2007 MAZDA CX-7 Recalls (4)

Campaign:
09E011000 on 04/02/2009
Component:
Equipment
Affected:
2,323
Defect:
Thule, inc. is recalling 2,323 owner-installed roof-mounted fit kits, models 3068 and 3069, manufactured between january 1, 2008 and february 28, 2009 that are used with thule podium foot packs, models 460 and 460r. these fit kits were sold as aftermarket equipment for use on the vehicles listed above. the bolt(s) used to secure the foot to the vehicle was manufactured to a hardness that may cause the bolt(s) to be brittle and potentially break under stress.
Consequence:
This may result in the bolt(s) snapping off during use or without a load. the unsecured rack and load can then come loose while driving creating a potential road hazard, possibly resulting in a vehicle crash.
Correction:
Thule will mail a retro fit kit along with repair instructions to owners free of charge. the safety recall is expected to begin on or before april 13, 2009. owners may contact thule toll-free at 1-800-238-2388.
Notes:
This recall only pertains to thule aftermarket roof mounted load carriers and has no relation to any original equipment installed on the listed passenger vehicles.owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to <a href=http://www.safercar.gov>http://www.safercar.gov</a> .
Campaign:
16V593000 on 08/10/2016
Component:
Suspension:front:control arm:lower ball joint
Manufactured:
02/13/2006 - 05/08/2012
Affected:
190,102
Defect:
Mazda north american operations (mazda) is recalling certain model year 2007-2012 mazda cx-7 vehicles manufactured february 14, 2006, to may 9, 2012. in the affected vehicles, water may enter the front suspension ball joint fittings. if the water is contaminated with salt, such as from driving on snowy roads that have been treated, the ball joint may corrode and separate from the lower control arm, resulting in a loss of steering control.
Consequence:
A loss of steering control can increase the risk of a crash.
Correction:
Mazda will notify owners, and dealers will replace both front lower control arms, free of charge. as a priority, mazda will first address all affected 2007-2008 vehicles as well as 2009-2011 vehicles currently registered in connecticut, delaware, illinois, indiana, iowa, kentucky, maine, maryland, massachusetts, michigan, minnesota, missouri, new hampshire, new jersey, new york, ohio, pennsylvania, rhode island, vermont, virginia. west virginia, wisconsin, and the district of columbia. the remaining vehicles will be addressed as parts are available. the recall began september 20, 2017. owners may contact mazda customer service at 1-800-222-5500. mazda's number for this recall is 9716h.
Notes:
Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.
Campaign:
17V429000 on 07/09/2017
Component:
Air bags:passenger side frontal
Manufactured:
02/13/2006 - 10/19/2011
Affected:
205,377
Defect:
Mazda north america operations (mazda) is recalling certain 2009-2011 mazda6, and 2007-2011 cx-7 and cx-9 vehicles. these vehicles are equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules, and used as original equipment or replacement equipment. in the event of a crash necessitating deployment of the front air bags, these inflators may rupture due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling.
Consequence:
An inflator rupture may result in metal fragments striking the vehicle occupants resulting in serious injury or death.
Correction:
Mazda will notify owners, and dealers will replace the passenger frontal air bag inflator with an alternate inflator, free of charge. the recall began on august 30, 2017. owners may contact mazda customer service at 1-800-222-5500. mazda's number for this recall is 1317f. note: this recall supersedes recall 16v356 and all vehicles that were not remedied under that campaign are now covered by this one.
Notes:
Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.
Campaign:
17V457000 on 07/20/2017
Component:
Air bags:passenger side frontal
Manufactured:
02/13/2006 - 01/05/2009
Affected:
79,402
Defect:
Mazda north america operations (mazda) is recalling certain 2012 cx-7, cx-9 and mazda6 vehicles sold, or ever registered, in the states of alabama, california, florida, georgia, hawaii, louisiana, mississippi, south carolina, texas, puerto rico, american samoa, guam, the northern mariana islands (saipan), and the u.s. virgin islands, or "zone a." additionally, unless included in "zone a" above, mazda is recalling certain 2009 cx-7, cx-9 and mazda6 vehicles sold, or ever registered in the states of arizona, arkansas, delaware, district of columbia, illinois, indiana, kansas, kentucky, maryland, missouri, nebraska, nevada, new jersey, new mexico, north carolina, ohio, oklahoma, pennsylvania, tennessee, virginia, and west virginia, or "zone b." additionally, unless included in "zone a" or "zone b" above, mazda is recalling certain 2007-2008 cx-7 and cx-9 sold, or ever registered in the states of alaska, colorado, connecticut, idaho, iowa, maine, massachusetts, michigan, minnesota, montana, new hampshire, new york, north dakota, oregon, rhode island, south dakota, utah, vermont, washington, wisconsin, and wyoming. these vehicles are equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules used as original equipment or replacement equipment. in the event of a crash necessitating deployment of the passenger frontal air bag, these inflators may rupture due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling.
Consequence:
An inflator rupture may result in metal fragments striking the vehicle occupants resulting in serious injury or death.
