2005 FORD F-250 SD Recalls (5)

Campaign:
05V266000 on 06/08/2005
Component:
Fuel system, gasoline:delivery:hoses, lines/piping, and fittings
Manufactured:
07/31/2004 - 05/08/2005
Affected:
78,675
Defect:
On certain pickup trucks and chassis cab vehicles equipped with 5.4l or 6.8l gasoline engines, the fuel jumper line may have an incorrect end form.
Consequence:
The fuel line may separate at the connection to the main fuel bundle. if the fuel line separates, an operator may notice a gasoline odor and/or fuel on the ground, loss of power, and the engine will eventually stall. fuel leakage in the presence of an ignition source could result in a fire.
Correction:
Dealers will install an external retention clip at the fuel jumper line to the main fuel bundle connection. the recall began on june 20, 2005. owners may contact ford at 1-800-392-3673.
Notes:
Ford recall no. 05s33.customers may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov.
Campaign:
05V270000 on 06/09/2005
Component:
Electrical system:wiring
Manufactured:
09/28/2003 - 05/30/2004
Affected:
180,104
Defect:
Certain pickup trucks, sport utility vehicles and vans equipped with 6.0l diesel engines may experience stalling without warning while driving and may or may not restart.
Consequence:
Should the engine stall, a vehicle crash could occur.
Correction:
Dealers will upgrade the fuel injection control module (ficm) wire harness or replaced, and/or have a new injection control pressure (icp)) sensor connector installed free of charge. the recall began on july 22, 2005. owners may contact ford at 1-800-392-3673.
Notes:
Ford recall no. 05s34.customers may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov.
Campaign:
08E026000 on 03/30/2008
Component:
Equipment
Affected:
338
Defect:
Truxxx is recalling 338 aftermarket replacement welded 3" lift blocks for rear suspensions, part no. 206073, included in suspension kit nos. 108035 and 108036, sold between july 26, 2007 and march 4, 2008, for use on ford my 2005-2008 f-250 superduty 4x4 light trucks. compressive forces of the welded lift blocks resulting from foreseeable and excess vehicle payloads as well as over-tightening of the u-bolts during installation may distort the blocks, reducing the intended clamping force of the u-bolts.
Consequence:
This could allow possible shifting and damage to the rear drive shaft and axle.
Correction:
Truxxx will notify customers/installers and will replace affected welded lift blocks with either non-welded aluminum or cast iron blocks free of charge. the recall is expected to begin on or about april 16, 2008. owners may contact truxxx at 1-800-381-8320.
Notes:
Truxxx recall no. 08-01blk.this recall only pertains to aftermarket suspension kits and has not relation to any original equipment installed on ford motor company vehicles.customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.
Campaign:
11V352000 on 07/12/2011
Component:
Exterior lighting:tail lights
Affected:
26,715
Defect:
Ford is recalling certain model year 2011 ranger trucks built from january 25, 2011, through april 25, 2011 at the twin cities assembly plant, and service parts distributed to dealers for certain 2004 through 2011 model year ranger trucks, 2002 through 2005 model year excursion vehicles, and 2002 through 2007 model year f-250, f-350, f-450, and f-550 trucks for failing to comply with the requirements of federal motor vehicle safety standard no. 108, "lamps, reflective devices, and associated equipment." the multi-function switch was shipped with a subcomponent (slider) that may experience deformation. a multi-function switch with a deformed slider may malfunction causing the turn signal, tail lights, hazard warning signal flashers and/or brake lights not to activate.
Consequence:
Non-functioning lights could increase the risk of a crash.
Correction:
Dealers will replace the switches free of charge. the safety recall began on august 15, 2011. owners may contact ford motor company customer relationship center at 1-866-436-7332.
Notes:
Ford's safety recall no. 11c18.owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to <a href=http://www.safercar.gov>http://www.safercar.gov</a> .
Campaign:
11V352000 on 07/12/2011
Component:
Exterior lighting:brake lights
Affected:
26,715
Defect:
Ford is recalling certain model year 2011 ranger trucks built from january 25, 2011, through april 25, 2011 at the twin cities assembly plant, and service parts distributed to dealers for certain 2004 through 2011 model year ranger trucks, 2002 through 2005 model year excursion vehicles, and 2002 through 2007 model year f-250, f-350, f-450, and f-550 trucks for failing to comply with the requirements of federal motor vehicle safety standard no. 108, "lamps, reflective devices, and associated equipment." the multi-function switch was shipped with a subcomponent (slider) that may experience deformation. a multi-function switch with a deformed slider may malfunction causing the turn signal, tail lights, hazard warning signal flashers and/or brake lights not to activate.
