2004 TOYOTA TUNDRA Recalls (10)

Campaign:
05V123000 on 03/29/2005
Component:
Engine and engine cooling:exhaust system
Manufactured:
07/31/2003 - 12/21/2004
Affected:
5,726
Defect:
Certain pickup trucks equipped with both vehicle stability control (vsc) and the trd dual exhaust systems. the trd dual exhaust system met all clearance specifications on models without vsc, however the driver's side exhaust located in a position where contact between a brake line found only on vehicles with vsc and the trd exhaust pipe might occur.
Consequence:
In this condition, the exhaust pipe flange may rub against the right rear brake line, which could cause brake fluid leakage. this could lead to an increase of vehicle stopping distance, which could result in a crash.
Correction:
Dealers will inspect and, if so equipped, will replace the trd dual exhaust system free of charge. during this replacement, the dealer will also inspect the specific brake line to assure it has not been damaged and replace it if necessary. the recall began on may 31, 2005. owners should contact toyota at 1-800-331-4331.
Notes:
Toyota recall no. 50e.customers may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov.
Campaign:
05V225000 on 05/16/2005
Component:
Suspension:front:control arm:lower ball joint
Manufactured:
07/31/2001 - 09/25/2003
Affected:
768,379
Defect:
On certain sport utility vehicles, due to a manufacturing issue in the front suspension lower ball joint, there is a possibility that the surface of the ball of the joint may have been scratched. the ball joint may eventually experience excessive wear and looseness, resulting in increased steering effort.
Consequence:
The lower ball joint may separate from the knuckle causing loss of steering control and a crash could occur.
Correction:
Dealers will replace the front suspension lower ball joints free of charge. the recall began on july 5, 2005. owners may contact toyota at 1-800-331-4331.
Notes:
Toyota recall no. 50j.customers may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov.
Campaign:
05V254000 on 06/05/2005
Component:
Air bags:on-off switch assembly
Manufactured:
09/02/2002 - 04/21/2005
Affected:
156,111
Defect:
Certain pickup trucks fail to comply with the requirements of federal motor vehicle safety standard no. 225, 'child restraint anchorage systems.' these vehicles have a manual air bag on-off switch to disable the front passenger air bag and do not have a child restraint lower anchorage system in the front passenger seat. this specification does not meet the standard requirements.
Consequence:
This standard establishes requirements for child restraint anchorage systems to ensure their proper location and strength for the effective securing of child restraints, to reduce the likelihood of the anchorage systems' failure, and to increase the likelihood that child restraints are properly secured and thus more fully achieve their potential effectiveness in motor vehicles.
Correction:
Dealers will remove the manual air bag on-off switch, replace the owner's manual, and affix a new sun visor air bag warning label. the recall began in early january 2007. owners may contact toyota at 1-800-331-4331.
Notes:
Toyota recall no. 70a.customers can also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov.
Campaign:
06E026000 on 03/22/2006
Component:
Exterior lighting
Affected:
61,944
Defect:
Certain pro-a motors corner lamps, turn signals, and headlights sold as replacement lamps for use on certain passenger vehicles listed above. some combination lamps that are not equipped with amber side reflectors fail to conform to federal motor vehicle safety standard no. 108, lamps, reflective devices, and associated equipment.
Consequence:
Without the amber reflectors, the vehicle will be poorly illuminated, possibly resulting in a vehicle crash without warning.
Correction:
Pro-a motors will notify owners and offer to repurchase the lamps. the recall began on april 3, 2006. owners may contact pro-a motors at 323-838-2988.
Notes:
This recall only pertains to pro-a motors aftermarket lamps and has no relation to any original equipment installed on the listed passenger vehicles.for more information on the lamp model numbers, click on document search and view document titled "lamp model numbers."customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.
Campaign:
06E049000 on 06/04/2006
Component:
Exterior lighting
Affected:
27,176
Defect:
Certain ck motorsports combination headlights, clear corner, bumper, and side marker lights sold as replacement lamps for use on the passenger vehicles listed above. some combination lamps that are not equipped with amber side reflectors fail to conform to federal motor vehicle safety standard no. 108, lamps, reflective devices, and associated equipment.
Consequence:
Without the amber reflectors, the vehicle will be poorly illuminated, possibly resulting in a vehicle crash without warning.
Correction:
Ck motorsport will notify owners and replace the noncompliant lamps free of charge. the recall began on july 1, 2006. owners may contact ck motorsport at 1-909-610-7211.
Notes:
This recall only pertains to aftermarket replacement equipment and has no relation to any original equipment installed on vehicles manufactured by the vehicle manufacturers.for more information on the lamp model numbers, click on document search and view document titled "lamp model numbers."customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.
Campaign:
06E065000 on 07/16/2006
Component:
Exterior lighting
Affected:
3,593
Defect:
Certain aj motorsport combination lamps sold as replacement lamps for use on the above listed passenger vehicles. combination lamps not equipped with amber side reflectors fail to conform with the requirements of federal motor vehicle safety standard no. 108, lamps, reflective devices, and associated equipment.
Consequence:
Lack of amber side reflectors in the lamps will decrease lighting visibility to other drivers and may possibly result in a vehicle crash.
Correction:
Aj motorsport will notify owners and offer reimbursement for the lamps. the recall began on july 31, 2006. owners may contact aj motorsport at 626-618-2026.
Notes:
This recall only pertains to aj motorsport aftermarket lamps and has no relation to any original equipment installed on the listed passenger vehicles.for more information on the lamp model numbers, click on document search and view document titled "lamp model numbers."customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.
Campaign:
07V013000 on 01/18/2007
Component:
Suspension:front:control arm:lower ball joint
Manufactured:
08/14/2003 - 11/16/2006
Affected:
533,124
Defect:
On certain trucks and mini vans, due to possible improper finishing of the front suspension lower ball joint, some ball joints may experience an incidental deterioration of the internal lubrication. this may cause the ball joint to wear and loosen prematurely, which could result in increased steering effort, reduced vehicle self-centering, and noise in the front suspension.
