2005 CHEVROLET SILVERADO Recalls (14)

Campaign:: 04V376000 on 08/04/2004
Component:: Fuel system, gasoline:delivery:hoses, lines/piping, and fittings
Manufactured:: 06/24/2004 - 07/25/2004
Affected:: 1,103
Defect:: On certain sport utility vehicles and pickup trucks equipped with 5.3l (rpo l59) v8 engines, the engine fuel rail crossover tube retainer screws were not manufactured to specifications and may break.
Consequence:: If the tube retainer screw breaks, fuel could leak from the fuel rail crossover joint, the engine may stall and, if an ignition source were present, an engine compartment fire could occur.
Correction:: Dealers will inspect the fuel rail crossover tube and, if necessary, replace the retainer screws. owners were notified by telephone on july 30, 2004, with a followup owner letter began august 5, 2004. owners should contact chevrolet at 1-800-630-2438 or gmc at 1-866-996-9463. note: the gm bulletin lists the tahoe and yukon models because canadian vehicles are included in the bulletin. no u.s. tahoe or yukon vehicles are included in the u.s. campaign.
Notes:: Gm recall no. 04066.customers can also contact the national highway traffic safety administrationgm recall no. 04066.customers can also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
Campaign:: 05V018000 on 01/26/2005
Component:: Steering:gear box:shaft sector
Manufactured:: 11/30/2004 - 01/30/2005
Affected:: 3,344
Defect:: On certain trucks, the bolt that attaches the intermediate steering shaft to the steering gear may not meet specification. the bolt may fracture resulting in the loss of steering.
Consequence:: If this happens while the vehicle is moving, a crash could occur without prior warning.
Correction:: Dealers will replace the intermediate steering shaft bolt free of charge. the recall began on january 24, 2005. owners may contact gmc at 1-866-996-9463 and chevrolet at 1-800-630-2438.
Notes:: Gm recall no.05010.customers may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov.
Campaign:: 05V043000 on 02/07/2005
Component:: Service brakes, hydraulic
Manufactured:: 03/31/2004 - 09/29/2004
Affected:: 77,411
Defect:: Certain trucks, sport utility vehicles, and vans equipped with bosch hydro-boost brake assemblies, the hydraulic brake booster pressure accumulator may crack and separate from the hydro-boost assembly during normal operating conditions.
Consequence:: If a separation occurred and the hood of the vehicle were open, fragments from the accumulator could cause injury to people in the immediate area. the presence of this crack or fractured surface could allow the hydraulic fluid to leak from the accumulator circuit of the booster assembly. the loss of fluid would cause increased steering and braking effort and a crash may occur without prior warning.
Correction:: Dealers will test the hydro-boost assembly for functional operation of the two-function valve. if the hydro-boost assembly fails the test, dealers will replace the assembly free of charge. the recall began on march 23, 2005. owners may contact chevrolet at 1-800-630-2438, gmc trucks at 1-866-996-9463 and hummer at 1-800-732-5493.
Notes:: Gm recall no. 05006.customers may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov.
Campaign:: 05V055000 on 02/14/2005
Component:: Power train:manual transmission:shift pattern indicator
Manufactured:: 12/31/2004 - 02/27/2005
Affected:: 7,194
Defect:: Certain sport utility vehicles equipped with an automatic transmission, fail to comply with the requirements of federal motor vehicle safety standard no. 102, "transmission shift lever sequence, starter interlock and transmission braking effect." under certain vehicle starting conditions, the shift lever position indicator located in the instrument panel cluster may not illuminate. if the shift lever position indicator does not illuminate, the driver may not know which gear the vehicle is in.
Consequence:: The vehicle may move in an unintended direction resulting in possible injury to others outside of the vehicle.
Correction:: Dealers will reprogram the instrument panel cluster free of charge. the recall began on february 14, 2005. owners may contact cadillac at 1-866-982-2339, chevrolet at 1-800-630-2438, and gmc at 1-866-996-9463.
Notes:: Gm recall no. 05023.customers may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov.
Campaign:: 05V161000 on 04/21/2005
Component:: Parking brake
Manufactured:: 03/31/2004 - 08/30/2004
Affected:: 90,242
Defect:: On certain pickup trucks equipped with manual transmissions and built with either pbr parking brake systems or trw parking brake systems, the parking brake friction linings may wear to an extent where the parking brake can become ineffective in immobilizing a parked vehicle.
Consequence:: If the parking brake does not hold, unintended vehicle movement could occur, which could result in a crash.
Correction:: Dealers will install a low-force spring clip retainer for vehicles equipped with a pbr parking brake system. on vehicles equipped with the trw parking brake system, dealers will install a redesigned parking brake cable assembly. the recall began on july 29, 2005. owners may contact chevrolet at 1-800-630-2438 or gmc at 1-866-996-9463.
Notes:: Gm recall no. 05042.customers may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov.
Campaign:: 05V163000 on 04/21/2005
Component:: Seat belts:rear
Manufactured:: 02/23/2004 - 11/01/2004
Affected:: 1,359,824
Defect:: On certain crew cab pickup trucks and sport utility vehicles, the 2nd row center occupant seat belt routing may make it difficult to position the lap portion of the safety belt low around the hips of occupants, especially smaller occupants, seated in this position. appropriate use of a child seat or booster seat, as recommended for small children, does improve the fit condition for this user group. in addition to instructions on proper infant and young child restraint (with child seats or boosters), special verbiage for restraining older child is included in the owner's manual. also, the suggested seat belt fit/routing for adults, irrespective of seating position, is described in the owner's manual text.
Consequence:: A lap portion of the seat belt routing that is not low and snug on the hips can allow the lap belt to ride up on an occupant's abdomen instead of fitting low around their hipbones, and therefore, can expose them to more risk of abdominal and internal organ injury.
Correction:: Dealers will cut open the guide loop, remove a portion of the loop, and then the remaining two sides should be folded over and secured with a retainer free of charge. the recall began on july 21, 2005. owners may contact cadillac at 1-866-982-2339, chevrolet at 1-800-630-2438, gmc at 1-866-996-9463, or hummer at 1-800-732-5493.
Notes:: Gm recall no. 05037.customers may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov.
Campaign:: 05V455000 on 10/05/2005
Component:: Steering:hydraulic power assist:hose, piping, and connections
Manufactured:: 06/30/2005 - 08/30/2005
Affected:: 123,592
Defect:: Certain passenger vehicles may have been built with a power steering hose that is not to specification. under extreme steering maneuvers, such as turning the steering wheel fully to the left or right while braking, the hose may fracture and leak fluid.
Consequence:: If this were to occur, power steering assist would be lost and increased steering effort would be required. on vehicles equipped with hydro-boost power brakes, it could also result in loss of power brake assist and increased braking effort would be required. if the power steering fluid spray were to spray onto hot engine parts, an engine compartment fire could occur.
Correction:: Dealers will inspect the power steering hose(s) for two suspect date codes and replace them if required. the recall will begin on october 14, 2005. owners may contact chevrolet at 1-800-630-2438, gmc at 1-866-996-9463, buick at 1-866-608-8080, cadillac at 1-866-982-2339, isuzu at 1-800-255-6727, or hummer at 1-800-732-5493.
Notes:: Gm recall no. 05086.customers may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov.
Campaign:: 06E023000 on 03/13/2006
Component:: Exterior lighting:headlights
Affected:: 292,000
Defect:: Certain anzo combination headlamp assemblies sold as replacement lamps for use on certain passenger vehicles. some combination lamps are not equipped with amber side reflectors which fail to conform to federal motor vehicle safety standard no. 108, "lamps, reflective devices, and associated equipment."
Consequence:: Without the amber reflectors, the vehicle will be poorly illuminated, possibly resulting in a vehicle crash.
Correction:: Anzo will notify owners and replace the headlamps free of charge. the recall began may 9, 2006. owners may contact anzo usa at 909-468-3688.
Notes:: This recall only pertains to aftermarket headlamp assemblies manufactured by anzo and has no relation to any original equipment installed on the listed passenger vehicles.customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.
Campaign:: 06E060000 on 06/28/2006
Component:: Exterior lighting
Affected:: 87,745
Defect:: Certain aai motorsports combination lamps sold as replacement lamps for use on the above list passenger vehicles. combination lamps not equipped with amber side reflectors fail to conform with the requirements of federal motor vehicle safety standard no. 108, "lamps, reflective devices, and associated equipment."
Consequence:: Lack of amber side reflectors in the lamps will decrease lighting visibility to other drivers and may possibly result in a vehicle crash
Correction:: Aai motorsports will notify owners and replace the lamps free of charge. the recall began on august 1, 2006. owners may contact aai motorsports at 909-923-9188.
Notes:: This recall only pertains to aai motorsports aftermarket lamps and has no relation to any original equipment installed on the listed passenger vehicles.for more information on the lamp model numbers, click on document search and view document titled "lamp model numbers."customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.
Campaign:: 06E064000 on 07/16/2006
Component:: Exterior lighting
Affected:: 4,029
Defect:: Certain tradesonic combination lamps sold as replacement lamps for use on the above listed passenger vehicles. combination lamps not equipped with amber side reflectors fail to conform with the requirements of federal motor vehicle safety standard no. 108, lamps, reflective devices, and associated equipment.
Consequence:: Lack of amber side reflectors in the lamps will decrease lighting visibility to other drivers and may possibly result in a vehicle crash.
Correction:: Tradesonic will notify owners and replace the lamps free of charge. the recall is expected to begin during july 2006. owners may contact tradesonic at 626-934-8884.
Notes:: This recall only pertains to tradesonic aftermarket lamps and has no relation to any original equipment installed on the listed passenger vehicles.for more information on the lamp model numbers, click on document search and view document titled "lamp model numbers."customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.
Campaign:: 06V289000 on 08/02/2006
Component:: Engine and engine cooling
Manufactured:: 02/29/2004 - 07/30/2005
Affected:: 38,439
Defect:: On certain trucks equipped with an 8.1l v8 (rpo l8-vin g) engine have a condition in which the engine fuel rail pulse damper retainer clip may fracture resulting in inadequate retention of the damper.
