2007 CHEVROLET C8500 Recall

Campaign:
07V190000 on 05/01/2007
Component:
Service brakes, air:supply:compressor
Manufactured:
05/31/2006 - 04/29/2007
Affected:
1,896
Defect:
On certain medium duty conventional and tilt cab trucks equipped with 7.8l diesel engines and air brakes, the air compressor may not build enough air pressure to support the air brake system.
Consequence:
If this condition were to occur while the vehicle was stationary (brakes applied) the air brakes would remain applied and prevent the vehicle from moving. if this condition were to occur while the vehicle was in motion, the dual system air pressure gauges would register the drop in pressure. if the pressure continued to drop, the low air pressure warning buzzer and warning lamp would activate as designed, warning the driver to move the vehicle to a safety location. if the driver ignores these warnings and continues to drive the vehicle, and if there was a continued loss of pressure, the rear spring parking brakes would automatically apply, preventing the truck from being driven.
Correction:
Dealers will replace the air compressor head. the recall began on may 23, 2007. owners may contact chevrolet at 1-800-630-2438, gmc at 1-866-996-9463, or isuzu at 1-800-255-6727.
Notes:
Gm recall no. 07066.customers may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov.

2007 CHEVROLET C8500 TSBs (41)

Bulletin:
070604021
Component:
061000 engine and engine cooling:engine
Summary:
Lack of power, engine will not rev-up, idle vibration, engine starting concerns, dtc;s p1093, p0087, p1087, p0088 and/or p1088 set (diagnose and replace suction control valve (scv) (fuel pressure regulator (fpr)), if necessary) *nj
Bulletin:
4522
Component:
110000 electrical system
Summary:
Multiple electrical concerns/ with 7.8 (rpo lg4 or lf8). *nj
Bulletin:
4525
Component:
980000 unknown or other
Summary:
How to determine date code for campaign 07164. *nj
Bulletin:
4488
Component:
171100 latches/locks/linkages:doors:latch
Summary:
Right outside door handle inoperative. *nj
Bulletin:
08-08-64-005
Component:
162300 structure:body:door
Summary:
Passenger side front outside door handle inoperative (replace outside door handle). *pe
Bulletin:
SB-08-J-003
Component:
061200 engine and engine cooling:engine:diesel
Summary:
Chevrolet, gmc and isuzu trucks: lack of power, engine will not rev up, idle vibration, engine starting concerns, dtcs p1093, p0087, p1087, p0088 and/or p1088 set (diagnose and replace suction control valve (scv) (fuel pressure regulator (f
Bulletin:
PIT-4883
Component:
013000 steering:gear box (other than rack and pinion)
Summary:
Gmc/chevrolet: fluid leak at steering gear input shaft. all c series models. when repairing a power steering fluid leak at the steering gear input shaft stub seal beware that the pressure seal is not available from gm spo parts. *pe
Bulletin:
PIT-4935
Component:
030000 service brakes, hydraulic
Summary:
Chevrolet/gmc: brake assist pump motor on and warning light/chime. owners may comment when turning the steering wheel with the brake applied that the hydraulic brake assist pump turns on and the brake warning lamp and chime may sound. mo
Bulletin:
SB-08-J-003-A
Component:
061200 engine and engine cooling:engine:diesel
Summary:
Izuzu: this tsb is for vehicles equipped with 7800 izuzu diesel engines. there is a process for getting horsepower/torque upgrades. *rm updated 3/9/12. *pe updated 7/27/12. *pe
Bulletin:
05-09-40-002E
Component:
151200 seat belts:front:webbing
Summary:
Gm: service bulletin explaining when the safety belts are supposed to lock. *rm updated 12/6/11. *pe
Bulletin:
SB-12-J-005
Component:
060000 engine (pws)
Summary:
Isuzu (chevrolet/gmc): trucks with diesel engine would have idle vibration, trouble starting, engine not revving up, and a lack of power due to possible operation condition of suction control valve (scv)/fuel rail pressure (frp) regulator
Bulletin:
SB-03-07-29-004K
Component:
102000 power train:manual transmission
Summary:
This informational bulletin provide information on the operating characteristics of a manual transmission.
Bulletin:
PI-0754-B
Component:
132000 visibility:glass, side/rear
Summary:
This informational bulletin provides information on a normal condition on tempered glass of spots showing on the rear and side windows when the vehicle is in the sunlight.
Bulletin:
SB-07-06-01-016C
Component:
060000 engine (pws)
Summary:
This informational bulletin provides information internal engine noise or damage after oil filter replacement
Bulletin:
SB-06-08-47-001L
Component:
118000 electrical system: software
Summary:
This informational bulletin provides warranty information on using the service programming system (sps) for programming control modules
Bulletin:
SB-03-06-03-004Q
Component:
111000 electrical system:battery
Summary:
This warranty administration bulletin provide policy information on using the el-50313 midtronics gr8 battery tester/charger for diagnosing battery replacements and maintaining batteries on new vehicles in dealer inventory.
Bulletin:
SB-15-06-03-001B
Component:
111000 electrical system:battery
Summary:
This informational bulletin provides information that may be useful on diagnosing batteries that have set for a long period of time and/or set in cold weather climates and testing those batteries.
Bulletin:
PIC-5260-A
Component:
110000 electrical system
Summary:
This preliminary information communication advises the technician the steps on diagnosing the concern. vehicle's sunroof operation intermittent, bind, noise, auto-reverse, and/or water leaks.
Bulletin:
PIC-5050-A
Component:
110000 electrical system
Summary:
This preliminary information communication advises the technician the steps on repairing the concern. a customer may identify a concern of unable to reactivate a vehicle's onstar that has been previously disabled by onstar. dealer is to ca
Bulletin:
PIC-4935-E
Component:
110000 electrical system
Summary:
This preliminary information communication provides information to help the dealership technicians perform a parasitic drain test for the onstar module. when performing battery parasitic drain test, there may be some confusion as to what th
Bulletin:
PIC-5374-D
Component:
353500 equipment:electrical:navigational system(global positioning system)
Summary:
This preliminary information communication advises the technician on the steps to diagnose and repair the concern of receiving frequent "off route" messages while following turn by turn (tbt) route navigation. the technician is provided in
Bulletin:
16NA241
Component:
110000 electrical system
Summary:
This technical bulletin provides a procedure to check the cylinders for damaged pistons and determine if the use of aftermarket calibrations or performance parts may be the cause.
Bulletin:
16NA260
Component:
353400 equipment:electrical:radio/tape deck/cd etc.
Summary:
This technical bulletin provides a procedure to reprogram the media disc player with the latest calibrations to correct a condition of the rear entertainment system not operating as intended in colder ambient temperature areas due to calibr
Bulletin:
000601012F
Component:
060000 engine (pws)
Summary:
This informational bulletin provides information to gm dealers on the correct cleaning methods when cleaning engine gasket sealing surfaces.
Bulletin:
000601026I
Component:
060000 engine (pws)
Summary:
This informational bulletins provides information on the intake manifold inspection/replacement after servere internal engine damage.
Bulletin:
030603004R
Component:
060000 engine (pws)
Summary:
This informational bulletin provides information on how to test a battery and what is needed to warranty a battery.
Bulletin:
030604017I
Component:
061200 engine and engine cooling:engine:diesel
Summary:
This informational bulletin explains the use of diesel fuel additives in an engine, are not required unless the customer desires additives to prevent fuel concerns depending on fuel or temperature related conditions.
Bulletin:
PI1394A
Component:
060000 engine (pws)
Summary:
This informational bulletin provides additional information on how to install pistons and suggest what tools to use.
Bulletin:
PIP4786C
Component:
060000 engine and engine cooling
Summary:
This preliminary information communication provides information to the technician about vehicles that may have low oil pressure message. technician may also find a diagnostic trouble code p0521 in the engine control module. technician shoul
Bulletin:
PIT5074J
Component:
110000 electrical system
Summary:
This preliminary information communication provides information to the technician about the use of j-35616-64b terminal test probe, replacement terminals, and terminated leads. the j-35616-64b is the latest test probe released for checking
Bulletin:
PIC4707E
Component:
353000 equipment:electrical
Summary:
This preliminary information communication advises the technician to diagnose the concern and the steps to repair the concern. the vehicle's xm travel link may be inopertive.
Bulletin:
PIC4935E
Component:
110000 electrical system
Summary:
This preliminary information communication provides information to help the dealership technicians perform a parasitic drain test for the onstar module. when performing battery parasitic drain test, there may be some confusion as to what th
Bulletin:
PIC5050A
Component:
353000 equipment:electrical
Summary:
This preliminary information communication advises the technician the steps on repairing the concern. a customer may identify a concern of unable to reactivate a vehicle's onstar that has been previously disabled by onstar. dealer is to ca
Bulletin:
PIC5088F
Component:
353400 equipment:electrical:radio/tape deck/cd etc.
Summary:
This preliminary information communication advises the technician on the steps to diagnose and repair the concern. the vehicle's xm radio only has xm preveiw channels.
Bulletin:
PIC5260A
Component:
130000 visibility
Summary:
This preliminary information communication advises the technician the steps on diagnosing the concern. vehicle's sunroof operation intermittent, bind, noise, auto-reverse, and/or water leaks.
Bulletin:
PIC5374D
Component:
353500 equipment:electrical:navigational system(global positioning system)
Summary:
This preliminary information communication advises the technician on the steps to diagnose and repair the concern of receiving frequent "off route" messages while following turn by turn (tbt) route navigation. the technician is provided in
Bulletin:
PIT5389A
Component:
353500 equipment:electrical:navigational system(global positioning system)
Summary:
This preliminary information communication advises the technician on the steps for diagnosing the concern. the vehicle may be unable to connect to onstar using the white, blue or red onstar buttons.
Bulletin:
PIT5485B
Component:
110000 electrical system
Summary:
This preliminary information communication advises the technician if unable to place an onstar call in the ignition on mode after the onstar canada upgrade, to contact the gm technical assistance center onstar group for further assistance.
Bulletin:
PIT5485A
Component:
110000 electrical system
Summary:
This preliminary information communication advises the technician, if unable to place an onstar call in the ignition on mode after the onstar canada upgrade to contact the gm technical assistance center onstar group for further assistance.
Bulletin:
PI0373A
Component:
135000 visibility:rearview mirrors/devices
Summary:
This preliminary informational bulletin provides a procedure for relearning the power folding mirriors and road testin to verify they correct a condtion of the power folding mirriors glass shakes, flutters at normal driving conditions.
Bulletin:
PIT3271G
Component:
350000 equipment
Summary:
This preliminary information communication provides information to the technician about changing the tire and wheel size on vehicles. general motors will only support a tire calibration for tires that have been sized, tested and designed fo

Home | Privacy