2007 CHEVROLET SILVERADO Recalls (4)

Campaign:
07E066000 on 08/28/2007
Component:
Equipment:electrical
Affected:
175
Defect:
Certain cequent 90 degree 7-way right angle adaptors sold by distributors in tow packages for aftermarket sales to tow 5th wheel rv travel trailers. due to incorrect wiring of the harness, the trailer lights may not operate properly.
Consequence:
If the trailer lights are not working properly, a vehicle crash can occur.
Correction:
All of the defective tow packages are still at the distributor level and have not been sold to any consumers.
Notes:
This recall only pertains to aftermarket cequent tow packages and has no relation to any original equipment installed on daimlerchrysler, gmc, or ford vehicles.customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.
Campaign:
07E106000 on 12/18/2007
Component:
Wheels:cap/cover/hub
Affected:
130,000
Defect:
Certain federal-mogul replacement wheel hub assemblies with the brand names: national, carquest p/nos. 515020, 515021, 515025, 515053, 515054, 515059, and 515060, shipped between january 23, 2006, and december 20, 2007, sold for light duty and medium duty trucks. the inboard retention nut used to maintain hub bearing assembly can loosen resulting in an abs light indication, noise, and/or wheel separation.
Consequence:
Wheel separation can result in a vehicle crash.
Correction:
Federal-mogul will notify customers and will replace the hub assembly free of charge. the recall began on february 7, 2008. owners can contact federal-mogul toll-free at 877-489-6659.
Notes:
This recall only pertains to replacement national, carquest wheel hub assemblies and has no relation to any original equipment installed on vehicles manufactured by general motors or ford.customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.
Campaign:
08E050000 on 08/13/2008
Component:
Exterior lighting:headlights
Affected:
1,921
Defect:
K2 motor is recalling 1,921 aftermarket headlamps of various models sold for use on the above listed vehicles. these headlamps are missing the amber side reflex reflector which fails to conform with the requirements of federal motor vehicle safety standard no. 108, "lamps, reflective devices, and associated equipment."
Consequence:
Without the amber side reflex reflectors, the lighting visibility may be affected, possibly resulting in a vehicle crash.
Correction:
K2 motor will notify owners and offer a full refund. the recall began on decemeber 17, 2008. owners may contact k2 motor at 1-909-839-2992.
Notes:
This recall only pertains to aftermarket replacement equipment and has no relation to any original equipment installed on vehicles manufactured by honda, ford, or chrysler llc. customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.
Campaign:
08V441000 on 08/27/2008
Component:
Electrical system
Manufactured:
09/29/2005 - 07/30/2007
Affected:
857,735
Defect:
Gm is recalling 857,735 my 2006-2008 buick lucerne; cadillac dts; hummer h2; my 2007-2008 cadillac escalade, escalade esv, escalade ext; chevrolet avalanche, silverado, suburban, tahoe; gmc acadia, sierra, yukon, yukon xl, saturn outlook; and my 2008 buick enclave vehicles equipped with a heated wiper washer fluid system. a short circuit on the printed circuit board for the washer fluid heater may overheat the control-circuit ground wire.
Consequence:
This may cause other electrical features to malfunction, create an odor, or cause smoke increasing the risk of a fire.
Correction:
Dealers will install a wire harness with an in-line fuse free of charge. the recall began on september 12, 2008. owners may contact buick at 1-866-608-8080; cadillac at 1-800-982-2339 or http://www.cadillac.com; chevrolet at 1-800-630-2438; saturn at 1-800-972-8876 or http://www.saturn.com, gmc at 1-866-996-9436; or hummer at 1-800-732-5493; or through their website at <a href=http://www.gmownercenter.com>http://www.gmownercenter.com</a> .
Notes:
Gm recall no. 08048. customers may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to <a href=http://www.safercar.gov>http://www.safercar.gov</a> .

2007 CHEVROLET SILVERADO TSBs (283)

Bulletin:
02-06-04-037
Component:
061000 engine and engine cooling:engine
Summary:
Some customers whose vehicles are operated in dusty type environments, such as farming or mining off-road type applications, may comment about the illumination of the instrument panel ses light, with diagnostic trouble code p0446 set. *tt
Bulletin:
3189
Component:
170000 latches/locks/linkages
Summary:
Unable to disable auto door locks. this includes 05 chevrolet gmc cadillac full size trucks and utilities. *eh also includes avalance, silverado suburban tahoe; gmc sierra, yukon, denali, yukon xl, denali xl. updated 8/26/08. *pe
Bulletin:
3187
Component:
060000 engine and engine cooling
Summary:
Engine low power will not go over 2300 rpms. *eh updated 6/11/10. *pe
Bulletin:
05-04-21-003
Component:
104000 power train:transfer case (4-wheel drive)
Summary:
Service 4wd light illuminated, diagnostic trouble code (dtc) c0374 set. *tt updated 10/05/07. *nj inspect wiring harness to transfer case speed sensors, replace wiring harness. updated 7/18/08 *pe
Bulletin:
3808
Component:
113000 electrical system:starter assembly
Summary:
Crank no start, rough running, or dtc p0335. *tt equipped with 5.3l, 6.0l, 6.2l engines. updated 1/30/08. *nj
Bulletin:
4169
Component:
031100 service brakes, electric
Summary:
Service stability lamp diagnostic trouble code (dtc) c0561. *kb updated 9/30/08. *pe
Bulletin:
050232008
Component:
015100 steering:hydraulic power assist:pump
Summary:
Gear box power steering pump, p/s performance concerns. *nj updated on 6/30/2011. *kb
Bulletin:
PIT-4056
Component:
036100 service brakes, hydraulic:antilock:control unit/module
Summary:
Gmc: unable to communicate with the ebcm dtc u0121. *nj vehicles equipped with jl4. updated 9/30/08. *pe updated 6/27/11. *pe updated 4/6/12. *pe
Bulletin:
4225
Component:
251000 electronic stability control:automatic (asc)
Summary:
Service stability lamp dtc c0710. *nj updated 3/25/11. *pe
Bulletin:
PIT 4162
Component:
251000 electronic stability control:automatic (asc)
Summary:
Service stability lamp dtc c0131. *nj updated 4/1/08. *nj updated 6/26/08. *nj updated 12/18/08. *pe updated 8/1/11. *pe
Bulletin:
PIT4046
Component:
031100 service brakes, electric
Summary:
Service brakes soon message dtc c0299. *nj updated 5/13/08. *nj updated 12/5/08. no hybrids vehicles. *pe
Bulletin:
4190
Component:
014000 steering:rack and pinion
Summary:
Engineering information request during rear ring and pinion replacement. *nj
Bulletin:
070941004
Component:
141100 air bags:frontal:sensor/control module
Summary:
New procedure for clearing passenger presence system (pps) and sensing and diagnostic module (sdm) dtcs b0071, b0074, b0081. *nj
Bulletin:
070940001
Component:
151200 seat belts:front:webbing
Summary:
Front seatbelt latch plate reversed, front seatbelt twisted (perform repair to untwist seatbelt). *nj
Bulletin:
3075
Component:
115000 electrical system:fuses and circuit breakers
Summary:
Blown mbec 1 or lbec 1 fuse. *kb
Bulletin:
4407
Component:
110000 electrical system
Summary:
Auxiliary power to 7-way trailer connector. *kb
Bulletin:
4133
Component:
103000 power train:automatic transmission
Summary:
Transmission slips, will not shift, ses light may be illuminated. *kb
Bulletin:
4052
Component:
103000 power train:automatic transmission
Summary:
2-3 upshift slip or flare. *kb
Bulletin:
4200
Component:
061000 engine and engine cooling:engine
Summary:
Perceived hesitation or lack of power during throttle reapply at slow speeds. *kb
Bulletin:
3917
Component:
061000 engine and engine cooling:engine
Summary:
Engine has low power on acceleration or when towing. equipped with the 6.0l ly6 and l76 engine. *nj updated 1/29/08. *nj
Bulletin:
3959
Component:
198000 tires:temporary/emergency spare tire
Summary:
Unable to lower spare tire from underneath the vehicle. *nj
Bulletin:
4486
Component:
117000 digital instrument panel
Summary:
One of the following concerns when programming the mileage or the hours into an exchange instrument panel cluster that is received from an electronic service center (esc). *nj
Bulletin:
PIP4219
Component:
103100 power train:automatic transmission:control module (tcm, pcm)
Summary:
Diagnosis for service fast learn adapts fails, no forward or no reverse. *nj updated 4/1/08. *nj
Bulletin:
070603005
Component:
111100 electrical system:battery:cables
Summary:
Replacement information for broken t-bolt on negative and/or positive battery cable terminal. *nj
Bulletin:
070847004
Component:
110000 electrical system
Summary:
Information on body control module (bcm) grounds. *nj updated 7/19/13. *pe