Consequence:: If the damper comes loose, a fuel leak may result. fuel leakage, in the presence of an ignition source, could result in a fire.
Correction:: Dealers will replace the engine fuel rail pulse damper retainer clip free of charge. the recall began on august 31, 2006. owners may contact chevrolet at 1-800-630-2438 and gmc trucks at 1-866-996-9463.
Notes:: Gm recall no. 06080.customers may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov.
Campaign:: 07E066000 on 08/28/2007
Component:: Equipment:electrical
Affected:: 175
Defect:: Certain cequent 90 degree 7-way right angle adaptors sold by distributors in tow packages for aftermarket sales to tow 5th wheel rv travel trailers. due to incorrect wiring of the harness, the trailer lights may not operate properly.
Consequence:: If the trailer lights are not working properly, a vehicle crash can occur.
Correction:: All of the defective tow packages are still at the distributor level and have not been sold to any consumers.
Notes:: This recall only pertains to aftermarket cequent tow packages and has no relation to any original equipment installed on daimlerchrysler, gmc, or ford vehicles.customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.
Campaign:: 07E106000 on 12/18/2007
Component:: Wheels:cap/cover/hub
Affected:: 130,000
Defect:: Certain federal-mogul replacement wheel hub assemblies with the brand names: national, carquest p/nos. 515020, 515021, 515025, 515053, 515054, 515059, and 515060, shipped between january 23, 2006, and december 20, 2007, sold for light duty and medium duty trucks. the inboard retention nut used to maintain hub bearing assembly can loosen resulting in an abs light indication, noise, and/or wheel separation.
Consequence:: Wheel separation can result in a vehicle crash.
Correction:: Federal-mogul will notify customers and will replace the hub assembly free of charge. the recall began on february 7, 2008. owners can contact federal-mogul toll-free at 877-489-6659.
Notes:: This recall only pertains to replacement national, carquest wheel hub assemblies and has no relation to any original equipment installed on vehicles manufactured by general motors or ford.customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.
Campaign:: 08E050000 on 08/13/2008
Component:: Exterior lighting:headlights
Affected:: 1,921
Defect:: K2 motor is recalling 1,921 aftermarket headlamps of various models sold for use on the above listed vehicles. these headlamps are missing the amber side reflex reflector which fails to conform with the requirements of federal motor vehicle safety standard no. 108, "lamps, reflective devices, and associated equipment."
Consequence:: Without the amber side reflex reflectors, the lighting visibility may be affected, possibly resulting in a vehicle crash.
Correction:: K2 motor will notify owners and offer a full refund. the recall began on decemeber 17, 2008. owners may contact k2 motor at 1-909-839-2992.
Notes:: This recall only pertains to aftermarket replacement equipment and has no relation to any original equipment installed on vehicles manufactured by honda, ford, or chrysler llc. customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.

2005 CHEVROLET SILVERADO TSBs (365)

Bulletin:: 010310010C
Component:: 020000 suspension
Summary:: Inspection of tire and wheel size prior to diagnosis of transmission shifts, poor performance, speedometer, cruise control concerns. bulletin 01-03-10-010b not received. *tt
Bulletin:: 020730004
Component:: 103000 power train:automatic transmission
Summary:: New product information, grade brake feature of allison 1000 series transmission. *slc this bulletin replaces 02-07-30-004. *tt
Bulletin:: 020601027
Component:: 061100 engine and engine cooling:engine:gasoline
Summary:: Information on higher than expected oil consumption. nlm
Bulletin:: 020730024A
Component:: 103400 power train:automatic transmission:lever and linkage:column shift
Summary:: Diagnosis of cracked or broken transmission case. *tt 2006 and prior cars and light duty trucks. *tt
Bulletin:: 030525007
Component:: 036000 service brakes, hydraulic:antilock
Summary:: Antilock brake (abs) activation at low speeds (clean wheel speed sensor mounting surface). *tt updated 10/23/09. *pe
Bulletin:: 030693001A
Component:: 061200 engine and engine cooling:engine:diesel
Summary:: Diagnostic information for turbo failure due to lack of oil or repeat turbo failures. *tt
Bulletin:: 030730044
Component:: 103000 power train:automatic transmission
Summary:: Information on allison transmission service repairs - full service of internal components. *tt
Bulletin:: 030844018A
Component:: 350000 equipment
Summary:: Rear seat audio (rsa) and/or rear hvac inoperative. *tt update. *tt
Bulletin:: 990089015C
Component:: 980000 unknown or other
Summary:: Light service support vehicle lssv (formerly commercial utility cargo vehicle - cucv ii and iii) service. *tt
Bulletin:: 030850014
Component:: 110000 electrical system
Summary:: Intermittent no start, service stability message, anti-lock brake system (abs) light illuminated, multiple diagnostic trouble codes (dtcs), dic shows unknown driver, various electrical related conditions. includes escalade esv and ext mod
Bulletin:: 3259C
Component:: 103000 power train:automatic transmission
Summary:: 4l80e, 4l85e whine noise in first and second gear. *tt
Bulletin:: 030310006
Component:: 020000 suspension
Summary:: Reference guide for the technician to upgrade a vehicle from factory wheels and tires to 20 inch wheels and tires, which are available through gmspo. *tt
Bulletin:: 01896
Component:: 061320 engine and engine cooling:engine:other fuel types:turbo-charger
Summary:: 6.6 lly duramax diesel engine turbocharger learn procedure. *mr
Bulletin:: 01060A
Component:: 111000 electrical system:battery
Summary:: Roof beacon switch left on causing battery draw. gmc gmt 800. *mj 2005 models added. *tt
Bulletin:: 040525002B
Component:: 036100 service brakes, hydraulic:antilock:control unit/module
Summary:: Anti-lock brake system (abs) light on, diagnostic trouble codes (dtcs) c0265, c0201, u1041 set and/or loss of communication with brake module. *tt update. *tt
Bulletin:: 3001
Component:: 106000 power train:axle assembly
Summary:: The service information and owners manual do not show a service interval for the 8.6, 9.5, 9.75, 10.5, and 11.5 inch rear axles with or without g80 (locking differential). *tt 2006 all general motors light duty trucks, vans and utilitie
Bulletin:: 3004
Component:: 061000 engine and engine cooling:engine
Summary:: 4.8l 5.3l 6.6l 8.1l p1285 p1286 or p2133 after replacing app sensor. *mj
Bulletin:: 3002
Component:: 135200 visibility:rearview mirrors/devices:exterior
Summary:: Service vme - switching mirrors from power folding to power extending. *mj
Bulletin:: 3001
Component:: 110000 electrical system
Summary:: No communication with any modules, multipe u-diagnostic trouble codes (dtcs), instrument panel cluster (ipc) warning indicators. 03-04 chevrolet all full size trucks and utilities and 03-04 gmc all full size trucks and utilities and 03-04
Bulletin:: 3000A
Component:: 022000 suspension:rear
Summary:: Rear axle locking differential chatter shudder noise on turns. *mj
Bulletin:: 3045
Component:: 200000 wheels
Summary:: Various steering or suspension concerns after gm accessories 20 inch tire/wheel assemblies have been installed. *tt
Bulletin:: 3051
Component:: 185000 vehicle speed control:cruise control
Summary:: Cruise control and/or the power take off unit (pto) may be inoperative. *tt
Bulletin:: 3083
Component:: 100000 power train
Summary:: M74 allison lct1000 pto gear applications. *tt
Bulletin:: 3086
Component:: 353600 equipment:air conditioner
Summary:: Air conditioner (a/c) low pressure switch diagnostic tool. currently the a/c low pressure switch open/close pressures cannot be accurately determined by measuring pressure at the low side service port. *tt
Bulletin:: 3087
Component:: 061000 engine and engine cooling:engine
Summary:: Crank no start with no cranking rpm spark or injector pulse. *tt
Bulletin:: 3089
Component:: 162000 structure:body
Summary:: Rattle type noise coming from the rear of the cab during body twist maneuvers or over bumps. *tt
Bulletin:: 3089
Component:: 110000 electrical system
Summary:: Service engine soon light and reduced engine power with a diagnostic trouble code p1516. diagnostic trouble codes p0120, p0220, p1514, p1515, p1518 and p2135 may also be present. *tt
Bulletin:: 3073
Component:: 185000 vehicle speed control:cruise control
Summary:: Downhill cruise control surge. *tt
Bulletin:: 3075B
Component:: 110000 electrical system
Summary:: Blown mbec 1 or lbec 1 fuse. *tt
Bulletin:: 3068
Component:: 061120 engine and engine cooling:engine:gasoline:turbo-charger
Summary:: Oil seepage from turbo air charge cooler hoses or hose blowing off during acceleration. possible diagnostic trouble code p0299. *tt updated 04-24-07. *kb
Bulletin:: 3078
Component:: 021600 suspension:front:wheel bearing
Summary:: Grease leak from front hub bearing. *tt update. *tt
Bulletin:: 3050A
Component:: 350000 equipment
Summary:: 02-05 onstar equipped vehicles emitting beeping noise before connecting to onstar. *tt
Bulletin:: 3054
Component:: 100000 power train
Summary:: Replacement flexplate may have larger bolt holes than the original flexplate. *tt
Bulletin:: 3055
Component:: 061000 engine and engine cooling:engine
Summary:: Service engine soon light with a p0300 misfire due to misfires mainly on cylinder 7. *tt
Bulletin:: 3063
Component:: 982000 other:school bus stop arm assembly
Summary:: Performance package rpo pcx. *tt
Bulletin:: 30559
Component:: 103000 power train:automatic transmission
Summary:: Allison lct1000 diagnostic trouble code p1711, p0872 after completing repairs. *tt
Bulletin:: 3128
Component:: 160000 structure
Summary:: All full size trucks pick up box sheet metal fracture/damage with aftermarket accessories installed. *sc
Bulletin:: 3105C
Component:: 100000 power train
Summary:: Ping, pop, snap, or click noise from the propeller shaft. *sc
Bulletin:: 3155
Component:: 180000 vehicle speed control
Summary:: Speedometer inoperative. *tc
Bulletin:: 3129A
Component:: 070000 fuel system, gasoline
Summary:: Smoke, fuel knock, surging, and high injector balance rates. *tc to include 2005 chevrolet kodiak and gmc topkick. *tt
Bulletin:: 3156
Component:: 030000 service brakes, hydraulic
Summary:: Rear park brake cable may not be properly connected. *tc gm administrative message. *tt
Bulletin:: 3157
Component:: 190000 tires
Summary:: Excessive tire spin setting diagnostic trouble code c0543. *tc
Bulletin:: 3132A
Component:: 104000 power train:transfer case (4-wheel drive)
Summary:: Nvg149 np3 transfer case may exhibit a bind or shudder on turns. *tc
Bulletin:: 3159
Component:: 110000 electrical system
Summary:: Instrument panel cluster parts restriction. *tc
Bulletin:: 3160
Component:: 060000 engine and engine cooling
Summary:: Gas engines exhaust buzz or rattle noise. *tc
Bulletin:: 3134B
Component:: 104000 power train:transfer case (4-wheel drive)
Summary:: Service 4wd indicator illuminated. *tc with diagnostic trouble code co327. *tt
Bulletin:: 3121
Component:: 060000 engine and engine cooling
Summary:: Exhaust vibration resonance or moan. (2004-2005 gmc denali) *sc
Bulletin:: 3119
Component:: 063140 engine and engine cooling:exhaust system:emission control:catalytic convertor
Summary:: Engineering investigation - catalytic converter replacement. *sc
Bulletin:: 3120
Component:: 353500 equipment:electrical:navigational system(global positioning system)
Summary:: Onstar center unable to perform remote diagnostic. (2004-2005 chevrolet yukon, 2005 chevrolet trailblazer, 2002, 2003, 2005 buick rainier, 2005 chevrolet express van, and 2005 cadillac seville) *sc
Bulletin:: 3106
Component:: 353400 equipment:electrical:radio/tape deck/cd etc.
