2004 VOLKSWAGEN R32 Recalls (2)
- Campaign:
- 07V063000 on 02/20/2007
- Component:
- Exterior lighting:brake lights:switch
- Manufactured:
- 09/30/2003 - 05/29/2004
- Affected:
- 1,002,000
- Defect:
- On certain passenger, wagon, and convertible vehicles equipped with or without cruise control, a brake light switch may malfunction if it was installed incorrectly.
- Consequence:
- The brake lights could become inoperative, or remain on. failure to provide the proper signal when braking could lead to a crash without warning.
- Correction:
- Dealers will install the newly designed brake light switch free of charge. the recall began on april 27, 2007, and will be conducted in several staggered mailings through september 21, 2007. vehicles within the make, model, and model year of this population may be involved in either this recall or 06v-183, but not both. the remedy is the same for each recall. volkswagen dealers will apply the remedy based on the vin number of the vehicle. owners may contact vw at 1-800-822-8987.
- Notes:
- Volkswagen recall no. n4.customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.
- Campaign:
- 07E023000 on 03/28/2007
- Component:
- Service brakes, hydraulic:foundation components:master cylinder
- Affected:
- 13,128
- Defect:
- Certain cardone master cylinders with part numbers 10-2925, 10-2987, 10-2987mza, 10-3083, 11-3015, 11-3042, 11-3044, 11-3045, 11-3047, 11-3064, and 11-3156, and with date codes lower than dca7078 sold as replacement equipment for use on the vehicles listed above. the seal on master cylinder can fail and leak brake fluid.
- Consequence:
- Loss of brake fluid can result in poor braking performance, possibly resulting in a vehicle crash.
- Correction:
- Cardone will notify owners and offer to repurchase any defective master cylinders. the recall began during april 2007. owners can contact cardone at 1-800-777-4780.
- Notes:
- This recall only pertains to aftermarket cardone master cylinders and has no relation to any original equipment installed on the vehicles listed above.customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.
2004 VOLKSWAGEN R32 TSBs (29)
- Bulletin:
- 0403
- Component:
- 062300 engine and engine cooling:cooling system:hose
- Summary:
- The lower radiator hose could contact the engine cooling fan which may lead to radiator hose wear. *tt
- Bulletin:
- 0401
- Component:
- 110000 electrical system
- Summary:
- Malfunction indicator lamp (mil) on with diagnostic trouble codes (dtc) p1347/17755 and p1340/17748 stored in memory. including various models volkswagen 2002-2003. *mj
- Bulletin:
- 004
- Component:
- 060000 engine and engine cooling
- Summary:
- Engine coolant temperature (ect) sensor. *tc
- Bulletin:
- 0502
- Component:
- 110000 electrical system
- Summary:
- Diagnostic trouble code (dtc) p1603 (18011) stored in dtc memory. *tt
- Bulletin:
- 2015831
- Component:
- 063000 engine and engine cooling:exhaust system
- Summary:
- Volkswagen: exhaust heat shield, replacement guidelines. heat shields are to be inspected after completion o any type of repair to the underbody (exhaust system transmission, etc.), and if damaged, replaced. *pe
- Bulletin:
- SB-28F3
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Volkswagen: vehicles may have ignition coils that could malfunction under certain conditions. if this happens, the malfunction indicator lamp (mil) will illuminated to let you know that the vehicle may experience some deterioration in per
- Bulletin:
- SA-28F3
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Volkswagen: (revised) vehicles may have ignition coils that could malfunction under certain conditions. if this happens, the malfunction indicator lamp (mil) will illuminated to let you know that vehicle may experience some deterioration
- Bulletin:
- SA-60A7-S9
- Component:
- 134000 visibility:sun roof assembly
- Summary:
- Volkswagen service campaign: see document search button for owner letter. inspect, clean and modify sunroof drains for certain volkswagen vehicles and revised maintenance schedule; sunroof drain inspection and cleaning. no models or model
- Bulletin:
- TSB-28-10-02
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Volkswagen: mil on or flashing, misfire dtcs p0300-0312 stored in ecm. the misfire condition may be caused by a malfunctioning ignition coil. vehicles are out of production. *pe
