2007 INTERNATIONAL PROSTAR Recalls (3)

Campaign:
07V179000 on 04/24/2007
Component:
Suspension:rear:axle:non-powered axle assembly
Manufactured:
11/14/2006 - 02/18/2007
Affected:
1,172
Defect:
On certain trucks, one or both rear axle housings may contain thinner material than what is necessary for normal vehicle operation. over time, this thinner material may result in a fatigue failure of the rear axle housing, possibly in the location of the brake flange.
Consequence:
A crack in the brake flange location of the rear axle housing may result in a wheel end lockup or wheel separation possibly resulting in property damage, personal injury, or death.
Correction:
Dealers will inspect the vehicle's rear axles and, if necessary, replace the axle housings. the recall began on may 18, 2007. owners may contact international at 1-800-448-7815.
Notes:
International recall no. 07505.customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.
Campaign:
07V180000 on 04/24/2007
Component:
Fuel system, diesel
Affected:
700
Defect:
On certain trucks equipped with davco fuel pro 382 heated fuel filters, when the key is in the 'on' position, the pre-heater, located in the fuel filter base, is energized.
Consequence:
If this pre-heater is energized while maintenance is being performed on the fuel filter, diesel fuel could ignite within the filter housing. a fire within the fuel filter housing may spread possibly resulting in property damage or personal injury.
Correction:
Dealers will inspect the fuel filters and fuel heaters and, if necessary, will replace the fuel heater. the recall began on may 11, 2007. owners may contact international at 1-800-448-7825.
Notes:
International recall no. 07506.customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.
Campaign:
08V258000 on 06/08/2008
Component:
Electrical system
Manufactured:
11/20/2000 - 05/20/2008
Affected:
51,588
Defect:
Navistar is recalling 51,588 heavy trucks, commercial buses and school buses manufactured between november 21, 2000 and may 21, 2008, equipped with one or more remote power modules. the potting material that encapsulates the circuit board of the vehicle's remote power module may not sufficiently seal the circuit board from water and contamination intrusion. if the encapsulation is compromised, water and contaminants may cause an internal electrical short, possibly resulting in a fire.
Consequence:
A fire could cause personal injury or death.
Correction:
Navistar will notify owners and repair the vehicles free of charge. the recall began on july 10, 2008. owners may contact navistar at 1-280-461-1890.
Notes:
Navistar recall no. 08505.customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.

2007 INTERNATIONAL PROSTAR TSBs (189)

Bulletin:
IK0800130
Component:
110000 electrical system
Summary:
International - air pressure gauges & a/c pressure transducer troubleshooting on post-2007 hpv and prostar. *nj
Bulletin:
IK0800131
Component:
110000 electrical system
Summary:
Lose all of gauges when hooked up with dlb. applies to all vehicles with esc's or bc's. *pe
Bulletin:
IK-1500040
Component:
071110 fuel system, gasoline:storage:tank assembly:filler pipe and cap
Summary:
International: three inch fuel tank fill cap gasket cracking. applies to heavy duty models. some of the three inch fuel fill cap gaskets have been cracking. used primarily on heavy duty vehicles like 5000, 8000, 9000 and prostar. *pe
Bulletin:
TSI-08-05-01
Component:
015200 steering:hydraulic power assist:hose, piping, and connections
Summary:
Navistar: prostar power steering cooler hoses. *pe
Bulletin:
TSI-08-05-02
Component:
015000 steering:hydraulic power assist system
Summary:
Navistar: power steering intermediate shaft u joint end play measurement. *pe
Bulletin:
AFC-08914
Component:
023100 suspension:multiple axle:torque arm
Summary:
Navistar: mislocated torque rod bracket on certain prostar and 9000 models. requires an inspection to determine if the torque rod bracket was mislocated on dana 40k and 46k tandem axles. model years unknown. *pe
Bulletin:
IK-0300023
Component:
061200 engine and engine cooling:engine:diesel
Summary:
International: lower front shock mount bending on prostar s models (113) bbc w/all engines and prostar models (122) bbc w/caterpillar c15 engines. prostar models with caterpillar c15 engines will only have the issue on the right side.