Summary:: Xm radio was working prior to july 26, 2004 and it is inoperative now. *jb
Bulletin:: 040601027
Component:: 061000 engine and engine cooling:engine
Summary:: Mis-machined engine oil gallery - inspect/replace engine. various 2005 models inclding chevrolet express. *nm actual service bulletin. *tt
Bulletin:: 3107
Component:: 060000 engine and engine cooling
Summary:: P0420 and p0430 dtsc in the detroit, michigan area with gen iii v-8 engines. *sc
Bulletin:: 3092
Component:: 100000 power train
Summary:: Allison lct 1000 buzz noise feel on tcc apply. *sc
Bulletin:: 3092
Component:: 030000 service brakes, hydraulic
Summary:: Brake dust accumulation. *sc
Bulletin:: 3094
Component:: 110000 electrical system
Summary:: Allison lct 1000 p1781 or p0802 setting in the electronic control module. (2005 chevrolet kodiak and 2005 gmc top kick) *sc
Bulletin:: 3121
Component:: 062000 engine and engine cooling:cooling system
Summary:: Exhaust vibration resonance or moan in vehicles with gen iii v8 engines. *tc
Bulletin:: 00837
Component:: 100000 power train
Summary:: Allison lct1000 overdrive disable lamp inoperative after installation of instrument panel (ip). *tt
Bulletin:: 3151
Component:: 100000 power train
Summary:: Allison lct1000 transmission hard to remove from park. *tt
Bulletin:: 3156
Component:: 100000 power train
Summary:: 261 transfer case drivelines growl 1100-1200 rpm. *tt
Bulletin:: 3056
Component:: 061000 engine and engine cooling:engine
Summary:: Check engine light with a p0300 due to 2-4 cylinders misfiring on the same bank of the engine. *tt
Bulletin:: 3161
Component:: 103000 power train:automatic transmission
Summary:: Allison lct1000 clunk noise on start in park. *eh
Bulletin:: 3192
Component:: 200000 wheels
Summary:: Availability of 20 inch wheels and tires through gmspo on 2005 models. *eh
Bulletin:: 3170
Component:: 103000 power train:automatic transmission
Summary:: Harsh 1-2 shift. *eh
Bulletin:: 3137
Component:: 106000 power train:axle assembly
Summary:: Service 4wd light on and no communication with transfer case control module. *eh
Bulletin:: 3061C
Component:: 110000 electrical system
Summary:: Diagnostic trouble code c0327 with or without additional diagnostic trouble codes setting. *tt
Bulletin:: 3193
Component:: 060000 engine and engine cooling
Summary:: Excessive oil consumption. *eh
Bulletin:: 3235
Component:: 190000 tires
Summary:: 20 inch wheels stop sell on 1500 crew cab with 5'8' bed. *eh
Bulletin:: 3204
Component:: 060000 engine and engine cooling
Summary:: Coolant leak at engine mount bolt. *eh
Bulletin:: 3205
Component:: 100000 power train
Summary:: Allison lct1000 pump separator plate change disregard additional valve. *tt
Bulletin:: 3189
Component:: 170000 latches/locks/linkages
Summary:: Unable to disable auto door locks. this includes 05 chevrolet gmc cadillac full size trucks and utilities. *eh also includes avalance, silverado suburban tahoe; gmc sierra, yukon, denali, yukon xl, denali xl. updated 8/26/08. *pe
Bulletin:: 3187
Component:: 060000 engine and engine cooling
Summary:: Engine low power will not go over 2300 rpms. *eh updated 6/11/10. *pe
Bulletin:: 3011B
Component:: 060000 engine and engine cooling
Summary:: Engine oil leak at main bering side bolt. *eh
Bulletin:: 3087
Component:: 060000 engine and engine cooling
Summary:: Crank no start, stall, hard start, and no cranking rpm. *eh
Bulletin:: 040731006
Component:: 100000 power train
Summary:: Excessive shifter and/or engine vibration, bearing growl and/or rattle type noise while depressing or releasing clutch pedal. *tt
Bulletin:: 040850015
Component:: 110000 electrical system
Summary:: Driver seat adjuster memory & heater switch will not illuminate. *tt
Bulletin:: 040604001
Component:: 061000 engine and engine cooling:engine
Summary:: Various intermittent driveability conditions - hesitation, lack of power, etc. *tt
Bulletin:: 040138010
Component:: 353600 equipment:air conditioner
Summary:: Diagnostic information to accurately diagnose a/c low pressure switch using new kent moore special tool ge-47742. *tt
Bulletin:: 040139009
Component:: 138110 visibility:defroster/defogger system:windshield:blower
Summary:: Hvac blower motor inoperative or stays running. *tt
Bulletin:: 040602006
Component:: 061000 engine and engine cooling:engine
Summary:: Engine overheating. *tt
Bulletin:: 020139007
Component:: 980000 unknown or other
Summary:: Automatic dual zone hvac battery draw. *ar
Bulletin:: 040850016B
Component:: 220000 seats
Summary:: Memory seat may not return to requested position. *eh
Bulletin:: 040526002
Component:: 051120 parking brake:conventional:mechanical:linkage and cable
Summary:: Parking brake may not hold. *tt
Bulletin:: 11102004
Component:: 980000 unknown or other
Summary:: Stop delivery of certain full size crew cab pickup trucks built at the flint assembly. *tt
Bulletin:: 3068B
Component:: 060000 engine and engine cooling
Summary:: Turbo air charge cooler hoses oil seepage or blows off on acceleration. this also includes 2004-2005 lly c2 c3 c4 c5 k2 k3 d4 d5 e4 e5 models. *eh
Bulletin:: 3212A
Component:: 060000 engine and engine cooling
Summary:: Fuel leaking from body of injector. this also includes 2004-2005 lly c2 c3 c4 c5 k2 k3 d4 d5 e4 e5 models. *eh
Bulletin:: 3250
Component:: 040000 service brakes, air
Summary:: Service engine soon light illuminated with diagnostic trouble code p0171 or p0174 set. the root cause may be a damaged or missing seal from the master cylinder to the brake booster. *eh
Bulletin:: 3227
Component:: 060000 engine and engine cooling
Summary:: Broken #2 and #7 injector connector terminals. this also includes lly 6.6 c2 c3 c4 c5 k2 k3 d4 d5 e4 e5. *eh
Bulletin:: 3230
Component:: 060000 engine and engine cooling
Summary:: Diesel oil leak at right rear of engine. this includes lly c2 c3 c4 c5 d4 d5 e4 e5 k2 k3 models. *eh
Bulletin:: 3238C
Component:: 060000 engine and engine cooling
Summary:: Fuel injector driver circuit codes p0201 through p0208. this also includes 2004 2005 lly c2 c3 c4 c5 e4 e5 d4 d5 k2 k3 models. *eh updated *eh
Bulletin:: 3243
Component:: 103000 power train:automatic transmission
Summary:: Leak from the vent 4l80e/4l85e transmission. *eh
Bulletin:: 3227
Component:: 162500 structure:body:tailgate
Summary:: Tailgate cable slack. this includes 1998-2006 chevrolet and gmc full and mid size trucks. *eh updated. *kb
Bulletin:: 3057
Component:: 010000 steering
Summary:: Service 4 wheel steer message with diagnostic trouble code c0455. *eh
Bulletin:: 11172004
Component:: 980000 unknown or other
Summary:: Stop delivery of certain full size crew cab pickup trucks. floor plan expense reimbursement information. *tt
Bulletin:: 000235003
Component:: 010000 steering
Summary:: Clunking noise under hood and can be felt in steering wheel. *eh updated *eh updated. *kb
Bulletin:: 030310002
Component:: 190000 tires
Summary:: Use of correct installation procedure for loose hubcap assembly. this service bulletin replaces 030310002. *eh
Bulletin:: 030310006D
Component:: 190000 tires
Summary:: 20 inch wheels and tires available through gmspo. *eh *tt
Bulletin:: 040138008
Component:: 353600 equipment:air conditioner
Summary:: Heat ventilation and air conditioning system cannot be controlled or defaults to defrost mode. *eh
Bulletin:: 030604036
Component:: 060000 engine and engine cooling
Summary:: Information on servicing fuel injectors to avoid contamination. *eh updated 03-19-07. *kb
Bulletin:: 040604070
Component:: 061000 engine and engine cooling:engine
Summary:: Information on the revised fuel filter for the 6.6l duramax diesel. *tt
Bulletin:: 040138013
Component:: 353600 equipment:air conditioner
Summary:: Hvac not cold enough a/c compressor does not engage . *eh
Bulletin:: 040138014
Component:: 353600 equipment:air conditioner
Summary:: High pitched tone heard inside vehicle when ac compressor is engaged. *eh
Bulletin:: 020601023C
Component:: 060000 engine and engine cooling
Summary:: Oil leak at cooler to engine block mating surface. *eh
Bulletin:: 10292004
Component:: 061120 engine and engine cooling:engine:gasoline:turbo-charger
Summary:: This is in regards to the unnecessary changing of turbochargers due to oil seepage. *tt
Bulletin:: 07282004
Component:: 060000 engine and engine cooling
Summary:: Stop delivery of certain vehicles equipped with a 5.3 liter engine. *eh
Bulletin:: 07302004
Component:: 070000 fuel system, gasoline
Summary:: Engine fuel rail crossover tube retainer screw were not manufactured to specifications and may break. *eh
Bulletin:: 3300C
Component:: 341000 communications:horn assembly
Summary:: Application of horn at horn pad inoperative. rke function for panic alarm works. *tt
Bulletin:: 050090001
Component:: 060000 engine and engine cooling
Summary:: Information on the proper air filter for the duramax diesel. *eh
Bulletin:: 0502118001
Component:: 010000 steering
Summary:: Quadrasteer intermittent service 4-wheel steer message. *tt
