Consequence:
A short could occur, possibly causing smoke and fire.
Correction:
Goshen coach is working with luminator and luminator will replace the electrical circuit connector board on all signs, built in 2007 and earlier, free of charge. please also see luminator's defect notice 09e-054. the safety recall began on december 11, 2009. owners may contact luminator at 1-972-516-3033 or goshen coach at 574-970-6300.
Notes:
Owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to <a href=http://www.safercar.gov>http://www.safercar.gov</a> .
Campaign:
09V383000 on 10/04/2009
Component:
Equipment:air conditioner
Manufactured:
07/31/2008 - 09/29/2009
Affected:
108
Defect:
Goshen coach is recalling certain model year 2008 and 2009 buses equipped with carrier k410 rooftop condensers. inadequate overcurrent protection of one or more of the fans in the k410 condenser may cause overheating of the fan's wires.
Consequence:
Overheating of the condenser unit wires could result in a fire causing property damage, personal injury or death.
Correction:
Goshen coach will notify owners to contact an authorized carrier dealer to obtain the remedy. please also see carrier's defect report 09e-055. the safety recall began on october 12, 2009. owners may contact carrier at 1-800-673-2431.
Notes:
Owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to <a href=http://www.safercar.gov>http://www.safercar.gov</a> .
Campaign:
10V116000 on 03/23/2010
Component:
Equipment adaptive
Manufactured:
10/31/2007 - 02/27/2010
Affected:
529
Defect:
Goshen coach has notified nhtsa of a defect in certain model year 2008-2010 pacer ls, pacer ltd, pacer ii, gcii, and sentinel buses fitted with ricon public use lifts. the restraint belt on these lifts was designed to prevent the lift from moving, unless the tongue of the belt is fully engaged and latched in the buckle. ricon has discovered, however, that it is possible for the operator to insert the belt tongue into the buckle without fully engaging the latching mechanism. in this case, the restraint belt would appear to be latched, and the operator could run the lift. if the restraint belt tongue is not fully engaged into the restraint belt buckle, and latched, the lift may operate with an occupant on the platform.
Consequence:
The user of the lift could be injured should the lift move without the restraint belt properly buckled.
Correction:
Goshen coach is working with ricon and ricon will be handling the remedy for this campaign. please see ricon's defect report 09e-060. ricon will provide customers with a warning decal and a dvd-based training aid. the recall began april 9, 2010. owners may contact ricon customer service at1-800-322-2884 or by email at www.dmata@wabtec.com.
Notes:
Owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to <a href=http://www.safercar.gov>http://www.safercar.gov</a> .
Campaign:
10V120000 on 03/24/2010
Component:
Equipment adaptive
Manufactured:
08/31/2007 - 02/27/2010
Affected:
125
Defect:
Goshen coach has notified nhtsa about a defect in certain model year 2008-2010 buses manufactured between september 2007 and february 2010, equipped with certain ricon s series and k series l-model wheelchair lifts, due to a problem in the software that controls the lift's "up" function. if the "up" switch is released before the floor level limit switch is activated, the lift may continue its upward travel for approximately 1 second before stopping. the continued upward travel may overrun the floor level cut off point.
Consequence:
When the platform overruns the vehicle floor level and stops at an angle from 15-20 degrees, it is possible for a person in a wheelchair to tip over and for someone standing on the platform to fall, possibly resulting in injuries.
Correction:
Goshen coach will notify owners and the repairs will be performed by authorized ricon dealers please see ricon's defect report 09e-061. ricon will provide owners with a bulletin outlining proper wheelchair lift operation and will ship owners a dvd-based training aid to promote proper lift operation. the safety recall began on april 5, 2010. owners may contact ricon customer service at 1-800-322-2884, emailing at www.dmata@wabtec.com.
Notes:
Owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to <a href=http://www.safercar.gov>http://www.safercar.gov</a> .
Campaign:
11V123000 on 02/23/2011
Component:
Equipment:air conditioner
Manufactured:
12/31/2005 - 12/30/2010
Affected:
2,017
Defect:
Goshen coach is recalling certain model year 2006-2011 buses equipped with carrier genv em-1 evaporator units. due to time, temperature, and/or vibration, the fuse may loosen in the fuse holder resulting in high resistance and arcing.
Consequence:
If sufficient arcing occurs, the fuse holder may melt, and may be accompanied by flame, smoke and potential fire.
Correction:
Goshen coach will notify owners and provide information on how to obtain the retrofit kit from carrier along with repair instructions. this service will be performed free of charge. the safety recall began on march 7, 2011. owners may contact carrier's hotline at 1-800-793-4741.
Notes:
Owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to <a href=http://www.safercar.gov>http://www.safercar.gov</a> .
Campaign:
12V199000 on 05/03/2012
Component:
Equipment adaptive
Manufactured:
01/30/2007 - 05/12/2011
Affected:
2,802
Defect:
Goshen is recalling certain model year 2007-2011 transit buses equipped with braun century-2 and vista-2 wheelchair lifts. over time and with frequent use, the roll stop latches on the outer barrier may become bent or misaligned.
Consequence:
A wheelchair occupant may defeat or ride over the insufficiently latched roll stop. if this occurs when the lift platform is in an elevated position, the wheelchair's occupant could fall and sustain injury.
Correction:
Goshen will notify owners, and repairs will be performed by authorized braun dealers, free of charge. the safety recall began during may 2012. owners may contact goshen at 1-574-970-6300.
Notes:
Customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.
Campaign:
13V008000 on 01/13/2013
Component:
Equipment
Manufactured:
10/12/2006 - 11/04/2012
Affected:
342
Defect:
Goshen coach is recalling certain buses as follows: gc ii, model years 2006-2012; gcii-550, model years 2007-2009; g-force, model years 2011-2012; pacer, model years 2006-2012; pacer ls, model years 2008, 2010, and 2013; pacer ltd, model year 2012; and sentinel, model year 2011. the buses are equipped with a ricon manufactured wheelchair lift which has an optional armored pendant cable. the cable may have been installed such that it doesn't clear the wheelchair lift and without a protective cover, or a misinstalled protective cover.
Consequence:
The cable may contact the power lug at the base of the wheel chair lift causing a short circuit that could result in a fire.
Correction:
Goshen coach is working with ricon to notify owners. ricon will provide a supplemental cover kit with instructions, free of charge. owners may contact goshen coach at 1-574-970-6300 or ricon at 1-818-267-3000.
Notes:
Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.

Home | Privacy