2004 MAZDA RX-8 Recalls (14)

Campaign:
04V074000 on 02/29/2004
Component:
Air bags:frontal
Manufactured:
04/09/2003 - 01/27/2004
Affected:
29,300
Defect:
As a result of an ncap test, certain passenger vehicles are being recalled for improperly wired front passenger seat air bags.
Consequence:
The air bag will not provide adequate protection when the vehicle is involved in a frontal crash.
Correction:
Dealers will install a new wiring harness in the front passenger seat air bag system. the recall began march 5, 2004. owners should contact mazda at 1-800-222-5500.
Notes:
Mazda recall no. 1604b-b.customers can also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
Campaign:
04V075000 on 02/29/2004
Component:
Power train:manual transmission
Manufactured:
04/09/2003 - 08/28/2003
Affected:
12,000
Defect:
On certain passenger vehicles with manual transmissions, the heat insulator may be cracked causing abnormal noise.
Consequence:
Continued operation of the vehicle can cause the insulator to come off and could pose a hazard to following vehicles.
Correction:
Dealers will replace the heat insulator. the recall began march 5, 2004. owners should contact mazda at 1-800-222-5500.
Notes:
Mazda recall no. 1704b.customers can also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
Campaign:
05V317000 on 07/13/2005
Component:
Engine and engine cooling
Manufactured:
04/09/2003 - 07/06/2005
Affected:
52,000
Defect:
If certain passenger vehicles are parked and the engine is operated at high rpm's for an excessive length of time, some of the parts around the exhaust system can melt and produce a variety of malfunctions. problems caused by the excessive heat build-up can range from inoperative oxygen sensor, neutral switch and back up lights, problems with the parking brakes, malfunctions of the gas gauge and/or possible fuel leaks resulting from heat damage to the fuel tank.
Consequence:
Fuel leakage, in the presence of an ignition source, could result in a fire.
Correction:
Dealers will inspect and replace parts. the recall began on august 30, 2005. owners may contact mazda at 1-800-222-5500.
Notes:
Mazda recall no.3305g.customers may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.
Campaign:
05V325000 on 07/19/2005
Component:
Suspension:front:control arm:lower ball joint
Affected:
27,800
Defect:
On certain passenger vehicles, due to improper forging of the lower control arm, cracks may occur in the ball joint socket.
Consequence:
In severe driving conditions, the ball may separate from the ball joint socket and a loss of steering may occur, which could result in a crash.
Correction:
Dealers will inspect and, if necessary, replace the control arms. the recall began on august 30, 2005. owners may contact mazda at 1-800-222-5500.
Notes:
Mazda recall no. 3405g.customers may also contact the national highway traffic safety administration's auto safety hotline at 1-888-327-4236; (tty: 1-800-424-9153); or go to http://www.safercar.gov.
Campaign:
16V354000 on 05/24/2016
Component:
Air bags:passenger side frontal
Manufactured:
04/09/2003 - 05/15/2011
Affected:
448,320
Defect:
Mazda north american operations (mazda) is recalling certain model year 2004-2011 rx-8, 2004-2006 mpv, 2003-2008 mazda6, and 2006-2007 mazdaspeed6 vehicles, originally sold, or ever registered, in alabama, california, florida, georgia, hawaii, louisiana, mississippi, south carolina, texas, puerto rico, american samoa, guam, the northern mariana islands (saipan), and the u.s. virgin islands, or "zone a." additionally, unless included in "zone a" above, mazda is recalling certain model year 2004-2008 rx-8, 2004-2006 mpv, 2003-2008 mazda6 vehicles, originally sold, or ever registered, in arizona, arkansas, delaware, district of columbia, illinois, indiana, kansas, kentucky, maryland, missouri, nebraska, nevada, new jersey, new mexico, north carolina, ohio, oklahoma, pennsylvania, tennessee, virginia, and west virginia, or "zone b." lastly, unless included in "zone a" or "zone b" above, mazda is recalling certain model year 2004 mazda rx-8 and mpv, 2003-2004 mazda6 vehicles originally sold, or registered, in alaska, colorado, connecticut, idaho, iowa, maine, massachusetts, michigan, minnesota, montana, new hampshire, new york, north dakota, oregon, rhode island, south dakota, utah, vermont, washington, wisconsin, and wyoming. these vehicles are equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules, and used as original equipment or replacement equipment. in the event of a crash necessitating deployment of the front air bags, these inflators may rupture due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling.
Consequence:
An inflator rupture may result in metal fragments striking the vehicle occupants resulting in serious injury or death.
Correction:
Mazda will notify owners, and dealers will replace the passenger frontal air bag inflator, free of charge. the recall began july 2016. owners may contact mazda customer service at 1-800-222-5500. mazda's number for this recall is 9416e. note: this recall is partially superseded by recall 18v402.
Notes:
Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.
Campaign:
16V354000 on 05/24/2016
Component:
Air bags:passenger side frontal
Manufactured:
04/09/2003 - 05/15/2011
Affected:
448,320
Defect:
Mazda north american operations (mazda) is recalling certain model year 2004-2011 rx-8, 2004-2006 mpv, 2003-2008 mazda6, and 2006-2007 mazdaspeed6 vehicles, originally sold, or ever registered, in alabama, california, florida, georgia, hawaii, louisiana, mississippi, south carolina, texas, puerto rico, american samoa, guam, the northern mariana islands (saipan), and the u.s. virgin islands, or "zone a." additionally, unless included in "zone a" above, mazda is recalling certain model year 2004-2008 rx-8, 2004-2006 mpv, 2003-2008 mazda6 vehicles, originally sold, or ever registered, in arizona, arkansas, delaware, district of columbia, illinois, indiana, kansas, kentucky, maryland, missouri, nebraska, nevada, new jersey, new mexico, north carolina, ohio, oklahoma, pennsylvania, tennessee, virginia, and west virginia, or "zone b." lastly, unless included in "zone a" or "zone b" above, mazda is recalling certain model year 2004 mazda rx-8 and mpv, 2003-2004 mazda6 vehicles originally sold, or registered, in alaska, colorado, connecticut, idaho, iowa, maine, massachusetts, michigan, minnesota, montana, new hampshire, new york, north dakota, oregon, rhode island, south dakota, utah, vermont, washington, wisconsin, and wyoming. these vehicles are equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules, and used as original equipment or replacement equipment. in the event of a crash necessitating deployment of the front air bags, these inflators may rupture due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling.
