2006 MAZDA TRIBUTE Recalls (4)

Campaign:
05V525000 on 11/16/2005
Component:
Visibility:windshield wiper/washer:motor
Manufactured:
08/28/2005 - 10/16/2005
Affected:
3,982
Defect:
On certain trucks and sport utility vehicles, the windshield wiper motor may have been produced without grease applied to the output shaft gear.
Consequence:
After a period of continuous use on the high speed setting, lack of grease on the output shaft gear may cause the gear teeth to distort or fracture during operation resulting in the loss of wiper function. inoperative wipers under inclement weather conditions could cause a crash due to impaired visibility.
Correction:
Dealers will inspect the wiper motor for the presence of grease and grease the wiper motor gears if necessary. the recall began on november 28, 2005. owners may contact mazda at 1-800-222-5500.
Notes:
Mazda recall no. 3705k.customers may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov.
Campaign:
12V357000 on 07/26/2012
Component:
Engine and engine cooling
Affected:
217,500
Defect:
Mazda is recalling certain model year 2001 through 2006, and 2008, tribute vehicles equipped with 3.0l v6 engines and speed control. inadequate clearance between the engine cover and the speed control cable connector could result in a stuck throttle when the accelerator pedal is fully or almost-fully depressed. this risk exists regardless of whether or not speed control (cruise control) is used.
Consequence:
A stuck throttle may result in very high vehicle speeds and make it difficult to stop or slow the vehicle, which could cause a crash, serious injury or death.
Correction:
Mazda will notify owners, and dealers will repair the vehicles by increasing the engine cover clearance, free of charge. remedy parts are now available. the safety recall began on september 13, 2012. owners may contact mazda customer assistance center at 1-800-222-5500, option #6.
Notes:
Mazda's recall campaign number is 6812g.owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.
Campaign:
12V357000 on 07/26/2012
Component:
Vehicle speed control:cables
Affected:
217,500
Defect:
Mazda is recalling certain model year 2001 through 2006, and 2008, tribute vehicles equipped with 3.0l v6 engines and speed control. inadequate clearance between the engine cover and the speed control cable connector could result in a stuck throttle when the accelerator pedal is fully or almost-fully depressed. this risk exists regardless of whether or not speed control (cruise control) is used.
Consequence:
A stuck throttle may result in very high vehicle speeds and make it difficult to stop or slow the vehicle, which could cause a crash, serious injury or death.
Correction:
Mazda will notify owners, and dealers will repair the vehicles by increasing the engine cover clearance, free of charge. remedy parts are now available. the safety recall began on september 13, 2012. owners may contact mazda customer assistance center at 1-800-222-5500, option #6.
Notes:
Mazda's recall campaign number is 6812g.owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.
Campaign:
15E045000 on 06/02/2015
Component:
Suspension:front:wheel bearing
Affected:
576
Defect:
The timken company (timken) is recalling certain aftermarket front wheel bearings, part number 510072, sold from january 22, 2015, to may 21, 2015, to be used as service parts on 2001-2012 ford escape, 2001-2011 mazda tribute, and 2005-2011 mercury mariner vehicles. the affected wheel bearings have incorrect dimensions of a 42mm bore, 76mm outer dimension, and 39mm width, instead of a 42mm bore, 78mm outer dimension and a 45mm width.
Consequence:
Use of an incorrectly sized wheel bearing can adversely affect the braking and steering of the vehicle, increasing the risk of a crash.
Correction:
Timken has begun notifying distributors who will offer purchasers replacement wheel bearings, free of charge. the recall began on may 21, 2015. owners may contact timken customer service at 1-866-984-6536.
Notes:
Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.

