2004 MAZDA MAZDA3 Recalls (2)

Campaign:
04V468000 on 09/23/2004
Component:
Air bags:frontal:sensor/control module
Manufactured:
06/23/2003 - 03/21/2004
Affected:
42,000
Defect:
On certain passenger vehicles, a crack in the air bag crash zone sensor housing can allow water to enter the sensor, causing a short circuit and illuminating the air bag warning light.
Consequence:
If this problem exists, the air will not deploy as designed in certain types of frontal crashes, increasing the risk of death or serious injury to the driver and front seat passenger.
Correction:
Dealers will inspect the crash zone sensor and replace it, if necessary. the recall began on october 28, 2004. owners should contact mazda at 1-800-222-5500.
Notes:
Mazda recall no.2304j.customers can also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
Campaign:
09E011000 on 04/02/2009
Component:
Equipment
Affected:
2,323
Defect:
Thule, inc. is recalling 2,323 owner-installed roof-mounted fit kits, models 3068 and 3069, manufactured between january 1, 2008 and february 28, 2009 that are used with thule podium foot packs, models 460 and 460r. these fit kits were sold as aftermarket equipment for use on the vehicles listed above. the bolt(s) used to secure the foot to the vehicle was manufactured to a hardness that may cause the bolt(s) to be brittle and potentially break under stress.
Consequence:
This may result in the bolt(s) snapping off during use or without a load. the unsecured rack and load can then come loose while driving creating a potential road hazard, possibly resulting in a vehicle crash.
Correction:
Thule will mail a retro fit kit along with repair instructions to owners free of charge. the safety recall is expected to begin on or before april 13, 2009. owners may contact thule toll-free at 1-800-238-2388.
Notes:
This recall only pertains to thule aftermarket roof mounted load carriers and has no relation to any original equipment installed on the listed passenger vehicles.owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to <a href=http://www.safercar.gov>http://www.safercar.gov</a> .

2004 MAZDA MAZDA3 TSBs (161)

Bulletin:
0100303
Component:
061000 engine and engine cooling:engine
Summary:
Front crankshaft bolt service warning. *tt
Bulletin:
0100803
Component:
061000 engine and engine cooling:engine
Summary:
Oil filter cartridge removal. *tt engine oil filter cartridge housing cover damage. *tt
Bulletin:
0200203
Component:
199000 tires:pressure monitoring and regulating systems
Summary:
Tire pressure monitoring system (tpms) warning lamp illuminated and a warning buzzer no diagnostic trouble code (dtc)-service tips. *mn *tt
Bulletin:
00403
Component:
350000 equipment
Summary:
Special tool shipment decemeber 2003 (sst). (2004 mazda3).*mr
Bulletin:
00104
Component:
980000 unknown or other
Summary:
Special tool shipment march 2004 (sst).*mr
Bulletin:
0100804
Component:
110000 electrical system
Summary:
Malfunction indicator lamp (mil) with dtc p0128. *mr
Bulletin:
0400104
Component:
030000 service brakes, hydraulic
Summary:
Front brake squeak when cold. *mr
Bulletin:
00204
Component:
063100 engine and engine cooling:exhaust system:emission control
Summary:
Evaporative emissions cap and receiver adapters for testing the vehicles evaporative emissions system are now available. *tt
Bulletin:
0901504
Component:
162000 structure:body
Summary:
Paint stains may be present on the hood, roof, and/or trunk after removal of rapgard material. *tt *mj
Bulletin:
032204
Component:
980000 unknown or other
Summary:
Dealer notice - service bulletin release. mazda. *tt
Bulletin:
032404
Component:
980000 unknown or other
Summary:
Dealer notice - service bulletin release (03/24/04). mazda *tt
Bulletin:
0901804
Component:
022000 suspension:rear
Summary:
Scraping noise bumps from right wheel. *mj
Bulletin:
0400304
Component:
030000 service brakes, hydraulic
Summary:
Squeak noise from rear brakes. *tt
Bulletin:
0101505
Component:
061000 engine and engine cooling:engine
Summary:
Front crankshaft bolt service warning. *mj including 2005 mazda b2300 and 2005 mazda6. (update) *sc
Bulletin:
418
Component:
350000 equipment
Summary:
A center stand assembly with the crash zone sensor pre-mounted is now available. *tt
Bulletin:
01012004
Component:
061000 engine and engine cooling:engine
Summary:
Engine no crank along with immobilizer malfunction. diagnostic trouble codes p1260 (immobilizer system problem) and b1600/b1602 (key id number cannot be read) and/or u2516 (ic-can bus off transmit error) may be stored in memory. mazda m-
Bulletin:
01012004
Component:
353000 equipment:electrical
Summary:
Unable to program homelink. mazda m-tips. *tt
Bulletin:
01012004
Component:
115000 electrical system:fuses and circuit breakers
Summary:
Room fuse location. mazda m-tips. *tt
Bulletin:
01012004
Component:
061000 engine and engine cooling:engine
Summary:
Splash shield hole. mazda m-tips. *tt
Bulletin:
01012004
Component:
110000 electrical system
Summary:
Malfunction indicator lamp on with diagnostic trouble codes p0442/p0455. mazda m-tips. *tt
Bulletin:
01012004
Component:
353600 equipment:air conditioner
Summary:
Air conditioner belt removal/installation. mazda m-tips. *tt
Bulletin:
01012004
Component:
061000 engine and engine cooling:engine
Summary:
Engine hard start/long crank. mazda m-tips. *tt
Bulletin:
01012004
Component:
350000 equipment
Summary:
Can't program keyless entry transmitter. mazda m-tips. *tt
Bulletin:
01012004
Component:
353000 equipment:electrical
Summary:
Antenna missing at predelivery inspection. mazda m-tips. *tt
Bulletin:
01012004
Component:
110000 electrical system
Summary:
Module configuration. mazda m-tips. *tt
Bulletin:
0902604
Component:
353000 equipment:electrical
Summary:
Speedometer replacement procedure. *tt
Bulletin:
0102504
Component:
111000 electrical system:battery
Summary:
Battery test procedure requirements. *tt
Bulletin:
0600204
Component:
015000 steering:hydraulic power assist system
Summary:
Abnormal whine noise of steering system. *tt
Bulletin:
0903004
Component:
136000 visibility:windshield wiper/washer
Summary:
Front wipers do not wipe well. *tt
Bulletin:
0903104
Component:
162300 structure:body:door
Summary:
Loose door trim screw cap. *tt
Bulletin:
08062004
Component:
980000 unknown or other
Summary:
Dealer notice - service bulletin release 8/6/2004. *tt
Bulletin:
0102804
Component:
061000 engine and engine cooling:engine
Summary:
Mazda special program (msp05) - o2 sensor diagnostic trouble code error, p2195/p2196. *tt
Bulletin:
0102904
Component:
072000 fuel system, gasoline:delivery
Summary:
Fuel delivery module (fdm) installation. *tt
Bulletin:
08182004
Component:
980000 unknown or other
Summary:
Dealer notice - service bulletin release - 08/18/2004. *tt
Bulletin:
0903204
Component:
133000 visibility:power window devices and controls
Summary:
Power window inoperative. *tt
Bulletin:
08262004
Component:
980000 unknown or other
Summary:
Dealer notice - service bulletin release - 08/26/2004. *tt
Bulletin:
0103604
Component:
110000 electrical system
Summary:
Mlafunction indicator lamp illumination, p0442 / p0455 / p0456. *tt
Bulletin:
0700504
Component:
353600 equipment:air conditioner
Summary:
A/c poor performance. *tt
Bulletin:
0903704
Component:
171100 latches/locks/linkages:doors:latch
Summary:
Driver door lock inoperative/ room light stays on. *eh
Bulletin:
00204
Component:
063100 engine and engine cooling:exhaust system:emission control
Summary:
Evaporative emmissions and reciver adapters. *eh
Bulletin:
06012004
Component:
353500 equipment:electrical:navigational system(global positioning system)
Summary:
Navigation system voice guidance. *jb
Bulletin:
06012004
Component:
103100 power train:automatic transmission:control module (tcm, pcm)
Summary:
Programmable module installation. ( 2004 mazda b series) *jb
Bulletin:
0400105
Component:
030000 service brakes, hydraulic
Summary:
Front brake squeak when cold. *mr
Bulletin:
0400305
Component:
030000 service brakes, hydraulic
Summary:
Brake squeak / grind noise from rear brakes. *tt
Bulletin:
0901205
Component:
133000 visibility:power window devices and controls
Summary:
One-touch power window stops halfway. *tt
Bulletin:
0200205
Component:
021000 suspension:front
Summary:
Front shock absorber noise. *tt
Bulletin:
0400205
Component:
030000 service brakes, hydraulic
Summary:
Brake rotor grooved. *tt
Bulletin:
0104104
Component:
060000 engine and engine cooling
Summary:
Engine hard start (cranks but takes 10 seconds or longer to start). *tt
Bulletin:
03012005
Component:
185000 vehicle speed control:cruise control
Summary:
Cruise control surge.mazda repair information. *tt
Bulletin:
03012005
Component:
106000 power train:axle assembly
Summary:
Front axle clicking noise. mazda repair information. *tt
Bulletin:
03012005
Component:
110000 electrical system
Summary:
Malfunction indicator lamp (mil) o with p2177 / p2187 set. mazda repair information. *tt
Bulletin:
0300305
Component:
105300 power train:driveline:driveshaft
Summary:
Drive shaft click noise. *sc
Bulletin:
0102105
Component:
060000 engine and engine cooling
Summary:
Engine vibration/ knocking noise/ no. 3 engine mount rubber broken. *sc updated on 09/25/07. *nj
Bulletin:
0101505
Component:
060000 engine and engine cooling
Summary:
Front crankshaft bolt service warning. *sc
Bulletin:
0100305
Component:
061110 engine and engine cooling:engine:gasoline:belts and associated pulleys
Summary:
Drive belt pulley breakage / charging warning light on / overheating. *tt
Bulletin:
01012005
Component:
100000 power train
Summary:
Wds transmission id. *tt
Bulletin:
090104
Component:
137000 visibility:rear window wiper/washer
Summary:
Front wipers inoperable. loose nut. *jb
Bulletin:
11012005
Component:
060000 engine and engine cooling
Summary:
2.0l (lf) engine differences. *tt
Bulletin:
0501005
Component:
103000 power train:automatic transmission
Summary:
1 - 2 shift shock. *tt
Bulletin:
0200505
Component:
020000 suspension
Summary:
Rubbing noise when turning steering wheel. *tt
Bulletin:
01012006
Component:
353000 equipment:electrical
Summary:
Key reminder chimes continuously / keyless entry inoperative. *tt
Bulletin:
0300106
Component:
162000 structure:body
Summary:
Body vibration at cruise speed. *tt
Bulletin:
0100206
Component:
060000 engine and engine cooling
Summary:
Engine misfire diagnostic procedures - service tip. *tt
Bulletin:
0100506
Component:
063100 engine and engine cooling:exhaust system:emission control
Summary:
Dtc p2407 after evap test performed. *tt
Bulletin:
0100606
Component:
110000 electrical system
Summary:
Mil illumination with dtc p0172 p2178 / p2188 stored in pcm memory. *tt
Bulletin:
0100806
Component:
185000 vehicle speed control:cruise control
Summary:
2.0l mt-fed /can only - cruise surge. *ak
Bulletin:
0100706
Component:
113200 electrical system:starter assembly:relay
Summary:
No start due to frozen main relay. *tt
Bulletin:
03012006
Component:
075000 fuel system, gasoline:carburetor system
Summary:
Vehicles may experience the following:the air cleaner box may be inappropriate for the vehicle.*ak
Bulletin:
03012006
Component:
015000 steering:hydraulic power assist system
Summary:
Intermittent hard to steer. *ak
Bulletin:
0200406
Component:
194000 tires:valve
Summary:
Tpms valve stem breaks when removing aftermarket valve stem caps - service tip. *tt
Bulletin:
0902505
Component:
110000 electrical system
Summary:
Passenger junction box (pjb) diagnostic tips. *tt
Bulletin:
0902206
Component:
136300 visibility:windshield wiper/washer:linkages
Summary:
Unusual noise from front wiper link. *tt
Bulletin:
0103306
Component:
061000 engine and engine cooling:engine
Summary:
Engine rpm drops/engine stalls. *tt
Bulletin:
0104406
Component:
117000 digital instrument panel
Summary:
Malfunction indicator light on with dtc p0106. *kb
Bulletin:
0800306
Component:
140000 air bags
Summary:
Non genuine accessories affect air bag operation. *kb
Bulletin:
0400107
Component:
046400 service brakes, air:antilock:abs warning light
Summary:
Abs warning light on with dtc c1141, c1142, c1233, or c1234/grinding noise from the front wheels. *kb
Bulletin:
0800107
Component:
140000 air bags
Summary:
Airbag warning light comes on with code b1877/b1881. *kb
Bulletin:
00307
Component:
980000 unknown or other
Summary:
Availability of non-required tools. *kb
Bulletin:
0102207
Component:
061000 engine and engine cooling:engine
Summary:
Engine stalls when driving at low speeds. *kb
Bulletin:
0102206
Component:
021000 suspension:front
Summary:
Front crankshaft bolt service warning. *nj
Bulletin:
06-003/08
Component:
015300 steering:hydraulic power assist:power steering fluid
Summary:
Heavy steering effort/power steering fluid leakage. some mazda3 vehicles (except mazdaspeed3) with vin's lower than jm1bk**** **709745 (produced before feb. 1, 2007) & some mazda5 vehicles with vin's lower than jm1cr**** **150635 (produce
Bulletin:
01-003/08
Component:
103100 power train:automatic transmission:control module (tcm, pcm)
Summary:
Multi-model - engine stalls when driving at low speed. *nj
Bulletin:
01-024/08
Component:
061000 engine and engine cooling:engine
Summary:
Mil comes on with dtc p2006 / variable tumble shutter valve can not completely close. *nj
Bulletin:
01-003-08
Component:
061000 engine and engine cooling:engine
Summary:
Mazda: engine stalls when driving at low speed. *pe
Bulletin:
SB-01-007-09
Component:
061000 engine and engine cooling:engine
Summary:
Mazda: vehicles may exhibit a concern of unstable idling or, in some rare cases, stalling, just after the vehicle stops with no dtcs detected. problem is due to the accumulation of carbon deposits inside the throttle body causing air flow
Bulletin:
SB-01-012-09
Component:
061000 engine and engine cooling:engine
Summary:
Mazda: mil comes on with p2004/check valve stuck open. some vehicles may experience an mil that comes on with dtc p2004 (variable tumble shutter valve stuck open). the cause may be the check valve in the intake manifold vacuum chamber being
Bulletin:
SB-01-023-10
Component:
071110 fuel system, gasoline:storage:tank assembly:filler pipe and cap
Summary:
Mazda: determining evaporative system leak location for dtcs p0441, p0442, p0455, p0455. some vehicles may have a mil illumination with dtcs stored in memory. *pe updated 4/18/11. *pe
Bulletin:
SB-06-003-10
Component:
012000 steering:column
Summary:
Mazda: steering column slightly moves in or out telescopically. some vehicles may exhibit a slight in or out movement of the steering wheel when it is pushed or pulled, even with the steering wheel release lever properly locked. *pe
Bulletin:
SB-01-028-10
Component:
061000 engine and engine cooling:engine
Summary:
Mazda: variable valve timing (vvt) noise when starting engine. when engine is first started, some vehicles may exhibit a loud ticking noise from the variable valve timing (vvt) (a). this is caused by the lock pin of the variable valve tim
Bulletin:
SB-09-057-10
Component:
120000 exterior lighting
Summary:
Mazda: there is condensation and fog in the front and rear combination lights. *rm
Bulletin:
01-006-11
Component:
060000 engine and engine cooling
Summary:
Mazda: a malfunction light is on with a stored trouble code. *rm
Bulletin:
MD-04-10
Component:
147000 air bags: alleged counterfeit air bag
Summary:
Mazda: information regarding the installation of counterfeit air bags, if installed by independent shop, or is oem from factory or dealer installed and to contact dealers or manufacturer if concern or unsure of air bags in vehicles. model
Bulletin:
MDE-2004
Component:
147000 air bags: alleged counterfeit air bag
Summary:
Mazda: see document search button for owner letter. information provided regarding the selling and importing of counterfeit airbags manufactured in china, installing in some vehicles. models 2004, 2010-2012 mazda3. *pe
Bulletin:
SB-2010
Component:
147000 air bags: alleged counterfeit air bag
Summary:
Mazda: see document search button for owner letter. information regarding importing and selling of counterfeit airbags manufactured in china and some 2004, 2010-2012 mazda3 vehicles may have them installed. *pe
Bulletin:
SB-09-005-13
Component:
350000 equipment
Summary:
Mazda: on some vehicles, to avoid potential interference of foot placed on pedals, information is provided regarding proper use, and placement, of driver's floor mat. various models and model years. *pe
Bulletin:
SB-08-001-13
Component:
141000 air bags:frontal
Summary:
Mazda: information provided regarding the indicator light illumination of the passenger airbag deactivation (pad). *pe
Bulletin:
02-004-14
Component:
011000 steering:wheel and handle bar
Summary:
Summary to be provided on a future date.