Consequence:
An inflator rupture may result in metal fragments striking the vehicle occupants resulting in serious injury or death.
Correction:
Mazda will notify owners, and dealers will replace the passenger frontal air bag inflator, free of charge. the recall began july 2016. owners may contact mazda customer service at 1-800-222-5500. mazda's number for this recall is 9416e. note: this recall is partially superseded by recall 18v402.
Notes:
Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.
Campaign:
16V354000 on 05/24/2016
Component:
Air bags:passenger side frontal
Manufactured:
04/09/2003 - 05/15/2011
Affected:
448,320
Defect:
Mazda north american operations (mazda) is recalling certain model year 2004-2011 rx-8, 2004-2006 mpv, 2003-2008 mazda6, and 2006-2007 mazdaspeed6 vehicles, originally sold, or ever registered, in alabama, california, florida, georgia, hawaii, louisiana, mississippi, south carolina, texas, puerto rico, american samoa, guam, the northern mariana islands (saipan), and the u.s. virgin islands, or "zone a." additionally, unless included in "zone a" above, mazda is recalling certain model year 2004-2008 rx-8, 2004-2006 mpv, 2003-2008 mazda6 vehicles, originally sold, or ever registered, in arizona, arkansas, delaware, district of columbia, illinois, indiana, kansas, kentucky, maryland, missouri, nebraska, nevada, new jersey, new mexico, north carolina, ohio, oklahoma, pennsylvania, tennessee, virginia, and west virginia, or "zone b." lastly, unless included in "zone a" or "zone b" above, mazda is recalling certain model year 2004 mazda rx-8 and mpv, 2003-2004 mazda6 vehicles originally sold, or registered, in alaska, colorado, connecticut, idaho, iowa, maine, massachusetts, michigan, minnesota, montana, new hampshire, new york, north dakota, oregon, rhode island, south dakota, utah, vermont, washington, wisconsin, and wyoming. these vehicles are equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules, and used as original equipment or replacement equipment. in the event of a crash necessitating deployment of the front air bags, these inflators may rupture due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling.
Consequence:
An inflator rupture may result in metal fragments striking the vehicle occupants resulting in serious injury or death.
Correction:
Mazda will notify owners, and dealers will replace the passenger frontal air bag inflator, free of charge. the recall began july 2016. owners may contact mazda customer service at 1-800-222-5500. mazda's number for this recall is 9416e. note: this recall is partially superseded by recall 18v402.
Notes:
Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.
Campaign:
16V354000 on 05/24/2016
Component:
Air bags:passenger side frontal
Manufactured:
04/09/2003 - 05/15/2011
Affected:
448,320
Defect:
Mazda north american operations (mazda) is recalling certain model year 2004-2011 rx-8, 2004-2006 mpv, 2003-2008 mazda6, and 2006-2007 mazdaspeed6 vehicles, originally sold, or ever registered, in alabama, california, florida, georgia, hawaii, louisiana, mississippi, south carolina, texas, puerto rico, american samoa, guam, the northern mariana islands (saipan), and the u.s. virgin islands, or "zone a." additionally, unless included in "zone a" above, mazda is recalling certain model year 2004-2008 rx-8, 2004-2006 mpv, 2003-2008 mazda6 vehicles, originally sold, or ever registered, in arizona, arkansas, delaware, district of columbia, illinois, indiana, kansas, kentucky, maryland, missouri, nebraska, nevada, new jersey, new mexico, north carolina, ohio, oklahoma, pennsylvania, tennessee, virginia, and west virginia, or "zone b." lastly, unless included in "zone a" or "zone b" above, mazda is recalling certain model year 2004 mazda rx-8 and mpv, 2003-2004 mazda6 vehicles originally sold, or registered, in alaska, colorado, connecticut, idaho, iowa, maine, massachusetts, michigan, minnesota, montana, new hampshire, new york, north dakota, oregon, rhode island, south dakota, utah, vermont, washington, wisconsin, and wyoming. these vehicles are equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules, and used as original equipment or replacement equipment. in the event of a crash necessitating deployment of the front air bags, these inflators may rupture due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling.
Consequence:
An inflator rupture may result in metal fragments striking the vehicle occupants resulting in serious injury or death.
Correction:
Mazda will notify owners, and dealers will replace the passenger frontal air bag inflator, free of charge. the recall began july 2016. owners may contact mazda customer service at 1-800-222-5500. mazda's number for this recall is 9416e. note: this recall is partially superseded by recall 18v402.
Notes:
Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.