2006 MAZDA TRIBUTE TSBs (51)

Bulletin:
0101604
Component:
061000 engine and engine cooling:engine
Summary:
Diagnostic tips for troubleshooting coil-on-plug misfire concerns. *tt this bulletin supersedes last issued 5/3/04. *tt
Bulletin:
0102605
Component:
071110 fuel system, gasoline:storage:tank assembly:filler pipe and cap
Summary:
Slow fuel fill or frequent filling station pump shut-off. *tt
Bulletin:
0901703
Component:
114000 electrical system:wiring
Summary:
Electrical - wiring - soldering and crimping repairs - service tip. *tt
Bulletin:
0004872
Component:
110000 electrical system
Summary:
Hesitation/stumble. *tt
Bulletin:
07
Component:
110000 electrical system
Summary:
Combination meter self diagnosis. *tt
Bulletin:
0200306
Component:
199000 tires:pressure monitoring and regulating systems
Summary:
Tire pressure monitoring system (tpms) indicator light on - tire pressure sensor training procedure. *tt
Bulletin:
0500706
Component:
103000 power train:automatic transmission
Summary:
Mercon atf is being replaced by mercon v as a service fluid. *kb
Bulletin:
0904006
Component:
110000 electrical system
Summary:
Smart junction box (sjb) replacement and clearing continuous dtcs from the sjb. *kb
Bulletin:
0800306
Component:
140000 air bags
Summary:
Non genuine accessories affect air bag operation. *kb
Bulletin:
0101307
Component:
061000 engine and engine cooling:engine
Summary:
No start/loss of engine timings/scraping noise at crankshaft pulley/possible engine damage. *kb
Bulletin:
0500407
Component:
061000 engine and engine cooling:engine
Summary:
Engine stalls on engagement/stopping. *kb
Bulletin:
00307
Component:
980000 unknown or other
Summary:
Availability of non-required tools. *kb
Bulletin:
0103407
Component:
072200 fuel system, gasoline:delivery:hoses, lines/piping, and fittings
Summary:
Some vehicles may exhibit a slow fuel fill concern during winter/freezing conditions, or a malfunction indicator lamp (mil) on with diagnostic trouble code (dtc) p0451 present. may be caused by water/moisture entering the fuel filler vent
Bulletin:
0102206
Component:
021000 suspension:front
Summary:
Front crankshaft bolt service warning. *nj
Bulletin:
SB-05-003-11
Component:
061000 engine and engine cooling:engine
Summary:
Mazda: the engine is stalling when stopping or engaging into drive or reverse. it may be intermittent and usually occurs on long drives. it may be caused by internal wear of the torque converter. *rm
Bulletin:
SB-09-005-13
Component:
350000 equipment
Summary:
Mazda: on some vehicles, to avoid potential interference of foot placed on pedals, information is provided regarding proper use, and placement, of driver's floor mat. various models and model years. *pe
Bulletin:
02-004-14
Component:
011000 steering:wheel and handle bar
Summary:
Summary to be provided on a future date.
Bulletin:
00-004/12
Component:
060000 engine (pws)
Summary:
Summary to be provided on a future date.
Bulletin:
02-009-16-3155
Component:
010000 steering
Summary:
Some customers may complain that the steering wheel is off center more than 3° even when driving straight on a flat road.
Bulletin:
00-001-13-2748
Component:
355200 equipment:other:owners/service/other manual
Summary:
Mazda has developed factory recommended scheduled maintenance services that support all major vehicle systems. mazda recommends dealers follow the scheduled maintenance tables as cited in the vehicle-specific workshop manual or owner's manu
Bulletin:
02-001-13-2752
Component:
350000 equipment
Summary:
Some customers may complain of signs of oil on the struts or shock absorbers. in most cases the oil that is present is normal, and a result of the oil that remains on the shaft during the normal sweeping process of the shaft seal. follow th
Bulletin:
02-004-13-2770
Component:
010000 steering
Summary:
Some customers may complain that the steering wheel is off center more than 3° even when driving straight on a flat road.