Consequence:
Non-functioning lights could increase the risk of a crash.
Correction:
Dealers will replace the switches free of charge. the safety recall began on august 15, 2011. owners may contact ford motor company customer relationship center at 1-866-436-7332.
Notes:
Ford's safety recall no. 11c18.owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to <a href=http://www.safercar.gov>http://www.safercar.gov</a> .

2005 FORD F-250 SD TSBs (138)

Bulletin:
17467
Component:
080000 fuel system, diesel
Summary:
Engine or fuel system concerns when using fuel with greater than 5% biodiesel concentration. *tt
Bulletin:
17406
Component:
061000 engine and engine cooling:engine
Summary:
Low power, poor fuel economy, fuel gelling cold, excessive white smoke cold, or hard start. *mj this oasis updates previous oasis dated 12/01/03. *tt
Bulletin:
04194
Component:
110000 electrical system
Summary:
Water-in-fuel (wif) lamp. *tt
Bulletin:
031404
Component:
061000 engine and engine cooling:engine
Summary:
Engine misfire or running - coil on plug (cop) ignition systems - wds cop kit diagnostic tips. to include various 2005 models. * ar this article 04161 supersedes tsb 03-14-04.
Bulletin:
18020
Component:
010000 steering
Summary:
Steering system noise. moan/grunt noise from the power steering when turning the steering wheel. *tt 2005 model added. *tt
Bulletin:
18069
Component:
061120 engine and engine cooling:engine:gasoline:turbo-charger
Summary:
Low power and/or diagnostic trouble code p0299 or p2263 - turbocharger diagnostic service tip. *tt
Bulletin:
18160
Component:
062000 engine and engine cooling:cooling system
Summary:
Temperature gauge reading at the top of the normal band (green) or bottom of the hot band (red) when engine operating temperature is actually within the normal range. *tt
Bulletin:
18170
Component:
020000 suspension
Summary:
Tire vibration from flat spotting. *tt
Bulletin:
0536
Component:
104000 power train:transfer case (4-wheel drive)
Summary:
4x4 transfer case jump out of 4th or 4l - manual shift transfer case. *tt
Bulletin:
18397
Component:
061000 engine and engine cooling:engine
Summary:
Lack of power, surge, and/or diagnostic trouble codes p2263 or p0299. *tt
Bulletin:
18406
Component:
162000 structure:body
Summary:
Service tips before arc welding on the frame or body of a unit. *tt
Bulletin:
02219
Component:
115000 electrical system:fuses and circuit breakers
Summary:
Adding additional bulbs to turn indicator or hazard flasher circuits - service tips. *tt
Bulletin:
0512
Component:
060000 engine and engine cooling
Summary:
Temperature gauge reads hot. *tt
Bulletin:
18367
Component:
110000 electrical system
Summary:
Message in the instrument cluster message center reading trailer fault. *tt
Bulletin:
18370
Component:
220000 seats
Summary:
Passenger seat slightly tilted. *tt
Bulletin:
18371
Component:
100000 power train
Summary:
Reverse shudder, loss of reverse and transmission fluid leakage (all gas models, and 6.0l diesels built before 12/13/2004). *tt
Bulletin:
18376
Component:
103000 power train:automatic transmission
Summary:
A cold weather reverse engagement stall. *tt
Bulletin:
18387
Component:
110000 electrical system
Summary:
Speedometer needle bounce, cruise control drop out, diagnostic trouble code p0500, and/or uncommanded wiper activation - service tip. *tt
Bulletin:
18393
Component:
021000 suspension:front
Summary:
Front end bottoms out - hits jounce bumpers. *tt
Bulletin:
04217
Component:
103100 power train:automatic transmission:control module (tcm, pcm)
Summary:
General power train control module (pcm) programming procedures. *tt
Bulletin:
04221
Component:
060000 engine and engine cooling
Summary:
Malfunction indicator lamp on with misfire dtc's spark knock piston scuffing. *eh vehicles built through 4/25/2005 - 5.4l 3v engine. *tt
Bulletin:
04227
Component:
100000 power train
Summary:
Drive away shudder or vibration. *eh
Bulletin:
04239
Component:
162900 structure:body:roof and pillars
Summary:
Water leak - roof flange area - water accumulation in headliner and/or leak at the cab floor pan area. *tt
Bulletin:
04236
Component:
020000 suspension
Summary:
Vehicle lean sag when observed from rear of vehicle. *eh
Bulletin:
18306
Component:
061000 engine and engine cooling:engine
