2007 IC FECB Recalls (6)

Campaign:
06V479000 on 12/20/2006
Component:
Seats
Manufactured:
10/10/2005 - 10/30/2006
Affected:
1,948
Defect:
Certain ic school and commercial buses manufactured between october 11, 2005, and october 31, 2006. these buses have the following safety issues: if the driver's seat is in the highest and most rear position, the back of the seat may lean against a barrier behind the seat, or against the seat back. this will prevent the seat belt from retracting which fails to conform to federal motor vehicle safety standard no. 209, seat belt assemblies. when adjust the seat to a higher position, the driver may pull the seat past the last stop so that the seat sits on the adjusting pin, which allows the seat to teeter on top of the pin. if over-travel occurs, the upper seat pedestal tube could separate from the lower pedestal tube during vehicle operation. if the driver is sitting in the driver's seat and reaches to adjust the seat height, their weight will cause the seat to drop, which could result in their hand being pinched between the seat and the lever. the driver's seat is difficult to adjust to a higher position because of the additional weight of the all belts to seat (abts) design.
Consequence:
This may result in personal injury.
Correction:
Ic will notify owners and repair the seats free of charge. the recall began on february 23, 2007. owners may contact ic at 1-800-448-7825.
Notes:
Ic recall no. 06512.customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.
Campaign:
07V067000 on 02/25/2007
Component:
Structure:body:door
Manufactured:
03/11/2004 - 11/28/2006
Affected:
6,184
Defect:
Certain my 2004-2007 ic ce, re, and fe commercial and school buses manufactured between march 12, 2004, and november 29, 2006. the side emergency door holdback mechanism may not be installed in the proper location. this may cause the mechanism to hold the door in the closed position.
Consequence:
If the door is held in the closed position, it may not perform its intended emergency function, possibly resulting in property damage, personal injury or death.
Correction:
Ic will notify owners and repair the affected buses free of charge. the recall began on march 16, 2007. owners can contact ic at 1-800-843-5615 or international at 1-800-448-7825.
Notes:
International recall no. 07503.customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.
Campaign:
08V011000 on 01/09/2008
Component:
Equipment adaptive
Manufactured:
07/10/2005 - 07/30/2006
Affected:
1,027
Defect:
International is recalling 1,027 my 2006-2007 be, ce, fe, and re school and commercial buses manufactured from july 11, 2005 through july 31, 2006, and equipped with braun platform lifts for failing to comply with the requirements of federal motor vehicle safety standard no. 404, "platform lift installations in motor vehicles." a passenger can approach the exposed lift doorway without the audible alarm alerting them of their proximity to the threshold.
Consequence:
Should the threshold warning system fail to operate, the lift user can fall from the vehicle and be seriously injured.
Correction:
International is working with braun corporation to have the doorway lift fixed free of charge (please see 06e094). owners may contact braun corporation at 1-800-946-7513 or international at 1-800-448-7825.
Notes:
International recall no. 07516.customers may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov.
Campaign:
08V089000 on 02/26/2008
Component:
Engine and engine cooling
Manufactured:
08/09/2006 - 04/23/2007
Affected:
34,993
Defect:
International is recalling 34,993 my 2006-2008 school and transit buses and heavy duty trucks/tractors manufactured between june 1, 2006 and june 28, 2007, equipped with international dt466 or dt570 engines. the base plate of the engine oil cooler may crack allowing pressurized oil to leak into the engine compartment.
Consequence:
This condition may cause either engine shut down without warning, or in extreme cases, possible engine fire which can lead to property damage, personal injury, or death.
Correction:
International will notify owners and repair the vehicles free of charge. the recall began on november 21, 2008. owners may contact international at 800-448-7825.
Notes:
International recall no. 08502.customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.
Campaign:
09V052000 on 02/09/2009
Component:
Equipment:electrical
Manufactured:
02/01/2000 - 06/01/2008
Affected:
61,316
Defect:
Navistar is recalling 61,316 my 2001 through 2009 ic be, ce, and fe model commercial and school buses manufactured between february 2, 2000 and june 2, 2008, equipped with an entrance door stepwell heater feature code 0048pms or 0548001 and/or a rear wall mounted heater feature code 0048tar or 0048psx. the affected heater units may fail in low speed operation causing elevated temperatures.
Consequence:
Elevated temperatures can result in a fire, possibly resulting in property damage, personal injury, or death.
Correction:
An interim letter was mailed on february 20, 2009, to communicate the defect and recommend action to mitigate the risk until the final remedy and customer notification could be provided at a later date. the manufacture filed an amended defect report dated march 27, 2009 advising that a final remedy has been developed and parts are being manufactured. the safety recall began on june 2, 2009. owners may contact navistar toll-free at 1-800-448-7825.
Notes:
Navistar's recall no. 09501.owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to <a href=http://www.safercar.gov>http://www.safercar.gov</a> .
Campaign:
12V473000 on 09/27/2012
Component:
Engine and engine cooling
Manufactured:
03/15/2005 - 02/23/2009
Affected:
1,168
Defect:
Navistar is recalling certain model year 2006 through 2010 ic transit buses, models 3300, 3200im, cecb, fccb, fecb, hccb, rccb, and recb, manufactured from march 16, 2005, through february 24, 2009, equipped with i-6 engines within feature codes 12n (pl, pm, pn, pr, ps, pt, pu, pv, sa, sg, sk, sl, sm, sv, sz, tb, ua, ub, uc, and ud). the high pressure engine oil line may develop a leak or possibly rupture.
Consequence:
A leak or rupture of the high pressure engine oil line could possibly result in an unexpected engine shut down or may result in an engine compartment fire.
Correction:
Navistar will notify owners, and dealers will replace the high pressure oil line free of change. the safety recall began on december 18, 2012. navistar distributed a renotification letter to owners on october 22, 2014. owners may contact navistar at 1-331-332-1590.
Notes:
Navistar's recall campaign number is 12525.owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.

2007 IC FECB TSBs (9)

Bulletin:
IK0800475
Component:
110000 electrical system
Summary:
Radio diagnostics and information
Bulletin:
IK1200029
Component:
062100 engine and engine cooling:cooling system:radiator assembly
Summary:
Radiator internal restriction and flush procedure
Bulletin:
IK2200075
Component:
131000 visibility:windshield
Summary:
Windshield glass discoloration (fogging)
Bulletin:
Rec15V-870
Component:
356000 equipment adaptive
Summary:
Ricon public use,"s" 2000 and 5500 series lift recall
Bulletin:
IK0700096
Component:
110000 electrical system
Summary:
Urea quality sensor (uqs) supplemental diagnostic and service information; only models with scr aftertreatment system and n9, n10, n13, a26 or cummins isb, isl, isx engines built from january 2016
Bulletin:
IK0700097
Component:
061200 engine and engine cooling:engine:diesel
Summary:
New ultrasonic def tank sending unit; only models with scr aftertreatment system.
Bulletin:
IK0800546
Component:
060000 engine and engine cooling
Summary:
Hvac fault 2609-19 with 4th gen bcm; only models equipped with 4th generation bcm
Bulletin:
IK0800475
Component:
353400 equipment:electrical:radio/tape deck/cd etc.
Summary:
Radio diagnostics and information
Bulletin:
IK1201299
Component:
060000 engine (pws)
Summary:
Engine oil capacities all electronic international engines 1994 - present. cummins isb, ism & isx

Home | Privacy