Bulletin:
060842009
Component:
120000 exterior lighting
Summary:
Use of auxiliary center high mounted stop lamp (chmsl) with installation of accessories overhead rack system. *nj
Bulletin:
070138009
Component:
353600 equipment:air conditioner
Summary:
Ei07264 - manual hvac performance, temperature, mode, a/c does not cool, dtc b0228, b0413, b0423, b0433, b3779, b3782 *nj updated 2/15/08. *nj
Bulletin:
070604027
Component:
073200 fuel system, gasoline:fuel injection system:injectors
Summary:
Ei07239 - 5.3l, lmg, lc9 driveability symptoms, hesitation, miss, lack of power, dtc p0300, p0301, p0302, p0303, p0304, p0305, p0306, p0307, p0308, p0171, p0172, p0174, p1174, p1175, check engine light, mil, injector. *nj u
Bulletin:
070842013
Component:
126100 exterior lighting:turn signal:flasher unit
Summary:
Turn signal in camper style outside rearview mirror (rpo dpn) does not illuminate turn signal flash (replace upper mirror glass) *nj
Bulletin:
070849018
Component:
114000 electrical system:wiring
Summary:
Various electrical concerns - intermittently functioning or inoperative component, ip warning light on, dic message displayed, dtc set, no crank/start (repair ip wiring harness) *nj
Bulletin:
070232008
Component:
011000 steering:wheel and handle bar
Summary:
Steering wheel off center while driving straight, clunk noise while turning, early front tire wear (perform torque to tighten analysis and repair as necessary) *nj updated 2/25/08. *nj
Bulletin:
4131
Component:
126000 exterior lighting:turn signal
Summary:
Right front turn signal inoperative. *nj
Bulletin:
PIT-4508
Component:
185000 vehicle speed control:cruise control
Summary:
Cruise control inoperative - keywords abs b3894 brake cylinder ebcm inop master module pressure sensor switch trailer. with rpo jl1. *nj models 2007-2013 avalanche, silverado, suburban, tahoe sierra, yukon, yukon denali, yukon xl, yuk
Bulletin:
4112
Component:
103000 power train:automatic transmission
Summary:
Sag or hesitation on acceleration (normal operating characteristics). equipped w/ gasoline engine and automatic transmission. *nj updated 1/30/08. *nj updated 10/01/08. *pe updated 8/12/09. *pe updated 9/23
Bulletin:
PIT4411
Component:
046400 service brakes, air:antilock:abs warning light
Summary:
Unwanted abs or valve activation on low speed turns. with stabilitrac (rpo jl4). *nj updated 4/1/08. *nj
Bulletin:
4512
Component:
171100 latches/locks/linkages:doors:latch
Summary:
Outside door handle loose, inoperative or does not retract. *nj
Bulletin:
07293
Component:
103100 power train:automatic transmission:control module (tcm, pcm)
Summary:
Chevrolet\gmc service campaign: see document search button for owner letter. transmission overheat in extreme cold ambient temperatures - reprogram tcm. located in alaska and minnesota; canadian yukon and northwest territories only. *n
Bulletin:
4529
Component:
061200 engine and engine cooling:engine:diesel
Summary:
High idle, elevated idle, and pto all different options. *nj
Bulletin:
4444
Component:
114100 electrical system:wiring:front underhood
Summary:
No start/no crank - loss of high speed gmlan communication. *nj
Bulletin:
PIP4307
Component:
061200 engine and engine cooling:engine:diesel
Summary:
Ses light on due to dtc p0101 and/or p0106 - inspect air filter and/or map sensor . with 6.6l diesel engine (rpo, lbz, lly, or lmm). *nj updated 5/13/08. *nj
Bulletin:
4303
Component:
104000 power train:transfer case (4-wheel drive)
Summary:
4 wheel drive inoperative front axle will not engage - keywords clunk grind growl k2 k3 equipped with a 9.25 front differential. *nj updated 2/27/08. *nj
Bulletin:
PIP-4290
Component:
103100 power train:automatic transmission:control module (tcm, pcm)
Summary:
Engine surge or stall at stop and/or dtc p0742 possible tcc applied. equipped with allison lct1000 transmission rpo m74 or mw7. *nj updated 4/22/13. *pe
Bulletin:
4322
Component:
251000 electronic stability control:automatic (asc)
Summary:
Unwanted stability activation and/or c0710 with lift/lower kits-different tires/wheel. with rpo jl4. *nj updated 12/18/08. *pe
Bulletin:
4132
Component:
114000 electrical system:wiring
Summary:
Sir light on, dtc's b0085, b0086, b0087 and b0088. *nj
Bulletin:
4143
Component:
103100 power train:automatic transmission:control module (tcm, pcm)
Summary:
U0106 loss of communication with glow plug control module. equipped with the 6.6l duramax diesel engine rpo code lmm. *nj
Bulletin:
070417002
Component:
106200 power train:axle assembly:axle shaft
Summary:
Whine type noise coming from rear of vehicle (diagnose and replace rear propeller shaft). *nj
Bulletin:
4419
Component:
050000 parking brake
Summary:
Service stabilitrak message c0196 and/or u2142. *nj
Bulletin:
PIP4344
Component:
061000 engine and engine cooling:engine
Summary:
Short duration cold start lifter tick noise. equipped with the 5.3 or 6.0 active fuel management engines. *nj
Bulletin:
08-02-32-001
Component:
015200 steering:hydraulic power assist:hose, piping, and connections
Summary:
Power steering, steering wheel shudder/vibration during low speed parking maneuvers (replace power steering assembly hose) excluding pickup models with 4.3l v6 engine (vin x - rpo lu3) built prior to 5/30/07. *nj updated 5/19/08.
Bulletin:
PIT4316
Component:
199000 tires:pressure monitoring and regulating systems
Summary:
Check low tire / aftermarket wheels / tire pressure monitor / fmvss 138 with (rpo uj6). *nj
Bulletin:
PIT4284
Component:
061000 engine and engine cooling:engine
Summary:
Engine stalls after being remote started. *nj
Bulletin:
PIP4321
Component:
061000 engine and engine cooling:engine
Summary:
Oil leak at rear of engine. equipped with a 4.8, 5.3, 6.0 or 6.2 v8 engine. *nj
Bulletin:
PIP4105
Component:
080000 fuel system, diesel
Summary:
Duramax diesels with dtc p009e, vehicles equipped with the 6.6 duramax diesel engine rpo code lmn. *nj updated 4/7/08. *nj
Bulletin:
PIT3569
Component:
199000 tires:pressure monitoring and regulating systems
Summary:
Low tire light on and/or dic check tire pressure message when cold, with rpo uj6. *nj
Bulletin:
PIP3343
Component:
063110 engine and engine cooling:exhaust system:emission control:crankcase (pcv)
Summary:
Possible engine oil leak due to pcv freeze-up, equipped with the 4.8, 5.3, 6.0, and 6.2 v-8 engines. *nj
Bulletin:
PIP4054A
Component:
022000 suspension:rear
Summary:
Eaton locking differential chatter shudder noise on turns, equipped with a locking rear differential rpo g80. *nj updated 7/17/2008. *pe
Bulletin:
070849029
Component:
117000 digital instrument panel
Summary:
Instrument panel (ip) gauges/gages difficult to read or see, poor backlighting (replace ip and program). *nj
Bulletin:
PIP4365
Component:
104000 power train:transfer case (4-wheel drive)
Summary:
Transfer case will not shift possible dtc's c0387 and/or c0569. on vehicles equipped with a magna transfer case rpo nqf. *nj updated 3/15/10. *pe updated on 6/27/2011. *kb
Bulletin:
PIT4595
Component:
114000 electrical system:wiring
Summary:
Service trailer brake message with dtc c1114 and/or c1112. with rpo jl1. *nj updated 3/28/11. *pe
Bulletin:
PIT4604
Component:
126000 exterior lighting:turn signal
Summary:
Turn signals flash fast after factory box removed. *nj updated 8/25/08. *pe
Bulletin:
PIP3605
Component:
103100 power train:automatic transmission:control module (tcm, pcm)
Summary:
Dtc u0101, no engine crank and no tech ii communication with tcm. equipped with allison lct1000 (rpo-mw7) automatic transmission. *nj
Bulletin:
PIT4366
Component:
114000 electrical system:wiring
Summary:
[check trailer wiring] message displayed on dic. with rpo jl1. *nj updated 3/28/11. *pe
Bulletin:
PIP4348
Component:
061200 engine and engine cooling:engine:diesel
Summary:
Duramax diesel dpf regeneration changes - vehicles equipped with the 6.6 duramax diesel engine rpo code lmm. *nj
Bulletin:
08-06-04-016
Component:
034100 service brakes, hydraulic:foundation components:master cylinder
Summary:
Diagnostic information on mil/ses with dtc p0171 (fuel trim system lean bank 1) and/or p0174 (fuel trim system lean bank 2) after brake master cylinder replacement. *nj
Bulletin:
08-08-45-002
Component:
114000 electrical system:wiring
Summary:
Left or right power outside mirror inoperative (inspect wire harness). *nj
Bulletin:
000235003N
Component:
012000 steering:column
Summary:
Clunking noise under hood and can be felt in steering wheel and/or steering column (replace upper intermediate steering shaft [i-shaft] assembly). *pe
Bulletin:
08-01-38-002
Component:
062200 engine and engine cooling:cooling system:fan
Summary:
Blower motor inoperative (replace blower motor) for extended and crew cab models only. *pe
Bulletin:
08142
