2004 SUZUKI VERONA Recalls (5)
- Campaign:
- 03V333000 on 09/15/2003
- Component:
- Seat belts:front:buckle assembly
- Manufactured:
- 06/15/2003 - 08/25/2003
- Affected:
- 4,548
- Defect:
- Certain passenger vehicles may have a mislocated sensor in the driver's seat belt buckle assembly. this condition can prevent the driver's seat belt tongue from being inserted into the buckle.
- Consequence:
- In the event of a crash, a seat occupant may not be properly restrained increasing the risk of injury.
- Correction:
- Dealers will replace the driver's seat belt buckle assembly. owner notification began september 4, 2003. owners should contact suzuki at 1-800-934-0934.
- Notes:
- Suzuki recall no. k4.customers can also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
- Campaign:
- 03V426000 on 10/29/2003
- Component:
- Air bags:frontal
- Manufactured:
- 06/15/2003 - 10/17/2003
- Affected:
- 7,797
- Defect:
- On certain passenger cars, the dual stage driver's air bag deploys in an improper sequence.
- Consequence:
- If the driver's air bag deploys improperly during a frontal vehicle crash, the driver could be severely injured or killed.
- Correction:
- Dealers will install an adapting wiring harness. owner notification began on october 30, 2003, to verona vehicle owners. all forenza vehicles were repaired at the port of entry. there are no owner notifications necessary for the forenza model vehicles. owners should contact suzuki at 1-800-934-0934.
- Notes:
- Suzuki recall no. kb.customers can also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
- Campaign:
- 04V396000 on 08/12/2004
- Component:
- Fuel system, gasoline:delivery
- Manufactured:
- 05/31/2003 - 05/30/2004
- Affected:
- 16,488
- Defect:
- In certain passenger vehicles, a fault in the adaptive fuel control logic can cause some vehicles to use air/fuel ratios during deceleration that are lean enough to cause engine stalling.
- Consequence:
- Engine stalling could result in a crash.
- Correction:
- Dealers will reprogram the electronic control module (ecm) on affected vehicles. the recall began on september 14, 2004. owners should contact suzuki at 1-800-934-0934.
- Notes:
- Suzuki recall no. ke.customers can contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
- Campaign:
- 05V022000 on 01/30/2005
- Component:
- Exterior lighting:brake lights:switch
- Manufactured:
- 08/03/2003 - 04/19/2004
- Affected:
- 37,796
- Defect:
- On certain passenger vehicles, the brake light switch may become misadjusted if an upward/rearward force is applied to the brake pedal. if this should occur, the brake light switch will not function properly, causing the brake lights, including the high mounted stop lamp, to remain illuminated continuously without brake pedal application, with the ignition switch in the on or off position.
- Consequence:
- If the brake lights remain on continuously while driving,a following driver may not know when your brakes have been applied, and a rear-end crash could occur without prior warning. this condition may also discharge the vehicle's battery, and, the automatic transmission torque converter clutch, cruise control and traction control system, if equipped, will become disabled.
- Correction:
- Dealers will replace the brake light switch free of charge. the recall began on march 16, 2005. owners may contact suzuki at 1-800-934-0934.
- Notes:
- Suzuki recall no. kf. customers may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov.
- Campaign:
- 14V363000 on 06/24/2014
- Component:
- Exterior lighting:headlights
- Manufactured:
- 05/31/2003 - 10/29/2005
- Affected:
- 25,899
- Defect:
- Suzuki motor of america, inc. (suzuki) is recalling certain model year 2004-2006 verona vehicles manufactured june 2003 to october 2005. in the affected vehicles, there may be heat generated within the drl module located in the instrument panel, which could melt the drl module.
- Consequence:
- If the drl module melts due to the heat generation, it could cause a vehicle fire.
- Correction:
- Suzuki will notify owners, and dealers will replace the drl module in the instrument panel, free of charge. the recall began on november 5, 2014. owners can contact suzuki customer service at 1-800-934-0934. suzuki's number for this recall is xc.
- Notes:
- Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.