Correction:
Mazda will notify owners, and dealers will replace the front passenger side air bag inflator with an alternate inflator, free of charge. the recall began october 4, 2017. owners may contact mazda customer service at 1-800-222-5500. mazda's number for this recall is 1317f. note: this recall supersedes recall 17v-012.
Notes:
Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.

2007 MAZDA CX-7 TSBs (144)

Bulletin:
0102006
Component:
110000 electrical system
Summary:
Mil illumination with dtc p0463 or dtc b1202 with no illumination. *kb
Bulletin:
0105306
Component:
061000 engine and engine cooling:engine
Summary:
Lack of power or hesitation on acceleration under 2,000 rpm. *kb
Bulletin:
0800306
Component:
140000 air bags
Summary:
Non genuine accessories affect air bag operation. *kb
Bulletin:
0100107
Component:
117000 digital instrument panel
Summary:
Mil illumination with dtc p0455. *kb
Bulletin:
0101007
Component:
061000 engine and engine cooling:engine
Summary:
Mil comes on with dtc p2006 (variable swirl control system shutter valve stuck closed). *kb
Bulletin:
70
Component:
050000 parking brake
Summary:
Parking brake pedal. *kb
Bulletin:
00307
Component:
980000 unknown or other
Summary:
Availability of non-required tools. *kb
Bulletin:
09012007
Component:
114200 electrical system:wiring:interior/under dash
Summary:
Mil illumination (dtc p2006) voluntary emission recall campaign 4807h and obd-ii compliance voluntary emission recall campaign 4907h. *nj
Bulletin:
0102206
Component:
021000 suspension:front
Summary:
Front crankshaft bolt service warning. *nj
Bulletin:
05-004/08
Component:
103100 power train:automatic transmission:control module (tcm, pcm)
Summary:
Sudden reduction of power at highway speeds in extremely cold ambient temperatures. *nj
Bulletin:
01-022-08
Component:
103100 power train:automatic transmission:control module (tcm, pcm)
Summary:
Rough idle, lack of power, and/or mil on with dtc p2177/p2187 (fuel system lean). *nj
Bulletin:
03-003/08
Component:
104000 power train:transfer case (4-wheel drive)
Summary:
Gear oil dripping from transfer case oil seal. 4wd vehicles with vin's lower than jm3er*9****188196 (produced before oct. 1, 2007). *nj
Bulletin:
01-022/08
Component:
103100 power train:automatic transmission:control module (tcm, pcm)
Summary:
Rough idle, lack of power, and/or mil on with dtc p2177/p2187 (fuel system lean). *nj
Bulletin:
05-008-08
Component:
061000 engine and engine cooling:engine
Summary:
Reduction in power when climbing a steep hill.. vehicles with vins lower than jm3 er**** ** 215746 and jm3 tb**** **159178. *pe
Bulletin:
08-003-08
Component:
140000 air bags
Summary:
Airbag warning light on - b1342, b2477 and/or c1946 set. vehicles with vins lower than jm3 tb**** **132479. *pe
Bulletin:
TSB-01-046-08
Component:
110000 electrical system
Summary:
Mazda: remote start causes hvac1 or ign1 fuse to blow; install load reduction relay service harness. *pe
Bulletin:
05-003-09
Component:
103000 power train:automatic transmission
Summary:
Mazda:some vehicles may experience a sudden reduction of power after being driven continuously in extremely cold ambient temperatures for long periods of time without a key off cycle. *pe
Bulletin:
SB-01-007-09
Component:
061000 engine and engine cooling:engine
Summary:
Mazda: vehicles may exhibit a concern of unstable idling or, in some rare cases, stalling, just after the vehicle stops with no dtcs detected. problem is due to the accumulation of carbon deposits inside the throttle body causing air flow
Bulletin:
REC-4907H
Component:
063100 engine and engine cooling:exhaust system:emission control
Summary:
Mazda service campaign: see document search button for owner letter. an emission recall campaigns on certain vehicles to address a malfunction indicator lamp illumination concern and a malfunction with the on board diagnostic adaptive feed
Bulletin:
SB-01-041-09
Component:
071110 fuel system, gasoline:storage:tank assembly:filler pipe and cap
Summary:
Mazda: it is possible that a malfunction indicator light may illuminate with dtc p0455 (evap system leak detected large leak) stored in memory, due to poor sealing between the fuel filler pipe and fuel filler cap. *pe
Bulletin:
SB-09-077-09
Component:
115000 electrical system:fuses and circuit breakers
Summary:
Mazda: power window fuse blown. when operating the power windows, if all power window switches are repeatedly kept on for several seconds after all (four) door glasses are opened or closed, some vehicles my experience power window fuse bl
Bulletin:
SB-01-024-10
Component:
061000 engine and engine cooling:engine
Summary:
Mazda: mil illumination with dtc p2119 stored in memory whenthe engine is started, then it shifts into limp home mode and the engine output decreases. throttle actuator control throttle body range/performance problem. *pe updated 10/
Bulletin:
SB-01-023-10
Component:
071110 fuel system, gasoline:storage:tank assembly:filler pipe and cap
Summary:
Mazda: determining evaporative system leak location for dtcs p0441, p0442, p0455, p0455. some vehicles may have a mil illumination with dtcs stored in memory. *pe updated 4/18/11. *pe
Bulletin:
SB-01-034-10
Component:
061000 engine and engine cooling:engine
Summary:
Mazda: throttle body replacement procedure change. procedure for replacing a throttle body and/or throttle body gasket has been revised. the on line workshop manual (ms3) will be revised accordingly. *pe
Bulletin:
SB-01-028-10
Component:
061000 engine and engine cooling:engine
Summary:
Mazda: variable valve timing (vvt) noise when starting engine. when engine is first started, some vehicles may exhibit a loud ticking noise from the variable valve timing (vvt) (a). this is caused by the lock pin of the variable valve tim
Bulletin:
08-003/11
Component:
117000 digital instrument panel
Summary:
Mazda: passenger air bag deactivation light illumination concerns. *rm
Bulletin:
09-010/11
Component:
121000 exterior lighting:headlights
Summary:
Mazda: some vehicles may have a low beam headlight malfunction. moisture may get into the unit and cause it to short. *rm
Bulletin:
SB-09-057-10
Component:
120000 exterior lighting
Summary:
Mazda: there is condensation and fog in the front and rear combination lights. *rm
Bulletin:
09-005-11
Component:
121000 exterior lighting:headlights
Summary:
Mazda: there is possible excessive condensation or water inside the headlamp unit on many mazda models. *rm
Bulletin:
SB-01-001-11
Component:
063200 engine and engine cooling:exhaust system:manifold/header/muffler/tail pipe
Summary:
Mazda: 2006-2007 mazda speed6. during long periods of slow speed or idling there may be white/blue smoke coming from the tailpipe. there could be problem with the turbocharger. *rm
Bulletin:
SB-01-002-11
Component:
063200 engine and engine cooling:exhaust system:manifold/header/muffler/tail pipe
Summary:
Mazda: while driving at low speeds or having a long idle there is white/blue smoke from the exhaust pipe. this could be caused by oil problems. *rm
Bulletin:
SB-01-018-11
Component:
061000 engine and engine cooling:engine
Summary:
Mazda: there is a rattle noise from the engine due to a stretched timing chain. *rm updated 4/18/2012. *kb
Bulletin:
SB-01-021-11
Component:
092100 fuel system, other:delivery:fuel pump
Summary:
Mazda: fuel pump or pressure line pipe installation/removal information. *rm
Bulletin:
SB-02-001-12
Component:
199000 tires:pressure monitoring and regulating systems
Summary:
Mazda: tpms warning light illumindated. this may be caused by damage to the valve nut and/or valve stem of the wheel. *kb
Bulletin:
SSP-86
Component:
063000 engine and engine cooling:exhaust system
Summary:
Mazda: see document search button for owner letter. due to insufficient crank case ventilation, heavy white smoke appears from exhaust pipes, after long idle periods, resulting in oil leakage past exhaust turgine shaft seal. *pe
Bulletin:
SSP-87
Component:
061000 engine and engine cooling:engine
Summary:
Mazda: see document search button for owner letter. due to wear on lock pin hole in vvt rotor or breakage of vvt case, loud ticking noise (knocking/rattle) is heard, from timing cover and/or valve (cylinder head) cover, when engine is st
Bulletin:
04-002-12
Component:
046000 service brakes, air:antilock
Summary:
Mazda: clunk/bang noise during first forward movement after sitting. this is a normal operating noise of the anti-lock brake system (abs). do not attempt any repairs. also included model cx-5 year 2013; model cx-9 years 2012-2013; model mia
Bulletin:
01-012-12
Component:
061000 engine and engine cooling:engine
Summary:
Mazda: variable timing (vvt) noise and/or timing chain noise. the repair procedure flowchart, repair procedure and warranty information have been revised. also included model mazdaspeed3 model year 2010 *js
Bulletin:
SB-08-001-12
Component:
140000 air bags
Summary:
Mazda: vehicles, with driver/passenger side air bags, may experience warning illumination for air bags, dtc b1994 and/or b1998. *pe
Bulletin:
SB-08-002-12
Component:
141000 air bags:frontal
Summary:
Mazda: on certain vehicles, passenger airbag deactivation (pad) indicator will illuminate during service. *pe
Bulletin:
SB-08-003-12
Component:
141000 air bags:frontal
Summary:
Mazda: air bag module (inflator no. 1 and no. 2) circuit resistance high and air bag system warning light is on, due to terminals of short harness being poorly connected to sas control module and passenger air bag module. models 2007-1
Bulletin:
SB-04-004-12
Component:
035000 service brakes, hydraulic:fluid
Summary:
Mazda: several wiring harnesses run under master cylinder and extreme caution is taken when refilling or replacing the master cylinder brake fluid, which could possibly cause a short circuit in wiring harness. model 2007-2012 cx-7.