Bulletin:
09-005-13-2781
Component:
350000 equipment
Summary:
This service bulletin provides information regarding the proper use of the driver's floor mat to avoid any poten-tial interference with the foot pedals. the following are possible causes of floor mat interference, which can be avoided with
Bulletin:
05-002-13-2777A
Component:
102400 power train:manual transmission:lubricant
Summary:
Always be sure to use the correct automatic transmission fluid when replacing atf. using the wrong atf may cause shift quality complaints or may even damage the transmission.note:'atf m-v (type m5) is not the same fluid as mercon®v or merco
Bulletin:
05-002-13-2777
Component:
102400 power train:manual transmission:lubricant
Summary:
Always be sure to use the correct automatic transmission fluid when replacing atf. using the wrong atf may cause shift quality complaints or may even damage the transmission.note:'atf m-v (type m5) is not the same fluid as mercon®v or merco
Bulletin:
00-001-13-2748A
Component:
355200 equipment:other:owners/service/other manual
Summary:
Mazda has developed factory recommended scheduled maintenance services that support all major vehicle systems. mazda recommends dealers follow the scheduled maintenance tables as cited in the vehicle-specific workshop manual or owner's manu
Bulletin:
02-004-13-2770A
Component:
011000 steering:wheel and handle bar
Summary:
Some customers may complain that the steering wheel is off center more than 3° even when driving straight on a flat road.
Bulletin:
02-004-13-2770B
Component:
011000 steering:wheel and handle bar
Summary:
Some customers may complain that the steering wheel is off center more than 3° even when driving straight on a flat road.
Bulletin:
00-004-12-2741
Component:
355200 equipment:other:owners/service/other manual
Summary:
Mazda has developed factory recommended scheduled maintenance services that support all major vehicle systems. mazda recommends dealers follow the scheduled maintenance tables as cited in the vehicle-specific workshop manual or owner's manu
Bulletin:
00-002-14-2936
Component:
350000 equipment
Summary:
Mazda north american operations received many requests from our dealers asking us to approve additional on-car brake lathes as an option for mnao authorized equipment. due to your feedback and after evaluating a few on-car brake lathes, we
Bulletin:
09-027-14-2935
Component:
356000 equipment adaptive
Summary:
This service bulletin provides information regarding the proper use of the driver's floor mat to avoid any potential interference with the foot pedals. the following are possible causes of floor mat interference, which can be avoided with p
Bulletin:
09-034-14-2956
Component:
356000 equipment adaptive
Summary:
In accordance with federal regulations, follow the procedure listed below when replacing a speedometer.note:'mazda vehicles are manufactured with tamper-proof speedometers.'when a speedometer is replaced, the new speedometer will read zero
Bulletin:
01-003-15-3014
Component:
350000 equipment
Summary:
Use the following repair procedure to minimize the need to replace the catalyst converter/exhaust pipe when removing oxygen sensors and/or air fuel ratio sensors.
Bulletin:
05-001-16-3128
Component:
355200 equipment:other:owners/service/other manual
Summary:
Always be sure to use the correct automatic transmission fluid when replacing atf. using the wrong atf may cause shift quality complaints or may even damage the transmission.note:' atf m-v (type m5) is not the same fluid as mercon®v or merc
Bulletin:
02-009-16-3155
Component:
011000 steering:wheel and handle bar
Summary:
Some customers may complain that the steering wheel is off center more than 3° even when driving straight on a flat road.
