2007 JAGUAR XK Recall

Campaign:: 09V161000 on 05/17/2009
Component:: Tires:pressure monitoring and regulating systems
Manufactured:: 09/17/2007 - 03/30/2009
Affected:: 112
Defect:: Jaguar is recalling 112 my 2007-2009 xk vehicles fitted with run flat tires for failing to comply with the requirements of federal motor vehicle safety standard no.138, "tire pressure monitoring system, (tpms)." the tpms warnings were turned off. if the tpms electronic control unit were to send a signal to the instrument cluster to display a tpms warning telltale, the light would not illuminate nor would the supplementary warning text on the instrument cluster message center be displayed.
Consequence:: Failure to warn of tire deflations is a non-compliance with fmvss 138 and could lead to tire failure and a crash.
Correction:: Dealers will update the car configuration file settings to enable the instrument cluster to flag the warning symbols as required by fmvss 138 and associated test in the instrument cluster message center. the remedy will be performed free of charge. the recall is expected to begin on or before june 8, 2009. owners may contact jaguar at 1-201-818-8500.
Notes:: Jaguar recall no. j013.owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to <a href=http://www.safercar.gov>http://www.safercar.gov</a> .

2007 JAGUAR XK TSBs (99)

Bulletin:: 204001
Component:: 199000 tires:pressure monitoring and regulating systems
Summary:: Tire pressure monitoring system (tpms) concern diagnosis. *tt
Bulletin:: 417001
Component:: 121000 exterior lighting:headlights
Summary:: Headlamp has condensation on the inside of the lens. *kb
Bulletin:: 204002
Component:: 020000 suspension
Summary:: Knock from front suspension. *kb
Bulletin:: 00008
Component:: 045000 service brakes, air:disc
Summary:: Clean and apply grease to front caliper brake pad anchor surfaces and install new front brake pads. jaguar x150, x350, and x200 years 2006-2007. *kb
Bulletin:: 00010
Component:: 192000 tires:sidewall
Summary:: Permanent high spot marking to tire inboard sidewall. *kb
Bulletin:: 00003
Component:: 141100 air bags:frontal:sensor/control module
Summary:: Restraints control module (rcm) configuration. *kb
Bulletin:: 00004
Component:: 061000 engine and engine cooling:engine
Summary:: Malfunction indicator lamp (mil) on with diagnostic trouble code (dtc) p0172/p0175 stored. *kb
Bulletin:: 00049
Component:: 220000 seats
Summary:: Jaguar- passenger seat occupancy warnings. *nj
Bulletin:: K013
Component:: 071110 fuel system, gasoline:storage:tank assembly:filler pipe and cap
Summary:: Service action: xk enhancement program - software upgrades and fuel filler flap repair. *nj updated 4/28/08. *nj
Bulletin:: JTB-00147
Component:: 110000 electrical system
Summary:: Jaguar: unable to unlock vehicle/no electrical power. after using mechanical key to enter vehicle, engine will not crank. repair procedure. *pe
Bulletin:: TSB-K-005
Component:: 103100 power train:automatic transmission:control module (tcm, pcm)
Summary:: Jaguar: tcm software update. a limited number of vehicles may have been manufactured away from process, and in some cases the engine control module (ecm) is unable to report the freeze frame data on behalf of the transmission control modu
Bulletin:: SSM-36224
Component:: 053000 parking brake:indicator light
Summary:: Jaguar: directional indicator operating with the stalk in the central position. if condition is found, replace the directional indicator switch. no model years listed. *pe
Bulletin:: JTB-00165
Component:: 194000 tires:valve
Summary:: Jaguar: tire valve stem damage during manual tire pressure checking or low tire pressure warnings illuminated-repair procedure. on vehicles fitted with tire pressure monitoring system (tpms) only, the following issues have been identified-
Bulletin:: JTB-00175
Component:: 034500 service brakes, hydraulic:foundation components:disc
Summary:: Jaguar: rear differential replacement. due to a change in design, the rear differential has a new service part. as a result, should the rear differential require replacement it will be necessary to convert the driveline system to use the
Bulletin:: JTB-00121
Component:: 161000 structure:frame and members
Summary:: Jaguar: on some xk models, water may leak into the passenger footwell due to a blocked air conditioning drain tube. *rm
Bulletin:: JTB-00208
Component:: 050000 parking brake
Summary:: Jaguar: electronic parking brake re-calibration procedure. *rm updated 10/17/14. *pe
Bulletin:: SSM-63697
Component:: 073200 fuel system, gasoline:fuel injection system:injectors
Summary:: Jaguar: fuel injector concerns 5.o aj133 gasoline, leading to potential problemssuch as poor running poor fuel economy, hard starting, rough idle, misfires and engine detonation. *js
Bulletin:: JTB-00344-NAS1
Component:: 350000 equipment
Summary:: Jaguar: damage during a repair or time of production, caused the earth stud, on some vehicles, to become broken or cross threaded. model 2003-2009 xj (x350), 206/onwards xk (x150), 2010/onwards xj (x351), 2014/onwards f-type (x152).
