2004 VOLKSWAGEN TOUAREG Recalls (4)
- Campaign:
- 03V266000 on 07/31/2003
- Component:
- Electrical system:wiring
- Manufactured:
- 03/31/2003 - 07/24/2003
- Affected:
- 670
- Defect:
- On certain sport utility vehicles, the tire pressure monitoring system (tpms) wiring harness may have been improperly routed during assembly. an improperly routed tpms wiring harness may contact the parking brake cable spring.
- Consequence:
- If this happens, the tpms wiring circuit could be interrupted, resulting in an inoperative tpms, and causing a short-to-ground condition that could potentially result in a fire.
- Correction:
- Dealers will inspect the tpms wiring harness routing and, if necessary, correct the wiring harness routing. owner notification began august 18, 2003. owners should contact vwoa at 1-800-893-5298.
- Notes:
- Vw recall no. ws.customers can also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
- Campaign:
- 04V233000 on 05/25/2004
- Component:
- Seat belts:rear
- Manufactured:
- 03/31/2003 - 12/30/2003
- Affected:
- 24,269
- Defect:
- On certain sport utility vehicles, the rear seat belt latch attachment bolt may have been insufficiently riveted.
- Consequence:
- In the event of a crash, the seat occupant may not be properly restrained increasing the risk of personal injury.
- Correction:
- Dealers will inspect and, if necessary, replace the belt buckle. owner notification began on june 21, 2004. owners should contact volkswagen at 1-800-822-8987.
- Notes:
- Vwoa recall no. vn.customers can also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
- Campaign:
- 04V592000 on 12/19/2004
- Component:
- Seat belts
- Manufactured:
- 03/25/2003 - 09/19/2004
- Affected:
- 50,483
- Defect:
- Certain passenger cars fail to comply with the requirements of federal motor vehicle safety standard no. 208, "occupant crash protection." all three rear seat positions and the front passenger position are equipped with seat belt retractors that have a locking feature which converts the retractor from an emergency locking retractor (elr) mode to an automatic locking retractor (alr) mode for the purposes of child restraint installation. the belt may deactivate the alr mode with certain child restraints.
- Consequence:
- When involved in a crash, the child restraints may not be properly secured, increasing the risk of injuries or death.
- Correction:
- Dealers will permanently install a 'clip' in each of the two rear outboard seat belts. the clips will prevent unwanted deactivation of the alr mode with child seat installations. the recall began on april 11, 2005. owners should contact vw at 1-800-822-8987.
- Notes:
- Vw recall no. uy.customers can also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
- Campaign:
- 17V583000 on 09/21/2017
- Component:
- Fuel system, gasoline:delivery:fuel pump
- Manufactured:
- 02/17/2003 - 11/29/2006
- Affected:
- 73,941
- Defect:
- Volkswagen group of america, inc. (volkswagen) is recalling certain 2004-2007 touareg vehicles. these gasoline-powered vehicles have a fuel filter flange that may crack, allowing fuel to leak.
- Consequence:
- A fuel leak in the presence of an ignition source increases the risk of a fire.
- Correction:
- Volkswagen will notify owners, and dealers will inspect the fuel filter flange for cracks, replacing the flange if cracks are found. if no cracks are found, a protective cover will be installed onto the filter flange. these repairs will be performed free of charge. the recall began march 9, 2018. owners may contact volkswagen customer service at 1-800-893-5298. volkswagen's number for this recall is 20ai.
- Notes:
- Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.