Consequence:
In extreme cases, if the vehicle is continuously operated in this condition, the lower ball joint may separate from the knuckle and could cause a loss of vehicle control.
Correction:
Dealers will replace the front suspension lower ball joints. the recall began on february 28, 2007. owners may contact toyota at 1-800-331-4331.
Notes:
Toyota recall no. 70b.customers may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov.
Campaign:
09E025000 on 05/10/2009
Component:
Exterior lighting:headlights
Affected:
42,540
Defect:
Dope, inc. is recalling 42,540 combination corner and bumper lamp assemblies of various part numbers sold for use as aftermarket equipment for various passenger vehicles. these headlamps fail to conform to the requirements of federal motor vehicle safety standard no. 108, "lamps, reflective devices, and associated equipment." these lamps do not contain the required amber side reflectors.
Consequence:
Decreased lighting visibility may result in a vehicle crash.
Correction:
Dope, inc. will notify owners and offer a full refund for the noncompliant combination lamps. the safety recall began on july 28, 2009. owners may contact dope, inc. at 1-626-272-1798.
Notes:
This recall only pertains to aftermarket replacement equipment and has no relation to any original equipment installed on vehicles produced by the vehicle manufacturer.in order to determine if your aftermarket lamp assembly is affected by this noncompliance, please review the list of model numbers provided to us by dope, inc.the list can be found under "document search" located at the bottom of your screen. owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to <a href=http://www.safercar.gov>http://www.safercar.gov</a> .
Campaign:
15V286000 on 05/12/2015
Component:
Air bags
Manufactured:
07/29/2002 - 12/21/2006
Affected:
1,069,055
Defect:
Toyota motor engineering & manufacturing (toyota) notified the agency on may 13, 2015, that they are recalling 2005-2007 lexus sc, toyota corolla, corolla matrix, sequoia, and pontiac vibe, and 2005-2006 toyota tundra vehicles that were originally sold, or ever registered, in florida, along the gulf coast, puerto rico, hawaii, the u.s. virgin islands, guam, saipan and american samoa. on june 16, 2015 toyota expanded the recall to cover an additional 769,055 vehicles, including certain model year 2002-2004 lexus sc, toyota sequoia, 2003-2004 toyota corolla matrix, toyota corolla, pontiac vibe, and toyota tundra vehicles, as well the vehicles covered by the may 13, 2015 notification in the portions of georgia, alabama, louisiana, mississippi and texas that were not previously included. the inflators in the front passenger air bags are susceptible to rupture in the event of a crash necessitating the deployment of the front passenger air bag.
Consequence:
In the event of a crash necessitating deployment of the passenger's frontal air bag, the inflator could rupture with metal fragments striking the vehicle occupants potentially resulting in serious injury or death.
Correction:
Toyota will notify their owners. pontiac vibe owners will be notified by gm. dealers will replace the passenger side front air bag, free of charge. owners may contact toyota customer service at 1-800-331-4331. toyota began the recall on july 13, 2015. pontiac vibe owners may contact gm at 1-800-762-2737. gm began the recall on june 29, 2015. note: this recacll supersedes recall 14v-655 in its entirety. for vehicles located in the u.s. states not listed above, please see toyota recall 15v-285 which covers all other u.s. states.
Notes:
Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.
Campaign:
15V285000 on 05/12/2015
Component:
Air bags
Manufactured:
05/23/2002 - 12/21/2006
Affected:
1,973,468
Defect:
Toyota motor engineering & manufacturing (toyota) notified the agency on may 13, 2015 that they are recalling certain model year 2004 sequoia vehicles manufactured august 18, 2003, to august 19, 2004, and 2003-2004 tundra vehicles manufactured march 18, 2003, to august 25, 2004. on june 16, 2015, toyota expanded the recall to include an additional 1,270,468 vehicles, including model year 2002-2003 and 2005-2007 sequoia, 2005-2006 tundra, 2003-2007 corolla, 2003-2007 corolla matrix, 2003-2007 pontiac vibe and 2002-2007 lexus sc vehicles. this is to address a safety defect in the passenger side frontal air bag inflator which may produce excessive internal pressure causing the inflator to rupture upon deployment of the air bag. this recall addresses both the passenger side frontal air bags that were originally installed in the vehicles, as well as replacement air bags that may have been installed as replacement service parts. a replacement air bag may have been installed, as one example, if a vehicle had been in a crash necessitating the replacement of the passenger side frontal air bag.
Consequence:
In the event of a crash necessitating deployment of the passenger's frontal air bag, the inflator could rupture with metal fragments striking the vehicle occupants potentially resulting in serious injury or death.
Correction:
Toyota will notify their owners. pontiac vibe owners will be notified by gm. dealers will replace the front passenger air bag. the recall began on july 13, 2015. toyota owners may contact toyota customer service at 1-800-331-4331. pontiac owners may call 1-800-762-2737. note: this recall supersedes recall 14v-312 in its entirety.
Notes:
Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.

