2006 MAZDA MAZDA5 Recalls (3)
- Campaign:
- 05V412000 on 09/19/2005
- Component:
- Engine and engine cooling:exhaust system
- Manufactured:
- 04/11/2005 - 09/15/2005
- Affected:
- 7,000
- Defect:
- On certain sport utility vehicles, a heat buildup in the exhaust system can occur.
- Consequence:
- This condition could result in a fire.
- Correction:
- Mazda instructed owners (september 16, 2005) to bring in their vehicles and will be given a rental or loaner vehicle at no cost while mazda repairs these vehicles. the recall began on october 26, 2005. owners may contact mazda at 1-800-222-5500.
- Notes:
- Mazda recall no. 3605j.customers may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236; (tty: 1-800-424-9153); or go to http://www.safercar.gov.
- Campaign:
- 06V463000 on 12/03/2006
- Component:
- Latches/locks/linkages:doors:latch
- Manufactured:
- 04/11/2000 - 01/31/2006
- Affected:
- 9,800
- Defect:
- On certain passenger vehicles currently registered in the following states: alaska, colorado, connecticut, delaware, idaho, illinois, indiana, iowa, kansas, kentucky, maine, maryland, massachusetts, michigan, minnesota, missouri, montana, nebraska, new hampshire, new jersey, new york, north dakota, ohio, pennsylvania, rhode island, south dakota, utah, vermont, west virginia, wisconsin,and wyoming. the side door latch mechanisms may experience water intrusion allowing the latch mechanism to freeze in cold weather.
- Consequence:
- As a result, when the door is opened the door latch pawl may remain in the open position resulting in the door not being able to be closed and latched. if the vehicle is operated with an open door it may allow an unbelted occupant to be ejected from the vehicle which could result in injury or death.
- Correction:
- Dealers will replace the sliding door latches with modified latches. the recall began on december 18, 2006. owners may contact mazda at 1-800-222-5500.
- Notes:
- Mazda recall no. 4306k.customers may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov.
- Campaign:
- 09E011000 on 04/02/2009
- Component:
- Equipment
- Affected:
- 2,323
- Defect:
- Thule, inc. is recalling 2,323 owner-installed roof-mounted fit kits, models 3068 and 3069, manufactured between january 1, 2008 and february 28, 2009 that are used with thule podium foot packs, models 460 and 460r. these fit kits were sold as aftermarket equipment for use on the vehicles listed above. the bolt(s) used to secure the foot to the vehicle was manufactured to a hardness that may cause the bolt(s) to be brittle and potentially break under stress.
- Consequence:
- This may result in the bolt(s) snapping off during use or without a load. the unsecured rack and load can then come loose while driving creating a potential road hazard, possibly resulting in a vehicle crash.
- Correction:
- Thule will mail a retro fit kit along with repair instructions to owners free of charge. the safety recall is expected to begin on or before april 13, 2009. owners may contact thule toll-free at 1-800-238-2388.
- Notes:
- This recall only pertains to thule aftermarket roof mounted load carriers and has no relation to any original equipment installed on the listed passenger vehicles.owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to <a href=http://www.safercar.gov>http://www.safercar.gov</a> .