Summary:
Oil leak at the engine oil cooler/oil filter housing - o-ring available for service. *tt
Bulletin:
042107
Component:
103100 power train:automatic transmission:control module (tcm, pcm)
Summary:
General (pcm) power train control module programming procedures. *tt
Bulletin:
042421
Component:
151300 seat belts:front:retractor
Summary:
Safety belt retraction speed. *tt
Bulletin:
042518
Component:
061000 engine and engine cooling:engine
Summary:
Crank no start, hard start, runs rough at idle - 6.0l engine. *tt *sc
Bulletin:
04261
Component:
010000 steering
Summary:
Steering wheel oscillation (back and forth motion) after riding over bumps/ruts. *tt
Bulletin:
04266
Component:
105000 power train:driveline
Summary:
A driveline clunk or bump when starting from a stop. *tt
Bulletin:
042616
Component:
160000 structure
Summary:
Weld bonding procedure. *tt
Bulletin:
0544
Component:
061000 engine and engine cooling:engine
Summary:
6.0 engine overheating with a snow plow installed on vehicles without the factory installed snow plow package. *tt
Bulletin:
04262
Component:
342000 communications:back up alarm
Summary:
False parking aid warnings. *tt update. *tt
Bulletin:
0557
Component:
110000 electrical system
Summary:
Low battery voltage - snow plow equipped vehicles - 6.0l diesel with single generator. *tt
Bulletin:
05121
Component:
100000 power train
Summary:
Engine quits upon drive or reverse engagement, or when coming to a stop-torqshift transmission. *sc
Bulletin:
05134
Component:
061000 engine and engine cooling:engine
Summary:
Hard start/long crank, rough idle, engine idle misfire-mil-dtcs p0300 through p0308, p0171, p0172, p0174, p0175, p0316, p2195, p2196, p2197, p2198. *sc
Bulletin:
05148
Component:
060000 engine and engine cooling
Summary:
Low power-cold side charge air cooler (cac) disconnected-oil leak at cac connections-6.0l-vehicles built 4/1/2004 through 2/15/2005. *sc
Bulletin:
05114
Component:
061200 engine and engine cooling:engine:diesel
Summary:
Various driveability symptoms-calibration update release-6.0 diesel engine. *sc
Bulletin:
05139
Component:
061200 engine and engine cooling:engine:diesel
Summary:
Diesel exhaust smell in cab-6.0l engine. *sc
Bulletin:
05132
Component:
061000 engine and engine cooling:engine
Summary:
Diagnostic trouble code (dtc) p0340 and or p0344-5.4 3v engine. *sc
Bulletin:
05135
Component:
061200 engine and engine cooling:engine:diesel
Summary:
Oil leak or boost pressure leak at hot side charge air cooler (cac) duct-6.0l diesel engine. *sc
Bulletin:
051112
Component:
110000 electrical system
Summary:
Abs light on and possible dtcs c1175, c1236, p0500, p0503. *sc
Bulletin:
05149
Component:
353600 equipment:air conditioner
Summary:
Lack of air conditioning cooling - climate control mode selection not working. *tt
Bulletin:
05215
Component:
060000 engine and engine cooling
Summary:
Buck/jerk or surge - 6.0l vehicles built before 8/22/2005. *tt
Bulletin:
18877
Component:
030000 service brakes, hydraulic
Summary:
Trailer brake controller applications. *tt
Bulletin:
18884
Component:
060000 engine and engine cooling
Summary:
Hard start, no start and/or other symptoms caused by a high pressure oil system leak - service tip. *tt
Bulletin:
18735
Component:
121000 exterior lighting:headlights
Summary:
Headlight adjustment - chassis cab incomplete vehicles. *tt
Bulletin:
18749
Component:
060000 engine and engine cooling
Summary:
High pressure oil leak at an injector. a hard start, or no start condition with low or no injection control pressure (icp) - service tip. *tt
Bulletin:
18694
Component:
061120 engine and engine cooling:engine:gasoline:turbo-charger
Summary:
Lack of power and/or dtc p2263 or p0299 after turbocharger replacement - service tip. *tt
Bulletin:
18525
Component:
060000 engine and engine cooling
Summary:
Buck/jerk, lacks power, black smoke, rolling idle, surge, mil on, and diagnostic trouble codes p2263, p0299, or p0401. *tt
Bulletin:
18537
Component:
110000 electrical system
Summary:
The normal output voltage from the ford trailer brake controller on certain vehicles built after 3/23/05 has changed. *tt
Bulletin:
05613
Component:
013000 steering:gear box (other than rack and pinion)
Summary:
Steering gear noise - 6.0l diesel engine - vehicles built before 11/24/2004. *tt
Bulletin:
05419
Component:
342000 communications:back up alarm
Summary:
False parking aid warnings. *tt
Bulletin:
0592
Component:
021000 suspension:front
Summary:
Front suspension bottoming out (hitting the jounce bumpers) and/or making a banging/clunking noise when driving. *tt
Bulletin:
18593
Component:
060000 engine and engine cooling
Summary:
Front seal oil leak - misdiagnosed as oil pressure regulator oil leak. *tt
Bulletin:
18609
Component:
102000 power train:manual transmission
Summary:
Fluid leak from the hydraulic clutch system - repairs/service tip. *tt
Bulletin:
18635
Component:
060000 engine and engine cooling
Summary:
High pressure pump o-ring available for concern related to a high pressure system oil leak. *tt
Bulletin:
051511
Component:
110000 electrical system
Summary:
Diagnostic procedure for trailer tow lights or no power due to open fuse. *tt
Bulletin:
051018
Component:
015000 steering:hydraulic power assist system
Summary:
Steering gear noise. moan/grunt noise from the power steering when turning the steering wheel, especially during left turns. vehicles built prior to 11/24/2004 - 5.4l and 6.8l engine. *tt
Bulletin:
05188
Component:
136100 visibility:windshield wiper/washer:switch/wiring
Summary:
Service kit available for wiper motor wiring. *tt
Bulletin:
05186
Component:
103100 power train:automatic transmission:control module (tcm, pcm)
Summary:
Malfunction indicator lamp, diagnostic trouble codes p0172, p0175, p2106, hesitation, surge, harsh drive engagements. to include 2005-2006 f-53. *tt
Bulletin:
05182
Component:
103100 power train:automatic transmission:control module (tcm, pcm)
Summary:
Diagnostic trouble code p2106, harsh drive engagements, transmission shudder - 5.4l 3v engine. *tt
Bulletin:
051713
Component:
060000 engine and engine cooling
Summary:
Coolant degas bottle overflow. *tt
Bulletin:
05174
Component:
138000 visibility:defroster/defogger system
Summary:
Vacuum pump inoperative or runs continuously - climate control defaults to defrost mode. *tt
Bulletin:
18822
Component:
103000 power train:automatic transmission
Summary:
Torqshift transmission - intermittent clunk when shifting from reverse gear or drive gear to park. multiple vehicles. ford oasis. to include 2006 ford f-53. *tt
Bulletin:
05L26
Component:
063100 engine and engine cooling:exhaust system:emission control
Summary:
Special field action 05l26 - vehicle noise emission control information label installation. *tt
Bulletin:
42601
Component:
010000 steering
Summary:
Steering wheel oscillation (back and forth motion), immediately following front or rear wheel impacts (pavement joints, frost heaves, rough roads, etc). *tt
Bulletin:
041601
Component:
060000 engine and engine cooling
Summary:
Wds cop kit diagnostic tip - coil on plug (cop) ignition systems - engine misfire or rough running. *tt
Bulletin:
05252
Component:
210000 trailer hitches
Summary:
Neutral tow capability -- service kit requirements. *tt
Bulletin:
051015
Component:
061000 engine and engine cooling:engine
Summary:
5.4l 3v with p030x and/or p0316 accompanied by spark knock. *tt
Bulletin:
052624
Component:
190000 tires
Summary:
Vibration diagnosis - tire/wheel runout. *tt
Bulletin:
05249
Component:
062000 engine and engine cooling:cooling system
Summary:
Coolant degas bottle overflow. *tt
Bulletin:
05254
Component:
063000 engine and engine cooling:exhaust system
Summary:
Exhaust smoke and/or smell, harsh transmission shifts -- 6.0l. *tt
Bulletin:
052614
Component:
103100 power train:automatic transmission:control module (tcm, pcm)
Summary:
Service calibration update -- loss of rpm on deceleration -- 6.8l 3v. various models including 2006 f-53 motorhome. *tt
Bulletin:
052615
Component:
110000 electrical system
Summary:
Mil on with dtc p0460 -- 6.0l. *tt
Bulletin:
05B35
Component:
060000 engine and engine cooling
Summary:
Customer satisfaction program 05b35 - the engine control modules may not be calibrated to the latest software levels, adversely affecting the performance and reliability of the engine. *tt
Bulletin:
05B32
Component:
061200 engine and engine cooling:engine:diesel
Summary:
Customer satisfaction program 05b32 - de-gas bottle fill level label and fluid level adjustment.