2004 TOYOTA TUNDRA TSBs (151)

Bulletin:
PG00503
Component:
198000 tires:temporary/emergency spare tire
Summary:
Spare tire carrier operation. various modlels including the 2004 landcruiser and 4 runner. *tt
Bulletin:
PD01303
Component:
350000 equipment
Summary:
Initial calibration of compass. *tt
Bulletin:
DL00303
Component:
100000 power train
Summary:
Synthetic rear differential fluid maintenance and repair information. *tt
Bulletin:
PD01103
Component:
350000 equipment
Summary:
Front and rear license plate installation. *tt
Bulletin:
02003
Component:
061000 engine and engine cooling:engine
Summary:
Malfunction indicator lamp (mil) on condition with diagnostic trouble code (dtc) p0441, p0442 and/or p0446. *tt
Bulletin:
01903
Component:
061000 engine and engine cooling:engine
Summary:
Malfunction indicator lamp on condition with diagnostic trouble code (dtc) p0442 - fuel filler tube improvement. *tt
Bulletin:
00104
Component:
980000 unknown or other
Summary:
Zero point calibration. *mr *tt
Bulletin:
3298
Component:
114000 electrical system:wiring
Summary:
Electrical wiring diagram repair manual correction. *tt
Bulletin:
00402
Component:
030000 service brakes, hydraulic
Summary:
Front brake vibration. *mj *sc
Bulletin:
00504
Component:
110000 electrical system
Summary:
Malfunction indicator lamp (mil) on with diagnostic trouble code (dtc) p0705 with unusual combination meter operation. *tt
Bulletin:
00404
Component:
353600 equipment:air conditioner
Summary:
The air conditioning system does not sufficiently cool the cabin. *tt
Bulletin:
00304
Component:
162000 structure:body
Summary:
Bedliner tailgate panel may warp/distort at elevated temperatures. *tt
Bulletin:
03704
Component:
061000 engine and engine cooling:engine
Summary:
Engine bank 1 and bank 2 a/f and 02 identification. various toyota models. *tt
Bulletin:
00504
Component:
010000 steering
Summary:
Vsc steering angle sensor initialization during pre-delivery service or after repair. *tt
Bulletin:
00503
Component:
980000 unknown or other
Summary:
2004 model year pre-delivery service (pds). all '04 models except prius. *tt
Bulletin:
04604
Component:
061000 engine and engine cooling:engine
Summary:
Intermittent extended or hard cranking. *tt
Bulletin:
05204
Component:
061000 engine and engine cooling:engine
Summary:
Extended engine crank condition after the engine is turned off. *tt
Bulletin:
00304
Component:
022000 suspension:rear
Summary:
Squeak noise coming from the rear shocks. *tt
Bulletin:
05015
Component:
021540 suspension:front:control arm:lower ball joint
Summary:
Special service campaign 50j - phase i - front suspension lower ball joint may experience excessive wear and looseness causing increased steering, effort, reduced vehicle self-centering, and noise in the front suspension. *tt
Bulletin:
00305
Component:
061000 engine and engine cooling:engine
Summary:
Abnormal squeal noise from the engine accessory drive belt area, usually during cold start-up. an improved 2uz-fe accessory drive belt has been developed to correct this condition. *tt
Bulletin:
4572
Component:
103000 power train:automatic transmission
Summary:
2004 tundra repair manual correction for the torque converter clutch and drive plate. 00400-rm109-u1. *tt
Bulletin:
4554B
Component:
110000 electrical system
Summary:
2004 tundra repair manual correction - wireless door lock control system (double cab). 00400-rm109-1u2. *tt 2005 tundra - 00400-rm115-0u3. *tt
Bulletin:
05009
Component:
063000 engine and engine cooling:exhaust system
Summary:
Special service campaign (ssc) 50e to replace the trd dual exhaust system on vehicles equipped with both vehicle stability control (vsc) and a trd dual exhaust system. *tt
Bulletin:
01005
Component:
353000 equipment:electrical
Summary:
Diagnostic guide for rear seat entertainment systems. *tt
Bulletin:
5026
Component:
036000 service brakes, hydraulic:antilock
Summary:
Diagnostics - anti-lock brake system (denso made). repair manual correction. 00400-rm445. 00400-rm956-u1. 00400-rm109-1u1. *tt
Bulletin:
00605
Component:
138110 visibility:defroster/defogger system:windshield:blower
Summary:
Squeal or chirp type noise emitted from the blower motor at various speeds. *tt
Bulletin:
00105
Component:
130000 visibility
Summary:
Front window rattle. *tt
Bulletin:
04805
Component:
060000 engine and engine cooling
Summary:
Malfunction indicator lamp on diagnostic trouble code p2742. *ak
Bulletin:
00506
Component:
030000 service brakes, hydraulic
Summary:
Inconsistent or unusual brake feeling. *tt
Bulletin:
TSB-0064-10
Component:
061000 engine and engine cooling:engine
Summary:
Toyota: techstream ecu flash reprogramming procedure. flash reprogramming allows the ecu software to be updated without replacing the ecu. flash calibration updates for specific vehicle models/ecus are released as field-fix procedures de
Bulletin:
SB-0003-11
Component:
071110 fuel system, gasoline:storage:tank assembly:filler pipe and cap
Summary:
Toyota: 2003-2004 tundra. a fuel filler problem is causing the malfunction indicator light to turn on. *rm
Bulletin:
TSB-0122-11
Component:
140000 air bags
Summary:
Toyota: information provided for replacing the seat covers for vehicles equipped with side airbags. *pe
Bulletin:
TSB-0087-12
Component:
181000 vehicle speed control:accelerator pedal
Summary:
Toyota: accelerator pedal sensor assembly information regarding the inspection, removal, and installation, if lubrication or oil, is applied. *pe
Bulletin:
TC15-002
Component:
161000 structure:frame and members
Summary:
This tsb contains an owner notification letter. select document search button below. certain toyota 2004-2006 tundra vehicles may exhibit corrosion to vehicles frame due to cold climate. *lj
Bulletin:
TC-15-002
Component:
161000 structure:frame and members
Summary:
Toyota: tsb contains an owner notification letter. select document search button below. limited service campaign (lsc) issued for certain vehicles, that are registered or operate, in specific cold climate areas with high usage of road s
Bulletin:
TC14-055
Component:
355200 equipment:other:owners/service/other manual
Summary:
Summary to be provided on a future date.
Bulletin:
T-SB-0187-12
Component:
190000 tires
Summary:
Summary to be provided on a future date.
Bulletin:
T-TT-0051-10
Component:
353600 equipment:air conditioner
Summary:
Summary to be provided on a future date.
Bulletin:
TC13-019
Component:
355200 equipment:other:owners/service/other manual
Summary:
Summary to be provided on a future date.
