2005 HYUNDAI TIBURON Recall
- Campaign:
- 05V187000 on 04/28/2005
- Component:
- Steering:linkages:tie rod assembly
- Manufactured:
- 02/21/2005 - 03/26/2005
- Affected:
- 277
- Defect:
- Certain passenger vehicles may have been built with threaded portions of the steering gearbox assembly's left and right inner ball joint assemblies that contain internal cracks in the material structure.
- Consequence:
- If the inner ball joint assembly was to break as a result of the internal crack, the tie rod end assembly would not longer be attached to the steering gear box. this would prevent steering control of that front wheel by the separated tie rod which could result in a crash.
- Correction:
- Dealers will replace the steering gearbox assemblies on these vehicles free of charge. owners were contacted by telephone beginning on april 8, 2005, and instructed not to drive their vehicles. hyundai will arrange to pick up and return their vehicles after repair. owners may contact hyundai at 1-800-633-5151.
- Notes:
- Hyundai recall no. 069.customers may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov.
2005 HYUNDAI TIBURON TSBs (11)
- Bulletin:
- 0540008
- Component:
- 103000 power train:automatic transmission
- Summary:
- Automatic transaxle diagnostic trouble codes list. *sc
- Bulletin:
- 0550001
- Component:
- 020000 suspension
- Summary:
- Four wheel alignment-ez cam xr camber angle adjusting bolts. *sc
- Bulletin:
- 0540004
- Component:
- 106000 power train:axle assembly
- Summary:
- Resetting automatic transaxle adaptive values. *sc automatic transaxle control module - reset and relearn adaptive values. *tt
- Bulletin:
- 0450013
- Component:
- 200000 wheels
- Summary:
- Wheel alignment specifications. *tt
- Bulletin:
- 0540015
- Component:
- 103100 power train:automatic transmission:control module (tcm, pcm)
- Summary:
- Reprogramming instructions for diagnostic trouble code (dtc) p0736. check engine light illuminated and dtc p0736 (reverse gear incorrect ratio) stored. *tt
- Bulletin:
- 01011901
- Component:
- 110000 electrical system
- Summary:
- Automatic transaxle diagnostic trouble codes list. *nm
- Bulletin:
- 158
- Component:
- 106000 power train:axle assembly
- Summary:
- Reprograms are available for automatic transaxle driveability issues. technet times. hyundai. *tt
- Bulletin:
- 0640018
- Component:
- 106000 power train:axle assembly
- Summary:
- Automatic transaxle diagnostic trouble codes (dtc) list. *kb
- Bulletin:
- TSB-09-AT-013
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Hyundai: automatic transaxle range switch diagnostic trouble codes p0705 (range switch signal problems), p0707 (range switch open circuit), and p0708 (range switch short circuit or multiple inputs). an improperly adjusted or improperly op
- Bulletin:
- TSB-09-AT-018
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Hyundai: ata solenoid diagnostic trouble codes p0740, p0741, p0742, p0743, p0746, p0748, p0750, p0755, p0760, p0765, p0770. incorrect operation of the transaxle solenoids may result in the following symptoms-check engine light illuminated
- Bulletin:
- 5NP-B6E2P-10
- Component:
- 103100 power train:automatic transmission:control module (tcm, pcm)
- Summary:
- "the pcm or tcm contains logic to adjust solenoid duty and line pressure as needed to compensate for normal clutch wear over the life of the transaxle. this bulletin provides the procedures necessary to reset (erase) and relearn the pcm/tcm
Home | Privacy