2005 NISSAN TITAN Recalls (6)

Campaign:
06V459000 on 11/29/2006
Component:
Electrical system
Manufactured:
07/22/2003 - 08/20/2006
Affected:
96,500
Defect:
On certain king cab trucks, the wires in the harness were routed through the rear doors and into the body. these wires may break due to over bending of the harness as the door is opened and closed. the harness contains wires for the driver seat belt pretensioner and for the front passenger seat belt which is part of the occupant classification system. wires for the rear audio speakers are also contained n the harness.
Consequence:
If the wires for the seat belts and speaker wires break and make contact, there is a possibility that the pretensioner may deploy. if this happens when the seat belt is retracted, it will not be possible to use the seat belt. if one of the wires on the right side harness for the seat belt tension sensor breaks, the passenger side front air bag will not deploy as designed in a frontal collision increasing the risk of a crash and personal injury.
Correction:
Dealers will replace the wire harness cover with a different type that prevents over bending of the harness and the harness will be rerouted free of charge. the recall began on february 19, 2007. owners may contact nissan at 1-800-647-7261.
Notes:
Customers may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov.
Campaign:
07E046000 on 07/05/2007
Component:
Equipment
Affected:
3,500
Defect:
Certain hopkins aftermarket trailer brake control connection harnesses sold for use on certain models of nissan vehicles which are listed above. the internal part numbers within hopkins are: 1010476025, 1040376025, 1110476025, 1170376025, 1290376025, 1010476035, 1040376035, 1110476035, 1170376035, and 1290376035. a wire may have been placed in an incorrect position in the electrical connector housing. this results in an incorrect routing of wires between the trailer brake controller and the towing vehicle wiring system.
Consequence:
This harness would result in power from the trailer brake controller going to the towing vehicle dash light circuit rather than the trailer brakes. this result would be the lack of trailer braking when the towing vehicle brakes were applied. it would also result in the towing vehicles dash lights being activated when the vehicle brakes were applied. the failure of the application of the trailer brake could result in reduced ability to stop and contribute to a possible crash.
Correction:
Hopkins will notify owners and replace the original harness with a revised harness free of charge. the recall began august 17, 2007. owners can contact hopkins at 800-835-0129.
Notes:
This recall only pertains to aftermarket harnesses and has no relation to any original equipment installed on vehicles manufactured by nissan.customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.
Campaign:
08V284000 on 06/26/2008
Component:
Equipment:air conditioner
Manufactured:
03/16/2005 - 08/20/2006
Affected:
180,664
Defect:
Nissan is recalling 180,664 my 2005-2006 titan, armada and infinity qx56 vehicles manufactured after march 17, 2005, that are equipped with a visteon air conditioning condenser fan motor. the fan motor may not be properly sealed allowing excessive water intrusion and inadequate drainage of moisture.
Consequence:
This could cause corrosion in the motor leading possibly to overheating and a fire.
Correction:
Dealers will install a 'thermal protector kit' and test the air conditioning condenser fan motor and replace it if necessary. the recall began on august 2, 2008. owners may contact nissan at 1-800-647-7261.
Notes:
Customers may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov.
Campaign:
10V074000 on 03/02/2010
Component:
Fuel system, other:storage:fuel gauge system
Affected:
340,000
Defect:
Nissan is recalling certain model year 2005-2009 titan, armada, and infiniti qx56 vehicles. the instrument panel fuel gauge may inaccurately display that the vehicle still has some fuel, typically about one quarter tank, when the fuel tank is empty.
Consequence:
This could cause the vehicle to run out of gas and stall on the highway, which could cause a crash.
Correction:
Dealers will replace the fuel sender unit inside the fuel tank with a new improved sender card. this service will be performed free of charge. the safety recall began on march 22, 2010. owners may contact nissan at 1-800-647-7261.
Notes:
Owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to <a href=http://www.safercar.gov>http://www.safercar.gov</a> .
Campaign:
10E019000 on 05/20/2010
Component:
Suspension:front:control arm:lower arm
Affected:
1,873
Defect:
Nissan is recalling certain front and rear lower links, p/nos. 54501zq00a, 54500zq00a, 551a1zq00a, 551a0zq00a , 54501ea00a, 54500ea00a, 551a1ea500, 551a0ea500, 54501zr00a, and 54500zr00a, sold between november 25, 2009 and may 14, 2010 as replacement parts for model year 2004 through 2010 titan, armada, and qx56, and model years 2005 through 2010 frontier, xterra, and pathfinder vehicles. the lower control link assembly has two cylindrical collars forming the inboard attachment points to the chassis. due to an improper welding process some collars may contain welds that do not meet strength specifications.
