2004 FORD ESCAPE Recalls (10)

Campaign:
04V574000 on 12/08/2004
Component:
Vehicle speed control:cables
Manufactured:
05/29/2001 - 01/22/2004
Affected:
470,245
Defect:
On certain sport utility vehicles built with 3.0l v6 engines, the accelerator cable may prevent the throttle from returning to the idle position.
Consequence:
An unexpected increase in engine idle speed may increase stopping distance and may result in a vehicle crash.
Correction:
Dealers will replace the accelerator cable. the recall began on january 10, 2005. owners should contact ford at 1-866-436-7332.
Notes:
Ford recall no. 04s25.customers can also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
Campaign:
04V602000 on 12/22/2004
Component:
Latches/locks/linkages:doors:latch
Manufactured:
06/08/2003 - 01/22/2004
Affected:
262,113
Defect:
Certain 2004-2005 sport utility vehicles and certain 2001-2003 sport utiity vehicle having rear liftgate components serviced with 2004 equivalent components fail to comply with the requirements of federal motor vehicle safety standard no. 206, 'door locks and door retention components.' the rear liftgate latching system does not meet the inertia load requirement in one direction.
Consequence:
If the liftgate is left unlocked, there is the potential that it may open during a crash.
Correction:
Dealers will replace the rear liftgate latch release rod, the release rod attachment clip and the door handle return spring. the recall began on march 31, 2005. owners should contact ford at 1-800-392-3673.
Notes:
Ford recall no. 04c09.customers can also contact the national highway traffic safety administration's auto safety hotline at 1-888-327-4236.
Campaign:
07E023000 on 03/28/2007
Component:
Service brakes, hydraulic:foundation components:master cylinder
Affected:
13,128
Defect:
Certain cardone master cylinders with part numbers 10-2925, 10-2987, 10-2987mza, 10-3083, 11-3015, 11-3042, 11-3044, 11-3045, 11-3047, 11-3064, and 11-3156, and with date codes lower than dca7078 sold as replacement equipment for use on the vehicles listed above. the seal on master cylinder can fail and leak brake fluid.
Consequence:
Loss of brake fluid can result in poor braking performance, possibly resulting in a vehicle crash.
Correction:
Cardone will notify owners and offer to repurchase any defective master cylinders. the recall began during april 2007. owners can contact cardone at 1-800-777-4780.
Notes:
This recall only pertains to aftermarket cardone master cylinders and has no relation to any original equipment installed on the vehicles listed above.customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.
Campaign:
07V156000 on 04/10/2007
Component:
Service brakes, hydraulic:antilock:control unit/module
Manufactured:
10/21/1999 - 01/22/2004
Affected:
446,460
Defect:
On certain sport utility vehicles equipped with antilock brakes (abs), the abs module connector may have missing or dislodged wire seals. this condition could allow contamination to enter the module connector, creating a potential for an electrical short.
Consequence:
An electrical short might cause an abs malfunction that would illuminate the abs warning light, and in some cases, the module may overheat resulting in burning odor, smoke, and/or fire. this condition could occur either when the vehicle ignition switch is in the off position or while the vehicle is being operated.
Correction:
Dealers will inspect the wire harness connector to the abs module for missing or dislodged wire seals, and repair or replace the harness connector as appropriate. the dealer will also inspect the connector on the abs module and replace it if it is found to be corroded or damaged. the recall began on april 23, 2007. owners may contact ford at 1-800-392-3673.
Notes:
Ford recall no. 07s51.customers may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov.
Campaign:
12V353000 on 07/25/2012
Component:
Engine and engine cooling
Affected:
529,719
Defect:
Ford motor company is recalling certain model year 2001 through 2004 escape vehicles equipped with 3.0l v6 engines and speed control manufactured from october 22, 1999, through january 23, 2004. inadequate clearance between the engine cover and the speed control cable connector could result in a stuck throttle when the accelerator pedal is fully or almost-fully depressed. this risk exists regardless of whether or not speed control (cruise control) is used.
Consequence:
A stuck throttle may result in very high vehicle speeds and make it difficult to stop or slow the vehicle, which could cause a crash, serious injury or death.
Correction:
Ford will notify owners, and dealers will repair the vehicles by increasing the engine cover clearance, free of charge. the safety recall began august 3, 2012. remedy parts are expected to be available in mid-august 2012. until then dealers will disconnect the speed control cable as an interim remedy, if parts are not available at the time of an owner's service appointment. owners may contact ford at 1-866-436-7332.
Notes:
Ford's recall campaign number is 12s37.owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.