2006 MAZDA MAZDA5 TSBs (98)
- Bulletin:
- 0102105
- Component:
- 060000 engine and engine cooling
- Summary:
- Engine vibration/ knocking noise/ no. 3 engine mount rubber broken. *sc updated on 09/25/07. *nj
- Bulletin:
- 0902105
- Component:
- 123000 exterior lighting:tail lights
- Summary:
- Taillight lens water droplets/air bubbles concern. *ts
- Bulletin:
- 01012006
- Component:
- 353000 equipment:electrical
- Summary:
- Key reminder chimes continuously / keyless entry inoperative. *tt
- Bulletin:
- 0300106
- Component:
- 162000 structure:body
- Summary:
- Body vibration at cruise speed. *tt
- Bulletin:
- 0100206
- Component:
- 060000 engine and engine cooling
- Summary:
- Engine misfire diagnostic procedures - service tip. *tt
- Bulletin:
- 0900406
- Component:
- 162200 structure:body:bumpers
- Summary:
- Front bumper reinforcement rib - service tip. *tt
- Bulletin:
- 03012006
- Component:
- 015000 steering:hydraulic power assist system
- Summary:
- Intermittent hard to steer. *ak
- Bulletin:
- 0200406
- Component:
- 194000 tires:valve
- Summary:
- Tpms valve stem breaks when removing aftermarket valve stem caps - service tip. *tt
- Bulletin:
- 0104406
- Component:
- 117000 digital instrument panel
- Summary:
- Malfunction indicator light on with dtc p0106. *kb
- Bulletin:
- 0800306
- Component:
- 140000 air bags
- Summary:
- Non genuine accessories affect air bag operation. *kb
- Bulletin:
- 00307
- Component:
- 980000 unknown or other
- Summary:
- Availability of non-required tools. *kb
- Bulletin:
- 0102207
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Engine stalls when driving at low speeds. *kb
- Bulletin:
- 0902707
- Component:
- 171100 latches/locks/linkages:doors:latch
- Summary:
- Rear slide door latch screw is corroded. *kb
- Bulletin:
- 0102206
- Component:
- 021000 suspension:front
- Summary:
- Front crankshaft bolt service warning. *nj
- Bulletin:
- 0800108
- Component:
- 150000 seat belts
- Summary:
- Seat belt retainer breaks. *nj
- Bulletin:
- 01-008/08
- Component:
- 103100 power train:automatic transmission:control module (tcm, pcm)
- Summary:
- Engine stumble while driving with light acceleration at 1500-2500 rpm. *nj
- Bulletin:
- 06-003/08
- Component:
- 015300 steering:hydraulic power assist:power steering fluid
- Summary:
- Heavy steering effort/power steering fluid leakage. some mazda3 vehicles (except mazdaspeed3) with vin's lower than jm1bk**** **709745 (produced before feb. 1, 2007) & some mazda5 vehicles with vin's lower than jm1cr**** **150635 (produce
- Bulletin:
- 01-003/08
- Component:
- 103100 power train:automatic transmission:control module (tcm, pcm)
- Summary:
- Multi-model - engine stalls when driving at low speed. *nj
- Bulletin:
- 01-024/08
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Mil comes on with dtc p2006 / variable tumble shutter valve can not completely close. *nj
- Bulletin:
- 01-003-08
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Mazda: engine stalls when driving at low speed. *pe
- Bulletin:
- SB-01-007-09
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Mazda: vehicles may exhibit a concern of unstable idling or, in some rare cases, stalling, just after the vehicle stops with no dtcs detected. problem is due to the accumulation of carbon deposits inside the throttle body causing air flow
- Bulletin:
- SB-01-012-09
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Mazda: mil comes on with p2004/check valve stuck open. some vehicles may experience an mil that comes on with dtc p2004 (variable tumble shutter valve stuck open). the cause may be the check valve in the intake manifold vacuum chamber being
- Bulletin:
- SB-09-054-09
- Component:
- 162300 structure:body:door
- Summary:
- Mazda: on some vehicles, the sliding door lock may be hard to operate. this may be caused by two things. first, too much grease has been applied to the lock actuator (a) and second, the lock lever of the remote controller (b) gets caught
- Bulletin:
- SB-06-003-10
- Component:
- 012000 steering:column
- Summary:
- Mazda: steering column slightly moves in or out telescopically. some vehicles may exhibit a slight in or out movement of the steering wheel when it is pushed or pulled, even with the steering wheel release lever properly locked. *pe
- Bulletin:
- SB-01-028-10
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Mazda: variable valve timing (vvt) noise when starting engine. when engine is first started, some vehicles may exhibit a loud ticking noise from the variable valve timing (vvt) (a). this is caused by the lock pin of the variable valve tim
- Bulletin:
- SB-09-057-10
- Component:
- 120000 exterior lighting
- Summary:
- Mazda: there is condensation and fog in the front and rear combination lights. *rm
- Bulletin:
- 09-005-11
- Component:
- 121000 exterior lighting:headlights
- Summary:
- Mazda: there is possible excessive condensation or water inside the headlamp unit on many mazda models. *rm
- Bulletin:
- 01-006-11
- Component:
- 060000 engine and engine cooling
- Summary:
- Mazda: a malfunction light is on with a stored trouble code. *rm
- Bulletin:
- 08-002-11
- Component:
- 140000 air bags
- Summary:
- Mazda: saltwater entering the crash sensor connector is causing the air bag warning light to come on. 2006-2010 mazda5. *rm
- Bulletin:
- SB-08-004-11
- Component:
- 141100 air bags:frontal:sensor/control module
- Summary:
- Mazda: 2006-2010 mazda 5. air bag warning light is on with a stored trouble code. *rm
- Bulletin:
- SB-09-005-13
- Component:
- 350000 equipment
- Summary:
- Mazda: on some vehicles, to avoid potential interference of foot placed on pedals, information is provided regarding proper use, and placement, of driver's floor mat. various models and model years. *pe
- Bulletin:
- SB-09-003-13
- Component:
- 121000 exterior lighting:headlights
- Summary:
- Mazda: on various model years and model vehicles, the headlamp assembly would have excessive condensation or water within and should be checked and replaced, if necessary for correct installation. *pe
- Bulletin:
- SB-08-001-13
- Component:
- 141000 air bags:frontal
- Summary:
- Mazda: information provided regarding the indicator light illumination of the passenger airbag deactivation (pad). *pe
- Bulletin:
- 02-004-14
- Component:
- 011000 steering:wheel and handle bar
- Summary:
- Summary to be provided on a future date.
- Bulletin:
- 00-004/12
- Component:
- 060000 engine (pws)
- Summary:
- Summary to be provided on a future date.
- Bulletin:
- SA234
- Component:
- 118000 electrical system: software
- Summary:
- Ids update 101.00 and 101.02 is now available on ms3 under the "ids/infotainment" tab.
- Bulletin:
- 02-009-16-3155
- Component:
- 010000 steering
- Summary:
- Some customers may complain that the steering wheel is off center more than 3° even when driving straight on a flat road.
- Bulletin:
- 00-004-16-3237
- Component:
- 350000 equipment
- Summary:
- Raising a vehicle with a jack can be dangerous if not done properly. the vehicle can slip off the jack and seri-ously injure someone. in this service information, some important warnings and cautions have been taken from the owner's manual.
- Bulletin:
- 01-016-16-3220
- Component:
- 060000 engine (pws)
- Summary:
- There is a concern that some water pumps are being replaced that are not faulty, due to signs of a very small coolant leak from the bleed hole. this service bulletin is to inform you about the water pump sealing mecha-nism and the criteria
- Bulletin:
- 00-001-13-2748
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- Mazda has developed factory recommended scheduled maintenance services that support all major vehicle systems. mazda recommends dealers follow the scheduled maintenance tables as cited in the vehicle-specific workshop manual or owner's manu
- Bulletin:
- 02-001-13-2752
- Component:
- 350000 equipment
- Summary:
- Some customers may complain of signs of oil on the struts or shock absorbers. in most cases the oil that is present is normal, and a result of the oil that remains on the shaft during the normal sweeping process of the shaft seal. follow th
- Bulletin:
- 02-004-13-2770
- Component:
- 010000 steering
- Summary:
- Some customers may complain that the steering wheel is off center more than 3° even when driving straight on a flat road.