2004 SUZUKI VERONA TSBs (25)
- Bulletin:
- 0110173R
- Component:
- 350000 equipment
- Summary:
- Tech 2 pcmcia card re flash update. verona model. *tt
- Bulletin:
- 0109043
- Component:
- 151400 seat belts:front:buckle assembly
- Summary:
- Driver's seat belt latch plate/tongue will not insert into the seat belt buckle. safety recall campaign. *tt
- Bulletin:
- 0111213
- Component:
- 110000 electrical system
- Summary:
- Electrical noise on am stations. *tt
- Bulletin:
- 0202244
- Component:
- 140000 air bags
- Summary:
- Replacing the sir clock spring. *tt
- Bulletin:
- 0402274
- Component:
- 150000 seat belts
- Summary:
- Slow and/or incomplete retraction of seat belts. *tt
- Bulletin:
- 0203044
- Component:
- 350000 equipment
- Summary:
- Service manual update for programming keyless transmitters. *tt
- Bulletin:
- 0104084
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Engine control module (ecm) software may cause the malfunction indicator lamp (mil) to fail to illuminate; engine runs rough immediately after starting a cold engine. *tt
- Bulletin:
- 0104304
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Electronic control module (ecm)software update, emission recall campaign kc, (california, new york, massachusetts, manie and vermont only).driveability improvement immediately after starting cold engine. *mj
- Bulletin:
- 0306234
- Component:
- 063110 engine and engine cooling:exhaust system:emission control:crankcase (pcv)
- Summary:
- Service manual updated - oil viscosity and crankcase capacity including oil filter. *mj
- Bulletin:
- 0204145
- Component:
- 062000 engine and engine cooling:cooling system
- Summary:
- Correct coolant usage. *eh
- Bulletin:
- 0305115R
- Component:
- 134000 visibility:sun roof assembly
- Summary:
- Sunroof will not close completely or closes and moves to vent position. *sc
- Bulletin:
- 0205135
- Component:
- 021100 suspension:front:stabilizer bar
- Summary:
- Noise from the front stabilizer bar bushings. including the 2005 suzuki verona *sc
- Bulletin:
- 0412174
- Component:
- 072200 fuel system, gasoline:delivery:hoses, lines/piping, and fittings
- Summary:
- Fuel line disconnecting procedure. including 2004 suzuki wagon, reno (rq420) and verona (rp625). *sc
- Bulletin:
- 0112174
- Component:
- 072200 fuel system, gasoline:delivery:hoses, lines/piping, and fittings
- Summary:
- Fuel line disconnecting procedure. suzuki 2004 forenza, wagon, reno (rq420), and verona (rp625). *sc
- Bulletin:
- 0506035
- Component:
- 103100 power train:automatic transmission:control module (tcm, pcm)
- Summary:
- Transmission control module (tcm) reprogramming to improve transmission shift quality. *tt
- Bulletin:
- 0810245
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Oil leak from drain plug. *tt
- Bulletin:
- 0710185
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Engine control module (ecm) reprogramming for false slow o2 sensor diagnostic trouble codes (dtcs). *tt
- Bulletin:
- 0211075
- Component:
- 103000 power train:automatic transmission
- Summary:
- Automatic transmission diagnostic trouble code (dtc) p0703 is present. dtc p0703 explained. *tt
- Bulletin:
- 101215
- Component:
- 063130 engine and engine cooling:exhaust system:emission control:gas recirculation valve (egr valve)
- Summary:
- Service manual update: egr dtcs p0400, p0401 and p0402. *tt
- Bulletin:
- 0701266
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Ecm reprogramming for false slow o2 sensor dtcs, evap related dtcs and various other unintended dtcs. *tt
- Bulletin:
- 0408115
- Component:
- 114000 electrical system:wiring
- Summary:
- Wire harness insulation damage behind the left front fender liner. *tt
- Bulletin:
- 1407276
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- O2 sensor replacement, affected vin list, customer satisfaction service action.
- Bulletin:
- TS0301238
- Component:
- 103100 power train:automatic transmission:control module (tcm, pcm)
- Summary:
- Automatic transmission control module initialization procedure. my 2004-2006 verona (rp625). *nj
- Bulletin:
- TS0301238
- Component:
- 103100 power train:automatic transmission:control module (tcm, pcm)
- Summary:
- Automatic transmission control module initialization procedure. *nj
- Bulletin:
- TS-04-03049
- Component:
- 103000 power train:automatic transmission
- Summary:
- Suzuki: automatic transmission shift lever is loose in the shift gate and/or ignition key cannot be removed. the transmission gear shift lever does not hold firmly to the left of the shift gate as expected. the shift lever tension spring h
Home | Privacy