2006 SUZUKI FORENZA Recalls (5)
- Campaign:
- 07V315000 on 07/23/2007
- Component:
- Seat belts:front:buckle assembly
- Manufactured:
- 05/05/2005 - 12/19/2006
- Affected:
- 75,697
- Defect:
- On certain passenger vehicles, the front seat belt tongue will not latch into the buckle and, in rare cases, even the locked tongue will pop out by low stretching force. if the buckle does not latch completely, the buckle could release without pressing the release button.
- Consequence:
- These buckle malfunctions, which could prevent a person from using the seat belt or could cause the seat belt to fail to function as designed, can increase the risk of injury in a crash.
- Correction:
- Dealers will replace the front driver and passenger seat belt buckles with the improved part free of charge. the recall began on august 31, 2007. owners may contact suzuki at 1-800-934-0934.
- Notes:
- Suzuki recall no. ky.customers may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov.
- Campaign:
- 07V452000 on 09/24/2007
- Component:
- Exterior lighting
- Manufactured:
- 09/22/2003 - 01/17/2006
- Affected:
- 93,963
- Defect:
- On certain passenger vehicles, headlamp low beam or daytime running light (drl) function may be inoperative due to a melted splice pack on the wiring harness.
- Consequence:
- Inappropriate lighting could reduce visibility of vehicles and increase the potential for a crash.
- Correction:
- Dealers will splice the power circuit wires for the low-beam headlamps and drl free of charge. the recall will be mailed in three phases, starting at the end of october 2007 and concluding by the end of january 2008;. owners may contact suzuki at 1-800-934-0934.
- Notes:
- Suzuki recall no. nb.customers may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov.
- Campaign:
- 12V397000 on 08/13/2012
- Component:
- Electrical system:wiring:interior/under dash
- Affected:
- 101,688
- Defect:
- Suzuki is recalling certain model year 2004-2006 forenza and model year 2005-2006 reno vehicles manufactured from september 23, 2003, through march 7, 2006. increased resistance due to poor contact between the terminals of certain wires can generate heat that can melt the splice pack used to connect the power circuit wires for the headlamps. this can result in intermittent or total loss of low/high beam headlamp function.
- Consequence:
- If the headlamps fail to function, this will lead to reduced driver visibility, increasing the risk of a crash.
- Correction:
- Suzuki will notify owners, and suzuki dealers will reconnect the affected wires with two heat-shrink crimps, free of charge. the safety recall began on september 25, 2012. owners may contact suzuki at 1-877-697-8985.
- Notes:
- Suzuki's recall campaign number is nu.customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.
- Campaign:
- 12V397000 on 08/13/2012
- Component:
- Exterior lighting:headlights
- Affected:
- 101,688
- Defect:
- Suzuki is recalling certain model year 2004-2006 forenza and model year 2005-2006 reno vehicles manufactured from september 23, 2003, through march 7, 2006. increased resistance due to poor contact between the terminals of certain wires can generate heat that can melt the splice pack used to connect the power circuit wires for the headlamps. this can result in intermittent or total loss of low/high beam headlamp function.
- Consequence:
- If the headlamps fail to function, this will lead to reduced driver visibility, increasing the risk of a crash.
- Correction:
- Suzuki will notify owners, and suzuki dealers will reconnect the affected wires with two heat-shrink crimps, free of charge. the safety recall began on september 25, 2012. owners may contact suzuki at 1-877-697-8985.
- Notes:
- Suzuki's recall campaign number is nu.customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.
- Campaign:
- 14V262000 on 05/18/2014
- Component:
- Exterior lighting:headlights
- Manufactured:
- 08/31/2003 - 07/29/2008
- Affected:
- 184,244
- Defect:
- Suzuki motor of america, inc. (suzuki) is recalling certain model year 2004-2008 forenza vehicles, and 2005-2008 reno vehicles manufactured from september 1, 2003, through july 30, 2008. in the affected vehicles, heat may be generated in the headlamp switch or daytime running light (drl) module which could melt the headlamp switch or the drl module.
- Consequence:
- If the heat generated within the headlamp switch or drl module located on the left side of the steering column melts the headlamp switch or drl module, there is an increased risk of a fire.
