2005 MAZDA MAZDA6 Recalls (7)

Campaign:
09E011000 on 04/02/2009
Component:
Equipment
Affected:
2,323
Defect:
Thule, inc. is recalling 2,323 owner-installed roof-mounted fit kits, models 3068 and 3069, manufactured between january 1, 2008 and february 28, 2009 that are used with thule podium foot packs, models 460 and 460r. these fit kits were sold as aftermarket equipment for use on the vehicles listed above. the bolt(s) used to secure the foot to the vehicle was manufactured to a hardness that may cause the bolt(s) to be brittle and potentially break under stress.
Consequence:
This may result in the bolt(s) snapping off during use or without a load. the unsecured rack and load can then come loose while driving creating a potential road hazard, possibly resulting in a vehicle crash.
Correction:
Thule will mail a retro fit kit along with repair instructions to owners free of charge. the safety recall is expected to begin on or before april 13, 2009. owners may contact thule toll-free at 1-800-238-2388.
Notes:
This recall only pertains to thule aftermarket roof mounted load carriers and has no relation to any original equipment installed on the listed passenger vehicles.owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to <a href=http://www.safercar.gov>http://www.safercar.gov</a> .
Campaign:
09E012000 on 04/06/2009
Component:
Exterior lighting
Affected:
16,270
Defect:
Sabersport is recalling 16,270 combination corner and bumper lamp assemblies of various part numbers sold for use as aftermarket equipment for various passenger vehicles. these headlamps fail to conform to the requirements of federal motor vehicle safety standard no. 108, "lamps, reflective devices, and associated equipment." these lamps do not contain the required amber side reflectors.
Consequence:
Decreased lighting visibility may result in a vehicle crash.
Correction:
Sabersport will notify owners and offer a full refund for the noncompliant combination lamps. the safety recall began on may 11, 2009. owners may contact sabersport at 1-909-598-7589.
Notes:
This recall only pertains to aftermarket replacement equipment and has no relation to any original equipment installed on vehicles produced by the vehicle manufacturer.in order to determine if your aftermarket lamp assembly is affected by this noncompliance, please review the list of model numbers provided to us by sabersport.the list can be found under "document search" located at the bottom of your screen.owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to <a href=http://www.safercar.gov>http://www.safercar.gov</a> .
Campaign:
09E025000 on 05/10/2009
Component:
Exterior lighting:headlights
Affected:
42,540
Defect:
Dope, inc. is recalling 42,540 combination corner and bumper lamp assemblies of various part numbers sold for use as aftermarket equipment for various passenger vehicles. these headlamps fail to conform to the requirements of federal motor vehicle safety standard no. 108, "lamps, reflective devices, and associated equipment." these lamps do not contain the required amber side reflectors.
Consequence:
Decreased lighting visibility may result in a vehicle crash.
Correction:
Dope, inc. will notify owners and offer a full refund for the noncompliant combination lamps. the safety recall began on july 28, 2009. owners may contact dope, inc. at 1-626-272-1798.
Notes:
This recall only pertains to aftermarket replacement equipment and has no relation to any original equipment installed on vehicles produced by the vehicle manufacturer.in order to determine if your aftermarket lamp assembly is affected by this noncompliance, please review the list of model numbers provided to us by dope, inc.the list can be found under "document search" located at the bottom of your screen. owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to <a href=http://www.safercar.gov>http://www.safercar.gov</a> .
