2004 MITSUBISHI FUSO FK617 Recalls (3)
- Campaign:
- 04V437000 on 09/09/2004
- Component:
- Interior lighting
- Manufactured:
- 04/13/1995 - 12/22/2003
- Affected:
- 16,101
- Defect:
- On certain trucks, the rebound cushion may stick to the hook hinge bracket, due to improper rubber composition of the cushion. this condition could result in the hook pin bracket remaining in the up (cab closed) position when the cab latch is unlocked. with the hook pin bracket in the up position, the cab tilt lock switch remains closed, improperly indicating that the cab latch is locked.
- Consequence:
- If the cab latch is unlocked for any reason, the instrument panel cab lock indicator will not notify the driver that the cab tilt lock mechanism is in the unlocked position. a crash could occur without prior warning.
- Correction:
- Dealers will replace the rebound cushion with a modified component and adjust the cable tilt lock switch and bottom bracket at the rear cab mount. the recall began on october 28, 2004. owners should contact mitsubishi fuso at 1-877-711-0707.
- Notes:
- Mitsubishi fuso recall no. s3026120.customers can also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
- Campaign:
- 04V478000 on 10/17/2004
- Component:
- Suspension:front:hub
- Manufactured:
- 05/22/2002 - 12/22/2003
- Affected:
- 2,537
- Defect:
- On certain trucks trucks equipped with an f040t front axle. the front wheel hub outer bearing lock nut may have been improperly tightened during assembly, and an insufficient amount of grease may have been applied to the outer bearing.
- Consequence:
- These conditions could result in the outer bearing generating excessive heat and/or breaking, causing the vehicle to become disabled. the excessive heat could cause a fire.
- Correction:
- Dealers will inspect the inner and outer front wheel hub bearings, and replace any bearing with signs of damage. the recall began on october 28, 2004. owners should contact mitsubishi fuso at 1-856-467-4500.
- Notes:
- Mitsubishi fuso recall no. r3123510.customers can also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
- Campaign:
- 09E010000 on 03/29/2009
- Component:
- Exterior lighting:headlights
- Affected:
- 156
- Defect:
- Mitsubishi fuso truck of america (mfta) is recalling 156 halogen sealed beam high beam headlamp assemblies sold between october 24, 2007 and december 2, 2008 for use as replacement equipment for certain mitsubishi fuso trucks. these lamps fail to conform to the sae standards or recommended practices referenced in table i of federal motor vehicle safety standard no. 108, "lamps, reflective devices, and associated equipment."
- Consequence:
- The purpose of this standard is to reduce deaths and injuries from motor vehicle crashes by providing adequate illumination of the roadway.
- Correction:
- Mfta will notify owners and replace the headlamps free of charge. the safety recall began on april 15, 2009. owners may contact mfta at 1-856-467-4500.
- Notes:
- Mfta's recall no. c1003910.owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to <a href=http://www.safercar.gov>http://www.safercar.gov</a> .
2004 MITSUBISHI FUSO FK617 TSB
- Bulletin:
- SC-C-0040690
- Component:
- 061200 engine and engine cooling:engine:diesel
- Summary:
- Mitsubishi truck: dpf caution label. enclosed is a replacement self adhesive diesel particulate filter (dpf) caution label to install over the existing label and a replacement dpf hang tag for the truck. the new label and hang tag better
Home | Privacy