Bulletin:
T-TT-0254-13
Component:
140000 air bags
Summary:
Summary to be provided on a future date.
Bulletin:
T-TT-0254-13
Component:
140000 air bags
Summary:
The technical instructions for safety recall dof (front passenger airbag inflater module) require a techstream health check and then a diagnostic report (customer friendly health check.) during the health check, a tis access error (s309
Bulletin:
T-SB-0012-13 REV
Component:
060000 engine (pws)
Summary:
"tsb: flash reprogramming allows the ecu software to be updated without replacing the ecu. flash calibration updates for specific vehicle models/ecus are released as field-fix procedures described in individual service bulletins. this bul
Bulletin:
T-TT-0381-16
Component:
350000 equipment
Summary:
Tech tip: some customers may experience difficulty programming homelink.
Bulletin:
T-TT-0362-15
Component:
060000 engine (pws)
Summary:
Tt: the vehicle may be difficult to start or have an abnormally low or rough idle after the battery has been disconnected or power to the engine ecm has been interrupted.
Bulletin:
T-SB-0014-11 Rev
Component:
103000 power train:automatic transmission
Summary:
Tsb: the purpose of this service bulletin is to provide information regarding the installation of the correct torque converter bolts during automatic transmission/transaxle assembly replacement. incorrect torque converter bolts or missing w
Bulletin:
T-SB-0134-14
Component:
100000 power train
Summary:
Tsb: the purpose of this bulletin is to provide precautions to follow when installing an automatic transmission/transaxle assembly to avoid mil "on" shifting issues and/or transmission damage. use the information in this bulletin when insta
Bulletin:
T-SB-0043-14 Rev
Component:
353000 equipment:electrical
Summary:
Tsb: the immobilizer and smart key reset is a feature that allows the registration of new keys when all master keys are lost. once the system is reset, all previously registered keys will be erased. follow the procedures in this bulletin to
Bulletin:
D0D_DSD_LSC_Expi
Component:
160000 structure
Summary:
Dl: customer vehicles that qualify for frame replacement under d0d must have their vehicle inspected on or before july 31, 2015. frame and ancillary parts orders must be submitted no later than monday, august 4th, 2015 following the expirat
Bulletin:
D0D_DSD_Dealer D
Component:
160000 structure
Summary:
Dd: frame replacement - customer vehicles that qualify for frame replacement under d0d/dsd must have their vehicle inspected on or before july 31,2015. frame and ancillary parts orders must be submitted no later than monday, august 4th, 201
Bulletin:
T-SB-0083-13 Rev
Component:
353600 equipment:air conditioner
Summary:
Tsb: the procedure in this bulletin is a general guideline on how to properly diagnose the air conditioning system after a component failure. refer to the applicable repair manual for vehicle specific repair procedures and parts.
Bulletin:
T-SB-0142-13 Rev
Component:
353600 equipment:air conditioner
Summary:
Tsb: some 2004 - 2015 model year toyota vehicles may exhibit odors naturally occurring from the hvac system and/or related environmental factors. although there is no way to eliminate these odors, follow the general procedure in this bullet
Bulletin:
T-SB-0101-11 Rev
Component:
110000 electrical system
Summary:
Tsb: when servicing interior electrical switches and components, please note the precautions in this bulletin to avoid damaging electrical components and switches. many lubricants, cleaners, and automotive chemicals contain silicone or othe
Bulletin:
DSD_LSC_Region L
Component:
160000 structure
Summary:
Region letter: * toyota has received reports that certain 2004 through 2006 model year tundra vehicles operated in specific cold climate areas with high road salt usage may exhibit more-than-normal corrosion to the vehicle's frame. * this
Bulletin:
DSD_LSC_Dealer L
Component:
160000 structure
Summary:
Dealer letter: * toyota has received reports that certain 2004 through 2006 model year tundra vehicles operated in specific cold climate areas with high road salt usage may exhibit more-than-normal corrosion to the vehicle's frame. * this
Bulletin:
DSD_LSC_Dealer D
Component:
161000 structure:frame and members
Summary:
Dealer daily: toyota has received reports that certain 2004 through 2006 model year tundra vehicles operated in specific cold climate areas with high road salt usage may exhibit more-than-normal corrosion to the vehicle's frame. this condit
Bulletin:
D0D_DSD_LSC_Expi
Component:
160000 structure
Summary:
Dl: customer vehicles that qualify for frame replacement under d0d must have their vehicle inspected on or before july 31, 2015. frame and ancillary parts orders must be submitted no later than monday, august 4th, 2015 following the expirat
Bulletin:
D0D_DSD_Dealer D
Component:
160000 structure
Summary:
Dd: frame replacement-customer vehicles that qualify for frame replacement under d0d/dsd must have their vehicle inspected on or before july 31,2015. frame and ancillary parts orders must be submitted no later than monday, august 4th, 2015
Bulletin:
DSD_LSC_Region L
Component:
161000 structure:frame and members
Summary:
Region letter: * toyota has received reports that certain 2004 through 2006 model year tundra vehicles operated in specific cold climate areas with high road salt usage may exhibit more-than-normal corrosion to the vehicle's frame. * this
Bulletin:
DSD_LSC_Dealer L
Component:
161000 structure:frame and members
Summary:
Dealer letter: * toyota has received reports that certain 2004 through 2006 model year tundra vehicles operated in specific cold climate areas with high road salt usage may exhibit more-than-normal corrosion to the vehicle's frame. * this
Bulletin:
DSD_LSC_Dealer D
Component:
160000 structure
Summary:
Dealer daily: toyota has received reports that certain 2004 through 2006 model year tundra vehicles operated in specific cold climate areas with high road salt usage may exhibit more-than-normal corrosion to the vehicle's frame. this condit
Bulletin:
T-SB-0142-13 Rev
Component:
353600 equipment:air conditioner
Summary:
Tsb: some 2004 - 2015 model year toyota vehicles may exhibit odors naturally occurring from the hvac system and/or related environmental factors. although there is no way to eliminate these odors, follow the general procedure in this bullet
Bulletin:
T-SB-0101-11 Rev
Component:
110000 electrical system
Summary:
Tsb: when servicing interior electrical switches and components, please note the precautions in this bulletin to avoid damaging electrical components and switches. many lubricants, cleaners, and automotive chemicals contain silicone or othe
Bulletin:
T-SB-0043-14 Rev
Component:
353000 equipment:electrical
Summary:
Tsb: the immobilizer and smart key reset is a feature that allows the registration of new keys when all master keys are lost. once the system is reset, all previously registered keys will be erased. follow the procedures in this bulletin to
Bulletin:
T-SB-0083-13 Rev
Component:
353600 equipment:air conditioner
Summary:
Tsb: the procedure in this bulletin is a general guideline on how to properly diagnose the air conditioning system after a component failure. refer to the applicable repair manual for vehicle specific repair procedures and parts.
