2005 NISSAN PATHFINDER Recalls (4)

Campaign:
07E046000 on 07/05/2007
Component:
Equipment
Affected:
3,500
Defect:
Certain hopkins aftermarket trailer brake control connection harnesses sold for use on certain models of nissan vehicles which are listed above. the internal part numbers within hopkins are: 1010476025, 1040376025, 1110476025, 1170376025, 1290376025, 1010476035, 1040376035, 1110476035, 1170376035, and 1290376035. a wire may have been placed in an incorrect position in the electrical connector housing. this results in an incorrect routing of wires between the trailer brake controller and the towing vehicle wiring system.
Consequence:
This harness would result in power from the trailer brake controller going to the towing vehicle dash light circuit rather than the trailer brakes. this result would be the lack of trailer braking when the towing vehicle brakes were applied. it would also result in the towing vehicles dash lights being activated when the vehicle brakes were applied. the failure of the application of the trailer brake could result in reduced ability to stop and contribute to a possible crash.
Correction:
Hopkins will notify owners and replace the original harness with a revised harness free of charge. the recall began august 17, 2007. owners can contact hopkins at 800-835-0129.
Notes:
This recall only pertains to aftermarket harnesses and has no relation to any original equipment installed on vehicles manufactured by nissan.customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.
Campaign:
08V690000 on 12/28/2008
Component:
Air bags:frontal
Manufactured:
05/31/2004 - 11/18/2008
Affected:
242,720
Defect:
Nissan is recalling 242,720 my 2005-2009 pathfinder, frontier and xterra vehicles originally sold in or currently registered in the states of connecticut, delaware, illinois, indiana, iowa, maine, maryland, massachusetts, michigan, minnesota, missouri, new hampshire, new jersey, new york, ohio, pennsylvania, rhode island, vermont, west virginia, wisconsin, and the district of columbia. in those areas of the country which use heavy concentrations of road salt in the winter, a mixture of snow/water and salt can enter into the front crash zone sensor (czs) housing. if this occurs, the czs may internally rust resulting in a signal interruption. if this happens, the red air bag warning light will illuminate to alert the vehicle operator.
Consequence:
This issue could result in the non-deployment of the driver and passenger front air bags in a crash, increasing the risk of personal injury.
Correction:
Dealers will replace the front czs with a redesigned sensor. the recall began on january 26, 2009. owners in the other states will receive extended warranty coverage for the sensor to 10 years. these owners will be notified of the warranty extension by mail and will receive a sticker to place in their warranty booklet explaining the extended warranty coverage. owners may contact nissan at 1-800-647-7261.
Notes:
Customers may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to <a href=http://www.safercar.gov>http://www.safercar.gov</a> .
Campaign:
10E019000 on 05/20/2010
Component:
Suspension:front:control arm:lower arm
Affected:
1,873
Defect:
Nissan is recalling certain front and rear lower links, p/nos. 54501zq00a, 54500zq00a, 551a1zq00a, 551a0zq00a , 54501ea00a, 54500ea00a, 551a1ea500, 551a0ea500, 54501zr00a, and 54500zr00a, sold between november 25, 2009 and may 14, 2010 as replacement parts for model year 2004 through 2010 titan, armada, and qx56, and model years 2005 through 2010 frontier, xterra, and pathfinder vehicles. the lower control link assembly has two cylindrical collars forming the inboard attachment points to the chassis. due to an improper welding process some collars may contain welds that do not meet strength specifications.
Consequence:
If the collar weld separates, the vehicle handling will deteriorate, possibly resulting in a vehicle crash.
Correction:
Nissan will notify owners and dealers will replace any affected lower link free of charge. the safety recall began on july 12, 2010. owners may contact nissan at 1-800-647-7261.
Notes:
Owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to <a href=http://www.safercar.gov>http://www.safercar.gov</a> .
Campaign:
10V517000 on 10/27/2010
Component:
Engine and engine cooling
Manufactured:
06/22/2004 - 06/15/2006
Affected:
747,480
Defect:
Nissan is recalling certain model year 2004-2006 armada, titan, infiniti qx56 and model year 2005-2006 frontier, pathfinder and xterra vehicles. the intelligent power distribution module (ipdm) assembly contains an engine control module (ecm) relay that has a diode for electrical current noise reduction. the ecm relay may allow silicon vapor to form and, over time, the silicon evaporates from the diode molding which causes silicon oxide to develop on the ecm relay contact due to arcing.
Consequence:
This could cause engine stalling increasing the risk of a crash.
Correction:
Dealers will replace the ecm relay inside the ipdm assembly. this service will be performed free of charge. the safety recall began on december 6, 2010. owners may contact nissan at 1-800-647-7261.
