2004 JAGUAR XJ Recalls (3)

Campaign:
04V024000 on 01/14/2004
Component:
Power train:automatic transmission
Manufactured:
11/30/2002 - 06/29/2003
Affected:
31,731
Defect:
On certain passenger vehicles equipped with automatic transmissions, with the forward drive gear selected and the vehicle stationary or in a forward motion, the gearbox could potentially select reverse gear, without indication.
Consequence:
This failure could result in a crash.
Correction:
Dealers will reprogram the transmission control module. the recall began on may 1, 2004. owners should contact jaguar at 1-201-818-8500.
Notes:
Jaguar recall no. r513.customers can also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
Campaign:
04V136000 on 03/21/2004
Component:
Air bags:frontal
Manufactured:
10/31/2003 - 01/30/2004
Affected:
1,142
Defect:
On certain passenger vehicles, the passenger air bag trim components have a poor aperture edge.
Consequence:
Should the air bag deploy, it could be cut, causing it to not inflate properly, which increases the risk of injury to the occupant in a crash.
Correction:
Dealers will inspect the passenger air bag aperture and, where necessary, remove any sharp, serrated edges. the recall began on may 14, 2004. owners should contact jaguar at 1-800-452-4827.
Notes:
Jaguar recall no. r719.customers can also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
Campaign:
09V144000 on 04/29/2009
Component:
Service brakes, hydraulic
Manufactured:
01/01/2003 - 01/18/2004
Affected:
14,551
Defect:
Jaguar is recalling 14,551 my 2004 xj vehicles. a potential concern has been identified with the installation of a noise vibration and harshness (nvh) pad fitted to the under tray and its interaction with the rear under floor brake pipes, rear cross member brake pipes, and their unions. a review of vehicle build conditions provides evidence that a touch condition can exist between the under floor and cross member brake pipes and the nvh pad at the rear of the under floor under tray. where the touch condition exists, water and dirt can collect and be held in contact with the pipes and their unions, abrade the corrosion protection and reduce the corrosion life of the pipes accordingly.
Consequence:
Corrosion of the brake pipes can lead to a loss of mechanical integrity of the braking system. this can result in extended brake pedal travel combined with reduced braking performance in the corresponding brake circuit. the instrument cluster may display the warning message 'fluid level low', along with the brake warning lamp being illuminated. in the event of both braking circuits losing integrity at the same time, complete loss of service brakes will occur, thereby potentially causing a vehicle crash.
Correction:
Dealers will remove the under tray at the rear of the vehicle and remove and discard the nvh pad fitted to the rear of the under tray. dealers will inspect the rear under floor and rear cross member brake pipes and unions for red rust. if red rust is present on the pipes or on the union, the brake pipes and union will be replaced with new components of the same design. this service will be performed free of charge. the recall is expected to begin during may 2009. owners may contact jaguar at 1-800-452-4827.
Notes:
Jaguar recall no. j012.owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to <a href=http://www.safercar.gov>http://www.safercar.gov</a> .

2004 JAGUAR XJ TSBs (77)

Bulletin:
50107
Component:
162000 structure:body
Summary:
Entry of water into vehicle possible sources. *eh update. *tt
Bulletin:
303717
Component:
060000 engine and engine cooling
Summary:
Oil cooler pipe interference with cross brace service action s717. *eh
Bulletin:
303511
Component:
060000 engine and engine cooling
Summary:
Oil leak from engine oil drain plug v8 engine service action s511. *eh
Bulletin:
21101
Component:
015000 steering:hydraulic power assist system
Summary:
Squeaking noise power steering system flush system. *eh
Bulletin:
20405
Component:
021000 suspension:front
Summary:
Front air suspension deletion of right side sensor change of vehicle specification. *eh
Bulletin:
41902
Component:
110000 electrical system
Summary:
Telephone inoperative incorrect telematics harness check/repair procedure. *eh
Bulletin:
50108
Component:
114200 electrical system:wiring:interior/under dash
Summary:
Floor console trim seperating not adhering repair. *eh
Bulletin:
41301
Component:
110000 electrical system
Summary:
Front parking aid operating with no obstruction present operating characteristics revised sensor. *eh
Bulletin:
10002
Component:
061110 engine and engine cooling:engine:gasoline:belts and associated pulleys
Summary:
Drive belt noise after cold start supercharger revised drive belt available. *eh