Bulletin:
T-SB-0304-17
Component:
162300 structure:body:door
Summary:
Tsb: vehicle replacement certification labels (the vinyl label installed on the driver door or door post) and vin plates (the metal plate riveted to dashboard) may be available from toyota, provided the request meets one of the criteria lis
Bulletin:
T-SB-0134-16_Rev
Component:
355200 equipment:other:owners/service/other manual
Summary:
Tsb: revision notice october 30, 2017 rev1: * applicability has been updated to include 2018 model year vehicles. supersession notice the information contained in this bulletin supersedes sb no. t-sb-0012-13. flash reprogramming allows the
Bulletin:
T-SB-0187-12_Rev
Component:
190000 tires
Summary:
Tsb: revision notice february 12, 2018 rev2: ? applicability has been updated to include 2015 ? 2018 model year vehicles. january 23, 2014 rev1: ? applicability has been updated to include 2013 ? 2014 model year vehicles. any previous print
Bulletin:
T-SB-0304-17_Rev
Component:
350000 equipment
Summary:
Tsb: supersession notice the information contained in this bulletin supersedes service bulletin nos. pg021-88, pg015-89, pg0015-90, pg002-91, pg002-93, pg005-97, pg007-01, pg007-07, and t-sb-0144-08. service bulletin nos. pg021-88, pg015-89
Bulletin:
T-SB-0187-12_Rev
Component:
190000 tires
Summary:
Tsb: revision notice february 12, 2018 rev2: ? applicability has been updated to include 2015 ? 2018 model year vehicles. january 23, 2014 rev1: ? applicability has been updated to include 2013 ? 2014 model year vehicles. any previous print
Bulletin:
Info packet for
Component:
161100 structure: frame and members:underbody shields
Summary:
Toyota has been offering corrosion-resistant compound ("crc") campaigns for different model year ("my") toyota vehicles registered in certain cold climate states with high road salt use. toyota motor sales. u.s.a. inc. ("tms") has develope
Bulletin:
Info packet for
Component:
161100 structure: frame and members:underbody shields
Summary:
Toyota has been offering corrosion-resistant compound ("crc") campaigns for different model year ("my") toyota vehicles registered in certain cold climate states with high road salt use. toyota motor sales. u.s.a. inc. ("tms") has develope
Bulletin:
Info packet for
Component:
161100 structure: frame and members:underbody shields
Summary:
Toyota has been offering corrosion-resistant compound ("crc") campaigns for different model year ("my") toyota vehicles registered in certain cold climate states with high road salt use. toyota motor sales. u.s.a. inc. ("tms") has develope
Bulletin:
Info packet for
Component:
161100 structure: frame and members:underbody shields
Summary:
Toyota has been offering corrosion-resistant compound ("crc") campaigns for different model year ("my") toyota vehicles registered in certain cold climate states with high road salt use. toyota motor sales. u.s.a. inc. ("tms") has develope
Bulletin:
Info packet for
Component:
161100 structure: frame and members:underbody shields
Summary:
Toyota has been offering corrosion-resistant compound ("crc") campaigns for different model year ("my") toyota vehicles registered in certain cold climate states with high road salt use. toyota motor sales. u.s.a. inc. ("tms") has develope
Bulletin:
Info packet for
Component:
161100 structure: frame and members:underbody shields
Summary:
Toyota has been offering corrosion-resistant compound ("crc") campaigns for different model year ("my") toyota vehicles registered in certain cold climate states with high road salt use. toyota motor sales. u.s.a. inc. ("tms") has develope
Bulletin:
LSC DOD - Region
Component:
160000 structure
Summary:
Toyota has received reports that certain 2004 through 2006 model year tundra vehicles operated in specific cold climate areas with high road salt usage may exhibit more-than-normal corrosion to the vehicle?s frame. toyota investigated thes
Bulletin:
LSC DOD - Dealer
Component:
160000 structure
Summary:
Toyota has received reports that certain 2004 through 2006 model year tundra vehicles operated in specific cold climate areas with high road salt usage may exhibit more-than-normal corrosion to the vehicle?s frame. toyota investigated thes
Bulletin:
Info packet for
Component:
160000 structure
Summary:
Toyota has been offering corrosion-resistant compound ("crc") campaigns for different model year ("my") toyota vehicles registered in certain cold climate states with high road salt use. toyota motor sales. u.s.a. inc. ("tms") has develope
Bulletin:
Info packet for
Component:
160000 structure
Summary:
Toyota has been offering corrosion-resistant compound ("crc") campaigns for different model year ("my") toyota vehicles registered in certain cold climate states with high road salt use. toyota motor sales. u.s.a. inc. ("tms") has develope
Bulletin:
Info packet for
Component:
160000 structure
Summary:
Toyota has been offering corrosion-resistant compound ("crc") campaigns for different model year ("my") toyota vehicles registered in certain cold climate states with high road salt use. toyota motor sales. u.s.a. inc. ("tms") has develope
Bulletin:
Info packet for
Component:
160000 structure
Summary:
Toyota has been offering corrosion-resistant compound ("crc") campaigns for different model year ("my") toyota vehicles registered in certain cold climate states with high road salt use. toyota motor sales. u.s.a. inc. ("tms") has develope
Bulletin:
Info packet for
Component:
160000 structure
Summary:
Toyota has been offering corrosion-resistant compound ("crc") campaigns for different model year ("my") toyota vehicles registered in certain cold climate states with high road salt use. toyota motor sales. u.s.a. inc. ("tms") has develope
Bulletin:
Info packet for
Component:
160000 structure
Summary:
Toyota has been offering corrosion-resistant compound ("crc") campaigns for different model year ("my") toyota vehicles registered in certain cold climate states with high road salt use. toyota motor sales. u.s.a. inc. ("tms") has develope
Bulletin:
T-TT-0132-11
Component:
030000 service brakes, hydraulic
Summary:
A key part to maintain the proper function and safe operation of the vehicle's braking system is to perform a visual inspection when installing brake pads, calipers, and discs. the following recommendations are intended to provide general
Bulletin:
Info packet for
Component:
161100 structure: frame and members:underbody shields
Summary:
Toyota has been offering corrosion-resistant compound ("crc") campaigns for different model year ("my") toyota vehicles registered in certain cold climate states with high road salt use. toyota motor sales. u.s.a. inc. ("tms") has develope
Bulletin:
Info packet for
Component:
161100 structure: frame and members:underbody shields
Summary:
Toyota has been offering corrosion-resistant compound ("crc") campaigns for different model year ("my") toyota vehicles registered in certain cold climate states with high road salt use. toyota motor sales. u.s.a. inc. ("tms") has develope
Bulletin:
Info packet for
Component:
161100 structure: frame and members:underbody shields
Summary:
Toyota has been offering corrosion-resistant compound ("crc") campaigns for different model year ("my") toyota vehicles registered in certain cold climate states with high road salt use. toyota motor sales. u.s.a. inc. ("tms") has develope
Bulletin:
Info packet for
Component:
161100 structure: frame and members:underbody shields
Summary:
Toyota has been offering corrosion-resistant compound ("crc") campaigns for different model year ("my") toyota vehicles registered in certain cold climate states with high road salt use. toyota motor sales. u.s.a. inc. ("tms") has develope
Bulletin:
Info packet for
Component:
161100 structure: frame and members:underbody shields
Summary:
Toyota has been offering corrosion-resistant compound ("crc") campaigns for different model year ("my") toyota vehicles registered in certain cold climate states with high road salt use. toyota motor sales. u.s.a. inc. ("tms") has develope
Bulletin:
Info packet for
Component:
161100 structure: frame and members:underbody shields
Summary:
Toyota has been offering corrosion-resistant compound ("crc") campaigns for different model year ("my") toyota vehicles registered in certain cold climate states with high road salt use. toyota motor sales. u.s.a. inc. ("tms") has develope
Bulletin:
T-SB-0187-12 Rev
Component:
190000 tires
Summary:
Toyota vehicles are equipped with either conventional or run-flat tires. sometimes punctures may occur as a result of contact with road debris or other hazards. if a puncture occurs, it may be possible to repair the tire and return it to se
Bulletin:
T-TT-0213-13
Component:
140000 air bags
Summary:
Toyota vehicles are equipped with supplemental restraint systems (srs), including various airbags and in some models, seat belt pre-tensioners, to help reduce the risk of injury in a collision. if a customer expresses any concerns that the
Bulletin:
LSC DOD
Component:
160000 structure
Summary:
Toyota will initiate a limited service campaign (lsc d0d) to inspect and, based upon toyota?s inspection criteria, apply corrosion-resistant compounds (crc) to key areas of the frame assembly of certain 2004-2006 model year tundra vehicles
Bulletin:
T-SB-0141-13
Component:
050000 parking brake
Summary:
A new special service tool (sst 09709-00002) has been introduced to aid in the inspection procedure for certain vehicles equipped with a floor pedal-type parking brake system. this bulletin references the correct method for installing the b
Bulletin:
T-SB-0142-13
Component:
353600 equipment:air conditioner
Summary:
Some 2004 ? 2014 model year toyota vehicles may exhibit odors naturally occurring from the hvac system and/or related environmental factors. although there is no way to eliminate these odors, follow the general procedure in this bulletin to
Bulletin:
T-SB-0185-13
Component:
130000 visibility
Summary:
The following procedures are recommended during routine maintenance or in the event of a customer concern for wiper performance.
Bulletin:
TS-BO030-01 Obso
Component:
130000 visibility/wiper (pws)
Summary:
This bulletin is now obsolete. please see t-sb-0185-13.
Bulletin:
T-SB-0122-11 Rev
Component:
140000 air bags
Summary:
Beginning in 1998, toyota introduced side airbags as optional equipment. toyota does not recommend replacement of original seat covers with non-toyota leather or other seat cover materials on vehicles due to the following: seat covers not
Bulletin:
T-SB-0071-11 Rev
Component:
100000 power train
Summary:
The purpose of this service bulletin is to provide precautions to follow when installing an automatic transmission/transaxle assembly to avoid mil ?on,? shifting issues, and/or transmission damage. use the information in this bulletin when
Bulletin:
T-TT-0269-13
Component:
132000 visibility:glass, side/rear
Summary:
The appearance of spots in tempered glass (when viewed at certain angles) is the result of the heat treating and quick quenching process during manufacturing.