Campaign:
16V354000 on 05/24/2016
Component:
Air bags:passenger side frontal
Manufactured:
05/28/2002 - 05/04/2008
Affected:
448,320
Defect:
Mazda north american operations (mazda) is recalling certain model year 2004-2011 rx-8, 2004-2006 mpv, 2003-2008 mazda6, and 2006-2007 mazdaspeed6 vehicles, originally sold, or ever registered, in alabama, california, florida, georgia, hawaii, louisiana, mississippi, south carolina, texas, puerto rico, american samoa, guam, the northern mariana islands (saipan), and the u.s. virgin islands, or "zone a." additionally, unless included in "zone a" above, mazda is recalling certain model year 2004-2008 rx-8, 2004-2006 mpv, 2003-2008 mazda6 vehicles, originally sold, or ever registered, in arizona, arkansas, delaware, district of columbia, illinois, indiana, kansas, kentucky, maryland, missouri, nebraska, nevada, new jersey, new mexico, north carolina, ohio, oklahoma, pennsylvania, tennessee, virginia, and west virginia, or "zone b." lastly, unless included in "zone a" or "zone b" above, mazda is recalling certain model year 2004 mazda rx-8 and mpv, 2003-2004 mazda6 vehicles originally sold, or registered, in alaska, colorado, connecticut, idaho, iowa, maine, massachusetts, michigan, minnesota, montana, new hampshire, new york, north dakota, oregon, rhode island, south dakota, utah, vermont, washington, wisconsin, and wyoming. these vehicles are equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules, and used as original equipment or replacement equipment. in the event of a crash necessitating deployment of the front air bags, these inflators may rupture due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling.
Consequence:
An inflator rupture may result in metal fragments striking the vehicle occupants resulting in serious injury or death.
Correction:
Mazda will notify owners, and dealers will replace the passenger frontal air bag inflator, free of charge. the recall began july 2016. owners may contact mazda customer service at 1-800-222-5500. mazda's number for this recall is 9416e. note: this recall is partially superseded by recall 18v402.
Notes:
Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.
Campaign:
16V354000 on 05/24/2016
Component:
Air bags:passenger side frontal
Manufactured:
05/28/2002 - 05/04/2008
Affected:
448,320
Defect:
Mazda north american operations (mazda) is recalling certain model year 2004-2011 rx-8, 2004-2006 mpv, 2003-2008 mazda6, and 2006-2007 mazdaspeed6 vehicles, originally sold, or ever registered, in alabama, california, florida, georgia, hawaii, louisiana, mississippi, south carolina, texas, puerto rico, american samoa, guam, the northern mariana islands (saipan), and the u.s. virgin islands, or "zone a." additionally, unless included in "zone a" above, mazda is recalling certain model year 2004-2008 rx-8, 2004-2006 mpv, 2003-2008 mazda6 vehicles, originally sold, or ever registered, in arizona, arkansas, delaware, district of columbia, illinois, indiana, kansas, kentucky, maryland, missouri, nebraska, nevada, new jersey, new mexico, north carolina, ohio, oklahoma, pennsylvania, tennessee, virginia, and west virginia, or "zone b." lastly, unless included in "zone a" or "zone b" above, mazda is recalling certain model year 2004 mazda rx-8 and mpv, 2003-2004 mazda6 vehicles originally sold, or registered, in alaska, colorado, connecticut, idaho, iowa, maine, massachusetts, michigan, minnesota, montana, new hampshire, new york, north dakota, oregon, rhode island, south dakota, utah, vermont, washington, wisconsin, and wyoming. these vehicles are equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules, and used as original equipment or replacement equipment. in the event of a crash necessitating deployment of the front air bags, these inflators may rupture due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling.
Consequence:
An inflator rupture may result in metal fragments striking the vehicle occupants resulting in serious injury or death.
Correction:
Mazda will notify owners, and dealers will replace the passenger frontal air bag inflator, free of charge. the recall began july 2016. owners may contact mazda customer service at 1-800-222-5500. mazda's number for this recall is 9416e. note: this recall is partially superseded by recall 18v402.
Notes:
Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.
Campaign:
17V474000 on 07/27/2017
Component:
Air bags:frontal:driver side inflator module
Manufactured:
05/28/2002 - 05/04/2008
Affected:
308,992
Defect:
Mazda north american operations (mazda) is recalling certain model year 2003-2008 mazda6, 2004-2008 rx-8, and 2006-2007 mazdaspeed6 vehicles. the affected vehicles are equipped with a dual-stage driver frontal air bag that may be susceptible to moisture intrusion and other factors, including manufacturing variability that, over time, could cause the inflator to rupture.
Consequence:
In the event of a crash necessitating deployment of the driver's frontal air bag, the inflator could rupture with metal fragments striking the driver or other occupants resulting in serious injury or death.
