2005 JEEP GRAND CHEROKEE Recalls (6)

Campaign:
05V396000 on 09/12/2005
Component:
Power train:automatic transmission
Manufactured:
04/30/2004 - 06/01/2005
Affected:
101,925
Defect:
On certain sport utility vehicles equipped with 3.7l engines and nag1 automatic transmissions, the air conditioner evaporator condensate water may enter the transmission at the fill tube grommet seal. this can result in shudder during torque converter clutch engagement.
Consequence:
It can lead to increased transmission operating temperatures, boiling of the water, and a subsequent purging of transmission fluid into the engine compartment potentially resulting in an underhood fire.
Correction:
Dealers will inspect the transmission for leakage at the fill tube grommet seal. if no leak is detected, a new fill tube grommet seal and water deflector shield will be installed, and proper alignment of the fill tube verified. if the presence of a leak is detected, the vehicle will be evaluated for shudder during torque converter engagement. if no shudder is detected, the transmission will be triple flushed, and new fill tube grommet seal and water deflector will be installed and proper alignment of the fill tube verified. if shudder is detected, the torque converter will be replaced, a new fill tube grommet seal and water deflector will be installed, and proper alignment of the fill tube verified. the recall began on october 31, 2005. owners may contact daimlerchrysler at 1-800-853-1403.
Notes:
Daimlerchrysler recall no. e13.customers may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov.
Campaign:
09E012000 on 04/06/2009
Component:
Exterior lighting
Affected:
16,270
Defect:
Sabersport is recalling 16,270 combination corner and bumper lamp assemblies of various part numbers sold for use as aftermarket equipment for various passenger vehicles. these headlamps fail to conform to the requirements of federal motor vehicle safety standard no. 108, "lamps, reflective devices, and associated equipment." these lamps do not contain the required amber side reflectors.
Consequence:
Decreased lighting visibility may result in a vehicle crash.
Correction:
Sabersport will notify owners and offer a full refund for the noncompliant combination lamps. the safety recall began on may 11, 2009. owners may contact sabersport at 1-909-598-7589.
Notes:
This recall only pertains to aftermarket replacement equipment and has no relation to any original equipment installed on vehicles produced by the vehicle manufacturer.in order to determine if your aftermarket lamp assembly is affected by this noncompliance, please review the list of model numbers provided to us by sabersport.the list can be found under "document search" located at the bottom of your screen.owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to <a href=http://www.safercar.gov>http://www.safercar.gov</a> .
Campaign:
09E039000 on 06/18/2009
Component:
Suspension
Affected:
44
Defect:
Rock krawler is recalling 44 performance suspension systems sold as aftermarket equipment for use on the vehicle listed above. these suspension systems were produced with grade 2 carriage bolts instead of the proper grade 5 carriage bolts. the improper grade 2 carriage bolts could experience a loss of clamping force for the bottom strut fork.
Consequence:
This condition could cause a loss of effective lift and lowering of the affected vehicle, possibly creating the driver to panic which could possibly lead to a vehicle crash.
Correction:
Rock krawler will notify owners and provide a free remedy. the safety recall began on october 15. 2008. all the affected untits have been remedied. owners may contact rock krawler at 1-518-270-9822.
Notes:
Owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to <a href=http://www.safercar.gov>http://www.safercar.gov</a> .
Campaign:
13V175000 on 05/06/2013
Component:
Power train:transfer case (4-wheel drive)
Manufactured:
02/10/2004 - 03/08/2010
Affected:
295,345
Defect:
Chrysler group llc (chrysler) is recalling certain model year 2005-2010 jeep grand cherokee vehicles manufactured february 11, 2004, through march 9, 2010; and 2006-2010 jeep commander vehicles manufactured january 31, 2005, through march 10, 2010. a transfer case electrical failure may result in an unintentional shifting of the transfer case into the neutral position.
Consequence:
If the vehicle shifts into neutral, it may roll away increasing the risk of a crash or personal injury.
Correction:
Chrysler will notify owners, and dealers will reflash the final drive controller which governs the transfer case, with new software, free of charge. the recall began on august 15, 2013. owners may contact chrysler at 1-800-247-9753. chrysler's recall campaign number is n23.
Notes:
Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.