Campaign:
16V354000 on 05/24/2016
Component:
Air bags:passenger side frontal
Manufactured:
04/09/2003 - 05/15/2011
Affected:
448,320
Defect:
Mazda north american operations (mazda) is recalling certain model year 2004-2011 rx-8, 2004-2006 mpv, 2003-2008 mazda6, and 2006-2007 mazdaspeed6 vehicles, originally sold, or ever registered, in alabama, california, florida, georgia, hawaii, louisiana, mississippi, south carolina, texas, puerto rico, american samoa, guam, the northern mariana islands (saipan), and the u.s. virgin islands, or "zone a." additionally, unless included in "zone a" above, mazda is recalling certain model year 2004-2008 rx-8, 2004-2006 mpv, 2003-2008 mazda6 vehicles, originally sold, or ever registered, in arizona, arkansas, delaware, district of columbia, illinois, indiana, kansas, kentucky, maryland, missouri, nebraska, nevada, new jersey, new mexico, north carolina, ohio, oklahoma, pennsylvania, tennessee, virginia, and west virginia, or "zone b." lastly, unless included in "zone a" or "zone b" above, mazda is recalling certain model year 2004 mazda rx-8 and mpv, 2003-2004 mazda6 vehicles originally sold, or registered, in alaska, colorado, connecticut, idaho, iowa, maine, massachusetts, michigan, minnesota, montana, new hampshire, new york, north dakota, oregon, rhode island, south dakota, utah, vermont, washington, wisconsin, and wyoming. these vehicles are equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules, and used as original equipment or replacement equipment. in the event of a crash necessitating deployment of the front air bags, these inflators may rupture due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling.
Consequence:
An inflator rupture may result in metal fragments striking the vehicle occupants resulting in serious injury or death.
Correction:
Mazda will notify owners, and dealers will replace the passenger frontal air bag inflator, free of charge. the recall began july 2016. owners may contact mazda customer service at 1-800-222-5500. mazda's number for this recall is 9416e. note: this recall is partially superseded by recall 18v402.
Notes:
Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.
Campaign:
16V354000 on 05/24/2016
Component:
Air bags:passenger side frontal
Manufactured:
04/09/2003 - 05/15/2011
Affected:
448,320
Defect:
Mazda north american operations (mazda) is recalling certain model year 2004-2011 rx-8, 2004-2006 mpv, 2003-2008 mazda6, and 2006-2007 mazdaspeed6 vehicles, originally sold, or ever registered, in alabama, california, florida, georgia, hawaii, louisiana, mississippi, south carolina, texas, puerto rico, american samoa, guam, the northern mariana islands (saipan), and the u.s. virgin islands, or "zone a." additionally, unless included in "zone a" above, mazda is recalling certain model year 2004-2008 rx-8, 2004-2006 mpv, 2003-2008 mazda6 vehicles, originally sold, or ever registered, in arizona, arkansas, delaware, district of columbia, illinois, indiana, kansas, kentucky, maryland, missouri, nebraska, nevada, new jersey, new mexico, north carolina, ohio, oklahoma, pennsylvania, tennessee, virginia, and west virginia, or "zone b." lastly, unless included in "zone a" or "zone b" above, mazda is recalling certain model year 2004 mazda rx-8 and mpv, 2003-2004 mazda6 vehicles originally sold, or registered, in alaska, colorado, connecticut, idaho, iowa, maine, massachusetts, michigan, minnesota, montana, new hampshire, new york, north dakota, oregon, rhode island, south dakota, utah, vermont, washington, wisconsin, and wyoming. these vehicles are equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules, and used as original equipment or replacement equipment. in the event of a crash necessitating deployment of the front air bags, these inflators may rupture due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling.
Consequence:
An inflator rupture may result in metal fragments striking the vehicle occupants resulting in serious injury or death.
Correction:
Mazda will notify owners, and dealers will replace the passenger frontal air bag inflator, free of charge. the recall began july 2016. owners may contact mazda customer service at 1-800-222-5500. mazda's number for this recall is 9416e. note: this recall is partially superseded by recall 18v402.
Notes:
Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.
Campaign:
16V793000 on 10/30/2016
Component:
Fuel system, gasoline:delivery:fuel pump
Manufactured:
04/09/2003 - 02/07/2008
Affected:
69,447
Defect:
Mazda north america operations (mazda) is recalling certain model year 2004-2008 rx-8 vehicles manufactured april 10, 2003, to february 18, 2008. the affected vehicles have fuel pump sealing rings that may deteriorate due to exposure to heat from the engine or exhaust pipe.
Consequence:
The deteriorated seals may leak fuel, which, in the presence of an ignition source, can increase the risk of a fire.
Correction:
Mazda will notify owners, and dealers will replace the fuel pump sealing ring set and add a thermal insulation pad to the fuel tank, free of charge. the recall began july 31, 2017. owners may contact mazda customer service at 1-800-222-5500. mazda's number for this recall is 0516j.
Notes:
Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.
Campaign:
17V354000 on 06/01/2017
Component:
Fuel system, gasoline:delivery:fuel pump
Manufactured:
04/09/2003 - 02/17/2008
Affected:
69,447
Defect:
Mazda north america operations (mazda) is recalling certain model year 2004-2008 rx-8 vehicles. heat from the engine and the exhaust may cause the main fuel pump pipe to crack.
Consequence:
If the fuel pump pipe cracks, fuel may leak, increasing the risk of a fire.
Correction:
Mazda will notify owners, and dealers will replace the fuel pump filter kit, free of charge. the recall began on july 31, 2017. owners may contact mazda customer service at 1-800-222-5500. mazda's number for this recall is 1017e.
Notes:
Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.
Campaign:
17V355000 on 06/01/2017
Component:
Suspension:front:control arm:lower arm
Manufactured:
04/09/2003 - 05/06/2004
Affected:
35,332
Defect:
Mazda north american operations (mazda) is recalling certain 2004 mazda rx-8 vehicles. the ball joint socket on the front suspension lower control arm may crack and the ball joint may separate from the socket.