Component:
061000 engine and engine cooling:engine
Summary:
Chevrolet service campaign: see document search button for owner letter. ecm eeprom - reprogram ecm. all 2007 and certain 2008 cheverolet silverado and express and gmc sierra and savana equipped with 6.6l duramax va diesel (rpo lmm - vin 6
Bulletin:
08-07-30-021
Component:
061000 engine and engine cooling:engine
Summary:
Loss of high speed gmlan communications, intermittent no crank, ipc gauge fluctuation, intermittent door lock cycling, transmission may not shift, dtcs u0073, u0100, u0101, u0102, 70140 (repair backed out terminal in transmission harness co
Bulletin:
08-07-30-016
Component:
103000 power train:automatic transmission
Summary:
Diagnostic information on mh1, mn8, mt1, m15 transmission slips, will not shift or may overheat, ses/mil may be illuminated, dtcs p0218, p0894 set. *pe updated 8/12/08. *pe
Bulletin:
SB-08-07-30-021
Component:
061000 engine and engine cooling:engine
Summary:
Loss of high speed gmlan communications, intermittent no crank, ipc gauge fluctuation, intermittent door lock cycling, transmission may not shift, dtcs u0073, u0100, u0101, u0102, u0121, u0140 set (repair backed out terminal in transmission
Bulletin:
08-07-30-023
Component:
103000 power train:automatic transmission
Summary:
4l60-e/4l65-e/4l70-e automatic transmission fluid leak from oil pump or bell housing area (replace torque converter hub-to-oil pump seal assembly). attn: this bulletin applies to vehicles built prior to december 2007. *pe
Bulletin:
07-06-04-033A
Component:
061200 engine and engine cooling:engine:diesel
Summary:
Lmm, clean exhaust filter light illuminated, mil/ses light illuminated with dtc(s) p244b and/or p2463 set (perform all si diagnostics for dtc(s) set, if ntf, replace air filter). vehicles with 6.6l duramax diesel engine. *pe
Bulletin:
SB-07-08-42-006H
Component:
126000 exterior lighting:turn signal
Summary:
Information on bcm calibrations available to restore bulb outage detection on vehicles produced by a second stage manufacturer, turn signals flash fast after factory box removed (upfitter). chassis cab models and pickups with box delete op
Bulletin:
PIT3504D
Component:
355200 equipment:other:owners/service/other manual
Summary:
Some customers may comment on various hvac concerns including temperature doors defaulting to full hot position or unable to obtain defrost position. *pe
Bulletin:
08-08-42-003
Component:
125100 exterior lighting:brake lights:switch
Summary:
Gmc: stop lamps intermittently turn off after coming to a complete stop while still having pressure on brake pedal (replace stop lamp switch). *pe updated 3/1/10. *pe
Bulletin:
08-06-03-007
Component:
061000 engine and engine cooling:engine
Summary:
Gmc: no start, no crank, intermittent electrical operations (check for poor connections within engine wiring harness junction block). *pe
Bulletin:
PIP-4380
Component:
061200 engine and engine cooling:engine:diesel
Summary:
Gmc: egr low flow dtc p0401. vehicles that are equipped with the 6.6l diesel engine rpo code lm. *pe
Bulletin:
PIP-4395
Component:
103000 power train:automatic transmission
Summary:
Gmc: flare and or harsh 2-3 shifts. this condition may be caused by leaking 1-2-3-4 and 3-5-r clutch fluid seal rings (230). models cadillacs, chevrolets, gmc, hummers, pontiacs. equipped with 6l80 (rpo myc) or 6l90 (rpo myd) automati
Bulletin:
08-04-19-004
Component:
062300 engine and engine cooling:cooling system:hose
Summary:
Gmc: correct front axle vent hose routing. the front axle vent hose is mounted in the left side of the engine compartment, and may not be correctly routed. *pe updated on 5/1/2012. *kb
Bulletin:
PIP-4372B
Component:
061120 engine and engine cooling:engine:gasoline:turbo-charger
Summary:
Gmc: oil leak at turbocharger air intake pipe. initial inspection ma reveal a leak that looks as it is coming from the rear of the engine. *pe
Bulletin:
PIP-4430
Component:
073100 fuel system, gasoline:fuel injection system:fuel rail
Summary:
Gmc: fuel rail pressure sensor performance dtc p0191. may set due to actual fuel rail pressure not dropping quickly enough when the engine is shut off. *pe
Bulletin:
PIT-4613A
Component:
111000 electrical system:battery
Summary:
Gmc: intermittent no crank and/or discharged battery. could be caused by a loose connection at the 175 amp mega fuse located on the passenger side of the cowl. *pe
Bulletin:
PIT-4696A
Component:
121000 exterior lighting:headlights
Summary:
Gmc: bmc failure after windshield wiper operation-keywords: ajar door dome driver dimmer flasher fog haul headlight head high hazard inop inoperative lamp light lock low not on off power park radio rap repeat signal shut speed stay switch t
Bulletin:
PIT-3046E
Component:
091200 fuel system, other:storage:fuel gauge system
Summary:
Gmc: fuel gauge fluctuation in park or neutral, causing the low fuel light to illuminate. *pe
Bulletin:
PIT-4665A
Component:
110000 electrical system
Summary:
General motors: during normal diagnostics and/or repair verification the abs light, traction control and/or stabilitrak indicators may be on with no dtc's displayed by the ebcm. *pe updated 11/17/10. *pe updated 3/14/11. *pe
Bulletin:
SB-08-09-41-002C
Component:
140000 air bags
Summary:
General motors: diagnostic information for intermittent restraints, air bag (sir) indicator/lamp on with dtc(s) b0012, b0013, b0016, b0016, b0019, b0020, b0022, b0023, b0026, b0033, b0040, b0042 or b0044 set. this may be caused by a loose,
Bulletin:
TB-09-06-04-022
Component:
061000 engine and engine cooling:engine
Summary:
General motors: malfunction indicator lamp (mil) illuminated, intermittent dtc p0191, slow fuel rail pressure (frp) decay, wiring harness connections, voltage fluctuations/interruptions (follow correction information below). *pe
Bulletin:
SB-08-02-35-004A
Component:
010000 steering
Summary:
General motors: the left and/or right steering wheel lower (spoke) cover is warped, loose, discolored or just fits poorly in the steering wheel. the paint finish seems to be peeling. *pe
Bulletin:
SB-08-06-04-029B
Component:
061200 engine and engine cooling:engine:diesel
Summary:
General motors: lbz, lly, lmm mil/ses light n dtc p0087-fuel rail pressure (frp) too low, lack of performance, no power, engine runs rough, no start (diagnose fuel system components). *pe updated 3/1/10. *pe
Bulletin:
PIP-4629
Component:
061200 engine and engine cooling:engine:diesel
Summary:
Chevrolet/gmc: diesel engine turbo dtc p2563 or p003a. may encounter a concern of ses light, reduced power, low power. *pe
Bulletin:
PIT-4846A
Component:
061000 engine and engine cooling:engine
Summary:
Cadillac/chevrolet/gmc: locations of high speed gmlan wiring concerns. gauges inoperative, no crank, harsh transmission shifting, no transmission shifting, door locks cycling and indicators on. *pe updated 11/17/10. *pe
Bulletin:
SB-070842006C
Component:
126000 exterior lighting:turn signal
Summary:
General motors: bcm calibrations available to restore bulb outage detection on vehicles produced by a second state manufacturer, turn signals flash fast after factory box removed (upfitter). may need to have body control module (bcm) rear
Bulletin:
SB-09-06-01-006
Component:
061000 engine and engine cooling:engine
Summary:
Gmc/cadillac/chevrolet: check engine light on, engine misfire, hard start, rough idle, hesitation, loss of power, poor performance, noise, dtcs p0300, p0301, p0302,p0303, p0304, p0305, p0306, p0307, p0308 set (replace engine). *pe
Bulletin:
PIT-4857
Component:
140000 air bags
Summary:
Gmc/chevrolet: sir mil on and tech 2 will not communicate with sdm. some modules may set a communication dtc u0151 against sdm. diagnostics may lead to replacement of sdm and replacing sdm may fix the concern for a short time or it may fa
Bulletin:
SB-09-03-09-001
Component:
022140 suspension:rear:springs:leaf spring assembly
Summary:
Chevrolet/gmc: a clunking noise coming from the rear of the vehicle. upon further investigation, the technician may diagnose the noise coming from the rear suspension leaf spring area. *pe updated 6/30/2011. *kb
Bulletin:
SB-09038
Component:
103000 power train:automatic transmission
Summary:
Chevrolet\gmc service campaign: see document search button for owner letter. enhanced calibration for transmission overheat in extreme cold air temperatures. located in certain us cold weather states; alberta, british columbia, manitoba,
Bulletin:
SB-09184-A
Component:
110000 electrical system
Summary:
Gmc\chevrolet service campaign: see document search button for owner letter. material over sensing & diagnostic module retaining moisture. vehicles may have a condition where an electronic component located beneath the driver's seat may c
