2006 SPARTAN MM Recalls (4)

Campaign:
06V094000 on 03/30/2006
Component:
Electrical system:fuses and circuit breakers
Manufactured:
11/07/2005 - 03/01/2006
Affected:
54
Defect:
On certain motor homes, the bussman box was incorrectly soldered and could fail.
Consequence:
Electrical power may be lost to components of the major chassis operating systems (engine, transmission, starting, cooling) causing the vehicle to shutdown and/or not be capable of powering up. one or a combination of the following conditions may occur: loss of electrical power to the engine, transmission starting and engine cooling systems, in the operation of the right chassis stop/turn signal and right trailer stop/turn signal, antilock brake system (abs), auxiliary brake system, heater elements in the air dryer, and/or the heater element in the water in-fuel separator, increasing the risk of a crash.
Correction:
Dealers will replace the defective components. the recall began on april 10, 2006. owners may contact spartan at 1-517-543-6400.
Notes:
Spartan recall no. spec 06005.customers may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov.
Campaign:
07V280000 on 06/28/2007
Component:
Engine and engine cooling:engine:diesel
Manufactured:
07/26/2005 - 12/12/2006
Affected:
495
Defect:
On certain motor homes built with cummins isl cm850 diesel engines, the connecting rod contains a machining defect in the wrist pin bushing of the rod that could cause a seizure of the piston pin.
Consequence:
If allowed to progress, this can lead to engine failure with the possibility of the rod rupturing the lock cavity, resulting in oil and debris on the roadway increasing the risk of a vehicle crash.
Correction:
Spartan is working with cummins to recalibrate the engine control module and enhance the engine protection system enabling it to provide early detection of the failure mode and avoid more serious engine damage and resultant safety hazard. cummins will also install a new valve cover with a crankcase pressure sensor free of charge (please see 07e033). owners may contact cummins at 800-343-7357 or spartan at 517-543-6400.
Notes:
Spartan recall no. spec 07008.customers may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov.
Campaign:
13V182000 on 05/07/2013
Component:
Steering
Manufactured:
07/19/2005 - 12/16/2010
Affected:
2,694
Defect:
Spartan motors chassis (spartan) is recalling certain model year 2006-2011 k2, and k3 and 2006-2010 mm motorhome chassis manufactured july 20, 2005, through december 17, 2010. the steering gear mounting brackets may crack and detach resulting in a loss of steering.
Consequence:
A loss of steering control may increase the risk of a crash.
Correction:
Spartan will notify owners. starting in mid-june 2013, dealers will install a replacement bracket or a reinforcement to the existing bracket. until the remedy is available, owners may have their vehicle inspected at any spartan service center. all repairs will be performed free of charge. notices were mailed to owners on june 24, 2013. owners can contact spartan at 1-855-589-9836.
Notes:
Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.
Campaign:
15V549000 on 08/31/2015
Component:
Engine and engine cooling:cooling system:fan
Manufactured:
03/16/2003 - 03/14/2007
Affected:
1,212
Defect:
Spartan motors usa (spartan) is recalling certain model year 2004-2008 k2, k3 and mm motorhomes manufactured march 17, 2003, to march 15, 2007. in the affected vehicles, the engine cooling fan may separate from the fan drive while the fan is spinning.
Consequence:
If the engine area is open and the cooling fan is operating and detaches, someone nearby may be injured.
Correction:
Spartan will notify owners, and dealers will replace the fan and fan drive system, free of charge. interim notices were mailed to owners on october 29, 2015. the recall began on october 29, 2015. owners may contact spartan customer service at 1-800-582-3454. spartan's number for this recall is 15014.
Notes:
Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.

2006 SPARTAN MM TSBs (3)

Bulletin:
TSB-08-350-001
Component:
022000 suspension:rear
Summary:
Spartan chassis: rear suspension, tag axle pivot boltis prone to failure in certain mountain master and k2 motorhome chassis equipped with a hendrickson tag axle and manufacture date 8/15/06-5/17/07. *pe
Bulletin:
TSB-15-310-002
Component:
091100 fuel system, other:storage:tank assembly
Summary:
Spartan motors: some motor home chassis are experiencing a fuel tank deformity and fuel sender by showing less fuel on fuel gauge than in fuel tank and would need to have fuel sender float arm adjustment. model 2002-15 mm, k3, k2, nvs.
Bulletin:
4VZ-E9QSR-09
Component:
020000 suspension
Summary:
This service bulletin provides instructions on how to apply appropriate torque to rear suspension fasteners to resolve popping noises.

Home | Privacy