Bulletin:
IK-0800158
Component:
046400 service brakes, air:antilock:abs warning light
Summary:
International: icon will not function properly. abs lights come on when icon starts or stops. unit shuts down before icon parameter is reached. if you have more than one hour in troubleshooting and do not have a good direction to follow
Bulletin:
SB-IK-0400063
Component:
031000 service brakes, hydraulic:pedals and linkages
Summary:
International: brake pedal not returning and sticking slightly in the applied position. brake pedal not returning and binding. brake light staying on. model prostar, no model years listed. *pe update 02/17/10. *pe updated 7
Bulletin:
IK-0800194
Component:
110000 electrical system
Summary:
International truck: intermittent or no front blower operation. outlines the process for troubleshooting the front blower on prostar, lonestar, durastar, transtar, and workstar models. no model years listed. *pe
Bulletin:
AFC-09908
Component:
061200 engine and engine cooling:engine:diesel
Summary:
Navistar: implementation of engine recalibration. this will require the recalibration of the engine ecm. in cold weather conditions, the software upgrade will ensure proper lubrication of the turbocharger by delaying accelerator pedal res
Bulletin:
IK-1600114
Component:
131000 visibility:windshield
Summary:
International: fixed vent window 016hkr replacement and rebonding instructions. unwanted air, noise, or water intrustion. model years not listed. *pe
Bulletin:
IK-1200431
Component:
061200 engine and engine cooling:engine:diesel
Summary:
Navistar: cummins air temperature sensor located rear of vehicle, instead of front, on some models. this can be mistaken for a ground connector. do not bolt this sensor to ground. should remain strapped to harness. *pe
Bulletin:
IK-1900136
Component:
061200 engine and engine cooling:engine:diesel
Summary:
Navistar int'l: developed in response to reports of intermittent or inoperable front blower motors on prostar and lonestar models built 12/10/07-12/04/09. provides general troubleshoooting procedure for the hvac blower circuit that can be
Bulletin:
AFC-10910
Component:
061200 engine and engine cooling:engine:diesel
Summary:
Navistar: some engines may experience engine over-heating due to the fan clutch not actuating. *rm updated 5/23/11. *pe
Bulletin:
IK-0800279
Component:
118000 electrical system: software
Summary:
International truck: there is a body controller software revision. *rm also included model durastar model year 2008. updated 3/11/2014 *js updated 8/04/2014 *js
Bulletin:
IK-0400057
Component:
040000 service brakes, air
Summary:
Navistar: the brake lights stay on and are not working. there are problems with voltage. *rm updated 10/15/12. *pe updated 11/6/2013 *js
Bulletin:
SB-IK-0800293-2
Component:
110000 electrical system
Summary:
Navistar: troubleshooting for intermittent or no front blower operation. *rm
Bulletin:
IK-0400087
Component:
022130 suspension:rear:springs:air suspension system
Summary:
Navistar: need to remount or realign the air suspension pressure sensor horizontal and not vertical. *pe updated 4/9/12. *js
Bulletin:
IK-1500035
Component:
071210 fuel system, gasoline:storage:auxillary tank:selector devices
Summary:
Navistar: trucks equipped with electric fuel transfer pump for two tanks, the fuel is balance between both tanks. the engine is supplied fuel directly from the draw tank. hpv, ngv and prostar. *pe updated 2/18/14. *pe update
Bulletin:
AFC-11929
Component:
060000 engine and engine cooling
Summary:
Navistar: hvac front inside module drain repair. *kb
Bulletin:
AFC-12902
Component:
060000 engine and engine cooling
Summary:
Navistar: maxxforce 11, 13, and 15 recalibration to adress frequent warning lights. *kb
Bulletin:
IK-0800334
Component:
115000 electrical system:fuses and circuit breakers
Summary:
Incorrect 5amp fuse at location f11-d on wabco 6 sensor 6 modulater. *kb
Bulletin:
IK-0700047
Component:
060000 engine (pws)
Summary:
International: on the aftertreatment support hanger, the horizontal aftertreatment support rod bolt is loose or backed out, due to possible wear and needs to be replaced, if necessary. *pe updated 02/07/2014 *js
Bulletin:
IK-0500043