2004 VOLKSWAGEN TOUAREG TSBs (131)
- Bulletin:
- 0302
- Component:
- 199000 tires:pressure monitoring and regulating systems
- Summary:
- Tire pressure monitoring system, warning light is on. *tt
- Bulletin:
- 0303
- Component:
- 123000 exterior lighting:tail lights
- Summary:
- Tail light assembly, removal procedure. *tt this bulletin replaces 0303 dated 09/30/2003. *tt
- Bulletin:
- 0401
- Component:
- 353000 equipment:electrical
- Summary:
- Radio frequency remote control transmitter functions only at close range. *tt
- Bulletin:
- 0407
- Component:
- 110000 electrical system
- Summary:
- Update programming (flashing) trailer control module. *tt
- Bulletin:
- 0402
- Component:
- 199000 tires:pressure monitoring and regulating systems
- Summary:
- Tire pressure monitoring system, antenna update. *tt
- Bulletin:
- 0401
- Component:
- 020000 suspension
- Summary:
- Instrument cluster multi-function display shows an air suspension error message. diagnostic trouble codes (dtcs) 00774, 00775, 00776, 01769 may also be stored in memory. *tt
- Bulletin:
- 0402
- Component:
- 131000 visibility:windshield
- Summary:
- Windshield, condensation on exterior lower center during warm/humid weather conditions. *mj
- Bulletin:
- 0413
- Component:
- 103100 power train:automatic transmission:control module (tcm, pcm)
- Summary:
- Update programming (flashing) transmission control module (tcm) for harsh shifting. *mj
- Bulletin:
- 0401
- Component:
- 110000 electrical system
- Summary:
- Malfunction indicator lamp (mil) on with diagnostic trouble codes (dtc) p1347/17755 and p1340/17748 stored in memory. including various models volkswagen 2002-2003. *mj
- Bulletin:
- 0402
- Component:
- 104000 power train:transfer case (4-wheel drive)
- Summary:
- Transfer case, checking/replacement. *mj
- Bulletin:
- 0402
- Component:
- 980000 unknown or other
- Summary:
- During low speed turns/maneuvering vehicle feels as if it is binding/tires scrubbing. *mj
- Bulletin:
- 0404
- Component:
- 199000 tires:pressure monitoring and regulating systems
- Summary:
- Tire pressure monitoring system, module coding. *mj
- Bulletin:
- 0401
- Component:
- 110000 electrical system
- Summary:
- Rear hatch glass, open warning displayed in multi-function display. *mj
- Bulletin:
- 0402
- Component:
- 141100 air bags:frontal:sensor/control module
- Summary:
- Airbag light in instrument cluster is on and one or both of the following diagnostic trouble codes are stored in diagnostic trouble codes (dtc) memory. *mj
- Bulletin:
- 0403
- Component:
- 140000 air bags
- Summary:
- Passenger occupant detection system (pods) fault. *mj
- Bulletin:
- 0415
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Customer states vehicle hesitates. *mj
- Bulletin:
- 0405
- Component:
- 111000 electrical system:battery
- Summary:
- Automatic battery cutoff switch (bcs), malfunctioning resulting in battery discharge. *mj
- Bulletin:
- VQ
- Component:
- 015000 steering:hydraulic power assist system
- Summary:
- A rubber part can rub against the power steering and/or transmission fluid lines located behind the radiator grille. this rubbing can lead to corrosion of the lines and possibly even a fluid leak. *tt
- Bulletin:
- 0401
- Component:
- 116100 electrical system:ignition:switch
- Summary:
- Ignition/starter switch -e415- deletion of emergency key release feature. *tt
- Bulletin:
- 0417
- Component:
- 140000 air bags
- Summary:
- Airbag monitoring light on, passenger occupant detection system (pods), diagnostic trouble code 02511 014 stored. *tt
- Bulletin:
- 0403
- Component:
- 116000 electrical system:ignition
- Summary:
- Ignition key emergency release revision. *tc
- Bulletin:
- 0402
- Component:
- 116000 electrical system:ignition
- Summary:
- Starter does not crank, engine does not start. *tc
- Bulletin:
- 0501
- Component:
- 110000 electrical system
- Summary:
- Air suspension, (dtc) diagnostic trouble code 01772 008 stored in dtc memory. supersedes 0402 dated december 20, 2004. *tt
- Bulletin:
- 0405
- Component:
- 199000 tires:pressure monitoring and regulating systems
- Summary:
- Tire pressure monitoring system (tpms), diagnosing. *tt
- Bulletin:
- 0402
- Component:
- 111000 electrical system:battery
- Summary:
- Battery cut-off switch, disconnecting and removing during the pre-delivery inspection (pdi). this bulletin supersedes group 00 number 04-02 dated apr 6, 2004 and group 00 number 04-03 dated apr 28, 2004. *tt
