2007 WESTERN STAR 4900 Recalls (14)

Campaign:
07V306000 on 07/17/2007
Component:
Steering
Manufactured:
01/04/2007 - 05/16/2007
Affected:
18,000
Defect:
Freightliner is recalling certain school bus chassis, heavy trucks, van chassis, rv motorhome chassis manufactured from january 5 to may 17, 2007, equipped with axle alliance company (aac) front axles. during the front axle assembly, the fasteners that attach the steering arm or tie rod arms to the spindle may be over or under tightened.
Consequence:
Incorrectly tightened steering arm fasteners may fatigue and fracture which could cause a crash without warning.
Correction:
Thomas built will notify owners, inspect the fasteners, and replace the steering arm if necessary. the recall began on december 21, 2007. owners can contact freightliner at 1-800-547-0712.
Notes:
Freightliner recall no. fl-501.customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.
Campaign:
07V316000 on 07/23/2007
Component:
Suspension:rear
Manufactured:
10/31/2006 - 11/29/2007
Affected:
1,200
Defect:
On certain trucks equipped with tuftrac rear suspensions, the center casting brackets may be out of specification. an out of square casting may have unacceptable stress in the bracket when it is installed and may cause it to crack in service.
Consequence:
The drive axle may not be held in position if a cracked bracket fractures completely. this will affect vehicle control and may cause a crash without warning.
Correction:
Dealers will inspect and castings that are out of specification will be replaced free of charge. the recall began on december 12, 2007. owners may contact freightliner at 1-800-547-0712.
Notes:
Freightliner recall no. fl-502.customers may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov.
Campaign:
07V335000 on 08/01/2007
Component:
Fuel system, gasoline:delivery
Manufactured:
11/30/2006 - 02/17/2007
Affected:
4,299
Defect:
On certain trucks, a manufacturing error in the fuel-water separator preheater thermoswitch may prevent the fuel preheater from turning off if the ignition is left on. if the ignition switch is left on when fuel is added to the fuel- water separator at the factory or during a filter element change, a small flame may occur inside the filter cover.
Consequence:
The potential exists for the flame to spread resulting in possible personal injury.
Correction:
Dealers will inspect the fuel filter date code and thermoswitch lot code to determine if they contain the suspect component free of charge. the recall began on october 4, 2007. owners may contact freightliner at 1-800-547-0712.
Notes:
Freightliner recall no. fl-508.customers may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov.
Campaign:
07V530000 on 11/18/2007
Component:
Trailer hitches:fifth wheel assembly
Manufactured:
12/31/2005 - 05/30/2007
Affected:
38,000
Defect:
On certain truck-tractors equipped with holland simplex se or se ii fifth wheels, the latch lever pivot bolt assembly may have been over-tightened which could distort the pivot bolt spacer sleeve. corrosion or contaminates in the pivot may cause it to bind and prevent the fifth wheel jaw from latching securely around the trailer king pin.
Consequence:
There is a possibility that the fifth wheel may fail to latch without the driver's knowledge. when the occurs, the driver could drive away and the trailer could become disengaged increasing the risk of a crash.
Correction:
Dealers will replace the pivot bolt and sleeve with a hex head shoulder bolt and washer. the recall began on january 3, 2008. owners may contact freightliner at 1-800-547-0712.
Notes:
Freightliner recall no. fl-514.customers may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov.
Campaign:
07V571000 on 12/13/2007
Component:
Service brakes, air:slack adjusters
Manufactured:
12/31/2004 - 01/30/2007
Affected:
31
Defect:
On certain heavy duty trucks built with sisu fr2p-21, sisu fr2p-26, sisu fr3p-33, or sisu fr3p-48 rear axles, a counter-bore machined in both ends of the worm wheel opening of the slack adjuster housing reduces material thickness between the worm wheel opening and the worm shaft opening. under normal service a crack may develop in this area rendering the slack adjuster inoperable and reducing brake effectiveness.
Consequence:
Reduced vehicle braking could lead to a crash.
Correction:
Dealers will inspect the slack adjusters, and replace the adjuster if found defective. the recall began on july 31, 2008. owners may contact freightliner at 1-800-547-0712.
Notes:
Freightliner recall no. fl-518.customers may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov.
Campaign:
08V113000 on 03/11/2008
Component:
Fuel system, diesel
Manufactured:
03/31/2004 - 04/29/2007
Affected:
62,000
Defect:
Daimler trucks is recalling 62,000 my 2005-2007 freightliner business class, century class, columbia, coronado, fld, classic, sterling a-line, l-line, and western star 4900 trucks. a fractured fuel line could leak diesel fuel.
Consequence:
If a leak continues undetected under certain conditions, fuel may ignite at a hot engine surface and/or fuel may be spilled on the road surface.
Correction:
High pressure fuel lines and transfer tubes will be inspected and replaced free of charged. the recall began on july 9, 2008. owners may contact daimler trucks at 1-800-547-0712.
Notes:
Daimler truck recall no. fl-526.customers may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov.
Campaign:
09V366000 on 09/24/2009
Component:
Engine and engine cooling
Manufactured:
03/31/2003 - 06/29/2009
Affected:
25,362
Defect:
Daimler trucks is recalling model year 2004-2010 trucks equipped with caterpillar c15 engine. the variable valve actuation oil line may rub against the p-clips retaining the oil line, causing an oil leak.
Consequence:
An oil leak may result in a fire.
Correction:
Daimler trucks is working with caterpillar to remedy these vehicles. please see caterpillar's defect report 09e-020. caterpillar will inspect and repair the necessary components free of charge. the recall began on may 5, 2009. owners may contact caterpillar toll-free at 1-800-447-4986 or daimler trucks at 1-800-547-0712.
Notes:
Daimler trucks recall no. fl-558. owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to <a href=http://www.safercar.gov>http://www.safercar.gov</a> .
Campaign:
09V391000 on 10/05/2009
Component:
Fuel system, gasoline:delivery:hoses, lines/piping, and fittings
Manufactured:
01/16/2006 - 03/30/2009
Affected:
10,185
Defect:
Daimler trucks is recalling certain model year 2006 through 2010 heavy trucks manufactured between january 17, 2006 and march 31, 2009, equipped with epa07 model mbe4000 engines built with plastic low pressure fuel lines. the plastic lines may experience leaks due to fatigue cracks caused by stress and vibration combined with high internal pressure.
Consequence:
If a diesel fuel leak continues undetected under certain conditions fuel may ignite on a hot engine surface and/or fuel may spill on the road increasing the risk of a crash.
Correction:
Daimler trucks will notify owners and the remedy will be performed by detroit diesel corporation authorized repair facilities and direct warranty customers. the safety recall began on may 7, 2010. owners may contact daimler trucks at 1-800-547-0712.
