2007 MERCURY MOUNTAINEER Recall
- Campaign:
- 07E104000 on 12/10/2007
- Component:
- Visibility:glass, side/rear
- Affected:
- 1,657
- Defect:
- Certain curved tempered replacement glass manufactured by hangzhou safety glass ltd and supplied to safelite by auto temp inc., identified as dot-430, and sold for use on certain domestic and foreign vehicles may not break into small pieces as expected of tempered glass and fails to conform to federal motor vehicle safety standard no. 205, "glazing materials."
- Consequence:
- In the event of a vehicle crash, the occupant(s) may be seriously injured by shattered glass.
- Correction:
- Safelite will notify its retail customers and replace the glass free of charge. retail customers can contact safelite toll free at 1-888-843-2906. safelite will notify its wholesale customers and reimburse wholesale customers for current inventory and at a specified rate for replacing their customer's glass. wholesale customers can contact safelite's wholesale division, service autoglass toll free at 1-888-246-6298. the recall began on january 15, 2008.
- Notes:
- This recall only pertains to certain curved tempered replacement glass manufactured by hangzhou safety glass, ltd. (dot-430) and supplied to safelite by auto temp inc., and has no relation to any original equipment installed on the vehicles listed above. customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.
2007 MERCURY MOUNTAINEER TSBs (18)
- Bulletin:
- 061710
- Component:
- 117000 digital instrument panel
- Summary:
- Mil on with p0463 or erratic fuel gauge operation. *kb
- Bulletin:
- 061713
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Calibration update 4.0l - various symptoms - surge, hesitation, torque converter cycling, no up shift after forced downshift, and poor a/c performance. *kb
- Bulletin:
- 06167
- Component:
- 091200 fuel system, other:storage:fuel gauge system
- Summary:
- Mil on with dtc p0463 or erratic fuel gauge operation. *kb
- Bulletin:
- 0728
- Component:
- 103000 power train:automatic transmission
- Summary:
- Overheat indication and shift quality improvements - calibration update release - 4.6l 3v with 6r60 transmission equipped vehicles only. *kb
- Bulletin:
- 0782
- Component:
- 138110 visibility:defroster/defogger system:windshield:blower
- Summary:
- Thumping/loud flutter - behind dash in defrost mode - lack of airflow to floor - manual a/c. *kb
- Bulletin:
- 062414
- Component:
- 012000 steering:column
- Summary:
- Lower steering column shaft pop/clunk noise. *kb
- Bulletin:
- 19865
- Component:
- 103100 power train:automatic transmission:control module (tcm, pcm)
- Summary:
- Multiple vehicle lines - intermittent pcm, fuel pump, ign, coil, a/c, abs or fog lamp operation. *nj
- Bulletin:
- 07253
- Component:
- 072200 fuel system, gasoline:delivery:hoses, lines/piping, and fittings
- Summary:
- Fuel fill--slow or early shut off--built before 11/28/2007. *nj
- Bulletin:
- 08-2-8
- Component:
- 036000 service brakes, hydraulic:antilock
- Summary:
- Improved brake pedal feel and firmness. *nj
- Bulletin:
- 20144
- Component:
- 103100 power train:automatic transmission:control module (tcm, pcm)
- Summary:
- Multiple vehicle lines - intermittent pcm, fuel pump, ign. coil, a/c, abs or fog lamp operation. *nj
- Bulletin:
- TSB-08-9-5
- Component:
- 103100 power train:automatic transmission:control module (tcm, pcm)
- Summary:
- Ford/mercury: 4.0l/4.6l hard start/rough running; after long hot soak/dip in rpm when coming to a stop; built on or before 4/2/08. may exhibit a dip in rpm below normal idle level of 600 rpm on deceleration. *pe
- Bulletin:
- TSB-08-19-3
- Component:
- 106200 power train:axle assembly:axle shaft
- Summary:
- Ford: some vehicles may exhibit oil separation from the internal lube found in the unitized cartridge seal. oil separation appears to be and is often misdiagnosed, as an axle lube leak. *pe
- Bulletin:
- TSB-08-18-2
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Ford/mercury/lincoln: vehicles may exhibit one or more of the following symptoms: drive away hesitation, loss of rpm on deceleration, difficulty starting, and/or idle rpm less than desired. the f53 motorhome chassis is included. *
- Bulletin:
- SI-20005
- Component:
- 102000 power train:manual transmission
- Summary:
- Ford/mercury: some vehicles equipped with 6r60 transmissions may exhibit various transmission performance issues. when compared to other transmissions, some of the shift characteristics are different than previous models due to the 100% s
- Bulletin:
- TSB-12-7-4
- Component:
- 060000 engine (pws)
- Summary:
- Ford/lincoln/mercury: if battery was disconnected or dead, vehicles/trucks may experience hard starts and engine idle rpm fluctuation and exhibit diagnostic trouble codes (dtcs) p0505, p0506, p2111 and p2112. *pe
- Bulletin:
- ASI-44429
- Component:
- 036500 service brakes, hydraulic:antilock:wheel speed sensor
- Summary:
- Ford/mercury: to prevent harness damage, on some vehicles, resulting in contact with tire or suspension components, proper routing of wiring harness for wheel speed sensor is key. 2006-2010 explorer, mountaineer, explorer sport trac.
- Bulletin:
- SSM 46085
- Component:
- 060000 engine (pws)
- Summary:
- The powertrain control/emissions diagnosis (pc/ed) manual has been revised for diagnosing electronic throttle bodies (etbs). the etc_act and etc_dsd pids should not used to diagnose possible etb concerns. the ids has a limited refresh rate
- Bulletin:
- SSM 47331
- Component:
- 060000 engine (pws)
- Summary:
- Various vehicles equipped with a 4.6l, 5.4l, 6.8l modular 3 valve engine built on or before 8-jan-2016 may exhibit symptoms that may include upper end engine noise, rough running, misfire and/or engine damage. if diagnosis leads to only cam
Home | Privacy