Bulletin:
SB-09-005-13
Component:
350000 equipment
Summary:
Mazda: on some vehicles, to avoid potential interference of foot placed on pedals, information is provided regarding proper use, and placement, of driver's floor mat. various models and model years. *pe
Bulletin:
SB-01-009-13
Component:
114000 electrical system:wiring
Summary:
Mazda: on some vehicles, damage of wire harness cover from brake fluid spillage from previous repair, vehicle would experience a possible short to shield wire and a lack of power. models 2007-2009 cx-7. *pe
Bulletin:
SB-09-003-13
Component:
121000 exterior lighting:headlights
Summary:
Mazda: on various model years and model vehicles, the headlamp assembly would have excessive condensation or water within and should be checked and replaced, if necessary for correct installation. *pe
Bulletin:
SB-02-007-13
Component:
021100 suspension:front:stabilizer bar
Summary:
Mazda: when driving on any rough road surfaces or passing over speed bumps, there is a squeak noise, in some vehicles, coming from front stabilizer. model 2007-2009 cx-7. *pe
Bulletin:
SB-08-001-13
Component:
141000 air bags:frontal
Summary:
Mazda: information provided regarding the indicator light illumination of the passenger airbag deactivation (pad). *pe
Bulletin:
ER-7113-L
Component:
063100 engine and engine cooling:exhaust system:emission control
Summary:
Mazda: see document search button for owner letter. the pcm software parameters are incorrect, on certain vehicles, and causes vehicle to exceed evaporative emission standards and require pcm to be reprogrammed with updated software to c
Bulletin:
EFC-1-13-00444
Component:
063100 engine and engine cooling:exhaust system:emission control
Summary:
Mazda: information regarding the evaporate emission standard launching of emission recall 7113-l. *pe
Bulletin:
02-004-14
Component:
011000 steering:wheel and handle bar
Summary:
Summary to be provided on a future date.
Bulletin:
03-001-13
Component:
060000 engine (pws)
Summary:
Summary to be provided on a future date.
Bulletin:
04-001-13
Component:
045000 service brakes, air:disc
Summary:
Summary to be provided on a future date.
Bulletin:
RF-09-03R1
Component:
060000 engine (pws)
Summary:
Summary to be provided on a future date.
Bulletin:
01-011-14
Component:
060000 engine (pws)
Summary:
Summary to be provided on a future date.
Bulletin:
1080M
Component:
060000 engine (pws)
Summary:
If an engine assembly is replaced after a catastrophic internal mechanical failure, clean the intake manifold internally before installing a replacement engine assembly. if the intake manifold is not cleaned properly, the replacement engine
Bulletin:
SA234
Component:
118000 electrical system: software
Summary:
Ids update 101.00 and 101.02 is now available on ms3 under the "ids/infotainment" tab.
Bulletin:
SA327
Component:
140000 air bags
Summary:
Takata recalls general information purpose: this page was created to assist with handling takata air bag recalls. processes: please use these process flowcharts to properly handle vehicles subject to the takata air bag recall. recall 82
Bulletin:
SA285
Component:
110000 electrical system
Summary:
Over the past two weeks, an increasing number of iphone se early adopters have reported audio issues with bluetooth phone calls when the smartphone is paired with a vehicle or wireless headset. the issue extends to gps voice navigation for
Bulletin:
1098M
Component:
160000 structure
Summary:
When removing parts from a vehicle, take caution of this symbol "r". failing to replace the non-reusable part may cause a system failure.
Bulletin:
02-009-16-3155
Component:
010000 steering
Summary:
Some customers may complain that the steering wheel is off center more than 3° even when driving straight on a flat road.
Bulletin:
MTI_1034
Component:
138120 visibility:defroster/defogger system:windshield:heater core
Summary:
This article provides hvac heater/defroster operating tips using mode selector dial. this includes the use of intermediate positions.
Bulletin:
MTI_1111
Component:
350000 equipment
Summary:
When installing a navigation sd card, confirm that the card is unlocked. also, mazda does not recommend swapping navigation system sd cards from one vehicle to another for testing. if swapped, the sd card that is installed into the other ve
Bulletin:
MTI_1031
Component:
350000 equipment
Summary:
Some customers may complain about a blurry rear view monitor display. this may be caused by an aftermarket accessory device.
Bulletin:
MTI_1032
Component:
350000 equipment
Summary:
Some customers may complain about a rattle type noise coming from the rear of the vehicle when driving on rough roads. this may be caused by a loose spare tire jack.
Bulletin:
MTI_1034
Component:
138000 visibility:defroster/defogger system
Summary:
This article provides hvac heater/defroster operating tips using mode selector dial. this includes the use of intermediate positions.
Bulletin:
MTI_1111
Component:
350000 equipment
Summary:
When installing a navigation sd card, confirm that the card is unlocked. also, mazda does not recommend swapping navigation system sd cards from one vehicle to another for testing. if swapped, the sd card that is installed into the other ve
Bulletin:
MTI_1031
Component:
350000 equipment
Summary:
Some customers may complain about a blurry rear view monitor display. this may be caused by an aftermarket accessory device
Bulletin:
1098M
Component:
160000 structure
Summary:
When removing parts from a vehicle, take caution of this symbol "r". failing to replace the non-reusable part may cause a system failure.