Bulletin:
09-030-15-3073
Component:
355200 equipment:other:owners/service/other manual
Summary:
Mazda infotainment systems require contacting the proper source for diagnostic support, parts authorization, and parts exchange. some components require prior authorization before ordering as exchange. refer to dag exchange central (mxconn
Bulletin:
SA-061-17
Component:
117000 digital instrument panel
Summary:
In an effort to achieve a higher level of customer experience and retain the value of mazda's vehicles, mnao warranty operations is© 2017 mazda north american operations, u.s.a. allowing all mazda dealers to utilize a third party, specmo en
Bulletin:
09-035-17-3080
Component:
117000 digital instrument panel
Summary:
In accordance with federal regulations, follow the procedure listed below when replacing a speedometer. note: tampering with a motor vehicle odometer is strictly prohibited by federal, and state laws. it is the dealer?s responsibility to co
Bulletin:
00-001-18-3446
Component:
350000 equipment
Summary:
Mazda has developed factory recommended scheduled maintenance services that support all major vehicle systems. mazda recommends dealers follow the scheduled maintenance tables as cited in the vehicle-specific workshop manual or owner's manu
Bulletin:
09-014-18-3443
Component:
160000 structure
Summary:
When encountering a vehicle with paint damage, refer to the "mazda pocket paint guide" to determine cause, prevention, remedy, and warranty coverage (if applicable).
Bulletin:
09-019-18-3450
Component:
356000 equipment adaptive
Summary:
This service bulletin provides information regarding the proper use of the driver's floor mat to avoid any potential interference with the foot pedals. the following are possible causes of floor mat interference, which can be avoided with p
Bulletin:
01-008-18-3451
Component:
111000 electrical system:battery
Summary:
This service bulletin provides testing and charging procedures in order to promote proper battery maintenance, to deliver new vehicles with fully charged batteries, and to reduce unnecessary battery replacement cost. for new vehicles in sto
Bulletin:
01-009-18-3452
Component:
111000 electrical system:battery
Summary:
The mazda gr8-1291 is required for all warranty battery testing. if the mazda gr8-1291 is not used, incorrect battery testing may result in unnecessary battery replacement. use the following test procedures in this service bulletin to test
Bulletin:
02-006-18-3449
Component:
021300 suspension:front:shock absorber
Summary:
Some customers may complain of signs of oil on the struts or shock absorbers. in most cases the oil that is present is normal, and a result of the oil that remains on the shaft during the normal sweeping process of the shaft seal. follow th
Bulletin:
05-001-18-3453
Component:
100000 power train
Summary:
Always be sure to use the correct automatic transmission fluid when replacing atf. using the wrong atf may cause shift quality complaints or may even damage the transmission. note: atf m-v (type m5) is not the same fluid as mercon®v or merc
Bulletin:
00-003-18-3480
Component:
030000 brakes (pws)
Summary:
Mazda north american operations has approved an additional on-car brake lathe as an option for mnaoauthorized equipment. the pro-cut on-car brake lathe has been added to the mnao authorizedequipment program.note: accu-turn is still an appro
Bulletin:
02-010-18-3477
Component:
011000 steering:wheel and handle bar
Summary:
Some customers may complain that the steering wheel is off center more than 3° even when driving straight on a flat road.
Bulletin:
09-025-18-3479
Component:
350000 equipment
Summary:
Mazda infotainment systems require contacting the proper source for diagnostic support, parts authorization, and parts exchange. some components require prior authorization before ordering as exchange. refer to dag exchange central (mxconne
Bulletin:
09-029-18-3497
Component:
350000 equipment
Summary:
In the event that all vehicle keys are lost and the vehicle key code is not available on the vehicle retail data inquiry system, replacement keys may only be acquired by obtaining the key code using the repair procedure below. mazda recomme
Bulletin:
09-034-18-3430
Component:
180000 vehicle speed control
Summary:
In accordance with federal regulations, follow the procedure listed below when replacing a speedometer. note: tampering with a motor vehicle odometer is strictly prohibited by federal, and state laws. it is the dealer's responsibility to co
Bulletin:
01-016-18-3522
Component:
063000 engine and engine cooling:exhaust system
Summary:
On some vehicles, a sulfur smell or 'rotten egg' odor may be noticed coming from the exhaust system. the odor is usually noticed after a cold start, fast idle, extended periods of idling and full throttle acceleration. sulfur smell is not a

Home | Privacy