- Bulletin:
- 09-005-13-2781
- Component:
- 350000 equipment
- Summary:
- This service bulletin provides information regarding the proper use of the driver's floor mat to avoid any poten-tial interference with the foot pedals. the following are possible causes of floor mat interference, which can be avoided with
- Bulletin:
- 05-002-13-2777A
- Component:
- 102400 power train:manual transmission:lubricant
- Summary:
- Always be sure to use the correct automatic transmission fluid when replacing atf. using the wrong atf may cause shift quality complaints or may even damage the transmission.note:'atf m-v (type m5) is not the same fluid as mercon®v or merco
- Bulletin:
- 05-002-13-2777
- Component:
- 102400 power train:manual transmission:lubricant
- Summary:
- Always be sure to use the correct automatic transmission fluid when replacing atf. using the wrong atf may cause shift quality complaints or may even damage the transmission.note:'atf m-v (type m5) is not the same fluid as mercon®v or merco
- Bulletin:
- 09-003-13-2776
- Component:
- 354000 equipment:mechanical
- Summary:
- When dealing with customer complaints of excessive condensation and/or water within the headlamp unit, first determine if all the bulb sockets are present and correctly installed. in most cases you will find that the bulb seal no. 1 (a) or
- Bulletin:
- 00-001-13-2748A
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- Mazda has developed factory recommended scheduled maintenance services that support all major vehicle systems. mazda recommends dealers follow the scheduled maintenance tables as cited in the vehicle-specific workshop manual or owner's manu
- Bulletin:
- 02-004-13-2770A
- Component:
- 011000 steering:wheel and handle bar
- Summary:
- Some customers may complain that the steering wheel is off center more than 3° even when driving straight on a flat road.
- Bulletin:
- 02-004-13-2770B
- Component:
- 011000 steering:wheel and handle bar
- Summary:
- Some customers may complain that the steering wheel is off center more than 3° even when driving straight on a flat road.
- Bulletin:
- 09-028-12-2701B
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- The multi information display (mid) and navigation system support for diagnostics, parts authorization, and parts exchange require contacting the proper source. please contact the appropriate source by referring to the following tables.
- Bulletin:
- 07-002-13-2842
- Component:
- 353600 equipment:air conditioner
- Summary:
- A musty/mildew type odor may come from the vents when the air conditioning (a/c) system is operating. it is most noticeable when the a/c is first turned on. this odor is the result of mold growth in the a/c evaporator/cooling unit which is
- Bulletin:
- 09-046-12-2744
- Component:
- 120000 lighting (pws)
- Summary:
- Some customers may complain of condensation/fog inside the front or rear combination lights. the recent new models have been fitted with a clear lens which can cause the symptom to be more noticeable, however, it does not affect the perform
- Bulletin:
- 00-004-12-2741
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- Mazda has developed factory recommended scheduled maintenance services that support all major vehicle systems. mazda recommends dealers follow the scheduled maintenance tables as cited in the vehicle-specific workshop manual or owner's manu
- Bulletin:
- 09-039-13-2852
- Component:
- 220000 seats
- Summary:
- Some vehicles may exhibit a chattering noise and the driver-side seat lift cannot be adjusted because the lock plate guide comes off the guide cam when operating the lift. if the lift lever is then operated with the lock plate guide off, th
- Bulletin:
- 09-007-14-2878
- Component:
- 122000 exterior lighting:fog lights
- Summary:
- Some customers may complain of condensation/fog inside the front or rear combination lights. the recent new models have been fitted with a clear lens which can cause the symptom to be more noticeable, however, it does not affect the perform
- Bulletin:
- 04-002-14-2879
- Component:
- 046400 service brakes, air:antilock:abs warning light
- Summary:
- Some customers may report a slight clunk/bang/buzz noise or jolt from the front of the vehicle. this concern will most likely occur during the vehicles first forward movement after starting the engine. this is a normal operating noise of th
- Bulletin:
- 09-012-14-2891
- Component:
- 353400 equipment:electrical:radio/tape deck/cd etc.
