2007 TOYOTA TACOMA Recalls (10)

Campaign:: 07V324000 on 07/25/2007
Component:: Power train:driveline
Manufactured:: 05/29/2007 - 06/03/2007
Affected:: 108
Defect:: On certain pickup trucks equipped with four wheel drive, a section of the rear propeller shaft may have been improperly cast.
Consequence:: The front side of the rear propeller shaft could separate at the joint and come into contact with the road surface which could result in a loss of vehicle control, increasing the possibility of a crash.
Correction:: Dealers will replace the rear propeller shaft with a new one free of charge. the recall began on august 1, 2007. owners may contact toyota at 1-800-331-4331.
Notes:: Toyota recall no. 70d.owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov.
Campaign:: 09V223000 on 06/14/2009
Component:: Equipment:other:labels
Manufactured:: 08/31/2005 - 05/03/2009
Affected:: 27,080
Defect:: Toyota is recalling 27,080 model year 2005 through 2010 passenger cars built from september 1, 2005 to may 4, 2009. these vehicles were not equipped with load carrying capacity modification labels which fails to conform with the requirements of federal motor vehicle safety standard no. 110, "tire selection and rims."
Consequence:: Incorrect load carrying capacity modification labels could result in the vehicle being overloaded, increasing the risk of a crash.
Correction:: Toyota will notify owners and provide them with a new, accurate label to be installed over the inaccurate label free of charge. the safety recall began on august 18, 2009. owners may contact toyota at 1-888-270-9371.
Notes:: Owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to <a href=http://www.safercar.gov>http://www.safercar.gov</a> .
Campaign:: 09V388000 on 10/05/2009
Component:: Vehicle speed control:accelerator pedal
Affected:: 4,445,056
Defect:: Toyota is recalling certain model year 2004-2010 passenger vehicles. the accelerator pedal can get stuck in the wide open position due to its being trapped by an unsecured or incompatible driver's floor mat.
Consequence:: A stuck open accelerator pedal may result in very high vehicle speeds and make it difficult to stop the vehicle, which could cause a crash, serious injury or death.
Correction:: Toyota filed an amended defect report on november 25, 2009, stating that dealers will modify the accelerator pedal and, on certain vehicles, alter the shape of the floor surface under the pedal. these changes address the risk of pedal entrapment due to interference with the floor mat. redesigned accelerator pedals will become available beginning in april 2010 and dealers will replace any modified pedal with the new pedal if desired. also, dealers will replace any genuine toyota or lexus all-weather floor mats with redesigned all-weather mats, or repurchase the previous mats from owners who do not want the new ones. additionally, software modifications will be installed on camry, avalon and lexus es 350, is 350 and is 250 models that will ensure that the brake overrides the accelerator in the event both brake and accelerator pedals are applied. toyota will begin mailing letters to owners on december 31, 2009. owners may contact toyota at 1-800-331-4331, lexus at 1-800-255-3987.
Notes:: Toyota recall no. 90l/90lg.owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to <a href=http://www.safercar.gov>http://www.safercar.gov</a> .
Campaign:: 10V036000 on 02/02/2010
Component:: Equipment:other:labels
Affected:: 153,418
Defect:: Southeast toyota is recalling certain model year 2005-2011 passenger vehicles for failing to comply with the requirements of federal motor vehicle safety standard no. 110, "tire selection and rims." these vehicles were sold without the requisite load carrying capacity modification labels.
Consequence:: A driver may overload a vehicle which may increase the risk of a crash.
Correction:: Dealers will mail to consumers the corrected label or the customer will have the option for dealers to install the label free of charge. the safety recall began on may 27, 2010. owners may contact southeast toyota at 1-800-301-6859.
Notes:: Owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to <a href=http://www.safercar.gov>http://www.safercar.gov</a> .
Campaign:: 10V035000 on 02/02/2010
Component:: Equipment:other:labels
Affected:: 271,417
Defect:: Gulf states toyota is recalling certain model year 2005-2010 vehicles for failing to comply with the requirements of federal motor vehicle safety standard no. 110, "tire selection and rims." these vehicles were sold between september 1, 2005 and june 2, 2008 without the requisite load carrying capacity modification labels.
Consequence:: This does not meet the standard requirements.
Correction:: Dealers will mail to consumers the corrected label or the customer will have the option for dealers to install the label free of charge. dealers will also correct the owner's manual. the safety recall began on may 27, 2010. owners may contact gulf states toyota at 713-580-3300.
Notes:: Owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to <a href=http://www.safercar.gov>http://www.safercar.gov</a> .
Campaign:: 12V092000 on 03/06/2012
Component:: Air bags:frontal
Manufactured:: 09/13/2004 - 08/28/2008
Affected:: 495,470
Defect:: Toyota is recalling certain model year 2005-2009 tacoma vehicles, manufactured from september 14, 2004, through august 29, 2008. over time, steering wheel vibration may damage the spiral cable assembly (clockspring) that powers the driver's air bag module. if damage occurs, the air bag warning lamp will illuminate and the air bag may become deactivated.
Consequence:: In the event of a crash, the driver's side air bag may not deploy, increasing the risk of personal injury.
Correction:: Toyota will notify owners, and dealers will replace the spiral cable assembly, free of charge. an interim letter is expected to be mailed to owners during april 2012. owners may contact toyota at 1-800-331-4331.
Notes:: Toyota will notify owners, and dealers will replace the spiral cable assembly, free of charge.the safety recall is expected to begin in early april 2012.owners may contact toyota at 1-800-331-4331.
Campaign:: 13V337000 on 08/06/2013
Component:: Seat belts
Manufactured:: 09/13/2004 - 03/28/2010
Affected:: 342,451
Defect:: Toyota is recalling certain model year 2005-2010 tacoma access cab vehicles manufactured september 14, 2004, through march 29, 2010; and model year 2011 tacoma access cab vehicles manufactured july 1, 2010, through september 7, 2011. if the access doors are repeatedly and forcefully closed, the screws that attach the seat belt pre-tensioner to the seat belt retractor can loosen over time. if the screws loosen completely, the seat belt pre-tensioner and the retractor spring cover could detach from the seat belt retractor.
Consequence:: If the seat belt pre-tensioner detaches from the seat belt assembly, the seat belt pre-tensioner will not perform as designed, increasing the risk of injury in a severe crash.
Correction:: Toyota will notify owners, and dealers will inspect the seat belt assemblies. based on the inspection, the seat belt assembly will be replaced or new pre-tensioner screws will be installed with thread-locking sealant and a retractor spring cover with stopper ribs to prevent loosening of the screws. these services will be provided at no cost to the owner. the recall began during february 2014. owners may contact toyota at 1-800-331-4331.
Notes:: Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.
Campaign:: 14V604000 on 09/28/2014
Component:: Suspension:rear:springs:leaf spring assembly:leaf
Manufactured:: 09/13/2009 - 12/05/2010
Affected:: 710,711
Defect:: Toyota motor engineering & manufacturing (toyota) is recalling certain model year 2005-2011 toyota tacoma pre-runner and 4x4 vehicles manufactured september 14, 2009, to october 11, 2010. in the affected vehicles, one of the leaf springs may fracture due to stress or corrosion. while being driven, the broken leaf could move out of position and contact surrounding components including the fuel tank, possibly puncturing the tank and causing a fuel leak.
Consequence:: If the fuel tank leaks fuel from being punctured, there is an increased risk of a fire.
Correction:: Toyota will notify owners and dealers will install new rear leaf spring assemblies. the recall began on january 29, 2016. owners may contact toyota customer service at 1-800-331-4331.
Notes:: Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.
Campaign:: 14V743000 on 11/18/2014
Component:: Seats:front assembly:seat heater/cooler
Manufactured:: 05/31/2005 - 09/29/2011
Affected:: 3,233
Defect:: Southeast toyota distributors, llc (set) is recalling certain model year 2010-2011 prius and corolla, 2009-2011 venza, 2006-2010 avalon, 2007-2010 fj cruiser, 2005-2011 sienna and sequoia, 2006-2011 tacoma 4x2 and 4x4, camry, highlander, tundra 4x2 and 4x4, and 2007-2011 rav4 and 4runner. the affected vehicles may experience compression of the seat cushion which may damage the seat heater wiring.
Consequence:: Damage to the seat heater wiring could cause the wires to short, increasing the risk of the seat burning and causing personal injury to the occupant.
Correction:: Set will notify owners, and dealers will disconnect the heaters with copper strand heating elements and refund the purchase price of the seat heater accessory, free of charge. the recall is expected to began in january 2015. owners may contact set customer service at 1-866-405-4226.
Notes:: Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.