Bulletin:
1066M
Component:
120000 exterior lighting
Summary:
Some customers may complain about improper operation of the auto-dimming mirror. this may be caused by an obstruction of the front and/or rear light sensor(s) (e.g. hanging a parking permit from the mirror). use a soft cloth with mild deter
Bulletin:
1099M
Component:
110000 electrical system
Summary:
When reprogramming a control module, always use the gr-8 battery management system power supply mode. if not used, the control module reprogramming may fail due to a weak vehicle battery.the gr-8 battery management system power supply mode
Bulletin:
00-004-16-3237
Component:
350000 equipment
Summary:
Raising a vehicle with a jack can be dangerous if not done properly. the vehicle can slip off the jack and seri-ously injure someone. in this service information, some important warnings and cautions have been taken from the owner's manual.
Bulletin:
1080M
Component:
060000 engine (pws)
Summary:
If an engine assembly is replaced after a catastrophic internal mechanical failure, clean the intake manifold internally before installing a replacement engine assembly. if the intake manifold is not cleaned properly, the replacement engine
Bulletin:
03-001-13-2760
Component:
018000 steering: adaptive steering
Summary:
Some customers may notice a vibration from the floor and/or steering wheel during acceleration at approx. 50 mph. to eliminate this concern, the amount of velocity joint grease was increased during mass-production.
Bulletin:
04-001-13-2757
Component:
356000 equipment adaptive
Summary:
The front disc plate fixing screws (a) have been discontinued. with this change, the disc plate (b) and wheel hub (c) have been modified without fixing holes, eliminating the need for the fixing screws (a).
Bulletin:
00-001-13-2748
Component:
355200 equipment:other:owners/service/other manual
Summary:
Mazda has developed factory recommended scheduled maintenance services that support all major vehicle systems. mazda recommends dealers follow the scheduled maintenance tables as cited in the vehicle-specific workshop manual or owner's manu
Bulletin:
02-001-13-2752
Component:
350000 equipment
Summary:
Some customers may complain of signs of oil on the struts or shock absorbers. in most cases the oil that is present is normal, and a result of the oil that remains on the shaft during the normal sweeping process of the shaft seal. follow th
Bulletin:
01-009-13-2764
Component:
070000 fuel system, gasoline
Summary:
Some vehicles may exhibit a lack of power with mil illumination and dtcs p2187 / p2177 stored in memory. 'p2187: fuel system too lean at idle'p2177: fuel system too lean at off idlethis concern may be caused by a/f sensor wire harness cover
Bulletin:
02-004-13-2770
Component:
010000 steering
Summary:
Some customers may complain that the steering wheel is off center more than 3° even when driving straight on a flat road.
Bulletin:
09-005-13-2781
Component:
350000 equipment
Summary:
This service bulletin provides information regarding the proper use of the driver's floor mat to avoid any poten-tial interference with the foot pedals. the following are possible causes of floor mat interference, which can be avoided with
Bulletin:
05-002-13-2777A
Component:
102400 power train:manual transmission:lubricant
Summary:
Always be sure to use the correct automatic transmission fluid when replacing atf. using the wrong atf may cause shift quality complaints or may even damage the transmission.note:'atf m-v (type m5) is not the same fluid as mercon®v or merco
Bulletin:
09-003-13-2776
Component:
354000 equipment:mechanical
Summary:
When dealing with customer complaints of excessive condensation and/or water within the headlamp unit, first determine if all the bulb sockets are present and correctly installed. in most cases you will find that the bulb seal no. 1 (a) or
Bulletin:
00-001-13-2748A
Component:
355200 equipment:other:owners/service/other manual
Summary:
Mazda has developed factory recommended scheduled maintenance services that support all major vehicle systems. mazda recommends dealers follow the scheduled maintenance tables as cited in the vehicle-specific workshop manual or owner's manu
Bulletin:
02-004-13-2770A
Component:
011000 steering:wheel and handle bar
Summary:
Some customers may complain that the steering wheel is off center more than 3° even when driving straight on a flat road.
Bulletin:
09-018-13-2803
Component:
355200 equipment:other:owners/service/other manual
Summary:
Some customers may complain that the ambient temperature display is not accurate, or it takes too long for the display to show actual temperature. when you encounter a customer with this concern, first verify the condition when the customer
Bulletin:
02-007-13-2809
Component:
350000 equipment
Summary:
Some vehicles may exhibit a squeak noise coming from the front stabilizer (a) when driving on rough road surfaces or passing over speed bumps.due to a lack of hardness on the edge of the front stabilizer bushing (b), noise occurs between th
Bulletin:
02-004-13-2770B
Component:
011000 steering:wheel and handle bar
Summary:
Some customers may complain that the steering wheel is off center more than 3° even when driving straight on a flat road.
Bulletin:
09-028-12-2701B
Component:
355200 equipment:other:owners/service/other manual
Summary:
The multi information display (mid) and navigation system support for diagnostics, parts authorization, and parts exchange require contacting the proper source. please contact the appropriate source by referring to the following tables.