Bulletin:
SB-09-09-41-005
Component:
051120 parking brake:conventional:mechanical:linkage and cable
Summary:
Gmc/cadillac/chevrolet: air bag readiness light on, service air bag message, inflatable restraint sensing and diagnostic module (sdm) corrosion (replace sdm/cut and remove carpet pad). *pe
Bulletin:
PIT-4790A
Component:
091200 fuel system, other:storage:fuel gauge system
Summary:
Gmc/chevrolet/cadillac: vehicle fuel gauge inaccurate below 1/4 tank. on rare occasions, the vehicle has an inaccurate fuel gauge reading at 1/4 or a 1/8 of a tank. *pe
Bulletin:
PIT-4816A
Component:
110000 electrical system
Summary:
Chevrolet/gmc/cadillac: multiple electrical concerns with dtc c0900 - keywords battery c/k cable clock crank cycle door dimming flicker gage gauge gmc hvac inop inoperative instrument intermittent ipc lock no panel power radio stall start
Bulletin:
PIP-4713
Component:
110000 electrical system
Summary:
Chevrolet/gmc: inspect for wire harness chafes near connector x108. dealer may encounter a concern of the ses light on with reduced power. diagnostics may reveal dtc's p0193, p0522 and/or p0652. *pe
Bulletin:
PIC-4872
Component:
111000 electrical system:battery
Summary:
Gmc/chevrolet/cadillac: sir mil on with dtc b1325 sym 03. during a low battery/voltage condition the passenger presence system may set a b1325 sym 03 along with other faults that are caused by the low batter/voltage condition. *pe
Bulletin:
PIP-4660
Component:
061200 engine and engine cooling:engine:diesel
Summary:
Gmc/chevrolet: engine coolant sensor dtcs p011a, p2184, and p2185. dealer may encounter concern of ses light on or dtcs p011a, p2184 and p2185. diesel engines have 2 ect (engine coolant temperature) sensors. *pe
Bulletin:
PIP-4664
Component:
061200 engine and engine cooling:engine:diesel
Summary:
Gmc/chevrolet: dtc p0101 with non gm air filter. may encounter concern of reduced power and ses light on. diagnostics may reveal maf (mass air flow) sensor dtc p0101. if diagnostics were inconclusive its possible dtc p0101 is setting du
Bulletin:
SB-09239
Component:
162300 structure:body:door
Summary:
Cadillac\chevrolet\gmc service campaign: see document search button for owner letter. special coverage adjustment-front and rear chrome interior door handle lever. some vehicles may be peeling on top surface of the front or rear chrome in
Bulletin:
SB-08-06-04-054A
Component:
061000 engine and engine cooling:engine
Summary:
Chevrolet/gmc: snow or ice ingestion into air cleaner element, malfunction indicator lamp (mil) illuminated, engine power is reduced message displayed, dtc p0101 set (perform repair as outlined). *pe
Bulletin:
SB-07-09-41-010A
Component:
140000 air bags
Summary:
Buick/cadillac/chevrolet/gmc: airbag light on, dtc b0071 and b0081 set (diagnose and replace right front seatbelt buckle, if necessary). upon investigation, the technician may find dtc b0071 set in the passenger presence system (pps) and
Bulletin:
SB-02-06-04-0371
Component:
061000 engine and engine cooling:engine
Summary:
Chevrolet/gmc: check engine light on, fuel tank hard to fill, dtcs p0442, p0446, p0455 or p0449 set (replace evaporative emission (evap) vent valve solenoid assembly and add/relocate fileter box using service kit). *pe
Bulletin:
PIP-4379-D
Component:
103000 power train:automatic transmission
Summary:
Chevrolet/gmc: delayed or no drive and delayed or no reverse with dtc's, range inhibit. model years 2001-2013. *pe updated on 06/08/2011. *kb updated on 06/16/2011. *kb updated 11/26/12. *pe updated 12/4/2013 *js
Bulletin:
PIT-5028
Component:
061000 engine and engine cooling:engine
Summary:
Pontiac/saturn/buick/gmc/chevrolet/cadillac/hummer: vehicle start and stalls after theft deterrent module replacement. model years 2006-2011. does not apply to vehicles with keyless access system. *pe
Bulletin:
PIP-4492P
Component:
061000 engine and engine cooling:engine
Summary:
Buick/cadillac/chevrolet/gmc/hummer/pontiac/saab: oil consumption and/or exhaust smoke-possible pcv baffle or lifter concern. upon inspection, obvious oil will be found in the intake manifold and/or pcv vacuum tube. *pe updated 3/21/
Bulletin:
PIP-4574M
Component:
061200 engine and engine cooling:engine:diesel
Summary:
Buick/chevrolet/gmc/pontiac/saab: excessive oil consumption and/or blue exhaust smoke-investigation update. in most cases did not start until the engine accumulated approximately 30,000 miles or more. *pe
Bulletin:
SB-07-06-03-002C
Component:
061000 engine and engine cooling:engine
Summary:
Cadillac/chevrolet/gmc: information on inspecting top post battery cable bolts, clamps and nuts during pre-delivery inspection (pdi). *pe
Bulletin:
SB-10-02-33-001
Component:
010000 steering
Summary:
Buick/cadillac/chevrolet/gmc/oldsmobile and hummer: information on pitman arm shaft seal service kit. do not replace entire steering gear for pitman seal leak. technicians have been replacing entire steering gears due to not being able to
Bulletin:
PIT-4900A
Component:
114000 electrical system:wiring
Summary:
Chevrolet/gmc: service trailer brake message with dtc(s) c1115, c1116, c1117, and/or c1118 (inspect wiring near parking brake pedal). this concern may be very intermittent and can occur with or without a trailer connected to truck. *pe
Bulletin:
PIT-4730A
Component:
110000 electrical system
Summary:
Buick/cadillac/chevrolet/gmc/hummer/pontiac/saturn: additional diagnostic information for u0140 or u0073. vehicle may exhibits some symptom(s) as door locks cycle while driving; intermittent no start; service stabilitrak dic message; spee
Bulletin:
PIT-4801B
Component:
114000 electrical system:wiring
Summary:
Gmc/chevrolet: check trailer wiring message in dic poor connections at 7-way). this concern could be caused by a poor connection at the 7-way trailer connector. there are several manufacturers of 7-way (trailer side) connectors and no in
Bulletin:
05-09-40-002E
Component:
151200 seat belts:front:webbing
Summary:
Gm: service bulletin explaining when the safety belts are supposed to lock. *rm updated 12/6/11. *pe
Bulletin:
PIP-4857
Component:
061320 engine and engine cooling:engine:other fuel types:turbo-charger
Summary:
Gm: there may be reduced power and an internal trouble code in high temperatures or when near the towing limit. *rm
Bulletin:
PIP-3504C
Component:
061200 engine and engine cooling:engine:diesel
Summary:
Gm: there is a diesel engine hard start when hot. starts fine when cold. there will be no internal trouble codes. *rm
Bulletin:
09-04-17-002E
Component:
106000 power train:axle assembly
Summary:
Gm: there may be a bump noise or clunk feel when stopping or launching. this may be caused by a slip in the transmission. *rm
Bulletin:
10-08-50-008B
Component:
221700 seats:front assembly:seat heater/cooler
Summary:
Gm: the driver or passenger heated seat are inoperative. they are slow to warm or may shut off. there are trouble codes set related to the ground terminal harness. *rm
Bulletin:
PIT-4322-D
Component:
010000 steering
Summary:
Gm: there is unwanted stability action or stability light on. this can be caused by the suspension being modified. *rm updated 6/18/12. *pe models 2007-13 all escalade; avalanche, silverado, suburban, tahoe; sierra, sierra denali, a
Bulletin:
PIP-3783-C
Component:
061000 engine and engine cooling:engine
Summary:
Gm: the engine light is on and the vehicle lacks power. there are multiple possible trouble codes. *rm updated 10/15/14. *pe
Bulletin:
PIP-4138K
Component:
060000 engine and engine cooling
Summary:
Gm: the service engine soon light is on, there is also a misfire or engine noise. there are multiple possible causes. *rm
Bulletin:
PIP-4568K
Component:
060000 engine and engine cooling
Summary:
Gm: service engine soon light is on with a misfire and a possible tick noise. *rm
Bulletin:
09-09-40-001A
Component:
150000 seat belts
Summary:
Gm: there are seat belt problems: difficulty latching and unlatching buckle. buckle release button is sticking. seat belt warning light illuminated. likely caused by sticky beverages that are spilled into the buckle assembly. *rm updated 4/
Bulletin:
10-00-89-017C
Component:
980000 unknown or other
Summary:
Gm: information on fixing multiple situations right the first time. *rm
Bulletin:
PI-0011A
Component:
171100 latches/locks/linkages:doors:latch
Summary:
Gm: the front or rear door may not open from the inside or outside handle, the door will not unlock with any method. the probably cause an incorrect installation of a handle component. *rm updated on 7/26/2013. all 2014 and prior gm pass
Bulletin:
PIP-4888
Component:
061320 engine and engine cooling:engine:other fuel types:turbo-charger
Summary:
Gm: information on inspecting and replacing turbos. *rm
