2005 INFINITI QX56 Recalls (4)

Campaign:
08V284000 on 06/26/2008
Component:
Equipment:air conditioner
Manufactured:
03/16/2005 - 08/20/2006
Affected:
180,664
Defect:
Nissan is recalling 180,664 my 2005-2006 titan, armada and infinity qx56 vehicles manufactured after march 17, 2005, that are equipped with a visteon air conditioning condenser fan motor. the fan motor may not be properly sealed allowing excessive water intrusion and inadequate drainage of moisture.
Consequence:
This could cause corrosion in the motor leading possibly to overheating and a fire.
Correction:
Dealers will install a 'thermal protector kit' and test the air conditioning condenser fan motor and replace it if necessary. the recall began on august 2, 2008. owners may contact nissan at 1-800-647-7261.
Notes:
Customers may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov.
Campaign:
10V074000 on 03/02/2010
Component:
Fuel system, other:storage:fuel gauge system
Affected:
340,000
Defect:
Nissan is recalling certain model year 2005-2009 titan, armada, and infiniti qx56 vehicles. the instrument panel fuel gauge may inaccurately display that the vehicle still has some fuel, typically about one quarter tank, when the fuel tank is empty.
Consequence:
This could cause the vehicle to run out of gas and stall on the highway, which could cause a crash.
Correction:
Dealers will replace the fuel sender unit inside the fuel tank with a new improved sender card. this service will be performed free of charge. the safety recall began on march 22, 2010. owners may contact nissan at 1-800-647-7261.
Notes:
Owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to <a href=http://www.safercar.gov>http://www.safercar.gov</a> .
Campaign:
10E019000 on 05/20/2010
Component:
Suspension:front:control arm:lower arm
Affected:
1,873
Defect:
Nissan is recalling certain front and rear lower links, p/nos. 54501zq00a, 54500zq00a, 551a1zq00a, 551a0zq00a , 54501ea00a, 54500ea00a, 551a1ea500, 551a0ea500, 54501zr00a, and 54500zr00a, sold between november 25, 2009 and may 14, 2010 as replacement parts for model year 2004 through 2010 titan, armada, and qx56, and model years 2005 through 2010 frontier, xterra, and pathfinder vehicles. the lower control link assembly has two cylindrical collars forming the inboard attachment points to the chassis. due to an improper welding process some collars may contain welds that do not meet strength specifications.
Consequence:
If the collar weld separates, the vehicle handling will deteriorate, possibly resulting in a vehicle crash.
Correction:
Nissan will notify owners and dealers will replace any affected lower link free of charge. the safety recall began on july 12, 2010. owners may contact nissan at 1-800-647-7261.
Notes:
Owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to <a href=http://www.safercar.gov>http://www.safercar.gov</a> .
Campaign:
10V517000 on 10/27/2010
Component:
Engine and engine cooling
Manufactured:
12/10/2003 - 02/01/2006
Affected:
747,480
Defect:
Nissan is recalling certain model year 2004-2006 armada, titan, infiniti qx56 and model year 2005-2006 frontier, pathfinder and xterra vehicles. the intelligent power distribution module (ipdm) assembly contains an engine control module (ecm) relay that has a diode for electrical current noise reduction. the ecm relay may allow silicon vapor to form and, over time, the silicon evaporates from the diode molding which causes silicon oxide to develop on the ecm relay contact due to arcing.
Consequence:
This could cause engine stalling increasing the risk of a crash.
Correction:
Dealers will replace the ecm relay inside the ipdm assembly. this service will be performed free of charge. the safety recall began on december 6, 2010. owners may contact nissan at 1-800-647-7261.
Notes:
Owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to <a href=http://www.safercar.gov>http://www.safercar.gov</a> .

