2005 CHRYSLER PACIFICA Recalls (2)

Campaign:
05V066000 on 03/02/2005
Component:
Exterior lighting:headlights
Manufactured:
06/30/2004 - 01/30/2005
Affected:
43,180
Defect:
Certain sport utility vehicles equipped with halogen headlamps may experience an intermittent and eventual total loss of headlamp function.
Consequence:
The head lights may not operate properly which could result in intermittent or no headlight function. this could impair a driver's visibility, increasing the risk of a crash.
Correction:
Dealers will inspect, and replace if necessary, the wiring harness and low beam bulb on both headlamp assemblies free of charge. the recall began on march 28, 2005. owners may contact daimlerchrysler at 1-800-853-1403.
Notes:
Daimlerchrysler recall no. e04.customers may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov.
Campaign:
06V432000 on 11/14/2006
Component:
Power train:automatic transmission:control module (tcm, pcm)
Manufactured:
07/07/2004 - 11/23/2005
Affected:
127,928
Defect:
On certain passenger vehicles, the fuel pump module and the power train control module (pcm) software may allow the engine to stall under certain operating conditions.
Consequence:
This could cause a crash to occur without prior warning.
Correction:
Dealers will reprogram the power train control module. the fuel pump module will also be replaced on vehicles built from august 1, 2004 through september 30, 2004. the recall began on november 21, 2006. owners may contact daimlerchrysler at 1-800-853-1403.
Notes:
Daimlerchrysler recall no. f44.customers may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov.

2005 CHRYSLER PACIFICA TSBs (67)

Bulletin:
2301703
Component:
162000 structure:body
Summary:
Front splash shield to fender rattle sound. *tt this bulletin supersedes bulletin 23-017-03, dated 06/13/2003. *tt
Bulletin:
1800604A
Component:
103100 power train:automatic transmission:control module (tcm, pcm)
Summary:
Generic powertrain control module (pcm) procedure. *tt *mj this bulletin supersedes bulletin 18-006-04a dated 04/06/2004. *tt
Bulletin:
0900404A
Component:
061000 engine and engine cooling:engine
Summary:
Accessory drive belt squeaking/chirping sound. *tt *mj this bulletin supersedes previous bulletin dated 05/25/04. *tt
Bulletin:
2301004
Component:
162000 structure:body
Summary:
Passenger compartment floor water leak. *tt this bulletin supersedes bulletin 23-010-04 dated 04-29-04. *tt
Bulletin:
2100804
Component:
110000 electrical system
Summary:
Malfunction indicator lamp (mil) illumination -diagnostic trouble code (dtc) p1776 solenoid switch valve latched in lr position. *mj this bulletin replaces 21-008-04 dated june 1, 2004. *tt
Bulletin:
0200404
Component:
020000 suspension
Summary:
Suspension/towing/lifting damage. *tt
Bulletin:
0300504
Component:
105500 power train:driveline:differential unit
Summary:
Rear axle seal weepage diagnosis. *mj
Bulletin:
0901304
Component:
061000 engine and engine cooling:engine
Summary:
Gasoline engine oil quality and viscosity grades. *tt
Bulletin:
0802904
Component:
221700 seats:front assembly:seat heater/cooler
Summary:
New heated seat control module available for service. *tt
Bulletin:
1803204
Component:
090000 fuel system, other
Summary:
Malfunction indicator lamp illumination diagnostic trouble code (dtc) p2066 fuel level sensor. *tt
Bulletin:
2303504
Component:
162000 structure:body
Summary:
Water in passenger compartment. *tt
Bulletin:
1900804
Component:
010000 steering
Summary:
In and out movement in steering column. *eh
Bulletin:
0200704
Component:
021000 suspension:front
Summary:
Low speed rattle/clunk sound from front suspension. *eh
Bulletin:
0803804
Component:
110000 electrical system
Summary:
Inoperative driver door switches. *tt
Bulletin:
2101104
Component:
100000 power train
Summary:
Power transfer unit (ptu) click/pop sound. *tt
Bulletin:
01011901
Component:
100000 power train
Summary:
Popping/clicking/snapping sound in front end. front half shaft and front hub assembly. gpop - issue review system. *tt
Bulletin:
04028
Component:
061110 engine and engine cooling:engine:gasoline:belts and associated pulleys
Summary:
Accessory drive belt squeaking/chirping sound. rapid response transmittal #04-028. *tt
Bulletin:
1901004
Component:
010000 steering
Summary:
Power steering fluid contamination. *tt
Bulletin:
1900105
Component:
010000 steering
Summary:
The steering wheel tilt mechanism is inoperative. *tt
Bulletin:
0800805
Component:
110000 electrical system
Summary:
1/1 o2 sensor usage. *tt
Bulletin:
0801405
Component:
110000 electrical system
