2007 BMW G650X MOTO Recalls (3)
- Campaign:
- 07V367000 on 08/16/2007
- Component:
- Engine and engine cooling:engine
- Manufactured:
- 01/19/2007 - 03/05/2007
- Affected:
- 173
- Defect:
- On certain motorcycles, a left-side chain tensioner has been incorrectly installed on the right side. as a result, a hex nut, which is used to secure the chain tensioner, is improperly seated against the tensioner.
- Consequence:
- Loosening of the chain tensioner and the rear wheel axle may occur. this could lead to a condition in which the motorcycle is unstable, increasing the risk of a crash.
- Correction:
- Dealers will install a new right side chain tensioner free of charge. the recall began on november 13, 2007. owners may contact bmw at 1-800-831-1117.
- Notes:
- Customers may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov.
- Campaign:
- 07V376000 on 08/21/2007
- Component:
- Fuel system, gasoline:delivery:fuel pump
- Manufactured:
- 01/04/2007 - 02/20/2007
- Affected:
- 764
- Defect:
- On certain motorcycles, the fuel pump wiring set has not been manufactured according to specification. the contacts in the plug for the fuel pump can break.
- Consequence:
- The fuel pump will fail and fuel delivery to the engine would cease causing the engine to stall increasing the risk of a crash.
- Correction:
- Dealers will replace the fuel pump unit wiring set free of charge. the recall began on october 1, 2007. owners may contact bmw at 1-800-831-1117.
- Notes:
- Customers may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov.
- Campaign:
- 08V106000 on 03/10/2008
- Component:
- Fuel system, gasoline:delivery:hoses, lines/piping, and fittings
- Manufactured:
- 07/31/2006 - 03/13/2007
- Affected:
- 1,391
- Defect:
- Bmw is recalling 1,391 my 2007 g650x challenge, country, and moto motorcycles. the fuel lines may have been damaged during production, and could develop a leak. the leak could occur either through the fabric inlay at the end of the line, or, through a crack in the actual line.
- Consequence:
- Fuel leakage, in the presence of an ignition source, could result in a fire.
- Correction:
- Dealers will inspect and replace the fuel lines free of charge. the recall began during april 2008. owners may contact bmw at 1-800-831-1117.
- Notes:
- Customers may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov.
2007 BMW G650X MOTO TSBs (8)
- Bulletin:
- 13-002-07
- Component:
- 072200 fuel system, gasoline:delivery:hoses, lines/piping, and fittings
- Summary:
- Bmw motorcycle: replacement of fuel line and termination of the engine test run to check the fuel hose campaign. *pe updated 10/16/08. *pe
- Bulletin:
- SB-13-002-07
- Component:
- 072200 fuel system, gasoline:delivery:hoses, lines/piping, and fittings
- Summary:
- Bmw motorcycle: replacement of fuel line and termination of the engine test run to check the fuel hose campaign. in isolated instances, fuel lines suffered incipient damage in the course of the manufacturing process. lines damaged in thi
- Bulletin:
- SB-00-021-07
- Component:
- 090000 fuel system, other
- Summary:
- Bmw motorcycle: engine fuels containing ethanol. bmw motorrad has no objection to the use of si engine fuels containing up to a maximum of 10% ethanol and imposes no warranty restrictions. ethanol mixtures in proportions higher than 10%
- Bulletin:
- SIB-16-02-09
- Component:
- 072100 fuel system, gasoline:delivery:fuel pump
- Summary:
- Bmw vehicles: fuel level sensor repairs. where it is necessary to replace the right or the left side fuel level sensor due to a failure, the entire pump and housing or delivery unit (suction jet assembly) do not need to be replaced as wel
- Bulletin:
- SB-22898888-02
- Component:
- 101000 power train:clutch assembly
- Summary:
- Bmw motorcycle: clutch does not open fully on models with rotax engine. the rotax engines may display the following symptoms after approx. 6000 mi on the clock: the clutch does not open fully; in some cases, the clutch lever cannot be pul
- Bulletin:
- TB-34-003-10
- Component:
- 034200 service brakes, hydraulic:foundation components:hoses, lines/piping, and fittings
- Summary:
- Bmw motorcycle: repair set for brake pipe distributor bracket. all models (k15) have a brake pipe distributor held by frame mounted bracket just behind the steering head. this frame mounted bracket can develop cracks. a repair set that
- Bulletin:
- SIB-63-02-01
- Component:
- 120000 exterior lighting
- Summary:
- Bmw: procedure for determining and replacing incandescent and halogen light bulbs under warranty. *rm
- Bulletin:
- SIB-11-03-08
- Component:
- 063110 engine and engine cooling:exhaust system:emission control:crankcase (pcv)
- Summary:
- Bmw: crankcase pressure diagnosis and information for all vehicles. *rm updated on 4/24/2013. *kb
Home | Privacy