Correction:
Mazda will notify owners, and dealers will replace the driver's frontal air bag inflator with an alternate inflator, free of charge. the recall began on september 12, 2017. owners may contact mazda customer service at 1-800-222-5500. mazda's number for this recall is 1417g. note: this recall supersedes recall 15v-382.
Notes:
Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.
Campaign:
18V402000 on 06/18/2018
Component:
Air bags:passenger side frontal
Manufactured:
05/28/2002 - 05/04/2008
Affected:
269,618
Defect:
Mazda north america operations (mazda) is recalling certain 2003-2008 mazda6, 2006-2007 mazdaspeed6 and 2004 mpv vehicles nationwide. mazda is also recalling 2005-2006 mpv vehicles in alabama, arizona, arkansas, california, delaware, the district of columbia, florida, georgia, hawaii, illinois, indiana, kansas, kentucky, louisiana, maryland, mississippi, missouri, nebraska, nevada, new jersey, new mexico, north carolina, ohio, oklahoma, pennsylvania, south carolina, tennessee, texas, virginia, west virginia, puerto rico, american samoa, guam, the northern mariana islands (saipan), and the u.s. virgin islands. these vehicles are equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules, and used as original equipment or replacement equipment. in the event of a crash necessitating deployment of the passenger frontal air bag, these passenger air bag inflators may explode due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling.
Consequence:
An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
Correction:
Mazda will notify owners, and dealers will replace the front passenger air bag inflator with an alternate inflator, free of charge. the recall began july 6, 2018. owners may contact mazda customer service at 1-800-222-5500 ,option 4. mazda's number for this recall is 2618f. note: this recall partially supersedes recall 16v354.
Notes:
Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.

2005 MAZDA MAZDA6 TSBs (97)

Bulletin:
0100803
Component:
061000 engine and engine cooling:engine
Summary:
Oil filter cartridge removal. *tt engine oil filter cartridge housing cover damage. *tt
Bulletin:
00204
Component:
063100 engine and engine cooling:exhaust system:emission control
Summary:
Evaporative emmissions and reciver adapters. *eh
Bulletin:
0101805
Component:
061110 engine and engine cooling:engine:gasoline:belts and associated pulleys
Summary:
Unusual noise from drive belt auto tensioner. *tt
Bulletin:
0800505
Component:
150000 seat belts
Summary:
Deactivation of seat belt minder. *sc
Bulletin:
0520
Component:
103000 power train:automatic transmission
Summary:
Automatic transmission fluid. *sc
Bulletin:
0900705
Component:
221700 seats:front assembly:seat heater/cooler
Summary:
Improper seat warmer operation. *tt
Bulletin:
0700105
Component:
131000 visibility:windshield
Summary:
Fogging on lower exterior of windshield. *tt
Bulletin:
0102205
Component:
180000 vehicle speed control
Summary:
Delayed throttle response during low speed acceleration. *tt
Bulletin:
10
Component:
110000 electrical system
Summary:
Mazda service program #10 - the malfunction indicator light (mil) may illuminate during an obd check at an inspection/maintenance (i/m) station causing the vehicle to fail the inspection/maintenance station (i/m) test even though the vehicl
Bulletin:
11012005
Component:
353000 equipment:electrical
Summary:
Information display functions. *tt
Bulletin:
01012006
Component:
353600 equipment:air conditioner
Summary:
Recirc air function inoperative. *tt
Bulletin:
01012006
Component:
162000 structure:body
Summary:
Center panel removal caution. *tt
Bulletin:
0100206
Component:
060000 engine and engine cooling
Summary:
Engine misfire diagnostic procedures - service tip. *tt
Bulletin:
0500906
Component:
103000 power train:automatic transmission
Summary:
1-2 shift shock (trans relearn procedure deleted). vehicles with automatic transmissions. *kb
Bulletin:
0200606
Component:
010000 steering
Summary:
Steering pull/drift-improved diagnostic and repair procedures. *kb
Bulletin:
0104406
Component:
117000 digital instrument panel
Summary:
Malfunction indicator light on with dtc p0106. *kb
Bulletin:
0800306
Component:
140000 air bags
Summary:
Non genuine accessories affect air bag operation. *kb
Bulletin:
0100907
Component:
072100 fuel system, gasoline:delivery:fuel pump
Summary:
Engine no start due to frozen main relay/fuel pump relay. *kb
Bulletin:
00307
Component:
980000 unknown or other
Summary:
Availability of non-required tools. *kb
Bulletin:
0102206
Component:
021000 suspension:front
Summary:
Front crankshaft bolt service warning. *nj
Bulletin:
09-007/08
Component:
121000 exterior lighting:headlights
Summary:
Headlight lens condensation or water entry - (not applicable to mazdaspeed6). *nj
Bulletin:
01-003/08
Component:
103100 power train:automatic transmission:control module (tcm, pcm)
Summary:
Multi-model - engine stalls when driving at low speed. *nj
Bulletin:
01-025/08
Component:
103100 power train:automatic transmission:control module (tcm, pcm)
Summary:
Mil illumination on with dtc p2112. vehicles produced before feb. 4, 2008. *nj
Bulletin:
01-003-08
Component:
061000 engine and engine cooling:engine
Summary:
Mazda: engine stalls when driving at low speed. *pe
Bulletin:
SB-01-007-09
Component:
061000 engine and engine cooling:engine
Summary:
Mazda: vehicles may exhibit a concern of unstable idling or, in some rare cases, stalling, just after the vehicle stops with no dtcs detected. problem is due to the accumulation of carbon deposits inside the throttle body causing air flow
Bulletin:
SB-01-023-10
Component:
071110 fuel system, gasoline:storage:tank assembly:filler pipe and cap
Summary:
Mazda: determining evaporative system leak location for dtcs p0441, p0442, p0455, p0455. some vehicles may have a mil illumination with dtcs stored in memory. *pe updated 4/18/11. *pe
Bulletin:
SB-01-028-10
Component:
061000 engine and engine cooling:engine
Summary:
Mazda: variable valve timing (vvt) noise when starting engine. when engine is first started, some vehicles may exhibit a loud ticking noise from the variable valve timing (vvt) (a). this is caused by the lock pin of the variable valve tim
Bulletin:
SB-09-057-10
Component:
120000 exterior lighting
Summary:
Mazda: there is condensation and fog in the front and rear combination lights. *rm
Bulletin:
SB-09-005-13
Component:
350000 equipment
Summary:
Mazda: on some vehicles, to avoid potential interference of foot placed on pedals, information is provided regarding proper use, and placement, of driver's floor mat. various models and model years. *pe
Bulletin:
SB-08-001-13
Component:
141000 air bags:frontal
Summary:
Mazda: information provided regarding the indicator light illumination of the passenger airbag deactivation (pad). *pe
Bulletin:
02-004-14
Component:
011000 steering:wheel and handle bar
Summary:
Summary to be provided on a future date.
Bulletin:
RF-04-14R4
Component:
130000 visibility
Summary:
Summary to be provided on a future date.
Bulletin:
SA234
Component:
118000 electrical system: software
Summary:
Ids update 101.00 and 101.02 is now available on ms3 under the "ids/infotainment" tab.
Bulletin:
SA327
Component:
140000 air bags
Summary:
Takata recalls general information purpose: this page was created to assist with handling takata air bag recalls. processes: please use these process flowcharts to properly handle vehicles subject to the takata air bag recall. recall 82
Bulletin:
02-009-16-3155
Component:
010000 steering
Summary:
Some customers may complain that the steering wheel is off center more than 3° even when driving straight on a flat road.
Bulletin:
00-004-16-3237
Component:
350000 equipment
Summary:
Raising a vehicle with a jack can be dangerous if not done properly. the vehicle can slip off the jack and seri-ously injure someone. in this service information, some important warnings and cautions have been taken from the owner's manual.