2005 INFINITI QX56 TSBs (49)

Bulletin:
03056A
Component:
046300 service brakes, air:antilock:wheel speed sensor
Summary:
Essential tool j-45741-inf abs active wheel sensor checker. *tt
Bulletin:
04041A
Component:
162000 structure:body
Summary:
Overhead roof console cracked. *tt
Bulletin:
05012
Component:
010000 steering
Summary:
Easy entry exit function inoperative steering wheel and seat don't return to auto drive position. *eh
Bulletin:
05014
Component:
181000 vehicle speed control:accelerator pedal
Summary:
Brake pedal feel - pedal height adjustment. *tt
Bulletin:
05015
Component:
103600 power train:automatic transmission:cooling unit and lines
Summary:
Atf is leaking from a transmission air cooler line. *tt update *sc
Bulletin:
04026D
Component:
030000 service brakes, hydraulic
Summary:
Brake judder. *sc
Bulletin:
05054
Component:
110000 electrical system
Summary:
Voluntary service campaign body control module sub-harness. enhanced electronic circuitry which may help further protect a vehicle from damage or fire caused by a short circuit in the electrical system of a towed trailer. *tt
Bulletin:
05059
Component:
062200 engine and engine cooling:cooling system:fan
Summary:
Rattle from condenser fan mount. *tt
Bulletin:
04061
Component:
110000 electrical system
Summary:
Engine will not crank and/or start and/or transmission improper operation. *tt
Bulletin:
06004
Component:
061000 engine and engine cooling:engine
Summary:
Malfunction indicator lamp with diagnostic trouble code u1000 or u1010 stored in engine control unit. 2002 - 2006 infiniti vehicles with can communication. *ak
Bulletin:
06007
Component:
030000 service brakes, hydraulic
Summary:
Groan noise from front brakes. *tt
Bulletin:
06011
Component:
036400 service brakes, hydraulic:antilock:abs warning light
Summary:
Abs and/or brake warning light on with dtc c1179. *tt
Bulletin:
03031
Component:
120000 exterior lighting
Summary:
Exterior lamp fogging. *kb
Bulletin:
07023
Component:
061000 engine and engine cooling:engine
Summary:
Low power with wide open throttle. *kb
Bulletin:
05060
Component:
203000 wheels:lugs/nuts/bolts
Summary:
Cam bolts for front wheel alignment. *kb
Bulletin:
ITB08-022
Component:
103000 power train:automatic transmission
Summary:
Infiniti; special automatic transmission fluid requirement. 2004 to current infinit vehicles. *nj
Bulletin:
ITB08-031
Component:
220000 seats
Summary:
Seat back board removal/installation. *nj
Bulletin:
ITB08-024A
Component:
141100 air bags:frontal:sensor/control module
Summary:
Srs precautions during service; incorrect removal and installation of the srs, can lead to a serious injury or death caused by unintentional activation of the srs on all infiniti models with the srs systems. *pe
Bulletin:
ITB-09-020
Component:
111000 electrical system:battery
Summary:
Infiniti: electronic control unit damage can result from improper battery connection. the battery is required to stay connected when the engine is running. no model years listed. *pe
Bulletin:
ITB-09-050
Component:
199000 tires:pressure monitoring and regulating systems
Summary:
Infiniti: tire pressure monitoring system (tpms) warning light on/blinking. no models or model years listed. *pe updated on 08-11-2011. *kb
Bulletin:
ITB-03-051-C
Component:
120000 exterior lighting
Summary:
Infiniti: exterior lamp fogging. water in the exterior lamps. this is generally not due to a defect. all current exterior lamp assemblies are vented to the atmosphere (not sealed). moisture in the air sometimes travels into and out of
Bulletin:
ITB-08-024A
Component:
140000 air bags
Summary:
Infiniti: srs precautions during service. included in the restraints section of the electronic service manual (esm) for each vehicle is information necessary to service the supplemental restraint system (srs) safely. improper maintenanc
Bulletin:
ITB-09-062
Component:
355200 equipment:other:owners/service/other manual
Summary:
Infiniti: vent control valve replacement. no applied vehicles affected: all models; no model years listed. *pe
Bulletin:
ITB-10-025
Component:
110000 electrical system
Summary:
Infiniti: the propeller shaft u joint (journal/journal bearings) is the source of noise and/or vibration on an applied vehicle. diagnose by evaluating the u joint with the propeller shaft removed. *pe
Bulletin:
ITB-04-051B
Component:
022520 suspension:rear:axle:non-powered axle assembly
Summary:
Infiniti: clicking noise from rear axles during take-off/acceleration. *pe updated 11/2/11. *pe
Bulletin:
ITB-08-044B
Component:
091200 fuel system, other:storage:fuel gauge system
Summary:
Infiniti: fuel gauge does not read full, is slow to respond, or is inaccurate. *pe
Bulletin:
ITB-10-027
Component:
121000 exterior lighting:headlights
Summary:
Infiniti: a xenon headlamp is not functioning because of an issue inside the headlamp assembly (an internal issue). refer to the appropriate service manual, follow the diagnostic and repair information for xenon headlamps. *pe
Bulletin:
ITB-01-003B
Component:
151000 seat belts:front
Summary:
Infiniti: d ring residue can cause slow seat belt retraction. seat belt retraction of the front seat belt(s) is slow, caused by residue build up on the d rings. models fx35/fx45(03-08); g35 coupe(03-07); g35(03-06); i30/i35 (00-04); q45(
Bulletin:
ITB-10-006A
Component:
102000 power train:manual transmission
Summary:
Infiniti: 5 speed a/t dtc diagnoses for p1701, p1702, p1703, p1704, p1705, p1754, p1759, p1764, p1769, p1774. applies to re 5r05a only transmissions (5 speed a/t). if one or more dtcs listed are found stored in self diagnosis, use the
Bulletin:
ITB-10-035A
Component:
021000 suspension:front
Summary:
Infiniti: front suspension noise. a noise (clunking, squeaking, popping) can be heard when performing at least one of the following actions-turning steering wheel left/right; driving over speed bumps; driving on rough roads; accelerating/