Bulletin:
PIT-4769B
Component:
061000 engine and engine cooling:engine
Summary:
Gm: the air bag light is on with a stored trouble code. *rm
Bulletin:
SB-09-08-110-002
Component:
350000 equipment
Summary:
Gm: the carpet is curling at the top front edge. the carpet was folded prior to installation and when installed it curls back up. 2007-2012 silverado/sierra. *rm
Bulletin:
PI-0474
Component:
061200 engine and engine cooling:engine:diesel
Summary:
Gm: an 'engine power is reduced' message appears and there is a stored trouble code. this is caused by wear of the internal fuel injector. *rm
Bulletin:
PB-10037A
Component:
110000 electrical system
Summary:
Gm: onstar is making incomplete calls without the driver knowing. when have a data connection. *rm
Bulletin:
SB-10240
Component:
353600 equipment:air conditioner
Summary:
General motors service campaign: see document search button for owner letter. the hvac blower may not work at certain functions or may become inoperable. there could be a burning smell or smoke. *rm updated 4/6/12. *pe
Bulletin:
PIT-5090
Component:
110000 electrical system
Summary:
Gm: there may be multiple electrical issues such as: no start, starter stays engaged, fog lamps won't turn on, washing fluid not spraying, park and reverse lights stay on, battery goes dead, and a buzz noise underneath the dash. 2007-2011 s
Bulletin:
SB-09-08-64-032A
Component:
162300 structure:body:door
Summary:
Gm: the chrome outside door handle is cracked or loose at the screw where it attaches. grease may have cause the screw to degrade or the torque was too high. *rm
Bulletin:
PIP-4966
Component:
036400 service brakes, hydraulic:antilock:abs warning light
Summary:
Chevrolet/cadillac/gmc: certain vehicles experiencing erratic or inoperative speedometer or anti-lock brake system message or malfunctioning indicator light displaying in driver's information center. *pe updated 08/5/2013 *js
Bulletin:
PI-0615
Component:
104000 power train:transfer case (4-wheel drive)
Summary:
Gmc/chevrolet: bulletin provides information on the seal revision and the transfer case output shaft slinger for certain model year trucks. *pe
Bulletin:
PIP-3366-B
Component:
103000 power train:automatic transmission
Summary:
Cadillac/chevrolet/gmc/hummer: some suvs and trucks are exhibiting a condition where by grinding/ratcheting type noise coming from automatic transmission when shifting into park while in 4wd low (4lo) range. *pe
Bulletin:
CSP-10414
Component:
111000 electrical system:battery
Summary:
Gmc/chevrolet: see docuemtn search button for owner letter. auxiliary battery feed may cause fusible link to melt and open circuit to prevent damage or fire in wiring harness, due to electrical over load. *pe
Bulletin:
PI-0648
Component:
353600 equipment:air conditioner
Summary:
Cadillac/chevrolet/gmc: original style blower motor assembly is no longer available. a revised hvac blower motor assembly for full size trucks is required, with modifications, to function properly. *pe updated 2/25/13.
Bulletin:
08-07-30-021G
Component:
103100 power train:automatic transmission:control module (tcm, pcm)
Summary:
Gm: loss of high speed gmlan communications, intermittent no crank, ip gage fluctuation, intermittent door look cycling, intermittent chime operation, various ip warning lamps illuminated, transmission may not shift, communication dtcs u007
Bulletin:
09-07-30-004F
Component:
103000 power train:automatic transmission
Summary:
Gm: slips in reverse or third, delayed reverse or drive engagement, dtc p0776, p2715, p2723, harsh 2-3 shifts (inspect 1-2-3-/ 3-5-r housing and pump seal rings). this condition may be caused by a cracked 1-2-3-4/ 3-5-r clutch housing. *j
Bulletin:
10-08-42-001C
Component:
121000 exterior lighting:headlights
Summary:
Gm: low beam headlamp bulb diagnosis/ replacement (inspect bulb and connector). do not replace the entire headlamp assembly for this condition. replace the bulb and inspect the connector. *js updated 4/7/15. *pe
Bulletin:
12-02-32-001
Component:
015200 steering:hydraulic power assist:hose, piping, and connections
Summary:
Gmc: hydraulic power steering leak at hose connection to steering rack. all potential leaks should be completely cleaned and indentified before attempting to repair or replace any power steering components. *js updated 4/22/13. *pe
Bulletin:
PI0639A
Component:
010000 steering
Summary:
Gm: the service stabilitrak message being displayed in dic. the stabilitrak indicator light may also be on. *js updated on 7/9/2013. *kb
Bulletin:
PI-0695
Component:
138110 visibility:defroster/defogger system:windshield:blower
Summary:
Gm: diagnose and repair hvac blower function. may not be any air flow from the hvac vents. one possible of this condition may be the contacts in the hvac junction block(s) located at the right side of the instrumental panel. *js update
Bulletin:
PI0522B
Component:
103000 power train:automatic transmission
Summary:
Gm: tick or rattle noise from front of dash, transmission filler tube cracked or broken (inspect filler tube, replace tube as necessary). *js updated 05/3/2013 *js
Bulletin:
PIT5074F
Component:
110000 electrical system
Summary:
Gm: j-35616-64b terminal test probe and replacement terminal. also included models verano, regal, lacrosse, cts, srx, volt, sonic, malibu, impala, equinox, cruze, avalanche, tahoe suburban, silverado, sierra, yukon, and terrain for model
Bulletin:
PIT-5179
Component:
185000 vehicle speed control:cruise control
Summary:
Cadillac/gmc/chevrolet: information on cruise control being inoperative due to bpp circuit signal and/or tcc/cruise brake pedal parameters, when brake pedal is released but shows applied. models 2007-2013 all escalades, avalanche, silver
Bulletin:
PIT-5120-A
Component:
026000 traction control system
Summary:
Gmc/chevrolet/cadillac: instrument panel messages regarding stabilitrak message, traction control message, service brake system message, is off and gauges, in various modules low speed settings, are inoperative. models 2007-13 all escala
Bulletin:
PIT-5184
Component:
011000 steering:wheel and handle bar
Summary:
Cadillac/chevrolet/gmc: will have inoperative cruise control; inoperative or unwanted activation of radio controls; backlighting flashes, flickers or inoperative due to possible short to ground on steering wheel coil connector x2. models
Bulletin:
PIP-4158F
Component:
061000 engine and engine cooling:engine
Summary:
General motors: low engine oil pressure, no oil pressure, and/or engine noise. this could be the result of a sticking oil pump pressure relief valve. *kb
Bulletin:
SB-07-02-32-002N
Component:
015000 steering:hydraulic power assist system
Summary:
Buick/cadillac/chevrolet/gmc/pontiac/ saturn: there is fluid leaking from power steering system, along a fluid leak in front of vehicle underneath and should be inspected, cleaned and identified before repairing or replacing. model 2010-
Bulletin:
SB-13-05-22-001
Component:
034100 service brakes, hydraulic:foundation components:master cylinder
Summary:
Chevrolet/gmc/cadillac: anytime hydraulic brake pipes assembly need replacing, pre-formed and pre-flared brake pipes are available, except rear axle crossover pipe. model 1999-2007 silverado, sierra, 2000-2006 escalade models, avalanche,
Bulletin:
PI-0773
Component:
103000 power train:automatic transmission
Summary:
Cadillac/chevrolet/gmc/hummer/pontiac: there is slipping or have no fourth, fifth or sixth gear and malfunction indicator lamp (mil) would be on, with diagnostic trouble code (dtc) p0796 found as active. *pe
Bulletin:
SB-080604003-C
Component:
060000 engine (pws)
Summary:
Gmc/chevrolet: engines, with egr system, has leakage from egr cooler engine coolant into the combustion chamber. model 2002-15 silverado, sierra, 2004-09 kodiak c4500-c5500, topkick c4500-c5500, 2006-15 express, savana. *pe
Bulletin:
UIB-117
Component:
061000 engine and engine cooling:engine
Summary:
General motors: an optional engine block heater plug in for onboard ac power and with continuous usage will result in shorting of wires, over heating system, electrical failure and compartment engine fires. model 2003-15 express cut away
Bulletin:
PIP-5276-E
Component:
060000 engine (pws)
Summary:
Cadillac/chevrolet/gmc: on some vehicles and/or trucks, instrument cluster will illuminate, after an oil change, indicating low oil pressure and/or ses lamp will illuminate. model 2007-13 canyon, sierra, savana, yukon, cts-v, escalade, av
Bulletin:
06-03-09-004H
Component:
022140 suspension:rear:springs:leaf spring assembly
Summary:
This technical bulletin provides a procedure to lube the rear leaf springs on vehicles with the condition of a squeak noise originating from the rear of the vehicle.