Bulletin:
01-016-16-3220
Component:
060000 engine (pws)
Summary:
There is a concern that some water pumps are being replaced that are not faulty, due to signs of a very small coolant leak from the bleed hole. this service bulletin is to inform you about the water pump sealing mecha-nism and the criteria
Bulletin:
00-001-13-2748
Component:
355200 equipment:other:owners/service/other manual
Summary:
Mazda has developed factory recommended scheduled maintenance services that support all major vehicle systems. mazda recommends dealers follow the scheduled maintenance tables as cited in the vehicle-specific workshop manual or owner's manu
Bulletin:
01-002-13-2753
Component:
063000 engine and engine cooling:exhaust system
Summary:
Some vehicles may exhibit a rattle noise and/or exhaust leaking noise from the rear of the vehicle. the noise may be caused by a gap between the exhaust hanger bracket and flange, which allows moisture containing road salt to enter and caus
Bulletin:
02-001-13-2752
Component:
350000 equipment
Summary:
Some customers may complain of signs of oil on the struts or shock absorbers. in most cases the oil that is present is normal, and a result of the oil that remains on the shaft during the normal sweeping process of the shaft seal. follow th
Bulletin:
02-004-13-2770
Component:
010000 steering
Summary:
Some customers may complain that the steering wheel is off center more than 3° even when driving straight on a flat road.
Bulletin:
09-005-13-2781
Component:
350000 equipment
Summary:
This service bulletin provides information regarding the proper use of the driver's floor mat to avoid any poten-tial interference with the foot pedals. the following are possible causes of floor mat interference, which can be avoided with
Bulletin:
05-002-13-2777A
Component:
102400 power train:manual transmission:lubricant
Summary:
Always be sure to use the correct automatic transmission fluid when replacing atf. using the wrong atf may cause shift quality complaints or may even damage the transmission.note:'atf m-v (type m5) is not the same fluid as mercon®v or merco
Bulletin:
05-002-13-2777
Component:
102400 power train:manual transmission:lubricant
Summary:
Always be sure to use the correct automatic transmission fluid when replacing atf. using the wrong atf may cause shift quality complaints or may even damage the transmission.note:'atf m-v (type m5) is not the same fluid as mercon®v or merco
Bulletin:
00-001-13-2748A
Component:
355200 equipment:other:owners/service/other manual
Summary:
Mazda has developed factory recommended scheduled maintenance services that support all major vehicle systems. mazda recommends dealers follow the scheduled maintenance tables as cited in the vehicle-specific workshop manual or owner's manu
Bulletin:
02-004-13-2770A
Component:
011000 steering:wheel and handle bar
Summary:
Some customers may complain that the steering wheel is off center more than 3° even when driving straight on a flat road.
Bulletin:
09-018-13-2803
Component:
355200 equipment:other:owners/service/other manual
Summary:
Some customers may complain that the ambient temperature display is not accurate, or it takes too long for the display to show actual temperature. when you encounter a customer with this concern, first verify the condition when the customer
Bulletin:
02-004-13-2770B
Component:
011000 steering:wheel and handle bar
Summary:
Some customers may complain that the steering wheel is off center more than 3° even when driving straight on a flat road.
Bulletin:
07-002-13-2842
Component:
353600 equipment:air conditioner
Summary:
A musty/mildew type odor may come from the vents when the air conditioning (a/c) system is operating. it is most noticeable when the a/c is first turned on. this odor is the result of mold growth in the a/c evaporator/cooling unit which is
Bulletin:
09-046-12-2744
Component:
120000 lighting (pws)
Summary:
Some customers may complain of condensation/fog inside the front or rear combination lights. the recent new models have been fitted with a clear lens which can cause the symptom to be more noticeable, however, it does not affect the perform
Bulletin:
00-004-12-2741
Component:
355200 equipment:other:owners/service/other manual
Summary:
Mazda has developed factory recommended scheduled maintenance services that support all major vehicle systems. mazda recommends dealers follow the scheduled maintenance tables as cited in the vehicle-specific workshop manual or owner's manu
Bulletin:
09-039-13-2852
Component:
220000 seats
Summary:
Some vehicles may exhibit a chattering noise and the driver-side seat lift cannot be adjusted because the lock plate guide comes off the guide cam when operating the lift. if the lift lever is then operated with the lock plate guide off, th
Bulletin:
09-007-14-2878
Component:
122000 exterior lighting:fog lights
Summary:
Some customers may complain of condensation/fog inside the front or rear combination lights. the recent new models have been fitted with a clear lens which can cause the symptom to be more noticeable, however, it does not affect the perform
Bulletin:
09-012-14-2891
Component:
353400 equipment:electrical:radio/tape deck/cd etc.