Bulletin:
ITB-12-014
Component:
016000 steering:electric power assist system
Summary:
Infiniti: power steering hose service part change. the hose now comes without the pressure sensor. if only pressure sensor needs replacement do not replace any hoses. *js
Bulletin:
ITB12-018
Component:
116200 electrical system:ignition:module
Summary:
Infiniti: the electronic control module (ecm) needs to be replaced on a 2004 my and later vehicle. *js
Bulletin:
ITB-11-049-B
Component:
118000 electrical system: software
Summary:
Infiniti: reprogramming electronic control unit (ecu) on all qualifying vehicles. no models listed. model years 1998-2013. *pe
Bulletin:
IPSB-12-051
Component:
147000 air bags: alleged counterfeit air bag
Summary:
Infiniti: information is being provided regarding consumer alert on dangers of counterfeit air bags, not made to standards of durability, reliability and quality, being installed, or used, in vehicles, that are a potential safety issue in
Bulletin:
ITB-13-12
Component:
170000 latches/locks/linkages
Summary:
Infiniti: lock/unlock request button on outside door handle outside door handle does not respond. lock/unlock request button located on outside door handles of vehicles can be disabled (or enabled) through either the "comfort & conv" setti
Bulletin:
ITB17-018
Component:
021520 suspension:front:control arm:upper ball joint
Summary:
Ball joint axial end play procedure service information when working on the front suspension, use the updated service information in this bulletin along with the electronic service manual (esm). the updated information in this bulletin
Bulletin:
ITB17-026
Component:
071100 fuel system, gasoline:storage:tank assembly
Summary:
Infiniti; fuel tank is slow or difficult to fill if you confirm the fuel tank is slow or difficult to fill (filling nozzle shuts off before tank is full). important: make sure this incident has been duplicated at a gas station by deale
Bulletin:
ITB17-042a
Component:
063130 engine and engine cooling:exhaust system:emission control:gas recirculation valve (egr valve)
Summary:
Infiniti; dtc p0456 caused by evap leak at vent control valve o-ring this bulletin has been amended. the applied vehicles and claims information sections have been revised. no other changes have been made. please discard previous version
Bulletin:
ITB09-015h
Component:
111000 electrical system:battery
Summary:
12 volt battery storage and maintenance for new vehicles in retailer inventory this bulletin has been amended throughout. please discard all previous versions of this bulletin.
Bulletin:
ITB00-024g
Component:
030000 brakes (pws)
Summary:
Brake noise/judder/pedal feel diagnosis and repair this bulletin has been amended to include vehicles built up to the publication date. also, tips for using the procut? brake lathe were added on page 8, and a brake noise diagnostic works
Bulletin:
ITB09-039e
Component:
131000 visibility:windshield
Summary:
Windshield cracking this bulletin has been amended to apply to the latest models and model years. also, warranty information on pages 1 and 8 has been updated. no other changes have been made. please discard previous versions of this bul
Bulletin:
ITB17-009a
Component:
132000 visibility:glass, side/rear
Summary:
Window glass warranty information this bulletin has been amended to apply to the latest models and model years, and warranty information on page 2 has been updated. no other changes have been made. please discard previous versions of thi
Bulletin:
ITB18-003
Component:
355100 equipment:other:labels
Summary:
Reduced vehicle load capacity label (regulatory requirement) this bulletin applies to vehicles equipped with dealer installed or vpc installed accessories. service information the national highway traffic safety administration (nhtsa
Bulletin:
IPSB17-130
Component:
350000 equipment
Summary:
Dbs enhancement: custom vin campaign report infiniti is pleased to announce the availability of a new dbs enhancement to the service > campaign screen: custom vin campaign report. the tool identifies open campaigns on a customized vin li
Bulletin:
ITB10-058b
Component:
060000 engine and engine cooling
Summary:
2004-2018 qx56 and qx80; engine oil leak at right side block ball plug this bulletin has been amended. the applied vehicles section has been updated. no other changes have been made. please discard all previous versions of this bulletin.
Bulletin:
ITB17-026a
Component:
070000 fuel system, gasoline
Summary:
Infiniti; fuel tank is extremely difficult to fill if customer reports: customer routinely experiences difficulty fueling the vehicle at different fuel stations (filling nozzle shuts off every few seconds while filling at multiple stati
Bulletin:
Revision 1-IEVAP
Component:
063100 engine and engine cooling:exhaust system:emission control
Summary:
Obd ii evap tube warranty enhancement update august 17, 2018 please discard earlier versions of this bulletin the announcement from march 21, 2017 has been revised to include: o clarification that the refueling concern is extremely ha
Bulletin:
Revision 1-NEVAP
Component:
063100 engine and engine cooling:exhaust system:emission control
Summary:
Obd ii evap tube warranty enhancement update august 17, 2018 please discard earlier versions of this bulletin. the announcement from march 21, 2017 has been revised to include: - clarification that the refueling concern is extremely h
Bulletin:
IPSB18-218 Retai
Component:
350000 equipment
Summary:
Dbs enhancement: retailed vehicle open campaign report infiniti announced the availability of a new dbs enhancement tool to the service > campaign screen: retailed vehicle open campaign report on july 9, 2018, which identifies owner cont

Home | Privacy