2006 ISUZU HVR Recall
- Campaign:
- 06V311000 on 08/15/2006
- Component:
- Service brakes, air
- Manufactured:
- 06/30/2005 - 04/29/2006
- Affected:
- 1,369
- Defect:
- Certain trucks fail to comply with the requirements of federal motor vehicle safety standard no. 121, "air brake systems." an internal control and check valve within the air brake application valve assembly was configured improperly, preventing air from flowing through the brake system as designed. in the event of an emergency stop, the vehicle's stopping distance would be increased.
- Consequence:
- If stopping distance was limited, a vehicle crash could result.
- Correction:
- Dealers will replace the air brake application valve assembly on c-series or reroute the air brake lines on t-series free of charge. the recall began on september 20, 2006. owners may contact chevrolet at 1-800-630-2438, gmc at 1-866-996-9463 and isuzu at 1-800-255-6727.
- Notes:
- Gm recall no. 06077.customers may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov.
2006 ISUZU HVR TSBs (34)
- Bulletin:
- 06140
- Component:
- 136000 visibility:windshield wiper/washer
- Summary:
- Passenger side wiper pattern change. *kb
- Bulletin:
- 070522001
- Component:
- 040000 service brakes, air
- Summary:
- Brake light switch inoperative, brake warning buzzer sounding and brake warning light on, dtc's c0164, c0272 set. (remove and splice wire/remove chmsl fuse/replace stop lamp switch). *kb
- Bulletin:
- 070604021
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Lack of power, engine will not rev-up, idle vibration, engine starting concerns, dtc;s p1093, p0087, p1087, p0088 and/or p1088 set (diagnose and replace suction control valve (scv) (fuel pressure regulator (fpr)), if necessary) *nj
- Bulletin:
- SB-08-J-003
- Component:
- 061200 engine and engine cooling:engine:diesel
- Summary:
- Chevrolet, gmc and isuzu trucks: lack of power, engine will not rev up, idle vibration, engine starting concerns, dtcs p1093, p0087, p1087, p0088 and/or p1088 set (diagnose and replace suction control valve (scv) (fuel pressure regulator (f
- Bulletin:
- SB05-08-133-001B
- Component:
- 042100 service brakes, air:supply:compressor
- Summary:
- Isuzu/gmc/chevrolet: diagnostic information for inoperative air seats, air horn and/or exhaust brake and release of new auxiliary air compressor relay and pressure switch on rpo k16 vehicles. *pe
- Bulletin:
- SB-08-J-003-A
- Component:
- 061200 engine and engine cooling:engine:diesel
- Summary:
- Izuzu: this tsb is for vehicles equipped with 7800 izuzu diesel engines. there is a process for getting horsepower/torque upgrades. *rm updated 3/9/12. *pe updated 7/27/12. *pe
- Bulletin:
- 05-09-40-002E
- Component:
- 151200 seat belts:front:webbing
- Summary:
- Gm: service bulletin explaining when the safety belts are supposed to lock. *rm updated 12/6/11. *pe
- Bulletin:
- CB-10-X-001
- Component:
- 063100 engine and engine cooling:exhaust system:emission control
- Summary:
- Isuzu service campaign: see document search button for owner letter. the emissions label was installed incorrectly so it cannot be seen. 2005-2007 h series. *rm
- Bulletin:
- SB-12-J-005
- Component:
- 060000 engine (pws)
- Summary:
- Isuzu (chevrolet/gmc): trucks with diesel engine would have idle vibration, trouble starting, engine not revving up, and a lack of power due to possible operation condition of suction control valve (scv)/fuel rail pressure (frp) regulator
- Bulletin:
- SB-03-07-29-004K
- Component:
- 102000 power train:manual transmission
- Summary:
- This informational bulletin provide information on the operating characteristics of a manual transmission.
- Bulletin:
- PI-0754-B
- Component:
- 132000 visibility:glass, side/rear
- Summary:
- This informational bulletin provides information on a normal condition on tempered glass of spots showing on the rear and side windows when the vehicle is in the sunlight.
- Bulletin:
- PIC-5260-A
- Component:
- 110000 electrical system
- Summary:
- This preliminary information communication advises the technician the steps on diagnosing the concern. vehicle's sunroof operation intermittent, bind, noise, auto-reverse, and/or water leaks.
- Bulletin:
- PIC-5050-A
- Component:
- 110000 electrical system
- Summary:
- This preliminary information communication advises the technician the steps on repairing the concern. a customer may identify a concern of unable to reactivate a vehicle's onstar that has been previously disabled by onstar. dealer is to ca
- Bulletin:
- PIC-4935-E
- Component:
- 110000 electrical system
- Summary:
- This preliminary information communication provides information to help the dealership technicians perform a parasitic drain test for the onstar module. when performing battery parasitic drain test, there may be some confusion as to what th
- Bulletin:
- PIC-5374-D
- Component:
- 353500 equipment:electrical:navigational system(global positioning system)
- Summary:
- This preliminary information communication advises the technician on the steps to diagnose and repair the concern of receiving frequent "off route" messages while following turn by turn (tbt) route navigation. the technician is provided in
- Bulletin:
- PIP5094A
- Component:
- 110000 electrical system
- Summary:
- This preliminary information communication advises the technician that ,when testing any circuit for open or resistance, it is imperative that all related terminal pin fit and tension be checked when the test steps require disconnection of
- Bulletin:
- 16NA260
- Component:
- 353400 equipment:electrical:radio/tape deck/cd etc.