Bulletin:
PIT5195A
Component:
117000 digital instrument panel
Summary:
This preliminary information communication provides information to the technician about vehicles that the speedometer needle appears to be inaccurate. dealer should advise the customer the specification for speedometer needle accuracy is +/
Bulletin:
PIT5215A
Component:
221700 seats:front assembly:seat heater/cooler
Summary:
This preliminary information communication provides information to the technician about vehicles that after installing the gm accessory heated seat kit, one or more of the following issues may be present the heated seat back and/or bottom t
Bulletin:
PIT5208A
Component:
071100 fuel system, gasoline:storage:tank assembly
Summary:
This preliminary information communication provides information to the technician about vehicles that after refueling the fuel gauge will show empty. technician may find diagnostic trouble code p2636 has set. technician should be advised th
Bulletin:
PIT5201A
Component:
162300 structure:body:door
Summary:
This preliminary information communication provides information to the technician about vehicles that have diagnostic trouble code b2555 may be found in a driver and/or passenger door module. technician should ignore the diagnostic trouble
Bulletin:
PIP4885G
Component:
100000 power train
Summary:
This preliminary information communication provides information to the technician about vehicles that have a groan, growl, or moan coming from the vehicle when operating the vehicle in four wheel drive. driving on clean, dry pavement in fou
Bulletin:
PIT4474E
Component:
110000 electrical system
Summary:
This preliminary information communication provides information to the technician about vehicles that have navigation or radio screen is blank or flashes on and off, no sound from speakers, and rear dvd screen inoperative. technician will f
Bulletin:
PIT3227J
Component:
162500 structure:body:tailgate
Summary:
This preliminary information communication provides information to the technician about vehicles that may have slack in one of the tailgate cables. technician should not replace any parts for this concern. please communicate to the customer
Bulletin:
PIP4885H
Component:
100000 power train
Summary:
This preliminary information communication provides information to the technician about vehicles that have a groan, growl, or moan coming from the vehicle when operating the vehicle in four wheel drive. driving on clean, dry pavement in fou
Bulletin:
PIP3119M
Component:
060000 engine (pws)
Summary:
This preliminary information communication provides information to the technician on the steps to diagnose and repair vehicles that may have a service engine soon malfunction indicator lamp on at low mileage. technician may find diagnostic
Bulletin:
PIT4813E
Component:
110000 electrical system
Summary:
This preliminary information communication provides information to the technician about vehicles with a "service charging system" message displayed on the driver information center and/or a low voltage reading on the volt gauge during the f
Bulletin:
PIP3783D
Component:
060000 engine (pws)
Summary:
This preliminary information communication provides information to the technician about vehicles that may have a service engine soon malfunction indicator lamp on or reduced engine power message. technician may find diagnostic trouble codes
Bulletin:
PIT5067A
Component:
353000 equipment:electrical
Summary:
This preliminary information communication provides information to the technician about vehicles that may have "press check to turn off motion sensor" message on the driver information center. if this message is displayed, the vehicle has a
Bulletin:
PIT4543B
Component:
120000 exterior lighting
Summary:
This preliminary information communication provides information to the technician about the operation of the ground illumination lamp. for the puddle lamps to operate they must be turned on using the drivers information center buttons and i
Bulletin:
PIT4366G
Component:
110000 electrical system
Summary:
This preliminary information communication provides information to the technician on the steps to diagnose and repair vehicles that may have an intermittent "check trailer wiring" message on the driver information center. technician will in
Bulletin:
PIP4932C
Component:
060000 engine and engine cooling
Summary:
This preliminary information communication provides information to the technician about vehicles with service engine soon malfunction indicator lamp. technician may find diagnostic trouble code p0101. technician should follow published serv
Bulletin:
05-08-51-001H
Component:
162000 structure:body
Summary:
This informational bulletin provides information on removing paint stains on the under side of protective shipping film
Bulletin:
06-06-01-010C
Component:
060000 engine (pws)
Summary:
This informational bulletin provides information on close coupled converters and there affect on newly installed engines or engines during there break in period.
Bulletin:
13-02-32-001D
Component:
015000 steering:hydraulic power assist system
Summary:
This technical bulletin provides a procedure to flush and bleed the power steering system to correct a condition of power steering noise or fluid leak from power steering pump, gear or high pressure hose during extreme low temperature condi
Bulletin:
PI0639C
Component:
010000 steering
Summary:
This preliminary informational bulletin provides a procedure to apply dielectric grease and a piece of adhesive shim stock to the steering angle sensor connector to correct a condition of service stabilitak message displayed in dic and dtc
Bulletin:
03-08-46-004R
Component:
353000 equipment:electrical
Summary:
This informational bulletin provides information on part restriction and ordering process information for onstar vehicle communication interface modules (vcim) (gmna only)
Bulletin:
PIT4376G
Component:
110000 electrical system
Summary:
This preliminary information communication advises the technician about key and theft information for fleet vehicles equipped with rpo 6e2 or 6e8 and converting to fleet mode. technician will need to ensure fleet vehicles with rpo 6e2 or 6e
Bulletin:
PIT5184A
Component:
011000 steering:wheel and handle bar
Summary:
This preliminary information communication provides information to the technician about vehicles that have an instrument panel backlighting flashes, flickers or inoperative, unwanted horn activation, radio controls inoperative or unwanted a
Bulletin:
PIT5243
Component:
162500 structure:body:tailgate
Summary:
This preliminary information communication provides information to the technician about vehicles that have tailgate may not lower slowly like the new 2014 silverado 1500 / sierra 1500 models. dealer should communicate to the customer this c
Bulletin:
PIT3237G
Component:
131000 visibility:windshield
Summary:
This preliminary information communication provides information to the technician about the percentage of uv protection or tint offered by the windshield or side glass. technician should be advised windshield reduces uv rays down to 4% or l
Bulletin:
PIT4844E
Component:
010000 steering
Summary:
This preliminary information communication provides information to the technician with the installation of cruise control on a vehicle which did not come equipped with the option. technician will need to contact the techline customer suppor
Bulletin:
PIP4379K
Component:
103000 power train:automatic transmission
Summary:
This preliminary information communication provides information to the technician about vehicles that have not engagement into drive, delayed, no engagement into reverse, and or a range inhibit. technician may find diagnostic trouble codes
Bulletin:
PIT4816E
Component:
110000 electrical system
Summary:
This preliminary information communication provides information to the technician about vehicles that have multiple electrical concerns and or intermittent no crank. technician will need to remove the 175 amp mega fuse and inspect for arcin
Bulletin:
PIT4729E
Component:
118500 electrical system: integrated trailer brake control
Summary:
This preliminary information communication provides information to the technician about customer's wanting to add the factory integrated trailer brake controller regular production option code (jl1) be installed on their full size pickup/ut
Bulletin:
PIT3189R
Component:
110000 electrical system
Summary:
This preliminary information communication provides information to the technician about customers that are unable to override the automatic door locking feature. technician will update the body control module on 2006 to 2007 model years. on
Bulletin:
PIP4568P
Component:
060000 engine (pws)
Summary:
This preliminary information communication provides information to the technician that some vehicles may have a service engine soon lamp, engine misfire on cylinder 1, 4, 6, or 7 and/or tick noise. technician will follow service information
Bulletin:
PIT4228D
Component:
133000 visibility:power window devices and controls
Summary:
This preliminary information communication provides information to the technician about vehicles that have passenger window express down feature is inoperative. technician should be advised that models equipped with either memory seats regu
Bulletin:
PIT4508C
Component:
110000 electrical system
Summary:
This preliminary information communication provides information to the technician about vehicles that the cruise control being inoperative. technician may find diagnostic trouble code b3894 set in the trailer brake control module. technicia
Bulletin:
PIP4885F
Component:
100000 power train
Summary:
This preliminary information communication provides information to the technician about vehicles that have a groan, growl, or moan coming from the vehicle when operating the vehicle in four wheel drive. driving on clean, dry pavement in fou
Bulletin:
PIT5184
Component:
110000 electrical system
Summary:
This preliminary information communication provides information to the technician about vehicles that have an instrument panel backlighting flashes, flickers or inoperative, unwanted horn activation, radio controls inoperative or unwanted a
Bulletin:
PIT5185
Component:
110000 electrical system
Summary:
This preliminary information communication provides information to the technician about vehicles that if the ignition key is turned to the start position, and then released when the engine begins cranking, the engine will continue cranking
Bulletin:
PIT4228E
Component:
133000 visibility:power window devices and controls
Summary:
This preliminary information communication provides information to the technician about vehicles that have passenger window express down feature is inoperative. technician should be advised that models equipped with either memory seats regu
Bulletin:
PIT4506C
Component:
190000 tires
Summary:
This preliminary information communication provides information to the technician that some owners of heavy duty trucks and utilities may ask if they can lower their tire pressures. tire pressures being set to the "tire and loading label" w
Bulletin:
PIT4089H
Component:
220000 seats
Summary:
This preliminary information communication provides information to the technician about vehicles that are unable to set a personalized easy exit seat and/or power tilt column position and they will only move a predetermined amount. dealer s
Bulletin:
PIT3078F
Component:
021700 suspension:front:hub
Summary:
This preliminary information communication provides information to the technician about vehicles that have grease leaking from front hub bearings. technician should not replace the bearing for grease purge. technician should be advised to n
Bulletin:
PIT4169F
Component:
031100 service brakes, electric
Summary:
This preliminary information communication provides information to the technician about vehicles that have a "service stability message" appears on the drivers information center. technician will find diagnostic trouble code c0561 set in th
Bulletin:
PIT4357F
Component:
353000 equipment:electrical
Summary:
This preliminary information communication provides information to the technician about vehicles that have the content theft alarm is inoperative. dealer should communicate to the customer this condition is a normal operating characteristic
Bulletin:
PIT4826B
Component:
030000 brakes (pws)
Summary:
This preliminary information communication provides information to the technician about hairline cracks may be noticed in the pad friction material, when performing a brake inspection. technician should be advised that the hairline cracks d
Bulletin:
PIT4844D
Component:
010000 steering
Summary:
This preliminary information communication provides information to the technician with the installation of cruise control on a vehicle which did not come equipped with the option. technician will need to contact the techline customer suppor
Bulletin:
PIT4978A
Component:
141100 air bags:frontal:sensor/control module
Summary:
This preliminary information communication provides information to the technician about vehicles that have a diagnostic trouble code b0081 in the sensing and diagnostic module and passenger presence sensor modules. technician should inspect
Bulletin:
PIP4932B
Component:
060000 engine and engine cooling
Summary:
This preliminary information communication provides information to the technician about vehicles with service engine soon malfunction indicator lamp. technician may find diagnostic trouble code p0101. technician should follow published serv
Bulletin:
PIT3665C
Component:
030000 brakes (pws)
Summary:
This preliminary information communication advises the technician that the hydro-boost is not serviceable and will need to be replaced if the brake pedal moves or applies on its own at a full turn.