Bulletin:
10003
Component:
060000 engine and engine cooling
Summary:
Buzzing knocking noise start or with ignition on adaptive speed control module repair procedure. *eh
Bulletin:
30302
Component:
060000 engine and engine cooling
Summary:
Malfunction indicator lamp on diagnostic trouble code p0128 stored repair procedure. *eh this bulletin replaces xj30302 dated 06/04. *eh
Bulletin:
41903
Component:
353500 equipment:electrical:navigational system(global positioning system)
Summary:
Navigation system diagnostic procedures. *eh
Bulletin:
41302
Component:
110000 electrical system
Summary:
Multiple warning on instrument cluster poor pin connections - check & repair pins. *eh
Bulletin:
50109
Component:
110000 electrical system
Summary:
Supplemental restraint system flash codes & parameter identification code definitions -diagnostics. *eh amended version. *tt
Bulletin:
30705
Component:
103000 power train:automatic transmission
Summary:
Squeal/squeak noise during acceleration flush and replace zf transmission fluid repair procedure. *eh
Bulletin:
30304
Component:
060000 engine and engine cooling
Summary:
Engine pinging/detonation check long and short term fuel trim reprogram engine control module. *eh
Bulletin:
307513
Component:
103000 power train:automatic transmission
Summary:
Incorrect gear selection zf 6 speed automatic transmission recall action r513. *eh
Bulletin:
501719
Component:
140000 air bags
Summary:
Passenger air bag door trim rough edges of opening recall r719. *eh
Bulletin:
41501
Component:
353400 equipment:electrical:radio/tape deck/cd etc.
Summary:
Loss of audio function or incorrect speaker operation caused by water damage to amplifier/audio components due to water ingress into the left hand side of the luggage compartment. *tt
Bulletin:
50102
Component:
162700 structure:body:trunk lid
Summary:
The luggage compartment lid may freeze to the rear window flip seal in low ambient temperatures. *tt
Bulletin:
20401
Component:
022130 suspension:rear:springs:air suspension system
Summary:
Diagnosing/servicing air suspension. gotec leak detection spray - specified hose cutters. *tt
Bulletin:
50103
Component:
162000 structure:body
Summary:
Side panel trim of the center console separating next to the vertical sewn seam. *tt
Bulletin:
303712
Component:
062300 engine and engine cooling:cooling system:hose
Summary:
The coolant hose from the thermostat housing to the auxiliary coolant pump may have been incorrectly routed in production, potentially causing the hose to touch the supercharger drive belt and wear through. service action s 712. *tt
Bulletin:
30702
Component:
105000 power train:driveline
Summary:
Driveline clunk/knock when changing from reverse to drive, or while downshifting from fifth to fourth or second to first when the vehicle is slowing. *tt this bulletin supersedes xj307-02, dated 06/03. *tt
Bulletin:
20402
Component:
192000 tires:sidewall
Summary:
Permanent high spot marking on tire inboard sidewall - information. *tt
Bulletin:
50104
Component:
110000 electrical system
Summary:
Intermittent sticking of the switch pack in the upper section of the center console. *tt
Bulletin:
20404
Component:
204000 wheels:cap/cover/hub
Summary:
Corrosion prevention - wheels & hubs - grease contact surfaces. *tt
Bulletin:
50105
Component:
221600 seats:front assembly:power adjust
Summary:
Loss of seat memory. *tt
Bulletin:
41904
Component:
111000 electrical system:battery
Summary:
Battery is discharged when the vehicle has been standing for a few days. diagnosis/repair procedure. *tt
Bulletin:
30706
Component:
103000 power train:automatic transmission
Summary:
Harsh transmission shifts - adaptive shift strategy drift - reprogram transmission control module & engine control module. *eh
Bulletin:
1186
Component:
110000 electrical system
Summary:
Using wds to program configure control modules common issues solutions vid block background information. this also includes 2003 xj series. *eh
Bulletin:
303713
Component:
062000 engine and engine cooling:cooling system
Summary:
Coolant reservoir bleed screw - retorque to 3 nm - service action s 713. *tt
Bulletin:
31001
Component:
091200 fuel system, other:storage:fuel gauge system
Summary:
Erratic fuel gauge reading - fuel tank sender - repair procedure. this bulletin supersedes xj310-01, dated 4/04. *tt
Bulletin:
50113
Component:
162000 structure:body
Summary:
Water ingress from the roof opening panel area, staining of the head lining, and possible instrument pack warning light illumination. update. *tt
Bulletin:
30307
Component:
180000 vehicle speed control
Summary:
Rough idle after cold start. *tt
Bulletin:
30308
Component:
180000 vehicle speed control
Summary:
Rough idle, restricted performance and poor/harsh transmission shifts with the possibility of diagnostic trouble codes (dtc) p0174, p0171, p0301 to p0308, p1316 and p1582 stored in the engine control module (ecm)
Bulletin:
41701
Component:
121000 exterior lighting:headlights
Summary:
Headlamp internal condensation - acceptable levels. repair guidelines. *tt
Bulletin:
30309
Component:
061000 engine and engine cooling:engine
Summary:
Engine detonation/pinging during acceleration from steady-state driving - reconfigure ecm. *tt
Bulletin:
20602
Component:
050000 parking brake
Summary:
Premature parking brake pad wear or the brakes binding. electronic park brake (epb) - re-calibration procedure. *tt
Bulletin:
20601
Component:
030000 service brakes, hydraulic
Summary:
Vibration when braking (comeback visits) - bremo brakes - disc/hub optimization procedure. *tt
Bulletin:
30708
Component:
103000 power train:automatic transmission
Summary:
Inability to shift gears - selector lever moves freely through j-gate - repair procedure. *tt
Bulletin:
20406
Component:
021230 suspension:front:springs:air suspension system
Summary:
Air suspension system - diagnosis. *tt updated 2/27/08. *nj
Bulletin:
50116
Component:
221600 seats:front assembly:power adjust
Summary:
Electrical seat judder, noisy/inoperative. *tt
Bulletin:
20603
Component:
034510 service brakes, hydraulic:foundation components:disc:caliper
Summary:
Brake caliper flexible hose - washer now available separately. *tt
Bulletin:
20407
Component:
020000 suspension
Summary:
Vibration felt through steering wheel or seats - wheels/tires - diagnostic procedure. *tt
Bulletin:
10011
Component:
020000 suspension
Summary:
Vibration/shimmy - tire radial force variation - optimizing wheels and tires. *tt
Bulletin:
50115
Component:
136000 visibility:windshield wiper/washer
Summary:
Windshield wipers inoperative or erratic operation - diagnostic information. *tt
Bulletin:
30310
Component:
180000 vehicle speed control
Summary:
Electronic throttle body - cleaning prohibited. *tt
Bulletin:
50119
Component:
162300 structure:body:door
Summary:
Exterior door handle stiff/binding-latch/door handle mechanism-lubricate mechanism. *sc
Bulletin:
41702
Component:
123000 exterior lighting:tail lights
Summary:
Concerns of the tail lamp bezel coming away from the tail lamp. *tt adhesive repair procedure. updated 11/07/07. *nj
Bulletin:
20607
Component:
050000 parking brake
Summary:
Electric parking brake (epb) actuator - dtcs c1784, c1785, c1786, c1799, c1801, c1802, c1803 - diagnostics. *tt
Bulletin:
20608
Component:
034500 service brakes, hydraulic:foundation components:disc
Summary:
Vibration when braking - brembo brakes discs thickness variation - diagnosis/repair. *tt
Bulletin:
21101
Component:
015000 steering:hydraulic power assist system
Summary:
Squeaking noise power steering system-repair procedure. *ak
Bulletin:
00010
Component:
192000 tires:sidewall
Summary:
Permanent high spot marking to tire inboard sidewall. *kb
Bulletin:
S-527
Component:
342000 communications:back up alarm
Summary:
Jaguar: key fob remote corrective modification. the remote control key fob fails to operate leading to customers using the mechanical key blade to lock/unlock the vehicle, and to turn off the alarm. csc letter was received. *pe
Bulletin:
TSB-J004
Component:
063100 engine and engine cooling:exhaust system:emission control
Summary:
Jaguar: non compliance issues relating to on board diagnostic (obd) system function covering thermostat diagnostic, calibration verification, in use monitor performance ratio, and an emission issue relating to open loop smoothing have been
Bulletin:
SSM-36224
Component:
053000 parking brake:indicator light
Summary:
Jaguar: directional indicator operating with the stalk in the central position. if condition is found, replace the directional indicator switch. no model years listed. *pe
Bulletin:
JTB-00175
Component:
034500 service brakes, hydraulic:foundation components:disc
Summary:
Jaguar: rear differential replacement. due to a change in design, the rear differential has a new service part. as a result, should the rear differential require replacement it will be necessary to convert the driveline system to use the
Bulletin:
UPS-2110-2B
Component:
355200 equipment:other:owners/service/other manual
Summary:
Jaguar: there are new pre-delivery inspection items for all xj models. *rm
Bulletin:
JTB-00208
Component:
050000 parking brake
Summary:
Jaguar: electronic parking brake re-calibration procedure. *rm updated 10/17/14. *pe
Bulletin:
JTB-00344-NAS1
Component:
350000 equipment
Summary:
Jaguar: damage during a repair or time of production, caused the earth stud, on some vehicles, to become broken or cross threaded. model 2003-2009 xj (x350), 206/onwards xk (x150), 2010/onwards xj (x351), 2014/onwards f-type (x152).