Campaign:: 16V396000 on 06/01/2016
Component:: Seats:front assembly:seat heater/cooler
Manufactured:: 12/04/1987 - 01/26/2012
Affected:: 7,749
Defect:: Southeast toyota distributors, llc (set) is recalling certain 2005-2011 4runner, highlander, sequoia, and sienna, 2005-2010 avalon and tundra, 2006-2008 camry solara, 2006-2010 highlander hybrid, 2006-2011 rav4 and tacoma, 2007-2010 fj cruiser, 2007-2011 camry hybrid, 2009-2010 venza, 2010-2012 prius, 1988-1990 and 2005-2010 camry, and 1989 and 2009-2010 corolla vehicles equipped with aftermarket accessory seat heaters with a copper strand heating element. the electrical wiring in the seat heaters may be damaged when the seat cushion is compressed.
Consequence:: If damaged, the copper strand heating element may short circuit, increasing the risk of a fire.
Correction:: Set will notify owners, and dealers will disconnect the seat heaters, free of charge, and refund the purchase price of the seat heater accessory. the recall began on july 14, 2016. owners may contact set customer service at 1-866-405-4226. set number for this recall is set16b.
Notes:: Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.

2007 TOYOTA TACOMA TSBs (237)

Bulletin:: 00406
Component:: 199000 tires:pressure monitoring and regulating systems
Summary:: Direct-type tire pressure warning system diagnostic tips. *kb
Bulletin:: 00407
Component:: 162500 structure:body:tailgate
Summary:: Bent rear tail gate. *kb
Bulletin:: 00407
Component:: 980000 unknown or other
Summary:: Driver and passenger's side floor mats. *nj
Bulletin:: T-SB-0076-08
Component:: 105500 power train:driveline:differential unit
Summary:: Rear differential whine or howling noise at highway speeds. *pe
Bulletin:: SB-0277-09
Component:: 103000 power train:automatic transmission
Summary:: Toyota: automatic transmission/transaxle. some vehicles may exhibit a mil on condition with dtc p0705 (transmission range sensor circuit malfunction (prndl input)) stored. common symptoms with this dtc can include possible delayed engage
Bulletin:: SB-0397-09 REV1
Component:: 355200 equipment:other:owners/service/other manual
Summary:: Toyota: vehicle interior: interior panels/trim to improve serviceability of the floor carpet grommet (floor clamp retainer), a new service part has been developed which allows the floor carpet grommet to be replaced separately from the ca
Bulletin:: TSB-0064-10
Component:: 061000 engine and engine cooling:engine
Summary:: Toyota: techstream ecu flash reprogramming procedure. flash reprogramming allows the ecu software to be updated without replacing the ecu. flash calibration updates for specific vehicle models/ecus are released as field-fix procedures de
Bulletin:: SB-0119-10 REV2
Component:: 013000 steering:gear box (other than rack and pinion)
Summary:: Toyota: some toyota tacoma vehicles manufactured between 2005 and 2011 may have a steering rattle noise when driving on rough surfaces. *rm
Bulletin:: TSB-0049-11
Component:: 102000 power train:manual transmission
Summary:: Toyota: information on installing manual transmission shift lever or park neutral position switch. *rm
Bulletin:: TSB-0122-11
Component:: 140000 air bags
Summary:: Toyota: information provided for replacing the seat covers for vehicles equipped with side airbags. *pe
Bulletin:: T-SB-0057-12
Component:: 010000 steering
Summary:: Toyota: steering intermediate shaft rattle noise. some vehicles may exhibit steering rattle noise when driven over rough road surfaces. also included 2wd tacoma prerunner. model years 2005-2012. *js
Bulletin:: TSB-0087-12
Component:: 181000 vehicle speed control:accelerator pedal
Summary:: Toyota: accelerator pedal sensor assembly information regarding the inspection, removal, and installation, if lubrication or oil, is applied. *pe
Bulletin:: TSB-0250-12
Component:: 103000 power train:automatic transmission
Summary:: Toyota: just before coming to a stop or accelerating from a stop would experience a bump from behind sensation or hear a thunking or clunking noise from rear of vehicle. information on repair procedure on rear propeller shaft (driveshaft
Bulletin:: TSB-0057-13
Component:: 103000 power train:automatic transmission
Summary:: Toyota: on some vehicles, with 5 speed automatic transmission, can hear a whinnying noise coming from the rear differential. model 2005-2013 tacoma. *pe
Bulletin:: TSB-0249-12
Component:: 105300 power train:driveline:driveshaft
Summary:: Toyota: the driveline vibrates between 15-25 mph. model 2005-2013 tacoma. *pe
Bulletin:: TSB-0016-13 REV1
Component:: 103000 power train:automatic transmission
Summary:: Toyota: a sensation of a bump from behind or exhibiting a clunk or thunk noise coming from rear just as accelerating or coming to a stop. model 2005-2013 tacoma. *pe
Bulletin:: TC-14-013
Component:: 161000 structure:frame and members
Summary:: Toyota: see document search button for owner letter. information provided regarding the corrosion resistant compound (crc) application for some vehicles frames due to usage of high road salt, in certain states. model 2005-2008 tacoma.
Bulletin:: TC-14-025
Component:: 121000 exterior lighting:headlights
Summary:: Toyota: see document search button for owner letter. the headlamp assembly inner lens distortion/bubbling, and possible cracked or separated inner lens, have an extended warranty coverage. model 2005-2011 tacoma. *pe
Bulletin:: TC-14-039
Component:: 161000 structure:frame and members
Summary:: Toyota: see document search button for owner letter. due to significant rust perforation and based upon inspection criteria, a limited service campaign has been issued regarding the application of corrosion resistant compounds (crc) to k
Bulletin:: TC 14-039
Component:: 161000 structure:frame and members
Summary:: Toyota: see document search button for owner letter. due to significant rust, from road salt, a limited service campaign has been issued regarding corrosion resistant compounds (crc) application, to key areas of frame assembly. model 2
Bulletin:: TC14-039
Component:: 161000 structure:frame and members
Summary:: Toyota: this tsb contains an owner notification letter. tacoma 2005-2008 reports showing 2005-2008 models that operated in cold climate may have more than normal corrosion vehicles to frame. *lj
Bulletin:: TC14-039
Component:: 161000 structure:frame and members
Summary:: Toyota tacoma 2005-2008: corrosion- resistant compound to frame of some trucks torevent rust. see document search button for owners letter. *lj
Bulletin:: TC15-009
Component:: 161100 structure: frame and members:underbody shields
Summary:: Toyota 2005-2008 tacoma: this contains an owner notification letter. select document search button below. certain reports received regarding corrosion to vehicles frame due to cold climate. *lj
Bulletin:: LSC(ESD
Component:: 161100 structure: frame and members:underbody shields
Summary:: This tsb contains document owner letter. see document search button. toyota tacoma 2005-2008: bulletin information regarding customer complaints of vehicles operating in cold weather with high road salt usage may experience corrosion to
Bulletin:: T-SB-0129-11
Component:: 120000 lighting (pws)
Summary:: Summary to be provided on a future date.
Bulletin:: T-SB-0016-13
Component:: 105300 power train:driveline:driveshaft
Summary:: Summary to be provided on a future date.
Bulletin:: T-SB-0250-12
Component:: 105300 power train:driveline:driveshaft
Summary:: Summary to be provided on a future date.
Bulletin:: T-SB-0186-12
Component:: 101100 power train:clutch assembly:pedal/linkage
Summary:: Summary to be provided on a future date.
Bulletin:: T-SB-0016-13
Component:: 105300 power train:driveline:driveshaft
Summary:: Summary to be provided on a future date.
Bulletin:: T-SB-0008-14
Component:: 105300 power train:driveline:driveshaft
Summary:: Summary to be provided on a future date.
Bulletin:: 9-29-14
Component:: 022000 suspension:rear
Summary:: Summary to be provided on a future date.
Bulletin:: T-SB-0066-11
Component:: 060000 engine (pws)
Summary:: Summary to be provided on a future date.
Bulletin:: T-SB-0186-12
Component:: 101100 power train:clutch assembly:pedal/linkage
Summary:: Summary to be provided on a future date.
Bulletin:: T-SB-0187-12
Component:: 190000 tires
Summary:: Summary to be provided on a future date.
Bulletin:: T-SB-0249-12
Component:: 105300 power train:driveline:driveshaft
Summary:: Summary to be provided on a future date.
Bulletin:: T-TT-0051-10
Component:: 353600 equipment:air conditioner
Summary:: Summary to be provided on a future date.
Bulletin:: T-TT-0124-11
Component:: 190000 tires
Summary:: Summary to be provided on a future date.
Bulletin:: TC13-019
Component:: 355200 equipment:other:owners/service/other manual
Summary:: Summary to be provided on a future date.
Bulletin:: T-TT-0268-13
Component:: 353400 equipment:electrical:radio/tape deck/cd etc.
Summary:: Summary to be provided on a future date.
