2006 NISSAN FRONTIER Recalls (7)

Campaign:
06V092000 on 03/29/2006
Component:
Fuel system, gasoline:storage:tank assembly:filler pipe and cap
Manufactured:
07/27/2004 - 02/22/2006
Affected:
42,000
Defect:
On certain king cab trucks, in a severe side impact crash, there is a possibility that deformation of the vehicle's body could cause the fuel filler cap tether to be stretched to the point of unscrewing the fuel filler cap.
Consequence:
This may result in a fuel spill which in the presence of an ignition source could result in a fire.
Correction:
Dealers will replace the fuel cap tether pin assembly with a modified one free of charge. the recall began on april 24, 2006. owners may contact nissan at 1-800-647-7261.
Notes:
Nissan recall no. r0603.customers may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov.
Campaign:
06E064000 on 07/16/2006
Component:
Exterior lighting
Affected:
4,029
Defect:
Certain tradesonic combination lamps sold as replacement lamps for use on the above listed passenger vehicles. combination lamps not equipped with amber side reflectors fail to conform with the requirements of federal motor vehicle safety standard no. 108, lamps, reflective devices, and associated equipment.
Consequence:
Lack of amber side reflectors in the lamps will decrease lighting visibility to other drivers and may possibly result in a vehicle crash.
Correction:
Tradesonic will notify owners and replace the lamps free of charge. the recall is expected to begin during july 2006. owners may contact tradesonic at 626-934-8884.
Notes:
This recall only pertains to tradesonic aftermarket lamps and has no relation to any original equipment installed on the listed passenger vehicles.for more information on the lamp model numbers, click on document search and view document titled "lamp model numbers."customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.
Campaign:
07E046000 on 07/05/2007
Component:
Equipment
Affected:
3,500
Defect:
Certain hopkins aftermarket trailer brake control connection harnesses sold for use on certain models of nissan vehicles which are listed above. the internal part numbers within hopkins are: 1010476025, 1040376025, 1110476025, 1170376025, 1290376025, 1010476035, 1040376035, 1110476035, 1170376035, and 1290376035. a wire may have been placed in an incorrect position in the electrical connector housing. this results in an incorrect routing of wires between the trailer brake controller and the towing vehicle wiring system.
Consequence:
This harness would result in power from the trailer brake controller going to the towing vehicle dash light circuit rather than the trailer brakes. this result would be the lack of trailer braking when the towing vehicle brakes were applied. it would also result in the towing vehicles dash lights being activated when the vehicle brakes were applied. the failure of the application of the trailer brake could result in reduced ability to stop and contribute to a possible crash.
Correction:
Hopkins will notify owners and replace the original harness with a revised harness free of charge. the recall began august 17, 2007. owners can contact hopkins at 800-835-0129.
Notes:
This recall only pertains to aftermarket harnesses and has no relation to any original equipment installed on vehicles manufactured by nissan.customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.
Campaign:
08V690000 on 12/28/2008
Component:
Air bags:frontal
Manufactured:
05/31/2004 - 11/18/2008
Affected:
242,720
Defect:
Nissan is recalling 242,720 my 2005-2009 pathfinder, frontier and xterra vehicles originally sold in or currently registered in the states of connecticut, delaware, illinois, indiana, iowa, maine, maryland, massachusetts, michigan, minnesota, missouri, new hampshire, new jersey, new york, ohio, pennsylvania, rhode island, vermont, west virginia, wisconsin, and the district of columbia. in those areas of the country which use heavy concentrations of road salt in the winter, a mixture of snow/water and salt can enter into the front crash zone sensor (czs) housing. if this occurs, the czs may internally rust resulting in a signal interruption. if this happens, the red air bag warning light will illuminate to alert the vehicle operator.
Consequence:
This issue could result in the non-deployment of the driver and passenger front air bags in a crash, increasing the risk of personal injury.
Correction:
Dealers will replace the front czs with a redesigned sensor. the recall began on january 26, 2009. owners in the other states will receive extended warranty coverage for the sensor to 10 years. these owners will be notified of the warranty extension by mail and will receive a sticker to place in their warranty booklet explaining the extended warranty coverage. owners may contact nissan at 1-800-647-7261.
Notes:
Customers may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to <a href=http://www.safercar.gov>http://www.safercar.gov</a> .