Campaign:
13V175000 on 05/06/2013
Component:
Electrical system
Manufactured:
02/10/2004 - 03/08/2010
Affected:
295,345
Defect:
Chrysler group llc (chrysler) is recalling certain model year 2005-2010 jeep grand cherokee vehicles manufactured february 11, 2004, through march 9, 2010; and 2006-2010 jeep commander vehicles manufactured january 31, 2005, through march 10, 2010. a transfer case electrical failure may result in an unintentional shifting of the transfer case into the neutral position.
Consequence:
If the vehicle shifts into neutral, it may roll away increasing the risk of a crash or personal injury.
Correction:
Chrysler will notify owners, and dealers will reflash the final drive controller which governs the transfer case, with new software, free of charge. the recall began on august 15, 2013. owners may contact chrysler at 1-800-247-9753. chrysler's recall campaign number is n23.
Notes:
Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.
Campaign:
14V438000 on 07/20/2014
Component:
Electrical system:ignition:switch
Manufactured:
02/10/2004 - 07/04/2007
Affected:
649,353
Defect:
This defect can affect the safe operation of the airbag system. until this recall is performed, drivers should adjust their seat to allow clearance between the driver's knee and the ignition key, and remove all items from their key ring, leaving only the vehicle key. chrysler group llc (chrysler) is recalling certain model year 2005-2007 jeep grand cherokee vehicles manufactured february 11, 2004, to july 5, 2007, and 2006-2007 jeep commander vehicles manufactured january 31, 2005, to july 5, 2007. in the affected vehicles, the driver may accidentally hit the ignition key with their knee, unintentionally knocking the key out of the run position, turning off the engine.
Consequence:
If the ignition key inadvertently moves into the off or accessory position, the engine will turn off, which will then depower various key safety systems including but not limited to air bags, power steering, and power braking. loss of functionality of these systems may increase the risk of crash and/or increase the risk of injury in the event of a crash.
Correction:
Chrysler will notify owners, and dealers will replace the ignition switch, free of charge. chrysler sent interim notifications to owners in september 2014. the recall began on october 9, 2015. owners may contact chrysler customer service at 1-800-853-1403. chrysler's number for this recall is p41.
Notes:
Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.

2005 JEEP GRAND CHEROKEE TSBs (82)

Bulletin:
2100903
Component:
103000 power train:automatic transmission
Summary:
Automatic transmission diagnostic teardown procedure. various models including the 2004 ram truck, durango, sebring convertible, cherokee, vision, neon, and voyager. *tt *sc
Bulletin:
1800904
Component:
103100 power train:automatic transmission:control module (tcm, pcm)
Summary:
Generic powertrain control module (pcm) procedure. this bulletin supersedes bulletin 18-009-04 dated 03/02/2004. *tt
Bulletin:
0423
Component:
106000 power train:axle assembly
Summary:
Front and rear axle fast feedback program. warranty planning & administration (wpa). *tt
Bulletin:
0424
Component:
100000 power train
Summary:
All wheel drive a580 transmission fast feedback program. *tt
Bulletin:
0427
Component:
104000 power train:transfer case (4-wheel drive)
Summary:
New venture gear 140/245 transfer case fast feedback program. warranty planning & administration. *tt
Bulletin:
0901404
Component:
061000 engine and engine cooling:engine
Summary:
New oil filter splash guard for 3.7l engine. *tt
Bulletin:
2400604
Component:
353600 equipment:air conditioner
Summary:
Growl-like sound from a/c compressor due to expansion valve. *tt
Bulletin:
1900904
Component:
015200 steering:hydraulic power assist:hose, piping, and connections
Summary:
Whine-liking sound due to power steering pressure hose grounding. *tt
Bulletin:
0901504
Component:
061000 engine and engine cooling:engine
Summary:
Engine oil viscosity grades for 5.7l multiple displacement system (mds). *tt
Bulletin:
0804204
Component:
110000 electrical system
Summary:
Fog lamps may fail to turn off as intended upon exiting vehicle. *tt
Bulletin:
04029
Component:
160000 structure
Summary:
Structural dust cover bolt may contact oil pan. *tt
Bulletin:
04030
Component:
122000 exterior lighting:fog lights
Summary:
Fog lamps may fail to turn off as intended upon exiting vehicle. rapid response transmittal. *tt
Bulletin:
04031
Component:
015200 steering:hydraulic power assist:hose, piping, and connections
Summary:
Release clip not removed from power steering return hose clamps. *tt
Bulletin:
2100205
Component:
103000 power train:automatic transmission
Summary:
Transmission fluid may be wicking in the right front corner of the transmission oil pan area. *eh
Bulletin:
1800505
Component:
110000 electrical system
Summary:
False downstream oxygen sensor diagnostic trouble code. *eh
Bulletin:
0800305
Component:
110000 electrical system
Summary:
Erroneous diagnostic trouble code u1108 may occur if front control module is replaced on a traffic message channel equipped vehicle. *eh
Bulletin:
0800405
Component:
110000 electrical system
Summary:
Park assist system false object detected and erroneous diagnostic trouble codes. *eh
Bulletin:
E03
Component:
120000 exterior lighting
Summary:
The automatic smart beam headlamp system may not turn off the fog lamps as intended. this condition may be intermittent and could result in a run-down battery. customer satisfaction notification e03. reprogram fmc/fog lamps. *tt
Bulletin:
1800705
Component:
061000 engine and engine cooling:engine
Summary:
Improved driveability and erroneous diagnostic trouble codes (dtcs). *tt
Bulletin:
0801005
Component:
120000 exterior lighting
Summary:
Auto headlamp feature may fail to operate as desired. *tt
Bulletin:
1800905
Component:
061000 engine and engine cooling:engine
Summary:
Extreme cold temperature start improvement and erroneous diagnostic trouble code (dtc). *tt
Bulletin:
0801405
Component:
110000 electrical system
Summary:
Mopar accessory remote starter inoperative due to hood switch. *tt
Bulletin:
2100605
Component:
102000 power train:manual transmission
Summary:
Upon upshifting the 6-speed manual transmission into reverse, the customer may notice that reverse gear may not remain engaged. *tt
Bulletin:
1801205
Component:
061000 engine and engine cooling:engine
Summary:
Idle quality, a/c performance, and 3,900 rpm limit. *tt
Bulletin:
2301305
Component:
171100 latches/locks/linkages:doors:latch
Summary:
Door key cylinder may freeze and not turn in left front door exterior handle. *sc
Bulletin:
2100805
Component:
100000 power train
Summary:
Flash: nag1 transmission-improvements to 4-3-4 and garage shifts. *sc
Bulletin:
2100905
Component:
110000 electrical system
Summary:
Mil (malfunction indicator lamp) illumination for dtc's (diagnostic trouble codes) p0750, p0755, p0760, p0765, p0846, p0871 or p0841. 2004-2005 jeep cherokee and 2005 chrysler 300/magnum *sc
Bulletin:
0801505
Component:
103100 power train:automatic transmission:control module (tcm, pcm)
Summary:
Powertrain control module initialization. *sc
Bulletin:
0900105
Component:
060000 engine and engine cooling
Summary:
Cylinder head bolt re-torque procedure. gpop - issue review system. *tt
Bulletin:
2302405
Component:
162000 structure:body
Summary:
Squeak-like sound when outside door handle is used/pulled. *tt
Bulletin:
2101105
Component:
103000 power train:automatic transmission
Summary:
Nag1 (w5a580) transmission - shudder when torque converter clutch engages. *tt
Bulletin:
05002
Component:
060000 engine and engine cooling
Summary:
New water pump for 3.7l engine - no longer common with 4.7l. advanced service information #05-002. *tt
Bulletin:
0803005
Component:
110000 electrical system
Summary:
Front control module - disable rke horn chirp feature if fcm is replaced. *tt
Bulletin:
0802905
Component:
110000 electrical system
Summary:
Intermittent 4wd lamp illumination or malfunction indicator lamp due to diagnostic trouble code p0573 - brake switch #1 circuit high. *tt
Bulletin:
1900505
Component:
010000 steering
Summary:
Click-like sound on turns - possible cancel cam interference with turn signal. *tt
Bulletin:
2401005
Component:
353600 equipment:air conditioner
Summary:
Hvac automatic temperature control - comfort setting improvements. operator may experience comfort setting drift; comfort setting slow to change when adjusted and/or comfort setting increments too small. *tt
Bulletin:
0803605
Component:
103000 power train:automatic transmission
Summary:
Transmission in limp-in mode or malfunction indicator lamp on due to powertrain control module ground wire. *tt