Bulletin:: 0508132001
Component:: 350000 equipment
Summary:: Accessory power outlet (apo) turns off automatically - parallel hybrid truck (rpo hp2). *tt
Bulletin:: 050420001
Component:: 022510 suspension:rear:axle:spindle
Summary:: Rear axle fluid level may appear to be lower than published specification. *eh
Bulletin:: 050730002
Component:: 103000 power train:automatic transmission
Summary:: New essential tool j 45096 23 automatic transmission oil cooler line adapter for allison transmission. *eh
Bulletin:: 3343
Component:: 211000 trailer hitches:fifth wheel assembly
Summary:: Why the crew cab short bed (5 foot 8 inch) is not recommended for fifth wheel trailering. *tt
Bulletin:: 3280
Component:: 073200 fuel system, gasoline:fuel injection system:injectors
Summary:: Rust found in the injector inlet filter during injector repairs. *tt
Bulletin:: 3282
Component:: 061000 engine and engine cooling:engine
Summary:: Engine overheat on vehicles equipped with rpo vyu snowplow prep package. *tt
Bulletin:: 3292
Component:: 060000 engine and engine cooling
Summary:: Diesel engine balance rates all showing zero. *eh
Bulletin:: 3373
Component:: 140000 air bags
Summary:: Sir light on steady after bulb test and no diagnostic trouble codes (dtcs). *tt
Bulletin:: 3293
Component:: 061000 engine and engine cooling:engine
Summary:: P0622 or charge indicator on after calibrating engine control module (ecm). *tt
Bulletin:: 3386
Component:: 015000 steering:hydraulic power assist system
Summary:: Lack of steering assist or shudder during parking lot type maneuvers. *tt
Bulletin:: 3303
Component:: 100000 power train
Summary:: Transmission fluid leak from the front of the transmission. *tt
Bulletin:: 3391
Component:: 110000 electrical system
Summary:: Unwanted operation of the hazard flashers. *eh
Bulletin:: 3294
Component:: 106000 power train:axle assembly
Summary:: Highway speed vibration on smooth surface. *eh
Bulletin:: 3309
Component:: 103000 power train:automatic transmission
Summary:: Investigation of extension seal leaks on 4l60e automatic transmission. *tt
Bulletin:: 3300
Component:: 105000 power train:driveline
Summary:: 4wd models with noise, vibration on dry pavement. *eh
Bulletin:: 04056
Component:: 200000 wheels
Summary:: 20 inch plus size wheel restriction - supplement to accessories bulletin acc04-056. gm voicemail express. *tt
Bulletin:: 07012004
Component:: 355200 equipment:other:owners/service/other manual
Summary:: Oil life system reset procedures-trucks. buick terazza 2005, gmc sierra denali 2002-2003, gmc b7 chassis medium duty 2003-2005 and gmc 560 c-series 2003-2005 *sc
Bulletin:: 3346
Component:: 061000 engine and engine cooling:engine
Summary:: There has been a high percentage of no trouble found (ntf) 6.6 lly engine control modules (ecms) being returned to the warranty parts center. the no trouble found (ntf) ecms are being replaced for a specific list of diagnostic trouble code
Bulletin:: 3347
Component:: 100000 power train
Summary:: High-speed 1st order propshaft vibration. *tt
Bulletin:: 3464
Component:: 162310 structure:body:door:hinge and attachments
Summary:: Door hinge replacement kit. *tt
Bulletin:: 3348
Component:: 061120 engine and engine cooling:engine:gasoline:turbo-charger
Summary:: Noise, service engine soon (ses) light, or low power. dealer may find turbine (exhaust side) wheel rub damage, a broken turbine shaft, or turbo bearing concern. *tt
Bulletin:: 03092005
Component:: 353400 equipment:electrical:radio/tape deck/cd etc.
Summary:: Cds stick in cd player. *eh
Bulletin:: 03102005
Component:: 010000 steering
Summary:: Steering gear whistle noise on turns. *eh
Bulletin:: 3351
Component:: 104000 power train:transfer case (4-wheel drive)
Summary:: Intermittent malfunction indicator lamp (mil) with diagnostic trouble code (dtc) c0374 or erratic 4wd/awd operation. *tt
Bulletin:: 3352
Component:: 100000 power train
Summary:: Service 4wd light on with either a variety of diagnostic trouble codes or no communication with the transfer case control module. *tt
Bulletin:: 3155
Component:: 110000 electrical system
Summary:: No shift, speedometer erratic/inoperative, p0721 c0237 p0500 c0055. *tt
Bulletin:: 3357
Component:: 110000 electrical system
Summary:: Malfunction indicator light is on and the vehicle has a code p0706. *tt
Bulletin:: 3232
Component:: 061000 engine and engine cooling:engine
Summary:: 1999 - 2005 gen ii cold engine misfire at idle with possible p0171 and/or p0174. *tt
Bulletin:: 3335A
Component:: 100000 power train
Summary:: Investigation of pump area leaks. *tt
Bulletin:: 3363
Component:: 100000 power train
Summary:: 4l60e/4l65e no reverse. *tt
Bulletin:: 3499
Component:: 017300 steering:linkages:arm:idler and attachment
Summary:: Steering idler arm inspection procedure. *tt
Bulletin:: 3369
Component:: 100000 power train
Summary:: To better understand sprag damage an engineering investigation is being conducted. typical symptoms include no forward movement in d4 or d3 shift lever position. movement can be obtained in d2, d1 or reverse. *tt
Bulletin:: 3371
Component:: 103000 power train:automatic transmission
Summary:: 4l80e/4l85e automatic transmission leak concern. *tt
Bulletin:: 3375
Component:: 060000 engine and engine cooling
Summary:: Rough idle, service engine soon (ses)light, unstable idle, hesitation, surge or stalling. with diagnostic trouble codes p0300, p0335 or p0336. *tt
Bulletin:: 3379
Component:: 020000 suspension
Summary:: 8.625 axle phasing, growl, cyclic, noise while driving. *tt
Bulletin:: 020307002
Component:: 020000 suspension
Summary:: Revised front caster and camber adjustment procedure. original not yet received. *tt
Bulletin:: 3328A
Component:: 060000 engine and engine cooling
Summary:: Surge at idle or 1100 to 1400 rpm. *eh
Bulletin:: 3364
Component:: 106000 power train:axle assembly
Summary:: Rear axle retainer button breakage. *eh
Bulletin:: 050310002
Component:: 020000 suspension
Summary:: Availability of new functional nut caps for steel wheels. *tt
Bulletin:: 050603001
Component:: 060000 engine and engine cooling
Summary:: Revised engine electrical and automatic transmission - 4l60e/4l65e subsections - new caution statements added. *tt
Bulletin:: 0508111002
Component:: 355200 equipment:other:owners/service/other manual
Summary:: Replacement procedure if hybrid emblem is missing fallen off. *eh
Bulletin:: 050604023
Component:: 060000 engine and engine cooling
Summary:: Revised diagnostic trouble code (dtc) p2563. *tt
Bulletin:: 050604024
Component:: 060000 engine and engine cooling
Summary:: Revised diagnostic trouble code (dtc) p1172 and dtc p2636. *tt
Bulletin:: 050849010
Component:: 110000 electrical system
Summary:: Information on resetting the battery light if it remains illuminated after (powertrain control module) pcm replacement. *tt
Bulletin:: 05023
Component:: 102300 power train:manual transmission:shift pattern indicator
Summary:: Shift lever position indicator illumination recall campaign. *tt
Bulletin:: 701
Component:: 090000 fuel system, other
Summary:: Fuel filter replacement. gm tech link. *tt
Bulletin:: 610
Component:: 162000 structure:body
Summary:: Rattle type noise coming from the rear of the cab during body twist maneuvers or over bumps. gm tech link. *tt
Bulletin:: 612
Component:: 030000 service brakes, hydraulic
Summary:: Service engine soon light illuminated. diagnostic trouble code (dtc) p0171 and/or p0174 (lean fuel trim) may be set. master cylinder o-ring damaged. gm tech link. *tt
Bulletin:: 609
Component:: 021700 suspension:front:hub
Summary:: Front hub bearing grease leak. *sc
Bulletin:: 702
Component:: 106000 power train:axle assembly
Summary:: The factory lubricant fill level may appear lower than the published specification on vehicles equipped with the 11.5-inch ring gear rear axle assembly. *tt
Bulletin:: 702
Component:: 061000 engine and engine cooling:engine
Summary:: Duramax air filter. gm tech links. *tt
Bulletin:: 702
Component:: 030000 service brakes, hydraulic
Summary:: Brake twang noise. gm tech links. *tt
Bulletin:: 708
Component:: 221700 seats:front assembly:seat heater/cooler
Summary:: Heated seats turn off. *sc
Bulletin:: 3504
Component:: 061200 engine and engine cooling:engine:diesel
Summary:: Hard start hot only after the engine has reached operating temperature and then shut off. *tt
Bulletin:: 3497
Component:: 103000 power train:automatic transmission
Summary:: Range inhibit and/or will not move. *tt
Bulletin:: 3671
Component:: 135200 visibility:rearview mirrors/devices:exterior
Summary:: Service vme - outside rearview mirror vibration. *tt
Bulletin:: 3479C
Component:: 061000 engine and engine cooling:engine
Summary:: Engine knock noise heard at all times. *tt
Bulletin:: 3702
Component:: 090000 fuel system, other
Summary:: Intermittently fuel filter life displays 0%. *tt
Bulletin:: 3526
Component:: 104000 power train:transfer case (4-wheel drive)