Campaign:
10V075000 on 03/02/2010
Component:
Fuel system, gasoline:storage:auxillary tank
Manufactured:
01/22/2006 - 03/15/2006
Affected:
80,689
Defect:
Nissan is recalling certain model year 2006 and model year 2008 frontier, xterra and pathfinder vehicles. the molded fuel tank shells can deform, causing the fuel sender float arm to contact an embossment molded into the tank shell causing the instrument panel fuel gauge to show that the vehicle has approximately one quarter tank when the fuel tank is empty.
Consequence:
This could cause the vehicle to run out of gas and stall in traffic, increasing the risk of a crash.
Correction:
Dealers will replace the fuel level sending unit inside the fuel tank with a new one that has a modified float arm. this service will be performed free of charge. the safety recall is expected to begin on or before march 22, 2010. owners may contact nissan at 1-800-647-7261.
Notes:
Owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to <a href=http://www.safercar.gov>http://www.safercar.gov</a> .
Campaign:
10E019000 on 05/20/2010
Component:
Suspension:front:control arm:lower arm
Affected:
1,873
Defect:
Nissan is recalling certain front and rear lower links, p/nos. 54501zq00a, 54500zq00a, 551a1zq00a, 551a0zq00a , 54501ea00a, 54500ea00a, 551a1ea500, 551a0ea500, 54501zr00a, and 54500zr00a, sold between november 25, 2009 and may 14, 2010 as replacement parts for model year 2004 through 2010 titan, armada, and qx56, and model years 2005 through 2010 frontier, xterra, and pathfinder vehicles. the lower control link assembly has two cylindrical collars forming the inboard attachment points to the chassis. due to an improper welding process some collars may contain welds that do not meet strength specifications.
Consequence:
If the collar weld separates, the vehicle handling will deteriorate, possibly resulting in a vehicle crash.
Correction:
Nissan will notify owners and dealers will replace any affected lower link free of charge. the safety recall began on july 12, 2010. owners may contact nissan at 1-800-647-7261.
Notes:
Owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to <a href=http://www.safercar.gov>http://www.safercar.gov</a> .
Campaign:
10V517000 on 10/27/2010
Component:
Engine and engine cooling
Manufactured:
08/04/2004 - 06/14/2006
Affected:
747,480
Defect:
Nissan is recalling certain model year 2004-2006 armada, titan, infiniti qx56 and model year 2005-2006 frontier, pathfinder and xterra vehicles. the intelligent power distribution module (ipdm) assembly contains an engine control module (ecm) relay that has a diode for electrical current noise reduction. the ecm relay may allow silicon vapor to form and, over time, the silicon evaporates from the diode molding which causes silicon oxide to develop on the ecm relay contact due to arcing.
Consequence:
This could cause engine stalling increasing the risk of a crash.
Correction:
Dealers will replace the ecm relay inside the ipdm assembly. this service will be performed free of charge. the safety recall began on december 6, 2010. owners may contact nissan at 1-800-647-7261.
Notes:
Owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to <a href=http://www.safercar.gov>http://www.safercar.gov</a> .

2006 NISSAN FRONTIER TSBs (42)

Bulletin:
02120A
Component:
036000 service brakes, hydraulic:antilock
Summary:
Antilock braking system (abs) light on and / or diagnostic trouble code for abs wheel speed sensor. *tt
Bulletin:
05002
Component:
162000 structure:body
Summary:
Spray-in bedliner repair (level 1). *tt
Bulletin:
06009
Component:
061000 engine and engine cooling:engine
Summary:
Malfunction indicator lamp on with diagnostic trouble code u1000 or u1010 stored in engine control unit. *ak
Bulletin:
06009
Component:
061000 engine and engine cooling:engine
Summary:
Mil on with dtc u1000 or u1010 stored in engine control unit. *tt
Bulletin:
06027
Component:
105500 power train:driveline:differential unit
Summary:
Rear final drive breather. *tt
Bulletin:
06030
Component:
072100 fuel system, gasoline:delivery:fuel pump
Summary:
Squeak from fuel pump. *tt
Bulletin:
06063A
Component:
061000 engine and engine cooling:engine
Summary:
Ticking noise from the engine during acceleration. nissan. *kb
Bulletin:
03030
Component:
120000 exterior lighting
Summary:
Exterior lamp fogging. *kb
Bulletin:
07042
Component:
061000 engine and engine cooling:engine
Summary:
Buzzing/whining noise from timing chain area. *kb
Bulletin:
NTB08-023
Component:
061000 engine and engine cooling:engine
Summary:
Nissan service campaign: see document search button for owner letter. voluntary emissions recall campaign - 2003-2005 sentra / 2005-2006 frontier ecm reprogramming. csc was received. *nj updated 6/21/11. *pe
Bulletin:
NTB08-049
Component:
103000 power train:automatic transmission
Summary:
Nissan; special automatic transmission fluid requirement. 2004 to current nissan vehicles. *nj
Bulletin:
NTB08-062
Component:
220000 seats
Summary:
Seat back board removal/installation. *nj
Bulletin:
NTB-08-055-A
Component:
141100 air bags:frontal:sensor/control module
Summary:
Nissan: srs precautions during service;improper maintenance, including incorrect removal and installation of the srs, can lead to a serious injury or death caused by unintentional activation of the srs on all nissan models with the srs sys
Bulletin:
NTB-09-030
Component:
110000 electrical system
Summary:
Nissan: the 12 volt battery is an important part of the vehicle electrical system and is required to stay connected when the engine is running. to prevent damage to vehicle electronic components follow the instructions/cautions. no mod
Bulletin:
NTB-09-101
Component:
199000 tires:pressure monitoring and regulating systems
Summary:
Nissan: tire pressure monitoring system (tpms) warning light on/flashing. no models or model years listed. *pe updated on 08-11-2011. *kb
Bulletin:
NTB-03-074-C
Component:
120000 exterior lighting
Summary:
Nissan: exterior lamp fogging. occasionally water is noticed in the exterior lamps. this is generally not due to a defect. all current exterior lamp assemblies are vented to the atmosphere (not sealed). this is necessary to allow for e
Bulletin:
NTB-09-129
Component:
355200 equipment:other:owners/service/other manual
Summary:
Nissan: vent control valve replacement. when replacing the evap canister vent control valve for reason: use the one listed on page 2; for vent control valve replacement procedure, refer to the appropriate section of the electronic service
Bulletin:
NTB-07-069C
Component:
091200 fuel system, other:storage:fuel gauge system
Summary:
Nissan: fuel gauge issues and/or dtc p0461/2/3. the fuel gauge is erratic, inaccurate, or inoperative. the mil is on with dtc p0461, p0462, or p0463 stored in self diagnosis. replace the fuel level sending unit with the one from the par
Bulletin:
NTB-10-061
Component:
121000 exterior lighting:headlights
Summary:
Nissan: xenon head lamp service. a xenon headlamp is not functioning because of an issue inside the headlamp assembly (an internal issue). in most cases, replacement of a bulb or hid control unit will solve the incident. this includes a
Bulletin:
NTB-10-008
Component:
022520 suspension:rear:axle:non-powered axle assembly
Summary:
Nissan: rear axle seal leaks. the rear axle assembly is leaking gear oil from the right and/or left hand axle seal, and the vehicle is equipped with a m226 style axle and no noise or vibration is coming from the rear final drive gears and
Bulletin:
NTB-10-045
Component:
061000 engine and engine cooling:engine
Summary:
Nissan: dtc p0420 (tw catalyst sys-bi) stored in the ecm. confirm this bulletin applies-check the current ecm part number; compare your current ecm part number to chart a. replace the exhaust manifold catalyst; reprogram the ecm. *pe
Bulletin:
NTB-04-047
Component:
104000 power train:transfer case (4-wheel drive)
Summary:
Nissan: oil leaking from transfer case. oil is leaking from one or a combination of three bolts at the rear of the transfer case. if bolts are not missing, do not replace transfer case, transfer control device; or transfer control unit f
Bulletin:
NTB-10-055
Component:
062200 engine and engine cooling:cooling system:fan
Summary:
Nissan: blower motor does not work. the blower motor for heater and air conditioner does not operate. there are signs of water intrusion in the blower motor. *pe
Bulletin:
NTB-10-115
Component:
015300 steering:hydraulic power assist:power steering fluid
Summary:
Nissan: power steering oil cooler service. if a power steering oil cooler needs to be replaced for any reason, please refer to the service procedure. *pe
Bulletin:
NTB-10-072A
Component:
021000 suspension:front
Summary:
Nissan: front suspension noise. a noise (clunking, squeaking, popping) can be heard when performing at least one of the following actions: turning the steering wheel left or right, driving over speed bumps, driving on rough roads, acceler
Bulletin:
NTB12-027
Component:
015200 steering:hydraulic power assist:hose, piping, and connections
Summary:
Nissan: pathfinder, xterra, and frontier; power steering hose service part change. *js
Bulletin:
NTB12-035
Component:
103100 power train:automatic transmission:control module (tcm, pcm)
Summary:
Nissan: ecm replacement procedures with consult iii plus. applies to all 2004 and later (does not apply to leaf/ev) vehicles. *js
Bulletin:
NTB-13-038
Component:
170000 latches/locks/linkages
Summary:
Nissan: lock/unlock request button on outside handle does not respond. *js
Bulletin:
NTB17-026
Component:
021000 suspension:front
Summary:
Ball joint axial end play procedure service information when working on the front suspension, use the updated service information in this bulletin along with the electronic service manual (esm). the updated information in this bulletin
Bulletin:
NTB17-030
Component:
070000 fuel system, gasoline
Summary:
Nissan; fuel tank is slow or difficult to fill if you confirm the fuel tank is slow or difficult to fill (filling nozzle shuts off before tank is full). important: make sure this incident has been duplicated at a gas station by dealer
Bulletin:
REV1_P7318
Component:
118000 electrical system: software
Summary:
Air bag control unit reprogram voluntary service campaign temporary suspension of this campaign on all affected 2004-2006 model year vehicles. nissan is aware of reprogramming concerns on 2004-2006 models subject to p7318 air bag contro
Bulletin:
NTB17-070
Component:
140000 air bags
Summary:
Voluntary service campaign 2004-2011 titan, and 2005-2011 frontier and xterra; air bag diagnosis sensor unit introduction nissan is conducting a voluntary service campaign on certain specific model year 2004- 2011 titan, and 2005-2011 f
Bulletin:
P7318a
Component:
118000 electrical system: software
Summary:
Air bag control unit reprogram software update notice ***** campaign update***** updated software has been released to asist at 3:00 pm central time to address concerns with some vehicles not being able to complete the reprogramming. th
Bulletin:
P7318b
Component:
140000 air bags
Summary:
Air bag control unit reprogram voluntary service campaign ***** campaign summary***** nissan is committed to customer satisfaction. nissan is conducting a voluntary service campaign to reprogram the air bag control unit (acu) in 2004-20
Bulletin:
NTB17-082a
Component:
042300 service brakes, air:supply:check valve
Summary:
Nissan; dtc p0456 caused by evap leak at vent control valve o-ring this bulletin has been amended. the applied vehicles and claims information sections have been revised. no other changes have been made. please discard previous versions
Bulletin:
NTB15-079c
Component:
356000 equipment adaptive
Summary:
2005-2015 frontier; mil on with dtc p0448 this bulletin has been amended to add steps to apply ept foam to seal the fuel filler pipe and other minor changes made throughout. please discard previous versions of this bulletin.
Bulletin:
NTB14-068b
Component:
134000 visibility:sun roof assembly
Summary:
Power moonroof initialization service information this bulletin has been amended. the appplied vehices section and step 3 on page 3 have been revised. no other changes have been made. please discard all previous versions.
Bulletin:
P7318
Component:
020000 suspension
Summary:
Air bag control unit reprogram voluntary service campaign update october 6, 2017 the announcement from august 15, 2017 has been revised to include: - claims information for unintended airbag deployment (related to campaign) temporary
Bulletin:
REVISION 3_P7318
Component:
140000 air bags
Summary:
Air bag control unit reprogram voluntary service campaign update january 5, 2018 the announcement from october 6, 2017 has been revised: - dealers may now use revised tsb ntb17-070 to resume repair of 2004-2006 model year vehicles. pl
Bulletin:
NTB17-070a
Component:
118000 electrical system: software
Summary:
Voluntary service campaign 2004-2011 titan, and 2005-2011 frontier and xterra; air bag diagnosis sensor unit this bulletin has been amended. the reprogramming procedure has been revised. no other changes have been made. discard all previ
Bulletin:
NTB17-030a
Component:
070000 fuel system, gasoline
Summary:
Nissan; fuel tank is extremely difficult to fill this bulletin applies to titan xd vehicles with a gas engine. this bulletin has been amended. changes have been made throughout. it is necessary for you to read this revised procedure t
Bulletin:
NTB17-030a
Component:
070000 fuel system, gasoline
Summary:
Nissan; fuel tank is extremely difficult to fill this bulletin applies to titan xd vehicles with a gas engine. this bulletin has been amended. changes have been made throughout. it is necessary for you to read this revised procedure t

Home | Privacy