- Bulletin:
- 0502
- Component:
- 110000 electrical system
- Summary:
- Diagnostic trouble code (dtc) p1603 (18011) stored in dtc memory. *tt
- Bulletin:
- 0402
- Component:
- 113000 electrical system:starter assembly
- Summary:
- Starter, does not crank, engine does not start; key cannot be removed from ignition switch. supersedes bulletin 04-02 dated nov 19, 2004. *tt
- Bulletin:
- 010504
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Customer states vehicle hesitates. *tt
- Bulletin:
- 690402
- Component:
- 142000 air bags:side/window
- Summary:
- Side airbag igniter, diagnostic trouble code(s) (dtcs) stored in dtc memory. original not received. *tt
- Bulletin:
- 940501
- Component:
- 123000 exterior lighting:tail lights
- Summary:
- Tail light assembly, difficult to remove or lens cracks during removal. *tt
- Bulletin:
- 0502
- Component:
- 060000 engine and engine cooling
- Summary:
- Starter does not crank, engine does not start; key cannot be removed from ignition switch. *eh update. *tt
- Bulletin:
- 0501
- Component:
- 105500 power train:driveline:differential unit
- Summary:
- Required rear final drive differential gear oil change. *tt
- Bulletin:
- 0502
- Component:
- 162300 structure:body:door
- Summary:
- Exterior door handle sticks in the opened position after door is opened. *tt
- Bulletin:
- VC
- Component:
- 355100 equipment:other:labels
- Summary:
- Install mercury label on vehicles registered in the states of vermont, maine and connecticut - environmental compliance action circular. *tt
- Bulletin:
- 0501
- Component:
- 190000 tires
- Summary:
- Dissatisfaction with length of tread life / ware rate of oe tire application. *tt
- Bulletin:
- 0512
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- Trailer lights inoperative, update programming (flashing) trailer control module. *sc
- Bulletin:
- 0502
- Component:
- 090000 fuel system, other
- Summary:
- Replace flexible fuel sensor -g133- and re-prime fuel system. *tt
- Bulletin:
- 0503
- Component:
- 110000 electrical system
- Summary:
- Module, vehicle position recognition control -j603-, diagnosis. *tt
- Bulletin:
- 0509
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Malfunction indicator lamp (mil) is on, diagnostic trouble codes (dtcs) p1411, p1423, secondary air injection system bank 1, bank 2, flow too low are stored in dtc memory. *tt
- Bulletin:
- 0515
- Component:
- 060000 engine and engine cooling
- Summary:
- Update programming to eliminate possible engine stumble or rough running condition (od). *tt
- Bulletin:
- 0403
- Component:
- 199000 tires:pressure monitoring and regulating systems
- Summary:
- Tire pressure system, warning light is on. *ak
- Bulletin:
- 0402
- Component:
- 199000 tires:pressure monitoring and regulating systems
- Summary:
- Tire pressure monitoring system displays error in instrument cluster. *tt
- Bulletin:
- 0601
- Component:
- 117000 digital instrument panel
- Summary:
- Self leveling suspension, error message displayed in multi-function display. instrument panel malfunction. *kb
- Bulletin:
- 270701
- Component:
- 112000 electrical system:alternator/generator/regulator
- Summary:
- Generator, insufficient ouput equipped with hid/bi-xenon headlamps and/or air suspension. *kb
- Bulletin:
- 01222007
- Component:
- 980000 unknown or other
- Summary:
- Update programming. *kb
- Bulletin:
- 5
- Component:
- 062000 engine and engine cooling:cooling system
- Summary:
- Product update circular. install improved air filter housing and inspect/replace battery cable, if necessary. *kb
- Bulletin:
- 2010617
- Component:
- 199000 tires:pressure monitoring and regulating systems
- Summary:
- Tire pressure monitoring system (tpms). *kb
- Bulletin:
- 2014628
- Component:
- 162300 structure:body:door
- Summary:
- Door, front or rear inner release handle remains in open position when exiting the vehicle. *kb
- Bulletin:
- 2014708
- Component:
- 103000 power train:automatic transmission
- Summary:
- Transmission, indicator illuminated in instrument cluster. *kb
- Bulletin:
- 90D7
- Component:
- 142000 air bags:side/window
- Summary:
- Volkswagen service campaign: see document search button for owner letter. 2004-2005 my touareg - inspect driver's and passenger's side impact airbag connectors and install wiring harness kit(s), if necessary. csc was received. *nj