Bulletin:
18999
Component:
046300 service brakes, air:antilock:wheel speed sensor
Summary:
Bearing & sensor assembly - abs sensor is available for service - base part number 2c204. *tt
Bulletin:
19015
Component:
090000 fuel system, other
Summary:
Fuel conditioner. low power, poor fuel economy, fuel gelling in cold weather, excessive white smoke on cold start, hard start, or coking of components exposed to exhaust. *tt
Bulletin:
052317
Component:
110000 electrical system
Summary:
Diagnostic trouble codes p0340/p0344/p0345/p0349 - 4.6l 3v and 5.4l 3v. *tt
Bulletin:
06213
Component:
060000 engine and engine cooling
Summary:
White smoke, lacks power, exhaust odor, surges, runs rough, or no start - 6.0l. *tt
Bulletin:
05255
Component:
061000 engine and engine cooling:engine
Summary:
5.4l 3v with p030x and/or p0316 accompanied by spark knock. *tt
Bulletin:
06311
Component:
102000 power train:manual transmission
Summary:
Buck/jerk steady throttle or slight tip in - 6.0l. *tt
Bulletin:
19099
Component:
117000 digital instrument panel
Summary:
P0404 service tip. *tt
Bulletin:
19082
Component:
110000 electrical system
Summary:
Lack of power or mil on - turbocharger sticking - revised diagnostics. *tt
Bulletin:
19062
Component:
190000 tires
Summary:
18 inch conti tr all-terrain tires. *tt
Bulletin:
0646
Component:
061000 engine and engine cooling:engine
Summary:
High pressure system diagnostics - 6.0l for a hard start/long crank or no start condition due to low injection control pressure (icp). *tt
Bulletin:
0645
Component:
100000 power train
Summary:
Neutral tow capability - service kit requirements. *tt
Bulletin:
052625
Component:
061000 engine and engine cooling:engine
Summary:
Misfire, lack of power, buck/jerk, excessive smoke or crank/no start. *tt
Bulletin:
06510
Component:
110000 electrical system
Summary:
6.0l - mil on with dtc p0460. *tt
Bulletin:
19245
Component:
061120 engine and engine cooling:engine:gasoline:turbo-charger
Summary:
Repeat turbocharger or vgt replacement. *tt
Bulletin:
06129
Component:
021600 suspension:front:wheel bearing
Summary:
Front wheel bearings - noise. *tt updated on 02-27-07. *kb
Bulletin:
062211
Component:
015300 steering:hydraulic power assist:power steering fluid
Summary:
Power steering fluid leak at jumper line to hydroboost connection. *kb
Bulletin:
06226
Component:
061000 engine and engine cooling:engine
Summary:
Buck/jerk steady throttle or slight tip in 6.0l. *kb
Bulletin:
061912
Component:
061000 engine and engine cooling:engine
Summary:
Diagnostic trouble codes (dtc) p0340, p0344, p0345, p0349. are found. *kb
Bulletin:
06152
Component:
061000 engine and engine cooling:engine
Summary:
Spark plug removal instructions - 5.4 3v. *kb
Bulletin:
061612
Component:
061000 engine and engine cooling:engine
Summary:
Service calibration update - loss of rpm on deceleration - 6.8l. *kb
Bulletin:
061811
Component:
061000 engine and engine cooling:engine
Summary:
Service calibration update - loss of rpm on deceleration - 6.8l. *kb updated 07-25-07. *kb
Bulletin:
19247
Component:
061000 engine and engine cooling:engine
Summary:
Oil flow from the base engine oil pump. *kb
Bulletin:
19375
Component:
061000 engine and engine cooling:engine
Summary:
Watch for oil flow from the base engine oil pump. vehicles equipped with a 6.0l diesel engine. *kb
Bulletin:
06151
Component:
011000 steering:wheel and handle bar
Summary:
Steering wheel oscillation. *kb
Bulletin:
06176
Component:
061200 engine and engine cooling:engine:diesel
Summary:
High pressure system diagnostics - 6.0l engines. *kb
Bulletin:
06171
Component:
061320 engine and engine cooling:engine:other fuel types:turbo-charger
Summary:
6.0l turbocharger carbon deposit diagnostics and service tips - lack of power, white or black smoke, surge, p0238, p0299, p0404, p2262, and/or p2263. *kb
Bulletin:
06239
Component:
061000 engine and engine cooling:engine
Summary:
Hesitation, runs rough, or surge either on acceleration or during idle in gear and occurs right after initial cold engine start up. *kb
Bulletin:
06229
Component:
061000 engine and engine cooling:engine
Summary:
6.0l - mil on with dtc p2138, p2139, and p2140. *kb
Bulletin:
0714
Component:
062200 engine and engine cooling:cooling system:fan
Summary:
Lack of cooling fan operation. *kb
Bulletin:
0727
Component:
061000 engine and engine cooling:engine
Summary:
6.0l - reduced engine performance - high altitude. *kb
Bulletin:
0754
Component:
061000 engine and engine cooling:engine
Summary:
Cold start driveability - white smoke, lacks power, exhaust odor, surges, runs, rough, or no start. *kb
Bulletin:
07515
Component:
061000 engine and engine cooling:engine
Summary:
6.0l oil seep or boost pressure leak at hot side charge air cooler duct. *kb
Bulletin:
06177
Component:
120000 exterior lighting
Summary:
Adding additional bulbs to turn indicator or hazard flasher circuits. *kb
Bulletin:
19614
Component:
061000 engine and engine cooling:engine
Summary:
Air filter water ingestion / snow packing with codes p0103. *kb
Bulletin:
19621
Component:
070000 fuel system, gasoline
Summary:
Lack of power due to low fuel pressure, fuel tank liner seperation. *kb
Bulletin:
0798
Component:
046400 service brakes, air:antilock:abs warning light
Summary:
Abs light on and possible c1175, c1236, p0500,p0503. *kb
Bulletin:
19521
Component:
061200 engine and engine cooling:engine:diesel
Summary:
Lack of power or lack of performance condition when operated above 5,000 feet of altitude. *kb
Bulletin:
19529
Component:
061200 engine and engine cooling:engine:diesel
Summary:
Misfire and dtc p0300. *kb
Bulletin:
19537
Component:
061200 engine and engine cooling:engine:diesel
Summary:
Misfire and dtc p0300. *kb
Bulletin:
19728
Component:
061200 engine and engine cooling:engine:diesel
Summary:
Lack of power due to low fuel pressure - fuel tank liner seperation. *kb
Bulletin:
0769
Component:
103100 power train:automatic transmission:control module (tcm, pcm)
Summary:
Buck/jerk when pulling large heavy gooseneck trailers. diesel engines. reprogramming the powertrain control module (pcm) with the latest calibration might solve the issue. *kb
Bulletin:
0772
Component:
022000 suspension:rear
Summary:
Rear of vehicle is too high/low -5th wheel and goose neck applications. *kb
Bulletin:
062401
Component:
061000 engine and engine cooling:engine
Summary:
6.0l diesel engine - oil leak or boost pressure leak at hot side charge air cooler duct. *kb
Bulletin:
07112
Component:
046400 service brakes, air:antilock:abs warning light
Summary:
Stuck or jumping/bouncing/erratic speedometer and/or tachometer. *nj
Bulletin:
071110
Component:
040000 service brakes, air
Summary:
Brake booster system may exhibit a brake pedal kickback and/or grabbing condition when applying the brakes. *nj
Bulletin:
19989
Component:
102000 power train:manual transmission
Summary:
2005-2008 f-super duty manual transmission- clutch pedal concern. *nj
Bulletin:
20052
Component:
104000 power train:transfer case (4-wheel drive)
Summary:
1999-2008 f250-f550 super duty 4x4 with electronic shift transfer case not engaging 4x4. *nj
Bulletin:
07219
Component:
063130 engine and engine cooling:exhaust system:emission control:gas recirculation valve (egr valve)
