2008 BMW 7 SERIES Recall

Campaign:
10V446000 on 09/30/2010
Component:
Service brakes, hydraulic:power assist:vacuum
Affected:
198,352
Defect:
Bmw is recalling certain model year 2004-2010 5-series, 6-series, and model year 2002-2008 7-series vehicles. a check valve of the brake vacuum pump may leak a small amount of lubricating oil. over time this could result in contamination of the brake booster.
Consequence:
Power assist braking performance could be adversely affected. in extreme cases there could be a complete loss of power assist braking. an unexpected reduction or loss in power braking assist may increase the risk of a crash.
Correction:
Bmw will notify owners and dealers will repair the vehicles free of charge. the safety recall began on november 24, 2010. owners may contact bmw at 1-800-525-7417.
Notes:
Owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to <a href=http://www.safercar.gov>http://www.safercar.gov</a> .

2008 BMW 7 SERIES TSBs (47)

Bulletin:
SI B63-04-08
Component:
121000 exterior lighting:headlights
Summary:
Bmw: headlamp moisture: fault diagnostics. water or condensation in one or both headlamps. models 5 series, 6 series, 7 series, x5, x6, 1 series, and 3 series. model years 2000-20008. *pe
Bulletin:
SI-B12-17-08
Component:
103000 power train:automatic transmission
Summary:
Bmw: service action on e65 and e66 with n62, n62tu, or n73,obd communication on models e65, e66 with n62tu, e65 (alpina b7) with n62. *pe
Bulletin:
SI-B61-06-09
Component:
110000 electrical system
Summary:
Bmw: sporadically, the following conditions may occur-wipers are running on a dry window; speedometer and tachometer are inoperative; check control message emf dropped out (drive control system emergency mode). *pe
Bulletin:
SI-B12-11-09
Component:
061000 engine and engine cooling:engine
Summary:
Bmw: vehicle may intermittently exhibit any of the following: hard to start or may not start; engine runs rough and lacks or loses power; engine power reduced. vapor lock in the fuel system could occur under certain engine operating conditi
Bulletin:
SI-B12-02-09
Component:
071110 fuel system, gasoline:storage:tank assembly:filler pipe and cap
Summary:
Bmw: service engine soon lamp or the check gas cap warnings are illuminated while driving. when diagnosed, the dme has stored faults for small leak, micro leak, super fine leak, or large leak in relation to the tank ventilation or evaporati
Bulletin:
SI-B72-01-09
Component:
151000 seat belts:front
Summary:
Bmw: the safety belts for the front seats have an electric motor-driven reel (ema) which will retract/pretension the seat belt a specified amount when certain hazardous driving situations are present. *pe
Bulletin:
SIB-12-26-09
Component:
061000 engine and engine cooling:engine
Summary:
Bmw vehicles: edk throttle potentiometer faults-diagnosis. models e60, e63, e64, e65, e66, and e70. the service engine soon and dsc/dtc warning lamps are illuminated. the engine enters the power reduction (fail safe) mode. *pe
Bulletin:
SIB-36-05-07
Component:
199000 tires:pressure monitoring and regulating systems
Summary:
Bmw: tire warning light illuminated due to low ambient temperature. model e90, e91(3 series);e92, e92 (3 series); e60 (5 series); e60 (m5); e63, e64 (6 series); e63, e64 (m6); e65, e66 (7 series); e70 (x5); e83 (x3); and e85, e86 (z4).