Campaign:
12V353000 on 07/25/2012
Component:
Vehicle speed control:cables
Affected:
529,719
Defect:
Ford motor company is recalling certain model year 2001 through 2004 escape vehicles equipped with 3.0l v6 engines and speed control manufactured from october 22, 1999, through january 23, 2004. inadequate clearance between the engine cover and the speed control cable connector could result in a stuck throttle when the accelerator pedal is fully or almost-fully depressed. this risk exists regardless of whether or not speed control (cruise control) is used.
Consequence:
A stuck throttle may result in very high vehicle speeds and make it difficult to stop or slow the vehicle, which could cause a crash, serious injury or death.
Correction:
Ford will notify owners, and dealers will repair the vehicles by increasing the engine cover clearance, free of charge. the safety recall began august 3, 2012. remedy parts are expected to be available in mid-august 2012. until then dealers will disconnect the speed control cable as an interim remedy, if parts are not available at the time of an owner's service appointment. owners may contact ford at 1-866-436-7332.
Notes:
Ford's recall campaign number is 12s37.owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.
Campaign:
14V165000 on 04/07/2014
Component:
Structure:frame and members
Manufactured:
10/21/1999 - 12/18/2003
Affected:
348,950
Defect:
Ford motor company (ford) is recalling certain model year 2001-2004 escape vehicles manufactured october 22, 1999, through january 23, 2004, originally sold, or currently registered in, connecticut, delaware, illinois, indiana, iowa, maine, maryland, massachusetts, michigan, minnesota, missouri, new hampshire, new jersey, new york, ohio, pennsylvania, rhode island, vermont, west virginia, wisconsin and the district of columbia. these vehicles may experience excessive corrosion at the forward attachment of the lower control arm.
Consequence:
A separation of the lower control arm can result in a significant loss of steering control, increasing the risk of a crash.
Correction:
Ford will notify owners, and dealers will install a newly designed reinforcement cross-brace, free of charge. the recall began on may 30, 2014. owners may contact ford at 1-800-392-3673. ford's number for this recall is 14s02.
Notes:
Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.
Campaign:
15E045000 on 06/02/2015
Component:
Suspension:front:wheel bearing
Affected:
576
Defect:
The timken company (timken) is recalling certain aftermarket front wheel bearings, part number 510072, sold from january 22, 2015, to may 21, 2015, to be used as service parts on 2001-2012 ford escape, 2001-2011 mazda tribute, and 2005-2011 mercury mariner vehicles. the affected wheel bearings have incorrect dimensions of a 42mm bore, 76mm outer dimension, and 39mm width, instead of a 42mm bore, 78mm outer dimension and a 45mm width.
Consequence:
Use of an incorrectly sized wheel bearing can adversely affect the braking and steering of the vehicle, increasing the risk of a crash.
Correction:
Timken has begun notifying distributors who will offer purchasers replacement wheel bearings, free of charge. the recall began on may 21, 2015. owners may contact timken customer service at 1-866-984-6536.
Notes:
Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.
Campaign:
15V606000 on 09/28/2015
Component:
Power train:automatic transmission:gear position indication (prndl)
Manufactured:
03/30/2001 - 08/31/2009
Affected:
57
Defect:
Ford motor company (ford) is recalling certain model year 2001-2008 ford escape and mercury mariner vehicles manufactured march 31, 2001, to september 1, 2009. the affected vehicles are equipped with either a 2.3l or 3.0l engine and have had their cd4e transmission replaced with remanufactured one that was rebuilt between june 11, 2015 through july 15, 2015. these service repair part transmissions have a shift lever bolt that may not be properly tightened. as a result, the shift control lever could disengage from the transmission without warning.
Consequence:
If the shift lever disengages from the transmission, a driver may be unable to shift gear positions and the indicated shift position may not represent the gear position the vehicle is in. should a disengagement occur while the vehicle is being driven, when the driver goes to stop and park the vehicle, the gear selection indicator may show that the transmission is in the "park" position, but the vehicle transmission may not actually be in the "park" gear position. if the vehicle is not in the "park" position there is a risk the vehicle will roll away as the driver and other occupants exit the vehicle or anytime thereafter. a vehicle rollaway increases the risk of injury to exiting occupants and bystanders.
Correction:
Ford will notify owners, and dealers will inspect the transmissions and either tighten the manual shift lever bolt or replace the manual shift lever assembly. these repairs will be performed free of charge. the recall began on october 23, 2015. owners may contact ford customer service at 1-866-436-7332. ford's number for this recall is 15s28.
Notes:
Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.