- Bulletin:
- 44 08 01
- Component:
- 199000 tires:pressure monitoring and regulating systems
- Summary:
- Tire pressure monitoring system (tpms), diagnosing. *nj
- Bulletin:
- 01 08 11
- Component:
- 118000 electrical system: software
- Summary:
- Update programming, mil on, dtc's p0420 and/or p0430 stored in ecm fault memory. *nj
- Bulletin:
- 2015831
- Component:
- 063000 engine and engine cooling:exhaust system
- Summary:
- Volkswagen: exhaust heat shield, replacement guidelines. heat shields are to be inspected after completion o any type of repair to the underbody (exhaust system transmission, etc.), and if damaged, replaced. *pe
- Bulletin:
- TB-97-09-02
- Component:
- 114000 electrical system:wiring
- Summary:
- Volkswagen: the wiring harness located on the driver's side floor pan near the a pillar may have a corroded splice(s) connection. locate splice to determine possible corrosion. repair wiring as per repair manual. *pe
- Bulletin:
- TB-87-08-02
- Component:
- 353600 equipment:air conditioner
- Summary:
- Volkswagen: a/c inoperative, evaporator temperature sensor-g308-damaged or dislodged. symptoms can be poor heat, no cooling, or insufficient cooling. *pe
- Bulletin:
- SB-28F3
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Volkswagen: vehicles may have ignition coils that could malfunction under certain conditions. if this happens, the malfunction indicator lamp (mil) will illuminated to let you know that the vehicle may experience some deterioration in per
- Bulletin:
- TB-01-09-16
- Component:
- 052000 parking brake:driveline
- Summary:
- Volkswagen: drivetrain binding/tires scrubbing during low speed maneuvering, esp light in instrument cluster on or flashing. tension in drivetrain; vibration and load sensitive knocking from the drivetrain; cracking noise upon acceleration
- Bulletin:
- SA-28F3
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Volkswagen: (revised) vehicles may have ignition coils that could malfunction under certain conditions. if this happens, the malfunction indicator lamp (mil) will illuminated to let you know that vehicle may experience some deterioration
- Bulletin:
- TSB-28-10-02
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Volkswagen: mil on or flashing, misfire dtcs p0300-0312 stored in ecm. the misfire condition may be caused by a malfunctioning ignition coil. vehicles are out of production. *pe
- Bulletin:
- TB-00-10-06
- Component:
- 510000 child seat:latch connector
- Summary:
- Volkswagen: child restraint latch guidance fixture; compliance with fmvss 225 (usa only). update to existing technical bulletin. no production change required. all models. *pe
- Bulletin:
- SAC-28F3/P1-REV
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Volkswagen: gasoline engine vehicles inspect, and if necessary, replace ignition coils. vehicles affected by this action may have ignition coils that could malfunction under certain conditions. models passat and wagon; golf; gti; jetta a
- Bulletin:
- SA-28F6
- Component:
- 061200 engine and engine cooling:engine:diesel
- Summary:
- Volkswagen service campaign: see document search button for owner letter. engine software may cause the vehicle to exceed emissions standards. *rm
- Bulletin:
- TB-35-11-01
- Component:
- 013000 steering:gear box (other than rack and pinion)
- Summary:
- Volkswagen: the gear box has a momentarily delay while accelerating. *rm
- Bulletin:
- TB-01-11-29
- Component:
- 105000 power train:driveline
- Summary:
- Volkswagen: certain model year vehicles experience tire rubbing or binding of drivetrain at low speed and the instrument cluster light would be on or flashing. *pe
- Bulletin:
- TB-01-12-04
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Volkswagen: gasoline engines have rough idle, have significant loss of power or stalling with reduced performance. *pe
- Bulletin:
- VWP-13-17
- Component:
- 121000 exterior lighting:headlights
- Summary:
- Volkswagen: information provided regarding warranty information, on some vehicles, for factory installed hid headlight bulb(s) limited extension warranty. models 2004-2007 touareg. *pe
- Bulletin:
- 2039001
- Component:
- 162300 structure:body:door
- Summary:
- Summary to be provided on a future date.