Bulletin:
SIB-24-03-08
Component:
061000 engine and engine cooling:engine
Summary:
Bmw: complaint of a delayed engagement and a harsh jolt when accelerating from a stop. the situation occurs only during the engine warm up phase (cold engine), and cannot be reproduced in the sport mode. egs software-unfavorable nic cali
Bulletin:
SIB-16-02-09
Component:
072100 fuel system, gasoline:delivery:fuel pump
Summary:
Bmw vehicles: fuel level sensor repairs. where it is necessary to replace the right or the left side fuel level sensor due to a failure, the entire pump and housing or delivery unit (suction jet assembly) do not need to be replaced as wel
Bulletin:
SIB-17-03-09
Component:
061120 engine and engine cooling:engine:gasoline:turbo-charger
Summary:
Bmw vehicles: n63 turbocharger auxiliary water pump faults. the service engine soon lamp is illuminated with the following fault codes stored in the dme control module. turbocharger coolant pump, control line, electric, 0x1016-line inter
Bulletin:
SI-B13-07-10
Component:
141000 air bags:frontal
Summary:
Bmw: air bag warning lamp illuminated; low resistance fault stored. one or more of the following low resistance ce faults may be stored for the passenger front airbag 930915, , and 930921. no model years listed. *pe
Bulletin:
SI-B 64-02-10
Component:
118000 electrical system: software
Summary:
Bmw: blower speed is greatly reduced when the vehicle is stationary. the blower indicator in the ihka control panel remains unchanged. system control software for the heating/air conditioning system is cause. *pe
Bulletin:
SIB-12-10-10
Component:
118000 electrical system: software
Summary:
Bmw: program control units (dme). due to errors in the data in the dme (digital motor electronics), in the test module no values can be read out for the following error codes-oxygen sensor check response time; charge air temperature senso
Bulletin:
SI-B63-02-10
Component:
110000 electrical system
Summary:
Bmw: check control message displayed; turn signals flash fast. intermittently or permanently, a bulb out check control message is displayed, together with the turn signal flashing fast. *pe updated on 11/8/2013. *kb
Bulletin:
SI-B12-06-10
Component:
061000 engine and engine cooling:engine
Summary:
Bmw: n54 engines-misfire faults, diagnosis with istad. situation (1) service engine soon lamp is illuminated with various misfire fault codes (e.g., 29cc, 29d2, 29d1, 29d0, 29c0, 29cf) stored in dme control module. do not follow the reco
Bulletin:
SIB-16-04-10
Component:
071100 fuel system, gasoline:storage:tank assembly
Summary:
Bmw vehicle: teileclearing for diagnostic module tank leakage (dmtl) system. teileclearing process has been developed to help identify the root causes of customer complaints relating to the dmtl system (e.g., evaporative system leaks, che
Bulletin:
SIB-24-01-08
Component:
103000 power train:automatic transmission
Summary:
Bmw vehicle: transmission warning light is illuminated and the transmission enters failsafe mode. fault code 4f81 (ratio monitoring, clutch a), in some cases combined with the subsequent faults 507b/507c (parking gear sensor implausible s
Bulletin:
SIB-63-10-10
Component:
121000 exterior lighting:headlights
Summary:
Bmw vehicle: adaptive headlights. a check control (cc) message is displayed for the adaptive headlights. the headlamps no longer turn with steering wheel movement. fault code 800fc6 is entered in the footwell module (frm3). a second tu
Bulletin:
SIB-65-22-10
Component:
220000 seats
Summary:
Bmw vehicles: replaced seat occupancy sensor mat will not enable. after replacing a cis (capacitive sensing passenger occupancy mat), the new mat will not enable when using ista/p. however, ista/p shows that the acsm (active crash safety
Bulletin:
SIB-32-04-07
Component:
015000 steering:hydraulic power assist system
Summary:
Bmw: a new technical process has been created for bmw to identify causes of steering complaints with a wide range of models. *rm
Bulletin:
SIB-63-02-01
Component:
120000 exterior lighting
Summary:
Bmw: procedure for determining and replacing incandescent and halogen light bulbs under warranty. *rm
Bulletin:
SIB-13-09-10
Component:
061000 engine and engine cooling:engine
Summary:
Bmw: some models equipped with the n54 engine may have an excessive crank time before starting. *rm
Bulletin:
SIB-65-24-03
Component:
141000 air bags:frontal
Summary:
Bmw: operating description of the passenger airbag status light. *rm
Bulletin:
SIB-27-01-07
Component:
104000 power train:transfer case (4-wheel drive)
Summary:
Bmw: a fault for oil wear is stored in the memory, but it does not illuminate the warning lamp. *rm
Bulletin:
SIB-24-02-10
Component:
103000 power train:automatic transmission
Summary:
The transmission warning light is on and the vehicle will not move forward or backwards. engine speed only increases while in neutral or park. *rm updated on 5/1/2012. *kb
Bulletin:
SI B12 55 06
Component:
060000 engine and engine cooling
Summary:
Bmw: there may be excessive cranking before the vehicle starts. the service engine soon light may also be on with a lack of engine power. *rm