Summary:
When replacing the siriusxm satellite radio unit (or a mazda connect tuner and amp unit (tau)) with replacement tuner for any reason, a call must be made to inform siriusxm of the existing radio id and the new/ replacement sat radio id as s
Bulletin:
04-004-14-2926
Component:
030000 brakes (pws)
Summary:
Some vehicles exhibit brake related concerns such as brake noise, brake judder or brake dragging. if you encounter a customer complaint for any one of these symptoms, refer to the following information to understand why symptoms may occur,
Bulletin:
09-023-14-2924
Component:
350000 equipment
Summary:
Some customers may complain that the ambient temperature display is not accurate, or it takes too long for the display to show actual temperature.when you encounter a customer with this concern, first verify the condition when the customer
Bulletin:
00-002-14-2936
Component:
350000 equipment
Summary:
Mazda north american operations received many requests from our dealers asking us to approve additional on-car brake lathes as an option for mnao authorized equipment. due to your feedback and after evaluating a few on-car brake lathes, we
Bulletin:
09-027-14-2935
Component:
356000 equipment adaptive
Summary:
This service bulletin provides information regarding the proper use of the driver's floor mat to avoid any potential interference with the foot pedals. the following are possible causes of floor mat interference, which can be avoided with p
Bulletin:
09-034-14-2956
Component:
356000 equipment adaptive
Summary:
In accordance with federal regulations, follow the procedure listed below when replacing a speedometer.note:'mazda vehicles are manufactured with tamper-proof speedometers.'when a speedometer is replaced, the new speedometer will read zero
Bulletin:
02-004-14-2976
Component:
011000 steering:wheel and handle bar
Summary:
Some customers may complain that the steering wheel is off center more than 3° even when driving straight on a flat road. follow steering wheel alignment procedure.
Bulletin:
01-003-15-3014
Component:
350000 equipment
Summary:
Use the following repair procedure to minimize the need to replace the catalyst converter/exhaust pipe when removing oxygen sensors and/or air fuel ratio sensors.
Bulletin:
09-003-16-3130
Component:
121000 exterior lighting:headlights
Summary:
Some customers may complain of condensation/fog inside the front (headlamp/headlight) or rear (taillamp/tail-light) combination lights. the recent new models have been fitted with a clear lens which can cause the symp-tom to be more noticea
Bulletin:
05-001-16-3128
Component:
355200 equipment:other:owners/service/other manual
Summary:
Always be sure to use the correct automatic transmission fluid when replacing atf. using the wrong atf may cause shift quality complaints or may even damage the transmission.note:' atf m-v (type m5) is not the same fluid as mercon®v or merc
Bulletin:
02-009-16-3155
Component:
011000 steering:wheel and handle bar
Summary:
Some customers may complain that the steering wheel is off center more than 3° even when driving straight on a flat road.
Bulletin:
09-030-15-3073
Component:
355200 equipment:other:owners/service/other manual
Summary:
Mazda infotainment systems require contacting the proper source for diagnostic support, parts authorization, and parts exchange. some components require prior authorization before ordering as exchange. refer to dag exchange central (mxconn
Bulletin:
02-002-16-3124
Component:
200000 wheels
Summary:
Some automotive cleaning products contain strong acid or alkali. when these types of cleaners are used to clean the wheels on mazda vehicles, the chemicals contents penetrate the clear coating of the wheel surface and damage the paint under
Bulletin:
04-004-16-3160
Component:
030000 brakes (pws)
Summary:
Some vehicles exhibit brake related concerns such as brake noise, brake judder or brake dragging. if you encounter a customer complaint for any one of these symptoms, refer to the following information to understand why symptoms may occur,
Bulletin:
08-001-13-2859
Component:
110000 electrical system
Summary:
This information is provided to help address passenger airbag deactivation (pad) indicator illumination con-cerns during vehicle service.