Bulletin:: SB-TC-14-039
Component:: 350000 equipment
Summary:: Summary to be provided on a future date.
Bulletin:: T-SB-0066-11
Component:: 102000 power train:manual transmission
Summary:: Summary to be provided on a future date.
Bulletin:: E0D ESD_R 11/30
Component:: 160000 structure
Summary:: Rl: toyota will be sending limited service campaign follow-up notices to remind owners whose vehicles have not yet had campaign repairs completed.
Bulletin:: E0D ESD_D 11/30
Component:: 160000 structure
Summary:: Dl: limited service campaign completion is important and is an integral part of our commitment to meet customer expectations of toyota products. toyota will be sending limited service campaign follow-up notices to remind owners whose vehicl
Bulletin:: E0D ESD 2/1
Component:: 160000 structure
Summary:: "dealer letter: frame replacement customer vehicles that qualify for frame replacement under e0d/esd must have their vehicle inspected on or before march 31, 2016. frame and ancillary parts orders must be submitted no later than tuesday, a
Bulletin:: E0D ESD 2/10
Component:: 160000 structure
Summary:: "quick reference guide: frame replacement all frames must be inspected on or before march 31, 2016 in order to qualify for frame replacement. vehicles inspected after this date will not be covered under the limited service campaign. crc a
Bulletin:: E0D ESD 2/29
Component:: 160000 structure
Summary:: "dealer letter: frame replacement customer vehicles that qualify for frame replacement under e0d/esd must have their vehicle inspected on or before march 31, 2016. frame and ancillary parts orders must be submitted no later than tuesday, a
Bulletin:: T-SB-0012-13 REV
Component:: 060000 engine (pws)
Summary:: "tsb: flash reprogramming allows the ecu software to be updated without replacing the ecu. flash calibration updates for specific vehicle models/ecus are released as field-fix procedures described in individual service bulletins. this bul
Bulletin:: T-TT-0381-16
Component:: 350000 equipment
Summary:: Tech tip: some customers may experience difficulty programming homelink.
Bulletin:: T-TT-0362-15
Component:: 060000 engine (pws)
Summary:: Tt: the vehicle may be difficult to start or have an abnormally low or rough idle after the battery has been disconnected or power to the engine ecm has been interrupted.
Bulletin:: GR1_REGION LETTE
Component:: 100000 power train
Summary:: Region letter: toyota will be sending safety recall follow-up notices to remind owners whose vehicles have not yet had campaign repairs completed. please note the following information for regional and pd associates.
Bulletin:: GR1_DEALER LETTE
Component:: 100000 power train
Summary:: "dealer letter: safety recall completion is important not only in satisfying government requirements, but also is an integral part of our commitment to meet customer expectations of toyota products. toyota will be sending safety recall foll
Bulletin:: E0D_LSC_CAT Regi
Component:: 160000 structure
Summary:: Region letter: condition: ? toyota has received reports that certain 2005 through 2008 model year tacoma
Bulletin:: E0D_LSC_CAT Deal
Component:: 160000 structure
Summary:: Region letter: condition: ? toyota has received reports that certain 2005 through 2008 model year tacoma
Bulletin:: T-SB-0044-14 Rev
Component:: 060000 engine and engine cooling
Summary:: Tsb: some 2012 - 2014 model year tacoma vehicles equipped with 1gr-fe engines may exhibit spark knock (detonation) during light acceleration and/or uphill in hot weather (80°f or higher). the engine control module/ecm (sae term: powertrain
Bulletin:: T-SB-0006-11 Rev
Component:: 100000 power train
Summary:: Tsb: world standard (ws) automatic transmission fluid (atf) was introduced to reduce maintenance costs and increase the mileage between scheduled maintenance checks. here are some important tips when working with atf-ws in toyota vehicles r
Bulletin:: T-SB-0014-11 Rev
Component:: 103000 power train:automatic transmission
Summary:: Tsb: the purpose of this service bulletin is to provide information regarding the installation of the correct torque converter bolts during automatic transmission/transaxle assembly replacement. incorrect torque converter bolts or missing w
Bulletin:: T-SB-0049-11 Rev
Component:: 100000 power train
Summary:: Tsb: the purpose of this bulletin is to provide information regarding transmission and/or park neutral position switch installation. if the manual shift lever is rotated prior to installing the park neutral position switch, the detent sprin
Bulletin:: T-SB-0260-08 Rev
Component:: 103000 power train:automatic transmission
Summary:: Tsb: the purpose of this bulletin is to assist in the identification and location of serial numbers on 2006 -2014 model year remanufactured automatic transmissions.
Bulletin:: ER10_Remail_Regi
Component:: 150000 seat belts
Summary:: Region letter: toyota will be sending safety recall follow-up notices to remind owners whose vehicles have not yet had campaign repairs completed.
Bulletin:: ER10_Remail_Deal
Component:: 150000 seat belts
Summary:: Dealer letter: safety recall completion is important not only in satisfying government requirements but also is an integral part of our commitment to meet customer expectations of toyota products. toyota will be sending safety recall follow
Bulletin:: T-SB-0186-12 Rev
Component:: 101000 power train:clutch assembly
Summary:: Tsb: some 2005 - 2014 model year tacoma vehicles may exhibit a squeak or creak noise from the clutch pedal when it is depressed or released. changes have been made to the clutch pedal and clutch master cylinder assembly to address this cond
Bulletin:: T-SB-0134-14
Component:: 100000 power train
Summary:: Tsb: the purpose of this bulletin is to provide precautions to follow when installing an automatic transmission/transaxle assembly to avoid mil "on" shifting issues and/or transmission damage. use the information in this bulletin when insta
Bulletin:: T-SB-0200-08 Rev
Component:: 103000 power train:automatic transmission
Summary:: Tsb: the purpose of this bulletin is to assist in the identification and location of serial numbers on 2006 - 2014 model year automatic transmissions.
Bulletin:: E0D_LSC_NY Regio
Component:: 160000 structure
Summary:: Region letter: condition: toyota has received reports that certain 2005 through 2008 model
Bulletin:: E0D_LSC_NY Deale
Component:: 160000 structure
Summary:: Dealer letter: condition: toyota has received reports that certain 2005 through 2008 model year tacoma vehicles oper
Bulletin:: T-SB-0250-12 Rev
Component:: 100000 power train
Summary:: Tsb: some 2wd 2005 - 2013 model year tacoma vehicles equipped with an automatic transmission may exhibit a clunk/thunk noise from the rear of the vehicle or a "bump-from-behind" sensation just before a stop or when accelerating from a stop.
Bulletin:: T-SB-0016-13 Rev
Component:: 100000 power train
Summary:: Tsb: some 4wd 2005 - 2013 model year tacoma vehicles equipped with an automatic transmission may exhibit a clunk/thunk noise from the rear of the vehicle or a "bump-from-behind" sensation just before a stop or when accelerating from a stop.
Bulletin:: E0D_LSC_Chicago
Component:: 160000 structure
Summary:: Region letter: condition-? toyota has received reports that certain 2005 through 2008 model year tacoma vehicles operated in specific cold climate areas (cold climate states) with high road salt usage may exhibit more-than-normal corrosion
Bulletin:: E0D_LSC_Chicago
Component:: 160000 structure
Summary:: Dealer letter: condition-? toyota has received reports that certain 2005 through 2008 model year tacoma vehicles operated in specific cold climate areas (cold climate states) with high road salt usage may exhibit more-than-normal corrosion
Bulletin:: FR1_Remail_Regio
Component:: 030000 brakes (pws)
Summary:: Rl: toyota will be sending safety recall follow-up notices to remind owners whose vehicles have not yet had campaign repairs completed. please note the following information for regional and pd associates.
Bulletin:: FR1_Remail_Deale
Component:: 030000 brakes (pws)
Summary:: Dl: safety recall completion is important not only in satisfying government requirements but also as an integral part of our commitment to meet customer expectations of toyota products. toyota will be sending safety recall follow-up notices
Bulletin:: E0D_Dealer Lette
Component:: 160000 structure
Summary:: Dl: condition * toyota has received reports that certain 2005 through 2008 model year tacoma veh
Bulletin:: ESD_Dealer Lette
Component:: 160000 structure
Summary:: Dl: condition * toyota has received reports that certain 2005 through 2008 model year tacoma vehi
Bulletin:: E0D_ESD_LSC_Rent
Component:: 162000 structure:body
Summary:: Ec: rental vehicle opcodes have been updated for limited service campaigns e0d and esd. refer to the updated dealer letter that has been posted to tis.
Bulletin:: T-SB-0043-14 Rev
Component:: 353000 equipment:electrical
Summary:: Tsb: the immobilizer and smart key reset is a feature that allows the registration of new keys when all master keys are lost. once the system is reset, all previously registered keys will be erased. follow the procedures in this bulletin to
Bulletin:: T-SB-0083-13 Rev
Component:: 353600 equipment:air conditioner
Summary:: Tsb: the procedure in this bulletin is a general guideline on how to properly diagnose the air conditioning system after a component failure. refer to the applicable repair manual for vehicle specific repair procedures and parts.