Bulletin:: JTB00191NAS2
Component:: 350000 equipment
Summary:: Summary to be provided on a future date.
Bulletin:: JTB00257NAS2
Component:: 190000 tires
Summary:: Summary to be provided on a future date.
Bulletin:: JTB00283NAS1
Component:: 130000 visibility
Summary:: Summary to be provided on a future date.
Bulletin:: JTB00302NAS1
Component:: 160000 structure
Summary:: Summary to be provided on a future date.
Bulletin:: JTB00317NAS2
Component:: 118000 electrical system: software
Summary:: Summary to be provided on a future date.
Bulletin:: JTB00149NAS4
Component:: 118000 electrical system: software
Summary:: Summary to be provided on a future date.
Bulletin:: JTB00191NAS3
Component:: 175200 latches/locks/linkages:trunk lid:lock
Summary:: Summary to be provided on a future date.
Bulletin:: JTB00268NAS2
Component:: 060000 engine (pws)
Summary:: Summary to be provided on a future date.
Bulletin:: JTB00176NAS2
Component:: 120000 lighting (pws)
Summary:: Summary to be provided on a future date.
Bulletin:: JTB00257NAS3
Component:: 190000 tires
Summary:: Summary to be provided on a future date.
Bulletin:: JTB00268NAS3
Component:: 060000 engine (pws)
Summary:: "situation: on vehicles fitted with the 4.2l naturally aspirated engine only, the engine may experience a rough start or stall following a hot soak of 15-20 minutes. cause: this may be caused by the fueling calibration not being robust for
Bulletin:: JTB00344NAS1
Component:: 160000 structure
Summary:: Summary to be provided on a future date.
Bulletin:: SSM-71498
Component:: 105300 power train:driveline:driveshaft
Summary:: "issue: engineering is investigating the cause of front drive shafts (half shafts) rubber boots split or damaged on jaguar vehicles in warranty. cause: unknown ' engineering investigation on-going."
Bulletin:: SSM71538
Component:: 171100 latches/locks/linkages:doors:latch
Summary:: "issue: customer may report door lock cylinder cover missing. cause: cylinder cover may have been incorrectly fitted at pdi or after emergency vehicle entry."
Bulletin:: SSM-66697
Component:: 062000 engine and engine cooling:cooling system
Summary:: "issue: after the engine coolant on a 5.0l v8 aj133 engine has been partially or fully drained and filled, the customer experiences the engine overheating. cause: the refill procedure has not been completed correctly, resulting in insuf
Bulletin:: JTB-00191-NAS-3
Component:: 356000 equipment adaptive
Summary:: "situation: the glove compartment lid may not be damped when opening. cause: this may be caused by the glove compartment lid damper cord retaining tab coming away from the glove compartment housing."
Bulletin:: JTB-00304-NAS-1
Component:: 355200 equipment:other:owners/service/other manual
Summary:: "situation: a lower-level service repair part is now available in the event of a front sun visor vanity mirror issue. cause: a lower-level service repair part to be used in the event a front sun visor vanity mirror requires replacement."
Bulletin:: SSM-68359
Component:: 355200 equipment:other:owners/service/other manual
Summary:: "issue: customers may report that they are unable to play music through their android phone when connected via cable to usb - xk does not support bluetooth streaming. cause: this could be for a number of reasons not necessarily relate
Bulletin:: SSM-69078
Component:: 110000 electrical system
Summary:: "issue: apple ios, and android phone issues after software updates. the customer may report a range of problems with their phone connection, audio quality or phonebook which have started to happen after the phone was manually or automati
Bulletin:: SSM-70698
Component:: 111000 electrical system:battery
Summary:: "issue: a customer may report that their phone, disconnects during or after phone calls, shows as paired but not available, is not showing as paired but is available, is difficult to pair, audio fragments when streaming music and/or oth
Bulletin:: SSM-71218
Component:: 030000 brakes (pws)
Summary:: "issue: customer repor ts a parkbrake warning lamp i l luminated and / or parkbrake faul t message displayed in the ipk (instrument pack), following investigation wi th sdd the fol lowing dtc p1571-64 (brake swi tch - signal plausibilit
Bulletin:: JTB00257NAS3
Component:: 010000 steering
Summary:: Situation: the steering wheel may exhibit a vibration / shimmy while driving. cause: this may be caused by a road wheel/tire assembly imbalance and/or temporary tire flat-spotting.