Consequence:
If the ball joint separates, steering control may be lost, increasing the risk of a crash.
Correction:
Mazda will notify owners, and dealers will replace the front lower control arms, free of charge. the recall began on july 31, 2017. owners may contact mazda customer service at 1-800-222-5500. mazda's number for this recall is 1117e.
Notes:
Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.
Campaign:
17V474000 on 07/27/2017
Component:
Air bags:frontal:driver side inflator module
Manufactured:
04/09/2003 - 02/17/2008
Affected:
308,992
Defect:
Mazda north american operations (mazda) is recalling certain model year 2003-2008 mazda6, 2004-2008 rx-8, and 2006-2007 mazdaspeed6 vehicles. the affected vehicles are equipped with a dual-stage driver frontal air bag that may be susceptible to moisture intrusion and other factors, including manufacturing variability that, over time, could cause the inflator to rupture.
Consequence:
In the event of a crash necessitating deployment of the driver's frontal air bag, the inflator could rupture with metal fragments striking the driver or other occupants resulting in serious injury or death.
Correction:
Mazda will notify owners, and dealers will replace the driver's frontal air bag inflator with an alternate inflator, free of charge. the recall began on september 12, 2017. owners may contact mazda customer service at 1-800-222-5500. mazda's number for this recall is 1417g. note: this recall supersedes recall 15v-382.
Notes:
Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.

2004 MAZDA RX-8 TSBs (126)

Bulletin:
0700303
Component:
138130 visibility:defroster/defogger system:windshield:controls/wiring
Summary:
Temperature control dial and/or fan control dial break or come off. *tt
Bulletin:
0102403
Component:
110000 electrical system
Summary:
Malfunction indicator lamp on with diagnostic trouble code p0128 and/or p0456. *tt
Bulletin:
0102703
Component:
061000 engine and engine cooling:engine
Summary:
Low oil level warning light comes on when level is not low. *tt
Bulletin:
0300403
Component:
105500 power train:driveline:differential unit
Summary:
The manual for the rx8 recommends using api service gl-5 sae-90 oil for differential lubrication. gl-5 sae-90 oil is not easily found in the north america. the oils have been tested and approved for use in the rx8 with no loss of performa
Bulletin:
0200203
Component:
199000 tires:pressure monitoring and regulating systems
Summary:
Tire pressure monitoring system (tpms) warning lamp illuminated and a warning buzzer no diagnostic trouble code (dtc)-service tips. *mn *tt
Bulletin:
0100104
Component:
061000 engine and engine cooling:engine
Summary:
Engine cover grommets missing. *tt
Bulletin:
0004123
Component:
103100 power train:automatic transmission:control module (tcm, pcm)
Summary:
B28 and later pcm calibration update information. repair information review1. *tt
Bulletin:
0004228
Component:
103100 power train:automatic transmission:control module (tcm, pcm)
Summary:
Power train control module (pcm) configuration (pmi) problem wds b28.0. repair information review1. *tt
Bulletin:
0100704
Component:
060000 engine and engine cooling
Summary:
A malfunction indicator lamp with diagnostic trouble code (dtc) p0300-0302 (misfire) when running, after the engine has been replaced. after replacing the engine, the eccentric shaft position sensor will remain in the pcm, causing the pcm
Bulletin:
0700204
Component:
353600 equipment:air conditioner
Summary:
Lack of air conditioner cooling performance and / or a noticable temperature fluctuation from the vents. *tt
Bulletin:
0101104
Component:
061000 engine and engine cooling:engine
Summary:
Engine cranks no start. *tt update. *tt
Bulletin:
0102204
Component:
061000 engine and engine cooling:engine
Summary:
Mazda special program (msp04) - engine no start, lack of power, diagnostic trouble codes p2107, p2108, p2402, or p0420 - powertrain control module (pcm) reflash. *tt
Bulletin:
01012004
Component:
110000 electrical system
Summary:
Module configuration. mazda m-tips. *tt
Bulletin:
0902604
Component:
353000 equipment:electrical
Summary:
Speedometer replacement procedure. *tt
Bulletin:
0102504
Component:
111000 electrical system:battery
Summary:
Battery test procedure requirements. *tt
Bulletin:
0902804
Component:
162000 structure:body
Summary:
Interference between trunk, rear combination lamps and/or rear bumper. *tt
Bulletin:
08262004
Component:
980000 unknown or other
Summary:
Dealer notice - service bulletin release - 08/26/2004. *tt
Bulletin:
0903504
Component:
133000 visibility:power window devices and controls
Summary:
Power window inoperative. *tt
Bulletin:
0400604
Component:
030000 service brakes, hydraulic
Summary:
Squeal noise from front brakes during braking. *tt
Bulletin:
0903404
Component:
220000 seats
Summary:
Chips and scratches on front seatback cover - leather seats. *tt
Bulletin:
0800404
Component:
140000 air bags
Summary:
Driver side air bag rattle. *tt
Bulletin:
00204
Component:
063100 engine and engine cooling:exhaust system:emission control
Summary:
Evaporative emmissions and reciver adapters. *eh
Bulletin:
06012004
Component:
353500 equipment:electrical:navigational system(global positioning system)
Summary:
Navigation system voice guidance. *jb
Bulletin:
06012004
Component:
103300 power train:automatic transmission:gear position indication (prndl)
Summary:
Gear range indicator change. *jb
Bulletin:
06012004
Component:
036400 service brakes, hydraulic:antilock:abs warning light
Summary:
Abs/tcs light on/lack of power. *jb
Bulletin:
06012004
Component:
200000 wheels
Summary:
Clicking noise from rear wheels. *jb
Bulletin:
06012004
Component:
103100 power train:automatic transmission:control module (tcm, pcm)
Summary:
Programmable module installation. ( 2004 mazda b series) *jb
Bulletin:
0104204
Component:
111000 electrical system:battery
Summary:
Battery replacement - service tip. *tt
Bulletin:
01012005
Component:
061000 engine and engine cooling:engine
Summary:
Diagnostic trouble code p0336 (eccentric shaft position sensor range/performance) at time of engine start. *tt
Bulletin:
01012005
Component:
061000 engine and engine cooling:engine
Summary:
Engine stalling at idle, p0172 (fuel trim too rich) after engine replacement, intake manifold removal/replacement, engine harness removal/replacement or fuel injector removal/replacement. *tt
Bulletin:
01012005
Component:
353400 equipment:electrical:radio/tape deck/cd etc.
