2005 BMW K1200 R SPORT Recalls (2)
- Campaign:
- 07V066000 on 02/22/2007
- Component:
- Engine and engine cooling
- Manufactured:
- 06/29/2005 - 12/30/2006
- Affected:
- 6,631
- Defect:
- On certain motorcycles, frequent short trips particularly during cold temperatures, can cause water to accumulate in the oil tank, and when the engine is running, escaping water vapor can condense on the oil tank air bleed valve. in freezing temperatures, this water could freeze and block the air bleed valve.
- Consequence:
- It is possible that a pressure build up in the oil tank could cause it to rupture, allowing oil to leak onto the rear tire. an oil leak could cause a fire. oil on the rear tire could cause loss of control.
- Correction:
- Dealers will install a new oil tank cap containing a valve to prevent overpressure in the tank free of charge. the recall began on april 10, 2007. owners may contact bmw at 1-800-831-1117.
- Notes:
- Customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.
- Campaign:
- 07V466000 on 10/03/2007
- Component:
- Service brakes, hydraulic:fluid
- Manufactured:
- 06/22/2005 - 07/18/2007
- Affected:
- 510
- Defect:
- On certain motorcycles, during long periods of riding at sustained high engine rpm, vibration within the brake fluid reservoir can cause the brake fluid to foam. this could allow air to enter the front brake system which could lead to a loss of front braking efficiency.
- Consequence:
- Air in the brake system can lead to a loss of braking capability, increasing the risk of a crash.
- Correction:
- Dealers will bleed the front brakes and install a damper weight in the brake fluid reservoir. this weight will dampen possible vibrations that can cause foaming of the brake fluid. the recall began on december 14, 2007. owners may contact bmw at 1-800-831-1117.
- Notes:
- Customers may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov.
2005 BMW K1200 R SPORT TSBs (13)
- Bulletin:
- 13-003-07
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Bmw motorcycle: idle speed too high. the cause is incorrect idle air metering by the idle actuator. *pe
- Bulletin:
- 33-001-08
- Component:
- 020000 suspension
- Summary:
- Bmw motorcycle: conversion of rear esa spring strut from potentiometer to hall sensor. *pe
- Bulletin:
- SIB-61-001-08
- Component:
- 022100 suspension:rear:springs
- Summary:
- Bmw motorcycles: esa rear spring strut cannot be calibrated with the gt1, cip error 14007. all models with esa, except r1200r (k27), r1200gs (k25/11) and r1200gs adv. (k25/12). model years unknown. *pe
- Bulletin:
- TSB-34-004-07
- Component:
- 035000 service brakes, hydraulic:fluid
- Summary:
- Bmw: vibrations on a long ride at constant high engine rpm can, under certain circumstances, cause foaming of the brake fluid in the brake fluid reservoir of the front brakes. the possibility of this foaming causing air to enter the brake s
- Bulletin:
- SB-17927831-02
- Component:
- 045000 service brakes, air:disc
- Summary:
- Bmw motorcycle: wheel speed dependent, clearly audible clanking noise occurs when braking to adjust speed. e series (k25; k25/02; k25/03; k25/11; k25/12; k25/hp; k26; k27; k28; k29; k29/hp; k40; k41; k43; k43/hv; k44; k589/03; k71). no mod
- Bulletin:
- SB-00-021-07
- Component:
- 090000 fuel system, other
- Summary:
- Bmw motorcycle: engine fuels containing ethanol. bmw motorrad has no objection to the use of si engine fuels containing up to a maximum of 10% ethanol and imposes no warranty restrictions. ethanol mixtures in proportions higher than 10%
- Bulletin:
- SIB-16-02-09
- Component:
- 072100 fuel system, gasoline:delivery:fuel pump
- Summary:
- Bmw vehicles: fuel level sensor repairs. where it is necessary to replace the right or the left side fuel level sensor due to a failure, the entire pump and housing or delivery unit (suction jet assembly) do not need to be replaced as wel
- Bulletin:
- SIB-63-02-01
- Component:
- 120000 exterior lighting
- Summary:
- Bmw: procedure for determining and replacing incandescent and halogen light bulbs under warranty. *rm
- Bulletin:
- SIB-16-002-14
- Component:
- 071000 fuel system, gasoline:storage
- Summary:
- Bmw mc: see document search button for owner letter. information provided regarding the warranty extension, with out mileage limitations, to 12 years due to a potential durability issue with film type fuel level sender fuel strip. model
- Bulletin:
- MC64010520
- Component:
- 117000 digital instrument panel
- Summary:
- Incorrect tire pressure appears in the instrument cluster. contamination or obstruction of the rdc sensor.
- Bulletin:
- MC62813747
- Component:
- 060000 engine (pws)
- Summary:
- Oil leak at theseal between the cylinder head cover and cylinder head on the right in the direction of travel. due to retrofit of chain gauide which prevents skipping of the timing chain.
- Bulletin:
- MC61461571
- Component:
- 121000 exterior lighting:headlights
- Summary:
- Mist forms in the headlight. this is due to condensation and goes away again.
- Bulletin:
- MC62133778
- Component:
- 350000 equipment
- Summary:
- Map data should be stored on a 64 gb sd card. in garmin express the note appears that a maximum of 32 gb is possible.
Home | Privacy