Summary:
Mopar accessory remote starter inoperative due to hood switch. *tt
Bulletin:
1801005
Component:
061000 engine and engine cooling:engine
Summary:
Mil illumination diagnostic trouble codes (dtc) p0135 - o2 sensor 1/1 heater performance. *tt
Bulletin:
0801905
Component:
141100 air bags:frontal:sensor/control module
Summary:
Airbag control and or occupant classification module service. 2005 chrysler voyager. *sc
Bulletin:
0801505
Component:
103100 power train:automatic transmission:control module (tcm, pcm)
Summary:
Powertrain control module initialization. *sc
Bulletin:
05005
Component:
060000 engine and engine cooling
Summary:
Rapid response transmittal#05-005. malfunction indicator lamp illumination diagnostic trouble codes (dtc) p0135 - o2 sensor 1/1 heater performance. *sc
Bulletin:
2301405
Component:
160000 structure
Summary:
Dip or sag in the center of the instrument panel (ip) *sc
Bulletin:
10182004
Component:
110000 electrical system
Summary:
P0508 and p0509 diagnostic test callout the incorrect circuit ids for iac return circuit and iac motor control circuit. *eh
Bulletin:
0803105
Component:
221700 seats:front assembly:seat heater/cooler
Summary:
Flash: front heated seats do not get warm enough. *tt
Bulletin:
2303305
Component:
162300 structure:body:door
Summary:
Front door glass binds, sticks, and/or will not move due to the front door belt inner weatherstrip. *tt
Bulletin:
2303205
Component:
162300 structure:body:door
Summary:
Front door glass service procedure revision. *tt
Bulletin:
4851010
Component:
062100 engine and engine cooling:cooling system:radiator assembly
Summary:
Radiator hose replacement. 2005 chrysler-cs. *sc
Bulletin:
0803905
Component:
110000 electrical system
Summary:
Front power and/or memory seat inoperative. *tt
Bulletin:
2401305
Component:
353600 equipment:air conditioner
Summary:
Air conditioning (a/c) cooling coil odor. *tt
Bulletin:
0200405
Component:
021400 suspension:front:macpherson strut
Summary:
Creaking/squawking sound from front strut area. *tt
Bulletin:
1900805
Component:
010000 steering
Summary:
Revised power steering system bleeding procedures. *sc
Bulletin:
2305405
Component:
222000 seats:mid/rear assembly
Summary:
Second row bench seat latch will not release. *ak
Bulletin:
1804005
Component:
180000 vehicle speed control
Summary:
Flash - no start or hard start. *tt
Bulletin:
0900505
Component:
061000 engine and engine cooling:engine
Summary:
Multiple cylinder misfire or rough idle. *tt
Bulletin:
1803905
Component:
061000 engine and engine cooling:engine
Summary:
Flash - engine roughness or idle fluctuation. *tt
Bulletin:
2200205
Component:
199000 tires:pressure monitoring and regulating systems
Summary:
Tire pressure monitor - system information. *tt
Bulletin:
1400106
Component:
090000 fuel system, other
Summary:
Loose fuel cap message or malfunction indicator lamp illumination for diagnostic trouble code p0457 - evap system - loose fuel cap. *tt
Bulletin:
1801006
Component:
061000 engine and engine cooling:engine
Summary:
Flash-i/m testing-revised engine rpm limits to perform a two speed idle (tsi) test. *ak
Bulletin:
1800406
Component:
061000 engine and engine cooling:engine
Summary:
Flash-no start or hard start. *ak
Bulletin:
01011901
Component:
061000 engine and engine cooling:engine
Summary:
Front end noise may be heard. pre-delivery shift quality, tire pressure sensor diagnostic tool information, and glass replacement. *kb
Bulletin:
0803006
Component:
103000 power train:automatic transmission
Summary:
Powertrain control module initialization. *kb
Bulletin:
2200406
Component:
199000 tires:pressure monitoring and regulating systems
Summary:
Tire pressure monitor system information. *kb
Bulletin:
1400207
Component:
070000 fuel system, gasoline
Summary:
Cleaning procedure for the mechanical throttle body. *kb
Bulletin:
1802907
Component:
103100 power train:automatic transmission:control module (tcm, pcm)
Summary:
Generic powertrain control module (pcm) procedure. *kb
Bulletin:
0500307
Component:
046300 service brakes, air:antilock:wheel speed sensor
Summary:
Wheel speed sensor service. *kb
Bulletin:
13-001-12
Component:
021000 suspension:front
Summary:
Chrysler: the customer may experience a vehicle vibration and/or shake. this bulletin involves inspecting the engine cradle for perforation and if necessary replace. *js
Bulletin:
WB-D-10-34
Component:
060000 engine (pws)
Summary:
Chrsyler: see document search button for owner letter. information regarding inspection and replacement of front engine cradle shows evidence of vibration and/or shaking while driving due to corrosion of front engine cradle. *p