- Summary:
- When replacing the siriusxm satellite radio unit (or a mazda connect tuner and amp unit (tau)) with replacement tuner for any reason, a call must be made to inform siriusxm of the existing radio id and the new/ replacement sat radio id as s
- Bulletin:
- 04-004-14-2926
- Component:
- 030000 brakes (pws)
- Summary:
- Some vehicles exhibit brake related concerns such as brake noise, brake judder or brake dragging. if you encounter a customer complaint for any one of these symptoms, refer to the following information to understand why symptoms may occur,
- Bulletin:
- 00-002-14-2936
- Component:
- 350000 equipment
- Summary:
- Mazda north american operations received many requests from our dealers asking us to approve additional on-car brake lathes as an option for mnao authorized equipment. due to your feedback and after evaluating a few on-car brake lathes, we
- Bulletin:
- 09-027-14-2935
- Component:
- 356000 equipment adaptive
- Summary:
- This service bulletin provides information regarding the proper use of the driver's floor mat to avoid any potential interference with the foot pedals. the following are possible causes of floor mat interference, which can be avoided with p
- Bulletin:
- 09-034-14-2956
- Component:
- 356000 equipment adaptive
- Summary:
- In accordance with federal regulations, follow the procedure listed below when replacing a speedometer.note:'mazda vehicles are manufactured with tamper-proof speedometers.'when a speedometer is replaced, the new speedometer will read zero
- Bulletin:
- 09-049-14-2980
- Component:
- 121000 exterior lighting:headlights
- Summary:
- When dealing with customer complaints of excessive condensation and/or water within the headlamp unit, first determine if all the bulb sockets are present and correctly installed. in most cases you will find that the bulb seal no. 1 (a) or
- Bulletin:
- 01-003-15-3014
- Component:
- 350000 equipment
- Summary:
- Use the following repair procedure to minimize the need to replace the catalyst converter/exhaust pipe when removing oxygen sensors and/or air fuel ratio sensors.
- Bulletin:
- 09-003-16-3130
- Component:
- 121000 exterior lighting:headlights
- Summary:
- Some customers may complain of condensation/fog inside the front (headlamp/headlight) or rear (taillamp/tail-light) combination lights. the recent new models have been fitted with a clear lens which can cause the symp-tom to be more noticea
- Bulletin:
- 05-001-16-3128
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- Always be sure to use the correct automatic transmission fluid when replacing atf. using the wrong atf may cause shift quality complaints or may even damage the transmission.note:' atf m-v (type m5) is not the same fluid as mercon®v or merc
- Bulletin:
- 02-009-16-3155
- Component:
- 011000 steering:wheel and handle bar
- Summary:
- Some customers may complain that the steering wheel is off center more than 3° even when driving straight on a flat road.
- Bulletin:
- 09-030-15-3073
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- Mazda infotainment systems require contacting the proper source for diagnostic support, parts authorization, and parts exchange. some components require prior authorization before ordering as exchange. refer to dag exchange central (mxconn
- Bulletin:
- 02-002-16-3124
- Component:
- 200000 wheels
- Summary:
- Some automotive cleaning products contain strong acid or alkali. when these types of cleaners are used to clean the wheels on mazda vehicles, the chemicals contents penetrate the clear coating of the wheel surface and damage the paint under
- Bulletin:
- 09-013-16-3161
- Component:
- 350000 equipment
- Summary:
- When dealing with customer complaints of excessive condensation and/or water within the headlamp unit, first determine if all the bulb sockets are resent and correctly installed. in most cases you will find that the bulb seal no. 1 (a) or
- Bulletin:
- 04-004-16-3160
- Component:
- 030000 brakes (pws)
- Summary:
- Some vehicles exhibit brake related concerns such as brake noise, brake judder or brake dragging. if you encounter a customer complaint for any one of these symptoms, refer to the following information to understand why symptoms may occur,
- Bulletin:
- 08-001-13-2859
- Component:
- 110000 electrical system
- Summary:
- This information is provided to help address passenger airbag deactivation (pad) indicator illumination con-cerns during vehicle service.