- Summary:
- This technical bulletin provides a procedure to reprogram the media disc player with the latest calibrations to correct a condition of the rear entertainment system not operating as intended in colder ambient temperature areas due to calibr
- Bulletin:
- 000601012F
- Component:
- 060000 engine (pws)
- Summary:
- This informational bulletin provides information to gm dealers on the correct cleaning methods when cleaning engine gasket sealing surfaces.
- Bulletin:
- 000601026I
- Component:
- 060000 engine (pws)
- Summary:
- This informational bulletins provides information on the intake manifold inspection/replacement after servere internal engine damage.
- Bulletin:
- 030603004R
- Component:
- 060000 engine (pws)
- Summary:
- This informational bulletin provides information on how to test a battery and what is needed to warranty a battery.
- Bulletin:
- 030604017I
- Component:
- 061200 engine and engine cooling:engine:diesel
- Summary:
- This informational bulletin explains the use of diesel fuel additives in an engine, are not required unless the customer desires additives to prevent fuel concerns depending on fuel or temperature related conditions.
- Bulletin:
- PI1394A
- Component:
- 060000 engine (pws)
- Summary:
- This informational bulletin provides additional information on how to install pistons and suggest what tools to use.
- Bulletin:
- PIP4786C
- Component:
- 060000 engine and engine cooling
- Summary:
- This preliminary information communication provides information to the technician about vehicles that may have low oil pressure message. technician may also find a diagnostic trouble code p0521 in the engine control module. technician shoul
- Bulletin:
- PIT5074J
- Component:
- 110000 electrical system
- Summary:
- This preliminary information communication provides information to the technician about the use of j-35616-64b terminal test probe, replacement terminals, and terminated leads. the j-35616-64b is the latest test probe released for checking
- Bulletin:
- PIC4707E
- Component:
- 353000 equipment:electrical
- Summary:
- This preliminary information communication advises the technician to diagnose the concern and the steps to repair the concern. the vehicle's xm travel link may be inopertive.
- Bulletin:
- PIC4935E
- Component:
- 110000 electrical system
- Summary:
- This preliminary information communication provides information to help the dealership technicians perform a parasitic drain test for the onstar module. when performing battery parasitic drain test, there may be some confusion as to what th
- Bulletin:
- PIC5050A
- Component:
- 353000 equipment:electrical
- Summary:
- This preliminary information communication advises the technician the steps on repairing the concern. a customer may identify a concern of unable to reactivate a vehicle's onstar that has been previously disabled by onstar. dealer is to ca
- Bulletin:
- PIC5088F
- Component:
- 353400 equipment:electrical:radio/tape deck/cd etc.
- Summary:
- This preliminary information communication advises the technician on the steps to diagnose and repair the concern. the vehicle's xm radio only has xm preveiw channels.
- Bulletin:
- PIC5260A
- Component:
- 130000 visibility
- Summary:
- This preliminary information communication advises the technician the steps on diagnosing the concern. vehicle's sunroof operation intermittent, bind, noise, auto-reverse, and/or water leaks.
- Bulletin:
- PIC5374D
- Component:
- 353500 equipment:electrical:navigational system(global positioning system)
- Summary:
- This preliminary information communication advises the technician on the steps to diagnose and repair the concern of receiving frequent "off route" messages while following turn by turn (tbt) route navigation. the technician is provided in
- Bulletin:
- PIT5389A
- Component:
- 353500 equipment:electrical:navigational system(global positioning system)
- Summary:
- This preliminary information communication advises the technician on the steps for diagnosing the concern. the vehicle may be unable to connect to onstar using the white, blue or red onstar buttons.
- Bulletin:
- PIT5485B
- Component:
- 110000 electrical system
- Summary:
- This preliminary information communication advises the technician if unable to place an onstar call in the ignition on mode after the onstar canada upgrade, to contact the gm technical assistance center onstar group for further assistance.
- Bulletin:
- PIT5485A
- Component:
- 110000 electrical system
- Summary:
- This preliminary information communication advises the technician, if unable to place an onstar call in the ignition on mode after the onstar canada upgrade to contact the gm technical assistance center onstar group for further assistance.
- Bulletin:
- PI0373A
- Component:
- 135000 visibility:rearview mirrors/devices
- Summary:
- This preliminary informational bulletin provides a procedure for relearning the power folding mirriors and road testin to verify they correct a condtion of the power folding mirriors glass shakes, flutters at normal driving conditions.
Home | Privacy