Component:
015200 steering:hydraulic power assist:hose, piping, and connections
Summary:
International: information being provided regarding the rusting of power steering hoses that needs to be removed and replaced. model prostar. no model years listed. *pe
Bulletin:
IK-0800382
Component:
111100 electrical system:battery:cables
Summary:
International: battery cables routed too close to spring hanger shackle bolt for left-sided battery box or 8600 boc battery box. model pro-star113 garland built. no model years listed. *pe
Bulletin:
IK-0800383
Component:
111100 electrical system:battery:cables
Summary:
International: spring hanger shackle bolt may have battery cables routed too close for left sided battery box or 8600 lsm boc battery box for excobedo built prostar 113. no model years listed. *pe
Bulletin:
IK-1500067
Component:
080000 fuel system, diesel
Summary:
International: information regarding the fuel system components and repairs to correct interference to avoid fuel line contact wear. model prostar. no model years listed. *pe
Bulletin:
IK0900075
Component:
062200 engine and engine cooling:cooling system:fan
Summary:
Iknow: stratis fan hub diagnostics. horton 12 thx vmaster ultra (stratis) viscous fan drive troubleshooting guide. *js updated 12/16/13. *pe
Bulletin:
IK1600170
Component:
160000 structure
Summary:
Iknow: sleeper side sill/underbody cross-member weld check and repair. the welds described herein are neither durability nor safety critical welds. *js
Bulletin:
IK-0800415
Component:
126000 exterior lighting:turn signal
Summary:
International: the turn signal lamps and hazards fails to illuminate and/or work properly. model 2007 and newer hpv, prostar, lonestar. *pe
Bulletin:
IK-1900088
Component:
136100 visibility:windshield wiper/washer:switch/wiring
Summary:
International: windshield wipers, due to washer input to esc staying on all the time, will not come on at all, or on either high or low all the time. models 20o7 hpv, prostar. *pe updated 09/18/2013 *js
Bulletin:
IK-0800418
Component:
123000 exterior lighting:tail lights
Summary:
Iknow: replacing truck -lite tail lights with weldon tail lights. if changing from truck-lite to weldon for the first time on a vehicle, two retrofit conversion kits should be ordered. *js
Bulletin:
IK-0800418
Component:
123000 exterior lighting:tail lights
Summary:
International: weldon tail lights are replacing the truck lite on some trucks built before 2/21/13. model prostar. no model years listed. *pe updated 07/23/2013 *js updated 09/11/2013 *js
Bulletin:
IK-0400119
Component:
030000 brakes (pws)
Summary:
Iknow: prostar brake assembly conversion. the weld may be cracking in the stamped s-cam tube bracket. the stamped spider brake assembly should be converted to a cast spider brake assembly. *js
Bulletin:
IK-1900205
Component:
135200 visibility:rearview mirrors/devices:exterior
Summary:
Iknow: install kit in order to alleviate loose, vibrating, or rattling of the hood-mounted mirrors. *js
Bulletin:
IK-08000422
Component:
111000 electrical system:battery
Summary:
Iknow: the battery cube fuse stud terminal with the alternative part needs to be replaced. some vehicles may experience a shorted fuse because the installation was improper. models include all prostars (prior to scr release) *js
Bulletin:
IK-1600183
Component:
160000 structure
Summary:
Iknow: repair procedures for complaints of foul odors in the cab. applies to post 2010 prostar/transtar. *js
Bulletin:
IK-0800427
Component:
110000 electrical system
Summary:
International: there are code faults, caused by load shedding, loaded in other modules and unit goes into load shed and fails to have power in switches. model prostar, lonestar. no years listed. *pe
Bulletin:
IK-0800465
Component:
102000 power train:manual transmission
Summary:
Navistar: steering wheel will not have shift controls due to phoenix shifter being programmed to look for steering wheel mounted shift controls and if an error is detected, a fault will be set. model prostar. *pe updated 9/14/15
Bulletin:
IK-0900094
Component:
062200 engine and engine cooling:cooling system:fan
Summary:
Ik: repair information regarding the missing or loose bolt attaching horton stratis anti rotation bracket (arb) to engine. model prostar, workstar, lonestar. no years listed. *pe updated 6/27/2014 *js updated 11/7/14. *pe
Bulletin:
IK-0400023
Component:
355100 equipment:other:labels
Summary:
Iknow: the brake controller may have fused labeled as 30 amp fuse. it should be labeled as 15 amp fuse in the f8-b location. *js
Bulletin:
IK-0900018
Component:
356000 equipment adaptive
Summary:
International: the upper radiator pipe breaks, on some trucks, at either the flange mates to engine or support bracket welded to pipe. model 2006-2007 prostar. *pe updated 1/30/15. *pe
Bulletin:
IK0400125
Component:
030000 brakes (pws)
Summary:
Navistar: various types navistar vehicles will be receiving updates on the rear s cam tube/ bracket parts. *ta updated 9/10/15 *cn
Bulletin:
IK0800172
Component:
115000 electrical system:fuses and circuit breakers
Summary:
Navistar: various types of vehicles including lonestar, prostar, 8600, and 7600 vehicles will need an operation to improve the cab circuit grounds. 7/17/15 *ta
Bulletin:
MIN15101
Component:
103600 power train:automatic transmission:cooling unit and lines
Summary:
Navistar: some navistar prostar vehicles with the cummins isx 15l engines installed were built with the front left frame crossmember bolt installed in the wrong direction. *ta
Bulletin:
IK-1200915
Component:
060000 engine (pws)
Summary:
Misfire diagnostics ibb; spn132(x) - fmi 31
Bulletin:
IK-1200991
Component:
060000 engine (pws)
Summary:
Diagnosing hard start / no start, rough idle complaints or icp pressure concerns
Bulletin:
IK-1201042
Component:
060000 engine (pws)
Summary:
Crankshaft and camshaft position sensor air gap specifications
Bulletin:
IK-1201117
Component:
063110 engine and engine cooling:exhaust system:emission control:crankcase (pcv)
Summary:
Ik1201117 - open crankcase breather
Bulletin:
IK-1201253
Component:
063200 engine and engine cooling:exhaust system:manifold/header/muffler/tail pipe
Summary:
Ik1201253 - exhaust manifold service procedures
Bulletin:
IK-1201314
Component:
355200 equipment:other:owners/service/other manual
Summary:
Performing relative compression test and misfire test with cpa tool
Bulletin:
IK-1201326
Component:
355200 equipment:other:owners/service/other manual
Summary:
Ik1201326 - service parts damaged new turbocharger oil supply tube
Bulletin:
IK-1500051
Component:
355200 equipment:other:owners/service/other manual
Summary:
Ik1500051 - davco fuel pro 382 technical manual, installation, diagnostics, and service
Bulletin:
IK0800475
Component:
110000 electrical system
Summary:
Radio diagnostics and information
Bulletin:
IK1200029
Component:
062100 engine and engine cooling:cooling system:radiator assembly
Summary:
Radiator internal restriction and flush procedure
Bulletin:
IK0400057
Component:
040000 service brakes, air
Summary:
New brake light operation; prostar and lonestar with air brakes
Bulletin:
IK0400057
Component:
030000 brakes (pws)
Summary:
Newer brake light operation
Bulletin:
IK0800130
Component:
353600 equipment:air conditioner
Summary:
Air pressure gauges and a/c pressure transducer troubleshooting
Bulletin:
IK1600023
Component:
135000 visibility:rearview mirrors/devices
Summary:
Mirror repair procedures and replacement parts availability
Bulletin:
IK0800279
Component:
118000 electrical system: software
Summary:
Body controller software revision 231 hvac improvements; post 2007 models only
Bulletin:
IK0800499
Component:
111000 electrical system:battery
Summary:
Battery discharge during extended storage; prostar equipped with feature 0008wen
Bulletin:
IK1600202
Component:
060000 engine (pws)
Summary:
Cowl tray seal; only built prior to 11/11/2013
Bulletin:
IK1600207
Component:
160000 structure
Summary:
Wind noise at upper side door
Bulletin:
IK0900115
Component:
062200 engine and engine cooling:cooling system:fan
Summary:
Fan shaft failure diagnostics with feature code 12thx (viscous fan drive)
Bulletin:
IK0800441
Component:
118500 electrical system: integrated trailer brake control
Summary:
Adding an electronic trailer brake controller
Bulletin:
IK0800427
Component:
356000 equipment adaptive
Summary:
Active faults during load shed
Bulletin:
IK1600207