Bulletin:
02-009-13-2854
Component:
200000 wheels
Summary:
Some automotive cleaning products contain strong acid or alkali. when these types of cleaners are used to clean the wheels on mazda vehicles, the chemicals contents penetrate the clear coating of the wheel surface and damage the paint under
Bulletin:
04-004-13-2853
Component:
030000 brakes (pws)
Summary:
Some vehicles exhibit brake related concerns such as brake noise, brake judder or brake dragging. if you encounter a customer complaint for any one of these symptoms, refer to the following information to understand why symptoms may occur,
Bulletin:
09-008-17-3324
Component:
121000 exterior lighting:headlights
Summary:
Take caution when cleaning plastic headlight lenses. damage can occur when using some cleaners that contain strong acid, alkaline cleanser or organic solvent. damage caused by using these cleaners is not covered by mazda's new vehicle limit
Bulletin:
17-04
Component:
114000 electrical system:wiring
Summary:
A newly established short cord (p/n gay2-67-sh0) has been released if a connector is broken when performing recall 9416e.
Bulletin:
SA-061-17
Component:
117000 digital instrument panel
Summary:
In an effort to achieve a higher level of customer experience and retain the value of mazda's vehicles, mnao warranty operations is© 2017 mazda north american operations, u.s.a. allowing all mazda dealers to utilize a third party, specmo en
Bulletin:
09018173351
Component:
117000 digital instrument panel
Summary:
Some customers may complain that the ambient temperature display is not accurate, or it takes too long for the display to show actual temperature. when you encounter a customer with this concern, first verify the condition when the customer
Bulletin:
09-035-17-3080
Component:
117000 digital instrument panel
Summary:
In accordance with federal regulations, follow the procedure listed below when replacing a speedometer. note: tampering with a motor vehicle odometer is strictly prohibited by federal, and state laws. it is the dealer?s responsibility to co
Bulletin:
SA-068-17
Component:
140000 air bags
Summary:
Stopper plates for air bag module connectors have been established as new service parts. when removing the connector (1) to the air bag module (2), make sure to first lift the stopper plate (3) carefully using a flathead screwdriver (but do
Bulletin:
08-003-17-3345
Component:
141200 air bags:frontal:driver side inflator module
Summary:
Mazda motor corporation is going to evaluate the following inflators to ensure the safety of the inflator with a desiccant. in order to do this, mnao is collecting inflators for evaluation in certain zones. for 2003-2008 mazda6 (including m
Bulletin:
01-002-18-3417
Component:
110000 electrical system
Summary:
Some vehicles may have a mil illumination with dtc's p0441, p0442, p0455, or p0456 stored in memory. to determine the location of the evaporative system leak, follow the repair procedure below. p0441 - evaporative emission control system in
Bulletin:
00-001-18-3446
Component:
350000 equipment
Summary:
Mazda has developed factory recommended scheduled maintenance services that support all major vehicle systems. mazda recommends dealers follow the scheduled maintenance tables as cited in the vehicle-specific workshop manual or owner's manu
Bulletin:
09-011-18-3448
Component:
121000 exterior lighting:headlights
Summary:
Some customers may complain of condensation/fog inside the front (headlamp/headlight) or rear (taillamp/taillight) combination lights. the recent new models have been fitted with a clear lens which can cause the symptom to be more noticeabl
Bulletin:
09-014-18-3443
Component:
160000 structure
Summary:
When encountering a vehicle with paint damage, refer to the "mazda pocket paint guide" to determine cause, prevention, remedy, and warranty coverage (if applicable).
Bulletin:
09-019-18-3450
Component:
356000 equipment adaptive
Summary:
This service bulletin provides information regarding the proper use of the driver's floor mat to avoid any potential interference with the foot pedals. the following are possible causes of floor mat interference, which can be avoided with p
Bulletin:
MT-003-18
Component:
140000 air bags
Summary:
The workshop manual has two-different airbag procedures, one for standard deployment and one for two-step deployment. standard deployment is for mexico spec vehicles and two-step deployment is for us and canadian spec vehicles.