Bulletin:
JTB00208NAS2
Component:
030000 brakes (pws)
Summary:
Summary to be provided on a future date.
Bulletin:
JTB00344NAS1
Component:
160000 structure
Summary:
Summary to be provided on a future date.
Bulletin:
SSM-72805
Component:
063100 engine and engine cooling:exhaust system:emission control
Summary:
Issue: a customer may raise a concern of their vehicle not passing state inspection in california and there is no warning light or other suggestion of a fault.
Bulletin:
JTB00344NAS1
Component:
350000 equipment
Summary:
"situation: an earth stud may be broken or cross threaded. cause: this may be caused by damage in production or during a repair."
Bulletin:
SSM63597
Component:
118000 electrical system: software
Summary:
"issue: jaguar land rover north america service diagnostics would like to make all sdd users aware of an emerging concern being tracked via the epqr system. users report dvd133 is unable to fully communicate with pcm on legacy jaguar veh
Bulletin:
SSM71361
Component:
118000 electrical system: software
Summary:
"issue: da-dongle/da-vina/da-st512 - j2534 vehicle communication interface device (vci) software requires updating to the latest level. da j2534 software driver level ' v4.0 (must be updated to this level on all sdd machines that use thi
Bulletin:
SSM37157
Component:
110000 electrical system
Summary:
"re-issued dec 2015. please note that as yet jaguar vehicles with bulb failure monitoring systems for trailer light failure sensing are not compatible with trailer light boards that have led based illumination. as a result of this the le
Bulletin:
SSM39211
Component:
073200 fuel system, gasoline:fuel injection system:injectors
Summary:
"re-issued dec 2015. issue: fuel injectors clogged leading to poor running / misfires / engine detonation on aj-v8 engines. cause: poor fuel quality or fuel contaminants blocking the holes in the fuel injector."
Bulletin:
SSM39290
Component:
110000 electrical system
Summary:
"help with diagnosing any issues / faults can be gained by phoning your jaguar technical helpline to help us with our analysis please ensure that you have the following information available before contacting jaguar cars: vin vehicle t
Bulletin:
SSM51717
Component:
062000 engine and engine cooling:cooling system
Summary:
"issue: coolant expansion tank stub pipe leaking on xj (x350), xk (x150) or xf (x250) up to the end of 2009 my. cause: the design of the stub pipe was not adequate and could result in the pipe splitting."
Bulletin:
SFCC_14DEC17
Component:
355200 equipment:other:owners/service/other manual
Summary:
Presentation from dealer shop foreman conference call
Bulletin:
SFCC_08MAR18
Component:
355200 equipment:other:owners/service/other manual
Summary:
Jaguar land rover shop foreman conference call
Bulletin:
SFCC_09AUG18_REV
Component:
350000 equipment
Summary:
Incontrol touch pro phase 4 customer letter
Bulletin:
SFCC_09AUG18_REV
Component:
350000 equipment
Summary:
Sim card activation issues
Bulletin:
SFCC_09AUG18_REV
Component:
110000 electrical system
Summary:
18c - new face of incontrol touch pro and 18c software improvements
Bulletin:
SFCC_09AUG18_REV
Component:
110000 electrical system
Summary:
A customer may report "hood open" message displays on ip with hood closed.

Home | Privacy