Notes:
Daimler truck's recall campaign number is 09c-2.owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to <a href=http://www.safercar.gov>http://www.safercar.gov</a> .
Campaign:
09V400000 on 10/13/2009
Component:
Engine and engine cooling
Manufactured:
02/26/2006 - 10/01/2009
Affected:
18,067
Defect:
Daimler trucks is recalling model year 2007-2010 freightliner, sterling and western star vehicles equipped with detroit diesel dd15 epa07 engines which were manufactured with grid heaters. increased internal grid heater resistance caused by improperly tightened screws may melt the solder on the grid heater circuit board leading to a short circuit.
Consequence:
A short-circuited grid heater could result in a vehicle fire and injury to vehicle occupants.
Correction:
The engine control logic will be reprogrammed free of charge by detroit diesel authorized repair facilities and direct warranty customers to provide cold weather starting without the need of a grid heater. the safety recall began on november 4, 2009. owners may contact detroit diesel at 1-313-592-5800 and daimler trucks at 1-800-547-0712.
Notes:
Daimler trucks recall no. 09c-4.owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to <a href=http://www.safercar.gov>http://www.safercar.gov</a> .
Campaign:
10V341000 on 07/26/2010
Component:
Engine and engine cooling
Manufactured:
09/04/2006 - 06/29/2010
Affected:
5,743
Defect:
Daimler trucks is recalling certain model year 2007 through 2011 freightliner, fccc, sterling, and western star heavy trucks manufactured from september 5, 2006, through june 30, 2010, equipped with specific mbe900 epa04 and epa07 model engines. the intake air grid heater may short circuit and fail due to excessive internal temperatures.
Consequence:
A short circuited grid heater could result in a vehicle fire and injury to vehicle occupants.
Correction:
Daimler trucks will notify owners and dealers will repair the buses free of charge. repairs will be performed by detroit diesel corporation authorized repair facilities. the safety recall is expected to begin on or about july 29, 2011. owners may contact daimler trucks toll-free at 1-800-547-0712.
Notes:
Daimler trucks' recall campaign number is 10c-5.owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to <a href=http://www.safercar.gov>http://www.safercar.gov</a> .
Campaign:
11V146000 on 03/03/2011
Component:
Engine and engine cooling
Affected:
2,073
Defect:
Daimler trucks (dtna) is recalling certain model year 2006 through 2011 freightliner, cascadia, century, columbia fld, and m2, sterling 9500, and western star 4900 heavy trucks manufactured from march 20, 2006, through june 30, 2010, equipped with specific mbe4000 epa07 model engines. the intake air grid heater may short circuit and fail due to excessive internal temperatures.
Consequence:
A short circuited grid heater could result in a vehicle fire and injury to vehicle occupants.
Correction:
Dtna will notify owners of the recall during march 2011. another notification will be issued once the remedy is released. dtna expects the remedy to be available by december 1, 2011. repairs will be performed by dtna dealers free of charge. owners may contact dtna toll-free at 1-800-547-0712. this recall is asscociated with a previous recall, campaign number 10v-341.
Notes:
Daimler trucks' recall campaign number is 10c-5.owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to <a href=http://www.safercar.gov>http://www.safercar.gov</a> .
Campaign:
11V478000 on 09/20/2011
Component:
Fuel system, diesel
Affected:
73,500
Defect:
Daimler trucks is recalling certain model year 2004 through 2008 heavy trucks manufactured from july 11, 2003, through september 28, 2007, equipped with epa04 model mbe4000 engines built with plastic low pressure fuel lines and fuel filters mounted near the center of the engine on the left-hand side. the plastic low pressure fuel line between engine mounted fuel filter and engine block may develop a substantial diesel fuel leak.
Consequence:
This could create a road hazard increasing the risk of a crash. fuel leakage, in the presence of an ignition source, could result in a fire.
Correction:
Daimler trucks will notify owners and the remedy will be performed by detroit diesel corporation authorized repair facilities. vehicles will be inspected and the plastic low pressure fuel line will be replaced with a steel low pressure fuel line. this service will be performed free of charge. an interim letter was mailed to owners on october 28, 2011. the safety recall began on february 21, 2012. owners may contact daimler trucks at 1-800-547-0712.
Notes:
Daimler trucks' campaign number is 11c-2.owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to <a href=http://www.safercar.gov>http://www.safercar.gov</a> .
Campaign:
12V074000 on 02/27/2012
Component:
Engine and engine cooling:engine:diesel
Affected:
103,437
Defect:
Daimler trucks (dtna) is recalling certain model year 2006-2013 freightliner, sterling, and western star vehicles, equipped with detroit diesel epa07 and epa10, dd13 and dd15/16 engines, manufactured from january 20, 2006, through february 20, 2012. the pump to rail high pressure fuel line support system used on these engines is sensitive to assembly torque and may be damaged during service work. as a result of other repairs, the line supports may loosen, potentially leading to fuel line cracking and a fuel leak.
Consequence:
A fuel leak could create a road hazard, increasing the risk of a crash. also a fuel leak in the presence of an ignition source can result in a fire.
Correction:
Dtna will notify owners, and where necessary, the high pressure fuel line support system will be replaced by dtna authorized service facilities, free of charge. the safety recall began on april 27, 2012. owners may contact dtna at 1-800-547-0712.
Notes:
Dtna's recall campaign number is 12c-2.customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.
Campaign:
17V810000 on 12/19/2017
Component:
Equipment
Manufactured:
07/10/2001 - 08/18/2016
Affected:
24,860
Defect:
Daimler trucks north america llc (dtna) is recalling certain 2002-2017 freightliner cascadia, century class, columbia and coronado trucks and western star 4700, 4900, 5700, 5900 and 6900 trucks. these vehicles are equipped with kidde plastic-handle or push button 'pindicator' fire extinguishers that may become clogged, preventing the extinguisher from discharging as expected or excessive force may be needed to activate the extinguisher. additionally, in certain models, the nozzle may detach from the valve assembly with enough force that it could cause injury and also render the product inoperable. for a full list of the affected fire extinguisher models visit: https://static.nhtsa.gov/odi/rcl/2017/rmisc-17e062-5427.pdf
Consequence:
In the event of a fire, if the fire extinguisher does not function properly, it can increase the risk of injury.
Correction:
Dtna will notify owners, and instruct them to contact kidde for a replacement fire extinguisher, free of charge. the recall began on april 11, 2018. owners may contact dtna customer service at 1-800-547-0712, or contact kidde customer service toll-free at 1-855-262-3540, or online at www.kidde.com and click on "product safety recall" for more information. dtna's number for this recall is fl-759.
Notes:
Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.