- Bulletin:
- TT42-08-01
- Component:
- 020000 suspension
- Summary:
- Summary to be provided on a future date.
- Bulletin:
- TT57-12-02
- Component:
- 350000 equipment
- Summary:
- Summary to be provided on a future date.
- Bulletin:
- 2031104
- Component:
- 060000 engine (pws)
- Summary:
- Summary to be provided on a future date.
- Bulletin:
- TT 96-12-08
- Component:
- 113000 electrical system:starter assembly
- Summary:
- Summary to be provided on a future date.
- Bulletin:
- TT 97-14-02
- Component:
- 110000 electrical system
- Summary:
- Tech tip denoting potential for damage of the data link connector when using after market plug in devices or scan tools and subsequent diagnostic direction.
- Bulletin:
- TT 50-14-01
- Component:
- 190000 tires
- Summary:
- Tech tips (all vehicles-tire dressing for vehicle detailing): the use of tire dressing gives your tires that shiny finish that completes the image of a clean (new) vehicle. this document informs that the use of non-water based products wil
- Bulletin:
- V941403 2011521
- Component:
- 120000 exterior lighting
- Summary:
- Technical bulletin (exterior lights, moisture accumulation): this document informs of the condensation and or water droplets visible on inside of exterior light lenses. the document also informs how to service the issue.
- Bulletin:
- TT 32-14-01
- Component:
- 103700 power train:automatic transmission:torque converter
- Summary:
- Tech tips (torque converter/flywheel/flexplate installation): incorrect torque converter or flywheel/flexplate installation can result in transmission damage. when installing an engine, flywheel or transmission, please follow the installat
- Bulletin:
- Quick Reference
- Component:
- 118000 electrical system: software
- Summary:
- Quick reference update guide: this document informs of the corresponding software/hardware and disc availability to the customer concerns about a vehicle
- Bulletin:
- V871409 2019947
- Component:
- 353600 equipment:air conditioner
- Summary:
- Technical bulletin (air conditioning, cleaning of the refrigerant circuit): in cases where an air conditioning system component (such as a compressor or other system component) has failed and debris from the compressor or component is circ
- Bulletin:
- V171404 2012855
- Component:
- 060000 engine (pws)
- Summary:
- Technical bulletin (engine oils which meet volkswagen oil quality standard): this document informs of a sample list of products generally available in the north american market that meet the volkswagen oil quality standard
- Bulletin:
- V011602 2014815
- Component:
- 070000 fuel system, gasoline
- Summary:
- Technical tips on what to do if improper gasoline has been added to the vehicle.