Summary:
6.0l--mil on--p0401, p0402, p0404, p1335--lack of power or surge with some 2003-2007 f-super duty, 2003-2005 excursion and 2004-2008 e-series vehicles. *nj
Bulletin:
07M08
Component:
073200 fuel system, gasoline:fuel injection system:injectors
Summary:
Ford\lincoln service campaign: see document search button for owner letter. customer satisfaction program 07m08: certain 2005 model year f-150, f-super duty, expedition, and navigator vehicles with 5.4l 3v engines-extended warranty covera
Bulletin:
08-2-11
Component:
061320 engine and engine cooling:engine:other fuel types:turbo-charger
Summary:
6.0l turbocharger carbon deposit diagnostics and service tips. *nj updated 5/29/08. *nj
Bulletin:
20228
Component:
061320 engine and engine cooling:engine:other fuel types:turbo-charger
Summary:
1999-2008 7.3l/6.0l/6.4l/4.5l diesel f-super duty - clean the charge air cooler (cac) system after certain turbo or engine failures - service tip. *nj
Bulletin:
20232
Component:
102000 power train:manual transmission
Summary:
2005-08 f250-550 super duty manual transmission - clutch pedal concern. *nj
Bulletin:
TSB-08-9-9
Component:
061200 engine and engine cooling:engine:diesel
Summary:
Ford: 6.0l diesel hard start/long crank/no start du to low injector control pressure (icp). ipe
Bulletin:
TSB-08-18-6
Component:
061200 engine and engine cooling:engine:diesel
Summary:
Ford truck: some trucks equipped with a 6.0l diesel engine may exhibit a hard start/long crank or no start condition due to low injection control pressure (icp). *pe
Bulletin:
LP-09L02
Component:
011000 steering:wheel and handle bar
Summary:
Ford trucks service campaign: see document search button for owner letter. vehicles have experienced severe steering wheel and front wheel vibrations and oscillations after traveling over a bump or dip in the road. models 2006 f-250/350 su
Bulletin:
TSB-09-20-12
Component:
061000 engine and engine cooling:engine
Summary:
Ford: some super duty trucks equipped with a 5.4l 3v or 6.8l 3v engine may experience premature automatic shut off of the fuel fill nozzle. *pe
Bulletin:
ASI-44404
Component:
061200 engine and engine cooling:engine:diesel
Summary:
Ford: on some trucks, there is a no crank situation and if voltage on transmission range sensor at pin 21, is less than 5 volts, disconnect the engine cooling fan clutch, electronically, and recheck voltage. model 2003-2007 f super duty,
Bulletin:
TSB-14-0114
Component:
060000 engine (pws)
Summary:
Lincoln/ford: when driving from idle up to 1200 rpm, there may be an intermittent rattle noise coming from engine. 2004-2013 f-150, f-250, f-350, expedition, mark lt, navigator. *pe
Bulletin:
ASI-44534
Component:
103000 power train:automatic transmission
Summary:
Ford: when shifting between park, reverse and/or during 2-3 shift, an intermittent clunk occurs with a torqshift transmission. model 2003-2014 f-super duty, e series, excursion, f-53 motorhome chassis, low cab forward. *p
Bulletin:
SSM 46345
Component:
350000 equipment
Summary:
Some 2005-2017 f-super duty 4x4 vehicles operated in extreme dust, mud or tar sand conditions may exhibit accelerated 4x4 vacuum hub seal and or wheel bearing wear as a result of harsh operating conditions. a knuckle seal shield kit is now
Bulletin:
DOR-B8H4Z-11
Component:
010000 steering
Summary:
This sku is a front upper ball joint. the customer communication requested return of unsold inventory to inspect for ball studs with excessive rotational friction in the ball joint assembly. excessive friction in the ball joint assembly ma

Home | Privacy