Campaign:
15V606000 on 09/28/2015
Component:
Power train:automatic transmission:lever and linkage:floor shift
Manufactured:
03/30/2001 - 08/31/2009
Affected:
57
Defect:
Ford motor company (ford) is recalling certain model year 2001-2008 ford escape and mercury mariner vehicles manufactured march 31, 2001, to september 1, 2009. the affected vehicles are equipped with either a 2.3l or 3.0l engine and have had their cd4e transmission replaced with remanufactured one that was rebuilt between june 11, 2015 through july 15, 2015. these service repair part transmissions have a shift lever bolt that may not be properly tightened. as a result, the shift control lever could disengage from the transmission without warning.
Consequence:
If the shift lever disengages from the transmission, a driver may be unable to shift gear positions and the indicated shift position may not represent the gear position the vehicle is in. should a disengagement occur while the vehicle is being driven, when the driver goes to stop and park the vehicle, the gear selection indicator may show that the transmission is in the "park" position, but the vehicle transmission may not actually be in the "park" gear position. if the vehicle is not in the "park" position there is a risk the vehicle will roll away as the driver and other occupants exit the vehicle or anytime thereafter. a vehicle rollaway increases the risk of injury to exiting occupants and bystanders.
Correction:
Ford will notify owners, and dealers will inspect the transmissions and either tighten the manual shift lever bolt or replace the manual shift lever assembly. these repairs will be performed free of charge. the recall began on october 23, 2015. owners may contact ford customer service at 1-866-436-7332. ford's number for this recall is 15s28.
Notes:
Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.

2004 FORD ESCAPE TSBs (47)

Bulletin:
031513
Component:
017500 steering:linkages:tie rod assembly
Summary:
Tie rod end inspection procedure. *tt
Bulletin:
03144
Component:
061000 engine and engine cooling:engine
Summary:
Engine misfire or rough running condition with coil on plug (cop) ignition systems may be more accurately diagnosed using the optional worldwide diagnostic system (wds) coil on plug (cop) kit. 2003 super duty f series included. *tt
Bulletin:
16964
Component:
030000 service brakes, hydraulic
Summary:
Excessive brake pad/lining dust and wear. *tt
Bulletin:
03181
Component:
110000 electrical system
Summary:
Remote keyless entry (rke) - service tips. *tt
Bulletin:
032011
Component:
110000 electrical system
Summary:
Airbag lamp illuminated and diagnostic trouble codes (dtcs) b1877 (driver pretensioner circuit open) or b1881 (passenger pretensioner circuit open). *tt this bulletin supersedes tsb 03-20-11 dated 2003. *tt
Bulletin:
17457
Component:
030000 service brakes, hydraulic
Summary:
Excessive front rotor wear and/or brake dust. *tt
Bulletin:
17482
Component:
103000 power train:automatic transmission
Summary:
Harsh shifts and engagements with only diagnostic trouble code (dtc) p1502. *tt
Bulletin:
17657
Component:
102000 power train:manual transmission
Summary:
Clutch chatter when cold. *tt
Bulletin:
17532
Component:
015200 steering:hydraulic power assist:hose, piping, and connections
Summary:
Low pressure power steering line leak after cold soak in temperatures of -23c (-10) or lower. *mj
Bulletin:
17316
Component:
090000 fuel system, other
Summary:
Fuel signal to instrument cluster service tip. *tt
Bulletin:
17343
Component:
151000 seat belts:front
Summary:
Front safety belt slow to retract and/or missing web stop button. *tt
Bulletin:
17366
Component:
100000 power train
Summary:
Final drive whine most noticeable at 25-45 mph during light acceleration or deceleration. *tt
Bulletin:
0471
Component:
110000 electrical system
Summary:
Warning indicators-parking aid-reverse sensing system (rss) and forward sensing system (fss)-false activation of warning tone-service tips. *mj update. *tt
Bulletin:
03L17
Component:
063100 engine and engine cooling:exhaust system:emission control
Summary:
Demonstration/delivery hold - special field action 03l17. revised smog emissions information. *tt
Bulletin:
031501
Component:
138130 visibility:defroster/defogger system:windshield:controls/wiring
Summary:
Inoperative electric rear window defroster (heated backlite) grid lines, integral antenna concerns. *tt
Bulletin:
04141
Component:
103000 power train:automatic transmission
Summary:
Transmission control indicator lamp (tcil) on with diagnostic trouble code p1783 and/or p0733 cold climate shift/engagement concerns with a cd4e transaxle. *tt
Bulletin:
18217
Component:
090000 fuel system, other
Summary:
Multiple vehicles - fuel level indication concerns - service tip. various models including 2005 super duty f-series, excursion, expedition, explorer, mountaineer and aviator. *tt
Bulletin:
041514
Component:
138130 visibility:defroster/defogger system:windshield:controls/wiring
Summary:
Rear window defroster grid/integral antenna diagnosis and repair - terminal tab repair. *tt
Bulletin:
031404
Component:
061000 engine and engine cooling:engine
Summary:
Engine misfire or running - coil on plug (cop) ignition systems - wds cop kit diagnostic tips. to include various 2005 models. * ar this article 04161 supersedes tsb 03-14-04.