Bulletin:: JTB00258NAS2
Component:: 010000 steering
Summary:: Situation: a steering wheel shimmy may be evident during the pre-delivery inspection (pdi) road test due to temporary flat spots on the rolling surface of the tire. cause: temporary flat spots naturally develop on the rolling surface of a
Bulletin:: SSM72926
Component:: 162000 structure:body
Summary:: Issue: customer may report erratic ambient air temperature readings or default setting (ie.-40°) appearing.
Bulletin:: SSM71794
Component:: 353000 equipment:electrical
Summary:: "issue: fm1 preset ceases to operate. (tuner is stuck in am band while touch screen displays fm1) cause: no error handling of frequency being stored in hd radio module."
Bulletin:: JTB00344NAS1
Component:: 350000 equipment
Summary:: "situation: an earth stud may be broken or cross threaded. cause: this may be caused by damage in production or during a repair."
Bulletin:: SSM63597
Component:: 118000 electrical system: software
Summary:: "issue: jaguar land rover north america service diagnostics would like to make all sdd users aware of an emerging concern being tracked via the epqr system. users report dvd133 is unable to fully communicate with pcm on legacy jaguar veh
Bulletin:: SSM71361
Component:: 118000 electrical system: software
Summary:: "issue: da-dongle/da-vina/da-st512 - j2534 vehicle communication interface device (vci) software requires updating to the latest level. da j2534 software driver level ' v4.0 (must be updated to this level on all sdd machines that use thi
Bulletin:: SSM71822
Component:: 353000 equipment:electrical
Summary:: "issued may 2014: issue during a recent market visit it was noted that a significant number of dealers have been carrying out pdi's and then returning the vehicle to a storage compound without refitting the transit relay or returning the
Bulletin:: SSM71827
Component:: 220000 seats
Summary:: "issue: climate controlled seat issues cause: unknown"
Bulletin:: SSM71832
Component:: 141200 air bags:frontal:driver side inflator module
Summary:: "issue:- customers have reported that the airbag warning light has illuminated in the instrument cluster after a previous repair. cause:- the drivers airbag circuit has been incorrectly diagnosed as being at fault or has more than one
Bulletin:: SSM67697
Component:: 110000 electrical system
Summary:: "issue: jaguar engineering have been monitoring reports for lack of cooling from the air conditioning system on some higher time in service vehicles, where insufficient performance of the air conditioning compressor has been found to be t
Bulletin:: SSM71915
Component:: 111000 electrical system:battery
Summary:: "issue a number of alternators are being replaced under warranty and are found to be faulty due to internal regulator chip damage. cause alternators are being damaged due to cross polarity when the vehicle is jump started."
Bulletin:: SSM67697
Component:: 353600 equipment:air conditioner
Summary:: "issue: jaguar engineering have been monitoring reports for lack of cooling from the air conditioning system on some higher time in service vehicles, where insufficient performance of the air conditioning compressor has been found to be t
Bulletin:: SSM71538
Component:: 162300 structure:body:door
Summary:: "issue: customer may report door lock cylinder cover missing. cause: cylinder cover may have been incorrectly fitted at pdi or after emergency vehicle entry."
Bulletin:: SSM71995
Component:: 162000 structure:body
Summary:: "issue: customers have reported that the armrest liner is damaged ' eg: corner broken ' see pic 1 as an example cause:: poor initial fit / interference contact"
Bulletin:: SSM51357
Component:: 091200 fuel system, other:storage:fuel gauge system
Summary:: "issue: when investigating customer reports for incorrect fuel gauge concerns the dealer technician may diagnose that the fuel senders are open circuit. this diagnosis may be incorrect depending on the multimeter settings selected by the
Bulletin:: SSM71538
Component:: 171100 latches/locks/linkages:doors:latch
Summary:: "issue: customer may report door lock cylinder cover missing. cause: cylinder cover may be damaged or have been incorrectly fitted at pdi or after emergency vehicle entry."
