2005 PORSCHE CAYENNE Recalls (2)
- Campaign:
- 04V593000 on 12/19/2004
- Component:
- Seat belts
- Affected:
- 31,000
- Defect:
- Certain passenger cars fail to comply with the requirements of federal motor vehicle safety standard no. 208, "occupant crash protection." all three rear seat positions and the front passenger position are equipped with seat belt retractors that have a locking feature which converts the retractor from an emergency locking retractor (elr) mode to an automatic locking retractor (alr) mode for the purposes of child restraint installation. the belt may deactivate the alr mode with certain child restraints.
- Consequence:
- When involved in a crash, the child restraints may not be properly secured increasing the risk of injury or death to the seat occupant.
- Correction:
- Dealers will permanently install a clip in either of the affected rear outboard seat belts and provide an owner's manual insert. the clips will prevent unwarranted conversion from alr to elr mode with child seat installation. the recall began may 17, 2005. owners should contact porsche at 1-800-545-8039.
- Notes:
- Porsche recall no. a506.customers can also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
- Campaign:
- 17V576000 on 09/20/2017
- Component:
- Fuel system, gasoline:delivery:fuel pump
- Manufactured:
- 05/26/2004 - 06/07/2005
- Affected:
- 50,145
- Defect:
- Porsche cars north america, inc. (porsche) is recalling certain 2003-2006 cayenne s and cayenne turbo vehicles, 2004-2006 cayenne vehicles, and 2006 cayenne s "titanium" edition vehicles. these gasoline-powered vehicles have a fuel pump flange that may crack, allowing fuel to leak.
- Consequence:
- A fuel leak in the presence of an ignition source increases the risk of a fire.
- Correction:
- Porsche will notify owners, and dealers will replace the fuel filter flanges with new filter flanges that have a protective film, free of charge. the recall began july 6, 2018. owners may contact porsche customer service at 1-800-767-7243. porsche's number for this recall is ah10.
- Notes:
- Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.
2005 PORSCHE CAYENNE TSBs (31)
- Bulletin:
- 511
- Component:
- 171100 latches/locks/linkages:doors:latch
- Summary:
- Improper function of the inner door release. checking front and rear door locks. quality improvement workshop campaign. *tt
- Bulletin:
- 518
- Component:
- 137000 visibility:rear window wiper/washer
- Summary:
- Rear wiper arm cap no longer holds after single removal. replacing rear wiper arm cap. quality improvement workshop campaign. *tt
- Bulletin:
- 9110
- Component:
- 110000 electrical system
- Summary:
- Porsche communication management 2 - pcm2.1. *tt
- Bulletin:
- 6963
- Component:
- 140000 air bags
- Summary:
- Airbag warning light activated, fault code 1217 and/or 1218 in the fault memory of the airbag control module. *tt this bulletin replaces bulletin group 6 #1104 dated 9-3-04. *eh
- Bulletin:
- 0202
- Component:
- 350000 equipment
- Summary:
- Service equipment required for cayenne. equipment information. porsche. this bulletin supersedes bulletin of the same name dated 9-15-02. *tt
- Bulletin:
- 1104
- Component:
- 140000 air bags
- Summary:
- Airbag warning light activated. *eh
- Bulletin:
- 304
- Component:
- 103000 power train:automatic transmission
- Summary:
- Hard shifting in range first to second. *tt update. *tt
- Bulletin:
- 1324
- Component:
- 060000 engine and engine cooling
- Summary:
- Higher oil consumption due to faulty oil scraper rings. *eh
- Bulletin:
- 4412
- Component:
- 010000 steering
- Summary:
- Steering wheel vibration *eh
- Bulletin:
- 0501
- Component:
- 020000 suspension
- Summary:
- Steering wheel vibration. update. *tt
- Bulletin:
- 0512
- Component:
- 353500 equipment:electrical:navigational system(global positioning system)
- Summary:
- Overheating fault in power train control module (pcm) display when the incorrect navigation dvd is used. *tt
- Bulletin:
- 0515
- Component:
- 110000 electrical system
- Summary:
- Miscellaneous lamp warnings in the instrument cluster. *tt
- Bulletin:
- 1536
- Component:
- 060000 engine and engine cooling
- Summary:
- Occasional engine oil leak at the sealing face for the chain tensioner. *tt
- Bulletin:
- 8
- Component:
- 500000 child seat
- Summary:
- Current child seat overview. *tt
- Bulletin:
- 2820
- Component:
- 116200 electrical system:ignition:module
- Summary:
- Bar ignition modules (coils) with part no. 948.602.104.00 and 948.602.104.01. *kb updated 8/9/11. *pe
- Bulletin:
- 2207
- Component:
- 199000 tires:pressure monitoring and regulating systems
- Summary:
- Tire pressure monitoring system troubleshooting tips. *kb
- Bulletin:
- 0702
- Component:
- 353600 equipment:air conditioner
- Summary:
- Level adjustment fault code 1772 - pressure sensor signal line -- the diagnosis for level control fault 1772 does not indicate the level control compressor as possible fault cause. *nj
- Bulletin:
- D76
- Component:
- 072200 fuel system, gasoline:delivery:hoses, lines/piping, and fittings
- Summary:
- Parts withdrawn. porsche cars north americ requests return of the following unit to pcna, but only in cases where the defect is visible: part number 955 110 235 01, description fuel line. *pe
- Bulletin:
- D77
- Component:
- 136100 visibility:windshield wiper/washer:switch/wiring
- Summary:
- Parts withdraw; porsche cars north america requests return of the following units to pcna: part numbers 955 628 320 00 and 955 628 321 00; description tip switch. *pe
- Bulletin:
- 24-07
- Component:
- 142000 air bags:side/window
- Summary:
- Porsche: w725- replacing side airbag wire harness plug connection (workshop campaign). *pe
- Bulletin:
- S-24-08
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Porsche: rough running engine at idle speed. diagnostics on hot film mass air flow sensor (maf). maf sensors that are in perfect working order are being replaced unnecessarily in the dealer's organization. *pe
- Bulletin:
- ATI-0903
- Component:
- 031100 service brakes, electric
- Summary:
- Porsche: brake booster distance sensor. vehicle has the warning phc unavailable. the vehicle has fault code 1673 for the brake booster distance sensor. the sensors replaced have been found not to have an internal failure. disconnect th
- Bulletin:
- PI-D47-13
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- Porsche: requesting return of part/s to pcna for high pressure pump #9a1 110 315 06. *pe
- Bulletin:
- PK-D8-16
- Component:
- 980000 unknown or other
- Summary:
- Porsche: information on how to read the vin. *rm
- Bulletin:
- ATI-1102
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Porsche: check engine light comes on. *pe
- Bulletin:
- ATI-1302
- Component:
- 203000 wheels:lugs/nuts/bolts
- Summary:
- Porsche: information provided regarding proper usage of an approved wheel bolt for a vehicle application. models 2003-2010 cayenne. *pe
- Bulletin:
- ATI-13-04
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Porsche: information concerning coolant pipe inspection in order to identify a cast support on the aluminum pipes. models include all cayenne (9pa) model years 2003-2006. *js
- Bulletin:
- ATI-1403
- Component:
- 114000 electrical system:wiring
- Summary:
- Porsche: some vehicles are experiencing, in driver's footwell, a main wiring harness corrosion, which is causing a no start situation. model 2003-2010 cayenne (s, gts, turbo). *pe
- Bulletin:
- 122-A4N7P-09
- Component:
- 118500 electrical system: integrated trailer brake control
- Summary:
- Information: a cayenne with optional equipment no. 1d6 will come with a trailer hitch receiver and wiring up to the receiver hitch that includes a control unit to operate the trailer parking lights, turn signals and brake lights. the cayenn
- Bulletin:
- 122-D9G9Q-09
- Component:
- 070000 fuel system, gasoline
- Summary:
- Information: leaks have occurred at the filter flange of the fuel pump over the service life of vehicles manufactured during certain periods on some volkswagen group brands. similar components are installed in cayenne vehicles from model y
- Bulletin:
- 122-M8L6W-08
- Component:
- 070000 fuel system, gasoline
- Summary:
- Subject: filter flange of fuel pump information: fine hairline cracks can occur on the filter flange of the fuel pump on the affected vehicles. as a result, fuel can seep out causing a smell of fuel.
Home | Privacy