Component:
162300 structure:body:door
Summary:
Wind noise at upper side door
Bulletin:
IK0800414
Component:
110000 electrical system
Summary:
Windows stop randomly or are inoperative, power door locks are inoperative
Bulletin:
IK0800460
Component:
114000 electrical system:wiring
Summary:
Build to vin wiring harnesses
Bulletin:
IK0900115
Component:
062200 engine and engine cooling:cooling system:fan
Summary:
Fan shaft failure diagnostics with feature code 12thx (viscous fan drive)
Bulletin:
IK0300008
Component:
060000 engine (pws)
Summary:
Vibration troubleshooting
Bulletin:
IK0400023
Component:
110000 electrical system
Summary:
Prostar wabco brake control fuse specification; only with wabco brakes controller
Bulletin:
IK0400033
Component:
190000 tires
Summary:
Automatic traction control (atc) tire size compatibility; only with feature 04azd and 04azj bendix atc
Bulletin:
IK0800478
Component:
121000 exterior lighting:headlights
Summary:
Headlight condensation or frost; excludes sealed beam headlights such as on workstar, paystar and 9900i)
Bulletin:
IK1100004
Component:
101000 power train:clutch assembly
Summary:
Clutch linkage rattle
Bulletin:
IK1100005
Component:
101000 power train:clutch assembly
Summary:
Eaton clutch information
Bulletin:
IK1600002
Component:
356000 equipment adaptive
Summary:
Prostar air deflector mounting procedure (rattling noise from air deflector or bulging between fasteners)
Bulletin:
IK1600008
Component:
356000 equipment adaptive
Summary:
Bottom bunk rattle on prostar; only models built prior to 12-11-07
Bulletin:
IK1600034
Component:
356000 equipment adaptive
Summary:
Rubbing between front and rear skirts on prostar
Bulletin:
IK1600036
Component:
356000 equipment adaptive
Summary:
Skirt, hood, and fender extension adjustment procedure
Bulletin:
IK1600049
Component:
356000 equipment adaptive
Summary:
Prostar side skirt paint mismatch
Bulletin:
IK1600062
Component:
356000 equipment adaptive
Summary:
Push-in trim fasteners popping out or missing
Bulletin:
IK1600063
Component:
353600 equipment:air conditioner
Summary:
Sleeper curtain getting sucked into hvac duct
Bulletin:
IK1600064
Component:
353600 equipment:air conditioner
Summary:
No idle curtains missing velcro; only models with feature 16uzl - no idle hvac
Bulletin:
IK1600065
Component:
162800 structure:body:hood
Summary:
Sleeper buzz, squeak, rattle
Bulletin:
IK1600066
Component:
356000 equipment adaptive
Summary:
Drawer rattle
Bulletin:
IK1600067
Component:
356000 equipment adaptive
Summary:
Work surface rattle
Bulletin:
IK1600095
Component:
170000 latches/locks/linkages
Summary:
Work surface latch jammed - replacement
Bulletin:
IK0800092
Component:
251000 electronic stability control:automatic (asc)
Summary:
The first check to make when troubleshooting any body controller or esc issue
Bulletin:
IK1500005
Component:
092100 fuel system, other:delivery:fuel pump
Summary:
Dual fuel tank transfer pump system with two wire pump troubleshooting; equipped with feature 595192 built after 08/19/2002
Bulletin:
IK1500035
Component:
090000 fuel system, other
Summary:
Dual fuel tank transfer pump troubleshooting on post-2007 ngv and prostar
Bulletin:
IK0400057
Component:
125000 exterior lighting:brake lights
Summary:
Brake light operation on hpv, prostar and lonestar
Bulletin:
IK0400057
Component:
120000 exterior lighting
Summary:
Newer brake light operation
Bulletin:
IK0400146
Component:
060000 engine (pws)
Summary:
N13, maxxforce 11, 13 engine two cylinder air compressor testing
Bulletin:
IK0700032
Component:
063000 engine and engine cooling:exhaust system
Summary:
Dpf snap accel test - quick test to all vehicles with dpfs
Bulletin:
IK0800296
Component:
353600 equipment:air conditioner
Summary:
Hvac faults 520211 and 520465
Bulletin:
IK1100005
Component:
101000 power train:clutch assembly
Summary:
Eaton clutch information
Bulletin:
IK1600023
Component:
356000 equipment adaptive
Summary:
Mirror repair procedures and replacement parts availability
Bulletin:
IK1900212
Component:
060000 engine and engine cooling
Summary:
Front blower motor runs breifly at initial power up
Bulletin:
IK1900218
Component:
356000 equipment adaptive
Summary:
Espar airtronic low run time.