Bulletin:: T-SB-0026-15
Component:: 100000 power train
Summary:: Tsb: some 2004 - 2015 model year tacoma, fj cruiser, and 4runner vehicles may exhibit a cyclical grinding or groaning noise coming from the front differential in 2wd that goes away when operated in 4wd. this noise can be addressed by replac
Bulletin:: T-SB-0057-13 Rev
Component:: 100000 power train
Summary:: Tsb: some 2005 - 2013 model year tacoma vehicles equipped with a 5-speed automatic transmission may exhibit a whine noise from the rear differential between 50 - 60 mph (80 - 97 km/h). use the following repair procedure to address this cond
Bulletin:: T-SB-0101-11 Rev
Component:: 110000 electrical system
Summary:: Tsb: when servicing interior electrical switches and components, please note the precautions in this bulletin to avoid damaging electrical components and switches. many lubricants, cleaners, and automotive chemicals contain silicone or othe
Bulletin:: T-SB-0040-08
Component:: 162000 structure:body
Summary:: Tsb: on some vehicles, when rapgard is removed, the paint may have a stained appearance. these stains appear to be under the clear coat (repainting this area is not necessary). the stain patterns are usually under wrinkles in the rapgard. t
Bulletin:: E0D_Dealer Daily
Component:: 160000 structure
Summary:: Dealer daily: due to limited availability of 05 - 08 tacoma frame activity parts, toyota will be implementing a new ordering process for all future frame and ancillary part orders. beginning january 28th, 2015 it will be mandatory for all d
Bulletin:: E0D_Dealer Daily
Component:: 160000 structure
Summary:: Dealer daily: due to limited availability of 05 - 08 tacoma frame activity parts, toyota will be implementing a new ordering process for all future frame and ancillary part orders. beginning january 28th, 2015 it will be mandatory for all d
Bulletin:: T-SB-0040-08
Component:: 162000 structure:body
Summary:: Tsb: on some vehicles, when rapgard is removed, the paint may have a stained appearance. these stains appear to be under the clear coat (repainting this area is not necessary). the stain patterns are usually under wrinkles in the rapgard. t
Bulletin:: FR1_Remail_Regio
Component:: 030000 brakes (pws)
Summary:: Rl: toyota will be sending safety recall follow-up notices to remind owners whose vehicles have not yet had campaign repairs completed. please note the following information for regional and pd associates.
Bulletin:: FR1_Remail_Deale
Component:: 030000 brakes (pws)
Summary:: Dl: safety recall completion is important not only in satisfying government requirements but also as an integral part of our commitment to meet customer expectations of toyota products. toyota will be sending safety recall follow-up notices
Bulletin:: E0D_Dealer Lette
Component:: 160000 structure
Summary:: Dl: condition * toyota has received reports that certain 2005 through 2008 model year tacoma vehi
Bulletin:: ESD_Dealer Lette
Component:: 160000 structure
Summary:: Dl: condition * toyota has received reports that certain 2005 through 2008 model year tacoma veh
Bulletin:: E0D_ESD_LSC_Rent
Component:: 160000 structure
Summary:: Ec: rental vehicle opcodes have been updated for limited service campaigns e0d and esd. refer to the updated dealer letter that has been posted to tis.
Bulletin:: T-SB-0057-13 Rev
Component:: 100000 power train
Summary:: Tsb: some 2005 - 2013 model year tacoma vehicles equipped with a 5-speed automatic transmission may exhibit a whine noise from the rear differential between 50 - 60 mph (80 - 97 km/h). use the following repair procedure to address this cond
Bulletin:: T-SB-0101-11 Rev
Component:: 110000 electrical system
Summary:: Tsb: when servicing interior electrical switches and components, please note the precautions in this bulletin to avoid damaging electrical components and switches. many lubricants, cleaners, and automotive chemicals contain silicone or othe
Bulletin:: T-SB-0043-14 Rev
Component:: 353000 equipment:electrical
Summary:: Tsb: the immobilizer and smart key reset is a feature that allows the registration of new keys when all master keys are lost. once the system is reset, all previously registered keys will be erased. follow the procedures in this bulletin to
Bulletin:: E0D ESD_Region L
Component:: 160000 structure
Summary:: Rl: toyota will be sending limited service campaign follow-up notices to remind owners whose vehicles have not yet had campaign repairs completed.
Bulletin:: E0D ESD_Dealer L
Component:: 350000 equipment
Summary:: Dl: limited service campaign completion is important and is an integral part of our commitment to meet customer expectations of toyota products. toyota will be sending limited service campaign follow-up notices to remind owners whose vehicl
Bulletin:: T-SB-0083-13 Rev
Component:: 353600 equipment:air conditioner
Summary:: Tsb: the procedure in this bulletin is a general guideline on how to properly diagnose the air conditioning system after a component failure. refer to the applicable repair manual for vehicle specific repair procedures and parts.
Bulletin:: T-SB-0026-15
Component:: 105500 power train:driveline:differential unit
Summary:: Tsb: some 2004 - 2015 model year tacoma, fj cruiser, and 4runner vehicles may exhibit a cyclical grinding or groaning noise coming from the front differential in 2wd that goes away when operated in 4wd. this noise can be addressed by replac
Bulletin:: ZH6_Toyota POL17
Component:: 355200 equipment:other:owners/service/other manual
Summary:: Warranty policy bulletin: toyota has received reports of customer concerns in which the vehicles operated in specific cold climate areas (cold climate states) with high road salt usage may exhibit more-than-normal corrosion with the vehicl
Bulletin:: ZH6_Tacoma_Frame
Component:: 160000 structure
Summary:: Reference guide: asm reference guide for warranty extension program (wep) zh6 - covered components: if frame replacement is needed.
Bulletin:: H0F_Massachusett
Component:: 356000 equipment adaptive
Summary:: Dealer letter: toyota has received a letter dated september 5, 2017 from the massachusetts department of environmental protection (madep), confirming that the h0f campaign is exempt from air permit requirements as long as toyota dealers com
Bulletin:: H0F_Dealer Lette
Component:: 160000 structure
Summary:: Dealer letter: september 7, 2017 tacoma uio (units in operation) has been updated. toyota will initiate a limited service campaign (lsc h0f) to apply corrosion resistant compound to key areas of the vehicle?s frame for the following vehicle
Bulletin:: H0F_ West Virgin
Component:: 355200 equipment:other:owners/service/other manual
Summary:: Dealer letter: toyota has received a letter dated september 8, 2017 from the west virginia department of environmental protection (wvdaq), confirming that the h0f campaign is exempt from air permit requirements as long as toyota dealers com
Bulletin:: H0F_Dealer Lette
Component:: 160000 structure
Summary:: Dealer letter: october 12, 2017 sequoia (zh8 and zh9) frame replacement and crc application now available. toyota will initiate a limited service campaign (lsc h0f) to apply corrosion resistant compound to key areas of the vehicle?s frame f
Bulletin:: ZH7_Region Email
Component:: 160000 structure
Summary:: Region email: ? 2007-2008 (zh7) tundra frame replacement and crc application is now available. on may 21, 2017, a settlement of claims in a class action lawsuit involving 2005 ? 2010 toyota tacoma, 2007-2008 tundra, and 2005-2008 sequoia ve
Bulletin:: ZH7_Dealer Email
Component:: 160000 structure
Summary:: Dealer email: ? 2007-2008 (zh7) tundra frame replacement and crc application is now available. on may 21, 2017, a settlement of claims in a class action lawsuit involving 2005 ? 2010 toyota tacoma, 2007-2008 tundra, and 2005-2008 sequoia ve
Bulletin:: ZH7_Region Lette
Component:: 160000 structure
Summary:: Region letter: october 19,2017 tundra frame replacement (zh7) and crc application is now available. ? added additional op codes for tundra to cover dealer costs of maintaining vehicles while waiting for frames, if applicable. ? added op cod
Bulletin:: H0F_Dealer Lette
Component:: 160000 structure
Summary:: Dealer letter: october 19, 2018 tundra (zh7) frame replacement and crc application is now available. toyota will initiate a limited service campaign (lsc h0f) to apply corrosion resistant compound to key areas of the vehicle?s frame for the
Bulletin:: T-SB-0304-17
Component:: 162300 structure:body:door
Summary:: Tsb: vehicle replacement certification labels (the vinyl label installed on the driver door or door post) and vin plates (the metal plate riveted to dashboard) may be available from toyota, provided the request meets one of the criteria lis
Bulletin:: ZH2_Dealer Daily
Component:: 356000 equipment adaptive
Summary:: Dealer daily message: customer support program zh2 certain 2005 ? 2011 model year tacoma coverage for propeller shaft universal joints ? customer support program zh2 dealer letter now available on tis. refer to the dealer letter on tis for
Bulletin:: ZH2_Region Email
Component:: 013100 steering:gear box:shaft sector
Summary:: Region email: toyota has received a number of reports regarding propeller shaft universal joints on certain 2005 ? 2011 model year tacoma vehicles. in these reports, customers have indicated that there is a drivetrain vibration and/or drive
Bulletin:: ZH2_Dealer Email
Component:: 356000 equipment adaptive
Summary:: Dealer email: toyota has received a number of reports regarding propeller shaft universal joints on certain 2005 ? 2011 model year tacoma vehicles. in these reports, customers have indicated that there is a drivetrain vibration and/or drive
Bulletin:: ZH2_Region Lette
Component:: 106200 power train:axle assembly:axle shaft
Summary:: Region letter: toyota has received a number of reports regarding propeller shaft universal joints on certain 2005 ? 2011 model year tacoma vehicles. in these reports, customers have indicated that there is a drivetrain vibration and/or driv
Bulletin:: ZH2_Dealer Lette
Component:: 106200 power train:axle assembly:axle shaft
Summary:: Dealer letter: toyota has received a number of reports regarding propeller shaft universal joints on certain 2005 ? 2011 model year tacoma vehicles. in these reports, customers have indicated that there is a drivetrain vibration and/or driv
Bulletin:: ZH2_Toyota POL17
Component:: 355200 equipment:other:owners/service/other manual
Summary:: Warranty policy bulletin: toyota has received reports in which customers have indicated that there is a drivetrain vibration and/or drivetrain noise. if the vehicle continues to be driven with the aforementioned condition, there is risk of
Bulletin:: T-SB-0134-16_Rev
Component:: 355200 equipment:other:owners/service/other manual
Summary:: Tsb: revision notice october 30, 2017 rev1: * applicability has been updated to include 2018 model year vehicles. supersession notice the information contained in this bulletin supersedes sb no. t-sb-0012-13. flash reprogramming allows the
Bulletin:: Tacoma CRC_Techn
Component:: 350000 equipment
Summary:: Technical instructions: corrosion-resistant compound campaign h0f certain 2005- 2010 model year tacoma. corrosion-resistant compound application.