- Bulletin:
- TT 97-14-02ss1
- Component:
- 110000 electrical system
- Summary:
- Tech tips damage to data link connector (dlc) from aftermarket devices (cannot communicate with vehicle obd system)
- Bulletin:
- V501604 2014370
- Component:
- 162000 structure:body
- Summary:
- Technical bulletin about paint finish, reducing swirl marks and fine scratches new vehicles (prior to retail delivery) with swirl marks and or fine scratches from polishing or cleaning. the document also have infromation about where to fi
- Bulletin:
- V271501 2011894
- Component:
- 111000 electrical system:battery
- Summary:
- Technical bulletin: battery, testing and charging using midtronics vas6161, mcr340v, incharge 940, or grx3000vas charger
- Bulletin:
- V011503 2014815
- Component:
- 070000 fuel system, gasoline
- Summary:
- Discusses the issues associated with using contaiminated gasoline. there are recommendations to use top tier gasoline retailers
- Bulletin:
- V941501 2011521
- Component:
- 120000 exterior lighting
- Summary:
- Technical bulletin: condensation and or water droplets becomming visible on inside of exterior light lenses issue is discussed in this document
- Bulletin:
- V271503 2016076
- Component:
- 111000 electrical system:battery
- Summary:
- Technical bulletin: battery, discharged, diagnosis for excessive static current draw
- Bulletin:
- TT 20-13-01
- Component:
- 091200 fuel system, other:storage:fuel gauge system
- Summary:
- Tech tips (ecm fault p1250 "fuel level too low" will not clear): this document informs to clear static ecm fault p1250 "fuel level too low", add fuel to vehicle and complete a road test of at least 10 miles. simply adding fuel without co
- Bulletin:
- TT 64-14-02
- Component:
- 138200 visibility:defroster/defogger system:rear window
- Summary:
- Tech tips (heated rear window, one or more lines inoperative): to detect which line(s) is inoperative, utilize a volt meter to check for 0 v, which will be present after the open in the grid line. this document informs of how to diagnose t
- Bulletin:
- TT 00-14-03
- Component:
- 118000 electrical system: software
- Summary:
- Tech tips (svm update instructions): this document informs when performing svm updates, the scan tool should be hardwired to the vehicle and the bluetooth physically turned off. a hard wired internet connection is also recommended.
- Bulletin:
- TT 64-14-02
- Component:
- 110000 electrical system
- Summary:
- Tech tips (heated rear window, one or more lines inoperative): to detect which line(s) is inoperative, utilize a volt meter to check for 0 v, which will be present after the open in the grid line. the check must be performed with the engin
- Bulletin:
- TT 01-15-02
- Component:
- 118000 electrical system: software
- Summary:
- Tech tips (scan tool lock up/scan stops at 33%): while performing a gff scan (with the newer version of odis software), the scan tool can lock up at 33%. the document informs how to service this issue
- Bulletin:
- V921502 2026253
- Component:
- 130000 visibility
- Summary:
- Technical bulletin (windshield wipers streak or smear): windshield or rear window is streaked, has a snakeskin appearance, or the surface feels rough. to avoid unnecessary replacement of wiper blades, the condition and cleanliness of the w
- Bulletin:
- V871508 2005566
- Component:
- 060000 engine and engine cooling
- Summary:
- Technical bulletin (hvac, unpleasant odor): unpleasant odor is coming from heating and ventilation system. odor mainly occurs after vehicle has been sitting (unused) at least 5 hours and within 20 to 60 seconds after vehicle is first start
- Bulletin:
- V871506 2019947
- Component:
- 060000 engine and engine cooling
- Summary:
- Technical bulletin (air conditioning, cleaning of the refrigerant circuit (u.s.only)): in cases where an air conditioning system component (such as a compressor or other system component) has failed and debris from the compressor or compon
- Bulletin:
- V581501 2039001
- Component:
- 160000 structure
- Summary:
- Technical bulletin (corrosion, rear inner doors in door fold area): corrosion in the fold of the rear door issue. this document contains information on how to diagnose, and service this issue. this document also gives examples on filling o
- Bulletin:
- V941402 2011521
- Component:
- 121000 exterior lighting:headlights
- Summary:
- Technical bulletin (exterior lights, moisture accumulation): exterior light assemblies (headlights, taillights, fog lights, turn signals) are vented and may collect moisture on their inner surfaces, depending on humidity and other climatic
- Bulletin:
- V871401 2005566
- Component:
- 353600 equipment:air conditioner
- Summary:
- Technical bulletin (hvac, unpleasant odor): unpleasant odor is coming from heating and ventilation system. odor mainly occurs after vehicle has been sitting (unused) at least 5 hours and within 20 to 60 seconds after vehicle is first start
- Bulletin:
- V011408 2014815
- Component:
- 060000 engine (pws)
- Summary:
- Technical bulletin the use of contaminated gasoline, seasonal fuel changes (summer/winter fuel) or gasoline with a low content of deposit control additives may result in one or more of the following conditions: -excessive accumulation of
- Bulletin:
- V011407 2014603
- Component:
- 118000 electrical system: software
- Summary:
- Technical bulletin this technical bulletin details the general process for carrying out a software version management (svm) software update for any technical bulletin (tsb) / required vehicle update (rvu).