Bulletin:
18173
Component:
100000 power train
Summary:
A final drive whine at 25-45 mph (40-72 km/h). *tt
Bulletin:
05310
Component:
150000 seat belts
Summary:
Safety belt web stop button service. *eh
Bulletin:
04174
Component:
110000 electrical system
Summary:
Malfunction indicator lamp (mil) illuminated - system lean diagnostic trouble codes (dtc's) - service tips. various models including 2004 f-series. *tt
Bulletin:
04214
Component:
010000 steering
Summary:
Steering drift/pull - improved diagnostic and repair procedure - service tip. *tt
Bulletin:
04217
Component:
103100 power train:automatic transmission:control module (tcm, pcm)
Summary:
General power train control module (pcm) programming procedures. *tt
Bulletin:
04232
Component:
103100 power train:automatic transmission:control module (tcm, pcm)
Summary:
Wheel speed sensor removal tip. *eh
Bulletin:
18280
Component:
140000 air bags
Summary:
Air bag warning lamp on . *eh
Bulletin:
18281
Component:
124000 exterior lighting:back up lights
Summary:
Condensation inside the foglamps. *eh
Bulletin:
18284
Component:
140000 air bags
Summary:
High airflow from defroster vents when in floor or floor defrost modes. *eh
Bulletin:
04191
Component:
150000 seat belts
Summary:
Safety belt buckle and pretensioner diagnostic trouble code (dtc) b1877, b1881, b1885 or b1886. *tt
Bulletin:
04189
Component:
138200 visibility:defroster/defogger system:rear window
Summary:
Rear window defroster grid/integral antenna diagnosis and repair - terminal tab repair. *tt
Bulletin:
042107
Component:
103100 power train:automatic transmission:control module (tcm, pcm)
Summary:
General (pcm) power train control module programming procedures. *tt
Bulletin:
042421
Component:
151300 seat belts:front:retractor
Summary:
Safety belt retraction speed. *tt
Bulletin:
042513
Component:
160000 structure
Summary:
Serviceability of instrument panel register vents. *tt
Bulletin:
042612
Component:
140000 air bags
Summary:
Side air bag diagnostic trouble code (dtc) b1994 or b1998. *tt
Bulletin:
04262
Component:
342000 communications:back up alarm
Summary:
False parking aid warnings. *tt update. *tt
Bulletin:
05419
Component:
342000 communications:back up alarm
Summary:
False parking aid warnings. *tt
Bulletin:
04244
Component:
110000 electrical system
Summary:
Restraint system - safety belt buckle and pretensioner diagnostic trouble code (dtc) b1877 and/or b1881. *tt
Bulletin:
041601
Component:
060000 engine and engine cooling
Summary:
Wds cop kit diagnostic tip - coil on plug (cop) ignition systems - engine misfire or rough running. *tt
Bulletin:
05252
Component:
210000 trailer hitches
Summary:
Neutral tow capability -- service kit requirements. *tt
Bulletin:
052624
Component:
190000 tires
Summary:
Vibration diagnosis - tire/wheel runout. *tt
Bulletin:
19016
Component:
061110 engine and engine cooling:engine:gasoline:belts and associated pulleys
Summary:
Replace timing belt idler pulley during 2.0l zetec engine cylinder head replacement - service tip. *tt
Bulletin:
04208
Component:
061000 engine and engine cooling:engine
Summary:
Camshaft tick noise - 3.0l 4v engine only. *tt
Bulletin:
0645
Component:
100000 power train
Summary:
Neutral tow capability - service kit requirements. *tt
Bulletin:
0693
Component:
110000 electrical system
Summary:
Pcm failure - electrical accessories intermittent - inoperative. *tt
Bulletin:
06116
Component:
061000 engine and engine cooling:engine
Summary:
Possible engine damage - install special service tools prior to removing crankshaft pulley bolt - service tip. *tt
Bulletin:
TSB-14-0143
Component:
021530 suspension:front:control arm:lower arm
Summary:
Ford: the lower control arm (lca) forward attachment will separate from subframe, causing diminishing directional control, due to operating in high corrosion areas for extended period of time. model 2001-2004 escape. *pe
Bulletin:
SSM 46085
Component:
060000 engine (pws)
Summary:
The powertrain control/emissions diagnosis (pc/ed) manual has been revised for diagnosing electronic throttle bodies (etbs). the etc_act and etc_dsd pids should not used to diagnose possible etb concerns. the ids has a limited refresh rate

Home | Privacy