Bulletin:
SI B12 11 10
Component:
060000 engine and engine cooling
Summary:
Bmw: there are high fuel pressure faults stored due to a software error. *rm
Bulletin:
SIB-24-01-10
Component:
103000 power train:automatic transmission
Summary:
Bmw: the emergency park release cable has been removed in these models and there is a procedure to disengage the park lock. 2011 e70/e71. updated on 06/08/2011. *kb updated on 06/21/2011. *rm
Bulletin:
SIB-11-03-08
Component:
063110 engine and engine cooling:exhaust system:emission control:crankcase (pcv)
Summary:
Bmw: crankcase pressure diagnosis and information for all vehicles. *rm updated on 4/24/2013. *kb
Bulletin:
SB-11-04-11
Component:
061110 engine and engine cooling:engine:gasoline:belts and associated pulleys
Summary:
Bmw: a noise is heard from the engine while running. the alternator drive belt tensioner is loose and/or shows wear. *rm
Bulletin:
SIB-51-11-11
Component:
162300 structure:body:door
Summary:
Bmw: when outside temp is below freezing the outside doors will not close or are difficult to open. a door cable has moisture intrusion and freezes. *rm
Bulletin:
CN-10E-A02
Component:
072100 fuel system, gasoline:delivery:fuel pump
Summary:
Bmw service campaign: see document search button for owner letter. there may be a problem with the fuel pump which could not meet emissions requirements. there may be a long crank and a service engine soon light. *rm
Bulletin:
SIB-12-19-11
Component:
110000 electrical system
Summary:
Bmw: after being removed, the electric motor electronics connector, that leads to ac compressor, must be sealed properly in order to prevent water ingress after being reinstalled. *pe
Bulletin:
SIB-61-07-12
Component:
061000 engine and engine cooling:engine
Summary:
Bmw: after a few miles or several thousand miles, check control message, hybrid malfunction, may appear after programming of software for vehicle. *pe
Bulletin:
SIB-61-06-12
Component:
012000 steering:column
Summary:
Bmw: steering column switch center contains one or more faults: internal control, steering wheel lock range exceeded, wiper angle defective. various check control messages appear with airbag warning lamp illuminated. *pe
Bulletin:
B61-17-12
Component:
133000 visibility:power window devices and controls
Summary:
Bmw: wipers lights and front power windows are inoperative. this situation may start and lead to a permanent fault. also included model f07 (5 series gran turismo) model years up to march 2012. *js
Bulletin:
RC-11V-521
Component:
061000 engine and engine cooling:engine
Summary:
Bmw: see document search button for owner letter. on certain model year 2008-2011 vehicles, a defect involving the electric auxiliary water pump can over heat or fail to cool engine and fire may occur in vehicle or engine compartment.
Bulletin:
SIB-11-07-12
Component:
060000 engine (pws)
Summary:
Bmw: while driving vehicle, at times would be rough running; white or blue smoke seen exiting exhaust system and the engine oil is consumed above specifications. *pe updated 1/11/13. *pe
Bulletin:
SIB-61-23-12
Component:
190000 tires
Summary:
Bmw: cruise control is operating at 40 miles per hour, when high voltage battery discharges, due to possibly installed incorrect or non approved size tires and wheels on vehicle. *pe
Bulletin:
SIB-11-08-12
Component:
060000 engine (pws)
Summary:
Bmw: due to damaged seal ring, during assembly, engine oil is leaking from engine oil pump volume control valve gasket seal ring. models e70, e71, f01, f02, f04, f07, f10, f12, f13. no model years listed. *pe
Bulletin:
SIB-61-37-12
Component:
111000 electrical system:battery
Summary:
Bmw: the high-voltage (hv) battery cells could be damaged if the vehicle is prevented from entering sleep mode for an extended period of time. updated 03/11/2013 *js
Bulletin:
SIB-61-13-05
Component:
111000 electrical system:battery
Summary:
Bmw: battery has an increased demand due to developemental process of the electrical system. this is causing the batter to need to undergo an energy diagnosis. *kb
Bulletin:
SIB-84-03-14
Component:
118000 electrical system: software
Summary:
Bmw: when using iphone, various connectivity failures occur, such as disconnection of call, list of contacts incomplete, due to the variants and software used. model 2008-2014.
Bulletin:
SIB-11-16-14
Component:
060000 engine (pws)
Summary:
Bmw: on certain vehicles, engine timing chain should be checked for early stages of wear, and a repair solution should be provided. *pe updated 9/25/15. *pe updated 10/6/15. *pe
Bulletin:
SIB-63-11-14
Component:
121300 exterior lighting:headlights:high/low beam dimmer switch
Summary:
Bmw: on some vehicles, when starting, low beam, with 0552 option, would briefly flashes, due to a faulty led main light module that needs replacing. model 2008-14 f01, f02, f06, f07, f10, f12, f13, f25. *pe
Bulletin:
SIB-13-04-15
Component:
090000 fuel system, other
Summary:
Bmw: procedural information on the installation of fuel system low pressure sensor and not correctly installed will lead to failure of low pressure sensor and metal supply line. model 2008-14. *pe

Home | Privacy