Bulletin:: ZH2_Dealer Daily
Component:: 100000 power train
Summary:: Dealer daily message: customer support program zh2 certain 2005 ? 2011 model year tacoma coverage for propeller shaft universal joints ? if the zh2 condition is present for an extended period it can lead to damage of the propeller shaft. ?
Bulletin:: T-SB-0187-12_Rev
Component:: 190000 tires
Summary:: Tsb: revision notice february 12, 2018 rev2: ? applicability has been updated to include 2015 ? 2018 model year vehicles. january 23, 2014 rev1: ? applicability has been updated to include 2013 ? 2014 model year vehicles. any previous print
Bulletin:: ZH6_Tacoma Frame
Component:: 160000 structure
Summary:: Technical instructions: technical instructions for warranty enhancement program zh6. certain 2005 through 2010 model year tacoma. updated 2-15-2018. frame replacement.
Bulletin:: T-SB-0186-12_Rev
Component:: 100000 power train
Summary:: Tsb: revision notice february 21, 2018 rev2: ? applicability has been updated to include 2015 ? 2017 model year tacoma vehicles. ? the parts information and repair procedure sections have been updated. september 10, 2014 rev1: ? applicabili
Bulletin:: ZH6_Brake Line U
Component:: 034200 service brakes, hydraulic:foundation components:hoses, lines/piping, and fittings
Summary:: Dealer daily message: warranty enhancement programs zh6 - certain 2005 ? 2010 model year tacoma vehicles. extension of warranty coverage for frame corrosion. 2005-2008 tacoma frame repair ? brake line update. a brake line used in certain 20
Bulletin:: ZH2_Toyota POL17
Component:: 100000 power train
Summary:: Warranty policy bulletin: toyota has received reports in which customers have indicated that there is a drivetrain vibration and/or drivetrain noise. if the vehicle continues to be driven with the aforementioned condition, there is risk of
Bulletin:: T-SB-0304-17_Rev
Component:: 350000 equipment
Summary:: Tsb: supersession notice the information contained in this bulletin supersedes service bulletin nos. pg021-88, pg015-89, pg0015-90, pg002-91, pg002-93, pg005-97, pg007-01, pg007-07, and t-sb-0144-08. service bulletin nos. pg021-88, pg015-89
Bulletin:: T-SB-0187-12_Rev
Component:: 190000 tires
Summary:: Tsb: revision notice february 12, 2018 rev2: ? applicability has been updated to include 2015 ? 2018 model year vehicles. january 23, 2014 rev1: ? applicability has been updated to include 2013 ? 2014 model year vehicles. any previous print
Bulletin:: T-SB-0129-11 Rev
Component:: 353000 equipment:electrical
Summary:: Some 2005 ? 2011 model year tacoma vehicles may experience a condition where the inner daytime running light (drl)/turn signal lens becomes distorted and bubbled in appearance. in addition, the inner lens may appear cracked or separated. up
Bulletin:: HR1_Region Lette
Component:: 140000 air bags
Summary:: Region letter: toyota will be sending safety recall follow-up notices to remind owners whose vehicles have not yet had campaign repairs completed.
Bulletin:: HR1_Dealer Lette
Component:: 140000 air bags
Summary:: Dealer letter: toyota will be sending safety recall follow-up notices to remind owners whose vehicles have not yet had campaign repairs completed.
Bulletin:: T-SB-0008-14
Component:: 020000 suspension
Summary:: Some 2005 ? 2014 model year tacoma vehicles equipped with automatic transmission may exhibit a vibration felt in the seat, floorboard, and steering wheel between 15 ? 25 mph caused by a second order drivetrain vibration under acceleration.
Bulletin:: T-TT-0132-11
Component:: 030000 service brakes, hydraulic
Summary:: A key part to maintain the proper function and safe operation of the vehicle's braking system is to perform a visual inspection when installing brake pads, calipers, and discs. the following recommendations are intended to provide general
Bulletin:: T-SB-0187-12 Rev
Component:: 190000 tires
Summary:: Toyota vehicles are equipped with either conventional or run-flat tires. sometimes punctures may occur as a result of contact with road debris or other hazards. if a puncture occurs, it may be possible to repair the tire and return it to se
Bulletin:: T-TT-0213-13
Component:: 140000 air bags
Summary:: Toyota vehicles are equipped with supplemental restraint systems (srs), including various airbags and in some models, seat belt pre-tensioners, to help reduce the risk of injury in a collision. if a customer expresses any concerns that the
Bulletin:: T-SB-0141-13
Component:: 050000 parking brake
Summary:: A new special service tool (sst 09709-00002) has been introduced to aid in the inspection procedure for certain vehicles equipped with a floor pedal-type parking brake system. this bulletin references the correct method for installing the b
Bulletin:: T-SB-0185-13
Component:: 130000 visibility
Summary:: The following procedures are recommended during routine maintenance or in the event of a customer concern for wiper performance.
Bulletin:: TS-BO030-01 Obso
Component:: 130000 visibility/wiper (pws)
Summary:: This bulletin is now obsolete. please see t-sb-0185-13.
Bulletin:: T-TT-0124-11
Component:: 190000 tires
Summary:: Please refer to the following recommendations for the best practices for vehicle tire rotations.
Bulletin:: T-SB-0122-11 Rev
Component:: 140000 air bags
Summary:: Beginning in 1998, toyota introduced side airbags as optional equipment. toyota does not recommend replacement of original seat covers with non-toyota leather or other seat cover materials on vehicles due to the following: seat covers not
Bulletin:: T-SB-0071-11 Rev
Component:: 100000 power train
Summary:: The purpose of this service bulletin is to provide precautions to follow when installing an automatic transmission/transaxle assembly to avoid mil ?on,? shifting issues, and/or transmission damage. use the information in this bulletin when
Bulletin:: T-TT-0269-13
Component:: 132000 visibility:glass, side/rear
Summary:: The appearance of spots in tempered glass (when viewed at certain angles) is the result of the heat treating and quick quenching process during manufacturing.
Bulletin:: T-TT-0051-10 Rev
Component:: 353600 equipment:air conditioner
Summary:: If a customer states there is an unpleasant odor in the vehicle from the hvac system, there are various factors that may be involved.
Bulletin:: T-SB-0249-12 Rev
Component:: 980000 unknown or other
Summary:: This bulletin is no longer applicable and is now obsolete.
