2004 CORBEIL MINIBUS Recalls (4)
- Campaign:
- 05V140000 on 04/10/2005
- Component:
- Visibility:rearview mirrors/devices:exterior
- Manufactured:
- 01/27/2003 - 02/24/2005
- Affected:
- 1,262
- Defect:
- Certain my 1998-2005 corbeil minibus school buses manufactured between january 28, 2003, and february 25, 2005, and built on ford chassis. the front cross view mirrors fail to conform to the visibility requirements of federal motor vehicle safety standard no. 111, rear view mirrors.
- Consequence:
- Driver's do not have a complete view of the front of the bus. the presence of a child near the front bumper could not been seen by the driver and the child could be seriously injured or killed should the vehicle move.
- Correction:
- Corbeil will notify its customers and replace the right hand cross mirror bracket to bring the vehicle into compliance with the regulation free of charge. the recall began on june 3, 2005. owners may contact corbeil at 1-888-439-3577 ext. 236.
- Notes:
- Corbeil recall no. w0061.customers may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov.
- Campaign:
- 05V429000 on 09/26/2005
- Component:
- Other:school bus stop arm assembly
- Manufactured:
- 01/20/2002 - 07/30/2005
- Affected:
- 5,277
- Defect:
- Certain 2001-2005 corbeil minibus school buses equipped with specialty manufacturing "5" series stop arms originally sold in or currently registered in the following states: alaska, colorado, connecticut, delaware, idaho, illinois, indiana, iowa, kansas, kentucky, maine, maryland, massachusetts, michigan, minnesota, missouri, montana, nebraska, nevada, new hampshire, new jersey, new mexico, new york, north dakota, ohio, oregon, pennsylvania, rhode island, south dakota, tennessee, utah, vermont, virginia, washington, west virginia, wisconsin, wyoming, and the district of columbia. in extremely cold weather, the microswitches used internally to position the sign in the open and closed positions may malfunction, causing the sign to open or close in an improper position, or to not open at all.
- Consequence:
- Should the stop arm not perform properly, a child or pedestrian may be endangered by passing vehicles should the motorist not stop at the correct location.
- Correction:
- Les entreprises will notify its customers and the original switch will be replaced free of charge with a switch pack that is not sensitive to extreme cold weather and will inspect to ensure the microswitch heater wiring is properly connected. the recall began on october 1, 2005. customers may contact specialty manufacturing at 1-800-951-7867 or collins bus customer service at 1-800-533-1850.
- Notes:
- Customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236; (tty: 1-800-424-9153); or go to http://www.safercar.gov.
- Campaign:
- 05V471000 on 10/12/2005
- Component:
- Structure:body
- Manufactured:
- 05/02/2004 - 06/03/2004
- Affected:
- 295
- Defect:
- Certain 2004 corbeil school buses manufactured between may 3 and june 4, 2004. expired glue was used to adhere the roof joints which fails to comply with the requirements of federal motor vehicle safety standard no. 221, school bus body joint strength.
- Consequence:
- In the event of a vehicle crash, the longitudinal roof joint could have less strength as required by fmvss 221, increasing the risk of injury.
- Correction:
- Corbeil will notify its owners and will provide a free repair kit. the recall began on march 17, 2006. owners may contact les entreprises customer service at 1-888-439-3577 ext. 260.
- Notes:
- Customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.
- Campaign:
- 05V472000 on 10/12/2005
- Component:
- Structure:body
- Manufactured:
- 04/25/2004 - 05/20/2004
- Affected:
- 245
- Defect:
- Certain 2004 corbeil minibus school buses manufactured between april 26 and may 21, 2004. an inadequate quantity of glue was used to seal the ceiling joints which fails to comply with the requirements of federal motor vehicle safety standard no. 221, school bus body joint strength.
- Consequence:
- In the event of a vehicle crash, the longitudinal roof joint could have less strength as required by fmvss 221, increasing the risk of injury.
- Correction:
- Corbeil will notify its customers and repair the buses by adding additional glue and/or screws to enforce the ceiling joints free of charge. the recall began on march 17, 2006. customers may contact corbeil at 450-439-3577.
- Notes:
- Customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236; (tty:1-800-424-9153); or go to http://www.safercar.gov.
Home | Privacy