Bulletin:
00-004/12
Component:
060000 engine (pws)
Summary:
Summary to be provided on a future date.
Bulletin:
09-043-12
Component:
220000 seats
Summary:
Summary to be provided on a future date.
Bulletin:
RF-11-12R
Component:
116000 electrical system:ignition
Summary:
Summary to be provided on a future date.
Bulletin:
SA234
Component:
118000 electrical system: software
Summary:
Ids update 101.00 and 101.02 is now available on ms3 under the "ids/infotainment" tab.
Bulletin:
02-009-16-3155
Component:
010000 steering
Summary:
Some customers may complain that the steering wheel is off center more than 3° even when driving straight on a flat road.
Bulletin:
00-004-16-3237
Component:
350000 equipment
Summary:
Raising a vehicle with a jack can be dangerous if not done properly. the vehicle can slip off the jack and seri-ously injure someone. in this service information, some important warnings and cautions have been taken from the owner's manual.
Bulletin:
01-016-16-3220
Component:
060000 engine (pws)
Summary:
There is a concern that some water pumps are being replaced that are not faulty, due to signs of a very small coolant leak from the bleed hole. this service bulletin is to inform you about the water pump sealing mecha-nism and the criteria
Bulletin:
00-001-13-2748
Component:
355200 equipment:other:owners/service/other manual
Summary:
Mazda has developed factory recommended scheduled maintenance services that support all major vehicle systems. mazda recommends dealers follow the scheduled maintenance tables as cited in the vehicle-specific workshop manual or owner's manu
Bulletin:
02-001-13-2752
Component:
350000 equipment
Summary:
Some customers may complain of signs of oil on the struts or shock absorbers. in most cases the oil that is present is normal, and a result of the oil that remains on the shaft during the normal sweeping process of the shaft seal. follow th
Bulletin:
02-004-13-2770
Component:
010000 steering
Summary:
Some customers may complain that the steering wheel is off center more than 3° even when driving straight on a flat road.
Bulletin:
09-005-13-2781
Component:
350000 equipment
Summary:
This service bulletin provides information regarding the proper use of the driver's floor mat to avoid any poten-tial interference with the foot pedals. the following are possible causes of floor mat interference, which can be avoided with
Bulletin:
05-002-13-2777A
Component:
102400 power train:manual transmission:lubricant
Summary:
Always be sure to use the correct automatic transmission fluid when replacing atf. using the wrong atf may cause shift quality complaints or may even damage the transmission.note:'atf m-v (type m5) is not the same fluid as mercon®v or merco
Bulletin:
05-002-13-2777
Component:
102400 power train:manual transmission:lubricant
Summary:
Always be sure to use the correct automatic transmission fluid when replacing atf. using the wrong atf may cause shift quality complaints or may even damage the transmission.note:'atf m-v (type m5) is not the same fluid as mercon®v or merco
Bulletin:
00-001-13-2748A
Component:
355200 equipment:other:owners/service/other manual
Summary:
Mazda has developed factory recommended scheduled maintenance services that support all major vehicle systems. mazda recommends dealers follow the scheduled maintenance tables as cited in the vehicle-specific workshop manual or owner's manu
Bulletin:
02-004-13-2770A
Component:
011000 steering:wheel and handle bar
Summary:
Some customers may complain that the steering wheel is off center more than 3° even when driving straight on a flat road.
Bulletin:
09-018-13-2803
Component:
355200 equipment:other:owners/service/other manual
Summary:
Some customers may complain that the ambient temperature display is not accurate, or it takes too long for the display to show actual temperature. when you encounter a customer with this concern, first verify the condition when the customer
Bulletin:
02-004-13-2770B
Component:
011000 steering:wheel and handle bar
Summary:
Some customers may complain that the steering wheel is off center more than 3° even when driving straight on a flat road.