Bulletin:
0803205
Component:
140000 air bags
Summary:
Daimlerchrysler corporation is now offering a passenger airbag deactivation wiring package. to include 2006 chrysler town and country and 300/touring. *tt
Bulletin:
7803405
Component:
061000 engine and engine cooling:engine
Summary:
Malfunction indicator lamp (mil) illumination due to diagnostic trouble codes (dtcs) p0420 or p0430. *tt
Bulletin:
1803305
Component:
061000 engine and engine cooling:engine
Summary:
Oil pressure warning light may illuminate. *tt
Bulletin:
0804605
Component:
110000 electrical system
Summary:
Generic scan tool - no communication with nag1 (w5a580) transmission module. *tt
Bulletin:
2101305
Component:
102000 power train:manual transmission
Summary:
Correct shift tower sealer application to prevent restriction of vent. *tt
Bulletin:
2401305
Component:
353600 equipment:air conditioner
Summary:
Air conditioning (a/c) cooling coil odor. *tt
Bulletin:
0700205
Component:
062000 engine and engine cooling:cooling system
Summary:
Hydraulic radiator cooling fan system diagnostic check chart aid. *tt
Bulletin:
2101505
Component:
100000 power train
Summary:
45rfe/545rfe trans - delayed engagement due to cooler return filter replacement. *sc
Bulletin:
2101605
Component:
100000 power train
Summary:
Rfe transmission - delayed engagement after an extended off period. *sc
Bulletin:
0804805
Component:
110000 electrical system
Summary:
Jeep service campaign: see document search button for owner letter. rear axle fluid may contaminate the differential mounted rear wheel speed sensor. *sc updated 3/17/09. csc letter was received. *pe
Bulletin:
2500105
Component:
063100 engine and engine cooling:exhaust system:emission control
Summary:
Malfunction indicator lamp due to diagnostic trouble code p0401-egr solenoid circuit negative deviation or system performance. *sc
Bulletin:
1900805
Component:
010000 steering
Summary:
Revised power steering system bleeding procedures. *sc
Bulletin:
1600105
Component:
105100 power train:driveline:universal joint
Summary:
High speed driveline vibration due to excess grease in rear propeller shaft joint. *ak
Bulletin:
1900905
Component:
015000 steering:hydraulic power assist system
Summary:
Cold temperature initial startup - power steering whine-like sound. *ak
Bulletin:
1803505
Component:
061000 engine and engine cooling:engine
Summary:
Flash:mil illumination at start-up due to dtc p2112 or p1521. *ak
Bulletin:
0806405
Component:
090000 fuel system, other
Summary:
Flash: fuel level indicator may momentarily drop to empty after refueling vehicle. *tt
Bulletin:
2200205
Component:
199000 tires:pressure monitoring and regulating systems
Summary:
Tire pressure monitor - system information. *tt
Bulletin:
1400106
Component:
090000 fuel system, other
Summary:
Loose fuel cap message or malfunction indicator lamp illumination for diagnostic trouble code p0457 - evap system - loose fuel cap. *tt
Bulletin:
2101705
Component:
100000 power train
Summary:
Flash: 42rle - improved hill climb capability in reverse or dtc's p1713 / p1776. *tt
Bulletin:
1800906
Component:
110000 electrical system
Summary:
Enhanced torque converter and glow plug operation or brake switch dtc p0504. *tt
Bulletin:
1800706
Component:
103100 power train:automatic transmission:control module (tcm, pcm)
Summary:
Generic powertrain control module (pcm) procedure. *ak
Bulletin:
1800806
Component:
103700 power train:automatic transmission:torque converter
Summary:
Flash: enhanced torque converter, glow plug, skim operation. *ak
Bulletin:
2100906
Component:
103000 power train:automatic transmission
Summary:
Malfunction indicator lamp (mil) illumination; a rattle-like sound from the torque converter; and intermittent torque converter lock and unlock when in lock-up mode. *tt
Bulletin:
1801806
Component:
110000 electrical system
Summary:
Flash: mil illumination at start-up due to dtc p2112 or p1521. *tt
Bulletin:
1800106
Component:
350000 equipment
Summary:
Starscan@/starmobile abort recovery procedures. *tt
Bulletin:
2101906
Component:
103000 power train:automatic transmission
Summary:
Idle rpm flare cold vehicle operation-revised transmission oil fill level. some vehicles may exhibit slight idle flare at launch. this may occur during cold 25 degrees to 43 degrees temperatures and is most noticeable after extended idling.