- Correction:
- Suzuki will replace the signal switch and add a jumper relay kit and will replace the drl module in teh instrument panel harness. suzuki distributed to owners an interim letter on july 30, 2014. the recall began october 29, 2014. owners may contact suzuki at 1-800-934-0934. suzuki's number for this recall is xa.
- Notes:
- Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.
2006 SUZUKI FORENZA TSBs (18)
- Bulletin:
- 0311075
- Component:
- 103000 power train:automatic transmission
- Summary:
- Dtc p0703 explained. automatic transmission dtc p0703 is present. all forenza models. suzuki. *tt
- Bulletin:
- 0703156
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Oil consumption or exhaust smoke (excessive). *tt
- Bulletin:
- 0808106
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Evaporative emission system continuous purge flow. ecm software could cause unnecessary illumination of the malfunction indicator lamp. suzuki. *kb
- Bulletin:
- 0910056
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Hard start with extended cranking time. ecm software logic. *kb
- Bulletin:
- 1102217
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Engine cranks but will not start mil on with dtc p0606 stored (control module performance). *kb
- Bulletin:
- 1103137
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Engine cranks cut will not start mil on with dtc p0606 (control module performance) stored. *kb
- Bulletin:
- 1404067
- Component:
- 072100 fuel system, gasoline:delivery:fuel pump
- Summary:
- No fuel pump prime before start up. *kb
- Bulletin:
- 1605227
- Component:
- 070000 fuel system, gasoline
- Summary:
- Service manual update, dtc p2106 throttle actuator control (tac) system performance. throttle limitation
- Bulletin:
- 0812177
- Component:
- 118000 electrical system: software
- Summary:
- P0441 or p0496 (evaporative emission system continuous purge flow). *nj
- Bulletin:
- TS0501158
- Component:
- 141100 air bags:frontal:sensor/control module
- Summary:
- Airbag light on; dtc b1378 (driver side airbag resistance too high) and/or dtc b1382 (passenger side airbag resistance too high). forenza, sedan/wagon, reno (rq420) 2005-2006. vin(s) -6k425022. *nj
- Bulletin:
- TS0601238
- Component:
- 103100 power train:automatic transmission:control module (tcm, pcm)
- Summary:
- Required automatic transmission control module initialization procedure. my 2004-2008 forenz sedan/wagon, reno (rq420). *nj
- Bulletin:
- TS 19 05028
- Component:
- 073200 fuel system, gasoline:fuel injection system:injectors
- Summary:
- Hard to find fuel odor; diagnostic information. *nj
- Bulletin:
- TS-09-03129R
- Component:
- 103000 power train:automatic transmission
- Summary:
- Suzuki vehicles: automatic transmission shift lever is loose in the shift gate and/or ignition key cannot be removed. the transmission gear shift lever does not hold firmly to the left of the shift gage as expected. *pe
- Bulletin:
- TSB-23-06110
- Component:
- 114000 electrical system:wiring
- Summary:
- Suzuki vehicles: counter measure procedure for dtc p2138. mil light is on, dtc p2138 stored. failure of the connector and/or wiring circuits between the ecm and the accelerator pedal position sensor. models forenza, forenza wagon and ren
- Bulletin:
- TB-22-02041R
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Suzuki vehicle: counter measure procedure for dtc p2135. mil light is on; dtc p2135 stored without fully checking system and circuits after repairs and/or replacement to throttle body. *pe
- Bulletin:
- SC-60R-1
- Component:
- 141000 air bags:frontal
- Summary:
- Suzuki: on certain vehicles, within the front passenger seat bottom cushion, the sensing sensor mat, an electric circuit disconnection may have developed, due to repeated flexing. *pe
- Bulletin:
- TS-30-06263
- Component:
- 060000 engine (pws)
- Summary:
- Suzuki: suzuki has replacement oil pumps that have a threaded plug. the threaded proves to be difficult to remove without causing damage to the new oil pump. this bulletin provides procedures when replacing the old oil pump. *js
- Bulletin:
- SUZ_013175
- Component:
- 141000 air bags:frontal
- Summary:
- This service bulletin updates a bulletin originally issued on may 18, 2016, concerning a special warranty extension (zh) for 2005-2008 suzuki forenza and suzuki reno vehicles. the updates are: (1) the existence of diagnostic trouble code (
Home | Privacy