Summary:
Satellite enabled audio units. *tt
Bulletin:
01012005
Component:
111000 electrical system:battery
Summary:
Battery replacement service tip. *tt
Bulletin:
04
Component:
061000 engine and engine cooling:engine
Summary:
Service program msp 04 campaign to reflash the power control module due to vehicles failing to start in cold ambient temperatures or hard to start after short distance driving when the engine does not reach normal operating temperature.
Bulletin:
0800805
Component:
140000 air bags
Summary:
Airbag warning light illuminated - dtc b1994 and/or b1998 set. *tt
Bulletin:
090104
Component:
061000 engine and engine cooling:engine
Summary:
Whine/squeal from engine at idle. *jb
Bulletin:
090104
Component:
138130 visibility:defroster/defogger system:windshield:controls/wiring
Summary:
Phantom fan speed indicator. *jb
Bulletin:
090104
Component:
138130 visibility:defroster/defogger system:windshield:controls/wiring
Summary:
Grease oozing from audio switch. *jb
Bulletin:
0103105
Component:
091100 fuel system, other:storage:tank assembly
Summary:
Fuel distributor insulator-removal / installation cautions-service tip. *ts
Bulletin:
0100405
Component:
061000 engine and engine cooling:engine
Summary:
Difficulty starting engine crank. *ts
Bulletin:
11012005
Component:
063200 engine and engine cooling:exhaust system:manifold/header/muffler/tail pipe
Summary:
P0442, p0455, p0456 set in powertrain control module (pcm). long cranking time to engine start. *tt
Bulletin:
01012006
Component:
162000 structure:body
Summary:
Broken rear license plate attachment. to include mazda rx-8 2006. *tt
Bulletin:
0100206
Component:
060000 engine and engine cooling
Summary:
Engine misfire diagnostic procedures - service tip. *tt
Bulletin:
0200406
Component:
194000 tires:valve
Summary:
Tpms valve stem breaks when removing aftermarket valve stem caps - service tip. *tt
Bulletin:
0500406
Component:
102000 power train:manual transmission
Summary:
Manual transmission-clutch hard to disengage. *kb
Bulletin:
0103906
Component:
010000 steering
Summary:
Mazda modular diagnostic system (m-mds) steering wheel angle sensor module self test shows fail. *kb
Bulletin:
0800306
Component:
140000 air bags
Summary:
Non genuine accessories affect air bag operation. *kb
Bulletin:
0900807
Component:
121000 exterior lighting:headlights
Summary:
Headlight auto-leveling malfunction indicator light illuminates. *kb
Bulletin:
0101407
Component:
061000 engine and engine cooling:engine
Summary:
Malfunction indicator lamp (mil) illuminated - p2004 set. *kb
Bulletin:
0901407
Component:
120000 exterior lighting
Summary:
Water in rear combination light. *kb
Bulletin:
0101607
Component:
116000 electrical system:ignition
Summary:
Ignition coil inspection. *kb
Bulletin:
00307
Component:
980000 unknown or other
Summary:
Availability of non-required tools. *kb
Bulletin:
01-013/08
Component:
103100 power train:automatic transmission:control module (tcm, pcm)
Summary:
Mazda special program (msp16) - engine lack of power -pcm reflash. vehicles produced from april 10, 2003 through nov. 9, 2007. vin range jm1fe17**40100053 - 80215462. *nj updated 6/3/08. *nj
Bulletin:
01-014/08
Component:
061000 engine and engine cooling:engine
Summary:
Engine lack of power. *nj
Bulletin:
01-015/08
Component:
061000 engine and engine cooling:engine
Summary:
Engine cranks no start. *nj
Bulletin:
01-019/08
Component:
062000 engine and engine cooling:cooling system
Summary:
Some vehicles may experience a mil with dtc p2070 (ssv stuck open). *nj
Bulletin:
02-005-08
Component:
021100 suspension:front:stabilizer bar
Summary:
Mazda: noise from front of vehicle/stabilizer control link broken. the plastic insert connecting the stabilizer control link ball joint to the control link may crack and become separated. *pe updated 3/19/09. *pe
Bulletin:
SB-01-016-10
Component:
061000 engine and engine cooling:engine
Summary:
Mazda: hesitation/idle vibration due to cracked engine mount. on some vehicles with manual transmission may experience deceleration in 3rd gear with engine speed less than 3000 rpm at approx. 30 mph (50km/h), then quickly depressing the a
Bulletin:
SB-09-057-10
Component:
120000 exterior lighting
Summary:
Mazda: there is condensation and fog in the front and rear combination lights. *rm
Bulletin:
04-002-12
Component:
046000 service brakes, air:antilock
Summary:
Mazda: clunk/bang noise during first forward movement after sitting. this is a normal operating noise of the anti-lock brake system (abs). do not attempt any repairs. also included model cx-5 year 2013; model cx-9 years 2012-2013; model mia
Bulletin:
SB-09-005-13
Component:
350000 equipment
Summary:
Mazda: on some vehicles, to avoid potential interference of foot placed on pedals, information is provided regarding proper use, and placement, of driver's floor mat. various models and model years. *pe
Bulletin:
SR-7714-F
Component:
141000 air bags:frontal
Summary:
Mazda: see document search button for owner letter. an increased combustion, during air bag deployment, is due to inflator propellant material, that was improperly processed and air bag module can rupture and injure occupant(s). model 20
Bulletin:
02-004-14
Component:
011000 steering:wheel and handle bar
Summary:
Summary to be provided on a future date.
