2004 HYUNDAI ELANTRA Recalls (5)
- Campaign:
- 03V322000 on 08/28/2003
- Component:
- Air bags
- Manufactured:
- 06/11/2003 - 08/10/2003
- Affected:
- 75
- Defect:
- On certain vehicles, if the front passenger seat is unoccupied or is occupied by someone lighter than 56.4 pounds, the passenger air bag is deactivated and will not deploy if a crash occurs. however, the occupant classification sensor may incorrectly interpret that a seated adult is an infant seat and deactivate the passenger air bag if someone heavier than 56.4 pounds who is seated with one leg resting on the outboard or inboard edge of the seat; with legs spread; or positioned off-center toward the center console and with his or her arm leaning on the console.
- Consequence:
- In the event of a vehicle crash, the air bag may not deploy, possibly resulting in serious injury to the right front passenger.
- Correction:
- The occupant classification sensor will be reprogrammed.
- Notes:
- Hyundai recallno. 062.all affected vehicles were delivered to enterprise rent-a-car and will not be placed in service until the recall repair work is complete.customer notification for this campaign is not necessary.also, customers can contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
- Campaign:
- 04V208000 on 05/09/2004
- Component:
- Fuel system, gasoline:delivery:hoses, lines/piping, and fittings
- Manufactured:
- 08/31/2003 - 04/13/2004
- Affected:
- 44,530
- Defect:
- During an insurance institute for highway safety (iihs) offset frontal barrier impact test on certain passenger vehicles, fuel spillage occurred as a result of fuel tank damage caused by contact between a vapor tube hose clamp ear and the fuel tank. the vapor tube hose clamp ear was found to be mispositioned and facing toward the fuel tank.
- Consequence:
- In the event of a crash, damage to the vehicle could cause the mispositioned clamp to puncture the fuel tank causing fuel leakage. fuel leakage, in the presence of an ignition source, could result in a fire.
- Correction:
- Dealers will inspect the position of the vapor tube hose clamp and correctly position the clamp, if necessary. owner notification began on may 24, 2004. owners should contact hyundai at 1-800-633-5151.
- Notes:
- Hyundai recall no. 067.customers can also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
- Campaign:
- 04V370000 on 08/01/2004
- Component:
- Fuel system, gasoline:delivery:hoses, lines/piping, and fittings
- Manufactured:
- 08/31/2003 - 04/13/2004
- Affected:
- 582
- Defect:
- During an insurance institute for highway safety (iihs) offset frontal barrier impact test, it was determined that fuel tan damage could occur. on certain passenger vehicles, a vapor tube hose clamp that is located near the fuel tank may not be positioned properly and could cause fuel leakage.
- Consequence:
- fuel leakage in the presence of an ignition source may result in a fire.
- Correction:
- Dealers will inspect the position of the vapor tube hose clamp ears and correctly position the clamp, if necessary. the recall began on october 5, 2004. owners should contact hyundai de puerto rico at 1-800-981-0188.
- Notes:
- Hyundai recall no. 067. customers can also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
- Campaign:
- 05V395000 on 09/12/2005
- Component:
- Air bags
- Manufactured:
- 06/11/2003 - 09/29/2005
- Affected:
- 231,160
- Defect:
- Certain vehicles equipped with an advanced air bag system. the occupant classification system (ocs) installed in the right front seat of the vehicle may misclassify a child restraint seat (crs) as an adult. this may occur if the crs is installed after an adult has been seated in the right front seat. if there has not been a 'key on' ' key off' cycle with the right front passenger seat empty prior to installation of the crs.
- Consequence:
- The possibility of misclassification of a crs as an adult may allow the right front airbag or side impact airbag to deploy in a crash and could result in injury to the right front occupant.
- Correction:
- Dealers will reprogram the vehicle's ocs electronic control unit (ecu) to remove the feature that may cause the crs to be recognized as an adult. the recall began on october 31, 2005. owners may contact hyundai at 1-800-633-5151.
- Notes:
- Hyundai recall no. 073.customers may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov.
- Campaign:
- 05V479000 on 10/16/2005
- Component:
- Air bags
- Manufactured:
- 06/11/2003 - 09/08/2005
- Affected:
- 2,105
- Defect:
- Certain vehicles equipped with an advanced air bag system. the occupant classification system (ocs) installed in the right front seat of the vehicle may misclassify a child restraint seat (crs) as an adult. this may occur if the crs is installed after an adult has been seated in the right front seat. if there has not been a 'key on' ' key off' cycle with the right front passenger seat empty prior to installation of the crs.
- Consequence:
- The possibility of misclassification of a crs as an adult may allow the right front airbag or side impact airbag to deploy in a crash and could result in injury to the right front occupant.
- Correction:
- Dealers will reprogram the vehicle's ocs electronic control unit (ecu) to remove the feature that may cause the crs to be recognized as an adult. the recall began on november 15, 2005. owners may contact hyundai of puerto rico at 1-800-981-0188.
- Notes:
- Hyundai pr recall no. 073.customers may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov.