- Bulletin:
- TB-00-10-06
- Component:
- 510000 child seat:latch connector
- Summary:
- Volkswagen: child restraint latch guidance fixture; compliance with fmvss 225 (usa only). update to existing technical bulletin. no production change required. all models. *pe
- Bulletin:
- SAC-28F3/P1-REV
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Volkswagen: gasoline engine vehicles inspect, and if necessary, replace ignition coils. vehicles affected by this action may have ignition coils that could malfunction under certain conditions. models passat and wagon; golf; gti; jetta a
- Bulletin:
- TB-35-11-01
- Component:
- 013000 steering:gear box (other than rack and pinion)
- Summary:
- Volkswagen: the gear box has a momentarily delay while accelerating. *rm
- Bulletin:
- TB-01-12-04
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Volkswagen: gasoline engines have rough idle, have significant loss of power or stalling with reduced performance. *pe
- Bulletin:
- Quick Reference
- Component:
- 118000 electrical system: software
- Summary:
- Quick reference update guide: this document informs of the corresponding software/hardware and disc availability to the customer concerns about a vehicle
- Bulletin:
- V011602 2014815
- Component:
- 070000 fuel system, gasoline
- Summary:
- Technical tips on what to do if improper gasoline has been added to the vehicle.
- Bulletin:
- TT 97-14-02ss1
- Component:
- 110000 electrical system
- Summary:
- Tech tips damage to data link connector (dlc) from aftermarket devices (cannot communicate with vehicle obd system)
- Bulletin:
- Reference - Refl
- Component:
- 118000 electrical system: software
- Summary:
- Quick reference update guide: this document informs of the corresponding software/hardware and disc availability to the customer concerns about a vehicle
- Bulletin:
- V871620 2005566
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- Update model and model year applicability.
- Bulletin:
- V691601 2010479
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- Update model year applicability to include 2017.
- Bulletin:
- V871622 2019947
- Component:
- 353600 equipment:air conditioner
- Summary:
- Update to model year applicability.
- Bulletin:
- V011615 2014815
- Component:
- 060000 engine (pws)
- Summary:
- Update to include additional model year applicability.
- Bulletin:
- TT 00-16-02
- Component:
- 350000 equipment
- Summary:
- Reminder for dealers to reference the repair manual and replace all necessary fasteners (bolts, nuts) that cannot be re-used
- Bulletin:
- TT 97-12-02
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- data link connector pin assignment chart that is applicable to all models. update model year applicability.
- Bulletin:
- 1-2017 Update
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- This communication is to update our profi dealers of the current status of the latest inbound and outbound profi requests.
- Bulletin:
- Ref. - Reflash U
- Component:
- 118000 electrical system: software
- Summary:
- Quick reference update guide of the vehicles expected upgraded software level. the latest corresponding technical bulletins that address the issues, and concerns that have been had with the vehicles.
- Bulletin:
- Elsa 6-22-15
- Component:
- 350000 equipment
- Summary:
- This document contains the vw elsa newsletter that contains a general overview of wiring diagrams updates, elsapro infomedia icons grayed out, workshop equipment tool storage application, technical bulletins, pending service solutions, tech
- Bulletin:
- Elsa 6-29-15
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- This document contains the vw elsa newsletter that contains a general overview of wiring diagrams updates, technical bulletins, pending service solutions, tech tips, campaigns, updates, and suggestions.
- Bulletin:
- V171701 2012855
- Component:
- 060000 engine and engine cooling
- Summary:
- 17 17 01 july 5, 2017 2012855 supersedes technical bulletin 17-16-02 (v171602) dated april 29, 2016 due to updated oil standards lists to current specifications. engine oils which meet volkswagen oil quality standards
- Bulletin:
- A971861 2013504-
- Component:
- 110000 electrical system
- Summary:
- This information bulletin contains instructions for checking the pins/terminals for contacts and nano contacts.
Home | Privacy