Bulletin:
RF-14-11
Component:
111000 electrical system:battery
Summary:
Summary to be provided on a future date.
Bulletin:
SA234
Component:
118000 electrical system: software
Summary:
Ids update 101.00 and 101.02 is now available on ms3 under the "ids/infotainment" tab.
Bulletin:
SA327
Component:
140000 air bags
Summary:
Takata recalls general information purpose: this page was created to assist with handling takata air bag recalls. processes: please use these process flowcharts to properly handle vehicles subject to the takata air bag recall. recall 82
Bulletin:
02-009-16-3155
Component:
010000 steering
Summary:
Some customers may complain that the steering wheel is off center more than 3° even when driving straight on a flat road.
Bulletin:
MTI_1034
Component:
138120 visibility:defroster/defogger system:windshield:heater core
Summary:
This article provides hvac heater/defroster operating tips using mode selector dial. this includes the use of intermediate positions.
Bulletin:
MTI_1111
Component:
350000 equipment
Summary:
When installing a navigation sd card, confirm that the card is unlocked. also, mazda does not recommend swapping navigation system sd cards from one vehicle to another for testing. if swapped, the sd card that is installed into the other ve
Bulletin:
MTI_1031
Component:
350000 equipment
Summary:
Some customers may complain about a blurry rear view monitor display. this may be caused by an aftermarket accessory device.
Bulletin:
MTI_1032
Component:
350000 equipment
Summary:
Some customers may complain about a rattle type noise coming from the rear of the vehicle when driving on rough roads. this may be caused by a loose spare tire jack.
Bulletin:
MTI_1034
Component:
138000 visibility:defroster/defogger system
Summary:
This article provides hvac heater/defroster operating tips using mode selector dial. this includes the use of intermediate positions.
Bulletin:
MTI_1111
Component:
350000 equipment
Summary:
When installing a navigation sd card, confirm that the card is unlocked. also, mazda does not recommend swapping navigation system sd cards from one vehicle to another for testing. if swapped, the sd card that is installed into the other ve
Bulletin:
MTI_1031
Component:
350000 equipment
Summary:
Some customers may complain about a blurry rear view monitor display. this may be caused by an aftermarket accessory device
Bulletin:
1066M
Component:
120000 exterior lighting
Summary:
Some customers may complain about improper operation of the auto-dimming mirror. this may be caused by an obstruction of the front and/or rear light sensor(s) (e.g. hanging a parking permit from the mirror). use a soft cloth with mild deter
Bulletin:
1099M
Component:
110000 electrical system
Summary:
When reprogramming a control module, always use the gr-8 battery management system power supply mode. if not used, the control module reprogramming may fail due to a weak vehicle battery.the gr-8 battery management system power supply mode
Bulletin:
00-001-13-2748
Component:
355200 equipment:other:owners/service/other manual
Summary:
Mazda has developed factory recommended scheduled maintenance services that support all major vehicle systems. mazda recommends dealers follow the scheduled maintenance tables as cited in the vehicle-specific workshop manual or owner's manu
Bulletin:
02-001-13-2752
Component:
350000 equipment
Summary:
Some customers may complain of signs of oil on the struts or shock absorbers. in most cases the oil that is present is normal, and a result of the oil that remains on the shaft during the normal sweeping process of the shaft seal. follow th
Bulletin:
02-004-13-2770
Component:
010000 steering
Summary:
Some customers may complain that the steering wheel is off center more than 3° even when driving straight on a flat road.
Bulletin:
09-005-13-2781
Component:
350000 equipment
Summary:
This service bulletin provides information regarding the proper use of the driver's floor mat to avoid any poten-tial interference with the foot pedals. the following are possible causes of floor mat interference, which can be avoided with
Bulletin:
00-001-13-2748A
Component:
355200 equipment:other:owners/service/other manual
Summary:
Mazda has developed factory recommended scheduled maintenance services that support all major vehicle systems. mazda recommends dealers follow the scheduled maintenance tables as cited in the vehicle-specific workshop manual or owner's manu
Bulletin:
02-004-13-2770A
Component:
011000 steering:wheel and handle bar
Summary:
Some customers may complain that the steering wheel is off center more than 3° even when driving straight on a flat road.
Bulletin:
09-018-13-2803
Component:
355200 equipment:other:owners/service/other manual
Summary:
Some customers may complain that the ambient temperature display is not accurate, or it takes too long for the display to show actual temperature. when you encounter a customer with this concern, first verify the condition when the customer
Bulletin:
02-004-13-2770B
Component:
011000 steering:wheel and handle bar
Summary:
Some customers may complain that the steering wheel is off center more than 3° even when driving straight on a flat road.
Bulletin:
09-028-12-2701B
Component:
355200 equipment:other:owners/service/other manual
Summary:
The multi information display (mid) and navigation system support for diagnostics, parts authorization, and parts exchange require contacting the proper source. please contact the appropriate source by referring to the following tables.