Bulletin:
09-028-12-2701B
Component:
355200 equipment:other:owners/service/other manual
Summary:
The multi information display (mid) and navigation system support for diagnostics, parts authorization, and parts exchange require contacting the proper source. please contact the appropriate source by referring to the following tables.
Bulletin:
07-002-13-2842
Component:
353600 equipment:air conditioner
Summary:
A musty/mildew type odor may come from the vents when the air conditioning (a/c) system is operating. it is most noticeable when the a/c is first turned on. this odor is the result of mold growth in the a/c evaporator/cooling unit which is
Bulletin:
09-043-12-2676A
Component:
220000 seats
Summary:
Some customer's may complain about a rattle noise in the driver's seat (a) when stopping or starting the vehicle. this rattle noise is caused by a gap between the seat frame and the link bracket. to correct the problem, a bracket and seat s
Bulletin:
09-046-12-2744
Component:
120000 lighting (pws)
Summary:
Some customers may complain of condensation/fog inside the front or rear combination lights. the recent new models have been fitted with a clear lens which can cause the symptom to be more noticeable, however, it does not affect the perform
Bulletin:
00-004-12-2741
Component:
355200 equipment:other:owners/service/other manual
Summary:
Mazda has developed factory recommended scheduled maintenance services that support all major vehicle systems. mazda recommends dealers follow the scheduled maintenance tables as cited in the vehicle-specific workshop manual or owner's manu
Bulletin:
09-039-13-2852
Component:
220000 seats
Summary:
Some vehicles may exhibit a chattering noise and the driver-side seat lift cannot be adjusted because the lock plate guide comes off the guide cam when operating the lift. if the lift lever is then operated with the lock plate guide off, th
Bulletin:
09-007-14-2878
Component:
122000 exterior lighting:fog lights
Summary:
Some customers may complain of condensation/fog inside the front or rear combination lights. the recent new models have been fitted with a clear lens which can cause the symptom to be more noticeable, however, it does not affect the perform
Bulletin:
04-004-14-2926
Component:
030000 brakes (pws)
Summary:
Some vehicles exhibit brake related concerns such as brake noise, brake judder or brake dragging. if you encounter a customer complaint for any one of these symptoms, refer to the following information to understand why symptoms may occur,
Bulletin:
09-023-14-2924
Component:
350000 equipment
Summary:
Some customers may complain that the ambient temperature display is not accurate, or it takes too long for the display to show actual temperature.when you encounter a customer with this concern, first verify the condition when the customer
Bulletin:
00-002-14-2936
Component:
350000 equipment
Summary:
Mazda north american operations received many requests from our dealers asking us to approve additional on-car brake lathes as an option for mnao authorized equipment. due to your feedback and after evaluating a few on-car brake lathes, we
Bulletin:
09-027-14-2935
Component:
356000 equipment adaptive
Summary:
This service bulletin provides information regarding the proper use of the driver's floor mat to avoid any potential interference with the foot pedals. the following are possible causes of floor mat interference, which can be avoided with p
Bulletin:
09-034-14-2956
Component:
356000 equipment adaptive
Summary:
In accordance with federal regulations, follow the procedure listed below when replacing a speedometer.note:'mazda vehicles are manufactured with tamper-proof speedometers.'when a speedometer is replaced, the new speedometer will read zero
Bulletin:
02-004-14-2976
Component:
011000 steering:wheel and handle bar
Summary:
Some customers may complain that the steering wheel is off center more than 3° even when driving straight on a flat road. follow steering wheel alignment procedure.
Bulletin:
01-003-15-3014
Component:
350000 equipment
Summary:
Use the following repair procedure to minimize the need to replace the catalyst converter/exhaust pipe when removing oxygen sensors and/or air fuel ratio sensors.