Summary:: Intermittent service 4wd light comes on with diagnostic trouble code (dtc) c0306 or c0308 stored in tccm. *tt
Bulletin:: 3525
Component:: 073200 fuel system, gasoline:fuel injection system:injectors
Summary:: Service vmx - duramax injector wiring harness support bracket kit. *tt
Bulletin:: 3562A
Component:: 190000 tires
Summary:: Bridgestone dueler product information update. *tt *sc
Bulletin:: 3559
Component:: 030000 service brakes, hydraulic
Summary:: Low brake fluid level source of leak unknown. *sc
Bulletin:: 3475A
Component:: 100000 power train
Summary:: Bulletin-sit-bulletin-no forward, slips, dtc p0875 p0876. *sc
Bulletin:: 3491
Component:: 090000 fuel system, other
Summary:: Highway speed excessive smoke and fuel knock. *tt
Bulletin:: 3431A
Component:: 062100 engine and engine cooling:cooling system:radiator assembly
Summary:: Service vme - coolant leak from radiator surge tank. *tt
Bulletin:: 3427
Component:: 110000 electrical system
Summary:: Additional diagnostic information dtc p0757. *tt
Bulletin:: 3394C
Component:: 080000 fuel system, diesel
Summary:: Duramax diesel injector driver codes. misfire, rough running, and the malfunction indicator lamp (mil) / service engine soon (ses) light on. *tt
Bulletin:: 3436
Component:: 061110 engine and engine cooling:engine:gasoline:belts and associated pulleys
Summary:: Accessory drive belt noise on cold start - reposition power steering pump pulley. *tt
Bulletin:: 3440
Component:: 100000 power train
Summary:: Clutch chatter on transmission engagement, hard to shift, gear clash. *tt
Bulletin:: 3439
Component:: 100000 power train
Summary:: No drive in d4 or d3. to include 2005 gmc jimmy. *tt
Bulletin:: 3450
Component:: 061200 engine and engine cooling:engine:diesel
Summary:: Duramax diesel hesitation or backfire. *tt
Bulletin:: 3568A
Component:: 030000 service brakes, hydraulic
Summary:: Service brake booster message. *tt
Bulletin:: 3438A
Component:: 103000 power train:automatic transmission
Summary:: Tcc surge and/or fluid contamination. *tt
Bulletin:: 3394
Component:: 061000 engine and engine cooling:engine
Summary:: 6.6 lly injector driver codes. misfire, rough running, and the mil/ses light on. *sc
Bulletin:: 3479A
Component:: 061000 engine and engine cooling:engine
Summary:: Lower end engine knock noise. *sc
Bulletin:: 3639
Component:: 135000 visibility:rearview mirrors/devices
Summary:: Service vme-outside rear view mirror inoperative. *sc
Bulletin:: 3400
Component:: 073200 fuel system, gasoline:fuel injection system:injectors
Summary:: Rough idle, fuel knock or smoke while driving, combustion leak type noise, or a misfire. 6.6 lly injector knock, heavy smoke during warm up cycle. *tt
Bulletin:: 3545
Component:: 138110 visibility:defroster/defogger system:windshield:blower
Summary:: Blower motor inoperative at low ambient temperatures. *tt
Bulletin:: 3225A
Component:: 061200 engine and engine cooling:engine:diesel
Summary:: 01-05 6.6 lly lb7 duramax diesel engine air filter usage. *sc
Bulletin:: 3260
Component:: 100000 power train
Summary:: 4l80e/4l85e harsh shift or slip no tcc apply. *tt
Bulletin:: 3267
Component:: 061000 engine and engine cooling:engine
Summary:: Diagnostic trouble code p0128 or engine will not reach operating temperature. *sc
Bulletin:: 3258
Component:: 061000 engine and engine cooling:engine
Summary:: 6.6l lly engine oil leak at rear housing cover bolt. *tt
Bulletin:: 3272
Component:: 180000 vehicle speed control
Summary:: Diesel hesitation or throttle delay. *sc
Bulletin:: 3256A
Component:: 063130 engine and engine cooling:exhaust system:emission control:gas recirculation valve (egr valve)
Summary:: Vehicle may be brought in for service engine soon (ses) or malfunction indicator lamp (mil) light on. *tt
Bulletin:: 3331
Component:: 117000 digital instrument panel
Summary:: Voltmeter is flucuating between 12 and 14 volts on their new 2005 chevrolet/ gmc/ cadillac model year light duty full size pickup and utility. *sc
Bulletin:: 3422
Component:: 135100 visibility:rearview mirrors/devices:interior
Summary:: Inaccurate outside temperature reading on inside rearview mirror. *tt
Bulletin:: 3320
Component:: 100000 power train
Summary:: 4l65e (rpo m32) transmission accumulator spring usage. *tt
Bulletin:: 3328B
Component:: 061200 engine and engine cooling:engine:diesel
Summary:: Engine rpm surge at 1100 to 1400 rpm. this condition may be noticed more when towing. *tt
Bulletin:: 3436
Component:: 152000 seat belts:rear
Summary:: Second row seat belt does not buckle. *tt
Bulletin:: 3413
Component:: 062000 engine and engine cooling:cooling system
Summary:: Coolant leak. early indications point to a corrosion stress crack on the upper clamp at the lower radiator hose to the water pump connection. engineerng is testing....*tt
Bulletin:: 3317
Component:: 060000 engine and engine cooling
Summary:: Hard start / no start outside temperatures below freezing. *tt updated 7/13/09. *pe
Bulletin:: 3105
Component:: 100000 power train
Summary:: Ping, pop, snap or click noise from the propeller shaft. *tt
Bulletin:: 3343
Component:: 061000 engine and engine cooling:engine
Summary:: Engine oil dipstick unseated or oil leak. *tt
Bulletin:: 3685
Component:: 030000 service brakes, hydraulic
Summary:: Brake drag or highway speed vibration. *tt
Bulletin:: 3484A
Component:: 061000 engine and engine cooling:engine
Summary:: Intermittent stall, low power, and hard restart when the vehicle is used during high ambient temperatures and in high altitudes. *tt
Bulletin:: 3326
Component:: 030000 service brakes, hydraulic
Summary:: Creak/twang noise on brake pedal apply ore release. *tt
Bulletin:: 3616A
Component:: 091200 fuel system, other:storage:fuel gauge system
Summary:: Fuel gauge inoperative or inaccurate, the service engine soon malfunction indicator lamp on, or front fuel tank is over filled with fuel, to the top of the filler cap. *tt
Bulletin:: 3630A
Component:: 091200 fuel system, other:storage:fuel gauge system
Summary:: Fuel gauge is inaccurate or reads empty on diesel equipped chassis cab with dual tanks. *tt
Bulletin:: 3616
Component:: 091200 fuel system, other:storage:fuel gauge system
Summary:: Fuel gauge inaccurate/ diagnostic trouble code p0461 and or p2636/ transfer pump will not shut off. *tt
Bulletin:: 3573
Component:: 133000 visibility:power window devices and controls
Summary:: Unwanted operation of rear windows. *tt
Bulletin:: 3488
Component:: 103000 power train:automatic transmission
Summary:: Fluid leakage front pump or torque converter area. *tt
Bulletin:: 3424
Component:: 104000 power train:transfer case (4-wheel drive)
Summary:: Electronic transfer case unable to complete shift. *tt
Bulletin:: 3541A
Component:: 130000 visibility
Summary:: Front door glass will not move or rattle in door. *tt
Bulletin:: 3422
Component:: 073000 fuel system, gasoline:fuel injection system
Summary:: Duramax diesel pilot to main injection fuel knock noise. *tt
Bulletin:: 3728
Component:: 030000 service brakes, hydraulic
Summary:: Service vme - brake pulsation due to rotor corrosion. *tt
Bulletin:: 3569
Component:: 022520 suspension:rear:axle:non-powered axle assembly
Summary:: Service vme - 8.6 inch rear axle which exhibit a gear whine condition (until december 23, 2005). *tt
Bulletin:: 050861004
Component:: 161100 structure: frame and members:underbody shields
Summary:: Underbody rattle. *tt
Bulletin:: 050604008
Component:: 061000 engine and engine cooling:engine
Summary:: Diagnostic trouble code (dtc) p1172 or p2636, fuel gauge reads empty, service engine soon (ses) light on. *tt
Bulletin:: 050310005
Component:: 200000 wheels
Summary:: Handling characteristics of vehicles with 20 inch wheel/tire assemblies installed. *tt
Bulletin:: 050730013
Component:: 103000 power train:automatic transmission
Summary:: 4l60-e/4l65-e automatic transmission second gear start, lack/loss of power when accelerating from a stop. *tt
Bulletin:: 050730012
Component:: 103000 power train:automatic transmission
Summary:: 4l60-e/4l65-e automatic transmission 2-3 shift clunk. *tt
Bulletin:: 050138012
Component:: 353600 equipment:air conditioner
Summary:: Ei05082 - loss of blower motor speeds except for high speed or inoperative. *tt updated. *kb updated *kb
Bulletin:: 050850008
Component:: 221700 seats:front assembly:seat heater/cooler
Summary:: Intermittent heated seats inoperative, diagnostic trouble code b3941 set. *tt
Bulletin:: 05-06-04-047
Component:: 061000 engine and engine cooling:engine
Summary:: Service engine soon (ses) light on with reduction in engine power, diagnostic trouble codes p0202 and p2146 or p0207 and p2149 set. *tt add dtc p1294. install revised 90 degree injector connector with harness support bracket servi
Bulletin:: 050601014
Component:: 061000 engine and engine cooling:engine
Summary:: Oil leak under extreme cold temperatures (-34 degrees c) (-30 degrees f) or colder). *tt
Bulletin:: 3654