Bulletin:
01-008-18-3451
Component:
111000 electrical system:battery
Summary:
This service bulletin provides testing and charging procedures in order to promote proper battery maintenance, to deliver new vehicles with fully charged batteries, and to reduce unnecessary battery replacement cost. for new vehicles in sto
Bulletin:
01-009-18-3452
Component:
111000 electrical system:battery
Summary:
The mazda gr8-1291 is required for all warranty battery testing. if the mazda gr8-1291 is not used, incorrect battery testing may result in unnecessary battery replacement. use the following test procedures in this service bulletin to test
Bulletin:
02-006-18-3449
Component:
021300 suspension:front:shock absorber
Summary:
Some customers may complain of signs of oil on the struts or shock absorbers. in most cases the oil that is present is normal, and a result of the oil that remains on the shaft during the normal sweeping process of the shaft seal. follow th
Bulletin:
02-008-18-3467
Component:
200000 wheels
Summary:
Some automotive cleaning products contain strong acid or alkali. when these types of cleaners are used to clean the wheels on mazda vehicles, the chemicals contents penetrate the clear coating of the wheel surface and damage the paint under
Bulletin:
04-004-18-3468
Component:
030000 brakes (pws)
Summary:
Some vehicles exhibit brake related concerns such as brake noise, brake judder or brake dragging. if you encounter a customer complaint for any one of these symptoms, refer to the following information to understand why symptoms may occur,
Bulletin:
05-001-18-3453
Component:
100000 power train
Summary:
Always be sure to use the correct automatic transmission fluid when replacing atf. using the wrong atf may cause shift quality complaints or may even damage the transmission. note: atf m-v (type m5) is not the same fluid as mercon®v or merc
Bulletin:
07-002-18-3432
Component:
353600 equipment:air conditioner
Summary:
A musty/mildew type odor may come from the vents when the air conditioning (a/c) system is operating. it is most noticeable when the a/c is first turned on. this odor is the result of mold growth in the a/cevaporator/cooling unit which is c
Bulletin:
08-001-18-3457
Component:
140000 air bags
Summary:
This information is provided to help address passenger airbag deactivation (pad) indicator illumination concerns during vehicle service.
Bulletin:
00-003-18-3480
Component:
030000 brakes (pws)
Summary:
Mazda north american operations has approved an additional on-car brake lathe as an option for mnaoauthorized equipment. the pro-cut on-car brake lathe has been added to the mnao authorizedequipment program.note: accu-turn is still an appro
Bulletin:
02-010-18-3477
Component:
011000 steering:wheel and handle bar
Summary:
Some customers may complain that the steering wheel is off center more than 3° even when driving straight on a flat road.
Bulletin:
09-023-18-3475
Component:
350000 equipment
Summary:
When replacing the siriusxm satellite radio unit (or a mazda connect tuner and amp unit (tau)) with replacement tuner for any reason, a call must be made to inform siriusxm of the existing radio id and the new/replacement sat radio id as so
Bulletin:
09-025-18-3479
Component:
350000 equipment
Summary:
Mazda infotainment systems require contacting the proper source for diagnostic support, parts authorization, and parts exchange. some components require prior authorization before ordering as exchange. refer to dag exchange central (mxconne
Bulletin:
09-034-18-3430
Component:
180000 vehicle speed control
Summary:
In accordance with federal regulations, follow the procedure listed below when replacing a speedometer. note: tampering with a motor vehicle odometer is strictly prohibited by federal, and state laws. it is the dealer's responsibility to co
Bulletin:
01-016-18-3522
Component:
063000 engine and engine cooling:exhaust system
Summary:
On some vehicles, a sulfur smell or 'rotten egg' odor may be noticed coming from the exhaust system. the odor is usually noticed after a cold start, fast idle, extended periods of idling and full throttle acceleration. sulfur smell is not a

Home | Privacy