Bulletin:: SSM71966
Component:: 350000 equipment
Summary:: "issue: submitting a brake noise epqr. specifically related to front brake disc grooving causing a noise and /or judder issue. cause: under investigation"
Bulletin:: SSM71966
Component:: 030000 brakes (pws)
Summary:: "issue: submitting a brake noise epqr. specifically related to front brake disc grooving causing a noise and /or judder issue. cause: under investigation"
Bulletin:: SSM71995
Component:: 350000 equipment
Summary:: "issue: customers have reported that the armrest liner is damaged ' eg: corner broken ' see pic 1 as an example cause:: poor initial fit / interference contact"
Bulletin:: SSM72012
Component:: 350000 equipment
Summary:: "issue the wrong component maybe replaced when troubleshooting bluetooth connectivity in car. cause the front control display interface module (touchscreen) has no effect on bluetooth connectivity in the car and as such may be incorrect
Bulletin:: SSM72022
Component:: 220000 seats
Summary:: "issue: seats not moving in one direction / one axis cause: motor connections not fully latched"
Bulletin:: SSM40913
Component:: 060000 engine (pws)
Summary:: "re-issued november 2014. issue: on investigation of warranty returns it has been noted that the engine-compartment lid latch has been lubricated. cause: lubricant applied to the engine-compartment lid latch during routine servicing or
Bulletin:: SSM43055
Component:: 220000 seats
Summary:: "re-issued november 2014. issue: seat movement maybe restricted on some vehicles that has the seat memory function. cause: if an obstruction is encountered while the seat is in motion, the seat will stop moving and further movement will b
Bulletin:: SSM71995
Component:: 160000 structure
Summary:: "issue: customers have reported that the armrest liner is damaged ' eg: corner broken ' see pic 1 as an example cause:: poor initial fit / interference contact"
Bulletin:: SSM72037
Component:: 060000 engine (pws)
Summary:: "issue: in some circumstances, the customer is reporting the engine failing to start, the engine running rough, the check engine light being displayed, or a combination of these symptoms. cause: dtc's captured by the vehicle electronic
Bulletin:: SSM72041
Component:: 010000 steering
Summary:: "issue: submitting a steering system noise epqr. cause: under investigation"
Bulletin:: SSM72141
Component:: 011000 steering:wheel and handle bar
Summary:: "issue: a steering wheel shimmy may be evident during the pre-delivery inspection (pdi) road test due to temporary flat spots on the rolling surface of the tire. cause: temporary flat spots naturally develop on the rolling surface of a
Bulletin:: SSM72202
Component:: 162300 structure:body:door
Summary:: "issue: door latch functionality cause: jlr engineering are currently investigating side door latch concerns and therefore would appreciate more information to aid investigations. known issues have been resolved and assured vins for effec
Bulletin:: JTB00283NAS2
Component:: 132000 visibility:glass, side/rear
Summary:: "situation: the bonding between the folding top and the rear glass may require repair. cause: this may be caused by bonding robustness between the folding top and the rear glass."
Bulletin:: SSM72617
Component:: 060000 engine (pws)
Summary:: Coolant expansion tank pressure caps leaking
Bulletin:: SSM39211
Component:: 073200 fuel system, gasoline:fuel injection system:injectors
Summary:: "re-issued dec 2015. issue: fuel injectors clogged leading to poor running / misfires / engine detonation on aj-v8 engines. cause: poor fuel quality or fuel contaminants blocking the holes in the fuel injector."
Bulletin:: SSM42872
Component:: 110000 electrical system
Summary:: "issued dec 2015. issue: jaguar are continuing to see no fault found warranty returns on headlamps and associated control modules cause: incorrect diagnosis. "
Bulletin:: SSM51717
Component:: 062000 engine and engine cooling:cooling system
Summary:: "issue: coolant expansion tank stub pipe leaking on xj (x350), xk (x150) or xf (x250) up to the end of 2009 my. cause: the design of the stub pipe was not adequate and could result in the pipe splitting."
Bulletin:: SSM71966
Component:: 030000 brakes (pws)
Summary:: "issue: submitting a brake noise epqr. specifically related to front brake disc grooving causing a noise and /or judder issue. cause: under investigation"
Bulletin:: SSM72202
Component:: 162000 structure:body
Summary:: "issue: door latch functionality cause: jlr engineering are currently investigating side door latch concerns and therefore would appreciate more information to aid investigations."