Component:: 126000 exterior lighting:turn signal
Summary:: Turn signals inoperative. *tt
Bulletin:: 0502118002
Component:: 010000 steering
Summary:: Diagnostic trouble code c0455, service rear wheel steering, system jumps from 4-wheel steer to 2-wheel steer. *tt
Bulletin:: 050730017
Component:: 103000 power train:automatic transmission
Summary:: 4l60-e/4l65-e automatic transmission/torque converter clutch (tcc) shudder, water in transmission. *tt
Bulletin:: 05-04-21-003
Component:: 104000 power train:transfer case (4-wheel drive)
Summary:: Service 4wd light illuminated, diagnostic trouble code (dtc) c0374 set. *tt updated 10/05/07. *nj inspect wiring harness to transfer case speed sensors, replace wiring harness. updated 7/18/08 *pe
Bulletin:: 050307006
Component:: 020000 suspension
Summary:: Revised wheel alignment specifications. *tt
Bulletin:: 0509610018
Component:: 060000 engine and engine cooling
Summary:: Accessory drive belt chirp, squeal, or squeak type noise at cold idle. *tt
Bulletin:: 05539
Component:: 103100 power train:automatic transmission:control module (tcm, pcm)
Summary:: Product emission recall to replace the powertrain/engine control module (pcm/ecm). the powertrain/engine control module (pcm/ecm) may have been manufactured with damaged internal ic chips, which may affect the fuel pump control and egr out
Bulletin:: 050601029
Component:: 061000 engine and engine cooling:engine
Summary:: Information on 4.3l engine front crankshaft pulley appearing to be out of round (normal condition). *tt
Bulletin:: 050604063
Component:: 061000 engine and engine cooling:engine
Summary:: Lm7, l59 or l33 engines with cold start rough or incorrect idle, misfire, malfunction indicator lamp (mil) or flashing requiring o2 sensor replacement. *tt
Bulletin:: 050850012
Component:: 220000 seats
Summary:: Unwanted/loose seat movement. *tt
Bulletin:: 3639
Component:: 060000 engine and engine cooling
Summary:: Oil pressure gauge reading low or near red zone. *tt
Bulletin:: 3609A
Component:: 100000 power train
Summary:: Harsh 1-2 shift, malfunction indicator lamp illuminated, diagnostic trouble code p0894 stored in pcm. *tt
Bulletin:: 3287B
Component:: 221700 seats:front assembly:seat heater/cooler
Summary:: Heated seat inoperative or shut off in 30 seconds. diagnostic trouble codes b2435, b2440, b3606 and/or b1825 set in the drivers seat module. *tt
Bulletin:: 3616
Component:: 090000 fuel system, other
Summary:: Service vme - 2006 duramax diesel engine fuel system components are not interchangeable with earlier year model vehicles. *tt
Bulletin:: 3766
Component:: 138110 visibility:defroster/defogger system:windshield:blower
Summary:: Front blower inoperative stay running during low ambient temperature. *tt
Bulletin:: 3100C
Component:: 060000 engine and engine cooling
Summary:: Ses light due to dtc p0116. *tt
Bulletin:: 3480A
Component:: 104000 power train:transfer case (4-wheel drive)
Summary:: Rattle noise at highway speed in 2wd. *tt
Bulletin:: 3691A
Component:: 138110 visibility:defroster/defogger system:windshield:blower
Summary:: Front hvac blower inoperative. *tt
Bulletin:: 3779
Component:: 030000 service brakes, hydraulic
Summary:: Squeak noise on brake apply. *tt
Bulletin:: 050849026
Component:: 060000 engine and engine cooling
Summary:: Low oil pressure message display and chimes activated while driving following hybrid (hp2) lm7 engine auto-start (reprogram the pcm). *ts
Bulletin:: 050601034
Component:: 060000 engine and engine cooling
Summary:: Engine oil leak at rear cover assembly area. *tt
Bulletin:: 3665
Component:: 104000 power train:transfer case (4-wheel drive)
Summary:: 4wd inoperative and possible dtc c0327 stored in the transfer case control module. *tt
Bulletin:: 3170E
Component:: 121000 exterior lighting:headlights
Summary:: Ipc, interior lights and/or headlamps flicker. *ak fb2
Bulletin:: 3673
Component:: 185000 vehicle speed control:cruise control
Summary:: Cruise control inoperative and/or malfunction indicator lamp on with diagnostic trouble code p0833 stored. the condition may not be able to be duplicated by the dealer yet the consumer may have a repeat concern. *ak
Bulletin:: 3691B
Component:: 061000 engine and engine cooling:engine
Summary:: Generation iii v8 engine piston repairs. *tt
Bulletin:: 060232001
Component:: 010000 steering
Summary:: Increased steering and brake effort. *tt
Bulletin:: 050235003A
Component:: 010000 steering
Summary:: Ei05061 - intermediate steering shaft clunk noise or stick-slip (follow strategy based diagnostics). 05-02-35-003 and 05-02-35-003a not yet received. *tt
Bulletin:: 060310003
Component:: 020000 suspension
Summary:: Information on p245/75r16 goodyear wrangler st tire usage/identification. *tt
Bulletin:: 050604077
Component:: 061000 engine and engine cooling:engine
Summary:: Lack of power lu3 engine) at high ambient temperatures only (if necessary, reprogram pcm with new service calibration).*ak
Bulletin:: 060308002
Component:: 021510 suspension:front:control arm:upper arm
Summary:: Revised upper control arm replacement. *tt
Bulletin:: 3630
Component:: 091200 fuel system, other:storage:fuel gauge system
Summary:: Inaccurate fuel gauge readings/rear float arm stuck. *tt updated 03-01-07. *kb updated 3/15/10. *pe
Bulletin:: 3401
Component:: 061120 engine and engine cooling:engine:gasoline:turbo-charger
Summary:: Turbocharger oil feed line kinked or restricted. *tt
Bulletin:: 3870
Component:: 101000 power train:clutch assembly
Summary:: Clutch pedal fade or clutch will not disengage typically when towing. *tt
Bulletin:: 3893
Component:: 116000 electrical system:ignition
Summary:: Loss of ignition 1 voltage to the ignition coils. consumer experienced intermittent stall, misfire, or crank no start. there may be no trouble codes set. *kb updated 3/17/09. *pe
Bulletin:: 3927
Component:: 103000 power train:automatic transmission
Summary:: Engine with a repeat cracked flywheel. *kb
Bulletin:: 3958
Component:: 044000 service brakes, air:drum
Summary:: Rear drum brakes excessive wear, drag, and aggressive. *kb
Bulletin:: 4150
Component:: 091200 fuel system, other:storage:fuel gauge system
Summary:: Dual tanks fuel gauge defaults to empty - new calibrations. stall start tank transfer. vehicles with 6.6l rpo lb7 or lly engines. *kb
Bulletin:: 060604026
Component:: 061000 engine and engine cooling:engine
Summary:: Intermittent ses/mil lamp illuminated, reduced engine power, fuel injector driver circuit. dtc's p0201, p0202, p0203, p0204, p0205, p0206, p0207, p0208. cylinder bank shut down dtc's p2146, or p2149. *kb
Bulletin:: 030693001
Component:: 061000 engine and engine cooling:engine
Summary:: Diagnostic information on turbocharger malfunction due to lack of engine oil for lbz, lb7, and lly duramax diesel engine. *kb
Bulletin:: 3340
Component:: 021244 suspension:front:springs:leaf spring assembly:u-bolt, leaf spring to axle
Summary:: Left front axle shaft difficult to remove. axle differential leak seal shaft. *kb
Bulletin:: 4024
Component:: 040000 service brakes, air
Summary:: Rear brake pulsation check drum to axle clearance, with rpo jf3 or jf7. *kb
Bulletin:: 3562
Component:: 190000 tires
Summary:: Bridgestone dueler product information update. *kb
Bulletin:: 3009
Component:: 020000 suspension
Summary:: Suspension vibration or frame beaming at 40 - 60 mph. *kb updated 8/25/08. *pe
Bulletin:: 3190
Component:: 110000 electrical system
Summary:: Unable to locate emergency light relay and/or blunt cut wires. *kb
Bulletin:: 4179
Component:: 140000 air bags
Summary:: Dual stage passenger air bag used in single stage application. *kb
Bulletin:: 3713
Component:: 133000 visibility:power window devices and controls
Summary:: Door glass pops out of run channel. *kb
Bulletin:: 3136
Component:: 102000 power train:manual transmission
Summary:: Slip condition in 2nd, 3rd, or 4th. damaged 2-4 or 3-4 clutch. *kb updated 10/31/07. *nj
Bulletin:: 4223
Component:: 190000 tires
Summary:: Bridgestone duravis tire chip and tear issue. *kb
Bulletin:: 4231
Component:: 061000 engine and engine cooling:engine
Summary:: Service vme. supplement to 00-02-35-003l. update on new i-shaft. *kb
Bulletin:: PIT4193
Component:: 190000 tires
Summary:: P245/70r17 general ameritrac tire wear vibration. *kb updated 12/13/07. *nj updated 1/30/08. *nj updated 5/25/11. *pe
Bulletin:: 3425
Component:: 190000 tires
Summary:: Unable to program tire size in ebcm/vses. *kb
Bulletin:: 060417002
Component:: 022520 suspension:rear:axle:non-powered axle assembly
Summary:: Rear drive axle whine noise (replace slip yoke assembly). *kb
Bulletin:: 010310010
Component:: 020000 suspension
Summary:: Inspection of tire and wheel size prior to diagnosis of transmission shifts, poor performance, speedometer, cruise control concerns. *kb
Bulletin:: 3568
Component:: 040000 service brakes, air
Summary:: Service brake booster message. *kb
Bulletin:: 4365
Component:: 330000 interior lighting