Bulletin:
IK0400133
Component:
356000 equipment adaptive
Summary:
Collision avoidance wingman flr-10 to flr 20 retrofit
Bulletin:
IK0800080
Component:
110000 electrical system
Summary:
1939 data link troubleshooting
Bulletin:
IK0800185
Component:
130000 visibility/wiper (pws)
Summary:
Wipers and aftertreatment lights inop on post 2007 trucks with body controller
Bulletin:
IK0800279
Component:
118000 electrical system: software
Summary:
Body controller software revision 231 hvac improvements for post 2007 prostar, durastar, transtar only
Bulletin:
IK0800485
Component:
356000 equipment adaptive
Summary:
Cluster issues
Bulletin:
IK1900015
Component:
353600 equipment:air conditioner
Summary:
Activate hvac front blower message in dash message center; with sleeper cab only
Bulletin:
IK1900019
Component:
353600 equipment:air conditioner
Summary:
Sleeper hvac blower will not run on high with engine off; with sleeper cab only
Bulletin:
IK1201360
Component:
355200 equipment:other:owners/service/other manual
Summary:
Cylinder performance analyzer (cpa) resource center; only models with 2004 thru 2017 international engines.
Bulletin:
IK1201363
Component:
070000 fuel system, gasoline
Summary:
Cpa injector misfire detection; only models with 2004 thru 2017 international engines.
Bulletin:
IK1900022
Component:
353600 equipment:air conditioner
Summary:
A/c refrigerant and oil capacities
Bulletin:
IK2700090
Component:
355200 equipment:other:owners/service/other manual
Summary:
Oncommand ez-tech download center
Bulletin:
IK2700100
Component:
355200 equipment:other:owners/service/other manual
Summary:
Oncommand eztech
Bulletin:
IK2900030
Component:
118000 electrical system: software
Summary:
Dealer ez-tech and diagnostic software support resource center
Bulletin:
IK0800427
Component:
356000 equipment adaptive
Summary:
Active faults during load shed
Bulletin:
IK1600023
Component:
162000 structure:body
Summary:
Mirror repair procedures and replacement parts availability
Bulletin:
IK0800341
Component:
110000 electrical system
Summary:
Trailer auxiliary switch lamp burning out; only vehicles equipped with feature code 0008tth or 0008thg
Bulletin:
IK0800080
Component:
118000 electrical system: software
Summary:
J1939 data link troubleshooting
Bulletin:
IK1200921
Component:
118000 electrical system: software
Summary:
Isx, n13, and n9 / n10 aftertreatment private data link troubleshooting
Bulletin:
IK1201009
Component:
060000 engine (pws)
Summary:
Winter front usage
Bulletin:
IK1201299
Component:
060000 engine (pws)
Summary:
Engine oil capacities
Bulletin:
IK2700100
Component:
118000 electrical system: software
Summary:
Oncommand ez-tech
Bulletin:
IK4300001
Component:
118000 electrical system: software
Summary:
Updating oncommand link with accelerator
Bulletin:
IK0500038
Component:
010000 steering
Summary:
Steering shake, shimmy, shudder, or steering vibration; only with 14k front weight rated axles and below
Bulletin:
IK0500058
Component:
010000 steering
Summary:
Steering fluids
Bulletin:
IK0800080
Component:
118000 electrical system: software
Summary:
J1939 data link troubleshooting
Bulletin:
IK0800351
Component:
118000 electrical system: software
Summary:
J1939 data link source address information
Bulletin:
IK1201248
Component:
062000 engine and engine cooling:cooling system
Summary:
Cooling system flush procedure
Bulletin:
IK2500511
Component:
118000 electrical system: software
Summary:
Using supplier software to check dtcs
Bulletin:
IK0800014
Component:
341000 communications:horn assembly
Summary:
City horn blows when driver shuts off truck and walks away; only equipped with with esc or body controller
Bulletin:
IK0800056
Component:
117000 digital instrument panel
Summary:
Retrieving fault codes through the cluster doesn?t work
Bulletin:
IK0800196
Component:
110000 electrical system
Summary:
Asterisk in lower right quadrant of dash display
Bulletin:
IK0800352
Component:
110000 electrical system
Summary:
Body controller/esc software updates
Bulletin:
IK0900018
Component:
062100 engine and engine cooling:cooling system:radiator assembly
Summary:
Prostar upper radiator pipe cracking or breaking at support bracket or at flange area; only prostars built before 8/28/07
Bulletin:
Rec17V-792_2017-
Component:
350000 equipment
Summary:
The fire extinguishers may become clogged or require excessive force to activate. in certain models, the nozzle may detach from the valve assembly with enough force that it could cause injury and also render the product inoperable. only equ
Bulletin:
IK0800080
Component:
118000 electrical system: software
Summary:
J1939 data link troubleshooting
Bulletin:
IK0700096
Component:
110000 electrical system
Summary:
Urea quality sensor (uqs) supplemental diagnostic and service information; only models with scr aftertreatment system and n9, n10, n13, a26 or cummins isb, isl, isx engines built from january 2016
Bulletin:
IK0700097
Component:
061200 engine and engine cooling:engine:diesel
Summary:
New ultrasonic def tank sending unit; only models with scr aftertreatment system.