Bulletin:
09-046-12-2744
Component:
120000 lighting (pws)
Summary:
Some customers may complain of condensation/fog inside the front or rear combination lights. the recent new models have been fitted with a clear lens which can cause the symptom to be more noticeable, however, it does not affect the perform
Bulletin:
00-004-12-2741
Component:
355200 equipment:other:owners/service/other manual
Summary:
Mazda has developed factory recommended scheduled maintenance services that support all major vehicle systems. mazda recommends dealers follow the scheduled maintenance tables as cited in the vehicle-specific workshop manual or owner's manu
Bulletin:
09-039-13-2852
Component:
220000 seats
Summary:
Some vehicles may exhibit a chattering noise and the driver-side seat lift cannot be adjusted because the lock plate guide comes off the guide cam when operating the lift. if the lift lever is then operated with the lock plate guide off, th
Bulletin:
09-007-14-2878
Component:
122000 exterior lighting:fog lights
Summary:
Some customers may complain of condensation/fog inside the front or rear combination lights. the recent new models have been fitted with a clear lens which can cause the symptom to be more noticeable, however, it does not affect the perform
Bulletin:
04-002-14-2879
Component:
046400 service brakes, air:antilock:abs warning light
Summary:
Some customers may report a slight clunk/bang/buzz noise or jolt from the front of the vehicle. this concern will most likely occur during the vehicles first forward movement after starting the engine. this is a normal operating noise of th
Bulletin:
04-004-14-2926
Component:
030000 brakes (pws)
Summary:
Some vehicles exhibit brake related concerns such as brake noise, brake judder or brake dragging. if you encounter a customer complaint for any one of these symptoms, refer to the following information to understand why symptoms may occur,
Bulletin:
09-023-14-2924
Component:
350000 equipment
Summary:
Some customers may complain that the ambient temperature display is not accurate, or it takes too long for the display to show actual temperature.when you encounter a customer with this concern, first verify the condition when the customer
Bulletin:
00-002-14-2936
Component:
350000 equipment
Summary:
Mazda north american operations received many requests from our dealers asking us to approve additional on-car brake lathes as an option for mnao authorized equipment. due to your feedback and after evaluating a few on-car brake lathes, we
Bulletin:
09-027-14-2935
Component:
356000 equipment adaptive
Summary:
This service bulletin provides information regarding the proper use of the driver's floor mat to avoid any potential interference with the foot pedals. the following are possible causes of floor mat interference, which can be avoided with p
Bulletin:
09-034-14-2956
Component:
356000 equipment adaptive
Summary:
In accordance with federal regulations, follow the procedure listed below when replacing a speedometer.note:'mazda vehicles are manufactured with tamper-proof speedometers.'when a speedometer is replaced, the new speedometer will read zero
Bulletin:
02-004-14-2976
Component:
011000 steering:wheel and handle bar
Summary:
Some customers may complain that the steering wheel is off center more than 3° even when driving straight on a flat road. follow steering wheel alignment procedure.
Bulletin:
01-003-15-3014
Component:
350000 equipment
Summary:
Use the following repair procedure to minimize the need to replace the catalyst converter/exhaust pipe when removing oxygen sensors and/or air fuel ratio sensors.
Bulletin:
09-003-16-3130
Component:
121000 exterior lighting:headlights
Summary:
Some customers may complain of condensation/fog inside the front (headlamp/headlight) or rear (taillamp/tail-light) combination lights. the recent new models have been fitted with a clear lens which can cause the symp-tom to be more noticea
Bulletin:
02-009-16-3155
Component:
011000 steering:wheel and handle bar
Summary:
Some customers may complain that the steering wheel is off center more than 3° even when driving straight on a flat road.
Bulletin:
09-030-15-3073
Component:
355200 equipment:other:owners/service/other manual
Summary:
Mazda infotainment systems require contacting the proper source for diagnostic support, parts authorization, and parts exchange. some components require prior authorization before ordering as exchange. refer to dag exchange central (mxconn
Bulletin:
02-002-16-3124
Component:
200000 wheels
Summary:
Some automotive cleaning products contain strong acid or alkali. when these types of cleaners are used to clean the wheels on mazda vehicles, the chemicals contents penetrate the clear coating of the wheel surface and damage the paint under
Bulletin:
04-004-16-3160
Component:
030000 brakes (pws)
Summary:
Some vehicles exhibit brake related concerns such as brake noise, brake judder or brake dragging. if you encounter a customer complaint for any one of these symptoms, refer to the following information to understand why symptoms may occur,
Bulletin:
08-001-13-2859
Component:
110000 electrical system
Summary:
This information is provided to help address passenger airbag deactivation (pad) indicator illumination con-cerns during vehicle service.