- Bulletin:
- 02-009-13-2854
- Component:
- 200000 wheels
- Summary:
- Some automotive cleaning products contain strong acid or alkali. when these types of cleaners are used to clean the wheels on mazda vehicles, the chemicals contents penetrate the clear coating of the wheel surface and damage the paint under
- Bulletin:
- 04-004-13-2853
- Component:
- 030000 brakes (pws)
- Summary:
- Some vehicles exhibit brake related concerns such as brake noise, brake judder or brake dragging. if you encounter a customer complaint for any one of these symptoms, refer to the following information to understand why symptoms may occur,
- Bulletin:
- 09-008-17-3324
- Component:
- 121000 exterior lighting:headlights
- Summary:
- Take caution when cleaning plastic headlight lenses. damage can occur when using some cleaners that contain strong acid, alkaline cleanser or organic solvent. damage caused by using these cleaners is not covered by mazda's new vehicle limit
- Bulletin:
- SA-061-17
- Component:
- 117000 digital instrument panel
- Summary:
- In an effort to achieve a higher level of customer experience and retain the value of mazda's vehicles, mnao warranty operations is© 2017 mazda north american operations, u.s.a. allowing all mazda dealers to utilize a third party, specmo en
- Bulletin:
- 09-035-17-3080
- Component:
- 117000 digital instrument panel
- Summary:
- In accordance with federal regulations, follow the procedure listed below when replacing a speedometer. note: tampering with a motor vehicle odometer is strictly prohibited by federal, and state laws. it is the dealer?s responsibility to co
- Bulletin:
- 09-001-17-3296b
- Component:
- 110000 electrical system
- Summary:
- When dealing with customer complaints of excessive condensation and/or water within the headlamp unit, first determine if all the bulb sockets (including o-ring), seals and covers are present and correctly installed. in most cases you will
- Bulletin:
- 01-002-18-3417
- Component:
- 110000 electrical system
- Summary:
- Some vehicles may have a mil illumination with dtc's p0441, p0442, p0455, or p0456 stored in memory. to determine the location of the evaporative system leak, follow the repair procedure below. p0441 - evaporative emission control system in
- Bulletin:
- 00-001-18-3446
- Component:
- 350000 equipment
- Summary:
- Mazda has developed factory recommended scheduled maintenance services that support all major vehicle systems. mazda recommends dealers follow the scheduled maintenance tables as cited in the vehicle-specific workshop manual or owner's manu
- Bulletin:
- 09-011-18-3448
- Component:
- 121000 exterior lighting:headlights
- Summary:
- Some customers may complain of condensation/fog inside the front (headlamp/headlight) or rear (taillamp/taillight) combination lights. the recent new models have been fitted with a clear lens which can cause the symptom to be more noticeabl
- Bulletin:
- 09-014-18-3443
- Component:
- 160000 structure
- Summary:
- When encountering a vehicle with paint damage, refer to the "mazda pocket paint guide" to determine cause, prevention, remedy, and warranty coverage (if applicable).
- Bulletin:
- 09-019-18-3450
- Component:
- 356000 equipment adaptive
- Summary:
- This service bulletin provides information regarding the proper use of the driver's floor mat to avoid any potential interference with the foot pedals. the following are possible causes of floor mat interference, which can be avoided with p
- Bulletin:
- MT-003-18
- Component:
- 140000 air bags
- Summary:
- The workshop manual has two-different airbag procedures, one for standard deployment and one for two-step deployment. standard deployment is for mexico spec vehicles and two-step deployment is for us and canadian spec vehicles.