2007 WESTERN STAR 4900 TSBs (266)

Bulletin:
SF371AB
Component:
015200 steering:hydraulic power assist:hose, piping, and connections
Summary:
Freightliner - western star power steering reservoir brackets. models affected: specific freightliner western star 4900 vehicles manufactured between may 26, 2006 and july 26, 2007. *nj
Bulletin:
SF383A
Component:
062100 engine and engine cooling:cooling system:radiator assembly
Summary:
Freightliner - modine radiator mounting joints. models affected: specific freightliner century class s/t and columbia vehicles, sterling l-line vehicles and western star 4900 vehicles manufactured between aug. 28, 2006 and jan. 29, 2007
Bulletin:
FSC-410A
Component:
071100 fuel system, gasoline:storage:tank assembly
Summary:
Western star service campaign: see document search button for owner letter. certain vehicles may have been built with 25 inch diameter fuel tank level sender arms and floats that may contact the tank wall and get stuck, possibly resulting
Bulletin:
35-7
Component:
021600 suspension:front:wheel bearing
Summary:
Western star: lubricate wheel bearings, rear drive axles. *js
Bulletin:
SB-49-12
Component:
061200 engine and engine cooling:engine:diesel
Summary:
Western star: around the diesel exhaust fluid (def) an excessive amount of crystal or powder built up indicates a leak caused by evaporation of def exposed to air and/or dampness. *pe
Bulletin:
SBW-4714
Component:
070000 fuel system, gasoline
Summary:
Western star: fuel tanks rotating in saddles. anti-slip material may need to be installed, or an additional strip of rubber. *js
Bulletin:
SB-33-04
Component:
021600 suspension:front:wheel bearing
Summary:
Western star: it has been recommended, by conmet, that the bearing spacer be replaced with new one when hub is removed. model 4700, 4900, 6900.. no years listed. *pe
Bulletin:
SB-35-11
Component:
350000 equipment
Summary:
Western star: conmet recommends replacing the bearing spacer when the hub is removed. model 4700, 4900, 6900. no years listed. *pe
Bulletin:
WSB-49-11
Component:
081100 fuel system, diesel:storage:tank assembly
Summary:
Western star: when truck sits, for any extended period, with a diesel exhaust fluid (def) system, it would crystallized, in the tank, around float, on def level sending unit tube and needs to be cleaned. *pe
Bulletin:
06 01-16
Component:
118000 electrical system: software
Summary:
0601-16 spn 103 (mcm) (ghg17) and spn 103 (mcm); (epa07;epa10;ghg14) diagnostic procedure
Bulletin:
06 09-16
Component:
118000 electrical system: software
Summary:
0609-16 spn 174 (mcm) (ghg17), spn 174 (mcm) (epa07), spn 174; (mcm) (epa10), and spn 174 diagnostic procedure
Bulletin:
06 10-16
Component:
118000 electrical system: software
Summary:
0610-16 spn 111 (cpc) (ghg17) and spn 111 (cpc); (epa07;epa10;ghg14) diagnostic procedure
Bulletin:
06 11-16
Component:
118000 electrical system: software
Summary:
0611-16 spn 110 (mcm) (ghg17) and spn 110 (mcm); (epa07;epa10;ghg14) diagnostic procedure
Bulletin:
06 12-16
Component:
355200 equipment:other:owners/service/other manual
Summary:
0612-16 spn 175 (mcm) (ghg17) and spn 175 (mcm); ( epa07;epa10;ghg14) diagnostic procedure
Bulletin:
16 TS-15
Component:
350000 equipment
Summary:
16ts15 epa07 and later power take-off (pto) dosing feature
Bulletin:
08 09-16
Component:
063000 engine and engine cooling:exhaust system
Summary:
0809-16 symptom diagnostics : noisy 1- box' aftertreatment
Bulletin:
09 02-16
Component:
060000 engine (pws)
Summary:
0902-16 symptom diagnostics - belt coming off, shredding or misalignment
Bulletin:
09 06-16
Component:
072100 fuel system, gasoline:delivery:fuel pump
Summary:
0906-16 low pressure fuel pump
Bulletin:
09 09-16
Component:
060000 engine (pws)
Summary:
0909-16 excessive oil consumption
Bulletin:
16TL20
Component:
060000 engine (pws)
Summary:
16tl20 heavy duty engine valve stem seal installing drift and sleeve
Bulletin:
1017-16
Component:
060000 engine (pws)
Summary:
1017-16 engine model and serial number designation
Bulletin:
1018-16
Component:
060000 engine (pws)
Summary:
1018-16 symptom diagnostics - noise
Bulletin:
1021-16
Component:
060000 engine and engine cooling
Summary:
1021-16 spn 110 (mcm)(epa07epa07;ghg14), spn 110 (cpc)(ghg14)
Bulletin:
SBW0004
Component:
355200 equipment:other:owners/service/other manual
Summary:
Sbw0004 western star courtesy engineering policy
Bulletin:
18SP718
Component:
070000 fuel system, gasoline
Summary:
18sp718rev epa07 dd1516 three-filter esoc fuel system to two-filter km59 gen1 fuel
Bulletin:
18SP687
Component:
060000 engine (pws)
Summary:
18sp687 18sp687 dd15/16 egr actuator replacement service kit
Bulletin:
18SP706
Component:
060000 engine and engine cooling
Summary:
18sp706 replacement of the high pressure fuel pump camshaft oil seal
Bulletin:
917-14
Component:
060000 engine (pws)
Summary:
917-14 installation and removal of the oil filter stand pipe
Bulletin:
920-14
Component:
350000 equipment
Summary:
920-14 additional cleaning and preparing
Bulletin:
909-14
Component:
080000 fuel system, diesel
Summary:
909-14 diesel exhaust fluid metering unit air pressure sensor circuit failed high and low
Bulletin:
915-14
Component:
060000 engine (pws)
Summary:
915-14 backwards running engine detecte
Bulletin:
905-14
Component:
060000 engine (pws)
Summary:
905-14 coolant level circuit failed
Bulletin:
913-14
Component:
060000 engine (pws)
Summary:
913-14 checking for poor engine brake performance
Bulletin:
912-14
Component:
060000 engine (pws)
Summary:
912-14 coolant in oil
Bulletin:
916-14
Component:
080000 fuel system, diesel
Summary:
916-14 fuel cooler leak test procedure - two-filter fuel system
Bulletin:
910-14
Component:
080000 fuel system, diesel
Summary:
910-14 installation of the high pressure fuel rail feed lines - two-filter system
Bulletin:
14TS26
Component:
060000 engine (pws)
Summary:
14ts26 replacement of the high pressure fuel pump camshaft oil seal
Bulletin:
18SP708
Component:
356000 equipment adaptive
Summary:
18sp708rev epa07 10 three-filter fuel
Bulletin:
18SP707
Component:
356000 equipment adaptive
Summary:
18sp707rev epa07/10 three-filter fuel system dd13 high pressure fuel feed lines, mounting bracket and p-clips service kit
Bulletin:
1110-14
Component:
091130 fuel system, other:storage:tank assembly:pressure relief devices
Summary:
1110-14 epa10 doc inlet pressure sensor
Bulletin:
1105-14
Component:
103300 power train:automatic transmission:gear position indication (prndl)
Summary:
1105-14 flywheel, ring gear and flywheel housing
Bulletin:
1102-14
Component:
356000 equipment adaptive
Summary:
1102-14 dd13 cylinder head r&r
Bulletin:
1104-14
Component:
080000 fuel system, diesel
Summary:
1104-14 metal in the fuel system
Bulletin:
1109-14
Component:
356000 equipment adaptive
Summary:
1109-14 diagnostic tes
Bulletin:
1108-14
Component:
356000 equipment adaptive
Summary:
1108-14 spn 636 (mcm) (epa07;epa10;ghg14)
Bulletin:
sb2080
Component:
062100 engine and engine cooling:cooling system:radiator assembly
Summary:
Sb2080 australian cst m1400 isolated radiator retrofit
Bulletin:
14-038
Component:
355200 equipment:other:owners/service/other manual
Summary:
14-038 additional detroit standard repair times
Bulletin:
14-039
Component:
355200 equipment:other:owners/service/other manual
Summary:
14-039 new detroit standard diagnostic times
Bulletin:
14-040
Component:
060000 engine (pws)
Summary:
14-040 additional detroit clos for the heavy duty engine platform
Bulletin:
18SP705REV5
Component:
350000 equipment
Summary:
18sp705rev5 18sp705rev5 ? dd platform delta pressure sensor
Bulletin:
18SP684REV4
Component:
350000 equipment
Summary:
18sp684rev4 18sp684rev4 ? epa07 and epa10 dd platform egr delta pressure sensor update
Bulletin:
14CSA20
Component:
355200 equipment:other:owners/service/other manual
Summary:
14csa20 egr valve actuator kit p/n e23539699
Bulletin:
14CSA21
Component:
355200 equipment:other:owners/service/other manual
Summary:
14csa21 holiday schedule for the detroit customer support center ?
Bulletin:
14CSA22
Component:
114000 electrical system:wiring
Summary:
14csa22 dtna chassis wiring diagrams
Bulletin:
14CSA23
Component:
355200 equipment:other:owners/service/other manual
Summary:
14csa23 csc announces ?tech tips? ? ddcsn
Bulletin:
1005-14
Component:
060000 engine and engine cooling
Summary:
1005-14 oil coolant module
Bulletin:
1010-14
Component:
355200 equipment:other:owners/service/other manual
Summary:
1010-14 spn 2623 (cpc) (ghg14)
Bulletin:
1008-14
Component:
355200 equipment:other:owners/service/other manual
Summary:
1008-14 spn 3510fmi 4,7, and 8 (cpc)(ghg14)
Bulletin:
1006-14
Component:
355200 equipment:other:owners/service/other manual
Summary:
1006-14 spn 4374 (acm) (ghg14)
Bulletin:
1007-14
Component:
355200 equipment:other:owners/service/other manual
Summary:
1007-14 spn 5016/fmi 3, 4 (acm) (epa10)
Bulletin:
1009-14
Component:
355200 equipment:other:owners/service/other manual
Summary:
1009-14 spn 5016 (acm) (ghg14)
Bulletin:
1003-14
Component:
113000 electrical system:starter assembly
Summary:
1003-14 rough running or stalling.
Bulletin:
14TS28
Component:
355200 equipment:other:owners/service/other manual
Summary:
14ts28 dd platform belt drive system - belt part numbers and diagnostics
Bulletin:
14TS30
Component:
355200 equipment:other:owners/service/other manual
Summary:
14ts30 aftertreatment harness diagnostics
Bulletin:
14TL7
Component:
354000 equipment:mechanical
Summary:
14tl7 dd platform flywheel housing runout tool w470589032100
Bulletin:
14TL8
Component:
350000 equipment
Summary:
14tl8 torcup? non-impacting torque tool.
Bulletin:
14TL9
Component:
355200 equipment:other:owners/service/other manual
Summary:
14tl9 special tool warranty program.
Bulletin:
14-040A
Component:
060000 engine (pws)
Summary:
14-040_additional_clos additional detroit clos for the heavy duty engine platform
Bulletin:
14-039A
Component:
355200 equipment:other:owners/service/other manual
Summary:
14-039_additional_sdts new detroit standard diagnostic times
Bulletin:
14-038A
Component:
355200 equipment:other:owners/service/other manual
Summary:
14-038_new_srts additional detroit standard repair times.
Bulletin:
14WO-9
Component:
355200 equipment:other:owners/service/other manual
Summary:
14wo-9_warranty_access detroit new user warranty access request
Bulletin:
14-029
Component:
355200 equipment:other:owners/service/other manual
Summary:
14-029 new detroit standard diagnostic times
Bulletin:
14-017R
Component:
355200 equipment:other:owners/service/other manual
Summary:
14-017r revised: detroit addition of admin time
Bulletin:
18SP703
Component:
070000 fuel system, gasoline
Summary:
18sp703 18sp703 - ghg14 km63 gen2 low pressure fuel pump-two-filter fuel system ki
Bulletin:
801-14
Component:
355200 equipment:other:owners/service/other manual
Summary:
801-14 fmi 19: rcm message not received or stopped arriving
Bulletin:
812-14
Component:
100000 power train
Summary:
812-14 fmi 3, 4: engine aux. shutdown input failed high and low
Bulletin:
811-14
Component:
103000 power train:automatic transmission
Summary:
811-14 fmi 7: internal error with the dt12 shift stalk lever
Bulletin:
803-14
Component:
060000 engine (pws)
Summary:
803-14 fmi 16,18: intake manifold pressure too high and low
Bulletin:
804-14
Component:
060000 engine and engine cooling
Summary:
804-14 fmi 16, 18 intake manifold pressure too high and low (restricted mode)
Bulletin:
813-14
Component:
070000 fuel system, gasoline
Summary:
813-14 installation of the one & two-piece fuel injector wiring harness - two & three-filter system
Bulletin:
14TS21
Component:
100000 power train
Summary:
14ts21 hdep camshaft position sensor change
Bulletin:
49-14
Component:
060000 engine and engine cooling
Summary:
49-14 - def tank coolant valve o-ring kit
Bulletin:
49-13
Component:
350000 equipment
Summary:
49-13 - def return line fitting heater, 6-gallon tanks
Bulletin:
0237-14
Component:
113100 electrical system:starter assembly:solenoid
Summary:
0237-14 engine brake solenoid
Bulletin:
0224-14
Component:
355200 equipment:other:owners/service/other manual
Summary:
0224-14 spn 1590 fmi 9 - cpc- all years february 2014
Bulletin:
0233-14
Component:
355200 equipment:other:owners/service/other manual
Summary:
0233-14 spn 51 fmi 2 - all years
Bulletin:
0215-14
Component:
090000 fuel system, other
Summary:
0215-14 check for rough running or stalling - three-filter fuel system
Bulletin:
0202-14
Component:
090000 fuel system, other
Summary:
0202-14 symptom diagnostics - hard start no start - two-filter fuel system
Bulletin:
0229-14
Component:
060000 engine (pws)
Summary:
0229-14 symptom based diagnostics - oil separator
Bulletin:
0219-14
Component:
090000 fuel system, other
Summary:
0219-14 metal in fuel
Bulletin:
0228-14
Component:
060000 engine (pws)
Summary:
0228-14 engine oil leaks - oil dye method
Bulletin:
0238-14
Component:
070000 fuel system, gasoline
Summary:
0238-14 removal of the high pressure fuel injector lines - two-filter
Bulletin:
0239-14
Component:
070000 fuel system, gasoline
Summary:
0239-14 high pressure fuel injector lines - three-filter system
Bulletin:
15-029
Component:
355200 equipment:other:owners/service/other manual
Summary:
_warranty recognition program - coming soon
Bulletin:
901-15
Component:
060000 engine (pws)
Summary:
901-15 oil breather vent
Bulletin:
15TL21
Component:
118000 electrical system: software
Summary:
15tl21 ghg17 diagnostic connector update
Bulletin:
15-028A
Component:
060000 engine and engine cooling
Summary:
15-028 new detroit coolant line srts
Bulletin:
12-038
Component:
355200 equipment:other:owners/service/other manual
Summary:
12-038-dlr - no problem found - policy claims - during basic vehicle chassis or base engine coverage
Bulletin:
12-039
Component:
355200 equipment:other:owners/service/other manual
Summary:
12-039-dlr owl pre-approval's time frame increases to 60 days
Bulletin:
12-040
Component:
162000 structure:body
Summary:
12-040-dlr roof fairing removal program
Bulletin:
12-043
Component:
355200 equipment:other:owners/service/other manual
Summary:
12-043-dlr helpline available for additional support
Bulletin:
Body SRT
Component:
162000 structure:body
Summary:
Body srt updates -2012.12.12
Bulletin:
sbw4713
Component:
113000 electrical system:starter assembly
Summary:
Sbw4713 crank no start, loss of engine prime on decked vehicles
Bulletin:
12-027
Component:
111000 electrical system:battery
Summary:
12-027-dlr detroit and alliance like batteries are now interchangeable
Bulletin:
sbw4205
Component:
045200 service brakes, air:disc:pads
Summary:
Sbw4205 bendix air disc brake thermal overload issues
Bulletin:
sbw4910
Component:
060000 engine (pws)
Summary:
Sbw4910 gentech def coolant-flow solenoid, testing and replacement
Bulletin:
sbw4911
Component:
110000 electrical system
Summary:
Sbw4911 def gauge reading incorrectly
Bulletin:
17TL25
Component:
020000 suspension
Summary:
17tl25 truckcam? alignment system
Bulletin:
17TL26
Component:
350000 equipment
Summary:
17tl26 injector heat sleeve removal tool dsn930e17002
Bulletin:
17TL27
Component:
070000 fuel system, gasoline
Summary:
17tl27 injector cup tool dsn930e17001
Bulletin:
17TL28
Component:
350000 equipment
Summary:
17tl28 fuel injector removal tool dsn930e17004
Bulletin:
16-007
Component:
355200 equipment:other:owners/service/other manual
Summary:
canadian warranty parts return address change
Bulletin:
16-008
Component:
355200 equipment:other:owners/service/other manual
Summary:
new detroit bearing failure analysis standard diagnostic time
Bulletin:
16-009R
Component:
355200 equipment:other:owners/service/other manual
Summary:
16-009r_owl enhancements
Bulletin:
16-010
Component:
355200 equipment:other:owners/service/other manual
Summary:
Warranty recognition program suspension
Bulletin:
16-011
Component:
355200 equipment:other:owners/service/other manual
Summary:
16-011 new detroit camshaft housing seal standard repair time
Bulletin:
0303-16
Component:
060000 engine and engine cooling
Summary:
hydrocarbon doser coolant lines
Bulletin:
0302-16
Component:
350000 equipment
Summary:
contaminated fluids
Bulletin:
0301-16 SPN 625
Component:
353000 equipment:electrical
Summary:
0301-16 spn 625 (cpc) (epa07) and spn 625 (cpc) (epa10 ghg14)
Bulletin:
0307-16 SPN 723
Component:
353000 equipment:electrical
Summary:
0307-16 spn 723 (mcm) march
Bulletin:
16TS5
Component:
100000 power train
Summary:
16ts5 release of the dd platform bearing failure guide
Bulletin:
16TS7
Component:
080000 fuel system, diesel
Summary:
16ts7 reman diesel particulate filter serial number
Bulletin:
16TS8
Component:
060000 engine and engine cooling
Summary:
16ts8 dd13 cylinder head and cylinder head gasket change
Bulletin:
16TS9
Component:
090000 fuel system, other
Summary:
16ts9 dd platform high pressure fuel lines
Bulletin:
16_TL-2
Component:
355200 equipment:other:owners/service/other manual
Summary:
16_tl-2 dd platform aftertreatment nox sensor socket w470589060900
Bulletin:
16TL3
Component:
350000 equipment
Summary:
16tl3 pocket iq? abs product family kit is available at pdc
Bulletin:
16TL4
Component:
355200 equipment:other:owners/service/other manual
Summary:
16tl4 doc face cleaning tool p n w470589239100
Bulletin:
16TL5
Component:
350000 equipment
Summary:
16tl5 dd platform aftertreatment soot sensor socket dsn0atz16001
Bulletin:
14-022
Component:
355200 equipment:other:owners/service/other manual
Summary:
14-022 pre-approval threshold increase from $2,500 to $5,000 usd
Bulletin:
14-023
Component:
355200 equipment:other:owners/service/other manual
Summary:
14-023 detroit axles pre-approval changes
Bulletin:
14-024
Component:
355200 equipment:other:owners/service/other manual
Summary:
14-024-dlr dtna & jad highlights - q1 & q2
Bulletin:
14-026
Component:
355200 equipment:other:owners/service/other manual
Summary:
14-026-dlr selectruck warranty enhancements
Bulletin:
14-027
Component:
355200 equipment:other:owners/service/other manual
Summary:
14-027 detroit's new consolidated labor operations (clos
Bulletin:
14-028
Component:
355200 equipment:other:owners/service/other manual
Summary:
14-028 remy extended coverage direct file
Bulletin:
18SP701
Component:
090000 fuel system, other
Summary:
18sp701rev2 18sp701rev2? ghg14 two-filter fuel system
Bulletin:
18SP709
Component:
090000 fuel system, other
Summary:
18sp709rev 18sp709rev ? epa10/ghg14 two-filter fuel
Bulletin:
18SP710
Component:
092300 fuel system, other:fuel filter
Summary:
18sp710rev 18sp710rev ? epa10 ghg14 two-filter fuel
Bulletin:
702-14
Component:
355200 equipment:other:owners/service/other manual
Summary:
702-14 spn 520230fmi 5 (ippc)(ghg14)
Bulletin:
707-14
Component:
118000 electrical system: software
Summary:
707-14 spn 520229 fmi 3 (ippc) (ghg14
Bulletin:
705-14
Component:
118000 electrical system: software
Summary:
705-14 spn 520203 fmi 6 (ippc)(ghg14)
Bulletin:
704-14
Component:
118000 electrical system: software
Summary:
704-14 spn 520200 fmi 6 (ippc)(ghg14)
Bulletin:
716-14
Component:
118000 electrical system: software
Summary:
716-14 spn 4077 (mcm)(epa07 epa10;ghg14
Bulletin:
703-14
Component:
118000 electrical system: software
Summary:
703-14 spn 3556 (acm) (epa10)
Bulletin:
709-14
Component:
118000 electrical system: software
Summary:
709-14 spn 3216 (mcm) (ghg14)
Bulletin:
706-14
Component:
110000 electrical system
Summary:
706-14 spn 171 fmi 3, 4 (cpc)(ghg14)
Bulletin:
701-14
Component:
110000 electrical system
Summary:
701-14 spn 168 fmi 0 and 1 (ippc)(ghg14
Bulletin:
711-14
Component:
110000 electrical system
Summary:
711-14 spn 107 (cpc) (ghg14
Bulletin:
710-14
Component:
110000 electrical system
Summary:
710-14 spn 96 (cpc) (ghg14)
Bulletin:
719-14
Component:
110000 electrical system
Summary:
719-14 spn 84 (cpc) (ghg14)
Bulletin:
712-14
Component:
060000 engine and engine cooling
Summary:
712-14 engine coolant temperature
Bulletin:
714-14
Component:
060000 engine (pws)
Summary:
714-14 symptom diagnostics - low engine compression
Bulletin:
715-14
Component:
060000 engine and engine cooling
Summary:
715-14 symptom diagnostics - coolant los
Bulletin:
713-14
Component:
060000 engine and engine cooling
Summary:
713-14 symptom diagnostics - combustion gas in coolant
Bulletin:
14TS18
Component:
060000 engine (pws)
Summary:
14ts18 ghg14 dd engine egr system fault code
Bulletin:
14TS19
Component:
090000 fuel system, other
Summary:
14ts19 dd platform high pressure fuel lines
Bulletin:
14TL2
Component:
060000 engine (pws)
Summary:
14tl2 dd platform engine stand adapter w060589023100
Bulletin:
14TL5
Component:
350000 equipment
Summary:
14tl5 abs power line carrier converter available through pdc
Bulletin:
sbw5430
Component:
110000 electrical system
Summary:
Sbw5430 disconnecting or connecting daytime running lights
Bulletin:
sbw0116
Component:
100000 power train
Summary:
Sbw0116 pilot bearing spacer for detroit engines with eaton transmissions
Bulletin:
sbw5461
Component:
110000 electrical system
Summary:
Sbw5461 guidelines for repairing or replacing an electrical harness
Bulletin:
15-009
Component:
060000 engine (pws)
Summary:
15-009 new detroit standard diagnostic times
Bulletin:
15-010
Component:
070000 fuel system, gasoline
Summary:
15-010-dlr transmission cooler line photos
Bulletin:
18SP712
Component:
070000 fuel system, gasoline
Summary:
18sp712 epa07 dd15/16 three-filter fuel system to two-filter km59 gen1 fuel system conversion service kit
Bulletin:
15CSA4
Component:
355200 equipment:other:owners/service/other manual
Summary:
15csa4 holiday schedule for the detroit customer support center
Bulletin:
307-15
Component:
073000 fuel system, gasoline:fuel injection system
Summary:
307-15 spn 3480 (mcm) (epa07;epa10;ghg14)
Bulletin:
15TS9
Component:
072000 fuel system, gasoline:delivery
Summary:
15ts9 hydrocarbon doser block fuel compensation pressure sensor
Bulletin:
15TL4
Component:
072100 fuel system, gasoline:delivery:fuel pump
Summary:
15tl4 w470589050900 ? 3/8? drive gen2 two-stage valve socket
Bulletin:
15TL5
Component:
355200 equipment:other:owners/service/other manual
Summary:
15tl5 davco shop pro® fxp 95
Bulletin:
15-009 - Detroit
Component:
355200 equipment:other:owners/service/other manual
Summary:
15-009_detroit_new_sdts
Bulletin:
15-015
Component:
355200 equipment:other:owners/service/other manual
Summary:
15-015 warranty exclusions reminder
Bulletin:
15-016
Component:
111000 electrical system:battery
Summary:
15-016-dlr new essential tool for cpwa, cppra, ltd cppra, & dsdwc parties: cadex ca-12 battery tester
Bulletin:
15-017
Component:
070000 fuel system, gasoline
Summary:
15-017 detroit: updated fuel injector sdts
Bulletin:
511-15
Component:
070000 fuel system, gasoline
Summary:
511-15 dd15 and dd16 exhaust gas recirculation valve actuator pull rod
Bulletin:
509-15
Component:
092300 fuel system, other:fuel filter
Summary:
509-15 symptom diagnostics - hard start/no start - three-filter fuel
Bulletin:
507-15
Component:
353000 equipment:electrical
Summary:
507-15 spn 1590( cpc)(ghg14) and spn 1590 (cpc)(epa07;epa10)
Bulletin:
sbw2023
Component:
062100 engine and engine cooling:cooling system:radiator assembly
Summary:
Sbw2023 modine copper/brass bolted downflow radiator rebuilding
Bulletin:
15CSA9
Component:
355200 equipment:other:owners/service/other manual
Summary:
15csa9 release of diagnosticlink® 8.02
Bulletin:
15CSA10
Component:
355200 equipment:other:owners/service/other manual
Summary:
15csa10 the detroit csc announcing a new feature ? ability to attach files to an existing csc
Bulletin:
15TS10
Component:
060000 engine and engine cooling
Summary:
15ts10rev dd engine platform coolant filter
Bulletin:
15TS3
Component:
060000 engine and engine cooling
Summary:
15ts3 detroit? coolant change from nitrite organic acid technology
Bulletin:
15TL6
Component:
073100 fuel system, gasoline:fuel injection system:fuel rail
Summary:
15tl6 w470589129100 ? hdep hp fuel rail test caps
Bulletin:
14TL-7
Component:
103000 power train:automatic transmission
Summary:
14tl-7rev dd platform flywheel housing runout tool w470589032100
Bulletin:
12-022
Component:
980000 unknown or other
Summary:
12-022-dlr daimler trucks remarketing corporation (dtr) now requires pre-approval for repairs $1,200 (usd) and greater
Bulletin:
sbw4206
Component:
030000 brakes (pws)
Summary:
Sbw4206 brake shimmy - meritor steelite x30 brake drum with excessive runout
Bulletin:
sbw3215
Component:
160000 structure
Summary:
Some vehicles may have been incorrectly shimmed at the factory, and may lean slightly to the right or left. while this does not affect the operation of the vehicle, it may be visually unpleasing to many customers.