Consequence:
If the collar weld separates, the vehicle handling will deteriorate, possibly resulting in a vehicle crash.
Correction:
Nissan will notify owners and dealers will replace any affected lower link free of charge. the safety recall began on july 12, 2010. owners may contact nissan at 1-800-647-7261.
Notes:
Owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to <a href=http://www.safercar.gov>http://www.safercar.gov</a> .
Campaign:
10V517000 on 10/27/2010
Component:
Engine and engine cooling
Manufactured:
08/18/2003 - 05/14/2006
Affected:
747,480
Defect:
Nissan is recalling certain model year 2004-2006 armada, titan, infiniti qx56 and model year 2005-2006 frontier, pathfinder and xterra vehicles. the intelligent power distribution module (ipdm) assembly contains an engine control module (ecm) relay that has a diode for electrical current noise reduction. the ecm relay may allow silicon vapor to form and, over time, the silicon evaporates from the diode molding which causes silicon oxide to develop on the ecm relay contact due to arcing.
Consequence:
This could cause engine stalling increasing the risk of a crash.
Correction:
Dealers will replace the ecm relay inside the ipdm assembly. this service will be performed free of charge. the safety recall began on december 6, 2010. owners may contact nissan at 1-800-647-7261.
Notes:
Owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to <a href=http://www.safercar.gov>http://www.safercar.gov</a> .

2005 NISSAN TITAN TSBs (57)

Bulletin:
02120A
Component:
036000 service brakes, hydraulic:antilock
Summary:
Antilock braking system (abs) light on and / or diagnostic trouble code for abs wheel speed sensor. *tt
Bulletin:
04066B
Component:
030000 service brakes, hydraulic
Summary:
Brake judder from front brakes.*mr
Bulletin:
05022
Component:
103000 power train:automatic transmission
Summary:
Atf leaking from air cooler line. *eh update *sc
Bulletin:
04066C
Component:
030000 service brakes, hydraulic
Summary:
Brake judder. *sc
Bulletin:
04066D
Component:
030000 service brakes, hydraulic
Summary:
Brake judder. *sc
Bulletin:
04131A
Component:
061000 engine and engine cooling:engine
Summary:
Engine will not crank and/or start and/or transmission improper operation. *tt
Bulletin:
05077
Component:
221200 seats:front assembly:recliner
Summary:
Front passenger flod flat seat manual recliner inoperative. *tt
Bulletin:
05086
Component:
110000 electrical system
Summary:
Voluntary service campaign body control module sub-harness. enhanced electronic circuitry which may help furtherprotect a vehicle from damage or fire caused by a short circuit in the electrical system of a towed trailer. *tt
Bulletin:
05092
Component:
220000 seats
Summary:
Right front seat back assembly rattles and excessive side-to-side movement. *tt
Bulletin:
05097
Component:
020000 suspension
Summary:
Cam bolts for front wheel alignment. *tt updated 09-12-07. *kb
Bulletin:
05096
Component:
062200 engine and engine cooling:cooling system:fan
Summary:
Rattle from condenser fan mount. *tt
Bulletin:
05002
Component:
162000 structure:body
Summary:
Spray-in bedliner repair (level 1). *tt
Bulletin:
06007
Component:
091200 fuel system, other:storage:fuel gauge system
Summary:
Fuel gauge always reads full. *tt
Bulletin:
06008
Component:
022141 suspension:rear:springs:leaf spring assembly:leaf
Summary:
Rear leaf spring squeak. *tt
Bulletin:
06009
Component:
061000 engine and engine cooling:engine
Summary:
Malfunction indicator lamp on with diagnostic trouble code u1000 or u1010 stored in engine control unit. *ak
Bulletin:
06016
Component:
030000 service brakes, hydraulic
Summary:
Groan noise from front brakes. nissan. *tt
Bulletin:
06009
Component:
061000 engine and engine cooling:engine
Summary:
Mil on with dtc u1000 or u1010 stored in engine control unit. *tt
Bulletin:
06027
Component:
105500 power train:driveline:differential unit
Summary:
Rear final drive breather. *tt
Bulletin:
06040
Component:
036400 service brakes, hydraulic:antilock:abs warning light
Summary:
Abs and/or brake warning light on with dtc c1179. *tt
Bulletin:
03030
Component:
120000 exterior lighting
Summary:
Exterior lamp fogging. *kb
Bulletin:
07040
Component:
061000 engine and engine cooling:engine
Summary:
Low power with wide open throttle. *kb
Bulletin:
NTB08-039
Component:
221600 seats:front assembly:power adjust
Summary:
2004-2008 titan & armada; passenger seat switch serviceability. vehicles with bucket seats only. *nj
Bulletin:
NTB08-049
Component:
103000 power train:automatic transmission
Summary:
Nissan; special automatic transmission fluid requirement. 2004 to current nissan vehicles. *nj
Bulletin:
NTB08-062
Component:
220000 seats
Summary:
Seat back board removal/installation. *nj
Bulletin:
NTB-08-055-A
Component:
141100 air bags:frontal:sensor/control module
Summary:
Nissan: srs precautions during service;improper maintenance, including incorrect removal and installation of the srs, can lead to a serious injury or death caused by unintentional activation of the srs on all nissan models with the srs sys
Bulletin:
NTB-09-025
Component:
151400 seat belts:front:buckle assembly
Summary:
Nissan: the front seat belt buckle needs to be replaced for any reason. *pe
Bulletin:
NTB-09-030
Component:
110000 electrical system
Summary:
Nissan: the 12 volt battery is an important part of the vehicle electrical system and is required to stay connected when the engine is running. to prevent damage to vehicle electronic components follow the instructions/cautions. no mod
Bulletin:
NTB-09-101
Component:
199000 tires:pressure monitoring and regulating systems
Summary:
Nissan: tire pressure monitoring system (tpms) warning light on/flashing. no models or model years listed. *pe updated on 08-11-2011. *kb
Bulletin:
NTB-03-074-C
Component:
120000 exterior lighting
Summary:
Nissan: exterior lamp fogging. occasionally water is noticed in the exterior lamps. this is generally not due to a defect. all current exterior lamp assemblies are vented to the atmosphere (not sealed). this is necessary to allow for e
Bulletin:
NTB-09-129
Component:
355200 equipment:other:owners/service/other manual
Summary:
Nissan: vent control valve replacement. when replacing the evap canister vent control valve for reason: use the one listed on page 2; for vent control valve replacement procedure, refer to the appropriate section of the electronic service
Bulletin:
NTB-10-052
Component:
021600 suspension:front:wheel bearing
Summary:
Nissan: the propeller shaft u joint (journal/journal bearings) is the source of noise and/or vibration on an applied vehicle. diagnose by evaluating the u joint with the propeller shaft removed. replace the u joint (journal/journal beari
Bulletin:
NTB-08-091B
Component:
091200 fuel system, other:storage:fuel gauge system
Summary:
Nissan: fuel gauge does not read full, is slow to respond, or is inaccurate. *pe
Bulletin:
NTB-10-061
Component:
121000 exterior lighting:headlights
Summary:
Nissan: xenon head lamp service. a xenon headlamp is not functioning because of an issue inside the headlamp assembly (an internal issue). in most cases, replacement of a bulb or hid control unit will solve the incident. this includes a
Bulletin:
NTB-07-054B
Component:
011000 steering:wheel and handle bar
Summary:
Nissan: vibration at low speed. a vibration is felt in the steering wheel (other than shimmy) and/or floor and/or seats when driving at a speed between approximately 25mph and approximately 40mph only. *pe
Bulletin:
NTB-04-047
Component:
104000 power train:transfer case (4-wheel drive)
Summary:
Nissan: oil leaking from transfer case. oil is leaking from one or a combination of three bolts at the rear of the transfer case. if bolts are not missing, do not replace transfer case, transfer control device; or transfer control unit f
Bulletin:
NTB-10-072A
Component:
021000 suspension:front
Summary:
Nissan: front suspension noise. a noise (clunking, squeaking, popping) can be heard when performing at least one of the following actions: turning the steering wheel left or right, driving over speed bumps, driving on rough roads, acceler
Bulletin:
NTB-11-005
Component:
353500 equipment:electrical:navigational system(global positioning system)
Summary:
Nissan: navigation map data update matrix. affecting all vehicles 2003-11 except leaf, equipped with navigation system. customer is mailed update disc(s) or sd card and installs data; dealership is mailed update disc(s) and the dealershi
Bulletin:
NTB-12-028
Component:
015200 steering:hydraulic power assist:hose, piping, and connections
Summary:
Nissan: power steering hose service part change. the hose now comes without the pressure sensor. do not damage pressure sensor upon removal. if only pressure sensor needs replacement, do not replace hose. *js
Bulletin:
NTB12-035
Component:
103100 power train:automatic transmission:control module (tcm, pcm)
Summary:
Nissan: ecm replacement procedures with consult iii plus. applies to all 2004 and later (does not apply to leaf/ev) vehicles. *js
Bulletin:
NTB-13-038
Component:
170000 latches/locks/linkages
Summary:
Nissan: lock/unlock request button on outside handle does not respond. *js
Bulletin:
NTB17-026
Component:
021000 suspension:front
Summary:
Ball joint axial end play procedure service information when working on the front suspension, use the updated service information in this bulletin along with the electronic service manual (esm). the updated information in this bulletin
Bulletin:
NTB17-030
Component:
070000 fuel system, gasoline
Summary:
Nissan; fuel tank is slow or difficult to fill if you confirm the fuel tank is slow or difficult to fill (filling nozzle shuts off before tank is full). important: make sure this incident has been duplicated at a gas station by dealer
Bulletin:
REV1_P7318
Component:
118000 electrical system: software
Summary:
Air bag control unit reprogram voluntary service campaign temporary suspension of this campaign on all affected 2004-2006 model year vehicles. nissan is aware of reprogramming concerns on 2004-2006 models subject to p7318 air bag contro
Bulletin:
NTB17-070
Component:
140000 air bags
Summary:
Voluntary service campaign 2004-2011 titan, and 2005-2011 frontier and xterra; air bag diagnosis sensor unit introduction nissan is conducting a voluntary service campaign on certain specific model year 2004- 2011 titan, and 2005-2011 f
Bulletin:
P7318a
Component:
118000 electrical system: software
Summary:
Air bag control unit reprogram software update notice ***** campaign update***** updated software has been released to asist at 3:00 pm central time to address concerns with some vehicles not being able to complete the reprogramming. th
Bulletin:
P7318b
Component:
140000 air bags
Summary:
Air bag control unit reprogram voluntary service campaign ***** campaign summary***** nissan is committed to customer satisfaction. nissan is conducting a voluntary service campaign to reprogram the air bag control unit (acu) in 2004-20
Bulletin:
NTB17-082a
Component:
042300 service brakes, air:supply:check valve
Summary:
Nissan; dtc p0456 caused by evap leak at vent control valve o-ring this bulletin has been amended. the applied vehicles and claims information sections have been revised. no other changes have been made. please discard previous versions
Bulletin:
NTB14-068b
Component:
134000 visibility:sun roof assembly
Summary:
Power moonroof initialization service information this bulletin has been amended. the appplied vehices section and step 3 on page 3 have been revised. no other changes have been made. please discard all previous versions.
Bulletin:
NTB17-082
Component:
351300 equipment:recreational vehicle:lpg tank valve/gauge
Summary:
Nissan; dtc p0456 caused by evap leak at vent control valve o-ring if you confirm the mil is on in an applied vehicle with dtc p0456 (evap very sml leak) and - dtc p0456 is not caused by a loose fuel fill cap (refer to ntb13-097). -
Bulletin:
NTB17-110
Component:
020000 suspension
Summary:
2004 - 2015 titan; vibration at 40 ? 50 mph if you confirm a low frequency vibration at 40 ? 50 mph and the vehicle is equipped with the correct tires as shown on the tire and loading information label on the driver side body side out
Bulletin:
P7318
Component:
020000 suspension
Summary:
Air bag control unit reprogram voluntary service campaign update october 6, 2017 the announcement from august 15, 2017 has been revised to include: - claims information for unintended airbag deployment (related to campaign) temporary
Bulletin:
REVISION 3_P7318
Component:
140000 air bags
Summary:
Air bag control unit reprogram voluntary service campaign update january 5, 2018 the announcement from october 6, 2017 has been revised: - dealers may now use revised tsb ntb17-070 to resume repair of 2004-2006 model year vehicles. pl
Bulletin:
NTB17-070a
Component:
118000 electrical system: software
Summary:
Voluntary service campaign 2004-2011 titan, and 2005-2011 frontier and xterra; air bag diagnosis sensor unit this bulletin has been amended. the reprogramming procedure has been revised. no other changes have been made. discard all previ
Bulletin:
NTB18-003
Component:
020000 suspension
Summary:
2004-2015 titan; squeak or tick noise from leaf springs if you confirm: a squeak or tick noise coming from the rear suspension leaf springs when driving. note: - noise is more pronounced when driving over rough roads below 30 mph. -
Bulletin:
NTB10-104c
Component:
060000 engine (pws)
Summary:
Titan, armada, nv; engine oil leak at right side block ball plug this bulletin has been amended. the applied vehicles section has been updated. no other changes have been made. please discard all previous versions of this bulletin.
Bulletin:
NTB17-030a
Component:
070000 fuel system, gasoline
Summary:
Nissan; fuel tank is extremely difficult to fill this bulletin applies to titan xd vehicles with a gas engine. this bulletin has been amended. changes have been made throughout. it is necessary for you to read this revised procedure t
Bulletin:
NTB17-030a
Component:
070000 fuel system, gasoline
Summary:
Nissan; fuel tank is extremely difficult to fill this bulletin applies to titan xd vehicles with a gas engine. this bulletin has been amended. changes have been made throughout. it is necessary for you to read this revised procedure t

Home | Privacy