- Bulletin:
- 01-008-18-3451
- Component:
- 111000 electrical system:battery
- Summary:
- This service bulletin provides testing and charging procedures in order to promote proper battery maintenance, to deliver new vehicles with fully charged batteries, and to reduce unnecessary battery replacement cost. for new vehicles in sto
- Bulletin:
- 01-009-18-3452
- Component:
- 111000 electrical system:battery
- Summary:
- The mazda gr8-1291 is required for all warranty battery testing. if the mazda gr8-1291 is not used, incorrect battery testing may result in unnecessary battery replacement. use the following test procedures in this service bulletin to test
- Bulletin:
- 02-006-18-3449
- Component:
- 021300 suspension:front:shock absorber
- Summary:
- Some customers may complain of signs of oil on the struts or shock absorbers. in most cases the oil that is present is normal, and a result of the oil that remains on the shaft during the normal sweeping process of the shaft seal. follow th
- Bulletin:
- 02-008-18-3467
- Component:
- 200000 wheels
- Summary:
- Some automotive cleaning products contain strong acid or alkali. when these types of cleaners are used to clean the wheels on mazda vehicles, the chemicals contents penetrate the clear coating of the wheel surface and damage the paint under
- Bulletin:
- 04-003-18-3455
- Component:
- 060000 engine and engine cooling
- Summary:
- Some customers may report a slight clunk/bang/buzz noise or jolt from the front of the vehicle. this concern will most likely occur during the vehicles first forward movement after starting the engine. this is a normal operating noise of th
- Bulletin:
- 04-004-18-3468
- Component:
- 030000 brakes (pws)
- Summary:
- Some vehicles exhibit brake related concerns such as brake noise, brake judder or brake dragging. if you encounter a customer complaint for any one of these symptoms, refer to the following information to understand why symptoms may occur,
- Bulletin:
- 05-001-18-3453
- Component:
- 100000 power train
- Summary:
- Always be sure to use the correct automatic transmission fluid when replacing atf. using the wrong atf may cause shift quality complaints or may even damage the transmission. note: atf m-v (type m5) is not the same fluid as mercon®v or merc
- Bulletin:
- 07-002-18-3432
- Component:
- 353600 equipment:air conditioner
- Summary:
- A musty/mildew type odor may come from the vents when the air conditioning (a/c) system is operating. it is most noticeable when the a/c is first turned on. this odor is the result of mold growth in the a/cevaporator/cooling unit which is c
- Bulletin:
- 08-001-18-3457
- Component:
- 140000 air bags
- Summary:
- This information is provided to help address passenger airbag deactivation (pad) indicator illumination concerns during vehicle service.
- Bulletin:
- 00-003-18-3480
- Component:
- 030000 brakes (pws)
- Summary:
- Mazda north american operations has approved an additional on-car brake lathe as an option for mnaoauthorized equipment. the pro-cut on-car brake lathe has been added to the mnao authorizedequipment program.note: accu-turn is still an appro
- Bulletin:
- 02-010-18-3477
- Component:
- 011000 steering:wheel and handle bar
- Summary:
- Some customers may complain that the steering wheel is off center more than 3° even when driving straight on a flat road.
- Bulletin:
- 09-023-18-3475
- Component:
- 350000 equipment
- Summary:
- When replacing the siriusxm satellite radio unit (or a mazda connect tuner and amp unit (tau)) with replacement tuner for any reason, a call must be made to inform siriusxm of the existing radio id and the new/replacement sat radio id as so
- Bulletin:
- 09-025-18-3479
- Component:
- 350000 equipment
- Summary:
- Mazda infotainment systems require contacting the proper source for diagnostic support, parts authorization, and parts exchange. some components require prior authorization before ordering as exchange. refer to dag exchange central (mxconne
- Bulletin:
- 09-034-18-3430
- Component:
- 180000 vehicle speed control
- Summary:
- In accordance with federal regulations, follow the procedure listed below when replacing a speedometer. note: tampering with a motor vehicle odometer is strictly prohibited by federal, and state laws. it is the dealer's responsibility to co
- Bulletin:
- 01-016-18-3522
- Component:
- 063000 engine and engine cooling:exhaust system
- Summary:
- On some vehicles, a sulfur smell or 'rotten egg' odor may be noticed coming from the exhaust system. the odor is usually noticed after a cold start, fast idle, extended periods of idling and full throttle acceleration. sulfur smell is not a
Home | Privacy