- Bulletin:
- V871402 2005566
- Component:
- 353600 equipment:air conditioner
- Summary:
- Technical bulletin (hvac, unpleasant odor): condensation, which is a normal condition in all a/c systems, can cause a musty odor. if the odor is noticeable in the vehicle when the engine is not turned on, the cause may be mold and mildew i
- Bulletin:
- V001404 2010380
- Component:
- 350000 equipment
- Summary:
- Technical bulletin (squeaks, rattles, noise, repair materials): this doucment contains a list of components and applications developed to repair concerns of squeaks, rattles, noise and trim fit conditions.
- Bulletin:
- Reference - Refl
- Component:
- 118000 electrical system: software
- Summary:
- Quick reference update guide: this document informs of the corresponding software/hardware and disc availability to the customer concerns about a vehicle
- Bulletin:
- V171403 2017813
- Component:
- 060000 engine (pws)
- Summary:
- Technical bulletin (oil consumption measurement): customer states oil consumption is higher than the volkswagen oil consumption standard of up to 0.5 quarts per 600 miles, or 0.5 liters per 1000 km. in order to provide effective lubricati
- Bulletin:
- TT 87-10-05
- Component:
- 353600 equipment:air conditioner
- Summary:
- Tech tips (air conditioning does not operate): this document informs of concerns of no or intermittent a/c operation where pressure diagnosis does not lead to a cause, be sure to check the n25 a/c clutch coil. the fan control module may se
- Bulletin:
- TT 00-13-02
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- Tech tips (technician helpline vehicle check sheets): when it becomes necessary to open a vw technician helpline vta case while performing diagnosis for a diesel particulate filter, manual transmission repair, or turbocharger concern, it
- Bulletin:
- TT 200901
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- Update to existing tip for fuel quality checking.
- Bulletin:
- V171302 2017813
- Component:
- 060000 engine and engine cooling
- Summary:
- Technical bulletin (oil consumption measurement): customer states oil consumption is higher than the volkswagen oil consumption standard of up to 0.5 quarts per 600 miles, or 0.5 liters per 1000 km. in order to provide effective lubrica
- Bulletin:
- TT 55-13-01
- Component:
- 114300 electrical system:wiring: rear compartment/trunk
- Summary:
- Tech tips (rear lid does not open after handle replacement): if the rear lid handle is replaced with part number 1j0 827 566l, the microswitch from the original handle must be transferred to the new handle. if original microswitch is not a
- Bulletin:
- PDI - TOUAREG TE
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- Touareg perfect delivery inspection (pdi) - technician and detailer inspections: a checklist to insure a customer receives a wonderful delivery of a vehicle that looks, feels, and meets the expectations of a new vehicle that he/she has pur
- Bulletin:
- TT 21-13-01
- Component:
- 061120 engine and engine cooling:engine:gasoline:turbo-charger
- Summary:
- Tech tips (equipped with turbocharged engine turbocharger replacement tip): if mechanical damage is found to the turbocharger (e.g. damaged compression wheel, loose or broken shaft), it is not enough to just replace the turbocharger. thi
- Bulletin:
- PDI - TOUAREG TE
- Component:
- 350000 equipment
- Summary:
- "touareg perfect delivery inspection (pdi) - technician and detailer inspections: a checklist to insure a customer receives a wonderful delivery of a vehicle that looks, feels, and meets the expectations of a new vehicle that he/she has pu
- Bulletin:
- V871620 2005566
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- Update model and model year applicability.