Bulletin:
9003623
Component:
355200 equipment:other:owners/service/other manual
Summary:
Wiper if mopar oe wipers are unavailable, the below alternatives can be offered instead. 05066964a$ = wbrw0011a$ 05066973a$ = wb000019a$ or wbf00019a$ 05096134a$ = wb000027a$ or wbf00028a$ 55154762a$ = wb000013a$ 68001330a$ = wb000019
Bulletin:
RL108213A$
Component:
060000 engine and engine cooling
Summary:
Nag1 (5a580) valve body as per warranty bulletin d-13-22, please use r2108213a$ valve body for all warranty (w), mopar (m) and mopar vehicle protection (f) claims.~ assembly also includes filter (52108325aa) and gasket (52108332aa).~
Bulletin:
9002519
Component:
355200 equipment:other:owners/service/other manual
Summary:
82212076, 82203694 - fabric cleaner this "fabric cleaner" is not intended for sale in california, the otc states (connecticut, delaware, massachusetts, maine, new hampshire, new jersey, new york, pennsylvania, virginia, and washington dc
Bulletin:
20616
Component:
110000 electrical system
Summary:
P/n cbszr068aa: inspect & return: module kit - occupant restraint you have been identified as either having stock, or have stock in transit to your dealership. please return part number cbszr068aa as per the qir attached. replacement par
Bulletin:
22892
Component:
355200 equipment:other:owners/service/other manual
Summary:
Return: lamp assy - chmsl& cargo light you have been identified as either having stock, or have stock in transit to your dealership. please return all stock of follow ing part numbers:55372082ae, 55372082ad, 55372082ac, 55372082ab, 553720
Bulletin:
22867
Component:
110000 electrical system
Summary:
Inspect and return: solenoid module - transmission you have been identified as either having stock, or have stock in transit to your dealership. please return suspect stock of follow ing part numbers:52120000aa, 52119435af, 05078709ab. s
Bulletin:
22958
Component:
117000 digital instrument panel
Summary:
1nt30xdvac - inspect and return: panel - instrument panel you have been identified as either having stock, or have stock in transit to your dealership. please return suspect stock of part number 1n t30xdvac. see attachments for identifyin
Bulletin:
20244
Component:
350000 equipment
Summary:
Cbxdp361aa return: spacer kit - visor you have been identified as either having stock, or have stock in transit to your dealership. please return stock of part number cbxdp361aa. replacement part number is cbxdp361ab w hich is in stock a
Bulletin:
Volume 2, Issue
Component:
355200 equipment:other:owners/service/other manual
Summary:
Warranty operations newsletter updates from warranty operations
Bulletin:
Volume 2, Issue
Component:
355200 equipment:other:owners/service/other manual
Summary:
Warranty operations newsletter updates from warranty operations
Bulletin:
23137
Component:
350000 equipment
Summary:
Inspect and return: trim cover assy - a-pillar rt/lt you have been identified as either having stock, or have stock in transit to your dealership. please return suspect stock of part numbers: 1za04dx9ae, 1za05dx9ae. see attachments for id
Bulletin:
23104
Component:
120000 lighting (pws)
Summary:
05182535ad - lamp assy ?tail light lt you have been identified as either having stock, or have stock in transit to your dealership. please return suspect stock of part number 05182535ad . see attachments for identifying suspect stock. pl
Bulletin:
23027
Component:
114000 electrical system:wiring
Summary:
Return: wiring assy - engine you have been identified as either having stock, or have stock in transit to your dealership. please return stock packaged before 2016/07/31 (31 july, 2016)of follow ing part numbers:68176457af, 68176459af. p
Bulletin:
9001329
Component:
050000 parking brake
Summary:
Part description: seat belt - retaining button kits. issue description: do not replace the entire seat belt if the seat belt web stop button is missing or damaged.~belt web button:~ 1d1 - light graystone - 05093280ab belt web button~1d5 -
Bulletin:
23-012-16
Component:
162600 structure:body:hatchback/liftgate
Summary:
Magnesium inner liftgate repair and appearance characteristics this bulletin involves discussing magnesium inner liftgate repair warnings and appearance characteristics.
Bulletin:
18-042-14
Component:
103100 power train:automatic transmission:control module (tcm, pcm)
Summary:
Generic powertrain control module (pcm) procedure this bulletin involves programming a generic pcm with software.

Home | Privacy