Bulletin:
PIT4225F
Component:
031100 service brakes, electric
Summary:
This preliminary information communication provides information to the technician about vehicles that have an antilock braking system lamp followed by a service stability message in the drivers information center. technician my find diagnos
Bulletin:
PIT4815C
Component:
110000 electrical system
Summary:
This preliminary information communication provides information to the technician with additional vehicle speed sensor diagnostic information. technician may encounter multiple issues when diagnosing a vehicle speed sensor. technician will
Bulletin:
PIT4250F
Component:
160000 structure
Summary:
This preliminary information communication provides information to the technician about vehicles that have water or dust from the openings under the bed rails near the stake pockets. dealer should communicate to the customer this condition
Bulletin:
PIT5161A
Component:
071100 fuel system, gasoline:storage:tank assembly
Summary:
This preliminary information communication provides information to the technician about vehicles that may have a bump feel or clunk noise at a stop or on launch. dealer should communicate to the customer this condition is a normal operating
Bulletin:
PIT4979C
Component:
070000 fuel system, gasoline
Summary:
This preliminary information communication provides information to the technician about vehicles that have a buzz or rattle type noise during light acceleration around 1200-2000 revolutions per minute. technician will need to reposition the
Bulletin:
PIT4505F
Component:
103000 power train:automatic transmission
Summary:
This preliminary information communication provides information to the technician about vehicles that have a rattle, buzz, tick, or vibration type noise that appears to be coming from the center of the dash. technician will adjust the trans
Bulletin:
PIT5039B
Component:
162200 structure:body:bumpers
Summary:
This preliminary information communication provides information to the technician about vehicles that the customer or up-fitter may have removed the rear bumper, install a different rear bumper, or add a different box/flat bed/cube box/hitc
Bulletin:
PIT4261C
Component:
192000 tires:sidewall
Summary:
This preliminary information communication provides information to the technician about vehicles with tire sidewall irregularities. this is a visual condition that will not affect durability, reliability or performance of the tires. dealer
Bulletin:
PIT3330F
Component:
353600 equipment:air conditioner
Summary:
This preliminary information communication provides information to the technician about customers may inquire about the availability of the passenger compartment air filter. dealer should advise the customer starting in 2003 the passenger c
Bulletin:
PIT5189
Component:
133000 visibility:power window devices and controls
Summary:
This preliminary information communication provides information to the technician the steps to diagnose and repair vehicles that have windows inoperative while the engine is running but work when the engine is off. technician should look fo
Bulletin:
PIT4813C
Component:
060000 engine and engine cooling
Summary:
This preliminary information communication provides information to the technician about vehicles with a "service charging system" message displayed on the driver information center and/or a low voltage reading on the volt gauge during the f
Bulletin:
PIT3271F
Component:
190000 tires
Summary:
This preliminary information communication provides information to the technician about changing the tire and wheel size on vehicles. general motors will only support a tire calibration for tires that have been sized, tested and designed fo
Bulletin:
PIT4543A
Component:
120000 lighting (pws)
Summary:
This preliminary information communication provides information to the technician about the puddle light operation. technician should be advised that the puddle lamps to operate, "approach lighting" must be turned on using the drivers infor
Bulletin:
PIP4138L
Component:
100000 power train
Summary:
This preliminary information communication provides information to the technician about vehicles that have a service engine soon malfunction indicator lamp on, engine misfire, and/or engine noise. technician may find diagnostic trouble code
Bulletin:
PIP5083
Component:
060000 engine (pws)
Summary:
This preliminary information communication provides information to the technician about vehicles that have misfires on cylinders 1, 4, 6 and 7. technician should inspect the camshaft part numbers. technician should ensure to use part number
Bulletin:
PIT5195
Component:
117000 digital instrument panel
Summary:
This preliminary information communication provides information to the technician about vehicles that the speedometer needle appears to be inaccurate. dealer should advise the customer the specification for speedometer needle accuracy is +/
Bulletin:
PIP5087
Component:
106000 power train:axle assembly
Summary:
This preliminary information communication provides information to the technician about vehicles that may have a service 4wd message displayed in the driver information center. technician may find diagnostic trouble code c0379. technician w
Bulletin:
PIT4605D
Component:
353600 equipment:air conditioner
Summary:
This preliminary information communication provides information to the technician about vehicles that have a cold air leak on the front passenger side while driving. technician will need to use black rtv silicone and apply over the seam bet
Bulletin:
PIP4158E
Component:
060000 engine and engine cooling
Summary:
This preliminary information communication provides information to the technician about vehicles that have low oil pressure, no oil pressure, and/or engine noise. technician will need to replace the oil pump, flush the oil cooler lines.
Bulletin:
PIT5209
Component:
353000 equipment:electrical
Summary:
This preliminary information communication provides information to the technician about vehicles that for no reason the alarm will go active. technician will need to use a scan tool to verify that the alarm was activated by the inclination
Bulletin:
PIP3119L
Component:
060000 engine and engine cooling
Summary:
This preliminary information communication provides information to the technician on the steps to diagnose and repair vehicles that may have a service engine soon malfunction indicator lamp on at low mileage. technician may find diagnostic
Bulletin:
PIT4417H
Component:
130000 visibility
Summary:
This preliminary information communication provides information to the technician about an owner that may request to have a different style mirror installed on their vehicle or request a different mirror before they purchase the vehicle. sw
Bulletin:
PIP5153
Component:
350000 equipment
Summary:
This preliminary information communication provides information to the technician about the new fluids available for axle service and clarifies usage. technician will use the chart to determine the proper axle lubricant to use.
Bulletin:
PIT3665E
Component:
031000 service brakes, hydraulic:pedals and linkages
Summary:
This preliminary information communication advises the technician that the hydro-boost is not serviceable and will need to be replaced if the brake pedal moves or applies on its own at a full turn.
Bulletin:
PIT5161E
Component:
071000 fuel system, gasoline:storage
Summary:
This preliminary information communication provides information to the technician about vehicles that may have a bump feel or clunk noise at a stop or on launch. dealer should communicate to the customer this condition is a normal operating
Bulletin:
00-03-10-003R
Component:
190000 tires
Summary:
This warranty administration bulletin provide policy information new tire warranty program and global warranty management submission information.
Bulletin:
99-09-40-005G
Component:
150000 seat belts
Summary:
This informational bulletin provides information on availability for the seat belt extender.
Bulletin:
06-06-01-010B
Component:
060000 engine and engine cooling
Summary:
This informational bulletin provides information on close-coupled converter and engine replacement.
Bulletin:
06-00-89-026L
Component:
030000 brakes (pws)
Summary:
This warranty administration bulletin provide policy information on a revised customer concern not duplicated/verified labor operation numbers and how to submit ccnd.
Bulletin:
01-03-10-003K
Component:
190000 tires
Summary:
This warranty administration bulletin provide policy information on gm of canada new vehicle limited warranty tire program and global warranty management (gwm) submission information.
Bulletin:
PI1018A
Component:
116000 electrical system:ignition
Summary:
This preliminary informational bulletin adds the 2015 model year to repair information on correcting a customer concern of poor, limited, reduced remote keyless entry (rke) or remote vehicle start (rvs) range.
Bulletin:
05-00-89-055E
Component:
356000 equipment adaptive
Summary:
This warranty administration bulletin provides information to clarify proper transaction administration of gm dealer empowerment program and goodwill cases.