Bulletin:
18SP726rev
Component:
070000 fuel system, gasoline
Summary:
18sp726 ? epa10 ghg14 two-filter fuel system km59 gen1 dd13 high pressure fuel fee
Bulletin:
0504-16
Component:
061320 engine and engine cooling:engine:other fuel types:turbo-charger
Summary:
Inspection of the dd13 turbocharger
Bulletin:
0510-16 SPN 2623
Component:
353000 equipment:electrical
Summary:
Spn 2623 (cpc)(ghg17), spn 2623 (cpc)(ghg14), and spn 2623 (cpc)(epa07 epa10 ghg14)
Bulletin:
0513-16
Component:
181000 vehicle speed control:accelerator pedal
Summary:
Fmi 2, 3, 4 remote accelerator pedal supply voltage
Bulletin:
0502-16
Component:
060000 engine (pws)
Summary:
Fmi 3 engine oil pressure sensor circuit failed high
Bulletin:
0514-16
Component:
063130 engine and engine cooling:exhaust system:emission control:gas recirculation valve (egr valve)
Summary:
Cleaning of the exhaust gas recirculation venturi pipe delta p sensor ports
Bulletin:
sbw8813
Component:
162800 structure:body:hood
Summary:
reducing excessive hood opening effort, 4900 models
Bulletin:
18SP729
Component:
092300 fuel system, other:fuel filter
Summary:
18sp729 ? epa07 10 three-filter fuel
Bulletin:
18SP730
Component:
070000 fuel system, gasoline
Summary:
18sp730 ? epa07 10 three-filter fuel system dd13 high pressure fuel feed lines, mounting bracket and p-clips service kit
Bulletin:
1201-15
Component:
060000 engine (pws)
Summary:
1201-15 crankshaft and bearings
Bulletin:
1205-15
Component:
063140 engine and engine cooling:exhaust system:emission control:catalytic convertor
Summary:
1205-15 selective catalyst reduction (scr) inlet temperature sensor
Bulletin:
1210-14
Component:
350000 equipment
Summary:
1210-14 cylinder head
Bulletin:
1202-15
Component:
355200 equipment:other:owners/service/other manual
Summary:
1202-15 symptom diagnostics - atd checklist
Bulletin:
1207-15
Component:
355200 equipment:other:owners/service/other manual
Summary:
1207-15 updated procedures with adding epa10 to the ghg14 title
Bulletin:
15TS4
Component:
060000 engine and engine cooling
Summary:
15ts4_rev2_ epa07 dd15 piston kits
Bulletin:
15TS16
Component:
110000 electrical system
Summary:
15ts16rev1 epa10 reman mcm improvement for fault codes spn 651 to 656
Bulletin:
15TL24
Component:
350000 equipment
Summary:
15tl24 otc 1750 revolver engine stand
Bulletin:
1213-16
Component:
080000 fuel system, diesel
Summary:
1213-16 spn 3480 (mcm) (epa07;epa10 ghg14)
Bulletin:
0114-17
Component:
063130 engine and engine cooling:exhaust system:emission control:gas recirculation valve (egr valve)
Summary:
0114-17 spn 2791 (mcm) (epa07;epa10)
Bulletin:
0120-17
Component:
060000 engine (pws)
Summary:
0120-17 diagnostic test - engine oil leaks - oil developer method
Bulletin:
sbw49017
Component:
073000 fuel system, gasoline:fuel injection system
Summary:
Magnetized fill neck for six-gallon def tanks
Bulletin:
0409-17
Component:
350000 equipment
Summary:
Spn 1663 (cpc) (epa07 10 ghg14 ghg17)
Bulletin:
sbw8325
Component:
132000 visibility:glass, side/rear
Summary:
Sbw8325 side window defroster and cooling improvement retrofit
Bulletin:
sbw9801
Component:
160000 structure
Summary:
Sbw9801 paint finish standards
Bulletin:
sbw5401
Component:
120000 exterior lighting
Summary:
Sbw5401 turn signal and brake override circuit
Bulletin:
sbw4911
Component:
110000 electrical system
Summary:
Sbw4911 def gauge reading incorrectly
Bulletin:
sbw5463
Component:
350000 equipment
Summary:
Sbw5463 nexiq usb-link upgrade and diagnostic connector
Bulletin:
706-15
Component:
350000 equipment
Summary:
706-15 spn 1323 (mcm) (ghg14) spn 1324 (mcm) (ghg14) spn 1325
Bulletin:
711-15
Component:
060000 engine and engine cooling
Summary:
711-15 high pressure fuel pump camshaft oil seal - three-filter system
Bulletin:
708-15
Component:
060000 engine and engine cooling
Summary:
708-15 high pressure fuel pump camshaft oil seal - two-filter system
Bulletin:
15TS14 GHG14
Component:
060000 engine and engine cooling
Summary:
15ts14 ghg14 dd engine cylinder liner seal replacement
Bulletin:
0202-15
Component:
060000 engine and engine cooling
Summary:
0202-15 epa10 and ghg14 diesel oxidation catalyst face cleaning
Bulletin:
15TS6
Component:
060000 engine and engine cooling
Summary:
15ts6 replacement of the high pressure fuel pump camshaft oil seal
Bulletin:
15TS8
Component:
080000 fuel system, diesel
Summary:
15ts8 epa10 and ghg14 diesel particulate filter (dpf) compatibility
Bulletin:
sbw3109
Component:
350000 equipment
Summary:
Sbw3109 huck-spin 2 changeover
Bulletin:
ICI12-024
Component:
355200 equipment:other:owners/service/other manual
Summary:
Ici12-024-dlr sf453 - termination date extended
Bulletin:
307-13
Component:
060000 engine and engine cooling
Summary:
307-13 spn 652-fmi 14 - epa07
Bulletin:
sbw2019
Component:
060000 engine and engine cooling
Summary:
Sbw2019 kysor fan clutch rocking runout inspection
Bulletin:
sbw5455
Component:
350000 equipment
Summary:
Sbw5455 virtual technician retrofit
Bulletin:
18SP693
Component:
070000 fuel system, gasoline
Summary:
18sp693 epa07-10 fuel rail clamp service kit (p-n a4720780335) for dd platform-three-filter fuel system engines
Bulletin:
207-13
Component:
060000 engine and engine cooling
Summary:
207-13 removal and installation of the camshaft housing
Bulletin:
13WO-2
Component:
355200 equipment:other:owners/service/other manual
Summary:
13wo-2-new standard rpr times orgl 11wo2 new standard repair times for epa07-10 dd13-15 diagnostic tests
Bulletin:
13TS5
Component:
070000 fuel system, gasoline
Summary:
13ts5 dd platform fuel filter module
Bulletin:
13TS6
Component:
060000 engine (pws)
Summary:
13ts6 dd platform engine oil filter.pdf
Bulletin:
18SP684
Component:
063130 engine and engine cooling:exhaust system:emission control:gas recirculation valve (egr valve)
Summary:
18sp684rev3 epa07 and epa10 dd platform egr delta pressure sensor update
Bulletin:
512-14
Component:
063130 engine and engine cooling:exhaust system:emission control:gas recirculation valve (egr valve)
Summary:
512-14 fmi 0: dpf outlet temperature very high
Bulletin:
18SP712
Component:
070000 fuel system, gasoline
Summary:
18sp712 epa07 dd15/16 three-filter fuel system to two-filter km59 gen1 fuel system conversion service kit
Bulletin:
307-15
Component:
072200 fuel system, gasoline:delivery:hoses, lines/piping, and fittings
Summary:
307-15 spn 3480 (mcm) (epa07;epa10;ghg14)
Bulletin:
15TS9
Component:
080000 fuel system, diesel
Summary:
15ts9 hydrocarbon doser block fuel compensation pressure sensor
Bulletin:
0202-17
Component:
060000 engine (pws)
Summary:
0202-17 dd13, dd15, and dd16 cylinder head assembly removal and installation
Bulletin:
sbw5455
Component:
350000 equipment
Summary:
Sbw5455 virtual technician retrofit
Bulletin:
717-13
Component:
060000 engine (pws)
Summary:
717-13 oil pan
Bulletin:
711-13
Component:
060000 engine (pws)
Summary:
711-13 spn 100-fmi 4 - all years
Bulletin:
702-13
Component:
070000 fuel system, gasoline
Summary:
702-13 test e two-filter fuel system
Bulletin:
705-13
Component:
070000 fuel system, gasoline
Summary:
705-13 test-e three-filter fuel system
Bulletin:
712-13
Component:
070000 fuel system, gasoline
Summary:
712-13 fuel cooler leak test procedure - three-filter fuel system
Bulletin:
710-13
Component:
070000 fuel system, gasoline
Summary:
710-13 metal in the fuel system - three-filter fuel system
Bulletin:
707-13
Component:
070000 fuel system, gasoline
Summary:
707-13 description and operation of the hc doser fuel supply pressure control valve - two filter system
Bulletin:
sbw5439
Component:
110000 electrical system
Summary:
Rx module fault codes
Bulletin:
603-13
Component:
036000 service brakes, hydraulic:antilock
Summary:
603-13 spn 84 -fmi 6 - epa07-ghg14
Bulletin:
608-13
Component:
070000 fuel system, gasoline
Summary:
608-13 high pressure fuel flange-two-filter system
Bulletin:
sbw0001
Component:
350000 equipment
Summary:
Sbw0001validity list western star
Bulletin:
35-11
Component:
100000 power train
Summary:
35-11 - bearing spacer replacement, conmet preset drive hubs
Bulletin:
33-4
Component:
100000 power train
Summary:
33-4- bearing spacer replacement, conmet preset steer hubs
Bulletin:
sbw2018
Component:
062100 engine and engine cooling:cooling system:radiator assembly
Summary:
Sbw2018 western star 4800 and 4900 radiator mounting
Bulletin:
18SP687
Component:
060000 engine and engine cooling
Summary:
18sp687 dd15 16 egr actuator replacement
Bulletin:
0104-15
Component:
060000 engine and engine cooling
Summary:
0104-15 spn 3464/ fmi 16, 18 (mcm) (ghg14)
Bulletin:
15TS1
Component:
060000 engine and engine cooling
Summary:
15ts1 ghg14 dd platform engines with codes spn: 1323 through spn: 1328, fmi: 31, idle smoothness control/cylinder misfire at idle
Bulletin:
15TS2
Component:
060000 engine and engine cooling
Summary:
15ts2 epa07 and epa10 dd platform engines with low oil pressure codes
Bulletin:
15TS4
Component:
060000 engine and engine cooling
Summary:
15ts4 epa07 dd15 piston kits
Bulletin:
15TS5
Component:
080000 fuel system, diesel
Summary:
15ts5rev ghg14 dd platform def pump leaks and code 4374 fmi 0 under pressurized def system
Bulletin:
13M2
Component:
355200 equipment:other:owners/service/other manual
Summary:
13m2 -final-23-sep-2013 field service campaign 13m2
Bulletin:
13M2-02
Component:
350000 equipment
Summary:
13m2- equipment owner field service campaign - 13m2
Bulletin:
13TS22
Component:
080000 fuel system, diesel
Summary:
Rev dd platform fuel injector cup seal
Bulletin:
18SP694
Component:
070000 fuel system, gasoline
Summary:
18sp694 epa07 dd platform high pressure fuel flange service kit (p-n- a4720785844)
Bulletin:
FL756
Component:
030000 service brakes, hydraulic
Summary:
Brake light pressure switch may not activate the brake lights with a light application of the brake pedal.
Bulletin:
ICI18-016 FL756
Component:
350000 equipment
Summary:
The automatic connector terminal removal tool is part of tool kit dde ki0cha17001.
Bulletin:
sbw0005
Component:
355100 equipment:other:labels
Summary:
If a gvwr certification label is lost or damaged, freightliner will supply a duplicate label. log on to dtnaconnect.com and under "dtnaconnect resources", select the "tool and services" plus sign. select "request for certification labl or
Bulletin:
sbw8329
Component:
161000 structure:frame and members
Summary:
In some operating conditions, water may leak into the cab onto the passenger floor through the hvac fresh air intake on the frontwall on 47,00,4900, and 5700 models.
Bulletin:
sbw31013
Component:
211000 trailer hitches:fifth wheel assembly
Summary:
With the start of production on march 6, 2018, the fasteners used to attach the slide- and plate-mount style fifth wheels to the outboard angles changed to m16 metric bolts, nuts, and washers.
Bulletin:
0505-18
Component:
061200 engine and engine cooling:engine:diesel
Summary:
0505-18 spn 3563 hdep inlet manifold pressure too low

Home | Privacy