Bulletin:
T-TT-0254-13
Component:
140000 air bags
Summary:
The technical instructions for safety recall dof (front passenger airbag inflator module) require a techstream health check and then a diagnostic report (customer friendly health check.) during the health check, a tis access error (s309-10
Bulletin:
T-SB-0141-10 Rev
Component:
162320 structure:body:door/window:emergency exit
Summary:
If a creak, tick, or rattle noise is heard at the top or bottom of the windshield, or at the top of the rear glass, the source of the noise may be the two stoppers bonded to the top of the windshield/rear glass, or the windshield retainers
Bulletin:
T-SB-0054-13
Component:
350000 equipment
Summary:
California (ca), federal (fed), and 50 state certified emission control underhood labels (emission labels) may be obtained through your dealership?s parts department utilizing standard replacement parts ordering procedures. follow the guide
Bulletin:
T-PG006-00 Obsol
Component:
355100 equipment:other:labels
Summary:
This bulletin is now obsolete. please see t-sb-0054-13.
Bulletin:
T-SB-0218-17_Rev
Component:
140000 air bags
Summary:
Tsb: revision notice july 20, 2017 rev1: applicability has been updated to exclude 2007 ? 2017 model year avanza vehicles. some hazardous material treatment and handling regulations at the state and local level define the pre-disposal deplo
Bulletin:
T-TT-0086-11
Component:
060000 engine (pws)
Summary:
Techtip: condition - the vehicle may be difficult to start or have an abnormally low or rough idle after the battery has been disconnected or power to the engine ecm has been interrupted.
Bulletin:
D0D_Quick Refere
Component:
161000 structure:frame and members
Summary:
Electronic communication: quick reference guide - due to the expiration of lsc d0d, on august 5, 2015 all vins were marked expired in tis. as a result, claims submitted after this date will automatically be rejected in the cps warranty syst
Bulletin:
DSD_Quick Refere
Component:
161100 structure: frame and members:underbody shields
Summary:
Electronic communication: quick reference guide - due to the expiration of lsc dsd, on august 5, 2015 all vins were marked expired in tis. as a result, claims submitted after this date will automatically be rejected in the cps warranty syst
Bulletin:
D0D_DSD_Limited
Component:
161100 structure: frame and members:underbody shields
Summary:
Dl: these campaigns are expired as of july 31, 2015.
Bulletin:
D0D_Limited Serv
Component:
160000 structure
Summary:
Ec: lsc d0d expires july 31,2015.
Bulletin:
DSD_Limited Serv
Component:
160000 structure
Summary:
Ec: lsc dsd expires july 31,2015.
Bulletin:
D0D_DSD_Limited
Component:
161000 structure:frame and members
Summary:
Dl: these campaigns are expired as of july 31, 2015.
Bulletin:
D0D_DSD_LSC_Regi
Component:
161000 structure:frame and members
Summary:
Rl: toyota will be sending limited service campaign follow-up notices to remind owners whose vehicles have not yet had campaign repairs completed. please note the following information for regional and pd associates.
Bulletin:
D0D_DSD_LSC_Deal
Component:
161000 structure:frame and members
Summary:
Dl: toyota will be sending limited service campaign follow-up notices to remind owners whose vehicles have not yet had campaign repairs completed. please note the following information for regional and pd associates.
Bulletin:
D0D_DSD_Dealer D
Component:
160000 structure
Summary:
Dd: frame replacement-customer vehicles that qualify for frame replacement under d0d/dsd must have their vehicle inspected on or before july 31,2015. frame and ancillary parts orders must be submitted no later than monday, august 4th, 2015
Bulletin:
T-SB-0043-14
Component:
353100 equipment:electrical:anti-theft devices
Summary:
Tsb: the immobilizer and smart key reset is a feature that allows the registration of new keys when all master keys are lost. once the system is reset, all previously registered keys will be erased.
Bulletin:
T-SB-0043-14 Rev
Component:
353100 equipment:electrical:anti-theft devices
Summary:
Tsb: the immobilizer and smart key reset is a feature that allows the registration of new keys when all master keys are lost. once the system is reset, all previously registered keys will be erased.
Bulletin:
T-SB-0012-13 Rev
Component:
118000 electrical system: software
Summary:
Tsb: flash reprogramming allows the ecu software to be updated without replacing the ecu. flash calibration updates for specific vehicle models/ecus are released as field-fix procedures described in individual service bulletins. this bullet
Bulletin:
E0V (E1V) Prelim
Component:
140000 air bags
Summary:
Region letter: the national highway traffic safety administration (nhtsa) and tk holdings, inc. (takata) have requested the support of bmw, chrysler, ford, honda, nissan, mazda, and toyota in investigating certain airbag inflator modules ma
Bulletin:
E0V (E1V)_SSC_El
Component:
140000 air bags
Summary:
Electronic communication: the national highway traffic safety administration (nhtsa) and tk holdings, inc. (takata) have requested the support of bmw, chrysler, ford, honda, nissan, mazda, and toyota in investigating certain airbag inflator
Bulletin:
T-TT-0010-10 Rev
Component:
060000 engine (pws)
Summary:
Tech tip: low battery voltage can contribute to a mil "on" condition for p0335 (crankshaft position
Bulletin:
T-SB-0142-13 Rev
Component:
353600 equipment:air conditioner
Summary:
Tsb: revision notice november 10, 2016 rev2: ? applicability has been updated to include 2016 ? 2017 model year toyota vehicles. ? parts information section has been updated. some 2004 ? 2017 model year toyota vehicles may exhibit odor
Bulletin:
T-SB-0012-13 Rev
Component:
118000 electrical system: software
Summary:
Tsb: obsolete notice: september 14, 2016: this bulletin is now obsolete. please see t-sb-0134-16.
Bulletin:
T-SB-0144-08_Obs
Component:
350000 equipment
Summary:
Tsb: obsolete notice november 21, 2017: this bulletin is now obsolete. please see t-sb-0304-17.
Bulletin:
T-SB-0229-12_Rev
Component:
110000 electrical system
Summary:
Tsb: revision notice november 22, 2017 rev1: ? applicability has been updated to include 2014 ? 2018 model year vehicles. any previous printed versions of this bulletin should be discarded. in the event that a toyota vehicle becomes submerg
Bulletin:
T-SB-0391-08 Rev
Component:
100000 power train
Summary:
This bulletin contains general vehicle pulling diagnosis and repair procedures along with specific information to help correct pulling complaints.