Bulletin:: T-SB-0141-10 Rev
Component:: 162320 structure:body:door/window:emergency exit
Summary:: If a creak, tick, or rattle noise is heard at the top or bottom of the windshield, or at the top of the rear glass, the source of the noise may be the two stoppers bonded to the top of the windshield/rear glass, or the windshield retainers
Bulletin:: T-SB-0054-13
Component:: 350000 equipment
Summary:: California (ca), federal (fed), and 50 state certified emission control underhood labels (emission labels) may be obtained through your dealership?s parts department utilizing standard replacement parts ordering procedures. follow the guide
Bulletin:: T-SB-0057-13
Component:: 100000 power train
Summary:: Some 2005 ? 2013 model year tacoma vehicles equipped with a 5-speed automatic transmission may exhibit a whine noise from the rear differential between 50 ? 60 mph (80 ? 97 km/h). use the following repair procedure to address this condition
Bulletin:: T-PG006-00 Obsol
Component:: 355100 equipment:other:labels
Summary:: This bulletin is now obsolete. please see t-sb-0054-13.
Bulletin:: ZH6, ZH7, ZH8, Z
Component:: 160000 structure
Summary:: Region letter email: on may 21, 2017, a settlement of claims in a class action lawsuit involving 2005 ? 2010 toyota tacoma, 2007-2008 tundra, and 2005-2008 sequoia vehicles regarding frame corrosion was approved. this finally approved cla
Bulletin:: ZH6, ZH7, ZH8, Z
Component:: 160000 structure
Summary:: Dealer packet email: on may 21, 2017, a settlement of claims in a class action lawsuit involving 2005 ? 2010 toyota tacoma, 2007-2008 tundra, and 2005-2008 sequoia vehicles regarding frame corrosion was approved. this finally approved cla
Bulletin:: ZH6_Dealer Packa
Component:: 160000 structure
Summary:: Dealer package: on may 21, 2017, a settlement of claims in a class action lawsuit involving 2005 ? 2010 toyota tacoma vehicles regarding frame corrosion was approved. this finally approved class action settlement includes inspection of the
Bulletin:: ZH6_Toyota POL17
Component:: 161100 structure: frame and members:underbody shields
Summary:: Warranty policy bulletin: toyota has received reports of customer concerns in which the vehicles operated in specific cold climate areas (cold climate states) with high road salt usage may exhibit more-than-normal corrosion with the vehicle
Bulletin:: TI_Frame Inspect
Component:: 355200 equipment:other:owners/service/other manual
Summary:: Technical instructions for warranty extension program zh6, zh7, zh8, and zh9.
Bulletin:: T-SB-0218-17_Rev
Component:: 140000 air bags
Summary:: Tsb: revision notice july 20, 2017 rev1: applicability has been updated to exclude 2007 ? 2017 model year avanza vehicles. some hazardous material treatment and handling regulations at the state and local level define the pre-disposal deplo
Bulletin:: H0F_CRC_Spray De
Component:: 355200 equipment:other:owners/service/other manual
Summary:: Crc spray application preparation. frame corrosion resistant compound (crc) application. please reference the included crc readiness checklist and faq (frequently asked question). these documents should be used to prepare your dealership fo
Bulletin:: H0F_PA Dealer Le
Component:: 355200 equipment:other:owners/service/other manual
Summary:: Dealer letter: this communication only applies to dealerships located in pennsylvania. as discussed in our august 28, 2017 dealer daily message, dealers in pennsylvania were required to wait to commence crc application for the h0f campaign
Bulletin:: H0F_Dealer Lette
Component:: 160000 structure
Summary:: Dealer letter: the attached dealer letter has been updated. september 29, 2017 rental invoice requirement has been added. ? estimated launch timing has been updated for tundra and sequoia models. september 7, 2017 tacoma uio (units in opera
Bulletin:: ZH6_Dealer Lette
Component:: 161000 structure:frame and members
Summary:: Dealer letter: the attached dealer letter has been updated. september 29, 2017 rental invoice requirement has been added. ? estimated launch timing has been updated for tundra and sequoia models.
Bulletin:: T-TT-0086-11
Component:: 060000 engine (pws)
Summary:: Techtip: condition - the vehicle may be difficult to start or have an abnormally low or rough idle after the battery has been disconnected or power to the engine ecm has been interrupted.
Bulletin:: ESD_Region Lette
Component:: 160000 structure
Summary:: Region letter: in 2014, toyota announced and rolled out a limited service campaign (lsc e0d) for certain 2005-2008 model year toyota tacoma vehicles currently registered in specific cold climate areas with high road salt usage (cold climate
Bulletin:: ESD_Dealer Lette
Component:: 160000 structure
Summary:: Dealer letter: in 2014, toyota announced and rolled out a limited service campaign (lsc e0d) for certain 2005-2008 model year toyota tacoma vehicles currently registered in specific cold climate areas with high road salt usage (cold climate
Bulletin:: ZH6_Toyota POL17
Component:: 160000 structure
Summary:: Warranty policy bulletin: toyota has received reports of customer concerns in which the vehicles operated in specific cold climate areas (cold climate states) with high road salt usage may exhibit more-than-normal corrosion with the vehicle
Bulletin:: ZH8 and ZH9_Regi
Component:: 160000 structure
Summary:: Region email: ? 2005-2007 (zh8) sequoia frame replacement and crc application is now available. ? 2008 (zh9) sequoia frame replacement and crc application is now available. on may 21, 2017, a settlement of claims in a class action lawsuit i
Bulletin:: ZH8 and ZH9_Deal
Component:: 160000 structure
Summary:: Dealer email: ? 2005-2007 (zh8) sequoia frame replacement and crc application is now available. ? 2008 (zh9) sequoia frame replacement and crc application is now available. on may 21, 2017, a settlement of claims in a class action lawsuit i
Bulletin:: ZH8_Region Lette
Component:: 160000 structure
Summary:: Region letter: october 12,2017 sequoia frame replacement (zh8 and zh9) is now available. ? added additional op codes for sequoia to cover dealer costs of maintaining vehicles while waiting for frames, if applicable. specific information for
Bulletin:: ZH6_Toyota POL17
Component:: 160000 structure
Summary:: Warranty policy bulletin: toyota has received reports of customer concerns in which the vehicles operated in specific cold climate areas (cold climate states) with high road salt usage may exhibit more-than-normal corrosion with the vehicle
Bulletin:: T-SB-0302-17
Component:: 100000 power train
Summary:: Tsb: some 2005 ? 2011 model year tacoma vehicles may exhibit a condition where there is a drivetrain vibration and/or drivetrain noise.
Bulletin:: T-SB-0043-14
Component:: 353100 equipment:electrical:anti-theft devices
Summary:: Tsb: the immobilizer and smart key reset is a feature that allows the registration of new keys when all master keys are lost. once the system is reset, all previously registered keys will be erased.
Bulletin:: T-SB-0043-14 Rev
Component:: 353100 equipment:electrical:anti-theft devices
Summary:: Tsb: the immobilizer and smart key reset is a feature that allows the registration of new keys when all master keys are lost. once the system is reset, all previously registered keys will be erased.
Bulletin:: T-SB-0008-14 Rev
Component:: 100000 power train
Summary:: Tsb: some 2005 ? 2014 model year tacoma vehicles equipped with 1gr-fe engine (prerunner and 4wd) and automatic or 6-speed manual transmission may exhibit a vibration felt in the seat, floorboard, and steering wheel between 15 ? 25 mph cause
Bulletin:: T-SB-0016-13 Rev
Component:: 100000 power train
Summary:: Tsb: some 4wd 2005 ? 2013 model year tacoma vehicles equipped with an automatic transmission may exhibit a clunk/thunk noise from the rear of the vehicle or a ?bump-from-behind? sensation just before a stop or when accelerating from a stop.
Bulletin:: T-SB-0250-12 Rev
Component:: 100000 power train
Summary:: Tsb: some 2wd 2005 ? 2013 model year tacoma vehicles equipped with an automatic transmission may exhibit a clunk/thunk noise from the rear of the vehicle or a ?bump-from-behind? sensation just before a stop or when accelerating from a stop.
Bulletin:: T-SB-0037-14
Component:: 350000 equipment
Summary:: Tsb: some 2005 ? 2014 model year tacoma vehicles used in severe off-road service conditions may exhibit a cracked horn mounting bracket. use the procedure in this bulletin to address this condition.