Bulletin:
IK0800546
Component:
060000 engine and engine cooling
Summary:
Hvac fault 2609-19 with 4th gen bcm; only models equipped with 4th generation bcm
Bulletin:
IK0800080
Component:
353000 equipment:electrical
Summary:
J1939 data link troubleshooting
Bulletin:
IK0800119
Component:
020000 suspension
Summary:
Prostar and nhpv with suspension dump feature code 595aca or 595bbc
Bulletin:
IK0800485
Component:
118000 electrical system: software
Summary:
Cluster software update instructions
Bulletin:
IK0800080
Component:
118000 electrical system: software
Summary:
J1939 data link troubleshooting; only models with 250k baud data link (black 9 pin diagnostic connector)
Bulletin:
IK0800374
Component:
355200 equipment:other:owners/service/other manual
Summary:
To get a helios capture; all 1939 and 1708 multiplexed trucks only
Bulletin:
IK0500049
Component:
010000 steering
Summary:
Luk/ixetic power steering pump fittings; only vehicles equipped with maxxforce 11, 13 engines
Bulletin:
IK1200271
Component:
180000 vehicle speed control
Summary:
Remote throttle control options for vehicles with esc?s or body controllers and international engines
Bulletin:
IK1500002
Component:
080000 fuel system, diesel
Summary:
Fuel level not equal between tanks on dual draw dual return dual tank systems.
Bulletin:
IK1600023
Component:
135200 visibility:rearview mirrors/devices:exterior
Summary:
Mirror repair procedures and replacement parts availability
Bulletin:
IK0800478
Component:
121000 exterior lighting:headlights
Summary:
Headlight condensation or frost; excludes sealed beam headlights such as on workstar, paystar and 9900i)
Bulletin:
IK0900030
Component:
160000 structure
Summary:
In chassis cleaning procedure for cooling package in all models with maxxforce 11, 13 engines
Bulletin:
IK1300016
Component:
100000 power train
Summary:
New synthetic oil for eaton and spicer transmissions; only with eaton or spicer transmissions
Bulletin:
IK1300021
Component:
102000 power train:manual transmission
Summary:
Transmission keeps shifting and display keeps flashing after ignition is turned off; only with freedom line transmission
Bulletin:
IK1300029
Component:
102000 power train:manual transmission
Summary:
Roll pins backing out of bell crank; only with manual transmission
Bulletin:
IK0400057
Component:
040000 service brakes, air
Summary:
2007 and newer brake light operation; only equipped with air brakes
Bulletin:
IK0800037
Component:
110000 electrical system
Summary:
Location of 1000 ohm resistor in the hvac wiring
Bulletin:
IK0800043
Component:
111000 electrical system:battery
Summary:
How to add lift gate battery protection; only models equipped with electronic system controller (esc) or body controller (bc).
Bulletin:
IK0800047
Component:
110000 electrical system
Summary:
Remote power module (rpm) troubleshooting
Bulletin:
IK0800119
Component:
020000 suspension
Summary:
Suspension dump; only models with programming feature 595aca (suspension dump).