Bulletin:
09-003-16-3130
Component:
121000 exterior lighting:headlights
Summary:
Some customers may complain of condensation/fog inside the front (headlamp/headlight) or rear (taillamp/tail-light) combination lights. the recent new models have been fitted with a clear lens which can cause the symp-tom to be more noticea
Bulletin:
05-001-16-3128
Component:
355200 equipment:other:owners/service/other manual
Summary:
Always be sure to use the correct automatic transmission fluid when replacing atf. using the wrong atf may cause shift quality complaints or may even damage the transmission.note:' atf m-v (type m5) is not the same fluid as mercon®v or merc
Bulletin:
02-009-16-3155
Component:
011000 steering:wheel and handle bar
Summary:
Some customers may complain that the steering wheel is off center more than 3° even when driving straight on a flat road.
Bulletin:
09-030-15-3073
Component:
355200 equipment:other:owners/service/other manual
Summary:
Mazda infotainment systems require contacting the proper source for diagnostic support, parts authorization, and parts exchange. some components require prior authorization before ordering as exchange. refer to dag exchange central (mxconn
Bulletin:
02-002-16-3124
Component:
200000 wheels
Summary:
Some automotive cleaning products contain strong acid or alkali. when these types of cleaners are used to clean the wheels on mazda vehicles, the chemicals contents penetrate the clear coating of the wheel surface and damage the paint under
Bulletin:
04-004-16-3160
Component:
030000 brakes (pws)
Summary:
Some vehicles exhibit brake related concerns such as brake noise, brake judder or brake dragging. if you encounter a customer complaint for any one of these symptoms, refer to the following information to understand why symptoms may occur,
Bulletin:
08-001-13-2859
Component:
110000 electrical system
Summary:
This information is provided to help address passenger airbag deactivation (pad) indicator illumination con-cerns during vehicle service.
Bulletin:
02-009-13-2854
Component:
200000 wheels
Summary:
Some automotive cleaning products contain strong acid or alkali. when these types of cleaners are used to clean the wheels on mazda vehicles, the chemicals contents penetrate the clear coating of the wheel surface and damage the paint under
Bulletin:
04-004-13-2853
Component:
030000 brakes (pws)
Summary:
Some vehicles exhibit brake related concerns such as brake noise, brake judder or brake dragging. if you encounter a customer complaint for any one of these symptoms, refer to the following information to understand why symptoms may occur,
Bulletin:
09-008-17-3324
Component:
121000 exterior lighting:headlights
Summary:
Take caution when cleaning plastic headlight lenses. damage can occur when using some cleaners that contain strong acid, alkaline cleanser or organic solvent. damage caused by using these cleaners is not covered by mazda's new vehicle limit
Bulletin:
SA-061-17
Component:
117000 digital instrument panel
Summary:
In an effort to achieve a higher level of customer experience and retain the value of mazda's vehicles, mnao warranty operations is© 2017 mazda north american operations, u.s.a. allowing all mazda dealers to utilize a third party, specmo en
Bulletin:
MT-013-17
Component:
120000 exterior lighting
Summary:
On some vehicles, the rear combination lamp lens becomes hazy and looks white when the brake or taillight is on. due to heat accumulated by extended brake light (e) usage, the red inner cap (a) is melted (b) and the inner (c) and/or outer (
Bulletin:
09018173351
Component:
117000 digital instrument panel
Summary:
Some customers may complain that the ambient temperature display is not accurate, or it takes too long for the display to show actual temperature. when you encounter a customer with this concern, first verify the condition when the customer
Bulletin:
09-035-17-3080
Component:
117000 digital instrument panel
Summary:
In accordance with federal regulations, follow the procedure listed below when replacing a speedometer. note: tampering with a motor vehicle odometer is strictly prohibited by federal, and state laws. it is the dealer?s responsibility to co
Bulletin:
01-002-18-3417
Component:
110000 electrical system
Summary:
Some vehicles may have a mil illumination with dtc's p0441, p0442, p0455, or p0456 stored in memory. to determine the location of the evaporative system leak, follow the repair procedure below. p0441 - evaporative emission control system in
Bulletin:
00-001-18-3446
Component:
350000 equipment
Summary:
Mazda has developed factory recommended scheduled maintenance services that support all major vehicle systems. mazda recommends dealers follow the scheduled maintenance tables as cited in the vehicle-specific workshop manual or owner's manu
Bulletin:
09-011-18-3448
Component:
121000 exterior lighting:headlights
Summary:
Some customers may complain of condensation/fog inside the front (headlamp/headlight) or rear (taillamp/taillight) combination lights. the recent new models have been fitted with a clear lens which can cause the symptom to be more noticeabl
Bulletin:
09-014-18-3443
Component:
160000 structure
Summary:
When encountering a vehicle with paint damage, refer to the "mazda pocket paint guide" to determine cause, prevention, remedy, and warranty coverage (if applicable).