- Bulletin:
- V691601 2010479
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- Update model year applicability to include 2017.
- Bulletin:
- V871622 2019947
- Component:
- 353600 equipment:air conditioner
- Summary:
- Update to model year applicability.
- Bulletin:
- V011615 2014815
- Component:
- 060000 engine (pws)
- Summary:
- Update to include additional model year applicability.
- Bulletin:
- TT 00-16-02
- Component:
- 350000 equipment
- Summary:
- Reminder for dealers to reference the repair manual and replace all necessary fasteners (bolts, nuts) that cannot be re-used
- Bulletin:
- Update 02122016
- Component:
- 118000 electrical system: software
- Summary:
- Quick reference of vehicle concerns. includes a list of software versions and the technical bulletin numbers that referred to the concerns updated
- Bulletin:
- TT 97-12-02
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- data link connector pin assignment chart that is applicable to all models. update model year applicability.
- Bulletin:
- 1-2017 Update
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- This communication is to update our profi dealers of the current status of the latest inbound and outbound profi requests.
- Bulletin:
- Touareg Module S
- Component:
- 110000 electrical system
- Summary:
- Volkswagen dealership communication: based on dealer feedback of odis service module scan lockups on early touareg. volkswagen created a method for a temporary workaround. the document is its procedure
- Bulletin:
- Ref. - Reflash U
- Component:
- 118000 electrical system: software
- Summary:
- Quick reference update guide of the vehicles expected upgraded software level. the latest corresponding technical bulletins that address the issues, and concerns that have been had with the vehicles.
- Bulletin:
- Elsa 6-22-15
- Component:
- 350000 equipment
- Summary:
- This document contains the vw elsa newsletter that contains a general overview of wiring diagrams updates, elsapro infomedia icons grayed out, workshop equipment tool storage application, technical bulletins, pending service solutions, tech
- Bulletin:
- Elsa 6-29-15
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- This document contains the vw elsa newsletter that contains a general overview of wiring diagrams updates, technical bulletins, pending service solutions, tech tips, campaigns, updates, and suggestions.
- Bulletin:
- V581601-2039001
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- To update claim processing statement.
- Bulletin:
- Quick Reference
- Component:
- 118000 electrical system: software
- Summary:
- Quick reference of vehicle concerns. includes a list of software versions and the technical bulletin numbers that referred to the concerns updated
- Bulletin:
- V171701 2012855
- Component:
- 060000 engine and engine cooling
- Summary:
- 17 17 01 july 5, 2017 2012855 supersedes technical bulletin 17-16-02 (v171602) dated april 29, 2016 due to updated oil standards lists to current specifications. engine oils which meet volkswagen oil quality standards
- Bulletin:
- TT001703
- Component:
- 118000 electrical system: software
- Summary:
- Tip for scan tool concerns that may occur duing a test plan
- Bulletin:
- A971861 2013504-
- Component:
- 110000 electrical system
- Summary:
- This information bulletin contains instructions for checking the pins/terminals for contacts and nano contacts.
- Bulletin:
- On-car analysis
- Component:
- 100000 power train
- Summary:
- On-car analysis list of customer complaints: transmission concerns (including clutch assembly, bevel box and haldex)
- Bulletin:
- On-car analysis
- Component:
- 100000 power train
- Summary:
- On-car analysis list of customer complaints: transmission concerns (including clutch assembly, bevel box and haldex)
- Bulletin:
- On-car analysis
- Component:
- 100000 power train
- Summary:
- On-car analysis list of customer complaints: transmission concerns (including clutch assembly, bevel box and haldex)
- Bulletin:
- On-car analysis
- Component:
- 100000 power train
- Summary:
- On-car analysis list of customer complaints: transmission concerns (including clutch assembly, bevel box and haldex)
Home | Privacy