Bulletin:
IK0800414
Component:
110000 electrical system
Summary:
Power windows stop randomly or are inoperative, power door locks are inoperative
Bulletin:
IK0900075
Component:
060000 engine (pws)
Summary:
Horton stratis fan hub diagnostics
Bulletin:
IK0700002
Component:
063000 engine and engine cooling:exhaust system
Summary:
Proper exhaust shield orientation
Bulletin:
IK0800064
Component:
110000 electrical system
Summary:
Battery drain ( parasitic drain) with sleeper refrigerator; only models with optional refrigerator
Bulletin:
IK0800201
Component:
353000 equipment:electrical
Summary:
Disable cummins icon; only models equipped with cummins engine and with icon installed.
Bulletin:
IK0800246
Component:
103000 power train:automatic transmission
Summary:
Manual mode button on the eaton shift console is flashing with no active codes in the tcm. with active code 3655, 3654 or 3656 in the body controller; only models with eaton ultra and auto shift transmissions
Bulletin:
IK0800296
Component:
353600 equipment:air conditioner
Summary:
Hvac faults 520211 and 520465; only models with body controllers
Bulletin:
IK0900007
Component:
060000 engine and engine cooling
Summary:
Ethylene glycol coolant color change to be phased-in approximately april 1, 2004
Bulletin:
IK1500005
Component:
070000 fuel system, gasoline
Summary:
Dual fuel tank transfer pump system with two wire pump troubleshooting; only models built with feature code: 595192
Bulletin:
IK1500035
Component:
070000 fuel system, gasoline
Summary:
Dual fuel tank transfer pump troubleshooting
Bulletin:
IK0800139
Component:
060000 engine and engine cooling
Summary:
Remote engine speed control module (rescm) troubleshooting; only trucks equipped with rescm
Bulletin:
IK0800414
Component:
133000 visibility:power window devices and controls
Summary:
Power windows stop randomly or are inoperative, power door locks are inoperative
Bulletin:
IK0300004
Component:
020000 suspension
Summary:
Drive axle and steer axle air suspension ride height settings; only models equipped with feature code 03azd and 03azg, hendrickson maxxpower' front air suspension.
Bulletin:
IK0800366
Component:
133000 visibility:power window devices and controls
Summary:
Power windows randomly stop
Bulletin:
IK0800404
Component:
110000 electrical system
Summary:
Circuit diagram for prostar/lonestar fifth wheel; link to missing diagram.
Bulletin:
IK1200634
Component:
355200 equipment:other:owners/service/other manual
Summary:
Aftertreatment resource center; all models equipped with epa 2007 and newer engines
Bulletin:
IK1600170
Component:
160000 structure
Summary:
Sleeper side sill/underbody cross-member weld check and repair
Bulletin:
IK1600171
Component:
060000 engine and engine cooling
Summary:
Espar heater; only models with feature code 16uzl
Bulletin:
IK0800201
Component:
110000 electrical system
Summary:
Disable cummins icon; only models equipped with cummins engine and with icon installed.
Bulletin:
IK0800414
Component:
110000 electrical system
Summary:
Power windows stop randomly or are inoperative, power door locks are inoperative
Bulletin:
IK0800468
Component:
353000 equipment:electrical
Summary:
Dash cluster stuck in one mode
Bulletin:
IK1600023
Component:
135000 visibility:rearview mirrors/devices
Summary:
Mirror repair procedures and replacement parts availability; only models with lang mekra mirrors
Bulletin:
IK1600177
Component:
134000 visibility:sun roof assembly
Summary:
Skyrise roof replacement
Bulletin:
IK1600202
Component:
161000 structure:frame and members
Summary:
Water entry into the cab / adding cowl tray seal; models built prior to 11/11/2013
Bulletin:
IK0800111
Component:
100000 hybrid powertrain: inverter
Summary:
Inverter/charger power system
Bulletin:
IK0800411
Component:
110000 electrical system
Summary:
Body controller resource center
Bulletin:
IK0800412
Component:
110000 electrical system
Summary:
Headlight operation and troubleshooting; only post 2007 vehicles built with a body controller
Bulletin:
IK0800414
Component:
110000 electrical system
Summary:
Power windows stop randomly
Bulletin:
IK0800475
Component:
353400 equipment:electrical:radio/tape deck/cd etc.
Summary:
Radio diagnostics and information
Bulletin:
IK1201299
Component:
060000 engine (pws)
Summary:
Engine oil capacities all electronic international engines 1994 - present. cummins isb, ism & isx
Bulletin:
IK1900022
Component:
060000 engine (pws)
Summary:
A/c refrigerant and oil capacities

Home | Privacy