Bulletin:
04-004-12-2726
Component:
035000 service brakes, hydraulic:fluid
Summary:
Use extreme care when replacing or re-filling brake fluid at the master cylinder. there are several wiring harnesses that run under the master cylinder that can be easily spilled upon. caution: brake fluid contains properties that can cause
Bulletin:
07-002-13-2842
Component:
353600 equipment:air conditioner
Summary:
A musty/mildew type odor may come from the vents when the air conditioning (a/c) system is operating. it is most noticeable when the a/c is first turned on. this odor is the result of mold growth in the a/c evaporator/cooling unit which is
Bulletin:
09-046-12-2744
Component:
120000 lighting (pws)
Summary:
Some customers may complain of condensation/fog inside the front or rear combination lights. the recent new models have been fitted with a clear lens which can cause the symptom to be more noticeable, however, it does not affect the perform
Bulletin:
00-004-12-2741
Component:
355200 equipment:other:owners/service/other manual
Summary:
Mazda has developed factory recommended scheduled maintenance services that support all major vehicle systems. mazda recommends dealers follow the scheduled maintenance tables as cited in the vehicle-specific workshop manual or owner's manu
Bulletin:
09-039-13-2852
Component:
220000 seats
Summary:
Some vehicles may exhibit a chattering noise and the driver-side seat lift cannot be adjusted because the lock plate guide comes off the guide cam when operating the lift. if the lift lever is then operated with the lock plate guide off, th
Bulletin:
09-007-14-2878
Component:
122000 exterior lighting:fog lights
Summary:
Some customers may complain of condensation/fog inside the front or rear combination lights. the recent new models have been fitted with a clear lens which can cause the symptom to be more noticeable, however, it does not affect the perform
Bulletin:
04-002-14-2879
Component:
046400 service brakes, air:antilock:abs warning light
Summary:
Some customers may report a slight clunk/bang/buzz noise or jolt from the front of the vehicle. this concern will most likely occur during the vehicles first forward movement after starting the engine. this is a normal operating noise of th
Bulletin:
09-012-14-2891
Component:
353400 equipment:electrical:radio/tape deck/cd etc.
Summary:
When replacing the siriusxm satellite radio unit (or a mazda connect tuner and amp unit (tau)) with replacement tuner for any reason, a call must be made to inform siriusxm of the existing radio id and the new/ replacement sat radio id as s
Bulletin:
01-003-14-2892
Component:
350000 equipment
Summary:
Bulletin note: mazda service program (msp36) released as bulletin 01-020/12 on 06/18/12 is no longer valid. it has been superceded by '2007-2012 cx-7 nonconformity to evaporative emission standard - emission recall 7113l'.
Bulletin:
04-004-14-2926
Component:
030000 brakes (pws)
Summary:
Some vehicles exhibit brake related concerns such as brake noise, brake judder or brake dragging. if you encounter a customer complaint for any one of these symptoms, refer to the following information to understand why symptoms may occur,
Bulletin:
09-023-14-2924
Component:
350000 equipment
Summary:
Some customers may complain that the ambient temperature display is not accurate, or it takes too long for the display to show actual temperature.when you encounter a customer with this concern, first verify the condition when the customer
Bulletin:
01-011-14-2907
Component:
060000 engine (pws)
Summary:
Some vehicles may exhibit a clunk noise from the engine compartment when driving over rough roads or over a speed bump. the noise may occur in areas of high ambient temperatures. due to high heat, the lubricant inside the no. 3 engine mount
Bulletin:
00-002-14-2936
Component:
350000 equipment
Summary:
Mazda north american operations received many requests from our dealers asking us to approve additional on-car brake lathes as an option for mnao authorized equipment. due to your feedback and after evaluating a few on-car brake lathes, we
Bulletin:
09-027-14-2935
Component:
356000 equipment adaptive
Summary:
This service bulletin provides information regarding the proper use of the driver's floor mat to avoid any potential interference with the foot pedals. the following are possible causes of floor mat interference, which can be avoided with p
Bulletin:
09-034-14-2956
Component:
356000 equipment adaptive
Summary:
In accordance with federal regulations, follow the procedure listed below when replacing a speedometer.note:'mazda vehicles are manufactured with tamper-proof speedometers.'when a speedometer is replaced, the new speedometer will read zero
Bulletin:
09-049-14-2980
Component:
121000 exterior lighting:headlights
Summary:
When dealing with customer complaints of excessive condensation and/or water within the headlamp unit, first determine if all the bulb sockets are present and correctly installed. in most cases you will find that the bulb seal no. 1 (a) or
Bulletin:
02-004-14-2976
Component:
011000 steering:wheel and handle bar
Summary:
Some customers may complain that the steering wheel is off center more than 3° even when driving straight on a flat road. follow steering wheel alignment procedure.
Bulletin:
09-024-15-3050
Component:
133000 visibility:power window devices and controls
Summary:
Some customers may experience inoperative front door window auto-closing operation when using the window switches (a). the window moves upward, but automatically returns to the halfway position (as if the jam-safe window function is operati
Bulletin:
01-003-15-3014
Component:
350000 equipment
Summary:
Use the following repair procedure to minimize the need to replace the catalyst converter/exhaust pipe when removing oxygen sensors and/or air fuel ratio sensors.
