2007 IC BECB Recall
- Campaign:
- 06V479000 on 12/20/2006
- Component:
- Seats
- Manufactured:
- 10/10/2005 - 10/30/2006
- Affected:
- 1,948
- Defect:
- Certain ic school and commercial buses manufactured between october 11, 2005, and october 31, 2006. these buses have the following safety issues: if the driver's seat is in the highest and most rear position, the back of the seat may lean against a barrier behind the seat, or against the seat back. this will prevent the seat belt from retracting which fails to conform to federal motor vehicle safety standard no. 209, seat belt assemblies. when adjust the seat to a higher position, the driver may pull the seat past the last stop so that the seat sits on the adjusting pin, which allows the seat to teeter on top of the pin. if over-travel occurs, the upper seat pedestal tube could separate from the lower pedestal tube during vehicle operation. if the driver is sitting in the driver's seat and reaches to adjust the seat height, their weight will cause the seat to drop, which could result in their hand being pinched between the seat and the lever. the driver's seat is difficult to adjust to a higher position because of the additional weight of the all belts to seat (abts) design.
- Consequence:
- This may result in personal injury.
- Correction:
- Ic will notify owners and repair the seats free of charge. the recall began on february 23, 2007. owners may contact ic at 1-800-448-7825.
- Notes:
- Ic recall no. 06512.customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.
2007 IC BECB TSBs (17)
- Bulletin:
- IK0800475
- Component:
- 110000 electrical system
- Summary:
- Radio diagnostics and information
- Bulletin:
- IK0400056
- Component:
- 046400 service brakes, air:antilock:abs warning light
- Summary:
- Brake light operation; only equipped with full power brake system
- Bulletin:
- IK1200029
- Component:
- 062100 engine and engine cooling:cooling system:radiator assembly
- Summary:
- Radiator internal restriction and flush procedure
- Bulletin:
- IK0400028
- Component:
- 033000 service brakes, hydraulic:power assist
- Summary:
- How to program parameters after changing a wabco fpb ecu ( park brake shows na )
- Bulletin:
- IK0800522
- Component:
- 121000 exterior lighting:headlights
- Summary:
- Repair information for damaged headlight connector
- Bulletin:
- Rec15V-870
- Component:
- 356000 equipment adaptive
- Summary:
- Ricon public use,"s" 2000 and 5500 series lift recall
- Bulletin:
- IK0800080
- Component:
- 110000 electrical system
- Summary:
- 1939 data link troubleshooting
- Bulletin:
- IK1300085
- Component:
- 050000 parking brake
- Summary:
- Wabco fpb/quadraulic brake uneven wear
- Bulletin:
- IK0700096
- Component:
- 110000 electrical system
- Summary:
- Urea quality sensor (uqs) supplemental diagnostic and service information; only models with scr aftertreatment system and n9, n10, n13, a26 or cummins isb, isl, isx engines built from january 2016
- Bulletin:
- IK0700097
- Component:
- 061200 engine and engine cooling:engine:diesel
- Summary:
- New ultrasonic def tank sending unit; only models with scr aftertreatment system.
- Bulletin:
- IK0800546
- Component:
- 060000 engine and engine cooling
- Summary:
- Hvac fault 2609-19 with 4th gen bcm; only models equipped with 4th generation bcm
- Bulletin:
- IK0800080
- Component:
- 353000 equipment:electrical
- Summary:
- J1939 data link troubleshooting
- Bulletin:
- IK0800080
- Component:
- 118000 electrical system: software
- Summary:
- J1939 data link troubleshooting; only models with 250k baud data link (black 9 pin diagnostic connector)
- Bulletin:
- IK0800374
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- To get a helios capture; all 1939 and 1708 multiplexed trucks only
- Bulletin:
- IK0800522
- Component:
- 121000 exterior lighting:headlights
- Summary:
- Repair information for damaged headlight connector
- Bulletin:
- IK0800475
- Component:
- 353400 equipment:electrical:radio/tape deck/cd etc.
- Summary:
- Radio diagnostics and information
- Bulletin:
- IK1201299
- Component:
- 060000 engine (pws)
- Summary:
- Engine oil capacities all electronic international engines 1994 - present. cummins isb, ism & isx
Home | Privacy