Bulletin:: T-SB-0012-13 Rev
Component:: 118000 electrical system: software
Summary:: Tsb: flash reprogramming allows the ecu software to be updated without replacing the ecu. flash calibration updates for specific vehicle models/ecus are released as field-fix procedures described in individual service bulletins. this bullet
Bulletin:: E0D_LSC_CIN Regi
Component:: 160000 structure
Summary:: Region letter: ? toyota has received reports that certain 2005 through 2008 model year tacoma vehicles operated
Bulletin:: ZTZ_WEP_Region L
Component:: 121000 exterior lighting:headlights
Summary:: Region letter: in our continuing efforts to ensure the best in customer satisfaction, toyota is announcing a warranty enhancement program to extend the warranty coverage for the headlamp assembly on 2005-2011 model year tacoma vehicles. in
Bulletin:: E0D_LSC_CIN Deal
Component:: 160000 structure
Summary:: Dealer letter: ? toyota has received reports that certain 2005 through 2008 model year tacoma veh
Bulletin:: ZTZ_WEP_Dealer L
Component:: 123000 exterior lighting:tail lights
Summary:: Dealer letter: in our continuing efforts to ensure the best in customer satisfaction, toyota is announcing a warranty enhancement program to extend the warranty coverage for the headlamp assembly on 2005-2011 model year tacoma vehicles. in
Bulletin:: T-TT-0010-10 Rev
Component:: 060000 engine (pws)
Summary:: Tech tip: low battery voltage can contribute to a mil "on" condition for p0335 (crankshaft position
Bulletin:: LSC E0D - CAT Re
Component:: 160000 structure
Summary:: Region letter: ? toyota has received reports that certain 2005 through 2008 model year tacoma vehicles
Bulletin:: ER5_Remail_Regio
Component:: 140000 air bags
Summary:: Region letter: toyota will be sending safety recall follow-up notices to remind owners whose vehicles have n
Bulletin:: LSC E0D - CAT De
Component:: 160000 structure
Summary:: Dealer letter: * toyota has received reports that certain 2005 through 2008 model year tacoma vehicles o
Bulletin:: ER5_Remail_Deale
Component:: 140000 air bags
Summary:: Dealer letter: toyota will be sending safety recall follow-up notices to remind owners whose vehicles have not yet
Bulletin:: T-SB-0012-13 Rev
Component:: 118000 electrical system: software
Summary:: Tsb: obsolete notice: september 14, 2016: this bulletin is now obsolete. please see t-sb-0134-16.
Bulletin:: ZH6_Dealer Daily
Component:: 030000 service brakes, hydraulic
Summary:: Dealer daily message: updated dealer daily - do not use brake lines with white mark warranty enhancement programs zh6 - certain 2005 ? 2010 model year tacoma vehicles extension of warranty coverage for frame corrosion. a brake line used in
Bulletin:: ZH6_05-10_Tacoma
Component:: 160000 structure
Summary:: Technical instructions: update 3-1-18 - frame part numbers corrected. technical instructions for warranty enhancement program zh6. certain 2005 through 2010 model year tacoma. frame replacement.
Bulletin:: ZH6_Dealer Packe
Component:: 160000 structure
Summary:: Dealer letter: march 2, 2018. rental sublet period added for use during repair. ? primary coverage expiration date changed. ? ancillary parts coverage section added. warranty enhancement program zh6 certain 2005 ? 2010 model year tacoma e
Bulletin:: ZH6_Toyota POL17
Component:: 160000 structure
Summary:: Warranty policy bulletin: toyota has received reports of customer concerns in which the vehicles operated in specific cold climate areas (cold climate states) with high road salt usage may exhibit more-than-normal corrosion with the vehicle
Bulletin:: T-SB-0144-08_Obs
Component:: 350000 equipment
Summary:: Tsb: obsolete notice november 21, 2017: this bulletin is now obsolete. please see t-sb-0304-17.
Bulletin:: T-SB-0229-12_Rev
Component:: 110000 electrical system
Summary:: Tsb: revision notice november 22, 2017 rev1: ? applicability has been updated to include 2014 ? 2018 model year vehicles. any previous printed versions of this bulletin should be discarded. in the event that a toyota vehicle becomes submerg
Bulletin:: T-SB-0066-11 Rev
Component:: 100000 power train
Summary:: Some 2005 ? 2013 model year tacoma vehicles equipped with a 5-speed manual transmission may exhibit a slipping feeling in all forward gears and reverse. replacement of the clutch disk, clutch cover, flywheel, and clutch pedal turnover sprin
Bulletin:: T-SB-0249-12 Rev
Component:: 020000 suspension
Summary:: Some vehicles may exhibit a vibration felt in the seat, floorboard, and/or steering wheel around 15-25 mph caused by a second order driveline vibration. use the following procedure to address the condition.
Bulletin:: Renotification (
Component:: 355200 equipment:other:owners/service/other manual
Summary:: Toyota will be sending safety recall follow up notices to remind owners whose vehicles have not yet had campaign repair completed. please note the following information for regional and pd associates.
Bulletin:: Renotification (
Component:: 355200 equipment:other:owners/service/other manual
Summary:: Toyota will be sending safety recall follow up notices to remind owners whose vehicles have not yet had campaign repair completed. please note the following information for regional and pd associates.
Bulletin:: T-SB-0016-13
Component:: 103000 power train:automatic transmission
Summary:: Some 4wd 2005 ? 2012 model year tacoma vehicles equipped with an automatic transmission may exhibit a clunk/thunk noise from the rear of the vehicle or a ?bump-from-behind? sensation just before a stop or when accelerating from a stop. impr
Bulletin:: T-SB-0391-08 Rev
Component:: 100000 power train
Summary:: This bulletin contains general vehicle pulling diagnosis and repair procedures along with specific information to help correct pulling complaints.
Bulletin:: T-TT-0226-13
Component:: 110000 electrical system
Summary:: The customer is having difficulty changing the multi-display screen from day mode. if the multi-display screen is set to day mode when the headlights are on, the setting we be memorized when the engine is turned off.
Bulletin:: SST Requirements
Component:: 355200 equipment:other:owners/service/other manual
Summary:: Ssts are key elements to provide your customers with swift and accurate repairs resulting in superior customer satisfaction.
Bulletin:: T-SB-0064-10 Rev
Component:: 118000 electrical system: software
Summary:: Flash reprogramming allows the ecu software to be updated without replacing the ecu. flash calibration updates for specific vehicle models/ecus are released as field-fix procedures described in individual service bulletins. this bulletin de
Bulletin:: T-SB-0012-13
Component:: 118000 electrical system: software
Summary:: Flash reprogramming allows the ecu software to be updated without replacing the ecu. flash calibration updates for specific vehicle models/ecus are released as field-fix procedures described in individual service bulletins. this bulletin de
Bulletin:: T-SB-0064-10 Rev
Component:: 355200 equipment:other:owners/service/other manual
Summary:: This bulletin is now obsolete. please see t-sb-0012-13.
Bulletin:: T-TT-0213-13
Component:: 140000 air bags
Summary:: Toyota vehicles are equipped with srs, including various airbags and in some models, seat belt pre-tensioners, to help reduce the risk of injury in a collision. if a customer expresses any concerns that the srs airbags or pretensioner devi
Bulletin:: T-SB-0249-12
Component:: 011000 steering:wheel and handle bar
Summary:: Some vehicles may exhibit a vibration felt in the seat, floorboard, and/or steering wheel around 15-25 mph caused by a second order driveline vibration. use the following procedure to address this condition.
Bulletin:: T-SB-0250-12
Component:: 100000 power train
Summary:: Some 2wd 2005 ? 2013 model year tacoma vehicles equipped with an automatic transmission may exhibit a clunk/thunk noise from the rear of the vehicle or a ?bump-from-behind? sensation just before a stop or when accelerating from a stop. impr
Bulletin:: T-SB-0132-08 Obs
Component:: 355200 equipment:other:owners/service/other manual
Summary:: This bulletin is now obsolete. please see t-sb-0249-12 .
Bulletin:: T-SB-0186-12
Component:: 101100 power train:clutch assembly:pedal/linkage
Summary:: Some 2005 ? 2012 model year tacoma vehicles may exhibit a squeak or creak noise from the clutch pedal when it is depressed or released. changes have been made to the clutch pedal and clutch master cylinder assembly to address this condition
Bulletin:: T-SB-0187-12
Component:: 162000 structure:body
Summary:: Toyota vehicles are equipped with either conventional or run-flat tires. sometimes punctures may occur as a result of contact with road debris or other hazards. if a puncture occurs, it may be possible to repair the tire and return it to se
Bulletin:: TSB-0012-13 Rev2
Component:: 060000 engine (pws)
Summary:: Tsb: flash reprogramming allows the ecu software to be updated without replacing the ecu. flash calibration updates for specific vehicle models/ecus are released as field-fix procedures described in individual service bulletins. this bull
Bulletin:: T-TT-0381-16
Component:: 118000 electrical system: software
Summary:: Tech tip: some customers may experience difficulty programming homelink.
Bulletin:: TC-16-001
Component:: 151000 seat belts:front
Summary:: Region letter: toyota will be sending safety recall follow-up notices to remind owners whose vehicles have not yet had campaign repairs completed. please note the following information for regional and pd associates.
