2007 FORD F-550 SD Recalls (3)

Campaign:
07E066000 on 08/28/2007
Component:
Equipment:electrical
Affected:
175
Defect:
Certain cequent 90 degree 7-way right angle adaptors sold by distributors in tow packages for aftermarket sales to tow 5th wheel rv travel trailers. due to incorrect wiring of the harness, the trailer lights may not operate properly.
Consequence:
If the trailer lights are not working properly, a vehicle crash can occur.
Correction:
All of the defective tow packages are still at the distributor level and have not been sold to any consumers.
Notes:
This recall only pertains to aftermarket cequent tow packages and has no relation to any original equipment installed on daimlerchrysler, gmc, or ford vehicles.customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.
Campaign:
11V352000 on 07/12/2011
Component:
Exterior lighting:tail lights
Affected:
26,715
Defect:
Ford is recalling certain model year 2011 ranger trucks built from january 25, 2011, through april 25, 2011 at the twin cities assembly plant, and service parts distributed to dealers for certain 2004 through 2011 model year ranger trucks, 2002 through 2005 model year excursion vehicles, and 2002 through 2007 model year f-250, f-350, f-450, and f-550 trucks for failing to comply with the requirements of federal motor vehicle safety standard no. 108, "lamps, reflective devices, and associated equipment." the multi-function switch was shipped with a subcomponent (slider) that may experience deformation. a multi-function switch with a deformed slider may malfunction causing the turn signal, tail lights, hazard warning signal flashers and/or brake lights not to activate.
Consequence:
Non-functioning lights could increase the risk of a crash.
Correction:
Dealers will replace the switches free of charge. the safety recall began on august 15, 2011. owners may contact ford motor company customer relationship center at 1-866-436-7332.
Notes:
Ford's safety recall no. 11c18.owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to <a href=http://www.safercar.gov>http://www.safercar.gov</a> .
Campaign:
11V352000 on 07/12/2011
Component:
Exterior lighting:brake lights
Affected:
26,715
Defect:
Ford is recalling certain model year 2011 ranger trucks built from january 25, 2011, through april 25, 2011 at the twin cities assembly plant, and service parts distributed to dealers for certain 2004 through 2011 model year ranger trucks, 2002 through 2005 model year excursion vehicles, and 2002 through 2007 model year f-250, f-350, f-450, and f-550 trucks for failing to comply with the requirements of federal motor vehicle safety standard no. 108, "lamps, reflective devices, and associated equipment." the multi-function switch was shipped with a subcomponent (slider) that may experience deformation. a multi-function switch with a deformed slider may malfunction causing the turn signal, tail lights, hazard warning signal flashers and/or brake lights not to activate.
Consequence:
Non-functioning lights could increase the risk of a crash.
Correction:
Dealers will replace the switches free of charge. the safety recall began on august 15, 2011. owners may contact ford motor company customer relationship center at 1-866-436-7332.
Notes:
Ford's safety recall no. 11c18.owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to <a href=http://www.safercar.gov>http://www.safercar.gov</a> .