Summary:: Ipc backlighting inoperative tbc 2a fuse open. *kb
Bulletin:: 3656
Component:: 980000 unknown or other
Summary:: Lct1000 tow/haul indicator inoperative with rpo 5g8. *kb
Bulletin:: 4030
Component:: 106000 power train:axle assembly
Summary:: New design front axle side bearing adjusters. *kb
Bulletin:: 070601009
Component:: 061200 engine and engine cooling:engine:diesel
Summary:: Diesel engine cylinder head gasket missing thickness grade markings. *kb
Bulletin:: 060139002
Component:: 061000 engine and engine cooling:engine
Summary:: Front blower motor inoperative or may not shut off in extremely low ambient temperature conditions. *kb
Bulletin:: 4144
Component:: 102000 power train:manual transmission
Summary:: Allison lct1000 harsh 3-2, 2-1 downshift, and abs may activate. *kb
Bulletin:: 040525002
Component:: 046400 service brakes, air:antilock:abs warning light
Summary:: Abs light on, dtc's c0265, c0201, u1041 set and/or loss of communication with brake module. (reground ebcm ground). *kb
Bulletin:: 050232008
Component:: 015100 steering:hydraulic power assist:pump
Summary:: Gear box power steering pump, p/s performance concerns. *nj updated on 6/30/2011. *kb
Bulletin:: 3075
Component:: 115000 electrical system:fuses and circuit breakers
Summary:: Blown mbec 1 or lbec 1 fuse. *kb
Bulletin:: 4486
Component:: 117000 digital instrument panel
Summary:: One of the following concerns when programming the mileage or the hours into an exchange instrument panel cluster that is received from an electronic service center (esc). *nj
Bulletin:: 070842013
Component:: 126100 exterior lighting:turn signal:flasher unit
Summary:: Turn signal in camper style outside rearview mirror (rpo dpn) does not illuminate turn signal flash (replace upper mirror glass) *nj
Bulletin:: PIP-4290
Component:: 103100 power train:automatic transmission:control module (tcm, pcm)
Summary:: Engine surge or stall at stop and/or dtc p0742 possible tcc applied. equipped with allison lct1000 transmission rpo m74 or mw7. *nj updated 4/22/13. *pe
Bulletin:: PIP3394
Component:: 103100 power train:automatic transmission:control module (tcm, pcm)
Summary:: Duramax diesel injector driver codes with 6.6 engine (vin 2 - rpo lly). *nj
Bulletin:: PIP3343
Component:: 063110 engine and engine cooling:exhaust system:emission control:crankcase (pcv)
Summary:: Possible engine oil leak due to pcv freeze-up, equipped with the 4.8, 5.3, 6.0, and 6.2 v-8 engines. *nj
Bulletin:: PIP4054A
Component:: 022000 suspension:rear
Summary:: Eaton locking differential chatter shudder noise on turns, equipped with a locking rear differential rpo g80. *nj updated 7/17/2008. *pe
Bulletin:: 000235003N
Component:: 012000 steering:column
Summary:: Clunking noise under hood and can be felt in steering wheel and/or steering column (replace upper intermediate steering shaft [i-shaft] assembly). *pe
Bulletin:: 08136
Component:: 091200 fuel system, other:storage:fuel gauge system
Summary:: Chevrolet\gmc service campaign: see document search button for owner letter. on-board diagnostics (obd)-fuel level sender-reprogram engine control module (ecm). csc was received. *pe
Bulletin:: PIT3504D
Component:: 355200 equipment:other:owners/service/other manual
Summary:: Some customers may comment on various hvac concerns including temperature doors defaulting to full hot position or unable to obtain defrost position. *pe
Bulletin:: 08-089
Component:: 353000 equipment:electrical
Summary:: Buick\cadillac\chevrolet\gmc\hummer\oldsmobile\pontiac\saab\saturn service campaign: see document search button for owner letter. special coverage adjustment-analog onstar deactivation. fcc ruled in 2002 wireless carriers would no longer r
Bulletin:: PIT-3046E
Component:: 091200 fuel system, other:storage:fuel gauge system
Summary:: Gmc: fuel gauge fluctuation in park or neutral, causing the low fuel light to illuminate. *pe
Bulletin:: PIT-4722
Component:: 103600 power train:automatic transmission:cooling unit and lines
Summary:: Gmc: fluid leak from transmission oil cooler lines due to corrosion. all 2000-2006 light duty trucks equipped with the light duty automatic transmission. *pe
Bulletin:: 08-089B
Component:: 355200 equipment:other:owners/service/other manual
Summary:: Buick\chevrolet\gmc service campaign: see document search button for owner letter. special coverage adjustment-analog onstar deactivation. csc letter was received. *pe
Bulletin:: 08089-B
Component:: 110000 electrical system
Summary:: General motors corp: special coverage adjustment; analog onstar deactivation. *pe updated 2/17/09. *pe
Bulletin:: PIP-4629
Component:: 061200 engine and engine cooling:engine:diesel
Summary:: Chevrolet/gmc: diesel engine turbo dtc p2563 or p003a. may encounter a concern of ses light, reduced power, low power. *pe
Bulletin:: PIP-4492P
Component:: 061000 engine and engine cooling:engine
Summary:: Buick/cadillac/chevrolet/gmc/hummer/pontiac/saab: oil consumption and/or exhaust smoke-possible pcv baffle or lifter concern. upon inspection, obvious oil will be found in the intake manifold and/or pcv vacuum tube. *pe updated 3/21/
Bulletin:: SB-10-02-33-001
Component:: 010000 steering
Summary:: Buick/cadillac/chevrolet/gmc/oldsmobile and hummer: information on pitman arm shaft seal service kit. do not replace entire steering gear for pitman seal leak. technicians have been replacing entire steering gears due to not being able to
Bulletin:: 05-09-40-002E
Component:: 151200 seat belts:front:webbing
Summary:: Gm: service bulletin explaining when the safety belts are supposed to lock. *rm updated 12/6/11. *pe
Bulletin:: PIP-3504C
Component:: 061200 engine and engine cooling:engine:diesel
Summary:: Gm: there is a diesel engine hard start when hot. starts fine when cold. there will be no internal trouble codes. *rm
Bulletin:: PIT-3749D
Component:: 161000 structure:frame and members
Summary:: Gm: on some truck models there is some frame corrosion. *rm updated on 5/2/2012. *kb
Bulletin:: PIP-4138K
Component:: 060000 engine and engine cooling
Summary:: Gm: the service engine soon light is on, there is also a misfire or engine noise. there are multiple possible causes. *rm
Bulletin:: 09-09-40-001A
Component:: 150000 seat belts
Summary:: Gm: there are seat belt problems: difficulty latching and unlatching buckle. buckle release button is sticking. seat belt warning light illuminated. likely caused by sticky beverages that are spilled into the buckle assembly. *rm updated 4/
Bulletin:: 10-00-89-017C
Component:: 980000 unknown or other
Summary:: Gm: information on fixing multiple situations right the first time. *rm
Bulletin:: PI-0011A
Component:: 171100 latches/locks/linkages:doors:latch
Summary:: Gm: the front or rear door may not open from the inside or outside handle, the door will not unlock with any method. the probably cause an incorrect installation of a handle component. *rm updated on 7/26/2013. all 2014 and prior gm pass
Bulletin:: PB-10037A
Component:: 110000 electrical system
Summary:: Gm: onstar is making incomplete calls without the driver knowing. when have a data connection. *rm
Bulletin:: SB-10240
Component:: 353600 equipment:air conditioner
Summary:: General motors service campaign: see document search button for owner letter. the hvac blower may not work at certain functions or may become inoperable. there could be a burning smell or smoke. *rm updated 4/6/12. *pe
Bulletin:: PIP-3366-B
Component:: 103000 power train:automatic transmission
Summary:: Cadillac/chevrolet/gmc/hummer: some suvs and trucks are exhibiting a condition where by grinding/ratcheting type noise coming from automatic transmission when shifting into park while in 4wd low (4lo) range. *pe
Bulletin:: SB-13-05-22-001
Component:: 034100 service brakes, hydraulic:foundation components:master cylinder
Summary:: Chevrolet/gmc/cadillac: anytime hydraulic brake pipes assembly need replacing, pre-formed and pre-flared brake pipes are available, except rear axle crossover pipe. model 1999-2007 silverado, sierra, 2000-2006 escalade models, avalanche,
Bulletin:: SB-080604003-C
Component:: 060000 engine (pws)
Summary:: Gmc/chevrolet: engines, with egr system, has leakage from egr cooler engine coolant into the combustion chamber. model 2002-15 silverado, sierra, 2004-09 kodiak c4500-c5500, topkick c4500-c5500, 2006-15 express, savana. *pe
Bulletin:: UIB-117
Component:: 061000 engine and engine cooling:engine
Summary:: General motors: an optional engine block heater plug in for onboard ac power and with continuous usage will result in shorting of wires, over heating system, electrical failure and compartment engine fires. model 2003-15 express cut away
Bulletin:: 06-03-09-004H
Component:: 022140 suspension:rear:springs:leaf spring assembly
Summary:: This technical bulletin provides a procedure to lube the rear leaf springs on vehicles with the condition of a squeak noise originating from the rear of the vehicle.