Bulletin:
09-003-16-3130
Component:
121000 exterior lighting:headlights
Summary:
Some customers may complain of condensation/fog inside the front (headlamp/headlight) or rear (taillamp/tail-light) combination lights. the recent new models have been fitted with a clear lens which can cause the symp-tom to be more noticea
Bulletin:
05-001-16-3128
Component:
355200 equipment:other:owners/service/other manual
Summary:
Always be sure to use the correct automatic transmission fluid when replacing atf. using the wrong atf may cause shift quality complaints or may even damage the transmission.note:' atf m-v (type m5) is not the same fluid as mercon®v or merc
Bulletin:
02-009-16-3155
Component:
011000 steering:wheel and handle bar
Summary:
Some customers may complain that the steering wheel is off center more than 3° even when driving straight on a flat road.
Bulletin:
09-030-15-3073
Component:
355200 equipment:other:owners/service/other manual
Summary:
Mazda infotainment systems require contacting the proper source for diagnostic support, parts authorization, and parts exchange. some components require prior authorization before ordering as exchange. refer to dag exchange central (mxconn
Bulletin:
09-013-16-3161
Component:
350000 equipment
Summary:
When dealing with customer complaints of excessive condensation and/or water within the headlamp unit, first determine if all the bulb sockets are resent and correctly installed. in most cases you will find that the bulb seal no. 1 (a) or
Bulletin:
04-004-16-3160
Component:
030000 brakes (pws)
Summary:
Some vehicles exhibit brake related concerns such as brake noise, brake judder or brake dragging. if you encounter a customer complaint for any one of these symptoms, refer to the following information to understand why symptoms may occur,
Bulletin:
08-001-13-2859
Component:
110000 electrical system
Summary:
This information is provided to help address passenger airbag deactivation (pad) indicator illumination con-cerns during vehicle service.
Bulletin:
02-009-13-2854
Component:
200000 wheels
Summary:
Some automotive cleaning products contain strong acid or alkali. when these types of cleaners are used to clean the wheels on mazda vehicles, the chemicals contents penetrate the clear coating of the wheel surface and damage the paint under
Bulletin:
04-004-13-2853
Component:
030000 brakes (pws)
Summary:
Some vehicles exhibit brake related concerns such as brake noise, brake judder or brake dragging. if you encounter a customer complaint for any one of these symptoms, refer to the following information to understand why symptoms may occur,
Bulletin:
09-008-17-3324
Component:
121000 exterior lighting:headlights
Summary:
Take caution when cleaning plastic headlight lenses. damage can occur when using some cleaners that contain strong acid, alkaline cleanser or organic solvent. damage caused by using these cleaners is not covered by mazda's new vehicle limit
Bulletin:
SA-061-17
Component:
117000 digital instrument panel
Summary:
In an effort to achieve a higher level of customer experience and retain the value of mazda's vehicles, mnao warranty operations is© 2017 mazda north american operations, u.s.a. allowing all mazda dealers to utilize a third party, specmo en
Bulletin:
09018173351
Component:
117000 digital instrument panel
Summary:
Some customers may complain that the ambient temperature display is not accurate, or it takes too long for the display to show actual temperature. when you encounter a customer with this concern, first verify the condition when the customer
Bulletin:
09-035-17-3080
Component:
117000 digital instrument panel
Summary:
In accordance with federal regulations, follow the procedure listed below when replacing a speedometer. note: tampering with a motor vehicle odometer is strictly prohibited by federal, and state laws. it is the dealer?s responsibility to co
Bulletin:
09-001-17-3296b
Component:
110000 electrical system
Summary:
When dealing with customer complaints of excessive condensation and/or water within the headlamp unit, first determine if all the bulb sockets (including o-ring), seals and covers are present and correctly installed. in most cases you will
Bulletin:
SA-068-17
Component:
140000 air bags
Summary:
Stopper plates for air bag module connectors have been established as new service parts. when removing the connector (1) to the air bag module (2), make sure to first lift the stopper plate (3) carefully using a flathead screwdriver (but do
Bulletin:
00-001-18-3446
Component:
350000 equipment
Summary:
Mazda has developed factory recommended scheduled maintenance services that support all major vehicle systems. mazda recommends dealers follow the scheduled maintenance tables as cited in the vehicle-specific workshop manual or owner's manu
Bulletin:
09-011-18-3448
Component:
121000 exterior lighting:headlights
Summary:
Some customers may complain of condensation/fog inside the front (headlamp/headlight) or rear (taillamp/taillight) combination lights. the recent new models have been fitted with a clear lens which can cause the symptom to be more noticeabl
Bulletin:
09-014-18-3443
Component:
160000 structure
Summary:
When encountering a vehicle with paint damage, refer to the "mazda pocket paint guide" to determine cause, prevention, remedy, and warranty coverage (if applicable).
Bulletin:
09-019-18-3450
Component:
356000 equipment adaptive
Summary:
This service bulletin provides information regarding the proper use of the driver's floor mat to avoid any potential interference with the foot pedals. the following are possible causes of floor mat interference, which can be avoided with p
Bulletin:
MT-003-18
Component:
140000 air bags
Summary:
The workshop manual has two-different airbag procedures, one for standard deployment and one for two-step deployment. standard deployment is for mexico spec vehicles and two-step deployment is for us and canadian spec vehicles.