Notes:
Owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to <a href=http://www.safercar.gov>http://www.safercar.gov</a> .

2005 NISSAN PATHFINDER TSBs (43)

Bulletin:
02120A
Component:
036000 service brakes, hydraulic:antilock
Summary:
Antilock braking system (abs) light on and / or diagnostic trouble code for abs wheel speed sensor. *tt
Bulletin:
05015A
Component:
063000 engine and engine cooling:exhaust system
Summary:
Rattle noise from vias power valve actuator / intake manifold collector. *tt
Bulletin:
05023
Component:
353400 equipment:electrical:radio/tape deck/cd etc.
Summary:
Poor radio reception in am fm modes. *eh
Bulletin:
05019
Component:
162900 structure:body:roof and pillars
Summary:
Rattle at sunroof frame and #1 roof bow. *tt
Bulletin:
5219
Component:
110000 electrical system
Summary:
Vehicle dynamic control (vdc) voluntary service campaign p5219. *tt
Bulletin:
05027
Component:
110000 electrical system
Summary:
2005 pathfinder with 4wd; dtc p1720 v/sp sen (a/t out) stored in the ecm. *sc
Bulletin:
05050
Component:
355200 equipment:other:owners/service/other manual
Summary:
Voluntary service campaign-2005 pathfinder vehicle dynamic control (vdc) *sc
Bulletin:
05069
Component:
220000 seats
Summary:
Front seat manual recliner inoperative. *tt
Bulletin:
05077
Component:
221200 seats:front assembly:recliner
Summary:
Front passenger flod flat seat manual recliner inoperative. *tt
Bulletin:
05086
Component:
110000 electrical system
Summary:
Voluntary service campaign body control module sub-harness. enhanced electronic circuitry which may help furtherprotect a vehicle from damage or fire caused by a short circuit in the electrical system of a towed trailer. *tt
Bulletin:
05092
Component:
220000 seats
Summary:
Right front seat back assembly rattles and excessive side-to-side movement. *tt
Bulletin:
05099
Component:
020000 suspension
Summary:
Cam bolts for front wheel alignment. *tt
Bulletin:
05094
Component:
221600 seats:front assembly:power adjust
Summary:
Driver's power seat up/down function does not move. *tt
Bulletin:
06009
Component:
061000 engine and engine cooling:engine
Summary:
Malfunction indicator lamp on with diagnostic trouble code u1000 or u1010 stored in engine control unit. *ak
Bulletin:
06009
Component:
061000 engine and engine cooling:engine
Summary:
Mil on with dtc u1000 or u1010 stored in engine control unit. *tt
Bulletin:
06030
Component:
072100 fuel system, gasoline:delivery:fuel pump
Summary:
Squeak from fuel pump. *tt
Bulletin:
06034
Component:
034500 service brakes, hydraulic:foundation components:disc
Summary:
Squeaking noise from brakes. *ak
Bulletin:
06046
Component:
141200 air bags:frontal:driver side inflator module
Summary:
Driver's seat side air bag open circuit (dtc b1134). *tt
Bulletin:
06056
Component:
105500 power train:driveline:differential unit
Summary:
Pop/clunk noise from the front of the vehicle. *tt
Bulletin:
03030
Component:
120000 exterior lighting
Summary:
Exterior lamp fogging. *kb
Bulletin:
07042
Component:
061000 engine and engine cooling:engine
Summary:
Buzzing/whining noise from timing chain area. *kb
Bulletin:
NTB08-049
Component:
103000 power train:automatic transmission
Summary:
Nissan; special automatic transmission fluid requirement. 2004 to current nissan vehicles. *nj
Bulletin:
NTB08-062
Component:
220000 seats
Summary:
Seat back board removal/installation. *nj
Bulletin:
NTB-08-055-A
Component:
141100 air bags:frontal:sensor/control module
Summary:
Nissan: srs precautions during service;improper maintenance, including incorrect removal and installation of the srs, can lead to a serious injury or death caused by unintentional activation of the srs on all nissan models with the srs sys
Bulletin:
NTB-09-030
Component:
110000 electrical system
Summary:
Nissan: the 12 volt battery is an important part of the vehicle electrical system and is required to stay connected when the engine is running. to prevent damage to vehicle electronic components follow the instructions/cautions. no mod
Bulletin:
NTB-09-101
Component:
199000 tires:pressure monitoring and regulating systems
Summary:
Nissan: tire pressure monitoring system (tpms) warning light on/flashing. no models or model years listed. *pe updated on 08-11-2011. *kb
Bulletin:
NTB-03-074-C
Component:
120000 exterior lighting
Summary:
Nissan: exterior lamp fogging. occasionally water is noticed in the exterior lamps. this is generally not due to a defect. all current exterior lamp assemblies are vented to the atmosphere (not sealed). this is necessary to allow for e
Bulletin:
NTB-09-129
Component:
355200 equipment:other:owners/service/other manual
Summary:
Nissan: vent control valve replacement. when replacing the evap canister vent control valve for reason: use the one listed on page 2; for vent control valve replacement procedure, refer to the appropriate section of the electronic service
Bulletin:
NTB-07-069C
Component:
091200 fuel system, other:storage:fuel gauge system
Summary:
Nissan: fuel gauge issues and/or dtc p0461/2/3. the fuel gauge is erratic, inaccurate, or inoperative. the mil is on with dtc p0461, p0462, or p0463 stored in self diagnosis. replace the fuel level sending unit with the one from the par
Bulletin:
NTB-10-052
Component:
021600 suspension:front:wheel bearing
Summary:
Nissan: the propeller shaft u joint (journal/journal bearings) is the source of noise and/or vibration on an applied vehicle. diagnose by evaluating the u joint with the propeller shaft removed. replace the u joint (journal/journal beari
Bulletin:
NTB-10-061
Component:
121000 exterior lighting:headlights
Summary:
Nissan: xenon head lamp service. a xenon headlamp is not functioning because of an issue inside the headlamp assembly (an internal issue). in most cases, replacement of a bulb or hid control unit will solve the incident. this includes a
Bulletin:
NTB-04-047
Component:
104000 power train:transfer case (4-wheel drive)
Summary:
Nissan: oil leaking from transfer case. oil is leaking from one or a combination of three bolts at the rear of the transfer case. if bolts are not missing, do not replace transfer case, transfer control device; or transfer control unit f
Bulletin:
NTB-10-055
Component:
062200 engine and engine cooling:cooling system:fan
Summary:
Nissan: blower motor does not work. the blower motor for heater and air conditioner does not operate. there are signs of water intrusion in the blower motor. *pe
Bulletin:
NTB-10-072A
Component:
021000 suspension:front
Summary:
Nissan: front suspension noise. a noise (clunking, squeaking, popping) can be heard when performing at least one of the following actions: turning the steering wheel left or right, driving over speed bumps, driving on rough roads, acceler
Bulletin:
NTB-11-005
Component:
353500 equipment:electrical:navigational system(global positioning system)
Summary:
Nissan: navigation map data update matrix. affecting all vehicles 2003-11 except leaf, equipped with navigation system. customer is mailed update disc(s) or sd card and installs data; dealership is mailed update disc(s) and the dealershi
Bulletin:
NTB12-027
Component:
015200 steering:hydraulic power assist:hose, piping, and connections
Summary:
Nissan: pathfinder, xterra, and frontier; power steering hose service part change. *js
Bulletin:
NTB12-035
Component:
103100 power train:automatic transmission:control module (tcm, pcm)
Summary:
Nissan: ecm replacement procedures with consult iii plus. applies to all 2004 and later (does not apply to leaf/ev) vehicles. *js
Bulletin:
NTB-13-038
Component:
170000 latches/locks/linkages
Summary:
Nissan: lock/unlock request button on outside handle does not respond. *js
Bulletin:
NTB17-026
Component:
021000 suspension:front
Summary:
Ball joint axial end play procedure service information when working on the front suspension, use the updated service information in this bulletin along with the electronic service manual (esm). the updated information in this bulletin
Bulletin:
NTB17-030
Component:
070000 fuel system, gasoline
Summary:
Nissan; fuel tank is slow or difficult to fill if you confirm the fuel tank is slow or difficult to fill (filling nozzle shuts off before tank is full). important: make sure this incident has been duplicated at a gas station by dealer
Bulletin:
NTB17-082a
Component:
042300 service brakes, air:supply:check valve
Summary:
Nissan; dtc p0456 caused by evap leak at vent control valve o-ring this bulletin has been amended. the applied vehicles and claims information sections have been revised. no other changes have been made. please discard previous versions
Bulletin:
NTB17-030a
Component:
070000 fuel system, gasoline
Summary:
Nissan; fuel tank is extremely difficult to fill this bulletin applies to titan xd vehicles with a gas engine. this bulletin has been amended. changes have been made throughout. it is necessary for you to read this revised procedure t
Bulletin:
NTB17-030a
Component:
070000 fuel system, gasoline
Summary:
Nissan; fuel tank is extremely difficult to fill this bulletin applies to titan xd vehicles with a gas engine. this bulletin has been amended. changes have been made throughout. it is necessary for you to read this revised procedure t

Home | Privacy