Bulletin:: PIT5195A
Component:: 117000 digital instrument panel
Summary:: This preliminary information communication provides information to the technician about vehicles that the speedometer needle appears to be inaccurate. dealer should advise the customer the specification for speedometer needle accuracy is +/
Bulletin:: PIT3227J
Component:: 162500 structure:body:tailgate
Summary:: This preliminary information communication provides information to the technician about vehicles that may have slack in one of the tailgate cables. technician should not replace any parts for this concern. please communicate to the customer
Bulletin:: PIP3119M
Component:: 060000 engine (pws)
Summary:: This preliminary information communication provides information to the technician on the steps to diagnose and repair vehicles that may have a service engine soon malfunction indicator lamp on at low mileage. technician may find diagnostic
Bulletin:: PIT4780Q
Component:: 100000 hybrid powertrain
Summary:: This preliminary information communication advises the technician that parallel hybrid truck parts are on parts restriction. dealer will need to call general motors technical assistance center for further assistance.
Bulletin:: 06-06-01-010C
Component:: 060000 engine (pws)
Summary:: This informational bulletin provides information on close coupled converters and there affect on newly installed engines or engines during there break in period.
Bulletin:: 03-08-46-004R
Component:: 353000 equipment:electrical
Summary:: This informational bulletin provides information on part restriction and ordering process information for onstar vehicle communication interface modules (vcim) (gmna only)
Bulletin:: PIT3237G
Component:: 131000 visibility:windshield
Summary:: This preliminary information communication provides information to the technician about the percentage of uv protection or tint offered by the windshield or side glass. technician should be advised windshield reduces uv rays down to 4% or l
Bulletin:: PIP4379K
Component:: 103000 power train:automatic transmission
Summary:: This preliminary information communication provides information to the technician about vehicles that have not engagement into drive, delayed, no engagement into reverse, and or a range inhibit. technician may find diagnostic trouble codes
Bulletin:: PIT3189R
Component:: 110000 electrical system
Summary:: This preliminary information communication provides information to the technician about customers that are unable to override the automatic door locking feature. technician will update the body control module on 2006 to 2007 model years. on
Bulletin:: PIT3078F
Component:: 021700 suspension:front:hub
Summary:: This preliminary information communication provides information to the technician about vehicles that have grease leaking from front hub bearings. technician should not replace the bearing for grease purge. technician should be advised to n
Bulletin:: PIP5072
Component:: 101000 power train:clutch assembly
Summary:: This preliminary information communication provides information to the technician about vehicles that have slip in forward ranges immediately after replacing the input housing. technician will inspect the 3-4 clutches and the forward clutch
Bulletin:: PIT3665C
Component:: 030000 brakes (pws)
Summary:: This preliminary information communication advises the technician that the hydro-boost is not serviceable and will need to be replaced if the brake pedal moves or applies on its own at a full turn.
Bulletin:: PIT3330F
Component:: 353600 equipment:air conditioner
Summary:: This preliminary information communication provides information to the technician about customers may inquire about the availability of the passenger compartment air filter. dealer should advise the customer starting in 2003 the passenger c
Bulletin:: PIT3271F
Component:: 190000 tires
Summary:: This preliminary information communication provides information to the technician about changing the tire and wheel size on vehicles. general motors will only support a tire calibration for tires that have been sized, tested and designed fo
Bulletin:: PIP3259J
Component:: 100000 power train
Summary:: This preliminary information communication provides information to the technician about vehicles that may have a planetary gear whine noise in first and second gear. technician should compare the noise to a like vehicle. technician will nee
Bulletin:: PIP4138L
Component:: 100000 power train
Summary:: This preliminary information communication provides information to the technician about vehicles that have a service engine soon malfunction indicator lamp on, engine misfire, and/or engine noise. technician may find diagnostic trouble code
Bulletin:: PIT5195
Component:: 117000 digital instrument panel
Summary:: This preliminary information communication provides information to the technician about vehicles that the speedometer needle appears to be inaccurate. dealer should advise the customer the specification for speedometer needle accuracy is +/
Bulletin:: PIP4972C
Component:: 110000 electrical system
Summary:: This preliminary information communication provides information to the technician about vehicles that will not move in forward or reverse. technician may find diagnostic trouble code p0877 or p2723 set. technician will need to inspect the v
Bulletin:: PIT4780M
Component:: 100000 hybrid powertrain
Summary:: This preliminary information communication advises the technician that the 2004-2007 parallel hybrid truck parts will be placed on restriction through the general motors technical assistance center. dealer will need to contact general motor
Bulletin:: PIP3119L
Component:: 060000 engine and engine cooling
Summary:: This preliminary information communication provides information to the technician on the steps to diagnose and repair vehicles that may have a service engine soon malfunction indicator lamp on at low mileage. technician may find diagnostic
Bulletin:: PIT3665E
Component:: 031000 service brakes, hydraulic:pedals and linkages
Summary:: This preliminary information communication advises the technician that the hydro-boost is not serviceable and will need to be replaced if the brake pedal moves or applies on its own at a full turn.
Bulletin:: PIT3227M
Component:: 162500 structure:body:tailgate
Summary:: This preliminary information communication provides information to the technician about vehicles that may have slack in one of the tailgate cables. technician should not replace any parts for this concern. please communicate to the customer
Bulletin:: 00-03-10-003R
Component:: 190000 tires
Summary:: This warranty administration bulletin provide policy information new tire warranty program and global warranty management submission information.
Bulletin:: 06-06-01-010B
Component:: 060000 engine and engine cooling
Summary:: This informational bulletin provides information on close-coupled converter and engine replacement.
Bulletin:: 05-00-89-055E
Component:: 356000 equipment adaptive
Summary:: This warranty administration bulletin provides information to clarify proper transaction administration of gm dealer empowerment program and goodwill cases.
Bulletin:: 15-08-44-001B
Component:: 353000 equipment:electrical
Summary:: This informational bulletin provides information on a gm of canada onstar® cellular communication upgrade.
Bulletin:: 15-08-44-001A
Component:: 353500 equipment:electrical:navigational system(global positioning system)
Summary:: This informational bulletin provides information on a gm of canada onstar® cellular communication upgrade.
Bulletin:: 05-06-04-035E
Component:: 090000 fuel system, other
Summary:: This informational bulletin provides dealership personnel with information on flexible fuel vehicles (ffvs) and the usage of e85 fuel in gm vehicles.
Bulletin:: 02-07-30-052J
Component:: 103000 power train:automatic transmission
Summary:: This informational bulletin provides technicians with information regarding automatic transmission oil cooler flow test essential tool j-45096 transflow®.
Bulletin:: 02-00-89-002O
Component:: 356000 equipment adaptive
Summary:: This informational bulletin provides information for dealers/technicians on when and how to submit a field product report (fpr) (u.s. dealers only).
Bulletin:: 07-06-04-019E
Component:: 060000 engine and engine cooling
Summary:: This technical bulletin provides repair information for repairing the ip to body harness connector to correct a customer concern for intermittent malfunction indicator lamp (mil) illuminated with reduced engine power displayed and dtc p21
Bulletin:: 15-08-44-001
Component:: 353000 equipment:electrical
Summary:: This informational bulletin provides information on a gm of canada onstar® cellular communication upgrade.
Bulletin:: 15-08-73-001
Component:: 353000 equipment:electrical
Summary:: This informational bulletin provides information on communication with onstar® module after canadian cellular upgrade.
Bulletin:: 00-05-22-002O
Component:: 030000 brakes (pws)
Summary:: This informational bulletin provides technicians with a brake lathe calibration procedure.
Bulletin:: 09-09-40-001C
Component:: 150000 seat belts
Summary:: This informational bulletin provides information to advise dealers about seat belt buckles not operating and/or seat belt warning light illumination, as well as difficulty latching and unlatching the buckle or the buckle release button stic
Bulletin:: 00-06-01-026G
Component:: 060000 engine and engine cooling
Summary:: This informational bulletin provides information to technicians regarding intake manifold inspection/replacement after severe internal engine damage.
Bulletin:: 15-00-89-005
Component:: 356000 equipment adaptive
Summary:: This warranty administration bulletin provides dealership personnel with policy and procedure requirements for essential tools that include consumable parts (u.s. only).
Bulletin:: 10-00-89-017X
Component:: 356000 equipment adaptive
Summary:: This informational bulletin provides a list off all the issues revolving around new vehicles for a one stop place to find growing concerns around them.
Bulletin:: 11-00-89-005C
Component:: 356000 equipment adaptive
Summary:: This warranty administration bulletin provides information on the clarification of use for dealer empowerment labor operations and customer enthusiasm
Bulletin:: 08-08-44-015E
Component:: 353000 equipment:electrical
Summary:: This informational bulletin provides information on inappropriate warranty claims submitted for damaged radios and ipcs
Bulletin:: 07-08-49-020I
Component:: 356000 equipment adaptive
Summary:: This informational bulletin provides a quick guide to updating which model vehicle after replacing the ipc.
Bulletin:: 06-08-43-003E
Component:: 136000 visibility:windshield wiper/washer
Summary:: This informational bulletin explains how to care for wiper blades.
Bulletin:: PIC4310K
Component:: 353000 equipment:electrical
Summary:: This preliminary information communication provides information to the technician about vehicle that may have an onstar system that has progression tones when pressing the blue or red button. technician will need to call general motors tech
Bulletin:: PIC3278F
Component:: 353000 equipment:electrical
Summary:: This preliminary information communication provides information to the technician the steps needed to diagnose and repair the vehicles that may have unwanted or phantom phone calls. technician will need to determine what type of call the cu
Bulletin:: PIT3271G
Component:: 190000 tires
Summary:: This preliminary information communication provides information to the technician about changing the tire and wheel size on vehicles. general motors will only support a tire calibration for tires that have been sized, tested and designed fo
Bulletin:: PIT5264C
Component:: 353000 equipment:electrical
Summary:: This preliminary information communication provides information to the technician about vehicles that are travelling from canada to the united states. while in the united states they are unable to receive turn-by-turn directions. due to the
Bulletin:: PIC5953A
Component:: 353000 equipment:electrical
Summary:: This preliminary information communication provides information to the technician about vehicles that may have an issue when using bluetooth voice recognition with an iphone. technician should work with the customer to insure the phone cont
Bulletin:: PIC4310L
Component:: 110000 electrical system
Summary:: This preliminary information communication provides information to the technician about vehicle that may have an onstar system that has progression tones when pressing the blue or red button. technician will need to call general motors tech

Home | Privacy