Bulletin:
01-008-18-3451
Component:
111000 electrical system:battery
Summary:
This service bulletin provides testing and charging procedures in order to promote proper battery maintenance, to deliver new vehicles with fully charged batteries, and to reduce unnecessary battery replacement cost. for new vehicles in sto
Bulletin:
01-009-18-3452
Component:
111000 electrical system:battery
Summary:
The mazda gr8-1291 is required for all warranty battery testing. if the mazda gr8-1291 is not used, incorrect battery testing may result in unnecessary battery replacement. use the following test procedures in this service bulletin to test
Bulletin:
02-006-18-3449
Component:
021300 suspension:front:shock absorber
Summary:
Some customers may complain of signs of oil on the struts or shock absorbers. in most cases the oil that is present is normal, and a result of the oil that remains on the shaft during the normal sweeping process of the shaft seal. follow th
Bulletin:
MT-004-18
Component:
110000 electrical system
Summary:
If you encounter any type of electrical concern (e.g, dead battery), interview the customer before proceeding with normal workshop manual diagnosis. aftermarket devices may be the cause of the electrical concern. ask the customer if any aft
Bulletin:
02-008-18-3467
Component:
200000 wheels
Summary:
Some automotive cleaning products contain strong acid or alkali. when these types of cleaners are used to clean the wheels on mazda vehicles, the chemicals contents penetrate the clear coating of the wheel surface and damage the paint under
Bulletin:
04-003-18-3455
Component:
060000 engine and engine cooling
Summary:
Some customers may report a slight clunk/bang/buzz noise or jolt from the front of the vehicle. this concern will most likely occur during the vehicles first forward movement after starting the engine. this is a normal operating noise of th
Bulletin:
04-004-18-3468
Component:
030000 brakes (pws)
Summary:
Some vehicles exhibit brake related concerns such as brake noise, brake judder or brake dragging. if you encounter a customer complaint for any one of these symptoms, refer to the following information to understand why symptoms may occur,
Bulletin:
05-001-18-3453
Component:
100000 power train
Summary:
Always be sure to use the correct automatic transmission fluid when replacing atf. using the wrong atf may cause shift quality complaints or may even damage the transmission. note: atf m-v (type m5) is not the same fluid as mercon®v or merc
Bulletin:
07-002-18-3432
Component:
353600 equipment:air conditioner
Summary:
A musty/mildew type odor may come from the vents when the air conditioning (a/c) system is operating. it is most noticeable when the a/c is first turned on. this odor is the result of mold growth in the a/cevaporator/cooling unit which is c
Bulletin:
08-001-18-3457
Component:
140000 air bags
Summary:
This information is provided to help address passenger airbag deactivation (pad) indicator illumination concerns during vehicle service.
Bulletin:
00-003-18-3480
Component:
030000 brakes (pws)
Summary:
Mazda north american operations has approved an additional on-car brake lathe as an option for mnaoauthorized equipment. the pro-cut on-car brake lathe has been added to the mnao authorizedequipment program.note: accu-turn is still an appro
Bulletin:
02-010-18-3477
Component:
011000 steering:wheel and handle bar
Summary:
Some customers may complain that the steering wheel is off center more than 3° even when driving straight on a flat road.
Bulletin:
09-023-18-3475
Component:
350000 equipment
Summary:
When replacing the siriusxm satellite radio unit (or a mazda connect tuner and amp unit (tau)) with replacement tuner for any reason, a call must be made to inform siriusxm of the existing radio id and the new/replacement sat radio id as so
Bulletin:
09-025-18-3479
Component:
350000 equipment
Summary:
Mazda infotainment systems require contacting the proper source for diagnostic support, parts authorization, and parts exchange. some components require prior authorization before ordering as exchange. refer to dag exchange central (mxconne
Bulletin:
MT-004-18
Component:
110000 electrical system
Summary:
Electrical concern and/or multiple dtc's due to aftermarket device: if you encounter any type of electrical concern (e.g, dead battery, engine no start, dtc(s) stored...), interview the customer before proceeding with normal workshop manual
Bulletin:
09-034-18-3430
Component:
180000 vehicle speed control
Summary:
In accordance with federal regulations, follow the procedure listed below when replacing a speedometer. note: tampering with a motor vehicle odometer is strictly prohibited by federal, and state laws. it is the dealer's responsibility to co
Bulletin:
MT-004-18
Component:
110000 electrical system
Summary:
If you encounter any type of electrical concern (e.g, dead battery, engine no start, dtc(s) stored...), interview the customer before proceeding with normal workshop manual diagnosis. aftermarket devices may be the cause of the electrical c
Bulletin:
01-016-18-3522
Component:
063000 engine and engine cooling:exhaust system
Summary:
On some vehicles, a sulfur smell or 'rotten egg' odor may be noticed coming from the exhaust system. the odor is usually noticed after a cold start, fast idle, extended periods of idling and full throttle acceleration. sulfur smell is not a

Home | Privacy