Bulletin:: SSM71598
Component:: 103000 power train:automatic transmission
Summary:: "issue: following the recent k202 campaign a few customers have reported continuing problems with the transmission control switch unit(s) fails to rise or initially rises before lowering itself back to its default position for an igniti
Bulletin:: SSM71678
Component:: 012000 steering:column
Summary:: "issue: a customer may report their steering column does not move when trying to adjust in a up/down or in/out movement. cause: when the instrument panel cluster software is updated, the steering column calibration will revert to it's
Bulletin:: SSM71498
Component:: 105300 power train:driveline:driveshaft
Summary:: "issue: engineering is investigating the cause of front drive shafts (half shafts) rubber boots split or damaged on jaguar vehicles in warranty. cause: unknown ' engineering investigation on-going."
Bulletin:: SSM71538
Component:: 171100 latches/locks/linkages:doors:latch
Summary:: "issue: customer may report door lock cylinder cover missing. cause: cylinder cover may have been incorrectly fitted at pdi or after emergency vehicle entry."
Bulletin:: 68358
Component:: 350000 equipment
Summary:: "issue: this ssm has been released to address the high number of speaker assemblies returned, many of which are deemed as 'no fault found'. cause: incorrect diagnosis."
Bulletin:: JTB00268NAS3
Component:: 060000 engine (pws)
Summary:: "situation: on vehicles fitted with the 4.2l naturally aspirated engine only, the engine may experience a rough start or stall following a hot soak of 15-20 minutes. cause: this may be caused by the fueling calibration not being robust fo
Bulletin:: SSM69078
Component:: 118000 electrical system: software
Summary:: "issue: apple ios, and android phone issues after software updates. the customer may report a range of problems with their phone connection, audio quality or phonebook which have started to happen after the phone was manually or automa
Bulletin:: SSM70698
Component:: 110000 electrical system
Summary:: "issue: a customer may report that their phone, disconnects during or after phone calls, shows as paired but not available, is not showing as paired but is available, is difficult to pair, audio fragments when streaming music and/or ot
Bulletin:: SSM 71218
Component:: 050000 parking brake
Summary:: "issue: customer repor ts a parkbrake warning lamp i l luminated and / or parkbrake faul t message displayed in the ipk (instrument pack), following investigation wi th sdd the fol lowing dtc p1571-64 (brake swi tch - signal plausibilit
Bulletin:: SSM-71598
Component:: 103000 power train:automatic transmission
Summary:: "issue: following the recent k202 campaign a few customers have reported continuing problems with the transmission control switch unit(s) fails to rise or initially rises before lowering itself back to its default position for an igniti
Bulletin:: "JAGUAR PRODUCT
Component:: 355200 equipment:other:owners/service/other manual
Summary:: Technical updates related to bulletins referenced in document.
Bulletin:: SSM58558
Component:: 030000 brakes (pws)
Summary:: Issue: submitting a brake noise epqr
Bulletin:: SFCC_14DEC17
Component:: 355200 equipment:other:owners/service/other manual
Summary:: Presentation from dealer shop foreman conference call
Bulletin:: SFCC_08MAR18
Component:: 355200 equipment:other:owners/service/other manual
Summary:: Jaguar land rover shop foreman conference call
Bulletin:: SFCC_09AUG18_REV
Component:: 350000 equipment
Summary:: Incontrol touch pro phase 4 customer letter
Bulletin:: SFCC_09AUG18_REV
Component:: 350000 equipment
Summary:: Sim card activation issues
Bulletin:: SFCC_09AUG18_REV
Component:: 110000 electrical system
Summary:: 18c - new face of incontrol touch pro and 18c software improvements
Bulletin:: SFCC_09AUG18_REV
Component:: 110000 electrical system
Summary:: A customer may report "hood open" message displays on ip with hood closed.
Bulletin:: SSM71538
Component:: 350000 equipment
Summary:: Issue: customer may report door lock cylinder cover missing or has become adrift.
Bulletin:: SSM71538 Attachm
Component:: 350000 equipment
Summary:: Issue: customer may report door lock cylinder cover missing or has become adrift.
Bulletin:: SSM71538 Attachm
Component:: 350000 equipment
Summary:: Issue: customer may report door lock cylinder cover missing or has become adrift.
Bulletin:: SSM71538.1
Component:: 350000 equipment
Summary:: Issue: customer may report door lock cylinder cover missing or has become adrift.
Bulletin:: SSM71538.1 Attac
Component:: 350000 equipment
Summary:: Issue: customer may report door lock cylinder cover missing or has become adrift.
Bulletin:: SSM71538.1 Attac
Component:: 350000 equipment
Summary:: Issue: customer may report door lock cylinder cover missing or has become adrift.

Home | Privacy