Bulletin:
2304006
Component:
980000 unknown or other
Summary:
Rear of sunroof glass is not flush to roof/sunroof will not close. *kb
Bulletin:
2100206
Component:
103000 power train:automatic transmission
Summary:
Flash 42rle - improved hill climb capability in reverse or diagnostic trouble codes (dtc) p1713/p1776. *kb
Bulletin:
0803006
Component:
103000 power train:automatic transmission
Summary:
Powertrain control module initialization. *kb
Bulletin:
2200406
Component:
199000 tires:pressure monitoring and regulating systems
Summary:
Tire pressure monitor system information. *kb
Bulletin:
0800107
Component:
140000 air bags
Summary:
Passenger air bag deactivation. *kb
Bulletin:
0900506
Component:
063200 engine and engine cooling:exhaust system:manifold/header/muffler/tail pipe
Summary:
This bulletin involves the replacement of mechanical clips for the intake manifold runner swirl valve linkage. *nj
Bulletin:
0900407
Component:
061000 engine and engine cooling:engine
Summary:
Engine cranks but will not start and applies to vehicles equipped with a 3.0l diesel engine. *nj
Bulletin:
0900507
Component:
061200 engine and engine cooling:engine:diesel
Summary:
3.0l diesel oil filter cap service. *nj
Bulletin:
2500108
Component:
063110 engine and engine cooling:exhaust system:emission control:crankcase (pcv)
Summary:
Positive crankcase ventilation (pcv) system freezes in extreme cold ambient temperatures -- involves installing revised pcv system components. *nj
Bulletin:
SB-18-014-09
Component:
103100 power train:automatic transmission:control module (tcm, pcm)
Summary:
Chrysler/jeep: flash: esp system may prematurely activate momentarily when negotiating a curve or mil illumination due to diagnostic trouble code p0340, p0344 or p0116. this involves selectively erasing and reprogramming the powertrain con
Bulletin:
CSN-P-73
Component:
104000 power train:transfer case (4-wheel drive)
Summary:
Fiat chrysler: tsb has an owner notification letter. select document search button below. when shifting out of current selected mode, final drive control module (fdcm) software causes service 4wd light to illuminate and switching out of
Bulletin:
RL108213A$
Component:
060000 engine and engine cooling
Summary:
Nag1 (5a580) valve body as per warranty bulletin d-13-22, please use r2108213a$ valve body for all warranty (w), mopar (m) and mopar vehicle protection (f) claims.~ assembly also includes filter (52108325aa) and gasket (52108332aa).~
Bulletin:
9002519
Component:
355200 equipment:other:owners/service/other manual
Summary:
82212076, 82203694 - fabric cleaner this "fabric cleaner" is not intended for sale in california, the otc states (connecticut, delaware, massachusetts, maine, new hampshire, new jersey, new york, pennsylvania, virginia, and washington dc
Bulletin:
N23050813
Component:
110000 electrical system
Summary:
New safety recall advanced communication ? n23050813 chrysler group llc (chrysler) announced a safety recall on certain 2005 - 2010 model year (wk) jeep grand cherokee and (xk) jeep commander vehicles equipped with a quadra-drive ii or qua
Bulletin:
9001199
Component:
110000 electrical system
Summary:
Part description: actuator motor
Bulletin:
08-069-14
Component:
110000 electrical system
Summary:
Uconnect hands free module fails to respond due to module lock up this bulletin involves replacing the hands free module (hfm) if required. the hfm fails to operate causing the uconnect hands free communications system to not respond when
Bulletin:
21-022-14
Component:
060000 engine (pws)
Summary:
4wd lamp illuminated and diagnostic trouble code c140f active in final drive control modules (fdcm) memory this bulletin involves verifying fdcm software level and then flash reprogramming of the fdcm with new software. customers may in
Bulletin:
21-022-14 REV. A
Component:
110000 electrical system
Summary:
4wd lamp illuminated and diagnostic trouble code c140f active in final drive control modules (fdcm) memory this bulletin involves verifying fdcm software level and then flash reprogramming of the fdcm with new software. customers may ind
Bulletin:
18-042-14
Component:
103100 power train:automatic transmission:control module (tcm, pcm)
Summary:
Generic powertrain control module (pcm) procedure this bulletin involves programming a generic pcm with software.

Home | Privacy