Bulletin:
T-TT-0226-13
Component:
110000 electrical system
Summary:
The customer is having difficulty changing the multi-display screen from day mode. if the multi-display screen is set to day mode when the headlights are on, the setting we be memorized when the engine is turned off.
Bulletin:
SST Requirements
Component:
355200 equipment:other:owners/service/other manual
Summary:
Ssts are key elements to provide your customers with swift and accurate repairs resulting in superior customer satisfaction.
Bulletin:
T-SB-0064-10 Rev
Component:
118000 electrical system: software
Summary:
Flash reprogramming allows the ecu software to be updated without replacing the ecu. flash calibration updates for specific vehicle models/ecus are released as field-fix procedures described in individual service bulletins. this bulletin de
Bulletin:
T-SB-0012-13
Component:
118000 electrical system: software
Summary:
Flash reprogramming allows the ecu software to be updated without replacing the ecu. flash calibration updates for specific vehicle models/ecus are released as field-fix procedures described in individual service bulletins. this bulletin de
Bulletin:
T-SB-0064-10 Rev
Component:
355200 equipment:other:owners/service/other manual
Summary:
This bulletin is now obsolete. please see t-sb-0012-13.
Bulletin:
T-TT-0213-13
Component:
140000 air bags
Summary:
Toyota vehicles are equipped with srs, including various airbags and in some models, seat belt pre-tensioners, to help reduce the risk of injury in a collision. if a customer expresses any concerns that the srs airbags or pretensioner devi
Bulletin:
T-SB-0187-12
Component:
162000 structure:body
Summary:
Toyota vehicles are equipped with either conventional or run-flat tires. sometimes punctures may occur as a result of contact with road debris or other hazards. if a puncture occurs, it may be possible to repair the tire and return it to se
Bulletin:
TSB-0012-13 Rev2
Component:
060000 engine (pws)
Summary:
Tsb: flash reprogramming allows the ecu software to be updated without replacing the ecu. flash calibration updates for specific vehicle models/ecus are released as field-fix procedures described in individual service bulletins. this bull
Bulletin:
T-TT-0381-16
Component:
118000 electrical system: software
Summary:
Tech tip: some customers may experience difficulty programming homelink.
Bulletin:
T-TT-0362-15
Component:
060000 engine (pws)
Summary:
Tt: the vehicle may be difficult to start or have an abnormally low or rough idle after the battery has been disconnected or power to the engine ecm has been interrupted.
Bulletin:
D0D_DSD_Limited
Component:
355200 equipment:other:owners/service/other manual
Summary:
Dl: these campaigns are expired as of july 31, 2015.
Bulletin:
D0D_Limited Serv
Component:
355200 equipment:other:owners/service/other manual
Summary:
Ec: lsc d0d expires july 31,2015.
Bulletin:
DSD_Limited Serv
Component:
355200 equipment:other:owners/service/other manual
Summary:
Ec: lsc dsd expires july 31,2015.
Bulletin:
D0D_DSD_Limited
Component:
355200 equipment:other:owners/service/other manual
Summary:
Dl: these campaigns are expired as of july 31, 2015.
Bulletin:
T-TT-0086-11
Component:
100000 power train
Summary:
Techtip: condition - the vehicle may be difficult to start or have an abnormally low or rough idle after the battery has been disconnected or power to the engine ecm has been interrupted.
Bulletin:
D0D_Quick Refere
Component:
350000 equipment
Summary:
Electronic communication: quick reference guide - due to the expiration of lsc d0d, on august 5, 2015 all vins were marked expired in tis. as a result, claims submitted after this date will automatically be rejected in the cps warranty syst
Bulletin:
DSD_Quick Refere
Component:
356000 equipment adaptive
Summary:
Electronic communication: quick reference guide - due to the expiration of lsc dsd, on august 5, 2015 all vins were marked expired in tis. as a result, claims submitted after this date will automatically be rejected in the cps warranty syst
Bulletin:
D0D_DSD_LSC_Regi
Component:
350000 equipment
Summary:
Rl: toyota will be sending limited service campaign follow-up notices to remind owners whose vehicles have not yet had campaign repairs completed. please note the following information for regional and pd associates.
Bulletin:
D0D_DSD_LSC_Deal
Component:
350000 equipment
Summary:
Dl: toyota will be sending limited service campaign follow-up notices to remind owners whose vehicles have not yet had campaign repairs completed. please note the following information for regional and pd associates.
Bulletin:
D0D_DSD_Dealer D
Component:
160000 structure
Summary:
Dd: frame replacement-customer vehicles that qualify for frame replacement under d0d/dsd must have their vehicle inspected on or before july 31,2015. frame and ancillary parts orders must be submitted no later than monday, august 4th, 2015
Bulletin:
T-SB-0057-18
Component:
350000 equipment
Summary:
Tsb: supersession notice the information contained in this bulletin supersedes service bulletin no. t-sb-0043-14. ? applicability has been updated to include 2017 ? 2018 model year toyota vehicles. service bulletin no. t-sb-0043-14 is obso
Bulletin:
T-SB-0304-17_Rev
Component:
350000 equipment
Summary:
Tsb: revision notice july 31, 2018 rev2: ? the supersession notice has been updated. january 11, 2018 rev1: ? the supersession notice has been updated. any previous printed versions of this bulletin should be discarded. supersession notice
Bulletin:
PG004-97-Obsolet
Component:
350000 equipment
Summary:
Technical service bulletin: obsolete notice: july 31, 2018: this bulletin is now obsolete. please see t-sb-0304-17.
Bulletin:
PG006-01-Obsolet
Component:
350000 equipment
Summary:
Technical service bulletin: obsolete notice: july 31, 2018: this bulletin is now obsolete. please see t-sb-0304-17.
Bulletin:
Safety Recall an
Component:
350000 equipment
Summary:
Update on technician certification requirements.

Home | Privacy