2005 TIFFIN ALLEGRO BUS Recalls (4)
- Campaign:
- 05V145000 on 04/12/2005
- Component:
- Equipment:recreational vehicle
- Manufactured:
- 04/26/2004 - 12/13/2004
- Affected:
- 867
- Defect:
- On certain recreational vehicles, the washer/dryer in the rear of the motor home can move.
- Consequence:
- A vehicle occupant could be injured if the washer/dryer moved.
- Correction:
- Tiffin has provided the owners with a repair kit and installation instructions. the recall began on january 7, 2005. owners may contact tiffin at 1-256-356-0205.
- Notes:
- Customers may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov.
- Campaign:
- 05V307000 on 07/04/2005
- Component:
- Electrical system
- Manufactured:
- 02/21/2005 - 04/11/2005
- Affected:
- 265
- Defect:
- On certain motor homes containing a 50 amp transfer switch built by intellitec, the material used for the wire lugs was changed from nickel plated to copper lugs. the copper lugs are softer than the nickel plated and do not retain the torque of the screw that clamps the wire connector.
- Consequence:
- When the torque is relaxed, the lugs can become loose resulting in excessive heat within the connected wire that could result in a fire.
- Correction:
- Dealers will replace the changeover box. the recall began on july 21, 2005. owners may contact tiffin at 1-256-356-8661.
- Notes:
- Customers may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov.
- Campaign:
- 08V027000 on 01/24/2008
- Component:
- Steering:gear box:shaft pitman
- Affected:
- 1,292
- Defect:
- Certain motor homes built on freightliner chassis and equipped with zf model 8018 steering gears may have been assembled with the incorrect recirculating ball spacer. this could potentially allow the recirculating balls to escape from the recirculating ball circuit resulting in a loss of steering.
- Consequence:
- The operator may notice higher required steering wheel inputs, or the need for more steering wheel adjustments while driving in a straight line in combination with metallic cracking noises prior to a loss of steering. loss of steering could result in a vehicle crash.
- Correction:
- Tiffin is working with freightliner to replace the steering gear free of charge (please see 07v343 and 07e049). owners may contact freightliner at 1-800-547-0712 or tiffin at 256-356-8661.
- Notes:
- Customers may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov.
- Campaign:
- 08V509000 on 10/02/2008
- Component:
- Equipment:recreational vehicle
- Affected:
- 3,507
- Defect:
- Tiffin is recalling 3,507 my 2004-2007 allegro, allegro bay and allero bus, my 2004-2005 phaeton and my 2005-2007 zephyr motor homes equipped with a two-door refrigerator manufactured by the dometic corporation. the refrigerator may have a defect in the boiler tube. pressurized coolant solution could be released into an area where an ignition source (gas flame) is present.
- Consequence:
- Release of coolant under certain conditions could ignite and result in a fire.
- Correction:
- Tiffin will be working with dometic in order to repair these refrigerators (please see 08e032). dometic will repair these refrigerators by installing a secondary burn housing, a thermal fuse, and a melt fuse free of charge. dometic has retained stericycle inc. to manage this campaign. stericycle will assist the owner in locating dealerships or service centers and will provide assistance with scheduling of appointments. owners may contact dometic/stericycle at 1-888-446-5157 or tiffin at 256-356-8661.
- Notes:
- Customers may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov.
2005 TIFFIN ALLEGRO BUS TSBs (8)
- Bulletin:
- SB-21
- Component:
- 350000 equipment
- Summary:
- Tiffin motorhomes service campaign: see document search button for owner letter. switch box grounding lug. the tap screw is not tight enough. this could cause problems at the load center causing a loss of ground. csc letter was receive
- Bulletin:
- SB-20
- Component:
- 351500 equipment:recreational vehicle:lpg water heater
- Summary:
- Tiffin motorhomes: there is a potential problem with the water heater by pass in your unit. there is a possibility it was incorrectly plumbed. csc letter was received. *pe
- Bulletin:
- C85-C86AC
- Component:
- 350000 equipment
- Summary:
- Tiffin motorhomes: tsb contains notification of owner letter. select document search button below. all tiffin motorhomes will be installing 2 back screws of the c85 and c86 a/c's to the roof of all tiffin motorhomes. *ta.
- Bulletin:
- SB-36
- Component:
- 353600 equipment:air conditioner
- Summary:
- Tiffin motorhomes: tsb contains notification of owner letter. select document search button below. two screws was not installed on the air condition units on the roof. *ta updated 11/24/15. *pe
- Bulletin:
- WI-196
- Component:
- 351000 equipment:recreational vehicle
- Summary:
- Tiffin motorhomes: tsb contains notification of owner letter. select document search button below. some tiffin motorhomes need driver/passenger seatbelts tightened on the mounting brackets located on the driver/passenger sidewall. *ta
- Bulletin:
- WI-268
- Component:
- 063200 engine and engine cooling:exhaust system:manifold/header/muffler/tail pipe
- Summary:
- Tiffin motorhomes: exhaust tip and pipes for muffler on bus models needs to be installed. *ta
- Bulletin:
- 16AWG
- Component:
- 113100 electrical system:starter assembly:solenoid
- Summary:
- Rv: instructions on how to install the charge solenoid wiring in a rv or vehicle. *ta
- Bulletin:
- Letter to dealer
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- This was a letter to our dealers we sent out when we first heard of the kidde fire extinguisher recall, even though it was still unofficial. we knew our coaches on the dealers' lots contained kidde and could not be sold unreplaced.
Home | Privacy