Bulletin:: GR1_Dealer Lette
Component:: 151000 seat belts:front
Summary:: Dealer letter: safety recall completion is important not only in satisfying government requirements, but also is an integral part of our commitment to meet customer expectations of toyota products. toyota will be sending safety recall follo
Bulletin:: TC-15-009
Component:: 160000 structure
Summary:: Region letter: in 2014, toyota announced and rolled out a limited service campaign (lsc e0d) for certain 2005-2008 model year toyota tacoma vehicles currently registered in specific cold climate areas with high road salt usage (cold climate
Bulletin:: ESD_Dealer Lette
Component:: 160000 structure
Summary:: Dealer letter: in 2014, toyota announced and rolled out a limited service campaign (lsc e0d) for certain 2005-2008 model year toyota tacoma vehicles currently registered in specific cold climate areas with high road salt usage (cold climate
Bulletin:: T-TT-0362-15
Component:: 060000 engine (pws)
Summary:: Tt: the vehicle may be difficult to start or have an abnormally low or rough idle after the battery has been disconnected or power to the engine ecm has been interrupted.
Bulletin:: E0D_Region Notic
Component:: 355200 equipment:other:owners/service/other manual
Summary:: Region notice: due to the expiration of lsc e0d, on april 1, 2016 all vins were marked expired in tis. as a result claims submitted after this date will automatically be placed in ?not approved? status in the cps warranty system.
Bulletin:: ESD_Region Notic
Component:: 355200 equipment:other:owners/service/other manual
Summary:: Region notice: due to the expiration of lsc esd, on april 1, 2016 all vins were marked expired in tis. as a result claims submitted after this date will automatically be placed in ?not approved? status in the cps warranty system.
Bulletin:: E0D ESD_Dealer D
Component:: 160000 structure
Summary:: Dealer letter: frame replacement customer vehicles that qualify for frame replacement under e0d/esd must have their vehicle inspected on or before march 31, 2016. frame and ancillary parts orders must be submitted no later than tuesday, ap
Bulletin:: E0D ESD_Quick Re
Component:: 160000 structure
Summary:: Quick reference guide: frame replacement all frames must be inspected on or before march 31, 2016 in order to qualify for frame replacement. vehicles inspected after this date will not be covered under the limited service campaign. crc ap
Bulletin:: E0D ESD_Dealer D
Component:: 160000 structure
Summary:: Dealer letter: frame replacement customer vehicles that qualify for frame replacement under e0d/esd must have their vehicle inspected on or before march 31, 2016. frame and ancillary parts orders must be submitted no later than tuesday, ap
Bulletin:: E0D ESD_Dealer D
Component:: 160000 structure
Summary:: Dealer daily: the dealer letter has been updated to include details of the frame registration and credit program that has been added to limited service campaigns e0d and esd.
Bulletin:: E0D ESD_Dealer D
Component:: 160000 structure
Summary:: Dealer daily: ? toyota has received reports that certain 2005 through 2008 model year tacoma vehicles operated in specific cold climate areas (cold climate states) with high road salt usage may exhibit more-than-normal corrosion to the vehi
Bulletin:: E0D_Dealer Lette
Component:: 160000 structure
Summary:: Dealer letter: the dealer letter has been updated to include details of the frame registration and credit program that has been added to limited service campaigns e0d and esd.
Bulletin:: ESD_Dealer Lette
Component:: 160000 structure
Summary:: Dealer daily: ? toyota has received reports that certain 2005 through 2008 model year tacoma vehicles operated in specific cold climate areas (cold climate states) with high road salt usage may exhibit more-than-normal corrosion to the vehi
Bulletin:: T-TT-0086-11
Component:: 100000 power train
Summary:: Techtip: condition - the vehicle may be difficult to start or have an abnormally low or rough idle after the battery has been disconnected or power to the engine ecm has been interrupted.
Bulletin:: H0F Dealer Lette
Component:: 355200 equipment:other:owners/service/other manual
Summary:: Dealer letter: december 14, 2017. ? technician certification requirements updated. ? instructions added for crc spray gun/parts replacement requests.
Bulletin:: ZH6_Toyota POL17
Component:: 160000 structure
Summary:: Warranty policy bulletin: toyota has received reports of customer concerns in which the vehicles operated in specific cold climate areas (cold climate states) with high road salt usage may exhibit more-than-normal corrosion with the vehicle
Bulletin:: ZH6, ZH7, ZH8, Z
Component:: 160000 structure
Summary:: Dealer daily message: frame programs. extension of warranty coverage for frame corrosion/frame replacement. frame ordering/repair/administration updates mis-built. for frames that are suspected to have been mis-built, dealers should: 1. co
Bulletin:: T-SB-0040-18
Component:: 162200 structure:body:bumpers
Summary:: Tsb: referencing this service bulletin provides best practice procedures when reassembling and installing the front shock absorber with coil spring. some 2005 - 2015 model year tacoma vehicles with applicable vds have a different coil sprin
Bulletin:: ZH2_Dealer Daily
Component:: 350000 equipment
Summary:: Dealer daily message: certain u-joint kits (campaign part # 04007-13204) used in customer support program zh2 may have been produced without the appropriate amount of grease. these parts should not be installed on vehicles. previously we re
Bulletin:: T-SB-0026-15_Rev
Component:: 100000 power train
Summary:: Tsb: revision notice june 8, 2018 rev2: ? applicability has been updated to exclude 2016 ? 2017 model year tacoma vehicles. ? the repair procedure section has been updated. may 15, 2017 rev1: ? applicability has been updated to include 201
Bulletin:: Toyota PRO18-03_
Component:: 350000 equipment
Summary:: Mis-built for frames that are suspected to have been mis-built, dealers should: 1. contact the parts technical support group (ptsg) at prasupport@toyota.com with information on the condition and status of repair. a. include the original par
Bulletin:: ZH2_Toyota POL17
Component:: 100000 power train
Summary:: Warranty policy bulletin: toyota has received reports in which customers have indicated that there is a drivetrain vibration and/or drivetrain noise. if the vehicle continues to be driven with the aforementioned condition, there is risk of
Bulletin:: T-SB-0057-18
Component:: 350000 equipment
Summary:: Tsb: supersession notice the information contained in this bulletin supersedes service bulletin no. t-sb-0043-14. ? applicability has been updated to include 2017 ? 2018 model year toyota vehicles. service bulletin no. t-sb-0043-14 is obso
Bulletin:: T-SB-0304-17_Rev
Component:: 350000 equipment
Summary:: Tsb: revision notice july 31, 2018 rev2: ? the supersession notice has been updated. january 11, 2018 rev1: ? the supersession notice has been updated. any previous printed versions of this bulletin should be discarded. supersession notice
Bulletin:: PG004-97-Obsolet
Component:: 350000 equipment
Summary:: Technical service bulletin: obsolete notice: july 31, 2018: this bulletin is now obsolete. please see t-sb-0304-17.
Bulletin:: PG006-01-Obsolet
Component:: 350000 equipment
Summary:: Technical service bulletin: obsolete notice: july 31, 2018: this bulletin is now obsolete. please see t-sb-0304-17.
Bulletin:: Safety Recall an
Component:: 350000 equipment
Summary:: Update on technician certification requirements.
Bulletin:: Frame Campaign W
Component:: 160000 structure
Summary:: Dealer daily message: frame warranty claim submission the information below should be referenced to ensure correct warranty claim submissions for frame replacement or spray campaigns (zh6-9 and h0f). key points ? do not perform campaign h0f
Bulletin:: H0F-Dealer Packa
Component:: 160000 structure
Summary:: Dealer package: june 25, 2018 added warranty claim submission flowchart. see appendix a. toyota will initiate a limited service campaign (lsc h0f) to apply corrosion resistant compound to key areas of the vehicle?s frame for the following v
Bulletin:: ZH6-Toyota POL17
Component:: 160000 structure
Summary:: Warranty policy bulletin: toyota has received reports of customer concerns in which the vehicles operated in specific cold climate areas (cold climate states) with high road salt usage may exhibit more-than-normal corrosion with the vehicle
Bulletin:: T-SB-0302-17-Rev
Component:: 100000 power train
Summary:: Tsb: revision notice june 27, 2018 rev2: ? the production change information and the parts information sections have been updated. march 14, 2018 rev1: ? the production change information and repair procedure sections have been updated. any
Bulletin:: HOF Dealer Lette
Component:: 161000 structure:frame and members
Summary:: Dealer letter: december 14, 2017. technician certification requirements updated. instructions added for crc spray gun/parts replacement requests.
Bulletin:: ZH2-Toyota POL17
Component:: 105000 power train:driveline
Summary:: Warranty policy bulletin: toyota has received reports in which customers have indicated that there is a drivetrain vibration and/or drivetrain noise. if the vehicle continues to be driven with the aforementioned condition, there is risk of

Home | Privacy