Bulletin:
09-03-09-001B
Component:
020000 suspension
Summary:
This technical bulletin provides repair information for the re-torque of leaf spring bolts to correct a customer concern for a clunking noise coming from the rear of the vehicle.
Bulletin:
09-03-09-001C
Component:
020000 suspension
Summary:
This technical bulletin provides repair information for the re-torque of leaf spring bolts to correct a customer concern for a clunking noise coming from the rear of the vehicle.
Bulletin:
04-06-04-051D
Component:
073000 fuel system, gasoline:fuel injection system
Summary:
This informational bulletin provides information for maintenance cleaning of the fuel injectors.
Bulletin:
15-08-44-001B
Component:
353000 equipment:electrical
Summary:
This informational bulletin provides information on a gm of canada onstar® cellular communication upgrade.
Bulletin:
15-08-44-001A
Component:
353500 equipment:electrical:navigational system(global positioning system)
Summary:
This informational bulletin provides information on a gm of canada onstar® cellular communication upgrade.
Bulletin:
00-06-01-026F
Component:
060000 engine and engine cooling
Summary:
This informational bulletin provides information to technicians regarding intake manifold inspection/replacement after severe internal engine damage.
Bulletin:
15-00-89-004A
Component:
060000 engine and engine cooling
Summary:
This informational bulletin provides technicians with updated information to help identify the differences between what is considered a fluid leak, and what is considered seepage.
Bulletin:
05-06-04-035E
Component:
090000 fuel system, other
Summary:
This informational bulletin provides dealership personnel with information on flexible fuel vehicles (ffvs) and the usage of e85 fuel in gm vehicles.
Bulletin:
02-07-30-052J
Component:
103000 power train:automatic transmission
Summary:
This informational bulletin provides technicians with information regarding automatic transmission oil cooler flow test essential tool j-45096 transflow®.
Bulletin:
15-08-44-001C
Component:
353500 equipment:electrical:navigational system(global positioning system)
Summary:
This informational bulletin provides information on a gm of canada onstar® cellular communication upgrade.
Bulletin:
99-00-89-019M
Component:
355200 equipment:other:owners/service/other manual
Summary:
This informational bulletin provides dealership personnel with global warranty management (gwm), warranty parts center (wpc), and parts return program information.
Bulletin:
02-00-89-002O
Component:
356000 equipment adaptive
Summary:
This informational bulletin provides information for dealers/technicians on when and how to submit a field product report (fpr) (u.s. dealers only).
Bulletin:
07-06-04-019E
Component:
060000 engine and engine cooling
Summary:
This technical bulletin provides repair information for repairing the ip to body harness connector to correct a customer concern for intermittent malfunction indicator lamp (mil) illuminated with reduced engine power displayed and dtc p21
Bulletin:
15-08-44-001
Component:
353000 equipment:electrical
Summary:
This informational bulletin provides information on a gm of canada onstar® cellular communication upgrade.
Bulletin:
15-08-73-001
Component:
353000 equipment:electrical
Summary:
This informational bulletin provides information on communication with onstar® module after canadian cellular upgrade.
Bulletin:
12-06-01-008B
Component:
356000 equipment adaptive
Summary:
This informational bulletin provides dealership personnel information on unscheduled supplemental services (including flushing services and additives) and proper use of gm simplified maintenance schedules (canada only).
Bulletin:
09-00-89-016D
Component:
356000 equipment adaptive
Summary:
This warranty administration bulletin provides retail and wholesale service personnel with the policies and the warranty claims submission procedures that support labor operation 0600014 - suspected tampering or vehicle modifications.
Bulletin:
04-00-89-015J
Component:
356000 equipment adaptive
Summary:
This warranty administration bulletin communicates gm required operating procedures (u.s. only) for service operations.
Bulletin:
PI1440
Component:
353600 equipment:air conditioner
Summary:
This preliminary informational bulletin provides technicians with diagnostic tips for a customer concern of odor emanating from hvac system.
Bulletin:
00-05-22-002O
Component:
030000 brakes (pws)
Summary:
This informational bulletin provides technicians with a brake lathe calibration procedure.
Bulletin:
13-08-116-001B
Component:
353000 equipment:electrical
Summary:
The intent of this technical bulletin is to identify aftermarket aldl or dlc interface devices as potential sources for causing multiple customer concerns that do not have other diagnostic methods to identify them.
Bulletin:
05-08-46-009D
Component:
353000 equipment:electrical
Summary:
This informational bulletin adds the 2014 and 2015 model years to information of a language change for onstar system (u.s. and canada only).
Bulletin:
09-09-40-001C
Component:
150000 seat belts
Summary:
This informational bulletin provides information to advise dealers about seat belt buckles not operating and/or seat belt warning light illumination, as well as difficulty latching and unlatching the buckle or the buckle release button stic
Bulletin:
07-00-89-037H
Component:
355200 equipment:other:owners/service/other manual
Summary:
This warranty administration bulletin provides policy information on courtesy transportation and roadside assistance programs.
Bulletin:
00-06-01-026G
Component:
060000 engine and engine cooling
Summary:
This informational bulletin provides information to technicians regarding intake manifold inspection/replacement after severe internal engine damage.
Bulletin:
10-08-110-001D
Component:
356000 equipment adaptive
Summary:
This informational bulletin provides information on the proper use of gm floor mats.
Bulletin:
15-00-89-005
Component:
356000 equipment adaptive
Summary:
This warranty administration bulletin provides dealership personnel with policy and procedure requirements for essential tools that include consumable parts (u.s. only).
Bulletin:
10-00-89-017X
Component:
356000 equipment adaptive
Summary:
This informational bulletin provides a list off all the issues revolving around new vehicles for a one stop place to find growing concerns around them.
Bulletin:
11-00-89-005C
Component:
356000 equipment adaptive
Summary:
This warranty administration bulletin provides information on the clarification of use for dealer empowerment labor operations and customer enthusiasm
Bulletin:
11-00-90-001A
Component:
060000 engine and engine cooling
Summary:
This informational bulletin provides information on the proper oils to use on gm vehicles including information regarding the differences of the dexos oils.
Bulletin:
PIP5276F
Component:
060000 engine (pws)
Summary:
This preliminary information communication provides steps the technician will uses to diagnose and repair vehicles that have low oil pressure after an oil change with the engine regular production option code l20, l77, l94, l96, l99, l9h, l
Bulletin:
PIT5484A
Component:
118000 electrical system: software
Summary:
This preliminary information communication advises the technician that if onstar is unable to configure the vehicle after the onstar 15-08-44-001 upgrade and onstar receives a 118 error code when attempting to configure the vehicle. dealers
Bulletin:
08-08-44-015E
Component:
353000 equipment:electrical
Summary:
This informational bulletin provides information on inappropriate warranty claims submitted for damaged radios and ipcs
Bulletin:
04-00-89-015H
Component:
356000 equipment adaptive
Summary:
This warranty administration bulletin provide policy information of the job card, for a repair on vehicles and what is acceptable - customer authorization; service manager approvals and transaction authorization; details of concern, cause a
Bulletin:
07-08-49-020I
Component:
356000 equipment adaptive
Summary:
This informational bulletin provides a quick guide to updating which model vehicle after replacing the ipc.
Bulletin:
06-08-43-003E
Component:
136000 visibility:windshield wiper/washer
Summary:
This informational bulletin explains how to care for wiper blades.
Bulletin:
14-00-89-003A
Component:
356000 equipment adaptive
Summary:
This information for warranty administration - changes the service policy and procedures section 1.6.2.11 and now is refered to article 3.2.9 of the 1st addition manual for details of technician identification and accounting of labor time
Bulletin:
PIC4310K
Component:
353000 equipment:electrical
Summary:
This preliminary information communication provides information to the technician about vehicle that may have an onstar system that has progression tones when pressing the blue or red button. technician will need to call general motors tech
Bulletin:
PIC3278F
Component:
353000 equipment:electrical
Summary:
This preliminary information communication provides information to the technician the steps needed to diagnose and repair the vehicles that may have unwanted or phantom phone calls. technician will need to determine what type of call the cu
Bulletin:
PIT3271G
Component:
190000 tires
Summary:
This preliminary information communication provides information to the technician about changing the tire and wheel size on vehicles. general motors will only support a tire calibration for tires that have been sized, tested and designed fo
Bulletin:
PIP4568R
Component:
060000 engine and engine cooling
Summary:
This preliminary information communication provides information to the technician that some vehicles may have a service engine soon lamp, engine misfire on cylinder 1, 4, 6, or 7 and/or tick noise. technician will follow service information
Bulletin:
PIT5264C
Component:
353000 equipment:electrical
Summary:
This preliminary information communication provides information to the technician about vehicles that are travelling from canada to the united states. while in the united states they are unable to receive turn-by-turn directions. due to the
Bulletin:
PIC4310L
Component:
110000 electrical system
Summary:
This preliminary information communication provides information to the technician about vehicle that may have an onstar system that has progression tones when pressing the blue or red button. technician will need to call general motors tech

Home | Privacy