Bulletin:
02-009-13-2854
Component:
200000 wheels
Summary:
Some automotive cleaning products contain strong acid or alkali. when these types of cleaners are used to clean the wheels on mazda vehicles, the chemicals contents penetrate the clear coating of the wheel surface and damage the paint under
Bulletin:
04-004-13-2853
Component:
030000 brakes (pws)
Summary:
Some vehicles exhibit brake related concerns such as brake noise, brake judder or brake dragging. if you encounter a customer complaint for any one of these symptoms, refer to the following information to understand why symptoms may occur,
Bulletin:
09-008-17-3324
Component:
121000 exterior lighting:headlights
Summary:
Take caution when cleaning plastic headlight lenses. damage can occur when using some cleaners that contain strong acid, alkaline cleanser or organic solvent. damage caused by using these cleaners is not covered by mazda's new vehicle limit
Bulletin:
SA-061-17
Component:
117000 digital instrument panel
Summary:
In an effort to achieve a higher level of customer experience and retain the value of mazda's vehicles, mnao warranty operations is© 2017 mazda north american operations, u.s.a. allowing all mazda dealers to utilize a third party, specmo en
Bulletin:
09018173351
Component:
117000 digital instrument panel
Summary:
Some customers may complain that the ambient temperature display is not accurate, or it takes too long for the display to show actual temperature. when you encounter a customer with this concern, first verify the condition when the customer
Bulletin:
09-035-17-3080
Component:
117000 digital instrument panel
Summary:
In accordance with federal regulations, follow the procedure listed below when replacing a speedometer. note: tampering with a motor vehicle odometer is strictly prohibited by federal, and state laws. it is the dealer?s responsibility to co
Bulletin:
SA-068-17
Component:
140000 air bags
Summary:
Stopper plates for air bag module connectors have been established as new service parts. when removing the connector (1) to the air bag module (2), make sure to first lift the stopper plate (3) carefully using a flathead screwdriver (but do
Bulletin:
08-003-17-3345
Component:
141200 air bags:frontal:driver side inflator module
Summary:
Mazda motor corporation is going to evaluate the following inflators to ensure the safety of the inflator with a desiccant. in order to do this, mnao is collecting inflators for evaluation in certain zones. for 2003-2008 mazda6 (including m
Bulletin:
00-001-18-3446
Component:
350000 equipment
Summary:
Mazda has developed factory recommended scheduled maintenance services that support all major vehicle systems. mazda recommends dealers follow the scheduled maintenance tables as cited in the vehicle-specific workshop manual or owner's manu
Bulletin:
09-011-18-3448
Component:
121000 exterior lighting:headlights
Summary:
Some customers may complain of condensation/fog inside the front (headlamp/headlight) or rear (taillamp/taillight) combination lights. the recent new models have been fitted with a clear lens which can cause the symptom to be more noticeabl
Bulletin:
09-014-18-3443
Component:
160000 structure
Summary:
When encountering a vehicle with paint damage, refer to the "mazda pocket paint guide" to determine cause, prevention, remedy, and warranty coverage (if applicable).
Bulletin:
09-019-18-3450
Component:
356000 equipment adaptive
Summary:
This service bulletin provides information regarding the proper use of the driver's floor mat to avoid any potential interference with the foot pedals. the following are possible causes of floor mat interference, which can be avoided with p
Bulletin:
MT-003-18
Component:
140000 air bags
Summary:
The workshop manual has two-different airbag procedures, one for standard deployment and one for two-step deployment. standard deployment is for mexico spec vehicles and two-step deployment is for us and canadian spec vehicles.
Bulletin:
01-008-18-3451
Component:
111000 electrical system:battery
Summary:
This service bulletin provides testing and charging procedures in order to promote proper battery maintenance, to deliver new vehicles with fully charged batteries, and to reduce unnecessary battery replacement cost. for new vehicles in sto
Bulletin:
01-009-18-3452
Component:
111000 electrical system:battery
Summary:
The mazda gr8-1291 is required for all warranty battery testing. if the mazda gr8-1291 is not used, incorrect battery testing may result in unnecessary battery replacement. use the following test procedures in this service bulletin to test
Bulletin:
02-006-18-3449
Component:
021300 suspension:front:shock absorber
Summary:
Some customers may complain of signs of oil on the struts or shock absorbers. in most cases the oil that is present is normal, and a result of the oil that remains on the shaft during the normal sweeping process of the shaft seal. follow th
Bulletin:
02-008-18-3467
Component:
200000 wheels
Summary:
Some automotive cleaning products contain strong acid or alkali. when these types of cleaners are used to clean the wheels on mazda vehicles, the chemicals contents penetrate the clear coating of the wheel surface and damage the paint under
Bulletin:
04-003-18-3455
Component:
060000 engine and engine cooling
Summary:
Some customers may report a slight clunk/bang/buzz noise or jolt from the front of the vehicle. this concern will most likely occur during the vehicles first forward movement after starting the engine. this is a normal operating noise of th
Bulletin:
04-004-18-3468
Component:
030000 brakes (pws)
Summary:
Some vehicles exhibit brake related concerns such as brake noise, brake judder or brake dragging. if you encounter a customer complaint for any one of these symptoms, refer to the following information to understand why symptoms may occur,
Bulletin:
00-003-18-3480
Component:
030000 brakes (pws)
Summary:
Mazda north american operations has approved an additional on-car brake lathe as an option for mnaoauthorized equipment. the pro-cut on-car brake lathe has been added to the mnao authorizedequipment program.note: accu-turn is still an appro
Bulletin:
02-010-18-3477
Component:
011000 steering:wheel and handle bar
Summary:
Some customers may complain that the steering wheel is off center more than 3° even when driving straight on a flat road.
Bulletin:
09-025-18-3479
Component:
350000 equipment
Summary:
Mazda infotainment systems require contacting the proper source for diagnostic support, parts authorization, and parts exchange. some components require prior authorization before ordering as exchange. refer to dag exchange central (mxconne
Bulletin:
09-034-18-3430
Component:
180000 vehicle speed control
Summary:
In accordance with federal regulations, follow the procedure listed below when replacing a speedometer. note: tampering with a motor vehicle odometer is strictly prohibited by federal, and state laws. it is the dealer's responsibility to co
Bulletin:
01-016-18-3522
Component:
063000 engine and engine cooling:exhaust system
Summary:
On some vehicles, a sulfur smell or 'rotten egg' odor may be noticed coming from the exhaust system. the odor is usually noticed after a cold start, fast idle, extended periods of idling and full throttle acceleration. sulfur smell is not a

Home | Privacy