2004 HYUNDAI ELANTRA TSBs (31)
- Bulletin:
- 033601401
- Component:
- 063100 engine and engine cooling:exhaust system:emission control
- Summary:
- Service information for sulev (super ultra low emission vehicle) elantra (only applied on elantra vehicles with california emissions specification and automatic transmission). *tt
- Bulletin:
- 0336024
- Component:
- 180000 vehicle speed control
- Summary:
- Resistance values for idle speed control actuator (isca). various models including the 2004 sonata. *tt
- Bulletin:
- 0490001
- Component:
- 140000 air bags
- Summary:
- Dual-stage supplemental restraint system (srs) repair after collision. 2004 accent also included. *tt
- Bulletin:
- 0436001
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- This bulletin describes the changes to the engine management/engine electrical system. *tt
- Bulletin:
- 03360142
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Service information for suleave elantra (only applied on elantra vehicles with california emissions specification and automatic transmission).*mr
- Bulletin:
- 0401003
- Component:
- 072100 fuel system, gasoline:delivery:fuel pump
- Summary:
- Fuel pump replacement. *mr service campaign t13. *tt
- Bulletin:
- 0490004
- Component:
- 110000 electrical system
- Summary:
- Occupant classification system (ocs) parts replacement. *mr
- Bulletin:
- 0480001
- Component:
- 162000 structure:body
- Summary:
- Rear spoiler fastener part number information. *mr
- Bulletin:
- 0490010
- Component:
- 133000 visibility:power window devices and controls
- Summary:
- Power window regulator motor.*mr
- Bulletin:
- 0450007
- Component:
- 015200 steering:hydraulic power assist:hose, piping, and connections
- Summary:
- Power steering pressure hose to oil pump bolt torque specification shop manual correction. *tt
- Bulletin:
- 0497002
- Component:
- 353600 equipment:air conditioner
- Summary:
- Fd46xg pag oil specifications for air conditioning component replacement. *tt
- Bulletin:
- 0440012
- Component:
- 103000 power train:automatic transmission
- Summary:
- Automatic transaxle harsh and/or delayed shifts. to include 2005 elantra. *tt
- Bulletin:
- 0440011
- Component:
- 103000 power train:automatic transmission
- Summary:
- Automatic transaxle harsh and/or delayed engagement into drive or reverse. to include 2005 elantra. *tt
- Bulletin:
- 0450009
- Component:
- 106000 power train:axle assembly
- Summary:
- Front knuckle assembly snap ring configuration revised. *tt
- Bulletin:
- 0804
- Component:
- 353600 equipment:air conditioner
- Summary:
- Fd46xg poly alkylen glycol (pag) oil specifications for air conditioning component replacement. *nm
- Bulletin:
- 0501002
- Component:
- 141100 air bags:frontal:sensor/control module
- Summary:
- Air bag control unit (acu) reprogramming procedure (service campaign 919). *tt
- Bulletin:
- 0590003
- Component:
- 140000 air bags
- Summary:
- The occupant classification system (ocs) passenger air bag off indicator light may not turn off or may switch on and off when some smaller stature adults are seated in the right front passenger seat. *tt fit-it-right occupant classificat
- Bulletin:
- 0540008
- Component:
- 103000 power train:automatic transmission
- Summary:
- Automatic transaxle diagnostic trouble codes list. *sc
- Bulletin:
- 0540002
- Component:
- 106000 power train:axle assembly
- Summary:
- Pcm reprogramming instructions for mild driveline bump between 2-10 mph. *sc
- Bulletin:
- 01011901
- Component:
- 110000 electrical system
- Summary:
- Automatic transaxle diagnostic trouble codes list. *nm
- Bulletin:
- 158
- Component:
- 106000 power train:axle assembly
- Summary:
- Reprograms are available for automatic transaxle driveability issues. technet times. hyundai. *tt
- Bulletin:
- 153
- Component:
- 140000 air bags
- Summary:
- Occupant classification system (ocs) reprogramming. fix-it-right. hyundai technet times. *tt
- Bulletin:
- 01011901
- Component:
- 140000 air bags
- Summary:
- Airbag reprogramming guide. *tt
- Bulletin:
- 0590003
- Component:
- 110000 electrical system
- Summary:
- Occupant classification system (ocs) reprogramming. passenger air bag off indicator light may not turn off or may switch on and off when some smaller stature adults are seated in the right front passenger seat. *tt
- Bulletin:
- 0640018
- Component:
- 106000 power train:axle assembly
- Summary:
- Automatic transaxle diagnostic trouble codes (dtc) list. *kb
- Bulletin:
- 0740009
- Component:
- 103000 power train:automatic transmission
- Summary:
- Automatic transaxle harsh and/or delayed engagement into drive or reverse. *kb
- Bulletin:
- TSB0740010
- Component:
- 103100 power train:automatic transmission:control module (tcm, pcm)
- Summary:
- Automatic transaxle harsh and/or delayed upshift or downshift - gds analysis. *pe
- Bulletin:
- TSB-09-AT-013
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Hyundai: automatic transaxle range switch diagnostic trouble codes p0705 (range switch signal problems), p0707 (range switch open circuit), and p0708 (range switch short circuit or multiple inputs). an improperly adjusted or improperly op
- Bulletin:
- TSB-09-AT-018
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Hyundai: ata solenoid diagnostic trouble codes p0740, p0741, p0742, p0743, p0746, p0748, p0750, p0755, p0760, p0765, p0770. incorrect operation of the transaxle solenoids may result in the following symptoms-check engine light illuminated
- Bulletin:
- 5NP-B6E2P-10
- Component:
- 103100 power train:automatic transmission:control module (tcm, pcm)
- Summary:
- "the pcm or tcm contains logic to adjust solenoid duty and line pressure as needed to compensate for normal clutch wear over the life of the transaxle. this bulletin provides the procedures necessary to reset (erase) and relearn the pcm/tcm
- Bulletin:
- 5NP-S9D9P-10
- Component:
- 103000 power train:automatic transmission
- Summary:
- This bulletin provides information on components, attributes, and precautions of the 7-speed dry-type dual clutch transmission (dct).
Home | Privacy