Bulletin:
09-019-18-3450
Component:
356000 equipment adaptive
Summary:
This service bulletin provides information regarding the proper use of the driver's floor mat to avoid any potential interference with the foot pedals. the following are possible causes of floor mat interference, which can be avoided with p
Bulletin:
MT-003-18
Component:
140000 air bags
Summary:
The workshop manual has two-different airbag procedures, one for standard deployment and one for two-step deployment. standard deployment is for mexico spec vehicles and two-step deployment is for us and canadian spec vehicles.
Bulletin:
01-008-18-3451
Component:
111000 electrical system:battery
Summary:
This service bulletin provides testing and charging procedures in order to promote proper battery maintenance, to deliver new vehicles with fully charged batteries, and to reduce unnecessary battery replacement cost. for new vehicles in sto
Bulletin:
01-009-18-3452
Component:
111000 electrical system:battery
Summary:
The mazda gr8-1291 is required for all warranty battery testing. if the mazda gr8-1291 is not used, incorrect battery testing may result in unnecessary battery replacement. use the following test procedures in this service bulletin to test
Bulletin:
02-006-18-3449
Component:
021300 suspension:front:shock absorber
Summary:
Some customers may complain of signs of oil on the struts or shock absorbers. in most cases the oil that is present is normal, and a result of the oil that remains on the shaft during the normal sweeping process of the shaft seal. follow th
Bulletin:
02-008-18-3467
Component:
200000 wheels
Summary:
Some automotive cleaning products contain strong acid or alkali. when these types of cleaners are used to clean the wheels on mazda vehicles, the chemicals contents penetrate the clear coating of the wheel surface and damage the paint under
Bulletin:
04-004-18-3468
Component:
030000 brakes (pws)
Summary:
Some vehicles exhibit brake related concerns such as brake noise, brake judder or brake dragging. if you encounter a customer complaint for any one of these symptoms, refer to the following information to understand why symptoms may occur,
Bulletin:
05-001-18-3453
Component:
100000 power train
Summary:
Always be sure to use the correct automatic transmission fluid when replacing atf. using the wrong atf may cause shift quality complaints or may even damage the transmission. note: atf m-v (type m5) is not the same fluid as mercon®v or merc
Bulletin:
07-002-18-3432
Component:
353600 equipment:air conditioner
Summary:
A musty/mildew type odor may come from the vents when the air conditioning (a/c) system is operating. it is most noticeable when the a/c is first turned on. this odor is the result of mold growth in the a/cevaporator/cooling unit which is c
Bulletin:
08-001-18-3457
Component:
140000 air bags
Summary:
This information is provided to help address passenger airbag deactivation (pad) indicator illumination concerns during vehicle service.
Bulletin:
00-003-18-3480
Component:
030000 brakes (pws)
Summary:
Mazda north american operations has approved an additional on-car brake lathe as an option for mnaoauthorized equipment. the pro-cut on-car brake lathe has been added to the mnao authorizedequipment program.note: accu-turn is still an appro
Bulletin:
02-010-18-3477
Component:
011000 steering:wheel and handle bar
Summary:
Some customers may complain that the steering wheel is off center more than 3° even when driving straight on a flat road.
Bulletin:
09-025-18-3479
Component:
350000 equipment
Summary:
Mazda infotainment systems require contacting the proper source for diagnostic support, parts authorization, and parts exchange. some components require prior authorization before ordering as exchange. refer to dag exchange central (mxconne
Bulletin:
09-034-18-3430
Component:
180000 vehicle speed control
Summary:
In accordance with federal regulations, follow the procedure listed below when replacing a speedometer. note: tampering with a motor vehicle odometer is strictly prohibited by federal, and state laws. it is the dealer's responsibility to co
Bulletin:
01-016-18-3522
Component:
063000 engine and engine cooling:exhaust system
Summary:
On some vehicles, a sulfur smell or 'rotten egg' odor may be noticed coming from the exhaust system. the odor is usually noticed after a cold start, fast idle, extended periods of idling and full throttle acceleration. sulfur smell is not a

Home | Privacy