2007 FORD F-550 SD TSBs (36)

Bulletin:
19247
Component:
061000 engine and engine cooling:engine
Summary:
Oil flow from the base engine oil pump. *kb
Bulletin:
19375
Component:
061000 engine and engine cooling:engine
Summary:
Watch for oil flow from the base engine oil pump. vehicles equipped with a 6.0l diesel engine. *kb
Bulletin:
06176
Component:
061200 engine and engine cooling:engine:diesel
Summary:
High pressure system diagnostics - 6.0l engines. *kb
Bulletin:
06171
Component:
061320 engine and engine cooling:engine:other fuel types:turbo-charger
Summary:
6.0l turbocharger carbon deposit diagnostics and service tips - lack of power, white or black smoke, surge, p0238, p0299, p0404, p2262, and/or p2263. *kb
Bulletin:
06239
Component:
061000 engine and engine cooling:engine
Summary:
Hesitation, runs rough, or surge either on acceleration or during idle in gear and occurs right after initial cold engine start up. *kb
Bulletin:
06229
Component:
061000 engine and engine cooling:engine
Summary:
6.0l - mil on with dtc p2138, p2139, and p2140. *kb
Bulletin:
19244
Component:
061200 engine and engine cooling:engine:diesel
Summary:
Runs rough or misfire due to a stuck valve. *kb
Bulletin:
0714
Component:
062200 engine and engine cooling:cooling system:fan
Summary:
Lack of cooling fan operation. *kb
Bulletin:
0727
Component:
061000 engine and engine cooling:engine
Summary:
6.0l - reduced engine performance - high altitude. *kb
Bulletin:
07312
Component:
071200 fuel system, gasoline:storage:auxillary tank
Summary:
Water in the fuel tank behind rear axle - 6.0l, 6.4l and 7.3l diesel engine. *kb updated 2/29/08. *nj
Bulletin:
0754
Component:
061000 engine and engine cooling:engine
Summary:
Cold start driveability - white smoke, lacks power, exhaust odor, surges, runs, rough, or no start. *kb
Bulletin:
07515
Component:
061000 engine and engine cooling:engine
Summary:
6.0l oil seep or boost pressure leak at hot side charge air cooler duct. *kb
Bulletin:
06177
Component:
120000 exterior lighting
Summary:
Adding additional bulbs to turn indicator or hazard flasher circuits. *kb
Bulletin:
19614
Component:
061000 engine and engine cooling:engine
Summary:
Air filter water ingestion / snow packing with codes p0103. *kb
Bulletin:
19621
Component:
070000 fuel system, gasoline
Summary:
Lack of power due to low fuel pressure, fuel tank liner seperation. *kb
Bulletin:
0798
Component:
046400 service brakes, air:antilock:abs warning light
Summary:
Abs light on and possible c1175, c1236, p0500,p0503. *kb
Bulletin:
19772
Component:
061000 engine and engine cooling:engine
Summary:
Power steering pump pulley alignment. *kb
Bulletin:
0643
Component:
031000 service brakes, hydraulic:pedals and linkages
Summary:
Customer satisfaction program. vehicles equipped with fixed pedals accelerator pedal inspection. effective until june 30, 2007. *kb this program is being extended until june 30, 2008. updated on 09/25/07. *nj
Bulletin:
19521
Component:
061200 engine and engine cooling:engine:diesel
Summary:
Lack of power or lack of performance condition when operated above 5,000 feet of altitude. *kb
Bulletin:
19529
Component:
061200 engine and engine cooling:engine:diesel
Summary:
Misfire and dtc p0300. *kb
Bulletin:
19537
Component:
061200 engine and engine cooling:engine:diesel
Summary:
Misfire and dtc p0300. *kb
Bulletin:
19728
Component:
061200 engine and engine cooling:engine:diesel
Summary:
Lack of power due to low fuel pressure - fuel tank liner seperation. *kb
Bulletin:
0769
Component:
103100 power train:automatic transmission:control module (tcm, pcm)
Summary:
Buck/jerk when pulling large heavy gooseneck trailers. diesel engines. reprogramming the powertrain control module (pcm) with the latest calibration might solve the issue. *kb
Bulletin:
0772
Component:
022000 suspension:rear
Summary:
Rear of vehicle is too high/low -5th wheel and goose neck applications. *kb
Bulletin:
062401
Component:
061000 engine and engine cooling:engine
Summary:
6.0l diesel engine - oil leak or boost pressure leak at hot side charge air cooler duct. *kb
Bulletin:
07112
Component:
046400 service brakes, air:antilock:abs warning light
Summary:
Stuck or jumping/bouncing/erratic speedometer and/or tachometer. *nj
Bulletin:
071110
Component:
040000 service brakes, air
Summary:
Brake booster system may exhibit a brake pedal kickback and/or grabbing condition when applying the brakes. *nj
Bulletin:
19989
Component:
102000 power train:manual transmission
Summary:
2005-2008 f-super duty manual transmission- clutch pedal concern. *nj
Bulletin:
20052
Component:
104000 power train:transfer case (4-wheel drive)
Summary:
1999-2008 f250-f550 super duty 4x4 with electronic shift transfer case not engaging 4x4. *nj
Bulletin:
07219
Component:
063130 engine and engine cooling:exhaust system:emission control:gas recirculation valve (egr valve)
Summary:
6.0l--mil on--p0401, p0402, p0404, p1335--lack of power or surge with some 2003-2007 f-super duty, 2003-2005 excursion and 2004-2008 e-series vehicles. *nj
Bulletin:
08-2-11
Component:
061320 engine and engine cooling:engine:other fuel types:turbo-charger
Summary:
6.0l turbocharger carbon deposit diagnostics and service tips. *nj updated 5/29/08. *nj
Bulletin:
20232
Component:
102000 power train:manual transmission
Summary:
2005-08 f250-550 super duty manual transmission - clutch pedal concern. *nj
Bulletin:
TSB-08-9-9
Component:
061200 engine and engine cooling:engine:diesel
Summary:
Ford: 6.0l diesel hard start/long crank/no start du to low injector control pressure (icp). ipe
Bulletin:
AS-21769
Component:
046000 service brakes, air:antilock
Summary:
Ford: if there is an intermittent lack of power, surge, or hesitation while driving the brakes will override acceleration. *rm
Bulletin:
ASI-44534
Component:
103000 power train:automatic transmission
Summary:
Ford: when shifting between park, reverse and/or during 2-3 shift, an intermittent clunk occurs with a torqshift transmission. model 2003-2014 f-super duty, e series, excursion, f-53 motorhome chassis, low cab forward. *p
Bulletin:
SSM 46345
Component:
350000 equipment
Summary:
Some 2005-2017 f-super duty 4x4 vehicles operated in extreme dust, mud or tar sand conditions may exhibit accelerated 4x4 vacuum hub seal and or wheel bearing wear as a result of harsh operating conditions. a knuckle seal shield kit is now

Home | Privacy